Seite 1 von 9
Cat Electronic Technician 2018A v1.0
Product Status Report
15.12.2020 16:33
• C11 730 (TXE07282)
• Transmission 730 (KYP00748)
• Monitor OHT
Product Status Report
Parameter Value
Product ID B1M04241
Equipment ID AT CFG
Comments www.mevas.eu
C11 730 (TXE07282) TOP
Parameter Value
Product ID B1M04241
Equipment ID B1M04241
Engine Serial Number TXE07282
ECM Part Number 3722905-00
ECM Serial Number 25426148JL
Software Group Part Number 3696646-00
Software Group Release Date NOV10
Software Group Description AT-730
Active Diagnostic Codes Present No
Logged Diagnostic Codes [Diagnostic Clock = 8839,4132 hours] - C11 730
(TXE07282)
Code Description Occ. First Last
No Logged Diagnostic Codes
Logged Event Codes [Diagnostic Clock = 8839,4132 hours] - C11 730
(TXE07282)
file:///C:/Users/Mevas1/Desktop/PSR/B1M04241_PSRPT_2020-12-15_16.33.07.xml 15.12.2020
Seite 2 von 9
Code Description Occ. First Last
E172 (1) High Air Filter Restriction 22 8775 8779
E172 (2) High Air Filter Restriction 1 8776 8776
Active Diagnostic Codes - C11 730 (TXE07282)
Code Description
No Active Diagnostic Codes
Active Event Codes - C11 730 (TXE07282)
Code Description
No Active Event Codes
Current Totals - C11 730 (TXE07282)
Description Value Unit
Total Fuel 147167 L
Ether Usage Unavailable L
Total Idle Time 3432:03 hours
Total Idle Fuel 12352 L
Total Max Fuel 554892 L
Total Operating Hours 8839 hours
Engine Starts 5247
Lifetime Total Engine Revolutions 664117932 rev
Starts/Hour 0,59
Average RPM 1252,25 rpm
Percentage Idle Time 38,83 %
Average Fuel Rate 16,65 L/h
Overall Load Factor 26 %
Configuration - C11 730 (TXE07282)
Description Value Unit
Product ID B1M04241
Equipment ID B1M04241
Engine Serial Number TXE07282
ECM Part Number 3722905-00
ECM Serial Number 25426148JL
Software Group Part Number 3696646-00
Software Group Release Date NOV10
file:///C:/Users/Mevas1/Desktop/PSR/B1M04241_PSRPT_2020-12-15_16.33.07.xml 15.12.2020
Seite 3 von 9
Software Group Description AT-730
Engine Fan Control On
Ether Solenoid Configuration Continuous Flow Solenoid
Engine Warm Up Elevated Idle Feature Enable Status Disabled
Engine Warm Up Elevated Idle Delay Time 5,0 min
PTO Engine Speed Setting 1500 rpm
Security System Immobilizer Installation Status Disabled or Not Installed
Engine Governor Primary Mode Configuration Torque Control
FLS 14
FTS -19
Total Tattletale 2
Lifetime: Time vs Engine Coolant Temperature - C11 730 (TXE07282)
Engine Coolant Temperature( Deg C ) hours %
<50,0 191,15 2,17
50,0-54,0 38,05 0,43
55,0-59,0 40,90 0,47
60,0-64,0 50,40 0,57
65,0-69,0 62,15 0,71
70,0-74,0 88,75 1,01
75,0-79,0 3624,75 41,22
80,0-84,0 4172,95 47,46
85,0-89,0 496,90 5,65
90,0-94,0 26,75 0,30
95,0-99,0 0,00 0,00
100,0-104,0 0,00 0,00
105,0-109,0 0,00 0,00
110,0-114,0 0,00 0,00
115,0-119,0 0,00 0,00
>120,0 0,00 0,00
Lifetime: Time vs Inlet Air Temperature - C11 730 (TXE07282)
Inlet Air Temperature( Deg C ) hours %
<40,0 387,70 55,28
40,0-44,0 149,15 21,26
45,0-49,0 137,35 19,58
50,0-54,0 27,05 3,86
55,0-59,0 0,15 0,02
60,0-64,0 0,00 0,00
65,0-69,0 0,00 0,00
file:///C:/Users/Mevas1/Desktop/PSR/B1M04241_PSRPT_2020-12-15_16.33.07.xml 15.12.2020
Seite 4 von 9
70,0-74,0 0,00 0,00
75,0-79,0 0,00 0,00
80,0-84,0 0,00 0,00
85,0-89,0 0,00 0,00
90,0-94,0 0,00 0,00
95,0-99,0 0,00 0,00
>100,0 0,00 0,00
Lifetime: Time vs Boost Pressure - C11 730 (TXE07282)
Boost Pressure( kPa ) hours %
<80,0 12,75 1,82
80,0-89,0 12,30 1,75
90,0-99,0 19,15 2,73
100,0-109,0 35,90 5,12
110,0-119,0 84,70 12,08
120,0-129,0 168,05 23,97
130,0-139,0 258,90 36,92
140,0-149,0 91,70 13,08
150,0-159,0 13,55 1,93
160,0-169,0 2,70 0,39
170,0-179,0 1,20 0,17
180,0-189,0 0,30 0,04
190,0-199,0 0,00 0,00
>200,0 0,00 0,00
Lifetime: Time vs Engine Speed And Engine Load Factor - C11 730 (TXE07282)
1100- 1300- 1500- 1700- 1900- 2100-
rpm <1100 >2300 Total
1299 1499 1699 1899 2099 2299
%
<50,0 2994,00 451,20 1042,00 949,60 545,55 208,70 111,45 7,95 6310,45
50,0-59,9 21,25 43,45 133,10 139,80 72,25 19,05 5,15 0,00 434,05
60,0-69,9 8,90 25,95 105,45 127,30 68,30 20,10 4,55 0,00 360,55
70,0-79,9 3,70 15,80 74,40 100,25 65,35 21,95 3,80 0,00 285,25
80,0-89,9 3,05 9,70 52,25 69,65 57,45 23,00 3,70 0,00 218,80
>90,0 2,25 29,80 153,05 198,15 205,65 124,00 9,90 0,00 722,80
Total 3033,15 575,90 1560,25 1584,75 1014,55 416,80 138,55 7,95 8331,90
Lifetime: Total Occurrences vs Engine Speed - C11 730 (TXE07282)
Engine Speed( rpm ) %
file:///C:/Users/Mevas1/Desktop/PSR/B1M04241_PSRPT_2020-12-15_16.33.07.xml 15.12.2020
Seite 5 von 9
<2500,0 0,00 0,00
2500,0-2599,0 1260,00 92,17
2600,0-2699,0 82,00 6,00
2700,0-2799,0 20,00 1,46
2800,0-2899,0 1,00 0,07
2900,0-2999,0 0,00 0,00
3000,0-3099,0 3,00 0,22
3100,0-3199,0 0,00 0,00
3200,0-3299,0 1,00 0,07
>3300,0 0,00 0,00
Injector Trim Calibration - C11 730 (TXE07282)
Injector Serial Number File Version
Injector1 000000005E0119308820 0
Injector2 000000005E0119308404 0
Injector3 000000005E01193078E3 0
Injector4 000000005E0119308216 0
Injector5 000000005E01193077CE 0
Injector6 000000005E0119308503 0
Monitoring System - C11 730 (TXE07282)
Description State Trip Point Delay Time
Engine Overspeed
Least Severe (1) Always On 2600 rpm 0 sec
Moderate Severity (2) Always On 2800 rpm 0 sec
High Air Filter Restriction Pressure
Least Severe (1) Always On 7,5 kPa 30 sec
Moderate Severity (2) Always On 9,0 kPa 30 sec
High Engine Coolant Temperature
Least Severe (1) Always On 110 Deg C 10 sec
Moderate Severity (2) Always On 111 Deg C 10 sec
High Engine Inlet Air Temperature
Least Severe (1) Always On 82,0 Deg C 8 sec
Moderate Severity (2) Always On 86,0 Deg C 8 sec
High Fuel Filter Pressure Restriction
Least Severe (1) Always On None 3600 sec
Moderate Severity (2) Always On None 14400 sec
High Fuel Pressure
Least Severe (1) Always On 758,0 kPa 8 sec
High Fuel Temperature
file:///C:/Users/Mevas1/Desktop/PSR/B1M04241_PSRPT_2020-12-15_16.33.07.xml 15.12.2020
Seite 6 von 9
Least Severe (1) Always On 90,0 Deg C 30 sec
Moderate Severity (2) Always On 91,0 Deg C 10 sec
Low Engine Oil Pressure
Least Severe (1) Always On None 8 sec
Moderate Severity (2) Always On None 4 sec
Transmission 730 (KYP00748) TOP
Parameter Value
Product ID B1M04241
Equipment ID B1M04241
ECM Part Number 3045687-02
ECM Serial Number 00536886MS
Software Group Part Number 4335813-00
Software Group Release Date NOV2012
Software Group Description 730(B1M00411-UP)TransType2
Logged Diagnostic Codes [Diagnostic Clock = 8839,4548 hours] -
Transmission 730 (KYP00748)
Code Description Occ. First Last
702- Transmission Gear Lever Selector Sensor (Switch) : Voltage
10 8770 8836
3 Above Normal
177-
Transmission Oil Temperature Sensor : Voltage Below Normal 127 8657 8834
4
177-
Transmission Oil Temperature Sensor : Voltage Above Normal 2 8803 8803
3
585- Transmission Output Speed Sensor # 1 : Erratic, Intermittent, or
2 8708 8726
2 Incorrect
672- Torque Converter Output Speed Sensor : Erratic, Intermittent, or
2 8671 8703
2 Incorrect
Logged Event Codes [Diagnostic Clock = 8839,4548 hours] - Transmission 730
(KYP00748)
Code Description Occ. First Last
E047 (1) Transmission Abuse Warning 115 7512 8742
E155 (2) High Torque Converter Oil Temperature 4 8523 8525
E329 (3) Transmission Filter Plugged 7 8792 8792
E330 (3) Transmission Output Speed Mismatch 3 7633 8726
file:///C:/Users/Mevas1/Desktop/PSR/B1M04241_PSRPT_2020-12-15_16.33.07.xml 15.12.2020
Seite 7 von 9
E556 (3) Low Brake Pump Pressure 1 7579 7579
E627 (1) Parking Brake Applied with Machine in Motion 20 8398 8814
Active Diagnostic Codes - Transmission 730 (KYP00748)
Code Description
No Active Diagnostic Codes
Active Event Codes - Transmission 730 (KYP00748)
Code Description
E764 (1) Trip Data Memory Full
Current Totals - Transmission 730 (KYP00748)
Description Value Unit
Total Operating Hours 8839 hours
Machine Working Distance 62169,1 km
Machine Idle Time 2731,10 hours
Machine Working Hours 6402 hours
Machine Working Total Fuel 110341,442 L
Load Count 26396
Total Forward Distance 83895,50 km
Total Reverse Distance 1520,80 km
Total Distance 85410,70 km
Configuration - Transmission 730 (KYP00748)
Description Value Unit
Equipment ID B1M04241
Product ID B1M04241
Transmission Serial Number K Y P00748
Transmission Maximum Forward Gear 6
Body Float Gear Limit 3
Body Up Sensor Installation Status Installed
Body Up Gear Limit 3
Top Drive Gear Select Enable Status Enabled
Transmission Hold Enable Status Enabled
Throttle Deactivated Retarding Enable Status Enabled
Hoist System Enable Status Enabled
Hoist Lower Valve Adjustment Status 0
file:///C:/Users/Mevas1/Desktop/PSR/B1M04241_PSRPT_2020-12-15_16.33.07.xml 15.12.2020
Seite 8 von 9
High Pressure Hydraulic Oil Filter Switch Config Not Installed
Information Units Status Metric
Auto Lube System Installation Status Unavailable
Cycle Counter Feature Installation Status Installed
Load Dump Departure Minimum Ground Speed Configuration 5 km/h
Ambient Air Temperature Operating Condition Configuration Normal
First Forward Gear Lockup Clutch Enable Enabled
Transmission Configuration Code 2
Operator # 1 Name MAX
Operator # 2 Name RENE
Operator # 3 Name $
Operator # 4 Name F
Operator # 5 Name Operator 5
Operator # 6 Name Operator 6
Operator # 7 Name WH@
Operator # 8 Name Operator 8
Operator # 9 Name Operator 9
Operator # 10 Name Operator 10
Customer Password # 1 * * * * * * * * * * * * * * * *
Customer Password # 2 * * * * * * * * * * * * * * * *
Total Tattletale 1
Shift Count Matrix [Transmission Shift Counts Start Time = 3 hours] -
Transmission 730 (KYP00748)
To N R 1 2 3 4 5 6
From
N --- 12781 72784 86 13 0 0 0
R 39741 --- 21880 0 0 0 0 0
1 41577 45658 --- 166523 0 0 0 0
2 4020 3193 158958 --- 172679 0 0 0
3 9 17 387 172117 --- 101969 0 0
4 6 2 22 121 101723 --- 45507 0
5 0 0 6 5 82 45412 --- 13221
6 0 0 0 0 2 0 13219 ---
Monitor OHT TOP
Parameter Value
Equipment ID AT CFG
file:///C:/Users/Mevas1/Desktop/PSR/B1M04241_PSRPT_2020-12-15_16.33.07.xml 15.12.2020
Seite 9 von 9
ECM Part Number 2395025-12
ECM Serial Number 3011B041HL
Software Group Part Number 3382686-00
Software Group Release Date JAN09
Software Group Description AT Messenger
Logged Diagnostic Codes [Diagnostic Clock = 8839,4473 hours] - Monitor OHT
Code Description Occ. First Last
No Logged Diagnostic Codes
Logged Event Codes [Diagnostic Clock = 8839,4473 hours] - Monitor OHT
Code Description Occ. First Last
No Logged Event Codes
Active Diagnostic Codes - Monitor OHT
Code Description
No Active Diagnostic Codes
Active Event Codes - Monitor OHT
Code Description
No Active Event Codes
Configuration - Monitor OHT
Description Value Unit
Equipment ID AT CFG
Product ID
Service Mode Enable Code 0
file:///C:/Users/Mevas1/Desktop/PSR/B1M04241_PSRPT_2020-12-15_16.33.07.xml 15.12.2020
