5.
Periodic Inspection/Maintenance
5.3 Periodic Inspection List
Such items marked ○ shall be carried out by customers.
For the following items or clauses marked ●, contact us directly or our distributors because they
require expert technical knowledge on them.
(Unit:Hour)
Maintenance Daily 250 300 500 1,000 2,000 3,000 6,000 12,000 Page
Check compressor oil level. ○ 4-5
Drain separator receiver tank. ○ 4-5
Check looseness in pipe connecting part, and
○ 4-7
wear and tear of pipe.
Check oil, water, fuel and air leak. ○ 4-11
Check performance of gauge and indication
○ 4-11
lamps.
Performance check of safety valve. ○ 4-12
Change compressor oil. ○ ○ 5-9
First time
Change compressor oil filter. ○ ○ 5-10
First time
Clean strainer in the scavenging orifice. ○ 5-11
Clean and change air filter element. ○ ○ 5-8
Clean Change
Clean outside of the oil cooler. ○ 5-13
Compressor
Change speed regulator diaphragm. ☆●
Change unloader regulator diaphragm. ★●
Change oil separator. ○ 5-15
Change nylon tubes. ☆●
Change pressure regulator diaphragm. ☆●
Check hoses. ★●
Check diaphragm of auto-relief valve. ★●
Clean butterfly valve (unloader) ●
Change diaphragm of vacuum-relief valve ★●
Change o-ring of vacuum-relief valve ★●
Performance check of pressure control valve ● 5-16
Check o-ring and piston of pressure control
● 5-16
valve
●
Change rubber coupling. Every 3
years
Change oil seal/bearing ●
Change solenoid valve for starting unload ●
※ The items or parts marked ☆ should be replaced every two years even if they are not in disorder within
their periodical maintenance interval because their materials will change or become degraded over the
course of as time passes. Also for the same reason, the parts marked ★ should be replaced every three
years.
※ The indicated replacement periods are rough estimates. Depending on the usage conditions or
environment, inspection/maintenance should be conducted earlier.
※ The above intervals of inspection and maintenance are respectively based on 1,000 hours of use per year.
5-3
5. Periodic Inspection/Maintenance
◎Refer to engine operation manual for inspection and maintenance of an engine.
For the details, contact our office nearby.
(Unit:Hour)
Maintenance Daily 50 250 500 1,000 2,000 3,000 6,000 Page
Drain fuel tank (Including sedimenter). ○ 4-6
Check fuel level ○ 4-6
Check engine oil level. ○ 4-3
Check coolant level. ○ 4-4
Check looseness in pipe connectors, terminals
○ 4-7
and tear in wiring.
Check belt tension. ○ 4-7
Change engine oil. ○ ○ 5-6
First time
Change engine oil filter. ○ ○ 5-7
First time
Check battery. ○ 5-8
Clean and change air filter element.
○ ○ 5-8
Clean Change
Engine
Change fuel filter. ○ 5-12
Checking for looseness of fixing belts of heat
insulating material used for exhaust flexible ○ 5-11
pipe.
Change fuel air-bleeding electromagnetic pump
○ 5-13
filter.
Clean outside of radiator. ○ 5-13
Change coolant. ☆○ 5-14
Clean the strainer provided inside the engine
○ 5-17
feed pump.
Clean inside of radiator. ●
Change fuel hose. ☆● 5-15
Clean inside of fuel tank. ●
Change radiator hoses. ☆●
Change wiring harness. ●
※ The items or parts marked ☆ should be replaced every two years even if they are not in disorder within
their periodical maintenance interval because their materials will change or become degraded over the
course of as time passes.
※ The indicated replacement periods are rough estimates. Depending on the usage conditions or
environment, inspection/maintenance should be conducted earlier.
※ The above intervals of inspection and maintenance are respectively based on 1,000 hours of use per year.
(Unit:Hour)
Maintenance Daily 250 300 500 1,000 2,000 3,000 6,000 Page
Supply grease to trailer hub bearing. ○ 5-17
Undercarriage
Supply grease to trailer spring pin ○ 5-17
Check and confirm that the nuts with which
○
tires are fixed are properly tightened
Check and confirm that the nuts with which ○
tires are fixed are properly tightened. Every 5-17
3 months
5-4
9. Wiring Diagram
A200333E-1
9-1
2011 年 月 日 初版
2011 年 月 日 修订
发行者 北越工业株士会社
总公司 工厂
新泻县燕市下粟生津 3074
TEL 0256-93-5571
FAX 0256-94-7567
（禁止擅自复印以及转载）
ＨＯＫＵＥＴＳＵ ＩＮＤＵＳＴＲＩＥＳ ＣＯ., ＬＴＤ.
8TH FLOOR SHINJUKU SAN-EI BLDG,
22-2 NISHI-SHINJUKU 1-CHOME,SHINJUKU-KU
TOKYO 160-0023 JAPAN
TEL:81-3-3348-7281
FAX:81-3-3348-7289
URL:http//www.airman.co.jp
Copyright(C)2020 HOKUETSU INDUSTRIES CO., LTD. All Rights Reserved.
39600 36542
Printed AUG.2022
