Cat Electronic Technician 2014A v1.
0
Product Status Report
12/4/2014 2:06 PM
Product Status Report
Parameter Value
Engine Serial Number 7WG05314
Equipment ID NOT PROGRAMMED
Comments
3456 Genset (7WG05314)
Parameter Value
Equipment ID NOT PROGRAMMED
Engine Serial Number 7WG05314
ECM Serial Number 3076B206CG
Personality Module Part Number 2628919-00
Personality Module Release Date Nov04
Personality Module Description EPG 3456
Logged Diagnostic Codes [Diagnostic Clock = 17220 hours] - 3456 Genset (7WG05314)
Code Description Occ. First Last
No Logged
Diagnostic
Codes
Logged Event Codes [Diagnostic Clock = 17220 hours] - 3456 Genset (7WG05314)
Code Description Occ. First Last
E017 High Engine Coolant Temperature Warning 5 7900 16439
E027 High Inlet Air Temperature Warning 3 7900 8215
E038 Low Engine Coolant Temperature Warning 124 1 17219
E100 Low Engine Oil Pressure Warning 1 16954 16954
Active Diagnostic Codes - 3456 Genset (7WG05314)
Code Description
No Active
Codes
Current Totals - 3456 Genset (7WG05314)
Description Value Unit
Total Time 17220 hours
Total Fuel 424468 L
Ether Usage Unavailable L
Configuration - 3456 Genset (7WG05314)
Description Value Unit
Equipment ID NOT PROGRAMMED
Engine Serial Number 7WG05314
ECM Serial Number 3076B206CG
Personality Module Part Number 2628919-00
Personality Module Release Date Nov04
Personality Module Description EPG 3456
Rating Number 1
Rated Frequency 50 Hz
Rated Engine Speed 1500 rpm
Rated Standby Power 400 kW
Rated Prime Power 364 kW
Rating Configuration Low BSFC
Test Spec 0K2713 0K2715
Engine Acceleration Rate 2000 rpm/s
Low Idle Speed 1200 rpm
Cooldown Speed 1800 rpm
Cooldown Duration 0 min
Crank Duration 10 sec
Maximum Number of Crank Cycles 0
Crank Terminate RPM 400 rpm
Ether Control Disabled
Fuel Pressure Sensor Installed
Exhaust Temperature Sensor Installation Not Installed
Status
Engine Oil Temperature Sensor Installation Not Installed
Status
User Defined Switch Installation Status Not Installed
Air Shutoff Disabled
User Defined Switch Active State Low
Configuration
Coolant Level Sensor Not Installed
System Gain 0
FLS -68
FTS 84
Total Tattletale 1
Monitoring System - 3456 Genset (7WG05314)
Description State Trip Point Delay Time
Engine Overspeed
Least Severe (1) On 2200 rpm 0 sec
Most Severe (3) Off 2300 rpm 0 sec
High Engine Coolant
Temperature
Least Severe (1) On 103 Deg C 5 sec
Moderate Severity (2) Off 105 Deg C 5 sec
Most Severe (3) Off 106 Deg C 20 sec
High Engine Inlet Air
Temperature
Least Severe (1) On 78.0 Deg C 30 sec
High Fuel Temperature
Least Severe (1) On 80.0 Deg C 30 sec
Low Engine Coolant
Temperature
Least Severe (1) On 75 Deg C 255 sec
Low Engine Oil
Pressure
Least Severe (1) On None 5 sec
Most Severe (3) Off None 10 sec
Low System Voltage
Least Severe (1) On 20 Volts 5 sec
Injector Codes Calibration - 3456 Genset (7WG05314)
Injector Code
Injector 1 5731
Injector 2 3286
Injector 3 3354
Injector 4 7711
Injector 5 8815
Injector 6 1081
Genset Control #1
Parameter Value
Module ID $58
Application ID $60
Data Link ID $01
Logged Diagnostic Codes [Diagnostic Clock = 17220 hours] - Genset Control #1
Code Description Occ. First Last
168- 4 Electrical System Voltage : Voltage Below Normal 48 0 17219
100- 2 Engine Oil Pressure Sensor : Erratic, Intermittent, 7 0 16962
or Incorrect
190- 3 Engine Speed Sensor : Voltage Above Normal 5 16954 16954
566- 7 Unexpected Engine Shutdown 12 5826 16455
110- 2 Engine Coolant Temperature Sensor : Erratic, 3 0 13867
Intermittent, or Incorrect
590- 9 Engine Control Module : Abnormal Update Rate 2 0 6173
269- 4 Sensor Power Supply : Voltage Below Normal 3 0 0
500-12 Electronic Control Module : Failure 1 0 0
Active Diagnostic Codes - Genset Control #1
Code Description
No Active
Codes
