Cat Electronic Technician 2024A v1.

1
Product Status Report

17/07/2024 14:38

Product Status Report

Parameter Value
Engine Serial Number S2R00559
Equipment ID Genset. #3
Comments

3516C Engine - Genset #1 (S2R00559)

Parameter Value
Equipment ID Genset. #3
Engine Serial Number S2R00559
ECM Serial Number 3352B237JP
Personality Module Part Number 4579040-00
Personality Module Release Date MAR14
Personality Module Description GENSET

Logged Diagnostic Codes [Diagnostic Clock = 43204 hours] - 3516C Engine - Genset #1
(S2R00559)
Code Description Occ. First Last
No Logged
Diagnostic
Codes

Logged Event Codes [Diagnostic Clock = 43204 hours] - 3516C Engine - Genset #1 (S2R00559)
Code Description Occ. First Last
E264 (3) Emergency Stop Activated 1 43202 43202
E004 (3) Engine Overspeed Shutdown 1 43201 43201
E190 (1) Engine Overspeed Warning 1 43201 43201

Active Diagnostic Codes - 3516C Engine - Genset #1 (S2R00559)

Code Description
No Active
Diagnostic
Codes

Active Event Codes - 3516C Engine - Genset #1 (S2R00559)

Code Description
No Active
Events

Current Totals - 3516C Engine - Genset #1 (S2R00559)

Description Value Unit
Total Time 43204 hours
Total Fuel 5562189 L

Configuration - 3516C Engine - Genset #1 (S2R00559)

Description Value Unit
Equipment ID Genset. #3
Engine Serial Number S2R00559
ECM Serial Number 3352B237JP
Personality Module Part Number 4579040-00
Personality Module Release Date MAR14
Rating Number 1
Rated Frequency 60 Hz
Rated Engine Speed 1800 rpm
Rated Real Genset Power 1901 kW
Rated Apparent Genset Power Unavailable Parameter
Rating Configuration Unavailable Parameter
Engine Rating Application Type Prime
Fuel Ratio Control Offset 0
Acceleration Delay Time 0 sec
Engine Acceleration Rate 150 rpm/s
Low Idle Speed 900 rpm
Cooldown Speed 1800 rpm
Cooldown Duration 0 min
Engine Pre-Lube Duration 0 sec
Engine Pre-Lube System Configuration Automatic
Engine Continuous Pre-Lube Interval 0 min
Crank Duration 10 sec
Maximum Number of Crank Cycles 3
Crank Terminate RPM 400 rpm
Engine Speed Droop 0.0 %
Rated Fuel Position 23.300 mm
Fuel Correction Factor 0 %
Governor Gain Factor #1 26214
Governor Minimum Stability Factor #1 300
Governor Maximum Stability Factor #1 7864
FLS 0
FTS 0
Air Shutoff Disabled
Air Intake Shutoff Detection Installation Unavailable
Status
Ether Control Disabled
Engine Cooling System Config SCAC (Separate Circuit Aftercooled)
Direct Fuel Control Mode Disabled
Desired Speed Input Configuration PWM
Secondary Desired Speed Input Not Installed
Configuration
Fuel Enable Input Configuration Switch to Ground
Secondary Fuel Enable Input Enable Enabled
Status
Coolant Level Sensor Not Installed
Aftercooler Coolant Level Sensor Not Installed
Installation Status
Cat Data Link #2 Identifier Engine Control #3
Inlet Air Temperature Sensor Installed
Engine Oil Temperature Sensor Installation Installed
Status
Cold Cylinder Cutout Disabled
Total Tattletale 14
MonSys Ovr SW Ins 17
Num of Turbo In 2

Lifetime: Time vs Engine Speed - 3516C Engine - Genset #1 (S2R00559)

Engine Speed( rpm ) hours %
<400.0 0.30 0.02
400.0-499.0 0.05 0.00
500.0-599.0 0.05 0.00
600.0-699.0 0.10 0.01
700.0-799.0 0.05 0.00
800.0-899.0 0.10 0.01
900.0-999.0 0.10 0.01
1000.0-1099.0 0.05 0.00
1100.0-1199.0 0.15 0.01
1200.0-1299.0 0.10 0.01
1300.0-1399.0 0.05 0.00
1400.0-1499.0 0.05 0.00
1500.0-1599.0 0.05 0.00
1600.0-1699.0 0.05 0.00
1700.0-1799.0 51.15 2.89
1800.0-1899.0 1719.70 97.04
1900.0-1999.0 0.00 0.00
>2000.0 0.00 0.00

Lifetime: Time vs Engine Load Factor - 3516C Engine - Genset #1 (S2R00559)

Engine Load Factor( % ) hours %
<5.0 1.00 0.06
5.0-9.0 0.20 0.01
10.0-14.0 0.35 0.02
15.0-19.0 15.25 0.86
20.0-24.0 981.60 55.39
25.0-29.0 301.35 17.00
30.0-34.0 89.45 5.05
35.0-39.0 23.20 1.31
40.0-44.0 5.25 0.30
45.0-49.0 38.20 2.16
50.0-54.0 66.00 3.72
55.0-59.0 134.25 7.58
60.0-64.0 67.05 3.78
65.0-69.0 45.05 2.54
70.0-74.0 3.45 0.19
75.0-79.0 0.50 0.03
80.0-84.0 0.00 0.00
85.0-89.0 0.00 0.00
90.0-94.0 0.00 0.00
95.0-99.0 0.00 0.00
>100.0 0.00 0.00

Lifetime: Time vs Right Exhaust Temperature - 3516C Engine - Genset #1 (S2R00559)

Right Exhaust Temperature( hours %
Deg C )
<450.0 1387.10 78.27
450.0-464.0 12.55 0.71
465.0-479.0 8.20 0.46
480.0-494.0 6.40 0.36
495.0-509.0 5.75 0.32
510.0-524.0 21.10 1.19
525.0-539.0 84.40 4.76
540.0-554.0 35.50 2.00
555.0-569.0 71.45 4.03
570.0-584.0 92.80 5.24
585.0-599.0 23.30 1.31
600.0-614.0 20.70 1.17
615.0-629.0 2.90 0.16
630.0-644.0 0.00 0.00
645.0-659.0 0.00 0.00
660.0-674.0 0.00 0.00
675.0-689.0 0.00 0.00
690.0-704.0 0.00 0.00
705.0-719.0 0.00 0.00
720.0-734.0 0.00 0.00
735.0-749.0 0.00 0.00
750.0-764.0 0.00 0.00
>765.0 0.00 0.00

Lifetime: Time vs Left Exhaust Temperature - 3516C Engine - Genset #1 (S2R00559)

Left Exhaust Temperature( Deg hours %
C)
<450.0 1356.10 76.53
450.0-464.0 15.55 0.88
465.0-479.0 17.10 0.96
480.0-494.0 12.15 0.69
495.0-509.0 9.50 0.54
510.0-524.0 4.05 0.23
525.0-539.0 2.60 0.15
540.0-554.0 15.70 0.89
555.0-569.0 52.65 2.97
570.0-584.0 76.10 4.29
585.0-599.0 68.80 3.88
600.0-614.0 107.45 6.06
615.0-629.0 29.80 1.68
630.0-644.0 4.45 0.25
645.0-659.0 0.05 0.00
660.0-674.0 0.00 0.00
675.0-689.0 0.00 0.00
690.0-704.0 0.00 0.00
705.0-719.0 0.00 0.00
720.0-734.0 0.00 0.00
735.0-749.0 0.00 0.00
750.0-764.0 0.00 0.00
>765.0 0.00 0.00

Monitoring System - 3516C Engine - Genset #1 (S2R00559)

Description State Trip Point Delay Time
Altitude (atmospheric
pressure)
Moderate Severity (2) Off 92.5 kPa 0 sec
Engine Overspeed
Least Severe (1) On 2070 rpm 0 sec
Most Severe (3) On 2070 rpm 0 sec
High Aftercooler
Coolant Temperature
Least Severe (1) On 60 Deg C 5 sec
Moderate Severity (2) Off 107 Deg C 5 sec
Most Severe (3) Off 107 Deg C 5 sec
High Air Filter
Restriction Pressure
Least Severe (1) On 7.0 kPa 5 sec
Moderate Severity (2) Off 7.0 kPa 5 sec
High Boost Pressure
Least Severe (1) Off 400.0 kPa 0 sec
Moderate Severity (2) Off 400.0 kPa 0 sec
High Crankcase
Pressure
Least Severe (1) On 2.0 kPa 3 sec
Moderate Severity (2) Off 6.0 kPa 10 sec
Most Severe (3) Off 3.5 kPa 3 sec
High Engine Coolant
Temperature
Least Severe (1) On 102 Deg C 5 sec
Moderate Severity (2) Off 107 Deg C 30 sec
Most Severe (3) Off 107 Deg C 5 sec
High Engine Oil Filter
Restriction Pressure
Least Severe (1) On 105 kPa 5 sec
High Exhaust
Temperature
Least Severe (1) On 650 Deg C 5 sec
Moderate Severity (2) Off 728 Deg C 5 sec
High Fuel Filter
Restriction Pressure
Least Severe (1) On 105 kPa 5 sec
Low Aftercooler
Coolant Level
Least Severe (1) Off None 30 sec
Most Severe (3) Off None 30 sec
Low Coolant Level
Least Severe (1) Off None 30 sec
Most Severe (3) Off None 30 sec
Low Engine Coolant
Temperature
Least Severe (1) Off 63 Deg C 5 sec
Low Engine Oil
Pressure
Least Severe (1) On None 4 sec
Most Severe (3) Off None 9 sec
Low Fuel Pressure
Most Severe (3) Off 220 kPa 20 sec
Low System Voltage
Least Severe (1) On 22 Volts 10 sec

Injector Codes Calibration - 3516C Engine - Genset #1 (S2R00559)

Injector Code
Injector 1 5617
Injector 2 9925
Injector 3 7706
Injector 4 2655
Injector 5 3305
Injector 6 7826
Injector 7 2530
Injector 8 2650
Injector 9 2655
Injector 10 5830
Injector 11 5500
Injector 12 2860
Injector 13 4966
Injector 14 5840
Injector 15 2536
Injector 16 2756

Bridge MPD - Port Engine

Parameter Value
ECM Part Number 307-754200
ECM Serial Number 1968G072MP
Software Group Part Number 3942605-00
Software Group Release Date JAN 12
Software Group Description Mini MPD/MPD

Configuration - Bridge MPD - Port Engine

Description Value Unit
Display Location Bridge
Engine Location Port