0% found this document useful (0 votes)
350 views4 pages

Pm102,Schematics Electric

CAt Info

Uploaded by

RonaldWiseman
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF, TXT or read online on Scribd
0% found this document useful (0 votes)
350 views4 pages

Pm102,Schematics Electric

CAt Info

Uploaded by

RonaldWiseman
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF, TXT or read online on Scribd
You are on page 1/ 4

Sheet1/3 Sheet3/3

Schematic Schematic
Harness And Wire Electrical Schematic Symbol Electrical Schematics Symbols And Definitions
Machine Machine
Component Location Code Note Component Location Code Note
Location Location
(&Sheet) (&Sheet) MH-C1 L-C10 1 1
180R_25W Resistor G-13(1) W No code 120R Resistor J-8(3) Y No code 1 2 2
MAIN_RELAY_1 J-17(1) W 270-5062 KE1 ALARM_KNOB_ARMREST H-15(3) X 116-5273/116-5275/180-5617 C20/S25
MAIN_RELAY_2 I-17(1) W 270-5062 KE2 ALARM_KNOB_LH F-16(3) Z 116-5273/116-5275/180-5618 C22/S26 Typical representation of a Typical representation of a
AUX_START_RELAY_1 H-17(1) W 270-5062 KE3 ALARM_KNOB_RH K-6(3) K 116-5273/116-5275/180-5619 C21/S24 Deutsch connector. The Sure-Seal connector. The
Plug Receptacle plug contains all sockets plug and receptacle contains
AUX_START_RELAY_2 G-17(1) W 270-5062 KE4 ALTERNATOR I-11(3) 1 9N-3043 C2
and the receptacle contains both pins and sockets.
STOP_ENGINE_RELAY J-17(1) W 270-5062 KE5 ANTISLAB_DN_FLOAT_SOL A-14(3) T 3E-3360 B6
2 all pins.
GEN_ON_RELAY I-17(1) W 270-5062 KE6 ANTISLAB_UP_SOL A-14(3) T 3E-3360 A6
AUX_GEN_ON_RELAY_2 H-17(1) W 270-5062 KE7 AUTOMATIC_MODE K-15(3) X 077-8200 C55

AUX_GEN_ON_RELAY_1 G-17(1) W 270-5062 KE8 REAR_RH_COLUMN_OUT_SOL A-15(3) I 3E-3360 B2 Pin or Socket
DRUM_INSP_RELAY J-16(1) W 270-5062 KE9 LOCK_COLUMN_SOL A-16(3) S 3E-3360 A3 Number Pressure Temperature Level Flow
Wire, Cable or Harness Component Symbol Symbol Symbol Symbol
REAR_RH_COLUMN_RELAY I-16(1) W 270-5062 KE10 BATTERY_1 I-10(3) 2 3T- 5760 C2 Assembly identification Part Number
ON_STANDBY_RELAY H-16(1) W 270-5062 KE11 BATTERY_2 I-11(3) 2 3T-5760 C3 Single Wire
WATER_SPRAY_RELAY G-16(1) W 270-5062 KE12 BEACON_1 H-4(3) 3 270-9019 L2 Connector
MOLDBOARD_ON_RELAY J-16(1) W 270-5062 KE13 BEACON_2 G-4(3) 3 270-9019 L1 9X-1123
MH-C1 L-C10
DWN_SIDE_PLATE_RELAY_LH I-16(1) W 270-5062 KE14 LOCK_REAR_RH_COLUMN_SW I-5(3) 4 No code C120 P-6F J-6F
P325-MH200 PK-14 1 P325-L32 PK-14 Normally open switch that will close with an increase of a specific condition (temp-press-etc.).
UP_SIDE_PLATE_RELAY_LH H-15(1) W 270-5062 KE15 BRAKE_PSI_SW B-10(3) J 270-4363 C16
U/D_SIDE_PLATE_RELAY_LH G-15(1) W 270-5062 KE16 BRAKE_SOL A-16(3) J 3E-3360 A21 Harness identification code.
Pin Socket This example indicates wire
DWN_SIDE_PLATE_RELAY_RH J-15(1) W 270-5062 KE17 BUTTON_AS E-16(3) Z 288381 C46 30 in harness "L". Normally open switch that is closed due to an applied condition, and will open again with a
UP_SIDE_PLATE_RELAY_RH I-15(1) W 270-5062 KE18 CANOPY_DN_SOL A-17(3) M 3E-3360 B1 specific decrease in that condition.
26 26 U/D_SIDE_PLATE_RELAY_RH H-15(1) W 270-5062 KE19 CANOPY_UP_SOL A-17(3) M 3E-3360 A1
FLOOD_LIGHTS_RELAY G-15(1) W 270-5062 KE20 CONVEYOR_DN_SOL A-11(3) E 3E-3360 A12 2 P200-L30 BK-14

26 BYPASS_COL_HEIGHT_RELAY J-14(1) W 270-5062 KE21 CONVEYOR_ON_SOL A-9(3) R 3E-3360 A10


Normally closed switch that will open with an increase of a specific condition.
AUX_DRUM_ON_RELAY I-14(1) W 270-5062 KE23 CONVEYOR_REV_SOL A-9(3) R 3E-3360 B10 Circuit Number Wire Wire
Identification Color Gauge
J PROPEL_PUMP_RELAY H-14(1) W 270-5062 KE24 CONVEYOR_LH_SOL A-11(3) F 3E-3360 B11
AUX_SENSOR_POWER_RELAY G-14(1) W 270-5062 KE25 CONVEYOR_RH_SOL A-10(3) F 3E-3360 A11
PROPEL_LEVER_RELAY J-13(1) W 270-5062 KE26 CONVEYOR_UP_SOL A-11(3) E 3E-3360 B12 Electrical Schematic Symbols And Definitions Normally closed switch that is open due to an applied condition, and will close again
LEVELING_GP_RELAY I-13(1) W 270-5062 KE27 MAIN_BRK J-9(3) W 171-2208 C7 with a specific decrease in that condition.
DRUM_ON_RELAY H-13(1) W 270-5062 KE28 GLOW_BRK J-9(3) W 171-2212 C6
K WATER_PUMP_RELAY G-13(1) W 270-5062 KE29 AUX_CLUTCH_SOL A-10(3) S 3E-3360 B7 FUSE - A component in an electrical circuit that will open the circuit if too too much current flows
through it.
R
PROPEL_BACKWARD_RELAY J-13(1) W 270-5062 KE30 STEER_LH/ROTATION_RH_SOL A-14(3) S 3E-3360 A22 The circle indicates that the component has screw terminals and a wire can be disconnected
REAR_RH_STEER_RELAY I-13(1) W 270-5062 KE31 DIODE_06 F-16(3) W 260-2929 from it.
REED SWITCH - A switch whose contacts are controlled by a magnet. A magnet closes the
ENGINE_SPEED_RELAY H-13(1) W 270-5062 KE32 DIODE_24 D-2(3) W 260-2929 contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
REAR_RH_COL_LOCK_RELAY G-13(1) W 270-5062 KE33 DISCONNECT_SW J-11(3) 9 7N-0718 C1
DIODE_01 G-17(1) W 260-2929 DN_COLUMN_SW H-15(3) X 246-8912 C9
No circle indicates that the wire cannot be disconnected from the component.
DIODE_02 G-17(1) W 260-2929 DRUM_PICKUP_SENS B-8(3) 5 4P-5620 C94 SENDER - A component that is used with a temperature or pressure gauge. The sender
DIODE_03 G-17(1) W 260-2929 HIGH_GEAR_SOL A-8(3) J 3E-3360 A13 measures the temperature or pressure. Its resistance changes to give an indication to the
DIODE_04 G-17(1) W 260-2929 LIGHT_1 E-6(3) 6 172-9973 L7 T gauge of the temperature or pressure.
26
DIODE_05 G-12(1) W 260-2929 LIGHT_2 E-6(3) 7 172-9973 L8
DIODE_07 H-12(1) W 260-2929 FLOAT_MOLDBOARD_SOL B-14(3) H 3E-3360 A5 RELAY (Magnetic Switch) - A relay is an electrical component that is activated by electricity. This indicates that the component has a wire connected to it that is connected to ground.
11 DIODE_08 J-7(1) W 260-2929 FUEL_LEVEL-SENSOR B-10(3) 8 7R-9920 C15 It has a coil that makes an electromagnet when current flows through it. The electromagnet
DIODE_09 J-7(1) W 260-2929 FRONT_COLUMN_DWN_SOL B-16(3) U 3E-3360 A19 can open or close the switch part of the relay.
DIODE_10 I-12(1) W 260-2929 FRONT_COLUMN_UP_SOL B-17(3) U 3E-3360 B19
DIODE_11 H-12(1) W 260-2929 FWD_REW_PUMP H-9(3) No Code C83 CIRCUIT BREAKER (C/B) - A component in an electrical circuit that will open the circuit if too This indicates that the component does not have a wire connected to ground. It is grounded
18 DIODE_12 H-9(1) W 260-2929 GENERAL_ON_SOL B-14(3) A 3E-3360 A4 much current flows through it. This does not destroy the circuit breaker and it can be reset to
21 DIODE_13 H-8(1) W 260-2929 GLOW_PLUG_RELAY H-9(3) No Code C4 become part of the circuit again.
by being fastened to the machine.
DIODE_14 H-8(1) W 260-2929 HANDLE_AS_MARCH K-14(3) X 497104016 C85
DIODE_15 H-8(1) W 260-2929 ROTARY_HELAC_SENS I-5(3) 10 219-2392 C109 SOLENOID - A solenoid is an electrical component that is activated by electricity. It has a coil
DIODE_16 H-8(1) W 260-2929 HIGH_PRESSURE_WATER_SOL A-8(3) Q 3E-3360 B8 that makes an electromagnet when current flows through it. The electromagnet can open or
DIODE_17 J-15(1) W 260-2929 HORN_AS G-4(3) 11 174-7875 C39 close a valve or move a piece of metal that can do work.
17 16 DIODE_18 G-15(1) W 260-2929 HORN_AS_REAR J-4(3) 12 174-7875 C86
DIODE_19 G-15(1) W 260-2929 HYDR_OIL_PSI_SW_1 I-10(3) No Code C18 MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is
DIODE_20 G-15(1) W 260-2929 HYDR_OIL_PSI_SW_2 I-10(3) No Code C18A activated by electricity and held latch by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
DIODE_21 G-15(1) W 260-2929 HYDR_OIL_TEMP I-9(3) 14 145-7028 C90 the latch coil circuit open at the time the coil latches.
DIODE_22 J-15(1) W 260-2929 INTAKE_AIR_FILTER_SW I-10(3) 15 No Code C24
DIODE_23 H-12(1) W 260-2929 KEY_SELECTOR_SW F-16(3) Z 288575 C45
DIODE_25 I-14(1) W 260-2929 LEGS_LIMIT_1_SW C-12/13(3) 19 288560 C77
DIODE_26 F-15(1) W 260-2929 LEGS_LIMIT_2_SW C-12/13(3) 19 288560 C78
DIODE_27 F-10(1) W 260-2929 LH_SIDE_PLATE_DN_SOL A-13(3) G 3E-3360 B15
DIODE_31 F-14(1) W 260-2929 LH_SIDE_PLATE_UP_SOL A-13(3) G 3E-3360 A15
DIODE_32 H-10(1) W 260-2929 MICROSW_GATE_OPEN K-16(3) W 283359 C112
FLASHER G-14(1) W 108-0358 C67 MOLDBOARD_MICROSW_1 D-14(3) Z 283359 C50
FLASHER(OPT) H-11(1) W 108-0358 C34 MOLDBOARD_MICROSW_2 F-7(3) W 283359 C44 QENR2009
FU1 H-12(1) 217-4223 10A MOLDBOARD_SWITCH_LH E-16(3) Z 8T-8034 C47
May2005
FU2 G-12(1) 217-4223 10A MOTOR_CONNECTOR K/L-8(3) W 133-8748 M
FU3 G-12(1) 217-4223 10A MOV_COLUMN_REAR_RH_SENS B-10(3) 18 497101016 C111
FU4 G-12(1) 217-4223 10A OIL_LEV_SW I-10(3) 13 146-8437 C17
FU5 G-12(1) 217-4223 10A ORIENT_CONVEYOR J/K-16(3) X 288235 C63
FU6 G-12(1) 217-4223 10A PROXIMITY_SWITCH_NC I-5(3) 16 283286 C114
FU7 G-12(1) 217-4223 10A PROXIMITY_SWITCH_NO J-5(3) 17 288560 C113
FU8 G-12(1) 217-4223 10A REAR_LH_COLUMN_DN_SOL B-16(3) L 3E-3360 B17
FU9 F/G-12(1) 217-4223 10A REAR_LH_COLUMN_UP_SOL B-15(3) L 3E-3360 A17
FU10 G-12(1) 217-4223 10A REAR_RH_COLUMN_DN_SOL B-15(3) B 3E-3360 B18
10 4
FU11 G-12(1) 270-6709 20A REAR_RH_COLUMN_IN_SOL A-16(3) I 3E-3360 A2(rientro)
FU12 F/G-12(1) 217-4223 10A REAR_RH_COLUMN_UP_SOL B-15(3) B 3E-3360 A18
FU13 F-12(1) 217-4223 10A STEER/ROTAT_REAR_RH_TRACK_SOL A-16(3) S 3E-3360 A25
7 19 Y X 22 13 20 1 7 23 24 25 FU14 F-12(1) 217-4223 10A STEER_RH/ROTATION_LH_SOL A-14(3) S 3E-3360 B22
FU15 G-12(1) 217-4223 10A RHEOSTAT_2 H-16(3) X 213-8147 C87
FU16 G-12(1) FUSES- W 217-4223 10A RH_SIDE_PLATE_DN_SOL A-13(3) C 3E-3360 B16
FU17 H-11(1) 217-4223 10A RH_SIDE_PLATE_UP_SOL A-12(3) C 3E-3360 A16
FU18 H-11(1) 217-4223 10A CLUTCH_SOL H-9(3) P 3E-3360 A7

Schematic
FU20 G-11(1) 217-4223 10A DIFFERENTIAL_LOCK_SOL B-17(3) J 3E-3360 A14
FU21 G-11(1) 217-4223 10A SOCKET_AS B-12(3) W 117-2311
FU22 G-11(1) 217-4223 10A STARTER (MOTOR) G/H-11(3) 20 (Verif.) 132-2156 C8
FU23 G-11(1) 217-4223 10A START_RELAY I-10(3) W 125-1302 C19
FU24 G-11(1) 217-4223 10A STEER_TRACKS_FRONT_SENS C-9(3) 21 282198 C111
11 FU25
FU26
G-11(1)
G-11(1)
217-4223
217-4223
10A
10A
STEER_TRACK_REAR_RH_SENS
STOP_LIGHT_1
I-5(3)
C-5(3)
22
23
224-5530
2U-4671
C108
L22 PM102
9
FU27
FU28
G-11(1)
G-11(1)
217-4223
217-4223
10A
10A
STOP_LIGHT_2
SWITCH_AS-HORN_LH
C-5(3)
D-16(3)
23
Z
2U-4671
158-6632
L23
C81 ColdPlaner
Electrical System
FU29 F-11(1) 217-4223 10A SWITCH_AS_HORN_RH K-6(3) K 158-6632 C80
FU30 G-10(1) 217-4223 10A SIDE_PLATE_LIGHT_LH K-4(3) 24 2U-4671 L20
FU31 G-10(1) 217-4223 10A SIDE_PLATE_LIGHT_RH K-4(3) 24 2U-4671 L21
2 FU32 F/G-10(1) 217-4223 10A UP_COLUMN_SW H-15(3) X 246-8912 C71 PM 102
HORN_AS_CONSOLE F-10(1) W 174-7875 C79 UP_MOLDBOARD_SOL B-14(3) H 3E-3360 B5
PLUS1_UNIT B-13/14(1) W 253-8112 C93
Z1X-1-Up
WARNING_LAMP(MOLDBOARD) C-16(3) Z 267-6376 S15
11 WARNING_LAMP(SPRAY) C-3(3) W 267-6355 S19
WARNING_LAMP(W_LOAD) C-2(3) W 267-6360 S20
WATER_ON/OFF_SOL A-9(3) Q 3E-3360 B9
WATER_REFILL_SOL A-8(3) Q 3E-3360 A8
WATER_LOAD_SWITCH D-2(3) W 8D-2676 C58
WATER_PSI_SW B-17(3) W No Code C60
WATER_PUMP_SWITCH K-6(3) Y 1V-6652 C57
WATER_SPRAY_SOL A-9(3) Q 3E-3360 A9
6 19 8 15 14 12 6 23 24 25
WATER_SPRAY_SWITCH D-3(3) W 8D-2676 C59
FLOOD_LIGHT_1 C-6(3) 26 172-9973 L3
FLOOD_LIGHT_2 C-6(3) 26 172-9973 L4
FLOOD_LIGHT_3 C-5(3) 26 172-9973 L28
FLOOD_LIGHT_4 D-6(3) 26 172-9973 L5
FLOOD_LIGHT_5 D-6(3) 26 172-9973 L6
FLOOD_LIGHT_6 D-6(3) 26 172-9973 L9
FLOOD_LIGHT_7 D-5(3) 26 172-9973 L10
FLOOD_LIGHT_8 K-4(3) 26 172-9973 L11
FLOOD_LIGHT_9 K-3(3) 26 172-9973 L12
Sheet2/3 FLOOD_LIGHT_10
FLOOD_LIGHT_11
E-5(3)
E-6(3)
26
26
172-9973
172-9973
L13
L14
Schematic FLOOD_LIGHT_12 G-4(3) 26 172-9973 L15
Machine
Component Location Code Note PLUG_CONN_DATA J-8(3) 3E-3370 C27
Location
(&Sheet) PLUG J-7(3) 8N-1532 C96
464R Resistor
825R Resistor
F-12(2) W 155-2273 Plug
1500R Resistor
2210R Resistor
ANTISLAB_SWITCH H-13(2) Y 8D-2676 C92
ANTISLAB_SW H-5(2) Y 5E-9299 C51
DRUM_ROT_LAMP G-7(2) Y 267-6356 S16
AUTO_LEVELING_SW G-13(2) Y 8D-2676 C68
AUTO_MANUAL_RPM G-13(2) Y 8D-2676 C23
BRAKE-KNOB E-13(2) Y 110-8338/116-5275/180-5617
C95/S7
BYPASS E-13(2) Y 1V-6652 C76
CANOPY_MOVE_SW D-13(2) Y 246-8912 C37
A L Assetto ruota posteriore SX
Q A L Left rear wheel positioning
CHANGE_SPEED H-13(2) Y 1V-6652 C64
COLUMN_RH_REAR F-12(2) Y 246-8912 C40
A L
3
COLUMN_ON_SW E-13(2) Y 8D-2676 C41
CONVEYOR_SW G-5(2) Y 3E-3360 C61 F B Assetto ruota posteriore DX M Sollevamento/abbassamento tettoia
DISPLAY_AS(COLOR/BW) E4(2) Y 263-7083/263-7079 C91 B Right rear wheel positioning M Canopy raising /lowering
DRUM_SWITCH F-5(2) Y 077-8200 C52 B M
ENGINE_FAILURE_LAMP G-9(2) Y 267-6352 S5 E
ENGINE_MALFUNCTION_LAMP G-9(2) Y 270-2479 S6 P Frizione-tenditore cinghie
C Sollevamento paratia laterale DX
FUEL_LEVEL_METER I-4(2) Y 170-6305 C14 P Clutch-belt tension
C Right side bulkhead raising
GENERAL_OFF_LAMP G-8(2) Y 267-6371 S12 P -Tendeur courroie
U C
GENERAL_ON_BUTTON H-13(2) Y 288381 C42
GENERAL_ON_LAMP G-7(2) Y 267-6370 S21 Y - CONTROL PANEL - DASHBOARD
30 W 5 GENERATOR_LAMP G-8(2) Y 267-6338 S13
E Sollevamento nastro trasportatore Q Pompa acqua (Spruzzatura carico)
E Raising conveyor belt Q Water pump (spray load)
HANDLE_AS_CONVEYOR I-13(2) Y 288235 C75 X - SEAT ARM CONTROL PANEL H E Q -chargement)
HAZARD H-7(2) Y 288271 C36
HORN_AS_SW(CONVEYOR) H-5(2) Y 158-6632 C121 W - RELE PANEL F Direzionamento nastro R Motore nastro trasportatore
HYDRAULIC_OIL_FILTER_LAMP G-10(2) Y 267-6345 S2
F Conveyor directioning R Conveyor belt motor
HYDRAULIC_OIL_LEVEL_LAMP G-10(2) Y 267-6342 S3 G
INTAKE_AIR_FILTER_LAMP G-10(2) Y 267-6344 S4 Z - LEFT GROUND PANEL F R
26 3 KEY-SWITCH F-13(2) Y 9G- 7641 C10
LAMP_TEST_SWITCH H-11(2) Y 268-0837 268-0834 155-2273C12 K - RIGHT GROUND PANEL S Sterzo cingolo posteriore DX +
G Sollevamento paratia laterale SX S rotazione
LIGHT-SWITCH D-13(2) Y 288335 C32 L G Left side bulkhead raising
LOW_LEVEL_WATER_TANK_LAMP G-7(2) Y 267-6350 S17 S Right rear carriage rotation
J - PILOT MANIFOLD G S
MOLDBOARD_SWITCH_RH H-5(2) Y 8D-2676 C49
PANEL_LIGHT_1 Y 7N-5876 L25 H Sollevamento tegolo T Antiplacca
D-7(2)
PANEL_LIGHT_2 Y 7N-5876 L26 H Main panel lifting T Antislab
PANEL_LIGHT_3 Y 7N-5876 L27 H T Anti-
D-8(2)
R
PANEL_LIGHT_4 Y 7N-5876 L24
PARKING_BRAKE_LAMP G-10(2) Y 267-6334 S1 I Rientro in sagoma ruota DX U Assetto anteriore
REV_DIR_CONVEYOR_SW G-5(2) Y 1V-6652 C62 I Right wheel return to camper
RHEOSTAT_1 F-13(2) Y 213-8155 C26 A T S M P I C B U Front positioning
I U
SECURITY_MODE_LAMP G-7(2) Y 267-6372 S23
SIDE_PLATE_LH_SW I-5(2) Y 246-8912 C65
SIDE_PLATE_RH_SW H-5(2) Y 246-8912 C66
SOCKET_AS_RH G-5(2) Y 117-2311
TURN_LIGHT_SWITCH G-8(2) Y 8D-2676 C35
TURN_SIGNALS_LAMP G-9(2) Y 267-6358 S10
UNLOCK_LAMP G-9(2) Y 273-6413 S8
WARNING_LAMP(FLASHER) F-5(2) Y 267-6376 S22
WARNING_LAMP_(SIDE_PLATE) F-5(2) Y 267-6376 S14
WATER_PUMP_SWITCH I-5(2) K 8D-2676 C56
Z WATER_SPRAY_LAMP G-7(2) Y 270-2482 S18
FLOOD_LIGHT_LAMP G-9(2) Y 267-6363 S9
YELLOW_L.(COLUMN) G-9(2) Y 267-6375 S11
120R Resistor E-4(2) Y No code

26 26 LEFT RIGHT
Sheet1/3
Sheet2/3
Sheet3/3

You might also like