Date Printed: 12/21/2022 Product: 160SS1NL
Safety Data Sheet
Prepared in Accordance with HCS 29
C.F.R. 1910.1200
1. Identification of the Substance/Mixture and the Company/Undertaking
1.1 Product Identifier 160SS1NL Revision Date: 12/05/2022
Product Name: SOLVENT 100 Supercedes Date: 08/31/2020
Thinner for industrial
1.2 Relevant identified uses of the coatings - Industrial use.
substance or mixture and uses
advised against
1.3 Details of the supplier of the safety data sheet
Manufacturer: Carboline Global Inc.
2150 Schuetz Road
St. Louis, MO USA 63146
Regulatory / Technical Information:
Contact Carboline Technical Services at
1-800-848-4645
Datasheet Produced by:
1.4 CHEMTREC 1-800-424-9300 (Inside US)
Emergency telephone number:
CHEMTREC +1 703 5273887 (Outside US)
HEALTH - Pittsburgh Poison Control 1-412-681-6669
2. Hazard Identification
2.1 Classification of the substance or mixture
Acute Toxicity, Inhalation, category 4
Hazardous to the aquatic environment, Chronic, category 2
Aspiration Hazard, category 1
Carcinogenicity, category 2
Eye Irritation, category 2
Flammable Liquid, category 3
STOT, single exposure, category 3, NE
STOT, single exposure, category 3, RTI
Skin Irritation, category 2
Page 1 / 11
Date Printed: 12/21/2022 Product: 160SS1NL
2.2 Label elements
Symbol(s) of Product
Signal Word
Danger
Named Chemicals on Label
1,2,4 TRIMETHYLBENZENE, CUMENE, ETHYL BENZENE, AROMATIC HYDROCARBON
HAZARD STATEMENTS
Flammable Liquid, category 3 H226 Flammable liquid and vapour.
Aspiration Hazard, category 1 H304 May be fatal if swallowed and enters airways.
Skin Irritation, category 2 H315 Causes skin irritation.
Eye Irritation, category 2 H319 Causes serious eye irritation.
Acute Toxicity, Inhalation, category 4 H332 Harmful if inhaled.
STOT, single exposure, category 3, RTI H335 May cause respiratory irritation.
STOT, single exposure, category 3, NE H336 May cause drowsiness or dizziness.
Carcinogenicity, category 2 H351 Suspected of causing cancer.
Hazardous to the aquatic environment, H411 Toxic to aquatic life with long lasting effects.
Chronic, category 2
PRECAUTION PHRASES
P210 Keep away from heat/sparks/open flames/hot surfaces. – No
smoking.
P261 Avoid breathing dust/fume/gas/mist/vapours/spray.
P273 Avoid release to the environment.
P280 Wear protective gloves/protective clothing/eye protection/
face protection.
P284 Wear respiratory protection.
P301+310 IF SWALLOWED: Immediately call a POISON CENTER or
doctor/physician.
P304+340 IF INHALED: Remove victim to fresh air and keep at rest in a
position comfortable for breathing.
P305+351+338 IF IN EYES: Rinse cautiously with water for several minutes.
Remove contact lenses, if present and easy to do so.
Continue rinsing.
P308+313 IF exposed or concerned: Get medical advice/attention
P331 Do NOT induce vomiting.
P332+313 If skin irritation occurs: Get medical advice/attention.
P391 Collect spillage.
P403+233 Store in a well-ventilated place. Keep container tightly
closed.
ADDITIONAL INFORMATION
Note_P Note P : The classification as a carcinogen or mutagen need
64742-95-6 not apply; the substance, CAS 64742-95-6, contains less
than 0,1 % w/w benzene
2.3 Other hazards
No Information
Results of PBT and vPvB assessment:
The product does not meet the criteria for PBT/VPvB in accordance with Annex XIII.
Page 2 / 11
Date Printed: 12/21/2022 Product: 160SS1NL
3. Composition/Information On Ingredients
3.2 Mixtures
Hazardous ingredients
Name According to EEC EINEC No. CAS-No. % Classifications
AROMATIC 265-199-0 64742-95-6 75 - 100 H304-315-319-332-335-336-351 Acute Tox. 4 Inhalation,
HYDROCARBON -411 Aquatic Chronic 2, Asp. Tox.
1, Carc. 2, Eye Irrit. 2, Skin
Irrit. 2, STOT SE 3 NE, STOT
SE 3 RTI
ETHYL BENZENE 202-849-4 100-41-4 1.0 - <2.5 H225-304-315-319-332-351-373 Acute Tox. 4 Inhalation,
-412 Aquatic Chronic 3, Asp. Tox.
1, Carc. 2, Eye Irrit. 2, Flam.
Liq. 2, Skin Irrit. 2, STOT RE 2
1,2,4 202-436-9 95-63-6 1.0 - <2.5 H226-315-319-332-335-411
TRIMETHYLBENZENE
CUMENE 202-704-5 98-82-8 1.0 - <2.5 H226-304-335-411 Aquatic Chronic 2, Asp. Tox.
1, Flam. Liq. 3, STOT SE 3
RTI
CAS-No. M-Factors
64742-95-6 0
100-41-4 0
95-63-6 0
98-82-8 0
Additional Information: The text for GHS Hazard Statements shown above (if any) is given in Section 16.
4. First-aid Measures
4.1 Description of First Aid Measures
AFTER INHALATION: Give oxygen or artificial respiration if needed. Remove person to fresh air. If signs/symptoms
continue, get medical attention.
AFTER SKIN CONTACT: In case of contact, immediately flush skin with plenty of water for at least 15 minutes while
removing contaminated clothing and shoes. If skin irritation persists, call a physician.
AFTER EYE CONTACT: Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician.
AFTER INGESTION: Do NOT induce vomiting. Never give anything by mouth to an unconscious person. If swallowed, call
a poison control centre or doctor immediately.
4.2 Most important symptoms and effects, both acute and delayed
Harmful if swallowed. Irritating to eyes and skin. Risk of serious damage to the lungs (by aspiration). Vapours may cause
drowsiness and dizziness.
4.3 Indication of any immediate medical attention and special treatment needed
No information available on clinical testing and medical monitoring. Specific toxicological information on substances, if
available, can be found in section 11.
When symptoms persist or in all cases of doubt seek medical advice.
5. Fire-fighting Measures
5.1 Extinguishing Media:
Carbon Dioxide, Dry Chemical, Foam
UNUSUAL FIRE AND EXPLOSION HAZARDS: Flammable liquid. Vapours are heavier than air and may spread along
floors. Vapours may form explosive mixtures with air. Vapors may travel to areas away from work site before igniting/flashing
back to vapor source. Provide adequate ventilation. Prevent the creation of flammable or explosive concentrations of vapour
in air and avoid vapour concentration higher than the occupational exposure limits. Keep away from heat/sparks/open
Page 3 / 11
Date Printed: 12/21/2022 Product: 160SS1NL
flames/hot surfaces. - No smoking. Electrical installations / working materials must comply with the technological safety
standards. Wear shoes with conductive soles.
FOR SAFETY REASONS NOT TO BE USED: No Information
5.2 Special hazards arising from the substance or mixture
No Information
5.3 Advice for firefighters
SPECIAL FIREFIGHTING PROCEDURES: In the event of fire, wear self-contained breathing apparatus. Cool containers /
tanks with water spray. Flammable.
SPECIAL FIREFIGHTING PROTECTION EQUIPMENT: No Information
6. Accidental Release Measures
6.1 Personal precautions, protective equipment and emergency procedures
Ensure adequate ventilation. Evacuate personnel to safe areas. Remove all sources of ignition. To avoid ignition of vapours
by static electricity discharge, all metal parts of the equipment must be grounded. Wear personal protective equipment. For
personal protection see section 8.
6.2 Environmental precautions
Do not allow material to contaminate ground water system. Prevent product from entering drains.
6.3 Methods and material for containment and cleaning up
Prevent further leakage or spillage if safe to do so. Contain spillage, soak up with non-combustible absorbent material, (e.g.
sand, earth, diatomaceous earth, vermiculite) and transfer to a container for disposal according to local / national regulations
(see section 13).
6.4 Reference to other sections
No Information
7. Handling and Storage
7.1 Precautions for safe handling
INSTRUCTIONS FOR SAFE HANDLING : Keep containers dry and tightly closed to avoid moisture absorption and
contamination. Prepare the working solution as given on the label(s) and/or the user instructions. Do not breathe vapours or
spray mist. Ensure all equipment is electrically grounded before beginning transfer operations. Do not use sparking tools. Do
not get in eyes, on skin, or on clothing. Use only with adequate ventilation/personal protection. Wash thoroughly after
handling.
PROTECTION AND HYGIENE MEASURES : Handle in accordance with good industrial hygiene and safety practice. Wash
hands before breaks and at the end of workday. When using, do not eat, drink or smoke.
7.2 Conditions for safe storage, including any incompatibilities
CONDITIONS TO AVOID: Heat, flames and sparks.
STORAGE CONDITIONS: Keep container closed when not in use. Store in a dry, well ventilated place away from sources of
heat, ignition and direct sunlight.
7.3 Specific end use(s)
No specific advice for end use available.
8. Exposure Controls/Personal Protection
8.1 Control parameters
Ingredients with Occupational Exposure Limits
(US)
Name CAS-No. ACGIH TWA ACGIH STEL ACGIH Ceiling
AROMATIC HYDROCARBON 64742-95-6 300.0 PPM N/E N/E
ETHYL BENZENE 100-41-4 20 PPM 125 ppm
1,2,4 TRIMETHYLBENZENE 95-63-6 25.0 PPM N/E N/E
Page 4 / 11
Date Printed: 12/21/2022 Product: 160SS1NL
CUMENE 98-82-8 50 PPM N/E N/E
Name CAS-No. OSHA PEL OSHA STEL
AROMATIC HYDROCARBON 64742-95-6 500.0 PPM
N/E
ETHYL BENZENE 100-41-4 435 MGM3, 100 PPM
545 MGM3, 125
PPM
1,2,4 TRIMETHYLBENZENE 95-63-6 N/E
N/E
CUMENE 98-82-8 245 MGM3, 50 PPM
N/E
FURTHER ADVICE: Refer to the regulatory exposure limits for the workforce enforced in each country. Some components may
not have been classified under the EU CLP Regulation.
8.2 Exposure controls
Personal Protection
RESPIRATORY PROTECTION: In order to avoid inhalation of spray-mist and sanding dust, all spraying and sanding must be
done wearing adequate respirator. Use only with ventilation to keep levels below exposure guidelines reported in this
document. User should test and monitor exposure levels to ensure all personnel are below guidelines. If not sure, or not able
to monitor, use State or federally approved supplied air respirator. For silica containing coatings in a liquid state, and/or if no
exposure limits are established above, air-supplied respirators are generally not required.
EYE PROTECTION: Safety glasses with side-shields.
HAND PROTECTION: Gloves should be discarded and replaced if there is any indication of degradation or chemical
breakthrough. Impervious gloves. Request information on glove permeation properties from the glove supplier. Lightweight
protective clothing
OTHER PROTECTIVE EQUIPMENT: Ensure that eyewash stations and safety showers are close to the workstation location.
ENGINEERING CONTROLS: Avoid contact with skin, eyes and clothing. Ensure adequate ventilation, especially in confined
areas.
9. Physical and Chemical Properties
9.1 Information on basic physical and chemical properties
Appearance: Clear Liquid
Physical State Liquid
Odor Aromatic
Odor threshold N/D
pH N/D
Melting point / freezing point (°C) N/D
Boiling point/range (°C) 316 F (157 C) - 342 F (172 C)
Flash Point (°C) 108F (42C)
Evaporation rate Slower Than Ether
Flammability (solid, gas) Not determined
Upper/lower flammability or explosive 0.9 - 7.1
limits
Vapour Pressure, mmHg 2.10 mmHg @68F (20C)
Vapour density Heavier than Air
Relative density Not determined
Solubility in / Miscibility with water N/D
Page 5 / 11
Date Printed: 12/21/2022 Product: 160SS1NL
Partition coefficient: n-octanol/water Not determined
Auto-ignition temperature (°C) Not determined
Decomposition temperature (°C) Not determined
Viscosity Unknown
Explosive properties Not determined
Oxidising properties Not determined
9.2 Other information
VOC Content g/l: 862
Specific Gravity (g/cm3) 0.87
10. Stability and Reactivity
10.1 Reactivity
No reactivity hazards known under normal storage and use conditions.
10.2 Chemical stability
Stable under normal conditions.
10.3 Possibility of hazardous reactions
Hazardous polymerisation does not occur.
10.4 Conditions to avoid
Heat, flames and sparks.
10.5 Incompatible materials
Strong oxidizing agents.
10.6 Hazardous decomposition products
Carbon dioxide (CO2), carbon monoxide (CO), oxides of nitrogen (NOx), dense black smoke.
Page 6 / 11
Date Printed: 12/21/2022 Product: 160SS1NL
11. Toxicological Information
11.1 Information on toxicological effects
Acute Toxicity:
Oral LD50: N/D
Inhalation LC50: N/D
Irritation: Unknown
Corrosivity: Unknown
Sensitization: Unknown
Repeated dose toxicity: Unknown
Carcinogenicity: Unknown
Mutagenicity: Unknown
Toxicity for reproduction: Unknown
STOT-single exposure: No Information
STOT-repeated exposure: No Information
Aspiration hazard: No Information
If no information is available above under Acute Toxicity then the acute effects of this product have not been tested.
Data on individual components are tabulated below:
Chemical Name Oral LD50 Dermal LD50 Vapor LC50 Gas LC50 Dust/Mist
CAS-No.
LC50
3670 ppm/8
4700 mg/kg,
64742-95-6 AROMATIC HYDROCARBON oral, rat
Not Available hours, rat, 0.000 0.000
inhalation
3500 mg/kg >5000 mg/l, 17.2 mg/L
100-41-4 ETHYL BENZENE rat, oral dermal rabbit
0.000 0.000
Inh, Rat, 4Hr
6000 mg/kg, 18000 mg /
95-63-6 1,2,4 TRIMETHYLBENZENE oral, rat
0.000 0.000
m3 / 4 hours
2910 mg/kg, 12300 MG/ 8000 ppm / 4
98-82-8 CUMENE oral, rat KG (RABBIT)
0.000 0.000
hours
Additional Information:
This product may contain Ethyl Benzene, which is listed by IARC as possibly carcinogenic to humans (Group 2B). This listing is
based on inadequate evidence of carcinogenicity in humans and sufficient evidence in experimental animals.
12. Ecological Information
12.1 Toxicity:
EC50 48hr (Daphnia): Unknown
IC50 72hr (Algae): Unknown
LC50 96hr (fish): Unknown
Page 7 / 11
Date Printed: 12/21/2022 Product: 160SS1NL
12.2 Persistence and degradability: Unknown
12.3 Bioaccumulative potential: Unknown
12.4 Mobility in soil: Unknown
12.5 Results of PBT and vPvB The product does not meet the criteria for PBT/VPvB in accordance with Annex XIII.
assessment:
12.6 Other adverse effects: Unknown
CAS-No. Chemical Name EC50 48hr IC50 72hr LC50 96hr
64742-95-6 AROMATIC HYDROCARBON No information No information No information
1.8 mg/l (Daphnia
100-41-4 ETHYL BENZENE Magna)
4.6 mg/l (Green Algae) 4.2 mg/l (Rainbow Trout)
95-63-6 1,2,4 TRIMETHYLBENZENE No information No information No information
98-82-8 CUMENE No information No information 6/32 mg/l (Fish)
13. Disposal Considerations
13.1 WASTE TREATMENT METHODS: Do not burn, or use a cutting torch on, the empty drum. If recycling is not practicable,
dispose of in compliance with local regulations. Dispose of in accordance with local regulations. Empty containers should be
taken to an approved waste handling site for recycling or disposal.
14. Transport Information
14.1 UN number UN1263
14.2 UN proper shipping name Paint Related Material
Technical name N/A
14.3 Transport hazard class(es) 3
Subsidiary shipping hazard N/A
14.4 Packing group III
14.5 Environmental hazards Unknown
14.6 Special precautions for user Unknown
EmS-No.: F-E, S-E
14.7 Transport in bulk according to Annex II Unknown
of MARPOL 73/78 and the IBC code
15. Regulatory Information
15.1 Safety, health and environmental regulations/legislation for the substance or mixture:
U.S. Federal Regulations: As follows -
CERCLA - Sara Hazard Category
This product has been reviewed according to the EPA ‘Hazard Categories’ promulgated under Sections 311 and 312 of the
Superfund Amendment and Reauthorization Act of 1986 (SARA Title III) and is considered, under applicable definitions, to
meet the following categories:
Flammable (gases, aerosols, liquids, or solids), Carcinogenicity, Acute Toxicity (any route of exposure), Skin Corrosion or
Irritation, Serious eye damage or eye irritation, Specific target organ toxicity (single or repeated exposure), Aspiration Hazard
Sara Section 313:
This product contains the following substances subject to the reporting requirements of Section 313 of Title III of the
Superfund Amendment and Reauthorization Act of 1986 and 40 CFR part 372:
Chemical Name CAS-No. %
Page 8 / 11
Date Printed: 12/21/2022 Product: 160SS1NL
ETHYL BENZENE 100-41-4 1.19
1,2,4 TRIMETHYLBENZENE 95-63-6 1
CUMENE 98-82-8 1
Toxic Substances Control Act:
All components of this product are either listed on the TSCA Inventory or are exempt.
This product contains the following chemical substances subject to the reporting requirements of TSCA 12(B) if exported from
the United States:
No TSCA 12(b) components exist in this product.
U.S. State Regulations: As follows -
New Jersey Right-to-Know:
The following materials are non-hazardous, but are among the top five components in this product.
No NJ Right-To-Know components exist in this
product.
Pennsylvania Right-To-Know
The following non-hazardous ingredients are present in the product at greater than 3%.
No PA Right-To-Know components exist in this product.
CALIFORNIA PROPOSITION 65
WARNING: Cancer and Reproductive Harm -- www.P65Warnings.ca.gov
International Regulations: As follows -
* Canadian DSL:
No Information
15.2 Chemical Safety Assessment:
No Chemical Safety Assessment has been carried out for this substance/mixture by the supplier.
16. Other Information
Text for GHS Hazard Statements shown in Section 3 describing each ingredient:
H225 Highly flammable liquid and vapour.
H226 Flammable liquid and vapour.
H304 May be fatal if swallowed and enters airways.
H315 Causes skin irritation.
H319 Causes serious eye irritation.
H332 Harmful if inhaled.
H335 May cause respiratory irritation.
H336 May cause drowsiness or dizziness.
H351 Suspected of causing cancer.
H373 May cause damage to organs through prolonged or repeated exposure.
H411 Toxic to aquatic life with long lasting effects.
H412 Harmful to aquatic life with long lasting effects.
Page 9 / 11
Date Printed: 12/21/2022 Product: 160SS1NL
Reasons for revision
No Information
The information contained herein is, to the best of our knowledge and belief accurate. However,
since the conditions of handling and use are beyond our control, we make no guarantee of results,
and assume no liability for damages incurred by use of this material. It is the responsibility of
the user to comply with all applicable federal, state, and local laws and regulations.
Page 10 / 11
Date Printed: 12/21/2022 Product: 160SS1NL
Page 11 / 11
