Serial Number: 4133

FAMILY,DM50

PARTS LIST
MODEL: DM50

Read the instruction manual before operating this equipment.

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

The Distributer/Dealer serving the area in which

your equipment is working will be able to give you the BEST and
FASTEST SERVICE of Genuine Replacement Parts.

IMPORTANT:
Be sure the parts book which you are ordering parts from is the parts book for
the Drill needing the replacement parts!
Each parts book is CUSTOM MADE to a specific Drill.
All parts books have a Drill SERIAL NUMBER and MODEL DESCRIPTION on
the header of each parts page. All Drills have a SERIAL NUMBER welded on the
frame at the drilling end of the MAIN FRAME or CHASSIS.

YOU MUST USE THE CORRECT PARTS BOOK TO INSURE

CORRECT PARTS IDENTIFICATION.

Continuing Product Improvement and advancement of product

design may cause changes to your Drill which may not be
reflected in this Parts/Service Manual. Production models may vary
in some detail. Drilling Solutions reserves the right to modify or make changes with-
out notice or obligation.

Parts Ordering Instructions

By giving complete information, you will enable us to fill your order

correctly and avoid unnecessary delays!

When ordering Replacement Parts, specify:

1. Unit Serial Number

2. The Name of each part as listed
3. The Part Number as listed in your Partsbook.
4. Quantity of parts desired.

Refer all communications concerning this unit to our nearest

Branch Office, Distributor, Dealer or Agent

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

WARNING IN THE MANUAL

CALIFORNIA PROPOSITION 65 INFORMATION

TO CALIFORNIA CUSTOMERS AND
TO CUSTOMERS SELLING DIESEL ENGINE EQUIPMENT
INTO OR FOR USE IN CALIFORNIA

CALIFORNIA
Proposition 65 Warning
Diesel engine exhaust and some of its constituents
are known to the State of California to cause cancer,
birth defects and other reproductive harm.

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Table of Contents

FRAME/CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
57402398 MAIN FRAME WELDMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
57083974 BLOCK, BEARING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

57231110 DECKING,SPLIT COOLERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

57193781 HANDRAILS--- DIV IND COLL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

TABLE OF CONTENTS
57095978 HOSE COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

UNDERCARRIAGE/TRACKS . . . . . . . . . . . . . . . . . . . 13
57390841 TRACK ASSY--- 325L +2 W/L&S . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
57388076 UNDERCARRIAGE,325L---L&S . . . . . . . . . . . . . . . . . . . 17
57562977 ROLLER ARRANGEMENT . . . . . . . . . . . . . . . . . . . . . . 19
57457566 CARRIER ROLLER GROUP . . . . . . . . . . . . . . . . . . . . . 21
57563140 GUARD GROUP---TRK GDE . . . . . . . . . . . . . . . . . . . . . 23
57415929 FINAL DRIVE GROUP---U/C . . . . . . . . . . . . . . . . . . . . . 25
57563348 TRACK ADJUSTMENT GROUP . . . . . . . . . . . . . . . . . . 29
57563397 SPRING GROUP RECOIL . . . . . . . . . . . . . . . . . . . . . . . . 31
57563413 IDLER,FRONT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
57563470 TRACK GROUP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
57563488 TRACK LINK ASSY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

JACKS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
57134991 JACK ASSY, FRONT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
57488868 CYLINDER HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . . . 43

57134975 JACK ASSY, REAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45

57224669 CYLINDER, HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . . 47

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page i
 Serial Number: 4133
FAMILY,DM50

Table of Contents

CAB/CONSOLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
57411639 CAB INSTL,SWINGDR,DM45HP . . . . . . . . . . . . . . . . . . . . . . . . . . 53
57411621 CAB,SWG’DR,DM45HPCONSOLE . . . . . . . . . . . . . . . . 61
57276909 HEATER, ASSY---LESS CABLE . . . . . . . . . . . . . . . . . . . 67
57243768 PANEL CONTROL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
57312001 PRE---CLEANER/FILTER KIT . . . . . . . . . . . . . . . . . . . . 71

57276792 GAGES/CONTROLS--- ETR CAT . . . . . . . . . . . . . . . . . . . . . . . . . . . 73

57276784 PANEL ASSY,ETR---CAT . . . . . . . . . . . . . . . . . . . . . . . . . 75
57078263 GAGE ASSY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
TABLE OF CONTENTS

57316184 CONTROL, ENG, ETR, CAT . . . . . . . . . . . . . . . . . . . . . . 79

57092686 GAUGE ASSY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
57092694 GAUGE ASSY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
57429920 GAUGE ASSY,400 PSI AIR . . . . . . . . . . . . . . . . . . . . . . . 85
57092702 GAUGE ASSY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
57100075 LEVEL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89

57093759 F/R CONT P--- HP UNITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91

57096398 MAIN VLV ASY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
58235128 KIT, SPLIT FLANGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
52178779 VALVE, FEED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
52223765 RELIEF VLV . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101
52236932 VALVE, PRESSURE---REMOTE . . . . . . . . . . . . . . . . . . . 103

57364465 AIR COND.--- CAT3408/3412 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105

57451353 KIT,AIR COND.---SGM . . . . . . . . . . . . . . . . . . . . . . . . . . . 111
57448086 EVAPORATOR W/THERMOSTAT . . . . . . . . . . . . . . . . . 115
57097487 PANEL,A/C FR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117

57097305 PIPING, HEATER/PRESS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 119

DERRICK/TOWER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
57428468 TOWER ASSY,25’ CABLE PD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 123
57425209 SUB 57492563 CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . 131

57085961 TOWER PIPING--- 2 MOTOR 25’ . . . . . . . . . . . . . . . . . . . . . . . . . . . 133

57116196 TOWER CYL,P--- DM45/50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 139

57402331 TOWER PINNING,PIPING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 141

57162091 ROTARY HEAD--- 4SF--- 2--- 12DM50 . . . . . . . . . . . . . . . . . . . . . . . . . 145

57367914 HOUSING, W/BUSH---ROTARYHD . . . . . . . . . . . . . . . . 153
57117764 MOTOR,HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
54472170 KIT,RETAINING RING . . . . . . . . . . . . . . . . . . . . . . . . . . . 159

57033052 SPINDLE SUB--- 4”BECO X 19” . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161

page ii WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Table of Contents

DERRICK/TOWER --- continued

57186504 ROD CHANGER--- 4)6.25 X30’ . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
57174138 ROD CHANGER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 165
57199093 CYLINDER, HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . . 169

57083560 PIPING, RD CHNGR/WRNCHCYL . . . . . . . . . . . . . . . . . . . . . . . . . 171

52167012 WRENCH,CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 175

57039810 KIT,SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 177

57054298 BREAKOUT--- 4.5 FLATS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 179

TABLE OF CONTENTS
57054009 CYLINDER, HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . . 181
58231119 SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 183

57121717 BREAKOUT PIPING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 185

50350586 INDEX CYL.P. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 191

57120321 BOOM, JIB--- 25’TOWER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193

52263159 HOIST, JIB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 197
50820935 MOTOR, HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . . . . . 201

57427478 ANGLE DRILL PKG --- 25’ . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 203

57018343 CYLINDER, HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . . 209

POWERPACK/ENGINE . . . . . . . . . . . . . . . . . . . . . . . . 211
57220790 ENGINE ASSY--- CAT 3412--- 575 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 213

57421190 BATTERY INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 217

57412587 EXHAUST ASSY--- CAT3412 DIT . . . . . . . . . . . . . . . . . . . . . . . . . . . 219

57228330 RADIATOR PIPING ASSY. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 223

57420747 COOLER ASSY/SPLIT--- MODINE . . . . . . . . . . . . . . . . . . . . . . . . . 225

57201741 BRACE COOLER REAR . . . . . . . . . . . . . . . . . . . . . . . . . 231
57247264 RADIATOR CORE KIT . . . . . . . . . . . . . . . . . . . . . . . . . . 233

AIR CLEANERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 235

57272916 AIR CLEANER ASSY--- CAT3412 . . . . . . . . . . . . . . . . . . . . . . . . . . . 237
50825504 AIR FILTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 239
50616028 AIR CLEANER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 241

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page iii
 Serial Number: 4133
FAMILY,DM50

Table of Contents

FUEL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243

57082901 FUEL TANK,P--- STD CUMM855 . . . . . . . . . . . . . . . . . . . . . . . . . . . 245

COMPRESSOR/AIR SYSTEM . . . . . . . . . . . . . . . . . . 247

57187817 COMPRESSOR ASSY--- 1050HR2 . . . . . . . . . . . . . . . . . . . . . . . . . . 249

57220725 PIPING, SPLIT COOLER--- COC . . . . . . . . . . . . . . . . . . . . . . . . . . . 253

57096067 COMP.CONT.P.--- UL88/HR2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 255

TABLE OF CONTENTS

57530917 REGULATOR ASSY, UL---88 . . . . . . . . . . . . . . . . . . . . . . 263

57085821 COMP.REC.P.--- HR2 AIR END . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 265

52187507 RECEIVER ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 267

57080616 PIPING, RECEIVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 269

57098907 REC--- TOWER P. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 271

52223666 VALVE, THROTTLE---INSTL . . . . . . . . . . . . . . . . . . . . . 275
52158714 VALVE, AIR---2 WAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 277

HYDRAULIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . 279

57297178 MAIN HYD DRV--- CAT3412 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 281
57367179 GEARBOX --- 4 HOLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 283
50421213 PUMP, HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 287
57058356 PUMP,DOUBLE HYDRAULIC . . . . . . . . . . . . . . . . . . . . 289
52245065 PUMP,HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 293
57480386 SERVO, PUMP---INPUT,MANUAL . . . . . . . . . . . . . . . . . 297
57123283 CAM STROKER ASSY . . . . . . . . . . . . . . . . . . . . . . . . . . . 299
57052631 SERVO OUTPUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 301

57348930 HYD TANK PIPING--- DM45/50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 303

57173957 RESERVOIR, HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . 309
57173999 PLATE,BOTTOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 311
52254885 FILTER, HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . . . . . . 313
52259363 FILTER ASSY---HYD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 315
50630656 FILTER, MAGNETIC . . . . . . . . . . . . . . . . . . . . . . . . . . . . 317
52217874 SEPARATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 319

52210259 FEED PUMP P--- HP UNITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 321

57137010 DBL.PUMP,P.--- SPLT COOLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 323

52167319 CONTROLS, SPEED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 329

page iv WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Table of Contents

HYDRAULIC SYSTEM --- continued

57160582 9 SPOOL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 331
57160053 VALVE, BARE, 9---SPOOL . . . . . . . . . . . . . . . . . . . . . . . . 335
50617091 SECTION,VALVE INLET . . . . . . . . . . . . . . . . . . . . . . . . . 337
50634336 VALVE, RELIEF . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 339
50613199 SECTION, VALVE SPOOL . . . . . . . . . . . . . . . . . . . . . . . . 341
50613207 SECTION, VALVE SPOOL . . . . . . . . . . . . . . . . . . . . . . . . 343
50613215 SECTION, VALVE SPOOL . . . . . . . . . . . . . . . . . . . . . . . . 345
50613728 HANDLE ASSY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 347

TABLE OF CONTENTS
57155384 FAN ASSEMBLY--- SUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 349

57116774 PIPING, JACKS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 353

52222171 O PRESS CONT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 355

57421307 PIPING,MAIN PROP--- 325--- F55 . . . . . . . . . . . . . . . . . . . . . . . . . . . 359

57035529 VLV.ASY.DVT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 365
57106429 VALVE, DIVERTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 367
52167756 VLV ASSY CK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 369
52226115 KIT, SPLIT FLANGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 371

ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . 373

57276800 WIRING, BASIC--- CAT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 375
57138166 JUNCTION BOX ASSY,8 X 6 . . . . . . . . . . . . . . . . . . . . . . 385

57157869 LIGHTS, NIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 387

OPTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 391
57404725 DUST COLLECTR INSTL--- 3600 . . . . . . . . . . . . . . . . . . . . . . . . . . . 393
57284309 DUST COLLECTOR---IR 3600 . . . . . . . . . . . . . . . . . . . . . 401
57003782 MOTOR,HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . . . . . . 403
52233194 CAM RING ASM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 405
52179488 PLATE,PORT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 407
52179595 SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 409

57391039 DUST CURTAIN INSTL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 411

57144099 WATER INJ 3GPM/100 GAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 415

57048977 PUMP, 3GPM WATER INJ. . . . . . . . . . . . . . . . . . . . . . . . . 419
57250250 MOTOR, HYDRAULIC . . . . . . . . . . . . . . . . . . . . . . . . . . 421

57112955 LUBRICATOR--- AIR LINE(PIG) . . . . . . . . . . . . . . . . . . . . . . . . . . . 423

52215233 NOZZLE,COMPLETE,ASM . . . . . . . . . . . . . . . . . . . . . . 425

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page v
 Serial Number: 4133
FAMILY,DM50

Table of Contents

OPTIONS --- continued

57390601 CENTRAL LUB SYSTEM--- 25 FT . . . . . . . . . . . . . . . . . . . . . . . . . . . 427
57166795 PUMP/TIMER,LINCOLNCENTRL . . . . . . . . . . . . . . . . 435

57143513 FIRE PROTECTION SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 437

57340317 DEI INSTL--- DM45 MULTIPASS . . . . . . . . . . . . . . . . . . . . . . . . . . . 443

57191082 INDICATOR, DRILLING EFF. . . . . . . . . . . . . . . . . . . . . 445

57379349 INSTL--- BATTERY EQUALIZER . . . . . . . . . . . . . . . . . . . . . . . . . . . 447

TABLE OF CONTENTS

TOOLS/ACCESSORIES . . . . . . . . . . . . . . . . . . . . . . . . 449
50814516 BASIC TOOLS--- 6.25/4.0BECO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 451
50260314 WRENCH,CHAIN---5.313---6.25 . . . . . . . . . . . . . . . . . . . . 453
50021120 TONG ASSY---W/FLAT INSERTS . . . . . . . . . . . . . . . . . . 455
50021138 CHAIN ASSY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 457

57059453 DECALS--- DM50 COMMONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 459

50623867 SEAL, ROD--- 6.25 IN ROD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 463

57328205 FILTER KIT,FIELD REPLACE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 465

57147910 DECALS, SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 467

57311151 MANUAL,SAFETY---DM45/50/L . . . . . . . . . . . . . . . . . . . 473

57243073 NAMEPLATES, COMMONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 475

page vi WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Table of Contents

TABLE OF CONTENTS

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page vii
 Serial Number: 4133
FAMILY,DM50

FRAME/CHASSIS
SECTION
FRAME/CHASSIS

page 1 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
FRAME/CHASSIS

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 2
 Serial Number: 4133
FAMILY,DM50

57402398 MAIN FRAME WELDMENT

MAIN FRAME WELDMENT

29

43

43
57402398

43

Figure 1 :MAIN FRAME WELDMENT

D57402398 REV 002
page 3 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57402398 MAIN FRAME WELDMENT

REF. PART NO. QTY. UNIT DESCRIPTION

029 58235615 1 EA SUPPORT,TWR

MAIN FRAME WELDMENT

57083974 2 EA D BLOCK, BEARING (See figure 2)
50245604 1 EA D SHAFT, TOWER SUPPORT
043 50425958 3 EA CROSSHEAD

57402398

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 4
 Serial Number: 4133
FAMILY,DM50

57083974 BLOCK, BEARING

3 3
MAIN FRAME WELDMENT

4 4
5 5
1 1

5
3
57402398

Bearing Block

Figure 2 :BLOCK, BEARING

C57083974 REV 004
page 5 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57083974 BLOCK, BEARING

REF. PART NO. QTY. UNIT DESCRIPTION

001 58235698 1 EA BLOCK, BEARING

MAIN FRAME WELDMENT

002 95002564 2 EA PIN, ROLL
003 57083966 1 EA CAP,BEARING
004 95105136 4 EA SCREW, CAP---1---8 X 4
005 57357618 2 EA SHIM, BLOCK---BEARING

57402398

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 6
 Serial Number: 4133
FAMILY,DM50

57231110 DECKING,SPLIT COOLERS

DECKING,SPLIT COOLERS

1
57231110

5 5
6 6
7 7
3

4 9
5
6
7
8

Figure 3 :DECKING,SPLIT COOLERS

E57231110 REV00
page 7 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57231110 DECKING,SPLIT COOLERS

REF. PART NO. QTY. UNIT DESCRIPTION

001 57139313 1 EA FRONT DECKING

DECKING,SPLIT COOLERS
002 56988280 1 EA DECK
003 57208969 1 EA DECKING,MIDDLE---COOLER
004 57213571 1 EA DECKING RIGHT REAR
005 95104170 64 EA SCREW, CAP---1/2---13 X 1---1/2
006 95081824 64 EA WASHER, LOCK---1/2
007 95077798 64 EA NUT, HEX---1/2---13
008 95064697 46 EA WASHER, FLAT---1/2
009 57213589 1 EA DECKING LEFT REAR

57231110

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 8
 Serial Number: 4133
FAMILY,DM50

57193781 HANDRAILS---DIV IND COLL.

HANDRAILS---DIV IND COLL.

5
7
3

4
57193781

Figure 4 :HANDRAILS--- DIV IND COLL.

E57193781 REV 01
page 9 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57193781 HANDRAILS---DIV IND COLL.

REF. PART NO. QTY. UNIT DESCRIPTION

001 57113110 1 EA HANDRAIL, REAR---CURBSIDE

HANDRAILS---DIV IND COLL.

002 56939424 1 EA HANDRAIL
003 56939416 1 EA HANDRAIL
004 57113128 1 EA HANDRAIL---REAR D.C. SIDE
005 57113144 8 EA BASEPLATE---3/8X4X4FLATBAR
006 57119018 8 EA TUBING, MTG. HANDRAILS
007 95103867 8 EA SCREW, CAP---3/8---16 X 3
008 95922894 8 EA NUT, HEX---3/8---16
009 95937413 8 EA WASHER, LOCK---3/8 PLATED

57193781

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 10
 Serial Number: 4133
FAMILY,DM50

57095978 HOSE COVER

HOSE COVER

3 2

5
8 6
9
7
9
57095978

4
1

Figure 5 :HOSE COVER

D57095978 REV 04
page 11 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57095978 HOSE COVER

REF. PART NO. QTY. UNIT DESCRIPTION

001 57095960 1 EA PANEL

HOSE COVER
57240822 1 EA D LATCH---DOOR
002 57096000 1 EA PANEL
003 57095945 1 EA COVER
004 57095952 1 EA COVER
005 95934543 8 EA SCREW, CAP---3/8---16 X 1/2
006 95937413 8 EA WASHER, LOCK---3/8 PLATED
007 57095994 1 EA GUARD,HOSE
008 57095986 1 EA GUARD,HOSE
009 56776792 1 EA SEALER

57095978

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 12
 Serial Number: 4133
FAMILY,DM50

UNDERCARRIAGE/TRACKS
SECTION
UNDERCARRIAGE/TRACKS

page 13 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
UNDERCARRIAGE/TRACKS

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 14
 Serial Number: 4133
FAMILY,DM50

57390841 TRACK ASSY---325L +2 W/L&S

8
2
7
6 5
TRACK ASSY---325L +2 W/L&S

9 6
8

7
8

7
10
9 14 15
16

1
57390841

13
15
16 11

14

12 27

Figure 6 :TRACK ASSY--- 325L +2 W/L&S

D57390841 REV 00
page 15 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57390841 TRACK ASSY---325L +2 W/L&S

REF. PART NO. QTY. UNIT DESCRIPTION

001 57388076 1.00 ST UNDERCARRIAGE,325L---L&S (See figure 7)

TRACK ASSY---325L +2 W/L&S

002 95201547 1 EA FITTING,LUBE
004 57309783 1 EA YOKE, OSCILLATION
005 57180184 1 EA BUSHING, CENTER
006 57180168 1 EA PIN, CENTER
007 95201547 6 EA FITTING,LUBE
008 56901853 6 EA BAR, FLAT
009 57188112 2 EA PIN, END YOKE
010 57309791 2 EA BUSHING, YOKE END
011 57309809 4 EA MOUNT, YOKE END
012 57315426 2 EA MOUNT, SHAFT TBG,OUTSIDE
013 57376618 2 EA TUBING, SHAFTOSCILLATION
014 52264652 2 EA RETAINER,TRACK
015 95378642 6 EA SCREW,CAP---3/4---10 X 2---1/4
016 95934691 6 EA WASHER,LOCK,HELICAL
027 57325060 2 EA MOUNT,SHAFT TBG, INSIDE

57390841

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 16
 Serial Number: 4133
FAMILY,DM50

57388076 UNDERCARRIAGE,325L---L&S
TRACK ASSY---325L +2 W/L&S

TRACK
GROUP
9 FRONT
ROLLER IDLER
TRACK
FINAL GROUP GROUP
MOTOR
DRIVE GUARD 1 8
7 GROUP
2
57390841

4
5
FRAME
ASSY
1
3 ROLLER
TRACK GROUP
GUIDE
GUARD
GROUP
6

SPROCKET
GROUP

Figure 7 :UNDERCARRIAGE,325L--- L&S

ILLUSTRATION REV 000
page 17 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57388076 UNDERCARRIAGE,325L---L&S

REF. PART NO. QTY. UNIT DESCRIPTION

001 57562977 1 EA ROLLER ARRANGEMENT (See figure 8)

TRACK ASSY---325L +2 W/L&S

002 57563124 1 EA GUARD GROUP---TCK MOT
57357097 12 EA D WASHER
57457772 12 EA D BOLT
57563132 2 EA D COVER
003 57563140 1 EA GUARD GROUP---TRK GDE (See figure 10)
004 57516601 1 EA FRAME ASSY,RH
005 57563272 1 EA FRAME ASSY---LH
006 57354946 2 EA SPROCKET GROUP
57355018 1 EA D SPROCKET, TRACK
57355026 18 EA D BOLT
007 58025800 2 EA FINAL DRIVE
58025818 1 EA D DRIVE GROUP
57415044 1 EA D MOTOR, HYD. TRACK/DR
57415929 1 EA D FINAL DRIVE GROUP---U/C(See figure 11)
57355075 40 EA D WASHER---PLATED
57356461 40 EA D BOLT
008 57354961 1 EA FRONT IDLER GROUP

57390841
57356479 4 EA D BOLT
57563348 1 EA D TRACK ADJUSTMENT GROUP(See figure 12)
57356503 2 EA D FRONT IDLER GROUP
57563397 1 EA D SPRING GROUP RECOIL(See figure 13)
57355026 4 EA D BOLT
57563413 1 EA D IDLER,FRONT (See figure 14)
009 57563470 2 EA TRACK GROUP (See figure 15)

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 18
 Serial Number: 4133
FAMILY,DM50

57562977 ROLLER ARRANGEMENT

5
1
TRACK ASSY---325L +2 W/L&S

6
57390841

2
3
4

Figure 8 :ROLLER ARRANGEMENT

C57562977 REV 000
page 19 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57562977 ROLLER ARRANGEMENT

REF. PART NO. QTY. UNIT DESCRIPTION

001 57457566 4 EA CARRIER ROLLER GROUP (See figure 9)

TRACK ASSY---325L +2 W/L&S

002 57356800 8 EA BOLT
003 57456790 72 EA BOLT
004 57355075 80 EA WASHER---PLATED
005 57356776 4 EA BOLT
006 57563041 20 EA ROLLER GROUP---SFLG

57390841

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 20
 Serial Number: 4133
FAMILY,DM50

57457566 CARRIER ROLLER GROUP

TRACK ASSY---325L +2 W/L&S

3 BEARING BEARING
4 5 6
2

COLLAR
7

SHAFT 9
57390841

Figure 9 :CARRIER ROLLER GROUP

C57457566 REV 000
page 21 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57457566 CARRIER ROLLER GROUP

REF. PART NO. QTY. UNIT DESCRIPTION

001 57457590 1 EA SHAFT ASSY

TRACK ASSY---325L +2 W/L&S

57562985 1 EA D SHAFT,TCK ROLLER
57562993 1 EA D COLLAR---RLR END
002 57563009 1 EA SEAL GROUP
003 57457608 1 EA ROLLER & BEARING ASSY
57563017 1 EA D RIM AS---CARR RLR
57563033 1 EA D BEARING---CARR RLR
57563025 1 EA D BEARING---CARR RLR
004 57356859 1 EA RETAINER
005 57356867 1 EA WASHER---THRUST
006 50727429 1 EA SEAL
007 57356875 5 EA BOLT---SOCKETHEAD
008 57356834 1 EA COVER---CARRIER ROLLER
009 57356768 1 EA PLUG---PIPE

57390841

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 22
 Serial Number: 4133
FAMILY,DM50

57563140 GUARD GROUP---TRK GDE

TRACK ASSY---325L +2 W/L&S

8 9
57390841

2 1 2
1

3 3
4 4

4 7 4 4 7 4
5 6 6 5

Figure 10 :GUARD GROUP--- TRK GDE

C57563140 REV 000
page 23 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57563140 GUARD GROUP---TRK GDE

REF. PART NO. QTY. UNIT DESCRIPTION

001 57563157 2 EA GUARD ASSY

TRACK ASSY---325L +2 W/L&S

002 57563165 2 EA GUARD ASSY
003 57357683 36 EA BOLT
004 57355075 72 EA WASHER---PLATED
005 57563173 18 EA BOLT
006 57357691 18 EA NUT
007 57563181 18 EA PIPE
008 57563199 2 EA GUARD ASSEMBLY
009 57563207 2 EA GUARD ASSEMBLY

57390841

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 24
 Serial Number: 4133
FAMILY,DM50

57415929 FINAL DRIVE GROUP---U/C

TRACK ASSY---325L +2 W/L&S

20 19 4 11 12 16 17 53 55 54 67 58
21 42 8 42
51
1
106
112 18

39 89

92
111
91
22
90
29 59
109
103

108
101
57390841

104
109
110
25 107
105
23
88

100
52 69 70

35 49 24 5 6 3 102 66
28
26

113 ---RING,SEAL
114 ---ADAPTER

Figure 11 :FINAL DRIVE GROUP--- U/C

C58025818 REV 00
page 25 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57415929 FINAL DRIVE GROUP---U/C

REF. PART NO. QTY. UNIT DESCRIPTION

001 57552408 1 EA SPINDLE

TRACK ASSY---325L +2 W/L&S

003 57552416 1 EA COUPLER
004 57552424 1 EA CARRIER, PLANET
005 57552432 1 EA PLATE, BACK---UP
006 57552440 1 EA RING, SNAP
008 57552457 1 EA RING, LOCATING
011 57552465 5 EA PLANET GEAR
012 57552473 5 EA PLANET BEARING
016 57552481 5 EA RING, SNAP
017 57552499 1 EA SHAFT, SUN GEAR
018 57552507 1 EA RING, SNAP
019 57552515 1 EA NUT, SHAFT
020 57552523 2 EA BEARING, TAP ROLLER
021 57552531 1 EA SEAL, FACE
022 57552549 1 EA RING, O
023 57552556 2 EA BOLT, HEX HEAD
024 57552564 5 EA BOLT, SOCKET HEAD
025 57552572 1 EA PISTON

57390841
026 57552580 1 EA PLATE, BACK UP
028 57552598 1 EA RING, SNAP
029 57457293 1 EA KIT---DISC(BRAKE)
035 57457301 5 EA KIT---SEAL(BRAKE)
039 57552622 1 EA PLUG, CAP
042 57552630 2 EA PLUG, EXPANDING
049 57552648 1 EA GEAR, RING
051 57552655 1 EA COVER, RING GEAR
052 57552663 1 EA SHAFT, SUN GEAR
053 57552671 1 EA CARRIER, PLANET
054 57552689 3 EA PLANET GEAR
055 57552697 3 EA PLANET BEARING
058 57552705 3 EA RING, SNAP
059 57552713 1 EA RING, SNAP
066 57552721 1 EA O---RING
067 57552739 12 EA BOLT, HEX HEAD
069 57552747 2 EA PLUG, SCREW
070 57552754 2 EA RING, SEAL
088 57552762 1 EA GEAR, SUN
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 26
 Serial Number: 4133
FAMILY,DM50

57415929 FINAL DRIVE GROUP---U/C

REF. PART NO. QTY. UNIT DESCRIPTION

089 57552770 1 EA CARRIER, PLANET

TRACK ASSY---325L +2 W/L&S

090 57552788 3 EA PLANET GEAR

091 57552796 3 EA PLANET BEARING
092 57552804 3 EA RING, SNAP
100 57552812 1 EA COVER
101 57552820 1 EA SLEEVE, LOCATING
102 57552838 1 EA SHAFT, INPUT
103 57552846 1 EA SLEEVE, SHIFT
104 57552853 1 EA BOLT, SOCKET HEAD
105 57552861 1 EA WASHER, THRUST
106 57552879 12 EA BOLT, HEX HEAD
107 57552887 1 EA O---RING
108 57552895 1 EA PLUG, SCREW
109 57552903 2 EA BOLT, HEX HEAD
110 57552911 2 EA BOLT, HEX HEAD
111 57552929 1 EA ADAPTER
112 57552937 1 EA RING, SEAL
113 57552754 1 EA RING, SEAL
114 57552952 1 EA ADAPTER
57390841

page 27 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57415929 FINAL DRIVE GROUP---U/C

TRACK ASSY---325L +2 W/L&S

57390841

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 28
 Serial Number: 4133
FAMILY,DM50

57563348 TRACK ADJUSTMENT GROUP

TRACK ASSY---325L +2 W/L&S

2
1 3 5

8
57390841

10 9

12 11

Figure 12 :TRACK ADJUSTMENT GROUP

C57563348 REV 000
page 29 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57563348 TRACK ADJUSTMENT GROUP

REF. PART NO. QTY. UNIT DESCRIPTION

001 57356511 2 EA BOLT

TRACK ASSY---325L +2 W/L&S

002 57563355 1 EA PLATE ASSY,RH,WARNING
003 57563363 1 EA PLATE ASSY,LH,WARNING
005 57563371 1 EA CYLINDER
006 57356552 1 EA SEAL---LIP TYPE
007 57356560 1 EA PISTON
008 57356578 2 EA RING
009 57356586 2 EA RING
010 57356594 2 EA O RING---SEAL
011 57563389 1 EA VALVE,FILL
012 50416551 1 EA VALVE

57390841

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 30
 Serial Number: 4133
FAMILY,DM50

57563397 SPRING GROUP RECOIL

TRACK ASSY---325L +2 W/L&S

6
1 2 3 4 5

8
57390841

Figure 13 :SPRING GROUP RECOIL

C57563397 REV 000
page 31 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57563397 SPRING GROUP RECOIL

REF. PART NO. QTY. UNIT DESCRIPTION

001 57356636 1 EA SUPPORT ASSY

TRACK ASSY---325L +2 W/L&S

002 57356644 1 EA SPRING
003 57563405 1 EA ROD
004 57356669 1 EA WASHER---HARD
005 57356677 1 EA NUT
006 57356685 1 EA SUPPORT
007 57356693 1 EA STRIP
008 57356701 2 EA BOLT---SOCKETHEAD

57390841

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 32
 Serial Number: 4133
FAMILY,DM50

57563413 IDLER,FRONT
TRACK ASSY---325L +2 W/L&S

8
4 5

6
57390841

Figure 14 :IDLER,FRONT
C57563413 REV 000
page 33 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57563413 IDLER,FRONT

REF. PART NO. QTY. UNIT DESCRIPTION

001 57563421 1 EA IDLER & BEARING ASSY

TRACK ASSY---325L +2 W/L&S

57563439 1 EA D IDLER ASSEMBLY
57563447 2 EA D BEARING---IDLER
003 57563454 2 EA SEAL GROUP---METAL FACE
004 57027310 2 EA SEAL
005 57356735 2 EA PIN
006 57563462 1 EA SHAFT---IDLER
007 57356750 2 EA BEARING---FRAME IDLER
008 57356768 1 EA PLUG---PIPE

57390841

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 34
 Serial Number: 4133
FAMILY,DM50

57563470 TRACK GROUP

TRACK ASSY---325L +2 W/L&S

3
57390841

Figure 15 :TRACK GROUP

C57563470 REV 000
page 35 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57563470 TRACK GROUP

REF. PART NO. QTY. UNIT DESCRIPTION

001 57563488 1 EA TRACK LINK ASSY (See figure 16)

TRACK ASSY---325L +2 W/L&S

002 57356974 180 EA BOLT---TRACK
003 57563496 45 EA SHOE,TRACK
004 57356990 180 EA NUT---TRACK

57390841

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 36
 Serial Number: 4133
FAMILY,DM50

57563488 TRACK LINK ASSY

TRACK ASSY---325L +2 W/L&S

1
2
8

7
57390841

Figure 16 :TRACK LINK ASSY

C57563488 REV 000
page 37 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57563488 TRACK LINK ASSY

REF. PART NO. QTY. UNIT DESCRIPTION

001 57357006 192 EA WASHER

TRACK ASSY---325L +2 W/L&S

002 57357014 47 EA BUSHING---TRACK
003 57357022 47 EA PIN---TRACK
004 57357030 48 EA LINK---LH TRACK
005 57357048 1 EA PIN---TRACK
006 57357055 1 EA BUSHING---MASTER
007 57357063 2 EA SPACER
008 57357071 48 EA LINK---RH TRACK

57390841

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 38
 Serial Number: 4133
FAMILY,DM50

JACKS
SECTION
JACKS

page 39 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
JACKS

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 40
 Serial Number: 4133
FAMILY,DM50

57134991 JACK ASSY, FRONT

JACK ASSY, FRONT

12
13 4
14

10

16

15

11 3
57134991

17

5 7

Figure 17 :JACK ASSY, FRONT

E57134991 REV 03
page 41 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57134991 JACK ASSY, FRONT

REF. PART NO. QTY. UNIT DESCRIPTION

002 57488868 2 EA CYLINDER HYDRAULIC (See figure 18)

JACK ASSY, FRONT

003 50072347 2 EA SLIDE
50105832 1 EA D ANCHOR D
95101457 2 EA D PLUG PIPE
004 50173467 2 EA CAP
005 50346436 2 EA FOOT,JACK
006 95403036 2 EA SCREW, CAP---1---8 X 8
007 95077244 2 EA NUT,HEX STOP---1 ---8
008 50067834 2 EA PIN
010 50171941 2 EA PIN, ANCHOR
011 95201547 4 EA FITTING,LUBE
012 95395489 8 EA SCREW, CAP---1---8 X 3---1/2
013 95228169 8 EA WASHER, LOCK---1
014 95077749 8 EA NUT, HEX---1 ---8
015 95341798 2 EA PIPE
016 57090953 2 EA BAR,SLIDING
017 50462332 2 EA PLATE

57134991

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 42
 Serial Number: 4133
FAMILY,DM50

57488868 CYLINDER HYDRAULIC

21 PLUG
24 PLUG
JACK ASSY, FRONT

23

20
000
000

22
000
000
000
19

26
000
000
000
000
000
57134991

30
29
28

25
27 000

000

000

18

Torque to1300--- 1400 ft/lb.

Figure 18 :CYLINDER HYDRAULIC

C57488868 REV01
page 43 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57488868 CYLINDER HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

000 57510927 1 EA SEAL KIT---CYLINDER

JACK ASSY, FRONT

57520850 1 EA D BACK---UP
57520868 1 EA D O---RING
57520876 2 EA D BACK---UP
57244832 1 EA D O---RING
57520884 1 EA D O---RING
57520892 2 EA D RING, INGRESSION
57245177 1 EA D SEAL ASSY
57245185 2 EA D SLYDRING
57520900 1 EA D O---RING
57520918 1 EA D BACK---UP
57245532 1 EA D STEPSEAL
57245540 1 EA D SLYDRING
57520926 1 EA D SEAL, ROD
57520934 1 EA D BACK---UP
57520942 1 EA D RING, CONTAMINATION
57520959 1 EA D WIPER
018 57181240 1 EA LOCKNUT
019 57060352 2 EA SCREW, SET---CLEVIS

57134991
020 57244915 6 EA PLUG, PORT
021 57224156 2 EA PLUG, PORT
022 57520967 1 EA BLOCK, VALVE
023 57205007 2 EA VALVE, COUNTERBALANCE
57240814 1 EA D SEAL KIT, VALVE
024 57244972 2 EA DRILL PLUG
025 57183618 1 EA SPACER, PISTON
026 57520975 1 EA HEAD
027 57520983 1 EA PISTON
028 57181232 1 EA ROD TUBE
029 57181059 1 EA ROD---TUBE
030 57245573 1 EA TUBE ASSY

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 44
 Serial Number: 4133
FAMILY,DM50

57134975 JACK ASSY, REAR

JACK ASSY, REAR

14

10

12
13

3
57134975

11

5 7
6

Figure 19 :JACK ASSY, REAR

E57134975 REV 02
page 45 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57134975 JACK ASSY, REAR

REF. PART NO. QTY. UNIT DESCRIPTION

002 57224669 1 EA CYLINDER, HYDRAULIC (See figure 20)

JACK ASSY, REAR

003 50072347 1 EA SLIDE
004 50427863 1 EA CAP, CROSSHE
005 50346436 1 EA FOOT,JACK
006 95280277 1 EA PIN,HINGE---1 X 6---3/4
007 95093381 2 EA PIN,COTTER---3/16 X 1---3/4
008 50067834 1 EA PIN
010 50171941 1 EA PIN,ANCHOR
011 95201281 2 EA FITTING,LUBE
012 95335352 4 EA SCREW,CAP---HEX,1---8 X 2---1/2
013 95228169 4 EA WASHER,LOCK---1”
014 57208746 1 EA SPACER

57134975

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 46
 Serial Number: 4133
FAMILY,DM50

57224669 CYLINDER, HYDRAULIC

1 --- SEAL KIT (NOT SHOWN)

2 --- SEAL KIT,FIELD SERVICE (NOT SHOWN)
3 --- INSTL INSTR---SEA (NOT SHOWN) 20
JACK ASSY, REAR

19 22
--- PLUG, PORT (NOT SHOWN)
23 --- DRILL PLUG (NOT SHOWN)
30 --- ASSY TOOL & INSTRUCT KIT (NOT SHOWN)

6
8
21
4

5
16
18

25
15
12
14
11
13
57134975

29
28
27

24
26 7

10

17

Torque to1300--- 1400 ft/lb.

Figure 20 :CYLINDER, HYDRAULIC

E57224669 REV001
page 47 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57224669 CYLINDER, HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

001 57248171 0 EA SEAL KIT

JACK ASSY, REAR

57239444 1 EA D INSTL INSTR---SEAL
57245516 1 EA D BACK---UP
57207078 1 EA D O---RING
57183600 2 EA D BACK---UP RING
95412870 1 EA D O RING
95868030 1 EA D O RING
57245177 1 EA D AQ SEAL ASSY
57245185 2 EA D SLYDRING
95868014 1 EA D O RING
57115727 1 EA D BACK UP RING
57245532 1 EA D STEPSEAL
57245540 1 EA D SLYDRING
57245557 1 EA D STEPSEAL
57245565 1 EA D EXCLUDER
002 57248189 0 EA SEAL KIT,FIELD SERVICE
57239444 1 EA D INSTL INSTR---SEAL
57245516 1 EA D BACK---UP

57134975
57207078 1 EA D O---RING
57183600 2 EA D BACK---UP RING
95412870 1 EA D O RING
95868030 1 EA D O RING
57245177 1 EA D AQ SEAL ASSY
57245185 2 EA D SLYDRING
95868014 1 EA D O RING
57115727 1 EA D BACK UP RING
57245532 1 EA D STEPSEAL
57245540 1 EA D SLYDRING
57245557 1 EA D STEPSEAL
57245565 1 EA D EXCLUDER
57115750 1 EA D ROD PACKING
57115768 1 EA D ROD WIPER
57157653 2.00 ST D RING, WEAR
57183592 2 EA D BACK---UP RING
57245110 1 EA D INSTRUCTIONS, KIT
003 57239444 0 EA INSTL INSTR---SEAL
004 57245516 1 EA BACK---UP
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 48
 Serial Number: 4133
FAMILY,DM50

57224669 CYLINDER, HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

005 57207078 1 EA O---RING

JACK ASSY, REAR

006 57183600 2 EA BACK---UP RING

007 57244832 1 EA O---RING
008 95868030 1 EA O RING
009 57245177 1 EA AQ SEAL ASSY
010 57245185 2 EA SLYDRING
011 95868014 1 EA O RING
012 57115727 1 EA BACK UP RING
013 57245532 1 EA STEPSEAL
014 57245540 1 EA SLYDRING
015 57245557 1 EA STEPSEAL
016 57245565 1 EA EXCLUDER
017 57181240 1 EA LOCKNUT
018 57244907 1 EA SET SCREW,1/4---28UNF---2
019 57244915 6 EA PORT PLUG
020 57224156 2 EA PLUG, PORT
021 57182883 1 EA VALVE BLOCK
022 57205007 2 EA VALVE, COUNTERBALANCE
57134975

57240814 1 EA D SEAL KIT---VALVE

023 57244972 0 EA DRILL PLUG
024 57183618 1 EA PISTON SPACER
025 57245318 1 EA HEAD, 5 X 4
026 57245201 1 EA PISTON, CYLINDER
027 57181232 1 EA ROD TUBE
028 57181059 1 EA ROD---TUBE
029 57245573 1 EA TUBE ASSY
030 57239436 1 EA ASSY TOOL & INSTRUCT KIT
57239469 1 EA D TOOL, 5” BORE SIZING
57239444 1 EA D INSTL INSTR---SEAL

page 49 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57224669 CYLINDER, HYDRAULIC

JACK ASSY, REAR

57134975

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 50
 Serial Number: 4133
FAMILY,DM50

CAB/CONSOLE
SECTION
CAB/CONSOLE

page 51 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
CAB/CONSOLE

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 52
 Serial Number: 4133
FAMILY,DM50

57411639 CAB INSTL,SWINGDR,DM45HP

24 ---FITTING, HYD (NOT SHOWN)

CAB INSTL,SWINGDR,DM45HP

1
57411639

SEE VIEW A & D

Figure 21 :CAB INSTL,SWINGDR,DM45HP

D57411639 REV 02
page 53 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57411639 CAB INSTL,SWINGDR,DM45HP

5
3
4

CAB INSTL,SWINGDR,DM45HP
7
6

1
11

57411639
6
7

Figure 22 :CAB INSTL,SWINGDR,DM45HP

D57411639 REV 02
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 54
 Serial Number: 4133
FAMILY,DM50

57411639 CAB INSTL,SWINGDR,DM45HP

10
CAB INSTL,SWINGDR,DM45HP

19

20

22

18

23
10
57411639

9
9

VIEW A

Figure 23 :CAB INSTL,SWINGDR,DM45HP

D57411639 REV 02
page 55 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57411639 CAB INSTL,SWINGDR,DM45HP

12
13
14
15

CAB INSTL,SWINGDR,DM45HP
53

54
41 55
42 31
43
32
51 44 21
45 33
34 22
46 23 11
35 12
47 36 24
48 25 13 1
37 2
49 26 14
38 3
50 27 15
39 16 4
28
40 17 5
29 6
30 18
19 7 1
20 8
9
10
52

57411639

BULKHEAD ASSEMBLY
SEE PAGE 5
FOR ITEM NO OF FITTING USED

Figure 24 :CAB INSTL,SWINGDR,DM45HP

D57411639 REV 02
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 56
 Serial Number: 4133
FAMILY,DM50

57411639 CAB INSTL,SWINGDR,DM45HP

Hole No. Item No. Of Fitting Used Description

1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Bit Air Pressure Gauge
2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Main Pump Pressure Gauge
3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Supercharge Pressure Gauge
CAB INSTL,SWINGDR,DM45HP

4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 . . . . . . . . . . . . . . Pressure Line 3 Spool Valve

5 .................................................. Torque Control (Option)
6 .................................................. Conduit (Basic Wiring)
7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Engine Oil Pressure Gauge
8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 . . . . . . . . . . . . . . Diverter Valve Remote Control
9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 . . . . . . . . . . . . . . Feed Cylinder Return
10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 . . . . . . . . . . . . . . Manifold Remote Control
11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Rod Changer Cylinder
12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Dust Curtain Cylinder
13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Rod Wrench Cylinder
14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Tower Raising & Lowering Cylinder
15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Front Jack Cylinder (Rod Changer Side)
16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Tower Pinning
17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Rear Jack Cylinder
18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 . . . . . . . . . . . . . . Hoist Motor
19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Front Jack Cylinder (Cab Side)
20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Feed Pressure Control Valve Return Line
21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Rod Changer Cylinder
22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Dust Curtain Cylinder
23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Rod Wrench Cylinder
24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Tower Raising & Lowering Cylinder
25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Front Jack Cylinder (Rod Changer Side)
26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Tower Pinning
27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Rear Jack Cylinder
28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 . . . . . . . . . . . . . . Hoist Motor
29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Front Jack Cylinder (Cab Side)
30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Feed Pressure Control Valve Pressure Line
31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 . . . . . . . . . . . . . . Index Motor
32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Breakout Cylinder
57411639

33
34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 . . . . . . . . . . . . . . Feed Pressure Gauge
35 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Propel Valve Pressure From Fan Pump
36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Propel Valve Pressure To Supply Manifold
37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Propel Valve Drain
38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Water Injection Metering Line (Option)
39 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Feed Control Remote Valve
40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 . . . . . . . . . . . . . . 9 --- Spool Valve Return Line
41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 . . . . . . . . . . . . . . Index Motor
42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Breakout Cylinder
43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 . . . . . . . . . . . . . . 9 --- Spool Valve Pressure
44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Feed Valve Drain
45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 . . . . . . . . . . . . . . Dust Collector Line
46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Over --- Pressure Control (XL 750)
47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Over --- Pressure Control (XL 750)
48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Water Injection Metering Line (Option)
49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 . . . . . . . . . . . . . . Feed Control Remote valve
50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 . . . . . . . . . . . . . . Dust Collector Control Valve Drain
51 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Wire Harness Entrance For B. O. Sol. & Options
52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Engine Water Temp. & Comp. Discharge Temp. Capillary Tubes
53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Drain A/C
54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Dryer/Evaporator
55 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Evaporator --- Compressor

Figure 25 :CAB INSTL,SWINGDR,DM45HP

D57411639 REV 02
page 57 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57411639 CAB INSTL,SWINGDR,DM45HP

CAB INSTL,SWINGDR,DM45HP
21

57411639

Figure 26 :CAB INSTL,SWINGDR,DM45HP

D57411639 REV 02
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 58
 Serial Number: 4133
FAMILY,DM50

57411639 CAB INSTL,SWINGDR,DM45HP

REF. PART NO. QTY. UNIT DESCRIPTION

001 57411621 1 EA CAB,SWG’DR,DM45HPCONSOLE

CAB INSTL,SWINGDR,DM45HP

002 57082786 1 EA PLATFORM,CAB

003 50693308 4 EA SPACER, CAB
004 50693290 8 EA SUPPORT, CAB
005 95104659 8 EA SCREW, CAP---3/4---10 X2---3/4
006 95077822 8 EA NUT, HEX---3/4---10
007 95081808 8 EA WASHER, LOCK---3/4
008 95937413 6 EA WASHER, LOCK---3/8 PLATED
009 95934592 6 EA SCREW, CAP---3/8---16 X2---1/4
010 95922894 6 EA NUT, HEX---3/8---16
011 57096794 1 EA STEP,CAB
012 95282422 13 EA ADAPTER
013 95364972 12 EA FITTING, HYD
014 95364964 5 EA ADAPTER
015 95332599 4 EA ADAPTER
018 95104212 2 EA SCREW, CAP---1/2---13 X2---3/4
019 95077798 2 EA NUT, HEX---1/2---13
020 95081824 2 EA WASHER, LOCK---1/2
57411639

021 57290041 1 EA DECAL, A/C HEATER FILTER

022 57053183 2.00 IN HOSE,HYD---A06 BULK
023 57082497 1 EA BAR,ROUND
024 56956220 1 EA FITTING, HYD

page 59 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57411639 CAB INSTL,SWINGDR,DM45HP

CAB INSTL,SWINGDR,DM45HP
57411639

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 60
 Serial Number: 4133
FAMILY,DM50

57411621 CAB,SWG’DR,DM45HPCONSOLE

13 ---WINDOW (NOT SHOWN)

27 ---CHANNEL---48 LG. (NOT SHOWN)
26 OPT.
CAB INSTL,SWINGDR,DM45HP

999

12
30

14
30

16
30
57411639

15
30

2
31

Figure 27 :CAB,SWG’DR,DM45HPCONSOLE
E57411621 REV 03
page 61 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
22
 Serial Number: 4133
FAMILY,DM50

57411621 CAB,SWG’DR,DM45HPCONSOLE

21

24

CAB INSTL,SWINGDR,DM45HP
999

21
24

22
21

21 17
30
22

24
19
30

57411639
17 19
30
23 22
21
17 24
30
18
23
3
31 22

18
30

Figure 28 :CAB,SWG’DR,DM45HPCONSOLE
E57411621 REV 03
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 62
 Serial Number: 4133
FAMILY,DM50

57411621 CAB,SWG’DR,DM45HPCONSOLE
CAB INSTL,SWINGDR,DM45HP

6 5

4
57411639

20

Figure 29 :CAB,SWG’DR,DM45HPCONSOLE
E57411621 REV 03
page 63 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57411621 CAB,SWG’DR,DM45HPCONSOLE

26
999

CAB INSTL,SWINGDR,DM45HP
HEATER WIRE

10
11

8
9

57411639
1

10

10

22

Figure 30 :CAB,SWG’DR,DM45HPCONSOLE
E57411621 REV 03
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 64
 Serial Number: 4133
FAMILY,DM50

57411621 CAB,SWG’DR,DM45HPCONSOLE

REF. PART NO. QTY. UNIT DESCRIPTION

001 57276909 1 EA HEATER, ASSY---LESS CABLE (See figure 31)

CAB INSTL,SWINGDR,DM45HP

002 57425704 1 EA SWING DOOR

57486987 1 EA D HANDLE,RECESSED,OUTSIDE
003 57096893 1 EA DOOR,FRONT
004 57096950 1 EA MOUNT,SEAT
005 57096968 1.00 ST ARM ASSY, SEAT
006 51218287 1 EA SEAT
57301822 1 EA D CUSHION, SEAT BACK
57301814 1 EA D CUSHION, BOTTOM
008 57097479 1 EA DOOR,A/C FLT
009 57097461 1 EA BARRIER
010 58235250 1 EA LIGHT,DOME
011 52218161 1 EA SWITCH
012 57425480 1 EA WINDOW
013 57119604 1 EA WINDOW---DM45/50
014 57425498 1 EA WINDOW
015 57119620 1 EA WINDOW---DM45/50
016 57119638 1 EA WINDOW---DM45/50
57411639

017 57119646 3 EA WINDOW---DM45/50

018 57119653 1 EA WINDOW---DM45/50
019 57119661 1 EA WINDOW---DM45/50
020 57243768 1 EA PANEL CONTROL (See figure 32)
021 56762206 4 EA CONNECTOR
022 56921406 3 EA TERMINAL
023 95329249 2 EA TERMINAL
024 57358830 305.00 IN CONDUIT, 3/8 NYLON
026 57312001 0 EA PRE---CLEANER/FILTER KIT (See figure 33)
027 57305500 1 EA CHANNEL---48 LG.
030 57240921 1 EA STRIKER, DOOR LATCH
031 57425522 1 EA RELEASE,INSIDE---SWINGDOOR
999 57283236 1 EA CAB HALF --- DM45/50

page 65 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57411621 CAB,SWG’DR,DM45HPCONSOLE

CAB INSTL,SWINGDR,DM45HP
57411639

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 66
 Serial Number: 4133
FAMILY,DM50

57276909 HEATER, ASSY---LESS CABLE

CAB INSTL,SWINGDR,DM45HP

10 12

20
19

21 18

14ga. RED POWER WIRE LENGTH

FROM OUTSIDE UNIT = 8”
57411639

13

JUMPER, SO HEATER MOTOR WILL

RUN WHEN KEY SWITCH IS OFF

7 ---KIT,CAB HEATER, RETROFIT

Figure 31 :HEATER, ASSY--- LESS CABLE

E57276909 REV 01
page 67 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57276909 HEATER, ASSY---LESS CABLE

REF. PART NO. QTY. UNIT DESCRIPTION

007 57245631 1 EA KIT,CAB HEATER, RETROFIT

CAB INSTL,SWINGDR,DM45HP
57417156 1 EA D VALVE, BALL
008 52218054 1 EA CORE
010 58235268 1 EA KNOB,CONTROL
012 52218146 1 EA SWITCH
013 57096836 1 EA BLOWER ASSY.
018 58234501 1 EA MOTOR, 24V
019 57096844 1 EA WHEEL,C.W.
020 57096844 1 EA WHEEL,C.W.
021 58234519 1 EA RESISTOR,24V

57411639

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 68
 Serial Number: 4133
FAMILY,DM50

57243768 PANEL CONTROL

CAB INSTL,SWINGDR,DM45HP

7
6

5
57411639

Figure 32 :PANEL CONTROL

E57243768 REV 02
page 69 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57243768 PANEL CONTROL

REF. PART NO. QTY. UNIT DESCRIPTION

001 57243750 1 EA PLATE TOP

CAB INSTL,SWINGDR,DM45HP
002 57082042 1 EA PLATE,FRONT
005 57192619 1 EA PLATE VAL. MOUNT
006 57078008 1 EA PANEL
007 57078032 1 EA PANEL, MOUNTING

57411639

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 70
 Serial Number: 4133
FAMILY,DM50

57312001 PRE ---CLEANER/FILTER KIT

26

24
CAB INSTL,SWINGDR,DM45HP

26

10 24

22
57411639

23

25
1
27

27

Figure 33 :PRE--- CLEANER/FILTER KIT

C57312001 REV00
page 71 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57312001 PRE ---CLEANER/FILTER KIT

REF. PART NO. QTY. UNIT DESCRIPTION

001 57371775 1 EA DUCT ASSY

CAB INSTL,SWINGDR,DM45HP
010 57371817 2 EA STRAPS --- MTG
022 57371791 1 EA REDUCER
023 57371809 1 EA CLAMP, HOSE
024 59302752 1 EA AIR CLEANER
025 57301780 1 EA ELEMENT, FILTER
026 57371759 1 EA PRE---CLEANER
57371833 1 EA D COVER, PRE---CLEANER
57371841 1 EA D BOWL
57371858 1 EA D SLEEVE, PRE---CLEANER
027 57371825 1 EA GASKET --- MATERIAL

57411639

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 72
 Serial Number: 4133
FAMILY,DM50

57276792 GAGES/CONTROLS---ETR CAT

GAGES/CONTROLS

4 3 2 1

5
57276792

6 9
7 10
8

Figure 34 :GAGES/CONTROLS--- ETR CAT

D57078255 REV05
page 73 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57276792 GAGES/CONTROLS---ETR CAT

REF. PART NO. QTY. UNIT DESCRIPTION

001 57276784 1 AS PANEL ASSY,ETR---CAT (See figure 35)

GAGES/CONTROLS
002 57316184 1 AS CONTROL, ENG, ETR, CAT (See figure 37)
003 57092686 1 AS GAUGE ASSY (See figure 38)
004 57092694 1 AS GAUGE ASSY (See figure 39)
005 57429920 1 AS GAUGE ASSY,400 PSI AIR (See figure 40)
006 95410627 12 EA SCREW,MACHINE---6---32 X 3/4
007 95037149 12 EA WASHER,LOCK---NO. 6
008 95076717 12 EA NUT,HEX MACHINE---NO.6---32
009 57092702 1 AS GAUGE ASSY (See figure 41)
010 57100075 1 EA LEVEL (See figure 42)

57276792

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 74
 Serial Number: 4133
FAMILY,DM50

57276784 PANEL ASSY,ETR ---CAT

GAGES/CONTROLS

13 12 11 9

14

15
4
57276792

3 5 3 7 8

Figure 35 :PANEL ASSY,ETR--- CAT

D57078271 REV04
page 75 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57276784 PANEL ASSY,ETR ---CAT

REF. PART NO. QTY. UNIT DESCRIPTION

003 52185832 3 EA SWITCH, PUSH BUTTON

GAGES/CONTROLS
004 56762198 2 EA SWITCH, SPST TOGGLE
005 56993678 1 EA SWITCH,KEY
007 57084055 4 EA BREAKER,15---AMP CIRCUIT
008 58206046 1 EA PLUG,HOLE
009 57093155 1 EA GAUGE,TEMP
011 57018533 1 EA SWITCHGAGE
012 57078263 1 AS GAGE ASSY (See figure 36)
013 57276776 1 EA TACHOMETER, CAT
014 57358855 1 EA PUSHBUTTON, 2---POSITION
57364010 1 EA D LED,LIGHT EMMITTING DIODE
015 57515314 1 EA GAUGE, AMMETER

57276792

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 76
 Serial Number: 4133
FAMILY,DM50

57078263 GAGE ASSY

GAGES/CONTROLS

2
1

3
57276792

#7 Bulkhead Fitting

Figure 36 :GAGE ASSY

B57078263 REV01
page 77 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57078263 GAGE ASSY

REF. PART NO. QTY. UNIT DESCRIPTION

001 56993702 1 EA SWITCHGAGE, OIL PRESSURE

GAGES/CONTROLS
002 52247681 1 EA FITTING 45DG
003 58146622 1 EA HOSE ASSY
004 56964349 1 EA HOSE ASSY

57276792

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 78
 Serial Number: 4133
FAMILY,DM50

57316184 CONTROL, ENG, ETR, CAT

GAGES/CONTROLS

5
3

4
DRIVESHAFT 16 6 7
14
GUARD 17 10 8
18 11 9
19

ENGINE
2
1
57276792

15
LEVER

DRIVESHAFT
GUARD 14

CONTROL 2
PANEL

EXHAUST SUPPORT

ENGINE THROTTLE

Figure 37 :CONTROL, ENG, ETR, CAT

C57093072 REV03
page 79 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57316184 CONTROL, ENG, ETR, CAT

REF. PART NO. QTY. UNIT DESCRIPTION

001 50248848 1 EA CLEVIS

GAGES/CONTROLS
002 50612530 1 EA CABLE---PUSH/PULL
003 50248863 1 EA CLAMP,CABLE
004 50248871 1 EA BRACKET
005 50248889 1 EA SHIM
006 95317673 2 EA WASHER,LOCK---NO. 8
007 95080321 2 EA WASHER,LOCK---NO. 12
008 95086005 2 EA NUT,HEX MACHINE---NO.12---24
009 95050993 2 EA SCREW,MACH
010 95073961 2 EA SCREW MACH
011 95076725 2 EA NUT,HEX MACHINE---NO.8---32
014 57119810 1 EA BAR,ROUND
015 95301842 1 EA CLAMP,HOSE
016 95920674 1 EA SCREW, CAP 3/8---16X1
017 95922233 1 EA WASHER, FLAT 3/8

57276792
018 95937413 1 EA LOCKWASHER---3/8 PLATED
019 95922894 1 EA NUT, HEX---3/8---16

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 80
 Serial Number: 4133
FAMILY,DM50

57092686 GAUGE ASSY

GAGES/CONTROLS

3
57276792

FOUR WAY
FEED VALVE

Figure 38 :GAUGE ASSY

B57092686 REV01
page 81 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57092686 GAUGE ASSY

REF. PART NO. QTY. UNIT DESCRIPTION

001 56930688 1 EA GAUGE, PRESSURE---0---5000PSI

GAGES/CONTROLS
002 95279196 1 EA FITTING,HYD
003 56954068 1 EA HOSE ASSY

57276792

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 82
 Serial Number: 4133
FAMILY,DM50

57092694 GAUGE ASSY

GAGES/CONTROLS

2
1

3
57276792

Figure 39 :GAUGE ASSY

B57092694 REV 00
page 83 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57092694 GAUGE ASSY

REF. PART NO. QTY. UNIT DESCRIPTION

001 56930688 1 EA GAUGE, PRESSURE---0---5000PSI

GAGES/CONTROLS
002 95293353 1 EA ADAPTER
003 56964216 1 EA HOSE ASSY

57276792

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 84
 Serial Number: 4133
FAMILY,DM50

57429920 GAUGE ASSY,400 PSI AIR

GAGES/CONTROLS

1 2

3
57276792

Figure 40 :GAUGE ASSY,400 PSI AIR

B57092710 REV 01
page 85 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57429920 GAUGE ASSY,400 PSI AIR

REF. PART NO. QTY. UNIT DESCRIPTION

001 56951395 1 EA GAUGE,AIR PRESS---400 PSI

GAGES/CONTROLS
002 95293353 1 EA ADAPTER
003 56965759 1 EA HOSE ASSY

57276792

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 86
 Serial Number: 4133
FAMILY,DM50

57092702 GAUGE ASSY

GAGES/CONTROLS

1
2

3
57276792

Hydraulic Tank
Supercharge Manifold

Figure 41 :GAUGE ASSY

B57092702REV00
page 87 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57092702 GAUGE ASSY

REF. PART NO. QTY. UNIT DESCRIPTION

001 56951395 1 EA GAUGE,AIR PRESS---400 PSI

GAGES/CONTROLS
002 95293353 1 EA ADAPTER
003 52226453 1 EA HOSE ASSY

57276792

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 88
 Serial Number: 4133
FAMILY,DM50

57100075 LEVEL
GAGES/CONTROLS

2
57276792

Figure 42 :LEVEL
Y50258565 REV 02
page 89 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57100075 LEVEL

REF. PART NO. QTY. UNIT DESCRIPTION

001 50046861 1 EA LEVEL

GAGES/CONTROLS
002 50046846 1 EA RING
003 50046853 1 EA RING,MTG
004 95078846 3 EA SCREW

57276792

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 90
 Serial Number: 4133
FAMILY,DM50

57093759 F/R CONT P---HP UNITS

F/R CONT P---HP UNITS

List only, no drawing required.

57093759

Figure 43 :F/R CONT P--- HP UNITS

LIST REV 00
page 91 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57093759 F/R CONT P---HP UNITS

REF. PART NO. QTY. UNIT DESCRIPTION

001 57096398 1 EA MAIN VLV ASY (See figure 44)

F/R CONT P---HP UNITS

002 52178779 1 EA VALVE, FEED (See figure 47)
003 52223765 1 EA RELIEF VLV (See figure 48)

57093759

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 92
 Serial Number: 4133
FAMILY,DM50

57096398 MAIN VLV ASY

9 7
7
F/R CONT P---HP UNITS

10

15
16
17
8
18
14

7 14
8 9

11
12

19
57093759

18

1 14

10
13

Figure 44 :MAIN VLV ASY

E57096398 REV 02
page 93 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57096398 MAIN VLV ASY

4
5 4
6 5
6

F/R CONT P---HP UNITS

34
RETURN TO TANK

30
29
FEED UP SET PORT RELIEF
PORT 29 AT 1000 PSI
A2

B2
A1

B1

PORTS ON 9---SPOOL VALVE

7

ON 9---SPOOL VALVE
8

ON 9---SPOOL VALVE
INLET PORT FROM
MAIN PUMP 39 SET MAIN PUMP RELIEF

TO SLOW ROTATION
21 AT 3000 PSI

TO PORT ”B1”

TO PORT ”A1”
INLET PORT FROM 38
MAIN PUMP
20
48
FOTWARD ROTATION PORT

38
REVERSE ROTATION PORT

57093759
40
ON 9---SPOOL VALVE

44
45 ”V” PORT46 33
32
TO PORT ”A1”

PRESSURE RELIEF 24 24
CAB FLOOR
TO PORT ”B1”
ON 9---SPOOL

VALVE PORT (HP ONLY) 25 25

26 26
27
VALVE

37 27
36 37 36
28 31 28 31
23

41
22

MAIN VALVE GAUGE PORT

1 7 10
3 2 9
4
5

Figure 45 :MAIN VLV ASY

E57096398 REV 02
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 94
 Serial Number: 4133
FAMILY,DM50

57096398 MAIN VLV ASY

REF. PART NO. QTY. UNIT DESCRIPTION

001 57096232 1 EA VALVE, MAIN

F/R CONT P---HP UNITS

50715507 4 EA D O---RING
50715499 4 EA D RING
002 52208253 1 EA BRACKET
003 95104527 1 EA SCREW,CAP---5/8---11 X 4---1/2
004 95077814 3 EA NUT, HEX 5/8---11
005 95081790 3 EA WASHER, LOCK---5/8
006 95104568 2 EA SCREW,CAP
007 52174232 4 EA YOKE END
008 35898246 20 EA WASHER
009 95208831 4 EA NUT, HEX JAM---1/2---20
010 52177706 2 EA LINK
011 95081667 2 EA WASHER, FLAT---1/2
012 52182151 1 EA ROD ARBOR
013 95002689 4 EA PIN, COTTER---1/8 X 1
014 52174240 2 EA BRACKET
015 95934816 4 EA SCREW, CAP---1/4---20 X 1
016 95931564 4 EA NUT, HEX---1/4---20
57093759

017 95922183 4 EA WASHER, FLAT---1/4

018 57093619 2 EA LEVER
019 57086381 2 EA LEVER,INPUT
020 95702015 1 EA FITTING,TUBE
021 57096521 1 EA ADAPTER
022 95209086 1 EA FITTING, HYD
023 95141511 1 EA ADAPTER
024 52171931 2 EA TUBE ASSY
025 95430534 8 EA SCREW, CAP---3/8---16 X1---1/4
026 95959151 8 EA WASHER, LOCK---3/8
027 95086518 2 EA O---RING
028 95303368 2 EA ADAPTER, STR---JIC/O---RING
029 56883572 2 EA KIT, SPLIT FLANGE
030 56783020 1 EA KIT, SPLIT FLANGE
031 57044554 2 EA HOSE ASSY
032 57053829 1 EA HOSE ASSY
033 57043341 2 EA HOSE ASSY
034 57158958 1 EA HOSE ASSY
035 50699297 2 EA CAP, PLASTIC---7/16---20THDS
page 95 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57096398 MAIN VLV ASY

REF. PART NO. QTY. UNIT DESCRIPTION

036 50696012 2 EA CAP, PLASTIC---3/4---16THDS

F/R CONT P---HP UNITS

037 50696772 2 EA CAP,PLASTIC---4---5/8---12THDS
038 50696764 2 EA CAP,PLASTIC---1---5/16---12THD
039 58235128 1 EA KIT, SPLIT FLANGE (See figure 46)
040 52221678 1 EA RELIEF VALVE
041 52177623 1 EA FITTING,HYD
044 95934550 2 EA SCREW, CAP---3/8---16 X 3/4
045 95937413 2 EA WASHER, LOCK---3/8 PLATED
046 56964133 1 EA HOSE ASSY
048 52167848 1 EA BRACKET, VALVE

57093759

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 96
 Serial Number: 4133
FAMILY,DM50

58235128 KIT, SPLIT FLANGE

F/R CONT P---HP UNITS

2
1

4
3
57093759

Figure 46 :KIT, SPLIT FLANGE

B58235128 REV002
page 97 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

58235128 KIT, SPLIT FLANGE

REF. PART NO. QTY. UNIT DESCRIPTION

001 57405185 2 EA FLANGE HALF,SIZE 20---CD62

F/R CONT P---HP UNITS

002 56940281 1 EA O---RING,SPLIT FLANGE (20)
003 95378667 4 EA SCREW, CAP
004 95081824 4 EA WASHER, LOCK---1/2

57093759

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 98
 Serial Number: 4133
FAMILY,DM50

52178779 VALVE, FEED

F/R CONT P---HP UNITS

11 5 1
14 13
5 5

5 2

7
8
7
57093759

#9 #4 #10
#8 12
TO HEAD END PORT
OF FEED CYLINDER TO FEED PUMP
TO ROD END PORT
OF FEED CTLINDER

Figure 47 :VALVE, FEED

W52178779 REV 05
page 99 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52178779 VALVE, FEED

REF. PART NO. QTY. UNIT DESCRIPTION

001 57346843 1 EA VALVE, 4---WAY SELECTOR

F/R CONT P---HP UNITS

57346850 1 EA D KIT, VALVE CONVERSION
002 95269023 4 EA SCREW CAP FH
005 95303368 3 EA ADAPTER, STR---JIC/O---RING
006 57117244 1 EA HOSE ASSY
007 56954167 2 EA HOSE ASSY
008 56954167 1 EA HOSE ASSY
011 59669713 1 EA FITTING, HYD
012 56959844 1 EA HOSE ASSY
013 95415774 1 EA FITTING,HYD
014 95364949 1 EA FITTING, HYD

57093759

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 100
 Serial Number: 4133
FAMILY,DM50

52223765 RELIEF VLV

F/R CONT P---HP UNITS

5 3

4 1
2

2
CONTROL PANEL

6
9
57093759

CAB FLOOR

10

Figure 48 :RELIEF VLV

W52223765 REV 02
page 101 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52223765 RELIEF VLV

REF. PART NO. QTY. UNIT DESCRIPTION

001 52236932 1 EA VALVE, PRESSURE---REMOTE (See figure 49)

F/R CONT P---HP UNITS

002 95341665 2 EA FITTING, HYD---90 DEG
003 95917613 4 EA SCREW,FLAT HD---1/4---20X1.5
004 95934766 4 EA WASHER, LOCK---1/4 PLATED
005 95931564 4 EA NUT, HEX---1/4---20
006 56965759 1 EA HOSE ASSY
007 56972680 1 EA HOSE ASSY
008 56965759 1 EA HOSE ASSY
009 56966211 1 EA HOSE ASSY
010 95371258 1 EA FITTING, HYD

57093759

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 102
 Serial Number: 4133
FAMILY,DM50

52236932 VALVE, PRESSURE ---REMOTE

F/R CONT P---HP UNITS

4
3
1
2

10
57093759

9
8
6
7
5

Figure 49 :VALVE, PRESSURE--- REMOTE

X357724 REV 01
page 103 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52236932 VALVE, PRESSURE ---REMOTE

REF. PART NO. QTY. UNIT DESCRIPTION

001 52155660 1 EA SPRING GUIDE,PISTON SEAL

F/R CONT P---HP UNITS

002 95017984 1 EA O---RING
003 50798925 1 EA SPRING
004 52155686 1 EA CONE
005 50798891 1 EA SEAT
006 52249604 1 EA PISTON
007 52249620 1 EA SLEEVE
008 52249638 1 EA SPRING
009 52249646 1 EA BALL
010 52249588 1 EA KNOB, CONTROL

57093759

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 104
 Serial Number: 4133
FAMILY,DM50

57364465 AIR COND.---CAT3408/3412

26
17 27
28
33
35
AIR COND.---CAT3408/3412

31

18 30
5

32

66
6
17
66 18
20 6
12
9
17 63
19
11

19

10
11
57364465

8
16
51
52 34
53
64
65
20

44
36 45
50

15
19

19
15
20 1

2 2
1

29 ---GROMMET, RUBBER (NOT SHOWN)

Figure 50 :AIR COND.--- CAT3408/3412

D57357519 REV 02
page 105 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57364465 AIR COND.---CAT3408/3412

22 32
18 23 31

AIR COND.---CAT3408/3412
26
27 24
6
28

30
20 30
66

22
23
24 9 24
25

24
25
20
12 6

57364465
17

18
1
20
26 56
27 57
28 58
34 59 19
36 60
16 62 4
19
21 41 8
55

3
20
9
54 26 61
19
11
21

10 27
17

Figure 51 :AIR COND.--- CAT3408/3412

D57357519 REV 02
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 106
 Serial Number: 4133
FAMILY,DM50

57364465 AIR COND.---CAT3408/3412

BLOWER MOTOR
A/C PACKAGE
RESISTOR
AIR COND.---CAT3408/3412

H
A/C PACKAGE L

ORANGE
M
ORANGE

YELLOW
RED
CIRCUIT BREAKER BLOWER SWITCH
NO. 4 IN CONSOLE M
L H A/C CONTROL PANEL
B C
15 AMP.
2 19
4
ON -- OFF SWITCH
A/C CONTROL PANEL
---8

CONDENSER

20
---6
57364465

HIGH PRESSURE 21 REF. A/C UNIT

SWITCH THERMOSTAT
D S OPEN AT 31 F
CLOSES AT 39 F

OUT COMPRESSOR
IN
CLUTCH

REC.
DRIER
---12

EVAPORATOR EXPANSION
VALVE
---6

FREON LIQID
FREON GAS
ELECTRIC WIRE

Figure 52 :AIR COND.--- CAT3408/3412

D57357519 REV 02
page 107 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57364465 AIR COND.---CAT3408/3412

REF. PART NO. QTY. UNIT DESCRIPTION

001 57451353 1 EA KIT,AIR COND.---SGM (See figure 53)

AIR COND.---CAT3408/3412
002 57097487 1 EA PANEL,A/C FR (See figure 56)
003 56773708 1 EA GROMMET, RUBBER
004 57098022 1 EA GROMMET, RUBBER
005 57364358 1 EA COIL, CONDENSER
006 57364366 1 EA DRIER, RECEIVER
008 57324097 1 EA V---BELT
009 57357311 1 EA BRACKET WELDMENT
010 57364341 1 EA COMPRESSOR, W/ORINGPORTS
57440653 1 EA D VALVE,SHUTOFF,SUCTIONPRT
57440661 1 EA D O---RING, SHUTOFF VALVE
57440646 1 EA D VALVE,SHUTOFF,DISCHGPORT
57440661 1 EA D O---RING, SHUTOFF VALVE
010 57364473 7.00 LB REFRIGERANT, R134A
011 52218294 1 EA SWITCH
012 57095515 1 EA CLAMP, DRIER AIR COND.
015 57059404 1 EA ELEMENT,FLTR
016 57324105 1 EA CLUTCH, A/C

57364465
017 57377947 1 EA HOSE ASSY
018 57377954 1 EA HOSE ASSY
019 57377939 1 EA HOSE ASSY
020 57413486 1 EA HOSE ASSY, 6X312 , R134A
021 56762248 3 EA CONNECTOR, SPLICE
022 95928982 26 EA SCREW, CAP---1/4---20 X 3/4
023 95931564 26 EA NUT, HEX---1/4---20
024 95934766 34 EA WASHER, LOCK---1/4 PLATED
025 95934782 8 EA SCREW, CAP---1/4---20 X1---3/4
026 95920674 14 EA SCREW, CAP---3/8---16 X 1
027 95937413 14 EA WASHER, LOCK---3/8 PLATED
028 95922894 14 EA NUT, HEX---3/8---16
029 56987456 1 EA GROMMET, RUBBER
030 57097933 2 EA ANGLE
031 57097917 4 EA ANGLE, SUPPORT,CONDENSER
032 57097925 2 EA BAR,FLAT
033 95351904 2 EA CLAMP, HOSE
034 57319154 1 EA GUARD, WELDMENT
57319162 1 EA D PLATE
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 108
 Serial Number: 4133
FAMILY,DM50

57364465 AIR COND.---CAT3408/3412

REF. PART NO. QTY. UNIT DESCRIPTION

57319170 1 EA D PLATE
AIR COND.---CAT3408/3412

035 95301859 2 EA CLAMP, HOSE

036 57290041 1 EA DECAL, A/C HEATER FILTER
041 50249671 90.00 IN WIRE, 14AWG---WHITE
044 56921398 2 EA TERMINAL
045 56921471 1 EA TERMINAL
050 57084055 1 EA BREAKER, CIRCUIT---15 AMP
051 52182763 1 EA DRIVE GROUP, AUX
052 95934550 4 EA SCREW, CAP---3/8---16 X 3/4
053 95920682 4 EA SCREW, CAP---3/8---16 X1---1/4
054 95922233 16 EA WASHER, FLAT---3/8
055 57319212 1 EA ADJUSTMENT ROD
056 57315574 1 EA BLOCK
057 95419198 1 EA SCREW,CAP---1/2---13 X 6---1/2
058 95077798 2 EA NUT, HEX---1/2---13
059 95081667 6 EA WASHER, FLAT---1/2
060 95081824 4 EA WASHER, LOCK---1/2
061 95104212 1 EA SCREW, CAP---1/2---13 X2---3/4
062 95239539 2 EA SUB 95077814 NUT
57364465

063 95104170 2 EA SCREW, CAP---1/2---13 X1---1/2

064 57319196 2 EA ANGLE
065 95958989 1 EA SCREW, CAP---3/8---16 X1---3/4
066 57097941 1 EA BRACKET

page 109 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57364465 AIR COND.---CAT3408/3412

AIR COND.---CAT3408/3412
57364465

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 110
 Serial Number: 4133
FAMILY,DM50

57451353 KIT,AIR COND.---SGM

AIR COND.---CAT3408/3412

A/C UNIT
57364465

Figure 53 :KIT,AIR COND.--- SGM

D57451353 REV 00
page 111 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57451353 KIT,AIR COND.---SGM

2 ---NOT SHOWN
10 10 3 ---NOT SHOWN
4
7 6 ---NOT SHOWN
8 ---NOT SHOWN
14 ---NOT SHOWN

AIR COND.---CAT3408/3412
100 ---NOT SHOWN
9

9
A/C UNIT
FRONT

10
7

57364465
9

15 7
10
15 9
10 5

11 9
9 12
13 1
7

9
9

Figure 54 :KIT,AIR COND.--- SGM

D57451353 REV 00
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 112
 Serial Number: 4133
FAMILY,DM50

57451353 KIT,AIR COND.---SGM

REF. PART NO. QTY. UNIT DESCRIPTION

001 57448086 1 EA EVAPORATOR W/THERMOSTAT (See figure 55)

AIR COND.---CAT3408/3412

002 57451320 1 EA INSULATION, PIPE---3/4

003 57451338 1 EA INSULATION,STRIP7.75WX40
004 57451361 4 EA ELBOW, 1/2 BARB---LASCO
005 57451379 1 EA TEE, 1/2 BARB---LASCO
006 57451387 2 EA TUBE,COPPER---1/2DIAX14 LG
007 57144156 156.00 IN HOSE---DRAIN
008 57451320 1 EA INSULATION, PIPE---3/4
009 95264776 16 EA CLAMP, HOSE
010 95351904 10 EA CLAMP, HOSE
011 95922183 2 EA WASHER, FLAT---1/4
012 95934766 2 EA WASHER, LOCK---1/4 PLATED
013 95934782 2 EA SCREW, CAP---1/4---20 X1---3/4
014 57451338 1 EA INSULATION,STRIP7.75WX40
015 56970429 2 EA SPACER
100 57451932 1 EA DRAWING,KIT AIR COND.
57364465

page 113 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57451353 KIT,AIR COND.---SGM

AIR COND.---CAT3408/3412
57364465

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 114
 Serial Number: 4133
FAMILY,DM50

57448086 EVAPORATOR W/THERMOSTAT

1 ---EVAPORATOR COIL---A/C
AIR COND.---CAT3408/3412

MEDIAM
2 LOW SPEED (RED) SPEED
HIGH SPEED (ORANGE) (YELLOW)
MOTOR LEAD
3 (ORANGE)
2 RESISTOR
SPEEDS

5
THERMSTAT
6

4
57364465

7
8

Figure 55 :EVAPORATOR W/THERMOSTAT

E57364333 REV REF
page 115 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57448086 EVAPORATOR W/THERMOSTAT

REF. PART NO. QTY. UNIT DESCRIPTION

001 57413114 1 EA EVAPORATOR COIL---A/C

AIR COND.---CAT3408/3412
002 58234501 1 EA MOTOR, 24V
003 57096844 2 EA WHEEL,C.W.
004 57413106 1 EA BLOCK EXP. VALVE---A/C
005 57276891 1 EA THERMOSTAT, EVAPORATOR
006 57413130 1 EA HOSE ASSY---A/C, LIQUID
007 57413254 1 EA HOSE ASSY, A/C---SUCTION
008 57440943 1 EA EVAPORATOR, FILTER KIT
009 57144156 156.00 IN HOSE---DRAIN

57364465

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 116
 Serial Number: 4133
FAMILY,DM50

57097487 PANEL,A/C FR
AIR COND.---CAT3408/3412

LOW MED ON
OFF HI

BLOWER OFF
57364465

7
6 1 2 6
3 4
5

Figure 56 :PANEL,A/C FR
C57097487 REV 03
page 117 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57097487 PANEL,A/C FR

REF. PART NO. QTY. UNIT DESCRIPTION

001 56762198 1 EA SWITCH, TOGGLE---SPST

AIR COND.---CAT3408/3412
002 52218146 1 EA SWITCH
003 58235268 1 EA KNOB,CONTROL
004 57147852 1 EA DECAL, A/C SWITCH
005 57147860 1 EA DECAL, BLOWER
006 57147845 1 EA LOUVER & BEZEL ASSY
007 57147878 1 EA PANEL, FRONT A/C

57364465

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 118
 Serial Number: 4133
FAMILY,DM50

57097305 PIPING, HEATER/PRESS.

WATER OUTLET 10
9
PIPING, HEATER/PRESS.

7
8 6
16 6
15 7
7 9
P. P. BASE
6
16
7
WATER INLET

10
MAIN FRAME

3 3 2
1 2
57097305

17 17

4
4 2
CONSOLE ENGINE
CAB

1
3

4
12 11
11 13
14

HOSE

HOSE

Figure 57 :PIPING, HEATER/PRESS.

D57097305 REV04
page 119 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57097305 PIPING, HEATER/PRESS.

REF. PART NO. QTY. UNIT DESCRIPTION

001 57100943 1 EA HOSE ASSY

PIPING, HEATER/PRESS.
002 57100935 1 EA HOSE ASSY
003 95279402 2 EA ELBOW, 90DEG MALE 37DGFL
004 57100232 2 EA HOSE ASSY
006 95219747 2 EA FITTING, HYD
007 50212224 2 EA VALVE, BALL---3/4
008 95030771 1 EA ELBOW
009 95264909 1 EA ELBOW, 90DEG---EXT/INT NPT
010 95365961 1 EA NIPPLE,PIPE
011 95256749 2 EA CLAMP---3/4
012 95934857 2 EA SCREW, CAP---1/4---20 X1---1/4
013 95931564 2 EA NUT, HEX---1/4---20
014 95934766 2 EA WASHER, LOCK---1/4 PLATED
015 95315222 1 EA FITTING, HYD
016 95219747 2 EA FITTING, HYD

57097305
017 95279105 2 EA FITTING, HYD

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 120
 Serial Number: 4133
FAMILY,DM50

DERRICK/TOWER
SECTION
DERRICK/TOWER

page 121 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
DERRICK/TOWER

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 122
 Serial Number: 4133
FAMILY,DM50

57428468 TOWER ASSY,25’ CABLE PD

TOWER ASSY,25’ CABLE PD

28

29

2
57428468

Figure 58 :TOWER ASSY,25’ CABLE PD

E57428468 REV 00
page 123 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57428468 TOWER ASSY,25’ CABLE PD

TOWER CHANNEL

1/32 TO 1/16

TOWER ASSY,25’ CABLE PD

CLEARANCE

16 63
62

6 60
15 54

54

10

18

17 2

57428468
9
11

9
19
11
50
19 19

7
19

Figure 59 :TOWER ASSY,25’ CABLE PD

E57428468 REV 00
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 124
 Serial Number: 4133
FAMILY,DM50

57428468 TOWER ASSY,25’ CABLE PD

13
29
TOWER ASSY,25’ CABLE PD

32

24

35 52

2
57428468

30
ADD AS REQUIRED

Figure 60 :TOWER ASSY,25’ CABLE PD

E57428468 REV 00
page 125 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57428468 TOWER ASSY,25’ CABLE PD

50

TOWER ASSY,25’ CABLE PD

8

12 11
39
10

11

12

57428468

33

Figure 61 :TOWER ASSY,25’ CABLE PD

E57428468 REV 00
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 126
 Serial Number: 4133
FAMILY,DM50

57428468 TOWER ASSY,25’ CABLE PD

ADD SHIMS TO TOP STOP

AS REQUIRED TO ASSURE THAT CENTER
LINE OF SPINDLE IS IN LINE WITH CENTER
TOWER ASSY,25’ CABLE PD

LINE OF CENTRALIZER BUSHING

20 CHAIN
21 GUARD 25
27
22 24
26
58

23

11
57428468

12

7
8

ROTARY HEAD

29

Figure 62 :TOWER ASSY,25’ CABLE PD

E57428468 REV 00
page 127 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57428468 TOWER ASSY,25’ CABLE PD

TOWER ASSY,25’ CABLE PD

8

57428468
6
5

Figure 63 :TOWER ASSY,25’ CABLE PD

E57428468 REV 00
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 128
 Serial Number: 4133
FAMILY,DM50

57428468 TOWER ASSY,25’ CABLE PD

REF. PART NO. QTY. UNIT DESCRIPTION

001 57479784 1 EA TOWER WELD,STD BOTTOM---25

TOWER ASSY,25’ CABLE PD

002 57425209 2 EA SUB 57492563 CYLINDER (See figure 64)

004 57315798 2 EA SUPPORT, FEED CYL---5 OD
006 57137382 2 EA GUIDE, SLIDING SPROCKET
007 50334242 4 EA SPROCKET
50412626 1 EA D BUSHING
008 52227337 4 EA PIN, SPROCKET
009 50338987 4 EA PIN, SPROCKET
010 50339001 4 EA PIN,CYLINDER
011 95201547 8 EA FITTING,LUBE
012 50339019 6 EA PLATE, LOCKING
013 95246062 2 EA PIN,ROLL---3/8 X 3---3/4
015 50339027 4 EA SHIM, GUIDE
016 52147543 4 EA BLOCK,GUIDE
017 95157731 20 EA CAPSCREW,HEX HEAD
018 95939948 20 EA WASHER,LOCK,HELICAL SPRG
019 50334457 8 EA WASHER, THRU
020 95104394 2 EA SCREW,CAP,HEX
57428468

021 95934741 2 EA WASHER,LOCK HELICAL

022 95094314 2 EA WASHER,FLAT,WIDE
023 50339043 2 EA BOLT,CHAIN
024 95929774 8 EA NUT,HEX
025 50244086 4 EA SHIM
026 95920674 4 EA SCREW,CAP,HEX
027 95937413 4 EA WASHER,LOCK,HELICAL
028 50707025 2 EA CHAIN, UPPER
029 57424137 2 EA CABLE ASSEMBLY, PULLDOWN
030 50244060 2 EA SPACER
031 57138760 1 EA DUST SHIELD
032 95077319 4 EA NUT,HEX,STOP
033 52158961 1 EA PLATE, EXTENSION
035 57315780 2 EA CLAMP,FEED CYL---5 OD
038 50622257 2 EA PLATE
039 57167934 2 EA FITTING,L90---120FSX12SAE
050 57360448 4 EA SHEAVE WITH BUSHING
50412626 1 EA D BUSHING
051 52264272 2 EA REST, CYLINDER
page 129 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57428468 TOWER ASSY,25’ CABLE PD

REF. PART NO. QTY. UNIT DESCRIPTION

052 57296394 2 EA FITTING,L90---160FSX12SAE

TOWER ASSY,25’ CABLE PD

054 57137416 6 EA PLATE, LOCK
055 95934550 12 EA SCREW,CAP,HEX
056 50692086 12 EA CLIP,LOCKING
057 56809395 12 EA WIRE
058 50219534 2 EA RACE, THRUST
060 57411092 2 EA RETAINER, CABLE
061 57411381 2 EA GUARDS, CABLE
062 95934733 4 EA WASHER,LOCK
063 95934451 4 EA SCREW,CAP,HEXHEAD,PLATED

57428468

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 130
 Serial Number: 4133
FAMILY,DM50

57425209 SUB 57492563 CYLINDER

TOWER ASSY,25’ CABLE PD

6
7
16

8
13 13
9
10 3
11 4

19 3

5 5

17

2
15
57428468

14

19

Figure 64 :SUB 57492563 CYLINDER

D57425209 REV 000
page 131 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57425209 SUB 57492563 CYLINDER

REF. PART NO. QTY. UNIT DESCRIPTION

001 57429292 1 EA SEAL KIT

TOWER ASSY,25’ CABLE PD

57245086 1 EA D O---RING
57429276 2 EA D BACK UP
57429250 1 EA D SEAL
57245441 2 EA D SLYDRING
57247397 1 EA D O---RING
57247405 1 EA D BACK UP
57245433 1 EA D STEPSEAL
57247413 1 EA D SLYDRING
57245458 1 EA D STEPSEAL
57245466 1 EA D EXCLUDER
012 57183584 1 EA LOCKNUT
013 57244907 1 EA SCREW, SET---1/4---28 X 2
014 57245292 4 EA PLUG, PORT
015 57245474 1 EA SPACER
016 57245581 1 EA HEAD,4---1/4 X 3---1/4
017 57429318 1 EA PISTON
018 57376659 1 EA ROD ASSY, FEED CYLINDER
019 57376667 1 EA TUBE ASSY, FEED CYLINDER

57428468

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 132
 Serial Number: 4133
FAMILY,DM50

57085961 TOWER PIPING ---2 MOTOR 25’

3 ---NOT SHOWN 45
46 47

23 19
TOWER PIPING---2 MOTOR 25’

16 20
37

15 14 13
17

16 36
12 19
20
34
11
84 5
6
57085961

7
1
91
32
33
22 19
16 20
5 83
8

9 49
22 21
AIR HOSE
ROTATION
ROTATION

21
DRAIN

10

90

Figure 65 :TOWER PIPING--- 2 MOTOR 25’

E57085961 REV08
page 133 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57085961 TOWER PIPING ---2 MOTOR 25’

42 80
38 82 81
77
17 23 85 77

TOWER PIPING---2 MOTOR 25’

43
73
79
75
46
18
24
44 40
40 41
47
78
74
77
76
48
45
28
29
30
31
VIEW A 23 89
25

26 17

57085961
18
24
27
11 VIEW F
89 1 84

15 34 89 1
91
14

13

8 5
12

SECTION D SECTION B SECTION C

Figure 66 :TOWER PIPING--- 2 MOTOR 25’

E57085961 REV08
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 134
 Serial Number: 4133
FAMILY,DM50

57085961 TOWER PIPING ---2 MOTOR 25’

46 45 2
1
TOWER PIPING---2 MOTOR 25’

19
5 20
7

VIEW G
6
4

SECTION H SECTION J

NOTE:
OVER CENTER VALVE (ITEM 49) SETTING PROCEDURE:
WITH POWER HEAD MOVING DOWN SLOWLY (LESS THAN 2FT.
PER MIN) IN FAST FEED MODE, ADJUST BOTH SETTING
SCREWS EQUALLY UNTIL MAIN VALVE GAUGE READS 700 PSI.
SCREW IN TO RAISE PRESSURE, OUT TO LOWER PRESSURE
57085961

86 TO ROD PORT
87 OF FEED CYLINDER

54
TO HEAD END PORT OF FEED CYL. 56
57
58 63
59 64
49
66 72
62
51 68
52 67
65 69 66 72
50 71 58
TO “B” PORT OF FEED CYL. VALVE
59
60
TO HEAD END PORT OF FEED CYL.
70 56
TO 4--- WAY DRILL SELECTOR VALVE, 55 61
PORT 2 53
TO “A” PORT OF FEED CYL. VALVE
TO 4--- WAY DRILL SELECTOR VALVE,
PORT 1 TO ROD PORT
86 OF FEED CYLINDER
VIEW E
87

Figure 67 :TOWER PIPING--- 2 MOTOR 25’

E57085961 REV08
page 135 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57085961 TOWER PIPING ---2 MOTOR 25’

REF. PART NO. QTY. UNIT DESCRIPTION

001 57083016 1 EA HOSE TRAY

TOWER PIPING---2 MOTOR 25’

002 57083008 1 EA HOSE TRAY
003 57083149 1 EA GUSSET (not shown)
004 57097263 2 EA GUSSET
005 57082992 2 EA BRACKET
006 57083172 1 EA GUSSET
007 57083198 1 EA BAR,FLAT
008 57083206 1 EA BAR, FLAT
009 57082984 1 EA BRACKET
010 57083180 1 EA GUSSET
011 57085607 1 EA CLAMP, STANDPIPE
012 57082554 1 EA STANDPIPE
013 57085573 1 EA STANDPIPE
014 57085581 1 EA STANDPIPE
015 57085599 1 EA STANDPIPE
016 56783020 8 EA KIT, SPLIT FLANGE
017 57092728 7 EA CLAMP ASSY, 1---1/4 PIPE
018 57083156 2 EA CLAMP ASSY, 3/4” PIPE

57085961
019 50023910 3 EA STEM
020 50743731 3 EA CLAMP, HOSE
021 57053787 2 EA HOSE ASSY
022 56960826 1 EA HOSE ASSY
023 57083032 1 EA MOUNT
024 56976616 3 EA BRACKET
025 57083057 1 EA PIPE ASSY
026 57083073 1 EA PIPE ASSY
027 57083065 1 EA PIPE ASSY
028 95035424 2 EA SCREW, CAP---5/8UNC X 2
029 95094314 2 EA WASHER, FLAT---5/8
030 95077814 2 EA NUT, HEX 5/8---11
031 50696517 4 EA CLIP,LOCKING
032 50347889 1 EA VALVE, CHECK
033 95219747 1 EA FITTING, HYD
034 56992357 3 EA HOSE ASSY
036 57326431 1 EA BAR, TOWER, PIPING MOUNT
037 95433330 1 EA HOSE,AIR
038 56956931 1 EA HOSE ASSY
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 136
 Serial Number: 4133
FAMILY,DM50

57085961 TOWER PIPING ---2 MOTOR 25’

REF. PART NO. QTY. UNIT DESCRIPTION

040 56988850 2 EA HOSE ASSY

TOWER PIPING---2 MOTOR 25’

041 56973126 1 EA HOSE ASSY

042 95316956 2 EA FITTING, HYD
043 95489282 1 EA ELBOW 4511/4
044 95293320 1 EA FITTING, HYD
045 95651683 1 EA ELBOW, PIPE
046 95238523 1 EA ELBOW STREET
047 57097131 1 EA PIPE,2NPT
048 57083552 1 EA CLAMP
049 50459155 1 EA VALVE
050 56996382 1 EA VALVE, CHECK
051 52167905 1 EA ADPT. CROSS
052 95279535 1 EA FITTING, HYD
053 56954217 1 EA HOSE ASSY
054 57097750 1 EA HOSE ASSY
055 57138893 1 EA HOSE ASSY
056 58217902 2 EA HOSE ASSY
057 95958997 2 EA SCREW,CAP---3/8---16 X 4---1/2
57085961

058 95922894 4 EA NUT, HEX---3/8---16

059 95922639 4 EA LOCKWASHER (HD)
060 95103909 2 EA SCREW, CAP---3/8---16 X 4
061 57100182 1 EA HOSE ASSY
062 95280194 1 EA FITTING, HYD---90 JIC/ORING
063 95365078 1 EA FITTING, HYD
064 56992514 1 EA HOSE ASSY
065 95666996 1 EA FITTING, HYD
066 56956915 2 EA HOSE ASSY
067 50335843 1 EA ADAPTER
068 56924962 1 EA FITTING, HYD---TEE ADAPTER
069 56955776 1 EA HOSE ASSY
070 57100182 1 EA HOSE ASSY
071 95329983 1 EA FITTING, HYD---JIC/O---RING
072 95280186 2 EA FITTING, HYD
073 56947609 1 EA HOSE ASSY
074 58042730 1 EA HOSE ASSY
075 95829263 1 EA FITTING, TUBE
076 95356960 1 EA FITTING, HYD
page 137 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57085961 TOWER PIPING ---2 MOTOR 25’

REF. PART NO. QTY. UNIT DESCRIPTION

077 57052599 4 EA FLANGE

TOWER PIPING---2 MOTOR 25’

077 95013702 16 EA SCREW, SOCK--- 5/8---11 X 2
077 95086567 4 EA O---RING
077 95209425 16 EA WASHER, LOCK---5/8
078 95280194 2 EA FITTING, HYD---90 JIC/ORING
079 95219853 2 EA FITTING, HYD
080 52147253 2 EA ADAPTER
081 95280095 2 EA FITTING, TEE---INT NPT
082 95219853 1 EA FITTING, HYD
083 56933732 1 EA CABLE, WHIP CHECK
084 57093197 1 EA BAR, ROUND
085 95737086 1 EA ELBOW,PIPE
086 95702619 2 EA ADAPTER
087 95279402 2 EA ELBOW, 90DEG MALE 37DG FL
089 56893217 8.00 FT WIRE
090 95301883 2 EA CLAMP, HOSE
091 57247181 1 EA CLAMP, STANDPIPE

57085961

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 138
 Serial Number: 4133
FAMILY,DM50

57116196 TOWER CYL,P---DM45/50

1
1

21
TOWER CYL,P---DM45/50

21 9
10 4
4 9

8 2

2 5
15

3 7 6 7
3
15

17---NOT SHOWN
23
57116196

22

B
20 20
21
A

18
18

19

Figure 68 :TOWER CYL,P--- DM45/50

V52221892 REV 04
page 139 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57116196 TOWER CYL,P---DM45/50

REF. PART NO. QTY. UNIT DESCRIPTION

001 95329975 2 EA FITTING, HYD

TOWER CYL,P---DM45/50
002 95365094 2 EA ADAPTER,90DEG---O---RING/JIC
003 56964224 2 EA HOSE ASSY
004 56964224 2 EA HOSE ASSY
005 95209094 1 EA FITTING, HYD
006 95302998 1 EA FITTING, HYD
007 95263380 2 EA FITTING, HYD---NPT/JIC
008 95279527 1 EA FITTING, HYD
009 95231031 2 EA FITTING, HYD
010 95264966 1 EA FITTING, HYD
015 56954100 2 EA HOSE ASSY
017 95666996 1 EA FITTING, HYD (UNDER HYD. TANK)
018 95201547 4 EA FITTING,LUBE
019 50813575 4 EA PLATE,LOCKING
020 50813567 4 EA PIN, CYLINDER
021 57224628 2 EA SUB 57488942---CYLINDER
022 56949407 1 EA HOSE ASSY
023 56961824 1 EA HOSE ASSY

57116196

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 140
 Serial Number: 4133
FAMILY,DM50

57402331 TOWER PINNING,PIPING

31 18
32 15
TOWER PINNING,PIPING

31

7
8
17 38
16 39
20 40 1
20 19

27 D

12 13 37
16 9
10 34
11
57402331

22 12
5
3 13
4
6
23

14
24
25

2
14
35

26 29

Figure 69 :TOWER PINNING,PIPING

D57402331 REV 01
page 141 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57402331 TOWER PINNING,PIPING

SPEED SWITCH

TOWER PINNING,PIPING
36
37

RELAY

TERM STRIP

34 GROUND

FRAME

57402331
1

34
36

37

41 ---SWITCH, TOGGLE---SPST

HYD. & ELECTRIC SHCEMATIC

Figure 70 :TOWER PINNING,PIPING

D57402331 REV 01
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 142
 Serial Number: 4133
FAMILY,DM50

57402331 TOWER PINNING,PIPING

REF. PART NO. QTY. UNIT DESCRIPTION

001 57359036 2 EA CLEVIS, TOWERPINNING---DML

TOWER PINNING,PIPING

002 56942600 1 EA SUB 57531683, KIT

57269227 1 EA D KIT,SEAL
57060337 1 EA D RING, RETAINING
57060345 1 EA D NUT, LOCK
57220303 1 EA D ROD CLEVIS
57060352 1 EA D SCREW, SET---CLEVIS
56975964 2 EA D PIN, CLEVIS
56975972 2 EA D PIN, CLIP
57060360 1 EA D HEAD, CYLINDER
57060378 1 EA D PISTON
57060386 1 EA D ROD
003 95342028 2 EA PIN, HINGE
004 95093381 4 EA PIN, COTTER---3/16 X 1---3/4
005 57141715 1 EA PIN,TOWER LOCKING
006 95081709 4 EA WASHER, FLAT---1
007 57045296 1 EA BAR, W/HOLES
008 52182623 1 EA VALVE, PRESS. REDUCING
57402331

009 95958914 2 EA SCREW,CAP---1/4---20 X 2---1/4

010 95931564 2 EA NUT, HEX---1/4---20
011 95934766 2 EA WASHER, LOCK---1/4 PLATED
012 57039752 1 EA VALVE, SOLENOID
57102311 1 EA D CARTRIDGE
57102329 1 EA D COIL S/A
013 57052623 1 EA BRACKET
014 95279493 2 EA FITTING, HYD
015 95704839 1 EA SWIVEL NUT
016 95316972 5 EA FITTING, HYD---NPT/JIC
017 95748927 1 EA TEE, NPT/JIC
018 56992522 1 EA HOSE ASSY
019 57020661 1 EA HOSE ASSY
020 56996036 2 EA HOSE ASSY
022 56954050 1 EA HOSE ASSY
023 57042921 1 EA HOSE ASSY
024 56943699 1 EA CLAMP ASSY,3 TUBE
025 57369969 1 EA TUBE, RECT.
026 57359127 1 EA SUPPORT,TOWER PINNINGCYL
page 143 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57402331 TOWER PINNING,PIPING

REF. PART NO. QTY. UNIT DESCRIPTION

027 95373841 1 EA TERMINAL

TOWER PINNING,PIPING
029 95748802 4 EA TIE, CABLE
031 95209094 2 EA FITTING, HYD
032 95257341 1 EA CAP, JIC---6
034 57359135 2 EA PLATE, PINNING---ANGLDRILL
035 57147092 1 EA ANGLE
036 57147100 1 EA PLATE
037 57147118 1 EA BAR,FLAT
038 95958930 2 EA SCREW,CAP---5/16---18 X2---1/4
039 95934303 2 EA WASHER, LOCK---5/16 PLATED
040 95929782 2 EA NUT, HEX---5/16---18
041 56762198 1 EA

57402331

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 144
 Serial Number: 4133
FAMILY,DM50

57162091 ROTARY HEAD---4SF ---2---12DM50

ROTARY HEAD---4SF---2---12DM50

5 TORQUE TO
50 80 FT. LBS. 127 49
6 129 126
128
46
37
43
39 36
28 42 35 28 48
48 38 31
9 9
13 6 25 24 6 13
15 22
45 32 51 22 15 41 12
26
130

23 33
23
34
20 47
8 19 10 19
17 11 17
14 20
21 21
57162091

16
27 18
2 5 27
125 4 125
6
3

118 OIL, GEAR

119 GREASE
120 COMPOUND, SILCONE

Figure 71 :ROTARY HEAD--- 4SF--- 2--- 12DM50

E57162091 REV10
page 145 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57162091 ROTARY HEAD---4SF ---2---12DM50

ROTARY HEAD---4SF---2---12DM50
63 55 55
64

121
65
48 30
44 48

60 30
48

56

48 123
48
44
44

57162091
124

48
48 61 44
44
48
48 62 44
44
124
30
48 30
48
122

Figure 72 :ROTARY HEAD--- 4SF--- 2--- 12DM50

E57162091 REV10
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 146
 Serial Number: 4133
FAMILY,DM50

57162091 ROTARY HEAD---4SF ---2---12DM50

ROTARY HEAD---4SF---2---12DM50

88 15

28
”A”

”B”
98

70
”A”
”B”
88

15 69
99 28
67

107
57162091

18

18

Figure 73 :ROTARY HEAD--- 4SF--- 2--- 12DM50

E57162091 REV10
page 147 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57162091 ROTARY HEAD---4SF ---2---12DM50

ROTARY HEAD---4SF---2---12DM50
54
53 65
55
44 52 58 48
48 64 44

56

131
8

57162091
64
64
112

48
44 60

Figure 74 :ROTARY HEAD--- 4SF--- 2--- 12DM50

E57162091 REV10
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 148
 Serial Number: 4133
FAMILY,DM50

57162091 ROTARY HEAD---4SF ---2---12DM50

56
57
ROTARY HEAD---4SF---2---12DM50

66

59

65

30
48

STOPS
57162091

110 110

Figure 75 :ROTARY HEAD--- 4SF--- 2--- 12DM50

E57162091 REV10
page 149 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57162091 ROTARY HEAD---4SF ---2---12DM50

REF. PART NO. QTY. UNIT DESCRIPTION

001 52210275 1 EA SPINDLE, DRIVE

ROTARY HEAD---4SF---2---12DM50
002 57578023 1 EA HOUSING,LOWER SEAL
003 52146784 2 EA SEAL, OIL
004 95434551 1 EA BEARING, ROLLER
005 95934451 14 EA SCREW,CAP,HEXHEAD,PLATED
006 95934733 37 EA WASHER,LOCK
008 57367914 1 EA HOUSING, W/BUSH---ROTARYHD (See figure 76)
009 95934378 4 EA CAPSCREW,HEX---HEAD,PLATED
010 52202736 1 EA GEAR, OUTPUT
011 52210291 1 EA SHRINK DISCS
57212383 12 EA D CAPSCREW---SOC HD METRIC
012 95086724 2 EA O---RING
013 95094314 4 EA WASHER, FLAT---5/8
014 52209798 1 EA SPACER
015 57191025 2 EA CAP, BEARING
016 95214037 2 EA BEARING
017 57191017 2 EA SHAFT, INTERMEDIATE
018 95033585 4 EA PLUG,PIPE---1/8 SQ HEAD

57162091
019 57159139 2 EA KEY, INTERMEDIATE SHAFT
020 57159113 2 EA GEAR, INTERMEDIATE
021 57170110 2 EA PINION, INPUT
022 95434874 2 EA BEARING
023 57159121 2 EA SPACER, INTERMEDIATEGEAR
024 57291304 1 EA NUT, ADJUSTING
95209987 1 EA D LOCKNUT,BRG
025 95270815 6 EA SCREW, CAP---5/16---18 X 1
026 57368052 2 EA ADAPTER, MOTOR
52245461 1 EA D ADAPTER
027 95711156 2 EA BEARING, SPHERICALROLLER
028 57117764 2 EA MOTOR,HYDRAULIC (See figure 77)
030 95935185 16 EA CAPSCREW,HEX HEAD,PLATED
031 57291288 1 EA WASHER, LOCK---TONGUED
57291296 1 EA D WASHER, LOCK, TONGUED
032 52248150 1 EA HOUSING, UPPER SEAL
033 95434569 1 EA BEARING, ROLLER
034 58229915 1 EA SEAL, OIL
035 52164282 1 EA SEAL, OIL
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 150
 Serial Number: 4133
FAMILY,DM50

57162091 ROTARY HEAD---4SF ---2---12DM50

REF. PART NO. QTY. UNIT DESCRIPTION

036 50822097 1 EA SLEEVE, WEAR

ROTARY HEAD---4SF---2---12DM50

037 52248176 1 EA SWIVEL

038 52187804 1 EA SLINGER
039 57347379 1 EA CAP, SPINDLE---SPUR HEAD
041 95055216 4 EA SCREW, CAP---5/8---11 X 1
042 50610971 1 EA RING, THREADED
043 50694876 1 EA PACKING, SWIVEL
57336067 2 EA D PACKING, SWIVEL---30XV
50694934 1 EA D BUSHING, WEAR
044 95929089 28 EA CAPSCREW,HEX HEAD
045 95934659 8 EA CAPSCREW,HEX HEAD
046 52210317 1 EA SHIM SET
046 57371163 1 EA SPACER, SWIVEL PACKING
047 52209939 2 EA BEARING
048 95934741 48 EA WASHER,LOCK HELICAL
049 57243719 2 EA SHIM, POWERHEAD---SPURGEAR
050 57183329 1 EA CAP, SWIVEL
051 95104204 8 EA SCREW, CAP
57162091

052 50624691 32 EA SHIM, GUIDE

053 57376816 8 EA GUIDE BLOCK---LONG,R.H.
054 50624709 32 EA SHIM, GUIDE
055 57376824 8 EA GUIDE BLOCK---SHORT,R.H.
056 52180106 1 EA PLATE, COVER
057 95064697 64 EA WASHER, FLAT---1/2
03209269 1 EA D WASHER 23---725
058 95293460 16 EA SCREW, CAP---1/2---13 X 7/8
059 50344605 12.00 FT WIRE, LOCK
060 95246088 12 EA PIN, ROLL---1/2 X 1---1/2
061 57367930 4 EA PIN, ANCHOR---ROTARY HEAD
062 50338482 4 EA SPACER, CHAIN
063 50702927 2 EA BUSHING, CHAIN ANCHOR
064 52249448 2 EA ANCHOR CHAIN
065 57143778 4 EA GUIDE, FINISHEDPOWERHEAD
066 95157731 32 EA SCREW, CAP---1/2 X 1.5
067 95249587 1 EA PLUG, PIPE---3/8 SQ HEAD
069 95201547 1 EA FITTING,LUBE
070 95249694 1 EA PLUG, PIPE---2 SQ HEAD
page 151 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57162091 ROTARY HEAD---4SF ---2---12DM50

REF. PART NO. QTY. UNIT DESCRIPTION

088 95246724 2 EA FITTING,RELIEF,HYD

ROTARY HEAD---4SF---2---12DM50
098 52253176 1 EA GAUGE, SIGHT
099 95040952 1 EA ELBOW,STREET---90DEG1/8NPT
107 50137256 1 EA PLUG, DRAIN
110 50704485 2 EA STOP, ANCHOR
112 52156916 1 EA TIEBAR
118 58209651 44.00 QT OIL, GEAR
119 52180957 1.00 LB GREASE
120 50700731 0.50 EA COMPOUND, SILICONE
121 52267408 1 EA PLATE, COVER
122 50530286 2 EA BUSHING, CHAIN
123 57055899 1 EA SUPPORT, SIDE PLATE
124 95104147 7 EA SCREW, CAP---1/2---13 X 1
125 95323465 2 EA PLUG HEAD
126 57191033 2 EA PLATE, END
127 50344605 2.00 FT WIRE, LOCK
128 95101762 6 EA SCREW, CAP---1/2---13 X1GRD8
129 95086625 1 EA O---RING
130 95097929 2 EA O---RING

57162091
131 57368243 4 EA SHIM, PINANCHOR---ROT.HEAD

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 152
 Serial Number: 4133
FAMILY,DM50

57367914 HOUSING, W/BUSH---ROTARYHD

ROTARY HEAD---4SF---2---12DM50

List only, no drawing required.

57162091

Figure 76 :HOUSING, W/BUSH--- ROTARYHD

E57367914 REV00
page 153 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57367914 HOUSING, W/BUSH---ROTARYHD

REF. PART NO. QTY. UNIT DESCRIPTION

001 57367906 1 EA CASTING,MACHINED---HOUSING

ROTARY HEAD---4SF---2---12DM50
002 52231008 1 EA COVER
003 95239927 4 EA PIN,DOWEL
004 95934451 24 EA SCREW,CAP,HEXHEAD,PLATED
005 95934733 24 EA WASHER,LOCK
006 57367922 4 EA BUSHINGHOUSING---ROTARYHEA

57162091

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 154
 Serial Number: 4133
FAMILY,DM50

57117764 MOTOR,HYDRAULIC

4 5 6 7
3
ROTARY HEAD---4SF---2---12DM50

2
8

19 20
18
15 16 17

14

10 11 13

9 12 28 30
26 27 29
23 25
57162091

24
22
21

31

32

33 SEAL KIT (NOT SHOWN) CONSISTS OF

ITEMS 2, 5, 26, 27, 29 and 31

Figure 77 :MOTOR,HYDRAULIC
B57117764 REV 003
page 155 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57117764 MOTOR,HYDRAULIC

ITEM 16 (RETAINING RING) IS ONE OF THE FOLLOWING

LIST:

ROTARY HEAD---4SF---2---12DM50
52155140 --- .083” (2.11mm), YELLOW
52155157 --- .081” (2.03mm), GREEN
52155165 --- .079” (2.01mm), RED
52204872 --- .087” (2.18mm), WHITE
52204864 --- .085” (2.13mm), BLUE
54408299 --- .077” (1.96mm), BLACK
54472469 --- .075” (1.90mm), ORANGE

SECURE THE PISTON AND SHOE ASSEMBLY

BY INSTALLING THE THICKEST OF THE
RETAINING RINGS THAT WILL FIT IN THE
GROOVE ON THE CAM CENTER POST. CHECK
CLEARANCE BETWEEN SHOE FACES AND
CREEP PLATE WITH A FEELER GAUGE. GRASP
ONE PISTON AND LIFT TIGHTLY AGAINST THE
SHOE RETAINER TO OBTAIN CLEARANCE.
GAP SHOULD BE BETWEEN .002”(.051mm)
AND .004”(.102mm). ASSEMBLY MUST BE FREE
TO ROTATE BY HAND WITH APPROXIMATE
FORCE OF 5 FT. LBS.(6.8 Nm).

57162091

Figure 78 :MOTOR,HYDRAULIC
B57117764 REV 003
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 156
 Serial Number: 4133
FAMILY,DM50

57117764 MOTOR,HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

001 54408059 2 EA PLUG

ROTARY HEAD---4SF---2---12DM50

002 52154994 2 EA O---RING

003 52215613 4 EA SCREW
004 54471321 1 EA PORT BLOCK, W/O SHUTTLE
005 54471768 1 EA GASKET
006 57181372 1 EA PLATE,PORT
007 52201712 1 EA FACEPLATE, BARREL---13/32
008 50817089 5 EA PINS
009 52155843 1 EA RING,RETAINING
010 57514903 1 EA SPRING, RETAINER
011 54471792 1 EA STOP,BARREL
012 57300816 12 EA DISC SPRING
013 57300824 12 EA THRUST WASHER
014 52201696 1 EA BARRL/SLEEVE
015 52155041 1 EA BEARING
016 54472170 1 EA KIT,RETAINING RING (See figure 79)
017 52204856 1 EA WASHER,THRUST
018 54413646 1 EA RETAINER PISTON & SHOE
57162091

019 52203668 1 EA PLATE, CREEP

020 54471917 1 EA CAM,MOTOR
021 54472105 2 EA PIN,DOWELL
022 54472113 1 EA HOUSING
023 54472121 1 EA SCREW,SOCKET HD CAP
024 57240806 1 EA SHAFT
025 57117772 1 EA BEARING,MOTOR SHAFT
026 57300329 1 EA O---RING
027 57117780 1 EA SEAL,SHAFT
028 57164592 1 EA RETAINER,SEAL
029 52215696 4 EA O---RING
030 54472139 4 EA SCREW,HEX HD CAP
031 57416950 1 EA O RING
032 57416943 1 EA RETAINER
033 54472147 1 EA KIT,SEAL M6F

page 157 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57117764 MOTOR,HYDRAULIC

ROTARY HEAD---4SF---2---12DM50
57162091

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 158
 Serial Number: 4133
FAMILY,DM50

54472170 KIT,RETAINING RING

ROTARY HEAD---4SF---2---12DM50

List only, no drawing required.

57162091

Figure 79 :KIT,RETAINING RING

B57117764 REV 003
page 159 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

54472170 KIT,RETAINING RING

REF. PART NO. QTY. UNIT DESCRIPTION

001 52155140 1 EA RING,RETAINING

ROTARY HEAD---4SF---2---12DM50
002 52155157 1 EA RING,RETAINING
003 52155165 1 EA RING,RETAINING
004 52204872 1 EA RING,RETAINING
005 52204864 1 EA RING,RETAINING
006 54408299 1 EA RING,RETAINING
007 54472469 1 EA RING,RETAINING

57162091

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 160
 Serial Number: 4133
FAMILY,DM50

57033052 SPINDLE SUB---4”BECO X 19”

SPINDLE SUB

96
57033052

95

Figure 80 :SPINDLE SUB--- 4”BECO X 19”

W50339373 REV15
page 161 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57033052 SPINDLE SUB---4”BECO X 19”

REF. PART NO. QTY. UNIT DESCRIPTION

095 50628007 2 EA LOCK, SPINDLE

SPINDLE SUB
096 57032955 1 EA ADPTR,DRL RD

57033052

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 162
 Serial Number: 4133
FAMILY,DM50

57186504 ROD CHANGER ---4)6.25 X30’

15 NOT SHOWN
13
ROD CHANGER---4)6.25 X30’

14

12

12

5
57186504

6
7

11
2

3
11
4
10

Figure 81 :ROD CHANGER--- 4)6.25 X30’

E57141889 REV 003
page 163 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57186504 ROD CHANGER ---4)6.25 X30’

REF. PART NO. QTY. UNIT DESCRIPTION

001 57174138 1 EA ROD CHANGER (See figure 82)

ROD CHANGER---4)6.25 X30’

002 50415496 5 EA CHUCK,5 HEX ROD
003 50519560 5 EA PLATE,ROD CHUCK LOCKING
004 50519578 5 EA BOLT,ROD CHUCK
005 95935128 6 EA SCREW, CAP---3/8---16 X 2
006 95922894 6 EA NUT,HEX,FINISHED
007 95937413 6 EA WASHER,LOCK,HELICAL
008 50461789 6 EA ADAPTER---MIDDLE,6.25 RODS
010 95201547 5 EA FITTING,LUBE
011 50519594 1 EA STOP, ROD CHUCK
012 52172384 6 EA BAR,STIFFNER
013 52185162 1 EA SPACER---ROD CHANGER
014 50461797 5 EA ADAPTER,UPPER---6.25 RODS
015 57213597 1 EA BREAKOUT KIT, RODCHANGER
57213563 1 EA D BREAKOUT PLATERODCHANGER
57213555 5 EA D BREAKOUTBLOCK,RODCHANGER

57186504

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 164
 Serial Number: 4133
FAMILY,DM50

57174138 ROD CHANGER

64 62
65 63
66
20 38
ROD CHANGER---4)6.25 X30’

18
19
17
21

12 38

8 67
9
22 23

68
12 38 19
21
8
9
6

24
57186504

32 25
33
28

29
30
38 61
28 31

73 4
60
2 36
3 56
7
38 37 34
1 35

69 NOT SHOWN

Figure 82 :ROD CHANGER

E57174138 REV 03
page 165 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57174138 ROD CHANGER

ROD CHANGER---4)6.25 X30’

38 20

23
22
68

13
15
16
6

38

8
11

57186504
26
9
10 38
38 12

54

41 55
40
53

38
39
50 44
50 42 48
51 49 51 43 57
52 52

Figure 83 :ROD CHANGER

E57174138 REV 03
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 166
 Serial Number: 4133
FAMILY,DM50

57174138 ROD CHANGER

REF. PART NO. QTY. UNIT DESCRIPTION

001 50248210 1 EA BEARING, LOWER

ROD CHANGER---4)6.25 X30’

002 50458959 1 EA BEARING, THRUST

003 50219534 2 EA RACE, THRUST
004 50170422 1 EA SEAL, ROD WIPER
005 57037392 1 EA ARM, LOWER
006 57209090 2 EA SHAFT, CLEVIS ASSY.
57037400 1 EA D SHAFT
50248236 1 EA D CLEVIS
57209066 1 EA D BLOCK, BEARING
007 50412998 3 EA SHIM
008 50248475 2 EA PIN, HINGE---ROD END
009 95210852 8 EA PIN, COTTER
010 50248467 2 EA PIN, HINGE---HEAD END
011 50248459 4 EA BUSHING, SWING CYLINDER
012 57199093 2 EA CYLINDER, HYDRAULIC (See figure 84)
013 50248434 2 EA PLATE, RETAINING
015 95950119 4 EA CAPSCREW,HEX HEAD,PLATED
016 95934691 4 EA WASHER,LOCK,HELICAL
57186504

017 57148090 1 EA SHAFT,PIPE ASSY

57037350 1 EA D SHAFT
57154692 1 EA D TUBING,ROUND
018 95308573 1 EA KEY,SQUARE
019 57165177 1 EA GUSSET
020 57138141 1 EA SUPPORT
57244113 0 EA D CAP,REPLACEMENT
95309829 4 EA D CAPSCREW,FLANGED 12 PT
95081667 4 EA D WASHER,FLAT,WIDE
021 57165185 1 EA BLOCK,SUPPORT
022 95105110 1 EA SCREW, CAP---1---8 X 3---1/2
023 95941084 1 EA NUT,HEX,FINISHED,PLATED
024 57141871 1 EA HOLDER ASSY
025 57083479 5 EA BUSHING, ROD CHUCK---STEEL
026 57141913 2 EA MOUNT,ROD CHANGER CYL
028 95018271 2 EA O---RING
029 50248368 1 EA RETAINER, BEARING
030 50243518 1 EA BEARING ASSY
031 50248426 1 EA SPACER
page 167 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57174138 ROD CHANGER

REF. PART NO. QTY. UNIT DESCRIPTION

032 95920708 8 EA CAPSCREW,HEX HEAD,PLATED

ROD CHANGER---4)6.25 X30’

033 95934733 8 EA WASHER,LOCK
034 50411602 1 EA INDEXER
035 95105052 1 EA CAPSCREW,HEX HEAD
036 50415231 1 EA RING,THREAD LOCKING
037 50415249 1 EA PLATE,KEEPER
038 95201547 9 EA FITTING,LUBE
039 95338844 1 EA KEY,SQUARE
040 57040016 1 EA CLAMP
041 57039620 1 EA CYLINDER, HYDRAULIC
57039828 1 EA D KIT,SEAL
042 95342002 1 EA PIN, HINGE
043 95018982 2 EA PIN, COTTER---3/16 X 1---1/2
044 50456896 1 EA BRACKET, INDEXING CYLIND
57165946 1 EA D PLATE
57165953 2 EA D PLATE
048 50456912 1 EA PIN
049 50456938 1 EA SPRING
050 50344191 2 EA BOLT, EYE

57186504
051 95922183 4 EA WASHER, FLAT---1/4
052 95931564 4 EA NUT,HEX,FINISHED
053 50456946 1 EA BRACKET
054 57141061 1 EA BRAKE BAND, ROD CHANGER
57141053 1 EA D BRAKE LINING---ROD CHANGER
055 95922928 2 EA NUT,HEX,FINISHED
056 95081709 1 EA WASHER, FLAT---1
057 95340758 1 EA PIN, DRIV---LOK
060 57141079 1 EA BRAKE, DISC
061 50829589 1 EA STOP, ROD CHANGER
062 50704519 1 EA ARM, UPPER---SPUR HEAD
063 95208971 1 EA FITTING, LUBE---90 DEG
064 50244086 8 EA SHIM
065 95934550 4 EA CAPSCREW,HEX HEAD
066 95937413 4 EA WASHER,LOCK,HELICAL
067 57037319 1 EA TUBING, ROUND
068 57083206 1 EA BAR, FLAT
069 57141913 1 EA MOUNT,ROD CHANGER CYL
073 95705547 1 EA FITTING,LUBE RELIEF
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 168
 Serial Number: 4133
FAMILY,DM50

57199093 CYLINDER, HYDRAULIC

1 ---SEAL KIT (NOT SHOWN)

ROD CHANGER---4)6.25 X30’

3 9
4 13

12

10
11
2
6

7
15
6

14

8
57186504

15

16

Figure 84 :CYLINDER, HYDRAULIC

E57199093 REV 01
page 169 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57199093 CYLINDER, HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

001 57242547 0 EA SEAL KIT

ROD CHANGER---4)6.25 X30’

002 57242554 1 EA LOCKNUT
003 57012684 3 EA SCREW, SET
004 57012676 3 EA PLUG, NYLON
005 57242562 1 EA O---RING
006 57242570 2 EA RING, CAST IRON
007 57242588 1 EA DISC 25
008 57224081 1 EA O---RING
009 57224099 1 EA RING, BACK---UP
010 57224115 1 EA U---CUP, LOADED
011 57224123 1 EA WIPER
012 57242596 1 EA HEADCAP
013 57242604 1 EA HEAD
014 57242612 1 EA PISTON
015 57242638 1 EA ROD ASSY
016 57242620 1 EA TUBE ASSY

57186504

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 170
 Serial Number: 4133
FAMILY,DM50

57083560 PIPING, RD CHNGR/WRNCHCYL

PIPING, ROD CHANGER

7
8
9
10

2
6 2
6

C1
V1
2

V2
6

C2
2
6 13
14
15
16
57083560

9---SPOOL
VALVE

CONTROL
PANEL
3 4
A
BULKHEAD
B
3 BULKHEAD 4

Figure 85 :PIPING, RD CHNGR/WRNCHCYL

D57083560 REV 04
page 171 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57083560 PIPING, RD CHNGR/WRNCHCYL

PIPING, ROD CHANGER

5

7 19
8 20
9 21
10

17 9---SPOOL VALVE

TO 9---SPOOL VALVE

57083560
5
9---SPOOL VALVE

1
HYD.
WRENCH
CYL. 4

BULKHEAD 11
CONTROL
PANEL

Figure 86 :PIPING, RD CHNGR/WRNCHCYL

D57083560 REV 04
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 172
 Serial Number: 4133
FAMILY,DM50

57083560 PIPING, RD CHNGR/WRNCHCYL

18
PIPING, ROD CHANGER

18

12
4
7
8
9
10

9 SPOOL VALVE

WRENCH SECTION
57083560

ROD CHANGER SECTION

Figure 87 :PIPING, RD CHNGR/WRNCHCYL

D57083560 REV 04
page 173 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57083560 PIPING, RD CHNGR/WRNCHCYL

REF. PART NO. QTY. UNIT DESCRIPTION

001 95371258 2 EA FITTING, HYD

PIPING, ROD CHANGER

002 95356903 4 EA FITTING, HYD
003 56966963 2 EA HOSE ASSY
004 56961782 2 EA HOSE ASSY
005 57044752 2 EA HOSE ASSY
006 95419594 4 EA FITTING, HYD
007 50034826 14 EA CLAMP, HOSE
008 95931564 7 EA NUT, HEX---1/4---20
009 95934766 7 EA WASHER, LOCK---1/4 PLATED
010 95105466 7 EA SUB 95920724---CAPSCREW,HEX
011 57004020 2 EA HOSE ASSY
012 56966294 2 EA HOSE ASSY
013 50462944 2 EA VALVE, CHECK---DBL PILOT OP
014 57054991 2 EA BAR, TAPPED
015 95044038 4 EA SUB 95943668---CAPSCREW,HEX
016 95934303 4 EA WASHER, LOCK---5/16 PLATED
017 52244449 2 EA HOSE ASSY
018 95329975 2 EA FITTING, HYD

57083560
019 95322871 1 EA CLAMP, HOSE
020 95937413 1 EA WASHER, LOCK---3/8 PLATED
021 95922894 1 EA NUT, HEX---3/8---16

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 174
 Serial Number: 4133
FAMILY,DM50

52167012 WRENCH,CYLINDER
WRENCH,CYLINDER

1
1

2
2

5
6 4
52167012

5
6

7 BAR, FLAT (NOT SHOWN)

Figure 88 :WRENCH,CYLINDER
D52167012 REV 006
page 175 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52167012 WRENCH,CYLINDER

REF. PART NO. QTY. UNIT DESCRIPTION

001 57039638 1 EA CYLINDER, HYDRAULIC

WRENCH,CYLINDER
57039810 1 EA D KIT,SEAL (See figure 89)
57012676 1 EA D PLUG, NYLON
57012684 1 EA D SCREW, SET
002 95342028 1 EA PIN,HINGE
004 50219617 1 EA SHAFT, ANCHOR
005 50219609 1 EA WASHER, RETAINING
006 95098711 1 EA PIN,ROL
007 57076267 2 EA BAR,FLAT

52167012

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 176
 Serial Number: 4133
FAMILY,DM50

57039810 KIT,SEAL
WRENCH,CYLINDER

14

15 11

11

10

12

13
52167012

Figure 89 :KIT,SEAL
E57039638 REV 00
page 177 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57039810 KIT,SEAL

REF. PART NO. QTY. UNIT DESCRIPTION

010 57326795 1 EA O---RING

WRENCH,CYLINDER
011 57326803 2 EA U---CUP
012 57224081 1 EA O---RING
013 57163529 1 EA RING, BACK UP
014 57163453 1 EA U---CUP
015 59322677 1 EA WIPER

52167012

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 178
 Serial Number: 4133
FAMILY,DM50

57054298 BREAKOUT ---4.5 FLATS

BREAKOUT---4.5 FLATS

12 16

15
14
13
57054298

Drill
Rod

3
1
4

5
2 7
8
17
9
10
11

Figure 90 :BREAKOUT--- 4.5 FLATS

E50350594 REV08
page 179 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57054298 BREAKOUT ---4.5 FLATS

REF. PART NO. QTY. UNIT DESCRIPTION

001 50348317 1 EA FORK CHUCK---4.5 FLATS

BREAKOUT---4.5 FLATS
50380799 1 EA D CHUCK
002 50422997 1 EA GUIDE, SLIDING
50383017 1 EA D GUIDE
003 57054009 1 EA CYLINDER, HYDRAULIC (See figure 91)
004 50350461 2 EA ANGLE, CYLINDER
005 95494563 4 EA SCREW, CAP---1/2---13 X2---1/4
007 95922902 4 EA NUT,HEX,FINISHED,PLATED
008 95201299 1 EA FITTING
009 95402996 2 EA SCREW,CAP
010 95081642 2 EA WASHER, FLAT---1
011 95076899 2 EA NUT, HEX JAM---1 ---8
012 95338604 2 EA PIN, ROLL---1/2 X 3---1/4
013 50345677 1 EA PIN
014 95104303 1 EA SCREW, CAP---1/2---13 X 5
015 50350644 1 EA SPACER
016 95321204 1 EA NUT, HEX JAM---1/2---13
017 50462514 1 EA PLATE, MOUNTING

57054298

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 180
 Serial Number: 4133
FAMILY,DM50

57054009 CYLINDER, HYDRAULIC

1 ---Seal Kit
BREAKOUT---4.5 FLATS

2
7
9

10

5
8 11
4

10
57054298

Figure 91 :CYLINDER, HYDRAULIC

D57054009 REV01
page 181 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57054009 CYLINDER, HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

001 58231119 1 EA SEAL KIT (See figure 92)

BREAKOUT---4.5 FLATS
002 58233792 1 EA RING, RETAINING
003 58233719 1 EA NUT, LOCK
004 57351728 1 EA CLEVIS, CYLINDER
005 57067571 1 EA SCREW, SET
006 57067555 1 EA PIN
007 57067563 1 EA CLIP
008 58233743 1 EA PISTON
009 58233800 1 EA HEAD
010 57168544 1 EA ROD
011 57168551 1 EA TUBE ASSY.

57054298

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 182
 Serial Number: 4133
FAMILY,DM50

58231119 SEAL KIT

BREAKOUT---4.5 FLATS

6
5

4
57054298

1
3

Figure 92 :SEAL KIT

A57054009 REV 01
page 183 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

58231119 SEAL KIT

REF. PART NO. QTY. UNIT DESCRIPTION

001 58233784 1 EA O’RING

BREAKOUT---4.5 FLATS
002 58233727 2 EA O---RING
003 58233735 3 EA RING, BACKUP
004 58233834 1 EA O’RING
005 58233826 1 EA RING BACKUP
006 58233818 1 EA WIPER

57054298

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 184
 Serial Number: 4133
FAMILY,DM50

57121717 BREAKOUT PIPING

A
BREAKOUT PIPING

13
22
28 23
24

B
DOUBLE
PUMP
MAINIFOLD

19

16

25

T
RP
TO HYD. TANK
57121717

TO JUNCTION
BOX ON FRONT
OF CAB

B 7

Figure 93 :BREAKOUT PIPING

E57121717 REV 01
page 185 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57121717 BREAKOUT PIPING

BREAKOUT PIPING
SET AT 200 PSI 16
22
23
T
24
REG
10

10 17

2 31 7
17
T ---P0RT
T P

27
P---PORT

3 17
4 6 30

57121717
5

VIEW A
C

Figure 94 :BREAKOUT PIPING

E57121717 REV 01
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 186
 Serial Number: 4133
FAMILY,DM50

57121717 BREAKOUT PIPING

BREAKOUT PIPING

26 21

25 15
16

14
9
19
R
REG 17
10 P
10 18
9
17
DOUBLE
PUMP
19 MANIFOLD
TO ”IN” ON ITEM 7
TO ”TANK” ON ITEM 7
8
7
57121717

3
4

VIEW C-- C

Figure 95 :BREAKOUT PIPING

E57121717 REV 01
page 187 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57121717 BREAKOUT PIPING

BREAKOUT PIPING
20

20

16
18

57121717
7

Figure 96 :BREAKOUT PIPING

E57121717 REV 01
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 188
 Serial Number: 4133
FAMILY,DM50

57121717 BREAKOUT PIPING

BREAKOUT PIPING

12

28 TO CONNECT ”C2” PORT RELIEF VALVE

WITH ”T” PORT ON ITEM 7

31
(BOTTOM) TO PISTON END
OF BREAKOUT CYLINDER 17
7

6
C2 TO ”REG.” PORT ON ITEM 16.
SET AT 210 PSI 27 P

C1 T TO ”R” PORT ON ITEM 16

2 29
9
TO ROD END OF BREAKOUT CYLINDER

8 17
22 30
23 6
24
7 VIEW B
57121717

P C1 -- 04

C2
T -- 04 P -- 04 BREAKOUT
CYLINDER

27
-- 04
T -- 04

-- 04
REG

16 R

-- 06
P
ATM -- 2
FROM DOUBLE PUMP MANIFOLD
HYDRAULIC SCHEMATIC

Figure 97 :BREAKOUT PIPING

E57121717 REV 01
page 189 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57121717 BREAKOUT PIPING

REF. PART NO. QTY. UNIT DESCRIPTION

002 95335980 2 EA FITTING, HYD

BREAKOUT PIPING
003 56955107 1 EA HOSE ASSY
004 95396404 1 EA FITTING, HYD
005 52198173 1 EA HOSE ASSY
006 95263380 2 EA FITTING, HYD---NPT/JIC
007 57039752 1 EA VALVE, SOLENOID
57102311 1 EA D CARTRIDGE
57102329 1 EA D COIL S/A
008 57052623 1 EA BRACKET
009 95263380 3 EA FITTING, HYD---NPT/JIC
010 57004020 2 EA HOSE ASSY
012 56762198 1 EA SWITCH, TOGGLE---SPST
013 95920724 2 EA SCREW, CAP---1/4---20 X1---1/2
014 95341079 1 EA FITTING, HYD
015 95279071 1 EA FITTING, HYD
016 52182623 1 EA VALVE, PRESS. REDUCING
017 95293403 4 EA FITTING, HYD
018 57045296 1 EA BAR, W/HOLES

57121717
019 57044752 1 EA HOSE ASSY
020 50034826 2 EA CLAMP, HOSE
021 95704839 1 EA SWIVEL NUT
022 95357232 4 EA SCREW, CAP---7/16---14X2---1/4
023 95931564 6 EA NUT, HEX---1/4---20
024 95934766 6 EA WASHER, LOCK---1/4 PLATED
025 57011355 1 EA HOSE ASSY
026 95257341 1 EA CAP, JIC---6
027 50514967 1 EA VALVE, RELIEF
028 57034357 1 EA HOSE ASSY
029 95377156 1 EA FITTING, STR---EXT NPT RUN
030 95279923 1 EA TEE
031 95341079 1 EA FITTING, HYD

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 190
 Serial Number: 4133
FAMILY,DM50

50350586 INDEX CYL.P.

INDEX CYL.P.

8
12
13
14
4 TO ROD END
INDEX CYL.

5 TO CYL END
INDEX CYL.
11
6 9

7
3
3
50350586

1 2
10

15
16
6

Figure 98 :INDEX CYL.P.

W50350586 REV 04
page 191 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50350586 INDEX CYL.P.

REF. PART NO. QTY. UNIT DESCRIPTION

001 56955107 1 EA HOSE ASSY

INDEX CYL.P.
002 56964190 1 EA HOSE ASSY
003 57097891 2 EA HOSE ASSY
004 56964182 1 EA HOSE ASSY
005 57100281 1 EA HOSE ASSY
006 50462944 1 EA VALVE,CHECK---DBL PILOTOP
007 95419594 4 EA FITTING, HYD
008 95365094 2 EA ADAPTER,90DEG---O---RING/JIC
009 50258193 4 EA PLATE, MOUNTING
010 52208691 1 EA BRACKET, MOUNTING
011 50034826 8 EA CLAMP, HOSE
012 95920724 8 EA SCREW, CAP---1/4---20 X1---1/2
013 95934766 8 EA WASHER, LOCK---1/4 PLATED
014 95931564 8 EA NUT, HEX---1/4---20
015 95935235 2 EA SCREW, CAP---5/16---18X1---1/2
016 95934303 2 EA WASHER, LOCK---5/16 PLATED

50350586

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 192
 Serial Number: 4133
FAMILY,DM50

57120321 BOOM, JIB---25’TOWER

53

DOUBLE PUMP
54 33
34

MANIFOLD
37
BOOM, JIB---25’TOWER

42

R 2 1
18 15 43
36 35

P
5
16
6

7 17

TANK PORT ATM --- 12

39 26
48 20
49 52
50
51 MAIN HYD. DRIVE
57120321

23
24
25 31 37 15
26 34

TANK PORT ATM --- 12

19
DOUBLE PUMP

2 22
46
MANIFOLD

R
1

3
18
P

1
2

35
4
MOTOR

PUMP

Figure 99 :BOOM, JIB--- 25’TOWER

D57120321 REV 15
page 193 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57120321 BOOM, JIB---25’TOWER

BOOM, JIB---25’TOWER
12 32
13
14 47
38 3

1 11 27
4 28
29
30

57120321
27
28
12 2 29
3 30
38

38 10
13 10 11
14 11 8
9
1

21 ---WIRE SHEAVE
44 ---HYD. TANK ASSY.

Figure 100 :BOOM, JIB--- 25’TOWER

D57120321 REV 15
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 194
 Serial Number: 4133
FAMILY,DM50

57120321 BOOM, JIB---25’TOWER

REF. PART NO. QTY. UNIT DESCRIPTION

BOOM, JIB---25’TOWER

001 52263159 1 EA HOIST, JIB (See figure 101)

002 57119968 1 EA MOUNT, HOIST
003 57120271 1 EA ARM, JIB HOIST---FIXED
004 58231812 1 EA ROPE, WIRE---3/8 X 59’
57360059 59.00 FT D ROPE, WIRE---3/8 BULK
005 57138950 1 EA HOOK, SWIVEL---2 TON
57138968 1 EA D KIT, LATCH
006 58060153 1 EA THIMBLE, WIRE ROPE---3/8
007 58060179 3 EA CLAMP, CABLE
008 95251088 6 EA SCREW, CAP---7/16---14 X1.75
009 95477873 6 EA NUT, HEX LOCK---7/16---14
010 50258193 4 EA PLATE, MOUNTING
011 57003634 2 EA BAR, FLAT
012 95201547 1 EA FITTING,LUBE
013 95093381 1 EA PIN, COTTER---3/16 X 1---3/4
014 57120339 1 EA PIN, JIB ARM
015 57080319 1 EA VALVE, 4---WAY
57120321

57172082 1 EA D KNOB & HANDLE ASM

016 95279162 1 EA FITTING, HYD
017 56992522 1 EA HOSE ASSY
018 56992092 1 EA HOSE ASSY
019 56981509 2 EA HOSE ASSY
020 95365078 1 EA FITTING, HYD
021 50245810 1 EA SHEAVE, WIRE
022 95279543 1 EA FITTING, HYD
023 95935128 17 EA SCREW, CAP---3/8---16 X 2
024 95937413 17 EA WASHER, LOCK---3/8 PLATED
025 95922894 17 EA NUT, HEX---3/8---16
026 50034818 36 EA CLAMP, HALF
027 95104188 4 EA SCREW, CAP---1/2---13 X1---3/4
028 95321204 4 EA NUT, HEX JAM---1/2---13
029 95245767 4 EA WASHER, BEVEL---1/2
030 95081667 8 EA WASHER, FLAT---1/2
031 52145489 1 EA NAMEPLATE
032 50820935 1 EA MOTOR, HYDRAULIC (See figure 102)
033 57097974 1 EA NAMEPLATE, JIB HOIST
page 195 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57120321 BOOM, JIB---25’TOWER

REF. PART NO. QTY. UNIT DESCRIPTION

034 95321626 4 EA SCREW, DRIVE

BOOM, JIB---25’TOWER
035 95279071 1 EA FITTING, HYD
036 95279071 1 EA FITTING, HYD
037 57120354 1 EA BRACKET, VALVE---JIBCONTRL
038 57120347 2 EA SPACER
039 57146474 1 EA LINK, SLING
042 57136897 2 EA FITTING, HYD
043 95279378 2 EA FITTING, HYD
044 57084311 0 EA HYD TANK ASY
046 95370045 1 EA FITTING,HYD
047 56953045 1 EA GASKET
048 95103990 1 EA SCREW, CAP---1/4---20 X3---1/4
049 50034826 2 EA CLAMP,HOSE,HALF
050 95934766 1 EA WASHER, LOCK---1/4 PLATED
051 95931564 1 EA NUT, HEX---1/4---20
052 95415584 1 EA PLUG, JIC---6
053 95938544 4 EA SCREW, CAP---5/16---18 X 3/4
054 95934303 4 EA WASHER, LOCK---5/16 PLATED

57120321

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 196
 Serial Number: 4133
FAMILY,DM50

52263159 HOIST, JIB

3
42
2 5 12 14
BOOM, JIB---25’TOWER

6
19 21
22
24 15 16
4 44 45 10 20 17
44
1 7 18
24
9
59
58 46
7 11
55 13
15
56

50 9

57 49
54

53
57

52
57120321

21 61
23
36
35 26
29
37 30
6 42 13
38
43 34
47 41
36 40 33
23
39
25
31
32
47
48

Figure 101 :HOIST, JIB

E52263159 REV01
page 197 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52263159 HOIST, JIB

REF. PART NO. QTY. UNIT DESCRIPTION

001 58232554 2 EA SCREW

BOOM, JIB---25’TOWER
002 58232562 1 EA COVER
003 52140480 6 EA CPSCRW/LCWSH
004 50830546 1 EA GASKET
005 50710532 1 EA ADAPTER
006 52260734 4 EA GASKET
007 50710508 2 EA BEARING CUP
009 52240090 2 EA HOUSING, HALF
010 52259769 1 EA GEAR/SPIDER
011 58232588 1 EA SCREW
012 50830660 2 EA DOWEL PIN
013 58232596 2 EA VALVE,RELIEF
014 52140464 1 EA GREASE PLUG
015 58232604 2 EA BUSHING
016 58232612 1 EA PLUG
017 52140423 7 EA B0LT---NUT
018 58232620 3 EA SCREW
019 52240132 1 EA GASKET

57120321
020 52240140 1 EA GASKET
021 58232638 2 EA PLUG
022 50830413 1 EA WORM KEY
023 50650407 2 EA RING, LOCK
024 52269883 2 EA SPACER
025 57241739 1 EA SPRING
026 57241747 1 EA PRESSURE PLATE---CLUTCH
029 50636513 1 EA GASKET
030 57419020 1 EA COVER, BRAKE HOUSING
031 52252053 6 EA SCREW
032 58232661 1 EA SEAL
033 58232679 1 EA NUT
034 58232687 1 EA SCREW
035 50650456 12 EA SPRING
036 50650415 2 EA WASHER
037 50650449 6 EA ROLL PIN
038 57241721 1 EA CLUTCH
039 50650381 4 EA PLATE, BRASS
040 50650399 5 EA PLATE
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 198
 Serial Number: 4133
FAMILY,DM50

52263159 HOIST, JIB

REF. PART NO. QTY. UNIT DESCRIPTION

041 50647767 6 EA CPSCRW/LCWSH

BOOM, JIB---25’TOWER

042 58232695 12 EA WASHER

043 57419012 1 EA HOUSING, BRAKE
044 50710490 2 EA BEARING CONE
045 50830520 1 EA WORM
046 50830538 1 EA WORMSHAFT
047 50830421 4 EA SPIDER KEY
048 58232703 1 EA SHAFT
049 52218500 1 EA SEAL
050 58232711 1 EA DRUM
052 58232737 1 EA BRACKET
053 50830397 1 EA BUSHING
054 50830553 1 EA ZERK FITTING
055 52140431 2 EA BOLT
056 50830587 1 EA CABLE CLAMP
057 58232745 8 EA WASHER
058 58232752 2 EA NUT
059 58232760 2 EA WASHER
061 57308009 1 EA SEAL, BRAKE
57120321

page 199 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52263159 HOIST, JIB

BOOM, JIB---25’TOWER
57120321

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 200
 Serial Number: 4133
FAMILY,DM50

50820935 MOTOR, HYDRAULIC

000 ---SEAL KIT

BOOM, JIB---25’TOWER

20
18
16
14 15
12
9 10
7
8
4

3
11
57120321

Figure 102 :MOTOR, HYDRAULIC

Y352128 REV00
page 201 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50820935 MOTOR, HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

000 52188976 1 EA SEAL KIT

BOOM, JIB---25’TOWER
001 50491729 4 EA SCREW, CAP---5/16 X 7/8
003 50998103 1 EA PLUG
004 52188851 1 EA FLANGE, MOUNTING
007 52188885 1 EA RACE, BEARING
008 56001118 1 EA BEARING, MOTOR
009 52188893 1 EA KEY,WOODRUFF
010 52188901 1 EA SHAFT, OUTPUT
011 50636547 1 EA O---RING
012 52188927 1 EA HOUSING, 1/2 NPT PORTS
014 52188935 1 EA DRIVE SHAFT
015 52188943 1 EA SPACER PLATE
016 52188950 1 EA GEROTOR SET
018 52188968 1 EA CAP, END
020 50799170 7 EA SCREW, CAP---5/16 X 1---1/2

57120321

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 202
 Serial Number: 4133
FAMILY,DM50

57427478 ANGLE DRILL PKG --- 25’

ANGLE DRILL PACKAGE

APORT A A
PORT B
TP: 57427478

44

POWER HEAD
45

41
4
5
46
42
51

2
31
48
50
49
47

31
2

19

Figure 103 :ANGLE DRILL PKG --- 25’

E57510133 REV 00
page 203 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57427478 ANGLE DRILL PKG --- 25’

26

ANGLE DRILL PACKAGE

43 29 11 27
15 43 36
16
17 38 V1 40
40
C1
V2
C2

39 B
24
25
18 A
25
17

TP: 57427478
20 17
30 17
32

17
33

21 22
34

23

15
16
17

Figure 104 :ANGLE DRILL PKG --- 25’

E57510133 REV 00
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 204
 Serial Number: 4133
FAMILY,DM50

57427478 ANGLE DRILL PKG --- 25’

13
11 28
11 14
14
ANGLE DRILL PACKAGE

10
41 2
9 42

12
37 4

3
24
TP: 57427478

C2 C1

36

V2 V1 (+) ( ---)
12

24 DC NO
SV
T P
2

Figure 105 :ANGLE DRILL PKG --- 25’

E57510133 REV 00
page 205 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57427478 ANGLE DRILL PKG --- 25’

REF. PART NO. QTY. UNIT DESCRIPTION

001 57429326 1 EA TIE BAR, O---30 DEGREES

ANGLE DRILL PACKAGE

002 50518653 1 EA SWITCH, LIMIT
003 57145468 1 EA PIN, TIEBAR--- 0---30 DEG
004 57206831 1 EA PLATE, CAM
005 95035424 6 EA SCREW, CAP---5/8UNC X 2
006 95103818 1 EA SUB 95935128---CAPSCREW,HEX
007 95076907 1 EA NUT, HEX JAM---3/4---10
008 95937413 1 EA WASHER, LOCK---3/8 PLATED
009 57102279 1 EA BRACKET
010 56953896 1 EA HOSE ASSY
011 56954589 2 EA HOSE ASSY
012 57232571 1 EA VALVE
57305377 2 EA D COIL, SOLENOID---24VDC
013 56953961 1 EA HOSE ASSY

TP: 57427478
014 95316972 4 EA FITTING, HYD---NPT/JIC
015 50258276 1 EA CLEVIS
016 95342028 1 EA PIN, HINGE
017 95093381 6 EA PIN, COTTER---3/16 X 1---3/4
018 57018343 1 EA CYLINDER, HYDRAULIC (See figure 106)
019 57445694 1 EA BRACKET, LIMIT SWITCH
020 50821362 1 EA PIN
021 50821313 1 EA PLATE, GUIDE
022 50821347 1 EA SUPPORT, ROD
023 50821321 1 EA GUIDE, ROD
024 57221475 1 EA ORIFICE, .125
57084287 1 EA D FITTING
025 95279527 2 EA FITTING, HYD
026 57229924 1 EA BAR, TAP
027 95044038 2 EA SUB 95943668---CAPSCREW,HEX
028 95415667 1 EA FITTING, HYD
029 95356853 2 EA FITTING, HYD
030 95866232 1 EA PIN, HINGE---1.13X5X4.5 GRP
031 57194987 1 EA ARM, ADJUSTABLE
032 50813393 1 EA BOLT
033 95228169 3 EA WASHER, LOCK---1”
034 95077749 3 EA NUT, HEX---1”---8
035 95105102 2 EA SCREW, CAP---1”---8 X 3---1/4
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 206
 Serial Number: 4133
FAMILY,DM50

57427478 ANGLE DRILL PKG --- 25’

REF. PART NO. QTY. UNIT DESCRIPTION

036 57225302 1 EA VALVE, OVERRUNNING LOAD

ANGLE DRILL PACKAGE

037 57232589 1 EA SUBPLATE

038 57011363 1 EA HOSE ASSY
039 58154337 1 EA HOSE ASSY
040 52251766 2 EA CLAMP ASSY
041 95080206 6 EA NUT, HEX LOCK---5/8---11
042 95103941 4 EA SUB 95971552---CAPSCREW,HEX
043 95356903 2 EA FITTING, HYD
044 52236783 8 EA CLAMP ASSY, 1/2”
045 95333209 30.00 FT CONDUIT, FLEX---1/2”
046 95301867 1 EA CLAMP, HOSE
047 95920674 4 EA SCREW, CAP---3/8---16 X 1
048 95937413 4 EA WASHER, LOCK---3/8 PLATED
049 95922894 4 EA NUT, HEX---3/8---16
050 57198285 2 EA ANGLE
TP: 57427478

051 95934766 4 EA WASHER, LOCK---1/4 PLATED

052 57510133 1 EA DRAWING,ANGLE PKG,0---30
065 95365078 1 EA FITTING, HYD

page 207 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57427478 ANGLE DRILL PKG --- 25’

ANGLE DRILL PACKAGE

TP: 57427478

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 208
 Serial Number: 4133
FAMILY,DM50

57018343 CYLINDER, HYDRAULIC

ANGLE DRILL PACKAGE

9
TP: 57427478

Figure 106 :CYLINDER, HYDRAULIC

D57018343 REV02
page 209 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57018343 CYLINDER, HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

000 57018350 1 EA KIT,SEAL

ANGLE DRILL PACKAGE

001 57068215 1 EA RING, RETAINING
002 57220295 1 EA LOCKNUT
009 57220279 1 EA PISTON

TP: 57427478

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 210
 Serial Number: 4133
FAMILY,DM50

POWERPACK/ENGINE
SECTION
POWERPACK/ENGINE

page 211 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
POWERPACK/ENGINE

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 212
 Serial Number: 4133
FAMILY,DM50

57220790 ENGINE ASSY---CAT 3412---575

1 26
ENGINE ASSY---CAT 3412---575

4
5

17
23

24
18 22
25
8 NOT SHOWN
21 NOT SHOWN
57220790

19
2

Figure 107 :ENGINE ASSY--- CAT 3412--- 575

D57220790 REV 06
page 213 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57220790 ENGINE ASSY---CAT 3412---575

14
15
16

ENGINE ASSY---CAT 3412---575

18 19
6
11

5 6
7 9
10
5
2 7

57220790
3
5
7
13
17

20 6

4 11
5
7 5
19 7
10
12 1

Figure 108 :ENGINE ASSY--- CAT 3412--- 575

D57220790 REV 06
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 214
 Serial Number: 4133
FAMILY,DM50

57220790 ENGINE ASSY---CAT 3412---575

REF. PART NO. QTY. UNIT DESCRIPTION

001 57220717 1 EA ENGINE,CAT 3412DIT---575

ENGINE ASSY---CAT 3412---575

57238602 1 EA D BOLT,FLY WHEEL

57238610 12 EA D BOLT, FLY WHEEL
57238628 12 EA D WASHER, FLAT HARDFACED
002 57172736 1 EA MOUNT,FRONT ENGINE
003 57171159 1 EA ENGINE MOUNT REAR
004 95035424 10 EA SCREW, CAP---5/8UNC X 2
005 95081790 24 EA WASHER, LOCK---5/8
006 95035432 12 EA SCREW, CAP---5/8---11 X2---1/4
007 95077814 16 EA NUT, HEX 5/8---11
008 57311987 1 EA WIRING, ENGINE, CAT
57311979 1 EA D HARNESS, WIRE, ENG. CAT
009 95094314 4 EA WASHER, FLAT---5/8
010 95266409 8 EA WASHER, BEVEL---5/8
011 50518083 4 EA SHIM SET
012 57185498 1 EA MOUNT, ENG, REAR W/BKT
57185464 1 EA D PLATE,FILTER MOUNTING
57171159 1 EA D ENGINE MOUNT REAR
57220790

013 95104436 2 EA SCREW, CAP---5/8---11 X1---1/2

014 95104147 2 EA SCREW, CAP---1/2---13 X 1
015 95081824 2 EA WASHER, LOCK---1/2
016 52222510 1 EA BRACKET
017 57294829 2 EA FILTER,FUEL SECONDARY
018 52183233 2 EA FILTER,OIL---ENGINE
019 57212011 2 EA ELEMENT,MAINTENANCE
020 57273138 1 EA PLATE, FILTER MTG
021 57212813 1 EA SENSOR,MAGNETICCAT3406TA
022 52235363 1 EA BRACKET, OIL
023 95002143 1 EA PLUG, PIPE---SQ HEAD, 3/4
024 56954233 1 EA HOSE ASSY
025 95219747 1 EA FITTING, HYD
026 57503682 1 EA LINK, MAIN PUMP CONTROLS

page 215 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57220790 ENGINE ASSY---CAT 3412---575

ENGINE ASSY---CAT 3412---575

57220790

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 216
 Serial Number: 4133
FAMILY,DM50

57421190 BATTERY INSTALLATION

1
BATTERY INSTALLATION

8 3

4 7
5
6
57421190

Figure 109 :BATTERY INSTALLATION

D57074783 REV05
page 217 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57421190 BATTERY INSTALLATION

REF. PART NO. QTY. UNIT DESCRIPTION

001 50623735 1 EA CABLE ASSY---BATTERY

BATTERY INSTALLATION
002 30441570 1 EA CABLE, BATTERY
003 56893365 1 EA CABLE, BATTERY
56769995 1 EA D TERMINAL
56770001 84.00 IN D CABLE, BATTERY---2/0
56770027 1 EA D LUG
004 95934592 6 EA SCREW, CAP---3/8---16 X2---1/4
005 95922894 6 EA NUT, HEX---3/8---16
006 95937413 6 EA WASHER, LOCK---3/8 PLATED
007 58231887 1 EA BOX, BATTERY
57143505 1 EA D COVER, BATTERY
008 57113177 2 EA BATTERY,12V---8DW/ELECTROL

57421190

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 218
 Serial Number: 4133
FAMILY,DM50

57412587 EXHAUST ASSY---CAT3412 DIT

EXHAUST ASSY---CAT3412 DIT

10

11

12

4 17
18 2 1
19
57412587

13
14
15

Figure 110 :EXHAUST ASSY--- CAT3412 DIT

E57412587 REV 01
page 219 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57412587 EXHAUST ASSY---CAT3412 DIT

EXHAUST ASSY---CAT3412 DIT

20
21
22
6
16
5
7
6

57412587
8

Figure 111 :EXHAUST ASSY--- CAT3412 DIT

E57412587 REV 01
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 220
 Serial Number: 4133
FAMILY,DM50

57412587 EXHAUST ASSY---CAT3412 DIT

REF. PART NO. QTY. UNIT DESCRIPTION

001 57574162 1 EA SILENCER,ALUMINIZED 8”

EXHAUST ASSY---CAT3412 DIT

002 50279413 2 EA BAND, MOUNTING---AIRCLEANR

003 52190733 1 EA PIPE,EXHAUST
004 52215506 1 EA CAP, WEATHER
005 50622745 1 EA COUPLING, V---RETAINER
006 50622729 2 EA FLANGE,PIPE
007 50622752 1 EA GASKET, FLAN
008 57412611 1 EA ELBOW---EXHAUST 8 90 DEG
009 56778699 6 EA CLAMP, SEAL
010 57412603 1 EA TUBING---FLEXIBLE EXH.8
011 57229791 1 EA ELBOW, 45 DEG. EXHAUST
012 57229783 1 EA FLANGE EXHAUST
013 95934469 8 EA CAPSCREW,HEX HEAD
014 95934733 8 EA WASHER,LOCK
015 95077798 8 EA NUT, HEX---1/2---13
016 57113029 1 EA COVER,TOP---COOLING PKG
017 95920682 4 EA SCREW, CAP---3/8---16 X1---1/4
018 95937413 4 EA WASHER, LOCK---3/8 PLATED
57412587

019 95922894 4 EA NUT, HEX---3/8---16

020 95104410 4 EA SCREW, CAP---5/8---11 X1---1/4
021 95934741 4 EA WASHER,LOCK HELICAL
022 95239539 4 EA SUB 95077814 NUT

page 221 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57412587 EXHAUST ASSY---CAT3412 DIT

EXHAUST ASSY---CAT3412 DIT

57412587

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 222
 Serial Number: 4133
FAMILY,DM50

57228330 RADIATOR PIPING ASSY.

13
14
13
RADIATOR PIPING ASSY.

16 13 14
33

15

17
15
13
12
32
13

19
13 1 20
13 8 28 21
18
27 29
2
28

31

22
4
6
57228330

5 5

21
10
9 20 5
7 11 4 ENGINE
OUTLET

3 30

31

23 26

24 25

ENGINE

ENGINE

Figure 112 :RADIATOR PIPING ASSY.

E57228330 REV05
page 223 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57228330 RADIATOR PIPING ASSY.

REF. PART NO. QTY. UNIT DESCRIPTION

001 57228348 1 EA TUBE WATER OUTLET

RADIATOR PIPING ASSY.

002 57228074 1 EA PIPE, WATER INLET
003 57229056 2 EA BAR W/HOLES
004 56989353 2 EA HOSE, RADIATOR
56989338 4.00 IN D HOSE, RADIATOR---BULK
005 52230810 4 EA CLAMP, HOSE
006 95391173 2 EA U---BOLT
007 95077798 4 EA NUT, HEX---1/2---13
008 57229031 1 EA HOSE, RADIATOR
009 57229049 1 EA HOSE RADIATOR
010 95081824 4 EA WASHER, LOCK---1/2
011 57277808 2 EA CLAMP, T---BOLT, 4.50
012 57135253 1 EA HOSE, RADIATOR
013 52230810 8 EA CLAMP, HOSE
014 50463645 2 EA HOSE HUMP
015 52223070 2 EA CLAMP
016 57065021 2 EA BRACKET
017 57054793 1 EA TUBE,COOLANT

57228330
018 57236226 1 EA RADIATOR TUBE SUPPORT
019 95375341 1 EA U---BOLT
020 95077798 4 EA NUT, HEX---1/2---13
021 95081824 4 EA WASHER, LOCK---1/2
022 95104196 2 EA SCREW, CAP---1/2---13 X 2
023 58146267 1 EA HOSE ASSY
024 56920903 1 EA FITTING,HYD
025 57237380 1 EA FITTING, MALE---FEMALE NPT
026 95748927 1 EA TEE, NPT/JIC
027 56989197 1 EA HOSE ASSY
028 95220844 2 EA CLAMP, HOSE
029 52230810 2 EA CLAMP, HOSE
030 95301834 1 EA CLAMP,HOSE
031 57351769 1 EA TUBE, DEAERATION
032 57350944 1 EA TUBE, DEAERATION
033 95326922 1 EA ADAPTER,45DEG. NPT/JIC

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 224
 Serial Number: 4133
FAMILY,DM50

57420747 COOLER ASSY/SPLIT ---MODINE

13
12
COOLER ASSY/SPLIT---MODINE

ENGINE FLY WHEEL HOUSE

FOR REF.
21
20
19
2 POWER PACK
BASE

11
57420747

10

MAIN FRAME

Figure 113 :COOLER ASSY/SPLIT--- MODINE

D57420747 REV02
page 225 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57420747 COOLER ASSY/SPLIT ---MODINE

COOLER ASSY/SPLIT---MODINE
ENGINE FLY WHEEL HOUSE

2 FOR REF.

4
5
13 6
12 3
7

57420747
8
1

2 POWER PACK
BASE
POWER PACK
BASE

Figure 114 :COOLER ASSY/SPLIT--- MODINE

D57420747 REV02
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 226
 Serial Number: 4133
FAMILY,DM50

57420747 COOLER ASSY/SPLIT ---MODINE

COOLER ASSY/SPLIT---MODINE

12
14

26
25
24
23
22
57420747

Figure 115 :COOLER ASSY/SPLIT--- MODINE

D57420747 REV02
page 227 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57420747 COOLER ASSY/SPLIT ---MODINE

COOLER ASSY/SPLIT---MODINE
10

16

57420747
18

9
15

17

Figure 116 :COOLER ASSY/SPLIT--- MODINE

D57420747 REV02
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 228
 Serial Number: 4133
FAMILY,DM50

57420747 COOLER ASSY/SPLIT ---MODINE

REF. PART NO. QTY. UNIT DESCRIPTION

001 95087409 2 EA SCREW, CAP---1/2---13 X2---1/2

COOLER ASSY/SPLIT---MODINE

002 57201741 1 EA BRACE COOLER REAR (See figure 117)

003 95958989 4 EA SCREW, CAP---3/8---16 X1---3/4
004 95922894 4 EA NUT, HEX---3/8---16
005 95937413 4 EA WASHER, LOCK---3/8 PLATED
006 95922373 4 EA WASHER, FLAT---3/8
007 57202467 4 EA PLATE, UPPER REAR
008 57202475 1 EA BRACKET, REAR LOWER
009 57279135 1 EA SHIELD, AIR CLEANER
010 57139727 1 EA SHIELD, A/C---UPPER
011 57187585 1 EA OIL COOLER(LOW PROFILE)
57101941 1 EA D COOLER,OIL---SAE O RINGPRT
57498719 1 EA D CORE, COOLER--- COC ONLY
57499634 1 EA D COOLER CORE --- HOC ONLY
012 57156945 1 EA RADIATOR---LARGE MODINE
57150450 1 EA D ASSEMBLY, RADIATOR
57242109 1 EA D TANK---RAD. TOP
57242117 1 EA D TANK---RAD. BOTTOM
57420747

57247264 1 EA D RADIATOR CORE KIT (See figure 118)

013 50262526 22.00 GL ANTI---FREEZE
014 52249828 1 EA HOSE,WATER
015 95053047 4 EA SCREW,CAP---HEX1/2---13X1.25
016 95077798 4 EA NUT, HEX---1/2---13
017 95081824 4 EA WASHER, LOCK---1/2
018 95064697 4 EA WASHER, FLAT---1/2
019 95087268 10 EA SCREW, CAP---5/8---11 X1---3/4
020 95081790 10 EA WASHER, LOCK---5/8
021 95077814 10 EA NUT, HEX 5/8---11
022 95368338 2 EA CLAMP, HOSE
023 95934816 2 EA SCREW, CAP---1/4---20 X 1
024 95931564 2 EA NUT, HEX---1/4---20
025 95934766 2 EA WASHER, LOCK---1/4 PLATED
026 95922373 2 EA WASHER, FLAT---3/8

page 229 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57420747 COOLER ASSY/SPLIT ---MODINE

COOLER ASSY/SPLIT---MODINE
57420747

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 230
 Serial Number: 4133
FAMILY,DM50

57201741 BRACE COOLER REAR

COOLER ASSY/SPLIT---MODINE

7 GREASE

5
6

5
6

2
57420747

Figure 117 :BRACE COOLER REAR

C57201741 REV000
page 231 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57201741 BRACE COOLER REAR

REF. PART NO. QTY. UNIT DESCRIPTION

002 57202483 1 EA TUBE REAR LOWER

COOLER ASSY/SPLIT---MODINE
003 57204232 1 EA TUBE, REAR UPPER
004 56961287 10.00 IN HOSE,HYD---E32 BULK
005 58086141 4 EA CLAMP,HOSE
006 95958799 4 EA NUT, ACORN---1/4---28
007 52180957 2.00 LB GREASE

57420747

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 232
 Serial Number: 4133
FAMILY,DM50

57247264 RADIATOR CORE KIT

12

11
12 4 10
COOLER ASSY/SPLIT---MODINE

11

5 4

7
4

9
4

4 25
10
57420747

5
4
4
11
5
4
12

Figure 118 :RADIATOR CORE KIT

D57145781 REV04
page 233 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57247264 RADIATOR CORE KIT

REF. PART NO. QTY. UNIT DESCRIPTION

001 57181448 1 EA CORE,RADIATOR

COOLER ASSY/SPLIT---MODINE
004 57247298 8 EA BAR, BOLTING
005 57247322 4 EA BAR, BOLTING
007 57362774 4 EA GASKET, RADIATOR
009 95935227 64 EA SCREW, CAP---5/16---18X1---1/4
010 95929006 6 EA SCREW, CAP---5/16---18 X 1
011 95934303 128 EA WASHER, LOCK---5/16 PLATED
012 95929782 128 EA NUT, HEX---5/16---18
025 95935235 58 EA SCREW, CAP---5/16---18X1---1/2

57420747

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 234
 Serial Number: 4133
FAMILY,DM50

AIR CLEANERS
SECTION
AIR CLEANERS

page 235 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
AIR CLEANERS

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 236
 Serial Number: 4133
FAMILY,DM50

57272916 AIR CLEANER ASSY---CAT3412

2
3
11 4
5
AIR CLEANER ASSY---CAT3412

6
8

16
13 17
7 18

32

10

1
13
57272916

9 12
13

33

14
15

34

19

33
20 4
21
22

Figure 119 :AIR CLEANER ASSY--- CAT3412

D57272916 REV 01
page 237 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57272916 AIR CLEANER ASSY---CAT3412

REF. PART NO. QTY. UNIT DESCRIPTION

001 50825504 1 EA AIR FILTER (See figure 120)

AIR CLEANER ASSY---CAT3412

002 50616028 1 EA AIR CLEANER (See figure 121)
003 58044744 2 EA BAND, MOUNTING
004 52265311 2 EA INDICATOR, RESTRICTION
005 56899669 2 EA SHROUD, INLET
006 57079105 1 EA DUCT, AIR
007 57314395 1 EA TUBE, AIR---ALUM.6X74
008 56761554 1 EA ELBOW, RUBBER---90 DEG
009 52145836 1 EA HOSE HUMP
010 57059636 1 EA ELBOW, RUBBER
011 58044561 1 EA HOSE HUMP, REDUCING
012 57440562 1 EA CLAMP, CONSTANT TORQUE
013 57439267 7 EA CLAMP, CONSTANT TORQUE
014 57235491 1 EA BRACKET, FILTER MTG
015 57318388 1 EA INTAKE,COMPRESSOR---7.50LG
016 95934592 8 EA SCREW, CAP---3/8---16 X2---1/4
017 95922894 8 EA NUT, HEX---3/8---16
018 95937413 8 EA WASHER, LOCK---3/8 PLATED

57272916
019 50424134 2 EA U---BOLT
020 95245767 4 EA WASHER, BEVEL---1/2
021 95081824 4 EA WASHER, LOCK---1/2
022 95077798 4 EA NUT, HEX---1/2---13
032 57235574 1 EA SUPPRT A.C.
033 95287629 4 EA FITTING, HYD
034 57004020 2 EA HOSE ASSY

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 238
 Serial Number: 4133
FAMILY,DM50

50825504 AIR FILTER

AIR CLEANER ASSY---CAT3412

7
000
9

10

000
11

000

000 13

4
57272916

000

Figure 120 :AIR FILTER

W50825504 REV02
page 239 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50825504 AIR FILTER

REF. PART NO. QTY. UNIT DESCRIPTION

000 50621796 1 EA KIT, GASKET---AIR CLEANER

AIR CLEANER ASSY---CAT3412

001 50816479 1 EA CUP ASSY
002 50816487 1 EA CLAMP
004 50816503 1 EA INLET,AIR
005 50816511 1 EA CLAMP
006 50817113 1 EA CHAMBER
007 52146966 1 EA ELEMENT, SAFETY
009 52248127 1 EA SIGNAL, SAFETY
010 52146958 1 EA ELEMENT, PRIMARY
011 50816446 1 EA NUT, WING
013 50817121 1 EA COVER ASSY

57272916

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 240
 Serial Number: 4133
FAMILY,DM50

50616028 AIR CLEANER

16 NOT SHOWN
AIR CLEANER ASSY---CAT3412

000 9
10
11

000
12 000
14

000

5
57272916

000

Figure 121 :AIR CLEANER

C50616028 REV05
page 241 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50616028 AIR CLEANER

REF. PART NO. QTY. UNIT DESCRIPTION

000 50621796 1 EA KIT, GASKET---AIR CLEANER

AIR CLEANER ASSY---CAT3412

001 50816479 1 EA CUP ASSY
002 50816487 1 EA CLAMP
004 50816503 1 EA INLET,AIR
005 50816511 1 EA CLAMP
006 50816529 1 EA BODY ASSY---AIR CLEANER
007 50616408 1 EA ELEMENT, SAFETY
009 50816420 1 EA NUT
010 95002697 1 EA PIN, COTTER---1/8 X 1---1/4
011 50616390 1 EA ELEMENT, PRIMARY
012 50816446 1 EA NUT, WING
014 50816537 1 EA ACCESS COVER
016 56899669 1 EA SHROUD, INLET

57272916

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 242
 Serial Number: 4133
FAMILY,DM50

FUEL SYSTEM
SECTION
FUEL SYSTEM

page 243 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
FUEL SYSTEM

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 244
 Serial Number: 4133
FAMILY,DM50

57082901 FUEL TANK,P---STD CUMM855

DUST COLLECTOR SIDE

FUEL TANK,P---STD CUMM855

SUCTION

7
27 22
8 19

20

RETURN

CAB SIDE 23 19

9
24

21 13
16 18
4
5 11 4
57082901

24
14 5
4 10
5
17 14 18
TO SUCTION LINE 16
28 OF ENGINE
TO RETUEN LINE
OF ENGINE (CUMMS) 12
ENGINE ONLY
23 20 7 21
19 22
19 22

3
4
5
6 6 1 25
27 26

Figure 122 :FUEL TANK,P--- STD CUMM855

D57082901 REV 05
page 245 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57082901 FUEL TANK,P---STD CUMM855

REF. PART NO. QTY. UNIT DESCRIPTION

001 52225190 1 EA TANK, 210 GAL. FUEL

FUEL TANK,P---STD CUMM855

002 50514074 4 EA PIN
003 95934782 8 EA SCREW, CAP---1/4---20 X1---3/4
004 95934766 14 EA WASHER, LOCK---1/4 PLATED
005 95931564 14 EA NUT, HEX---1/4---20
006 52225075 2 EA PIPE FUEL TK
95038113 1 EA D BUSHING PIPE
007 50219518 1 EA FILLER, TANK---2.5 NPT
57497190 1 EA D HEAD ASSY,FILLER---2.5NPT
54418090 1 EA D GASKET
008 50616762 1 EA GAUGE, FUEL
009 50258441 1 EA PUMP, FUEL
010 95920724 2 EA SCREW, CAP---1/4---20 X1---1/2
011 50829480 1 EA VALVE, CHECK
012 95063475 1 EA TEE
013 95003463 1 EA TEE, PIPE
014 52263035 2 EA U---BOLT
016 95330023 2 EA FITTING, HYD

57082901
017 95376141 1 EA ADAPTER---90DEG,ORING/JIC
018 95287629 2 EA FITTING, HYD
019 95279543 3 EA FITTING, HYD
020 95279535 1 EA FITTING, HYD
021 58183468 1 EA HOSE ASSY
022 58147356 1 EA HOSE ASSY
023 57015836 1 EA HOSE ASSY
024 57034357 2 EA HOSE ASSY
025 95002002 1 EA BUSHING
026 95267092 1 EA PETCOCK
027 52246774 100.00 GL FUEL, DIESEL
028 95302121 1 EA FITTING, HYD

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 246
 Serial Number: 4133
FAMILY,DM50

COMPRESSOR/AIR SYSTEM
SECTION
COMPRESSOR/AIR SYSTEM

page 247 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
COMPRESSOR/AIR SYSTEM

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 248
 Serial Number: 4133
FAMILY,DM50

57187817 COMPRESSOR ASSY---1050HR2

COMPRESSOR ASSY---1050HR2

Torque to 30 ft/lb.
6 Torque to 46 ft/lb.
7

4 15 13
16 14

19

2 17

18
25

26
57187817

27
28
29
20
21
22
23

24
3

Figure 123 :COMPRESSOR ASSY--- 1050HR2

D57064792 REV 10
page 249 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57187817 COMPRESSOR ASSY---1050HR2

COMPRESSOR ASSY---1050HR2
8
9
10
Torque to 150 ft/lb.

1 7
12
Torque to 250 ft/lb.

57187817
Filter
Assembly
#36756120

Oil Filters
#36758613

Figure 124 :COMPRESSOR ASSY--- 1050HR2

D57064792 REV 10
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 250
 Serial Number: 4133
FAMILY,DM50

57187817 COMPRESSOR ASSY---1050HR2

REF. PART NO. QTY. UNIT DESCRIPTION

COMPRESSOR ASSY---1050HR2

001 57170896 1 EA SUPPORT, COMPRESSOR

002 36001535 1 EA AIR END---1050HR2
35364975 1 EA D KEY DRIVE COUPLING
35104082 1 EA D LOCKNUT
35593516 1 EA D SEAL---SHAFT
35856467 1 EA D OIL SEAL COVER
95022372 1 EA D O---RING
92304435 4 EA D SCREW,SET---M12 X 25MM
36765113 1 EA D GEAR,SET HR2,900,1050CFM
35272541 18 EA D SCREW,CAP---M16X2 X 40MM
003 50518083 4 EA SHIM SET
004 52206547 1 EA VALVE, BUTTERFLY
005 95214524 2 EA GASKET RING
006 56946247 8 EA SCREW, CAP---M20X2.5 X80MM
007 50759455 12 EA WASHER, LOCK M20
008 95035432 2 EA SCREW, CAP---5/8---11 X2---1/4
009 95266409 2 EA WASHER, BEVEL---5/8
57187817

010 95080206 2 EA NUT, HEX LOCK---5/8---11

012 35272558 4 EA SCREW, HEX---M20 X 45
013 95104022 12 EA SCREW, CAP---7/16---14 X 1.5
014 95238143 12 EA WASHER, LOCK---7/16
015 95457610 12 EA SCREW, CAP---3/8---16 X3---1/4
016 95937413 12 EA WASHER, LOCK---3/8 PLATED
017 36783710 1 EA COUPLING, ASSY
018 35103852 1 EA BUSHING, SPLIT TAPER
019 57077562 1 EA GUARD, COMPRESSOR
020 95958989 4 EA SCREW, CAP---3/8---16 X1---3/4
021 95922894 4 EA NUT, HEX---3/8---16
022 95338356 4 EA WASHER, BEVEL---3/8
023 95937413 4 EA WASHER, LOCK---3/8 PLATED
024 57134140 8 EA SCREW, HEX---M20 X 25
025 57134157 7 EA SCREW, HEX---M16 X 20
026 52247657 2 EA PLATE, COVER
027 95928982 4 EA SCREW, CAP---1/4---20 X 3/4
028 95934766 4 EA WASHER, LOCK---1/4 PLATED
029 52263787 2 EA GASKET
page 251 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57187817 COMPRESSOR ASSY---1050HR2

COMPRESSOR ASSY---1050HR2
57187817

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 252
 Serial Number: 4133
FAMILY,DM50

57220725 PIPING, SPLIT COOLER ---COC

7
COOLER

RECEIVER
TANK
PIPING, SPLIT COOLER

30
31 4

32 13 AIR END
1 16
12 STRAINER

14 11
OIL
37 PUMP
5

3
38
39
STRAINER 40
44 6
45
10
29 28 32 33 7 9

COOLER
31
26
57220725

30
13

2
16 12
AIR END 4
RECEIVER
TANK
32 1
14 11

3
STRAINER

9 6 29
33 POWER PACK BASE

Figure 125 :PIPING, SPLIT COOLER--- COC

D57220725 REV 03
page 253 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57220725 PIPING, SPLIT COOLER ---COC

REF. PART NO. QTY. UNIT DESCRIPTION

001 35321645 1 EA VALVE, RELIEF---75 PSI

PIPING, SPLIT COOLER

002 95219853 2 EA FITTING, HYD
003 57139982 1 EA BRACKET, MOUNTING---AMOT
004 95365177 2 EA FITTING, HYD
005 95279477 1 EA FITTING, HYD
006 57117491 1 EA ELBOW,LONG---JIC/ORING---90
007 95431292 1 EA FITTING, HYD
009 95431292 1 EA FITTING, HYD
010 95663803 1 EA FITTING, TUBE
011 52226164 1 EA FITTING, HYD
012 95678041 1 EA FITTING, HYD
013 95208682 1 EA FITTING, HYD
014 57170821 1 EA VALVE, TEMPERATURE BYPASS
57170839 1 EA D ELEMENT
95000477 1 EA D O---RING
95022281 1 EA D O---RING
016 95387346 1 EA ADAPTER
026 52226164 1 EA FITTING, HYD
028 95279477 1 EA FITTING, HYD

57220725
029 56957855 1 EA HOSE ASSY
030 56962368 1 EA HOSE ASSY
031 56957889 1 EA HOSE ASSY
032 57029191 1 EA HOSE ASSY
032 56981632 1 EA HOSE ASSY
033 57162646 1 EA HOSE ASSY
033 56956865 1 EA HOSE ASSY
037 57080251 1 EA FITTING, HYD
038 95087409 4 EA SCREW, CAP---1/2---13 X 2---1/2
039 95208831 4 EA NUT, HEX JAM---1/2---20
040 95081667 8 EA WASHER, FLAT---1/2
044 95081824 4 EA WASHER, LOCK---1/2
045 95077798 4 EA NUT, HEX---1/2---13

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 254
 Serial Number: 4133
FAMILY,DM50

57096067 COMP.CONT.P.---UL88/HR2

2
COMP.CONT.P.---UL88/HR2

47

28 4

5
2
27
26 19 8 6

7
8

35 10
13

25
24
9 19

23
57096067

21

10 9
21

18 19
17
A

A
C

16
11
15
14
13 11
C

Figure 126 :COMP.CONT.P.--- UL88/HR2

D57096067 REV 05
page 255 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57096067 COMP.CONT.P.---UL88/HR2

15
36

COMP.CONT.P.---UL88/HR2
15 16

34 35
14
11 13

34 19

17
19

29 30

CAB FLOOR
CONSOLE
62
25
21
39 63 9
ADJUST TO PREVENT BUTTERFLY
VALVE FROM STICKING IN
THE CLOSED POSITION

57096067
9
55 68”
77 BUTTERFLY VALVE
78 27 CLOSED
BUTTERFLY VALVE 65 10
OPEN 72 66
67
24 .005 AT 30” ADJ SCREW
68
73 65
74 66
75 67
76 71 69
70

26

Figure 127 :COMP.CONT.P.--- UL88/HR2

D57096067 REV 05
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 256
 Serial Number: 4133
FAMILY,DM50

57096067 COMP.CONT.P.---UL88/HR2

16

23
COMP.CONT.P.---UL88/HR2

50

40 49
38 41
42
INTERSTAGE 48
39
PRESS. PORT
39
18
17

32

14
33
31

11
57096067

13

11 11

18 18 11
34
34
35 35
20
20 45 39

44 44 45

CAB FLOOR
CONSOLE
10
DETAIL -- E 10

Figure 128 :COMP.CONT.P.--- UL88/HR2

D57096067 REV 05
page 257 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57096067 COMP.CONT.P.---UL88/HR2

82 ---BLOCK, VALVE---BUTTERFLY
45 25
79

COMP.CONT.P.---UL88/HR2
34

13 21
63
19

26 35
71

81
80
83
63
45

25
13

79 35

57096067
39 28
63 41
27 42 54 8
62 51 53 4
26 8 54

6 6
56

57
58 5
67

Figure 129 :COMP.CONT.P.--- UL88/HR2

D57096067 REV 05
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 258
 Serial Number: 4133
FAMILY,DM50

57096067 COMP.CONT.P.---UL88/HR2

REF. PART NO. QTY. UNIT DESCRIPTION

002 56956139 1 EA HOSE ASSY

COMP.CONT.P.---UL88/HR2

004 57015752 1 EA HOSE ASSY

005 57410466 1 EA HOSE ASSY
006 95219721 3 EA FITTING, HYD
007 95264966 1 EA FITTING, HYD
008 95231031 4 EA FITTING, HYD
009 57097115 1 EA HOSE ASSY
010 57099061 1 EA HOSE ASSY
011 57043697 2 EA HOSE ASSY
013 57034308 2 EA HOSE ASSY
014 50258128 1 EA VALVE, 3---WAY
015 52210986 1 EA VALVE, NEEDLE
016 56275969 1 EA REGULATOR
56275977 0 EA D KIT, REPAIR REGULATOR
017 57043812 1 EA HOSE ASSY
018 57043820 1 EA HOSE ASSY
019 57097081 2 EA HOSE ASSY
020 52162138 1 EA MANIFOLD
57096067

021 57097107 1 EA HOSE ASSY

023 50262492 1 EA GAUGE,PRESSURE---0---160PSI
024 57050718 1 EA BRACKET
025 57530917 1 EA REGULATOR ASSY, UL---88 (See figure 130)
026 56974223 1 EA HOSE ASSY
027 57057408 1 EA HOSE ASSY
028 35316405 1 EA VALVE, POPPET---ANTIRUMBLE
029 95364972 1 EA FITTING, HYD
030 95282422 1 EA ADAPTER
031 95381158 1 EA FITTING, HYD
032 95049359 1 EA PLUG, PIPE---1/8 HEXSOCKET
033 95279451 1 EA FITTING, HYD
034 95316972 1 EA FITTING, HYD---NPT/JIC
035 95209094 5 EA FITTING, HYD
036 95341079 1 EA FITTING, HYD
038 58160458 1 EA BRACKET, MOUNTING
039 95293403 3 EA FITTING, HYD

page 259 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57096067 COMP.CONT.P.---UL88/HR2

REF. PART NO. QTY. UNIT DESCRIPTION

040 95917696 2 EA SCREW,FLAT HD---1/4---20X3/4

COMP.CONT.P.---UL88/HR2
041 95931564 6 EA NUT, HEX---1/4---20
042 95934766 6 EA WASHER, LOCK---1/4 PLATED
044 52187465 1 EA FITTING, HYD
045 95033593 3 EA PLUG, PIPE---1/4 SQ HEAD
047 95219713 1 EA FITTING, HYD
048 95655064 1 EA ADAPTER, INT NPT/O---RING
049 95323481 1 EA FITTING HYD
050 95423331 1 EA FITTING,HYD
051 52231818 1 EA BRACKET
053 52231792 2 EA U---BOLT
054 95264941 2 EA FITTING, HYD
056 35306984 1 EA ORIFICE, .09
057 95920674 2 EA SCREW, CAP---3/8---16 X 1
058 95922894 2 EA NUT, HEX---3/8---16
062 95323465 2 EA PLUG HEAD
063 95329975 2 EA FITTING, HYD
065 52227733 2 EA LINKAGE

57096067
066 95862876 2 EA NUT, HEX---3/8---24
067 95213401 4 EA WASHER, LOCK---3/8 EXT.
068 52208162 1 EA LINK
069 95033932 1 EA PIN, ROLL---3/16 X 1---1/4
070 95365078 1 EA FITTING, HYD
071 56947534 1 EA FITTING, HYD
072 50462845 1 EA TIE ROD
95098356 2 EA D NUT, HEX JAM---3/8---24
073 50704147 1 EA SCREW
074 95201331 1 EA NUT, HEX JAM---1/2---13
075 35272558 2 EA SCREW, HEX---M20 X 45
076 50759455 2 EA WASHER, LOCK M20
077 52264926 2 EA BOLT 12MM
078 95081824 2 EA WASHER, LOCK---1/2
079 50527332 1 EA SUB 57294944---VALVE KIT
080 95221065 1 EA TEE, SERVICE
081 95279493 1 EA FITTING, HYD
082 57100091 1 EA BLOCK, VALVE---BUTTERFLY
57100117 1 EA D CHAIN,MACH.
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 260
 Serial Number: 4133
FAMILY,DM50

57096067 COMP.CONT.P.---UL88/HR2

REF. PART NO. QTY. UNIT DESCRIPTION

58148446 6.75 IN D CHAIN

COMP.CONT.P.---UL88/HR2

57100125 1 EA D BAR,SQ.
083 49833478 1 EA FITTING, HYD
57096067

page 261 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57096067 COMP.CONT.P.---UL88/HR2

COMP.CONT.P.---UL88/HR2
57096067

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 262
 Serial Number: 4133
FAMILY,DM50

57530917 REGULATOR ASSY, UL---88

COMP.CONT.P.---UL88/HR2

--- Power Chamber

--- Metering Chamber

A
1
--- Pilot Chamber
2 3

4
57096067

SECTION A-- A

Figure 130 :REGULATOR ASSY, UL--- 88

C57530917 REV00
page 263 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57530917 REGULATOR ASSY, UL---88

REF. PART NO. QTY. UNIT DESCRIPTION

001 36887396 1 EA REGULATOR, UL---88 ASSY

COMP.CONT.P.---UL88/HR2
36037471 0 EA D KIT, REPAIR UL---88 ASSY
002 50527308 1 EA SCREW, STOP
003 95077798 1 EA NUT, HEX---1/2---13
004 95033965 1 EA PIN,ROLL

57096067

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 264
 Serial Number: 4133
FAMILY,DM50

57085821 COMP.REC.P.---HR2 AIR END

COMP.REC.P.---HR2 AIR END

3 5
2
9 4
57085821

2
10 1
7 6
8

Figure 131 :COMP.REC.P.--- HR2 AIR END

C57064784 REV 05
page 265 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57085821 COMP.REC.P.---HR2 AIR END

REF. PART NO. QTY. UNIT DESCRIPTION

001 57064776 1 EA ADAPTER

COMP.REC.P.---HR2 AIR END

002 50428564 2 EA CLAMP, HOSE
003 95033619 1 EA PLUG, PIPE---1/2 SQ HEAD
004 95033619 1 EA PLUG, PIPE---1/2 SQ HEAD
005 36843720 1 EA VALVE, CHECK
006 95225116 2 EA GASKET RING
007 35292135 8 EA SCREW, CAP---METRIC
008 95081790 8 EA WASHER, LOCK---5/8
009 57137986 17.50 IN HOSE, AIR---U48 BULK
010 95033619 1 EA PLUG, PIPE---1/2 SQ HEAD

57085821

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 266
 Serial Number: 4133
FAMILY,DM50

52187507 RECEIVER ASSEMBLY

RECEIVER ASSEMBLY

8
14
7 12

9
1

16 6
52187507

15
4 13 --- Torque to
353---380ft/lbs
18 10 dry
8 11
5
17

Figure 132 :RECEIVER ASSEMBLY

D52187507 REV04
page 267 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52187507 RECEIVER ASSEMBLY

REF. PART NO. QTY. UNIT DESCRIPTION

001 57159212 1 EA TANK, OIL SEPARATOR

RECEIVER ASSEMBLY
002 57101636 1 EA ELEMENT, OIL SEPARATOR
57212409 1 EA D GASKET---SEPR ELEMENT
003 35516749 1 EA GAUGE, SIGHT
004 95243234 1 EA NIPPLE, PIPE
005 50829605 1 EA VALVE, BALL---1/2”
006 95653317 2 EA FITTING, HYD
007 52263712 1 EA NAMEPLATE
008 95064192 6 EA SCREW,DRIVE---#6 X 1/4
009 95042289 1 EA O---RING
010 30382519 1 EA PLATE
011 95081808 18 EA WASHER, LOCK---3/4
012 30395610 1 EA PLUG
013 95104667 18 EA SCREW, CAP---3/4---10 X 3
014 52202058 38.00 GL OIL, COMPRESSOR
015 57085128 1 EA STEM,HOSE
016 50412899 1 EA GASKET
017 95373585 4 EA SCREW, CAP---5/8---11X1.75

52187507
018 95081790 4 EA WASHER, LOCK---5/8

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 268
 Serial Number: 4133
FAMILY,DM50

57080616 PIPING, RECEIVER

Receiver Tank

3
1
PIPING, RECEIVER

To Comp
Gauge 2
35
34 36
2 37
12
19 29
21 7
27 8
31 9
HR2 26 22 20
Air End 23
Discharge 28 12
11

10 5

13
24 32 14

33 6
57080616

Figure 133 :PIPING, RECEIVER

C57080616 REV 04
page 269 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57080616 PIPING, RECEIVER

REF. PART NO. QTY. UNIT DESCRIPTION

001 95038212 1 EA BUSHING, PIPE---REDUCING

PIPING, RECEIVER
002 95242996 2 EA NIPPLE,PIPE---1---1/2 X 2
003 95532271 1 EA UNION,PIPE---1---1/2 NPT
005 95038170 1 EA BUSHING, PIPE---REDUCING
006 56957798 1 EA HOSE ASSY
007 95103875 2 EA SUB 95935151---CAPSCREW,HEX
008 95922894 2 EA NUT, HEX---3/8---16
009 95937413 2 EA WASHER, LOCK---3/8 PLATED
010 52172723 1 EA VALVE, MANUAL SHUTOFF
011 95097317 1 EA NIPPLE, PIPE
012 95279402 2 EA ELBOW, 90DEG MALE 37DG FL
013 35517234 1 EA ORIFICE
014 35132299 1 EA SILENCER
019 56974223 1 EA HOSE ASSY
020 35849215 1 EA VALVE, AUTO BLOWDOWN
021 50621986 1 EA VALVE, SAFETY
022 95293403 1 EA FITTING, HYD
023 95219713 1 EA FITTING, HYD

57080616
024 95219739 1 EA FITTING, HYD
026 95446480 1 EA CROSS, PIPE---1---1/2 NPT
027 95037438 1 EA BUSHING, PIPE
028 95038170 1 EA BUSHING, PIPE---REDUCING
029 95061123 1 EA NIPPLE,PIPE
031 57079204 1 EA VALVE, PILOT OPERATED
57379984 1 EA D SEAL KIT, VITON
032 57043804 1 EA HOSE ASSY
033 95263380 1 EA FITTING, HYD---NPT/JIC
034 95329975 1 EA FITTING, HYD
035 95775623 1 EA FITTING, HYD
036 95317426 1 EA ADAPTER,90DEG,EXT/EXT NPT
037 50622273 1 EA VALVE, RELIEF

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 270
 Serial Number: 4133
FAMILY,DM50

57098907 REC---TOWER P.
REC---TOWER P.
57098907

20
TO BIT AIR PRESSURE
GAUGE (BULK HEAD
FITTING #21)
OPERATORS CAD

1 HOSE IS ROUTED UNDER

3 POWER PACK
2

Figure 134 :REC--- TOWER P.

E57098907 REV 07
page 271 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57098907 REC---TOWER P.

REC---TOWER P.
5

8
23
7

12
13

14 9

15
10

RECEIVER TANK
11
16 25

18
26

57098907
9

19

21

22

20

Figure 135 :REC--- TOWER P.

E57098907 REV 07
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 272
 Serial Number: 4133
FAMILY,DM50

57098907 REC---TOWER P.

REF. PART NO. QTY. UNIT DESCRIPTION

001 95313961 248.00 IN HOSE,AIR---R32 BULK

REC---TOWER P.

002 57323826 1 EA HOSE, AIR

003 50743731 4 EA CLAMP, HOSE
004 52223666 1 EA VALVE, THROTTLE---INSTL (See figure 136)
005 50023910 1 EA STEM
007 57391047 1 EA VALVE,MIN.PRESSURE
57514846 1 EA D KIT---REPAIR
008 95238523 1 EA ELBOW, STREET
009 95007886 2 EA TEE
010 95242624 1 EA NIPPLE, PIPE
011 95243200 1 EA NIPPLE PIPE
012 95038261 1 EA BUSHING, PIPE
013 95238515 1 EA ELBOW, 90 DEG STREET
014 95209862 1 EA NIPPLE, PIPE
015 50829605 1 EA VALVE,BALL---1/2
016 57442477 1 EA REGULATOR, PRESSURE
50603869 1 EA D SERVICE KIT
018 95033601 1 EA PLUG, PIPE---3/8 SQ HEAD
57098907

019 95221107 1 EA FITTING, HYD

020 57025926 1 EA HOSE ASSY
021 95775623 1 EA FITTING, HYD
022 95317426 1 EA ADAPTER, 90DG---EXT/EXTNPT
023 95436747 1 EA NIPPLE
025 95315214 1 EA FITTING, HYD
026 95302733 1 EA FITTING

page 273 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57098907 REC---TOWER P.

REC---TOWER P.
57098907

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 274
 Serial Number: 4133
FAMILY,DM50

52223666 VALVE, THROTTLE ---INSTL

3
REC---TOWER P.

2 BOLT
BRAZE ALL
AROUND

10

7
11
8 15

14
12 13
57098907

1 5
9

15

Figure 136 :VALVE, THROTTLE--- INSTL

V52223666 REV 03
page 275 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52223666 VALVE, THROTTLE ---INSTL

REF. PART NO. QTY. UNIT DESCRIPTION

001 52158714 1 EA VALVE, AIR---2 WAY (See figure 137)

REC---TOWER P.
002 95104147 1 EA SCREW, CAP---1/2---13 X 1
003 50135888 1 EA KNOB
004 95097333 1 EA NIPPLE
005 95033593 2 EA PLUG, PIPE---1/4 SQ HEAD
007 50626977 2 EA BRACKET---THRTLE VLV MTG
008 52223690 1 EA MANIFOLD
95048559 1 EA D NIPPLE
95446522 2 EA D COUPLING
009 50195718 2 EA U BOLT
010 95937413 4 EA WASHER, LOCK---3/8 PLATED
011 95922894 4 EA NUT, HEX---3/8---16
012 50058072 1 EA VALVE STOP D
013 95934857 1 EA SCREW, CAP---1/4---20 X1---1/4
014 95934766 1 EA WASHER, LOCK---1/4 PLATED
015 95031316 2 EA ELBOW, PIPE

57098907

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 276
 Serial Number: 4133
FAMILY,DM50

52158714 VALVE, AIR ---2 WAY

REC---TOWER P.

2
5 15
3

14

7
1
6

8
57098907

Figure 137 :VALVE, AIR--- 2 WAY

D52158714 REV 01
page 277 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52158714 VALVE, AIR ---2 WAY

REF. PART NO. QTY. UNIT DESCRIPTION

001 50308758 1 EA DISC, VALVE

REC---TOWER P.
002 50370808 1 EA BODY, VALVE
003 50308766 2 EA CAP, VALVE
004 50622463 1 EA SPINDLE, VALVE
005 50730613 1 EA HANDLE, VALVE
006 95086682 1 EA O---RING
007 50555697 1 EA SPRING, DISC
008 95097713 1 EA O---RING
014 95079984 1 EA SCREW, CAP---5/16---18X1---1/4
015 95935136 6 EA SCREW, CAP---3/8---16 X2---3/4

57098907

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 278
 Serial Number: 4133
FAMILY,DM50

HYDRAULIC SYSTEM
SECTION
HYDRAULIC SYSTEM

page 279 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
HYDRAULIC SYSTEM

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 280
 Serial Number: 4133
FAMILY,DM50

57297178 MAIN HYD DRV---CAT3412

18
Torque to 19 2
18
75 ft/lb 19
Torque to 20
90 ft/lb 10
28 12
MAIN HYD DRV---CAT3412

8
26
Use approximately
8 9 quarts of gear oil 22
26 2
1 11 21
12
23
24
18
10 19
12 20

5
57297178

25
21 29
13 30
14
9 1
28

NOTE:
The slip splines and U ---joints must
be lubricated through grease 5
fittings provided on the drive shaft
using a lithium soap base grease
meeting the NLGI grade 1 or grade
2 specifications.
3
6
31 ---NOT SHOWN 8
32 ---NOT SHOWN

Figure 138 :MAIN HYD DRV--- CAT3412

E57114464 REV 03
page 281 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57297178 MAIN HYD DRV---CAT3412

REF. PART NO. QTY. UNIT DESCRIPTION

001 57367179 1 EA GEARBOX --- 4 HOLE (See figure 139)

MAIN HYD DRV---CAT3412

002 50421213 1 EA PUMP, HYDRAULIC (See figure 141)
003 95934659 4 EA SCREW,CAP,HEX
005 50626605 2 EA BRACKET
006 95922902 4 EA NUT,HEX,FINISHED,PLATED
008 95934733 12 EA WASHER,LOCK
009 57273765 1 EA GUARD, DRIVESHAFT
010 95335345 8 EA SCREW,CAP
011 95929089 4 EA SCREW,CAP,HEX
012 95934741 12 EA WASHER,LOCK HELICAL
013 95934170 4 EA SCREW,CAP,HEX
014 95080206 4 EA NUT, HEX LOCK---5/8---11
018 95934659 4 EA SCREW,CAP,HEX
019 95934733 4 EA WASHER,LOCK
020 57058356 1 EA PUMP,DOUBLE HYDRAULIC (See figure 142)
021 52247111 2 EA PUMP, HYDRAULIC
52245065 1 EA D PUMP,HYDRAULIC (See figure 144)
57425415 1 EA D ALTERATION INSTRUCTION
022 50416544 9.00 GL OIL, GEAR

57297178
023 95922415 12 EA WASHER,FLAT,PLAIN
024 95065868 4 EA SCREW, SET---1/2---13 X 1/2
025 56986599 2 EA WASHER
026 95215257 8 EA CAPSCREW,HEX
028 57368524 1 EA DRIVE SHAFT
57227787 0 EA D CROSS KIT
029 95250692 1 EA DRAIN COCK
030 57173692 1 EA ADAPTERENGINE/DRIVESHAFT
031 95934592 8 EA SCREW,CAP,HEX
032 95937413 8 EA WASHER,LOCK,HELICAL

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 282
 Serial Number: 4133
FAMILY,DM50

57367179 GEARBOX --- 4 HOLE

8
MAIN HYD DRV---CAT3412

7 7

8
8

9 11 31 14
30 16

28 29
28

30

9 9
57297178

4
31 11
11 31

Figure 139 :GEARBOX --- 4 HOLE

E57367179 REV 01
page 283 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57367179 GEARBOX --- 4 HOLE

3 NOT SHOWN
34 NOT SHOWN

MAIN HYD DRV---CAT3412

29
28

27

21

23

25

22
24

57297178
26

33 8

20

Figure 140 :GEARBOX --- 4 HOLE

E57367179 REV 01
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 284
 Serial Number: 4133
FAMILY,DM50

57367179 GEARBOX --- 4 HOLE

REF. PART NO. QTY. UNIT DESCRIPTION

001 57367302 1 EA HOUSING --- GEARBOX

MAIN HYD DRV---CAT3412

003 57367310 16 EA BOLT, ADAPTER

004 57367328 1 EA PLUG, PIPE
005 59514976 1 EA PLUG, MAGNETIC
007 50817618 4 EA GEAR, 56T
008 59904268 8 EA BEARING --- PUMP DRIVE
009 59572917 2 EA ADAPTER,SAE B
011 50597624 2 EA ADAPTER, SAE C
014 50597434 2 EA O---RING
016 57367344 2 EA O---RING
020 57367583 1 EA GEAR, PINION
021 57198111 1 EA ADAPTER, INPUT SHAFT
022 50597459 1 EA SUB 95223475---RING,RETAIN
023 50597442 1 EA RING,SNAP
024 57153793 1 EA INPUT SHAFT
025 95200663 1 EA BEARING
026 57171928 1 EA SEAL,OIL
027 57367369 1 EA ELBOW, 90 DEGREE
57297178

028 57367377 1 EA BUSHING, REDUCER

029 59677831 1 EA BREATHER
030 52143195 1 EA SLEEVE, ADAPTER
031 59516096 2 EA SLEEVE,SPLINE
033 57171910 1 EA BEARING
034 57367385 1 EA BEARING

page 285 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57367179 GEARBOX --- 4 HOLE

MAIN HYD DRV---CAT3412

57297178

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 286
 Serial Number: 4133
FAMILY,DM50

50421213 PUMP, HYDRAULIC

32 ---KIT,CARTRDGE
33 ---KIT,SEAL
99 ---KIT,SEAL
MAIN HYD DRV---CAT3412

20 21 22
23
19 27
26

3 4 5 6 7
2 24
25

1 17 18 28
11 12 13 14 15 16
8 9 10
31
29 30
57297178

Figure 141 :PUMP, HYDRAULIC

W50421213 REV 003
page 287 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50421213 PUMP, HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

001 50477926 4 EA SCREW

MAIN HYD DRV---CAT3412

002 50816909 1 EA PLATE,ROTAT
003 50559848 2 EA SCREW
004 50747310 1 EA VALVE,PLATE
005 50293737 2 EA PIN
006 50446327 1 EA BEARING
007 50816925 1 EA GASKET
008 50446343 1 EA RING,SNAP
009 50446350 1 EA LIMITER,LIFT
010 50446368 1 EA SPRING
011 50816933 1 EA WASHER,THRST
012 50816941 1 EA BLOCK
013 50446392 3 EA PIN
014 50446400 1 EA WASHER
015 50447333 1 EA WASHER,SPR
016 50447341 1 EA PLATE,SHOE
017 50816958 1 EA KIT,PISTON
018 50447366 1 EA PLATE,SWASH
019 50816966 1 EA HOUSING

57297178
020 50559913 1 EA PLATE
021 50559848 2 EA SCREW
022 50559848 2 EA SCREW
023 50560077 1 EA NAMEPLATE
024 50816974 1 EA O---RING
025 50318534 1 EA PLUG
026 50816982 1 EA SEAL,SHAFT
027 50560135 1 EA SPACER
028 50721174 1 EA SHAFT
029 50447374 1 EA BEARING
030 50559830 1 EA RING,SNAP
031 50005909 1 EA RING,SNAP
032 50427699 1 EA KIT,CARTRDGE
033 50823707 1 EA KIT,SEAL
099 50427699 0 EA KIT,CARTRDGE

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 288
 Serial Number: 4133
FAMILY,DM50

57058356 PUMP,DOUBLE HYDRAULIC

MAIN HYD DRV---CAT3412

26

16 20
18
16 21 7 15 14 19
14 15 17 8 10 12 6 11

27
57297178

SHOWN 45˚ OUT

OF POSITION

22
21 17 9 24 2
25 13 18 3

Figure 142 :PUMP,DOUBLE HYDRAULIC

B57058356 REV 003
page 289 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57058356 PUMP,DOUBLE HYDRAULIC

23 23

MAIN HYD DRV---CAT3412

12 OR 10 25 25
12 10

24
6 OR 7 24

6
7

23 11 11
8 8
5

15
14 24
13 9

16 24 5

57297178
5
15 15

14 14

16 16

FRONT PORT REAR PORT

(P1) (P2)

28 SEAL KIT (NOT SHOWN) 30 P1 CARTRIDGE ASSEMBLY

CONSISTES OF (NOT SHOWN) CONSISTS OF
ITEMS 14, 16, 17, 18 AND 19 ITEMS 5, 6, 12, 14 AND 16

29 SHAFT KIT (NOT SHOWN) 31 P2 CARTRIDGE ASSEMBLY

CONSISTS OF (NOT SHOWN) CONSISTS OF
ITEMS 4 AND 26 ITEMS 5, 7, 10, 14 AND 16

Figure 143 :PUMP,DOUBLE HYDRAULIC

B57058356 REV 003
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 290
 Serial Number: 4133
FAMILY,DM50

57058356 PUMP,DOUBLE HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

001 57191991 1 EA END CAP

MAIN HYD DRV---CAT3412

002 57192007 1 EA HOUSING

003 57192015 1 EA MOUNTING CAP
004 57192213 1 EA SHAFT, SPLINED #3
005 57185217 2 EA PRESSURE PLATE
006 57419939 1 EA CAM RING
007 57192080 1 EA CAM RING
008 57192098 20 EA VANE
009 57192163 1 EA P2 ROTOR ASSY.
010 54494026 1 EA PLATE,PORT,REAR
011 57192106 20 EA VANE PIN
012 54494018 1 EA PLATE,PORT,FRONT
013 57192122 1 EA P1 ROTOR ASSY.
014 50815851 2 EA SEAL,SQ SECT
015 57192130 2 EA BACK UP RING
016 57192148 2 EA SQUARE SECTION GASKET
017 57307720 1 EA GASKET,SQ.SECTION
018 57192197 1 EA O---RING
57297178

019 50495860 1 EA SEAL SHAFT

020 50644558 1 EA RING SNAP
021 57192023 7 EA CAPSCREW
022 57045494 4 EA CAP
023 50816271 4 EA SCREW
024 50604479 4 EA DOWEL PIN
025 50816289 2 EA PIN
026 50632538 1 EA BEARING BALL
027 50806223 2 EA RING,SNAP
028 57032997 1 EA KIT,SEAL
029 57053555 1 EA KIT, SHAFT
030 57150278 1 EA CAM ASSEMBLY
031 57053522 1 EA CAM ASSEMBLY (14)

page 291 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57058356 PUMP,DOUBLE HYDRAULIC

MAIN HYD DRV---CAT3412

57297178

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 292
 Serial Number: 4133
FAMILY,DM50

52245065 PUMP,HYDRAULIC

Torque to
30 ft/lb
MAIN HYD DRV---CAT3412

21
19 23
21 22
1
2 20

25

24

18

12
57297178

16
17

Figure 144 :PUMP,HYDRAULIC

E52226834 REV 010
page 293 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52245065 PUMP,HYDRAULIC

15

MAIN HYD DRV---CAT3412

14

13

12

11

57297178
10

Figure 145 :PUMP,HYDRAULIC

E52226834 REV 010
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 294
 Serial Number: 4133
FAMILY,DM50

52245065 PUMP,HYDRAULIC
MAIN HYD DRV---CAT3412

10

11

3 8
57297178

4
5
6
7

Figure 146 :PUMP,HYDRAULIC

E52226834 REV 010
page 295 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52245065 PUMP,HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

001 57480386 1 EA SERVO, PUMP---INPUT,MANUAL (See figure 147)

MAIN HYD DRV---CAT3412

002 57300212 1 EA DRIVE SHAFT ASSY
57300220 1 EA D SHAFT, MOTOR
54407317 1 EA D BEARING
52155751 2 EA D RING, RETAINING
003 57026403 1 EA RING,RETAING
004 57026411 1 EA RING,RETAING
005 57026429 1 EA RING,RETAING
006 52204864 1 EA RING,RETAINING
007 52204872 1 EA RING,RETAINING
008 52204856 1 EA WASHER,THRUST
009 57026478 1 EA PLATE,CREEP
010 57123283 1 EA CAM STROKER ASSY (See figure 148)
011 52218690 1 EA PIST/SHOEASY
012 52201696 1 EA BARRL/SLEEVE
013 52201712 1 EA FACEPLATE, BARREL---13/32
014 52155033 1 EA GASKET, HOUSING
015 57026395 1 EA BEARING, BARREL
016 52201845 1 EA PLATE, PORT---RH 13/32

57297178
017 52154952 1 EA GASKET
018 52163474 1 EA GEROTOR ASSY
019 52233145 1 EA VALVE BLOCK
020 57153090 1 EA KIT---SHIM
021 52154515 1 EA SEAL, SHAFT
022 52154531 1 EA GASKET, RETAINING
023 52154499 1 EA GASKET
024 52154622 4 EA WASHER, NYLITE
025 57052631 1 EA SERVO OUTPUT (See figure 149)

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 296
 Serial Number: 4133
FAMILY,DM50

57480386 SERVO, PUMP---INPUT,MANUAL

MAIN HYD DRV---CAT3412

B C

A A

B C
57297178

2
6 29 1 27 28 19
9
11 7
21 26
22 10 8
20 31

26

4
24 5

18 14 23
12 SECTION A ---A
13
15
3 SECTION C---C

SECTION B---B

Figure 147 :SERVO, PUMP--- INPUT,MANUAL

D57480386 REV 00
page 297 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57480386 SERVO, PUMP---INPUT,MANUAL

REF. PART NO. QTY. UNIT DESCRIPTION

001 52201746 1 EA SHAFT LINK

MAIN HYD DRV---CAT3412

002 54407390 4 EA SCREW
003 57239725 1 EA NUT,ACORN
004 52201803 1 EA RING,RETAING
005 54407416 1 EA O---RING
006 52154622 4 EA WASHER, NYLITE
007 95097689 2 EA O---RING
008 57153108 1 EA SHEAR SEAL
009 54407457 3 EA WASHER,THRUST
010 52201811 1 EA PIPE PLUG
011 54407499 1 EA COVER
012 57305948 1 EA PIN---PUMP
013 54407580 1 EA SCREW,ADJ
014 54407606 1 EA PIN
015 57104929 1 EA NUT, JAM
018 54407630 2 EA SPOOL,CENT LUBE GROOVES
019 54407481 1 EA WASHER,THRUST
020 57240566 2 EA SPRING
021 52154937 2 EA O---RING

57297178
022 57240574 2 EA PLUG
023 57239717 2 EA SCREW, SET
024 57104937 2 EA NUT, JAM
026 52155454 2 EA PIN
027 52201779 2 EA WASHER
028 52201761 1 EA SEAL,SHEAR
029 57417339 1 EA SERVO---CONT.COVER GASKET
031 57104895 2 EA COVER, NUT

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 298
 Serial Number: 4133
FAMILY,DM50

57123283 CAM STROKER ASSY

MAIN HYD DRV---CAT3412

13
14 23

25
8
9
6
20
7
6

19
7 17
24
16
18
26 15
27 30 22
57297178

28 29

12
21
11 10

Figure 148 :CAM STROKER ASSY

C54410741 REV 000
page 299 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57123283 CAM STROKER ASSY

REF. PART NO. QTY. UNIT DESCRIPTION

006 57240749 2 EA SCREW, MOTOR

MAIN HYD DRV---CAT3412

007 52201738 1 EA SERVO PLATE
008 52155256 2 EA SCREW
009 57240764 1 EA PLATE, MOTOR
010 54408331 4 EA SCREW
011 54408349 4 EA SCREW
012 54408356 4 EA SCREW
013 52155306 5 EA PLUG
014 52155314 5 EA O---RING
015 52155330 1 EA COVER,CONTROL
016 52155348 4 EA PIN
017 54408364 2 EA CONTROL CHAMBER
018 52155363 2 EA SEAL
019 52155371 4 EA BALL
020 52203718 1 EA CRADLE
021 57064065 8 EA VANE HOLD DOWN SPRING
022 57181307 4 EA HOLD DOWN---VANE
023 52155322 1 EA COVER
024 54408406 1 EA ROCKER AND PLUG

57297178
025 57240756 2 EA SCREW, SET
026 54408372 4 EA PLATE,SEAL VANE
027 54408380 2 EA SEAL VANE
028 52203767 2 EA O---RING
029 54408398 2 EA SPACER,VANE
030 57150617 2 EA CHECK VALVE

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 300
 Serial Number: 4133
FAMILY,DM50

57052631 SERVO OUTPUT

12
17
B
MAIN HYD DRV---CAT3412

A A

15
B
57297178

9
1 13 14 19 7

11 8

10

2
6 5 4

SECTION B---B SECTION A ---A

Figure 149 :SERVO OUTPUT

C57052631 REV 000
page 301 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57052631 SERVO OUTPUT

REF. PART NO. QTY. UNIT DESCRIPTION

001 54409123 1 EA SERVO SHAFT ASSY

MAIN HYD DRV---CAT3412

002 54407390 4 EA SCREW
004 52201803 2 EA RING,RETAING
005 54407416 1 EA O---RING
006 52154622 4 EA WASHER, NYLITE
007 95097689 2 EA O---RING
008 57153108 1 EA SHEAR SEAL
009 54407457 3 EA WASHER,THRUST
010 52201811 1 EA PIPE PLUG
011 57151144 1 EA COVER
012 54407473 1 EA INDICATOR
013 52201779 2 EA WASHER
014 52201761 1 EA SEAL,SHEAR
015 57417339 1 EA SERVO---CONT.COVER GASKET
017 57240756 1 EA SCREW, SET
019 54407481 1 EA WASHER,THRUST

57297178

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 302
 Serial Number: 4133
FAMILY,DM50

57348930 HYD TANK PIPING ---DM45/50

3
4
5
32
36 FILLER PLUG
HYD TANK PIPING---DM45/50

60
WATER INJECTION
39
MOTOR RETURN
WATER INJECTION FLOW 39
CONTROL VALVE RETURN 8
59
FAN PUMP 86
RELIEF RETURN
43

30 FILLER PLUG
85

FEED & ROTATION

11 38 VALVE RETURN

FEED SELECTION 40 FROM 9 SPOOL VALVE

78 RETURN 37
VALVE RETURN
52 FROM “B” PORT
OF AMOT VALVE
39
57348930

9
29 10

85 VENT MANIFOLD BEFORE FILLER CAP

DISCONNECTING HOSE 19
20 59
67 81 60
97
83 15 17
82 25
18
84 31
31
28 21
28 14 65 PSI
17
70 13
71 79 DOUBLE 16
PUMP 58
SUCTION
72 35 34
SLOW FEED 33
PUMP SUCTION
34 1 79
2

Figure 150 :HYD TANK PIPING--- DM45/50

E57348930 REV 02
page 303 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57348930 HYD TANK PIPING ---DM45/50

54

HYD TANK PIPING---DM45/50

7 26
3 6
4 CYLINDER
5 RETRACTED

27

DRAIN MANIFOLD BEFORE

DISCONNECTING HOSES 64

47

57348930
23
10 51
63
MAIN PUMPS
CASE DRAIN 92 61 46 ATM--- 13 ATM--- 7
24
RETURN
PORTS 45 IN OUT
65 91 49 50
48
PUMP RETURN

ATM---13
TO TANK
DRILL FEED

76
50
49

57
96
41 41

65 94
PROPEL MOTOR
65 HYD. TANK 12
CASE DRAIN 12 DRAIN
RETURN PORTS 93 95

ROTATION MOTOR
CASE DRAIN RETURN
PORTS

Figure 151 :HYD TANK PIPING--- DM45/50

E57348930 REV 02
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 304
 Serial Number: 4133
FAMILY,DM50

57348930 HYD TANK PIPING ---DM45/50

66 ---FITTING,HYD
87 ---FITTING,HYD
88 ---FITTING,HYD
HYD TANK PIPING---DM45/50

HIGH PRESSURE RELIEF VALVE MOUNTED

MAGNETIC FILTER RETURN PORT ON TOWER SUPPORT “T” PORT ATM--- 3 MAIN PUMPS AUX. SUCTION PORTS
ATM--- 7
COOLER FAN MOTOR CASE
DRAIN ATM--- 8

DUST COLLECTOR MOTOR

CASE DRAIN PORT ATM--- 14
RELIEF VALVE
RETURN 2 SPEED
FAN OPTION MAIN
PUMPS PILOT PRESS
RETURN PORT ATM6

42 FILTER RETURN
NO BUMP ROD CHANGER
DECELERATING VALVE FROM FEED PUMP
ATM6 CASE DRAIN
ATM--- 13 RETURN
AUTO BREAKOUT 22 FROM FEED
DECLARATION VALVE
PRESSURE REDUCING
VALVE “R” PORT AUTO 23 (NO BUMP OPTION)
ROD SUPPORT VALVE
“T” PORT ATM--- 4
80 43 42 TOWER LOCK PRESSURE
REDUCING VALVE PORT
CONSOLE DRILL “R” HOIST VALVE PORT
PROPEL VALVE PORT #1
ATM--- 2 PRESSURE
42 “T” ATM--- 12
REDUCING VALVE PORT
“R” FOR PRESSURE
57348930

MANIFOLD
OVER PRESSURE CONTROL
CONSOLE FEED SYSTEM VALVE RETURN PORT
RELIEF VALVE PORT “T”

SUPER CHARGE GAGE PORT SUCTION MANIFOLD SUP --- 2

MAIN PUMP INLET

OVERPRESSURE CONTROL
VALVE RETURN PORT PROPEL CIRCUIT SUPER CHARGE PRESSURE

MAIN PUMP INLET SUP10 2--- SPEED FAN PILOT

PROPEL CIRCUIT SUPER CHARGE PRESSURE

RETURN MANIFOLD FILTER PORT SUP 8

Figure 152 :HYD TANK PIPING--- DM45/50

E57348930 REV 02
page 305 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57348930 HYD TANK PIPING ---DM45/50

REF. PART NO. QTY. UNIT DESCRIPTION

001 57173957 1 EA RESERVOIR, HYDRAULIC (See figure 153)

HYD TANK PIPING---DM45/50

002 52223781 150.00 GL OIL, HYDRAULIC
003 95053047 14 EA SCREW,CAP---HEX1/2---13X1.25
004 95081824 14 EA WASHER, LOCK---1/2
005 95077798 14 EA NUT, HEX---1/2---13
006 57431983 1 EA MANIFOLD,RETURN SAEPORTS
007 50348804 1 EA PLATE
008 52254885 1 EA FILTER, HYDRAULIC (See figure 155)
009 95920674 8 EA SCREW, CAP---3/8---16 X 1
010 95937413 10 EA WASHER, LOCK---3/8 PLATED
011 50691658 1 EA MANIFOLD
012 50630656 1 EA FILTER, MAGNETIC (See figure 157)
013 50247691 1 EA STRAINER, OIL
014 50261825 2 EA VALVE, CHECK
015 50247733 1 EA VALVE, CHECK
016 50463454 1 EA THERMOMETER
017 50364199 2 EA FITTING, TUBE
018 50247709 1.00 IN TUBING, VINYL

57348930
019 50903236 1 EA BREATHER
020 95038105 1 EA BUSHING, PIPE---REDUCING
021 50811173 1 EA VENT
022 95326955 1 EA PLUG W/O RNG
023 95640074 1 EA NIPPLE,PIPE
024 57167132 1 EA DISCONNECT
025 50829704 1 EA DECAL, VENT MANIFOLD
026 50810993 1 EA DECAL, HYD.OIL LEVEL
027 50829712 1 EA DECAL, DRAIN MANIFOLD
028 95404323 2 EA PLUG, PIPE---2 SQ C’SUNK
029 50691831 1 EA NIPPLE
030 95663803 1 EA FITTING, TUBE
031 95219770 3 EA FITTING, HYD
032 57093775 1 EA PLUG, MINI
033 95356986 1 EA FITTING, HYD
034 50691690 3 EA ADAPTER
035 56950454 1 EA HOSE ASSY
036 57094526 1 EA PLUG, VENT
95735346 1 EA D FITTING, HYD
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 306
 Serial Number: 4133
FAMILY,DM50

57348930 HYD TANK PIPING ---DM45/50

REF. PART NO. QTY. UNIT DESCRIPTION

037 95280186 1 EA FITTING, HYD

HYD TANK PIPING---DM45/50

038 95357604 1 EA ADAPTER, 90DEG---ORING/JIC

039 95664934 5 EA PLUG, 1---1/16---12
040 95356960 1 EA FITTING, HYD
041 52217874 1 EA SEPARATOR (See figure 158)
042 95343596 1 EA PLUG, WITH O---RING
043 95735346 2 EA FITTING, HYD
045 95049292 1 EA NIPPLE PIPE
046 57420846 1 EA BRACKET, FILTER
047 95280152 1 EA ADAPTER, 45DEG---ORING/JIC
048 95038048 1 EA BUSHING
049 57044620 1 EA HOSE ASSY
050 95219754 2 EA FITTING, HYD
051 95702627 1 EA FITTING,HYD
052 95371217 1 EA FITTING
054 95280186 1 EA FITTING, HYD
057 56994569 1 EA HOSE ASSY
058 95315289 2 EA FITTING
57348930

059 56973027 1 EA HOSE ASSY

060 56956675 1 EA HOSE ASSY
061 95279428 1 EA FITTING, HYD
063 95920682 2 EA SCREW, CAP---3/8---16 X1---1/4
064 52223807 1 EA DECAL, HYDRAULIC OIL
065 95280186 8 EA FITTING, HYD
066 95431292 1 EA FITTING, HYD
067 95038154 1 EA BUSHING PIPE
070 95371241 1 EA ADAPTER, STR.---JIC/O---RING
071 95371209 1 EA ADAPTER,90DEG---O---RING/JIC
072 57044661 1 EA HOSE ASSY
076 95647806 1 EA FITTING, HYD
078 95357570 1 EA FITTING, HYD
079 95356986 1 EA FITTING, HYD
080 95303335 1 EA FITTING, HYD
081 95324273 1 EA FITTING, HYD
082 50261825 1 EA VALVE, CHECK
083 95219770 1 EA FITTING, HYD
084 57149353 1 EA HOSE ASSY.
page 307 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57348930 HYD TANK PIPING ---DM45/50

REF. PART NO. QTY. UNIT DESCRIPTION

085 95829362 1 EA FITTING, HYD

HYD TANK PIPING---DM45/50

086 95431292 1 EA FITTING, HYD
087 95280160 1 EA FITTING, HYD
088 95279105 3 EA FITTING, HYD
091 95647806 1 EA FITTING, HYD
092 95356960 1 EA FITTING, HYD
093 95219747 1 EA FITTING, HYD
094 52235363 1 EA BRACKET, OIL
95038766 1 EA D COUPLING
095 95002143 1 EA PLUG, PIPE---SQ HEAD, 3/4
096 57183832 1 EA HOSE ASSY
097 57352825 1 EA VALVE, RELIEF

57348930

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 308
 Serial Number: 4133
FAMILY,DM50

57173957 RESERVOIR, HYDRAULIC

15
16
HYD TANK PIPING---DM45/50

13
14

10

12
17
11
18

9
57348930

Figure 153 :RESERVOIR, HYDRAULIC

E57173957 REV 07
page 309 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57173957 RESERVOIR, HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

003 57173999 1 EA PLATE,BOTTOM (See figure 154)

HYD TANK PIPING---DM45/50

004 57173981 1 EA SUCTION MANIFOLD
005 57173965 1 EA REAR PLATE
006 57173973 1 EA FRONT SIDE PLATE
008 57306680 1 EA MANIFOLD---SUCTION
009 57350449 1 EA FILTER MNT BKT
010 95038410 1 EA CAP, PIPE---1---1/2
011 50820307 1 EA COVER TOP
012 57352304 1 EA MTG.PLATE---RV,HYD. TANK
013 95958963 8 EA SCREW,CAP---3/8---16 X 5/8
014 95265443 8 EA WASHER,LOCK---3/8
015 95104071 3 EA SCREW, CAP---1/4---20 X 5/8
016 95096350 3 EA WASHER, LOCK---1/4
017 50819192 1 EA GASKET
018 50819200 1 EA GASKET, TOP

57348930

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 310
 Serial Number: 4133
FAMILY,DM50

57173999 PLATE,BOTTOM
HYD TANK PIPING---DM45/50

List only, no drawing required.

57348930

Figure 154 :PLATE,BOTTOM

D57173999 REV 003
page 311 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57173999 PLATE,BOTTOM

REF. PART NO. QTY. UNIT DESCRIPTION

003 57179277 8 EA BOSS,SAE O---RING 9/16---18

HYD TANK PIPING---DM45/50

004 57132268 2 EA BOSS,O---RING
005 57132250 3 EA BOSS,O---RING
006 57348146 1 EA COUPLING SAE HALF

57348930

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 312
 Serial Number: 4133
FAMILY,DM50

52254885 FILTER, HYDRAULIC

1
HYD TANK PIPING---DM45/50

4
4

1
3 2
57348930

4
4

Figure 155 :FILTER, HYDRAULIC

D52254885 REV 03
page 313 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52254885 FILTER, HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

001 52259363 2 EA FILTER ASSY---HYD (See figure 156)

HYD TANK PIPING---DM45/50

002 52263530 2 EA MANIFOLD
003 52263548 1 EA MANIFOLD
004 52263555 1 EA O---RING
005 52263563 1 EA BOLT
006 52263571 1 EA NUT,LOCK

57348930

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 314
 Serial Number: 4133
FAMILY,DM50

52259363 FILTER ASSY---HYD

HYD TANK PIPING---DM45/50

11

8
4

5
57348930

10

Figure 156 :FILTER ASSY--- HYD

W52259363 REV02
page 315 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52259363 FILTER ASSY---HYD

REF. PART NO. QTY. UNIT DESCRIPTION

002 35277151 1 EA GLASS

HYD TANK PIPING---DM45/50

004 95070603 1 EA O---RING
005 57113367 1 EA VALVE,BY PASS
006 35251511 1 EA O---RING
007 52263183 1 EA ELEMENT, FILTER---MAIN HYD
008 35251529 1 EA HOUSING
009 50815638 1 EA BOLT
010 35251545 1 EA WASHER, GSKT
011 35251552 1 EA SPRING

57348930

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 316
 Serial Number: 4133
FAMILY,DM50

50630656 FILTER, MAGNETIC

HYD TANK PIPING---DM45/50

1
9
2

10
57348930

6 4
11

Figure 157 :FILTER, MAGNETIC

W348725 REV02
page 317 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50630656 FILTER, MAGNETIC

REF. PART NO. QTY. UNIT DESCRIPTION

001 95104170 4 EA SCREW, CAP---1/2---13 X1---1/2

HYD TANK PIPING---DM45/50

002 95081667 4 EA WASHER, FLAT---1/2
003 50815646 1 EA ALARM, DIRTY FILTER
004 50815653 1 EA ELEMENT, BUSHING
005 50343490 1 EA ELEMENT, FILTER---3 MICRON
006 50815661 1 EA MAGNET ASSY
007 50815679 1 EA SPRING PLATE
008 50709336 1 EA SPRING, COMPRESSION
009 50815695 1 EA O---RING
010 50815703 1 EA HOUSING, SINGLE ELEMENT
011 50815711 1 EA RING,RETAING

57348930

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 318
 Serial Number: 4133
FAMILY,DM50

52217874 SEPARATOR
HYD TANK PIPING---DM45/50

1
9
2

10
57348930

6 4
11

Figure 158 :SEPARATOR

C52217874 REV 002
page 319 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52217874 SEPARATOR

REF. PART NO. QTY. UNIT DESCRIPTION

001 95104170 4 EA SCREW, CAP---1/2---13 X1---1/2

HYD TANK PIPING---DM45/50

002 95081667 4 EA WASHER, FLAT---1/2
003 52224144 1 EA ALARM,DIRT
004 52224151 1 EA BUSHING
005 52214178 1 EA ELEMENT,FLTR---3 MICRON
006 52224177 1 EA MAGNET ASSY
007 52224185 1 EA PLATE,SPRING
008 52224193 1 EA SPRING,COMPR
009 52224201 1 EA O---RING
010 52224219 1 EA HOUSING
011 52224227 1 EA RING,RETAINING

57348930

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 320
 Serial Number: 4133
FAMILY,DM50

52210259 FEED PUMP P---HP UNITS

FEED PUMP P---HP UNITS

TO SLOW FEED PUMP SUCTION

PORT ON HYDRAULIC TANK

3
5
4

1
52210259

TO RELIEF VALVE
PRESSURE PORT

6
TO MAGNETIC
SEPARATOR MANIFOLD

Figure 159 :FEED PUMP P--- HP UNITS

W356589 REV 00
page 321 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52210259 FEED PUMP P---HP UNITS

REF. PART NO. QTY. UNIT DESCRIPTION

001 95356853 1 EA FITTING, HYD

FEED PUMP P---HP UNITS

002 57044521 1 EA HOSE ASSY
003 95650149 1 EA ADAPTER
004 95357570 1 EA FITTING, HYD
005 57053829 1 EA HOSE ASSY
006 95356721 1 EA FITTING, HYD
008 95357604 1 EA ADAPTER, 90DEG---ORING/JIC
009 57100208 1 EA HOSE ASSY

52210259

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 322
 Serial Number: 4133
FAMILY,DM50

57137010 DBL.PUMP,P.---SPLT COOLER

64
62 23
DBL.PUMP,P.---SPLT COOLER

42 43

8
15

44 41

10
39
13 12 40
26
33
11

33 19

17 14
20
24
57137010

38 16

36

46 21 25
18 47
48
49
53
34
45
28

30 27
32 31
62 51 58
50

54
52
56 55
37 25
36
36

Figure 160 :DBL.PUMP,P.--- SPLT COOLER

E57137010 REV 01
page 323 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57137010 DBL.PUMP,P.---SPLT COOLER

23

DBL.PUMP,P.---SPLT COOLER
8

1 4
2 5
6
7

57137010
11

14
35
25 13 12 9 10
16 29
22 39
24 40 28
26
11 50
50

36 27
17 63 20
16 14

Figure 161 :DBL.PUMP,P.--- SPLT COOLER

E57137010 REV 01
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 324
 Serial Number: 4133
FAMILY,DM50

57137010 DBL.PUMP,P.---SPLT COOLER

DBL.PUMP,P.---SPLT COOLER

59
57 60
61

58
56
55

52
54

TO BREAKOUT WRENCH
PRESSURE REDUCING VALVE

TO PROPEL ON/OFF VALVE

TO TOWER PINNING
CONTROL VALVE
DOUBLE PUMP MANIFOLD
SUPPLY FROM PUMP
57137010

57
27
30
51 TO RELIEFVALVE

51
62 31

TO FAN MOTOR

52
21

Figure 162 :DBL.PUMP,P.--- SPLT COOLER

E57137010 REV 01
page 325 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57137010 DBL.PUMP,P.---SPLT COOLER

REF. PART NO. QTY. UNIT DESCRIPTION

DBL.PUMP,P.---SPLT COOLER
001 50696384 1 EA ADAPTER
002 95033353 1 EA PLUG,PIPE
003 56988033 1 EA HOSE ASSY
004 50691989 1 EA FLANGE
005 95086625 1 EA O---RING
006 95055232 4 EA SCREW, CAP---5/8---11 X1---1/4
007 95209425 4 EA WASHER, LOCK---5/8
008 56966948 1 EA HOSE ASSY
009 95286902 1 EA FITTING
010 50336247 2 EA U---BOLT
011 95279238 1 EA FITTING HYD
012 95279956 1 EA TEE
013 95219754 1 EA FITTING, HYD
014 57140188 1 EA HOSE ASSY
015 56964224 1 EA HOSE ASSY
016 52234457 1 EA BRACKET
017 95280095 1 EA FITTING, TEE---INT NPT

57137010
018 58217902 1 EA HOSE ASSY
019 95754651 1 EA TEE, JIC
020 52159183 1 EA VALVE,TEMP
37189511 1 EA D ELEMENT,TEMP
37187085 1 EA D SEAL,ELEMENT
37184280 1 EA D SEAL,HOUSING
021 57007528 1 EA HOSE ASSY
022 95219762 2 EA FITTING, HYD
023 95280160 1 EA FITTING, HYD
024 95097366 2 EA NIPPLE,PIPE
025 56973035 1 EA HOSE ASSY
026 56987951 1 EA HOSE ASSY
027 56954159 1 EA HOSE ASSY
028 57486565 1 EA VALVE---PRESS RELIEF
029 95279329 1 EA FITTING, HYD
030 95219721 1 EA FITTING, HYD
031 95219762 1 EA FITTING, HYD
032 95279881 1 EA FITTING, HYD
033 57437154 1 EA HOSE ASSY
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 326
 Serial Number: 4133
FAMILY,DM50

57137010 DBL.PUMP,P.---SPLT COOLER

REF. PART NO. QTY. UNIT DESCRIPTION

034 95315230 1 EA FITTING, HYD

DBL.PUMP,P.---SPLT COOLER

035 95676417 1 EA FITTING HYD---90

036 56957830 1 EA HOSE ASSY
037 56987936 1 EA HOSE ASSY
038 56987910 1 EA HOSE ASSY
039 95937413 4 EA WASHER, LOCK---3/8 PLATED
040 95922894 4 EA NUT, HEX---3/8---16
041 56976590 1 EA HOSE ASSY
042 56964299 1 EA HOSE ASSY
56972706 1 EA HOSE ASSY
043 95675880 1 EA TEE---INT NPT/JIC/INT NPT
044 57438574 1 EA HOSE ASSY
045 95279436 1 EA FITTING, HYD
046 57059701 2 EA FLANGE,1NPTF
047 95055299 8 EA SCREW, CAP---3/8---16 X 3/4
048 95922639 8 EA LOCKWASHER (HD)
049 95086518 2 EA O---RING
050 95219739 1 EA FITTING, HYD
051 95038055 2 EA BUSHING
57137010

052 56956154 1 EA HOSE ASSY

053 59713438 2 EA COUPLING, MIN
054 57005662 1 EA HOSE ASSY
055 95316972 1 EA FITTING, HYD---NPT/JIC
056 95338372 1 EA FITTING, HYD
057 95033593 4 EA PLUG, PIPE---1/4 SQ HEAD
058 52162138 1 EA MANIFOLD
059 95958914 2 EA SCREW,CAP---1/4---20 X 2---1/4
060 95931564 2 EA NUT, HEX---1/4---20
061 95934766 2 EA WASHER, LOCK---1/4 PLATED
062 95279535 2 EA FITTING, HYD
063 95038048 1 EA BUSHING
064 57005696 1 EA HOSE ASSY

page 327 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57137010 DBL.PUMP,P.---SPLT COOLER

DBL.PUMP,P.---SPLT COOLER
57137010

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 328
 Serial Number: 4133
FAMILY,DM50

52167319 CONTROLS, SPEED

CONTROLS, SPEED

CONTROL
CONSOLE
5

2 3

2
52167319

5
3
5
3
6 NOT SHOWN
7 NOT SHOWN
8 NOT SHOWN
9 NOT SHOWN
10 NOT SHOWN

MAIN ROTATION / CONTROL PUMP

Figure 163 :CONTROLS, SPEED

V353392 REV 00
page 329 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52167319 CONTROLS, SPEED

REF. PART NO. QTY. UNIT DESCRIPTION

001 52158094 2 EA CONTROL

CONTROLS, SPEED
57115503 1 EA D KNOB, TRANS. SHFTCONTROL
57176737 1 EA D SWIVELS
002 50457050 2 EA CABLE,CONTRL
003 52153210 2 EA BRACKET---CABLE MTG
004 50248848 2 EA CLEVIS
005 57503682 2 EA LINK, MAIN PUMP CONTROLS
006 95959136 10 EA WASHER, LOCK---1/4 PLATED
007 95067609 2 EA SCREW, CAP---1/4---20 X 3/4
008 50619915 2 EA NUT, LOCK---1/2 CONDUIT
009 50696939 2 EA CONNECTOR, CORD GRIP
010 95931564 8 EA NUT, HEX---1/4---20

52167319

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 330
 Serial Number: 4133
FAMILY,DM50

57160582 9 SPOOL VALVE

33
9 SPOOL VALVE

7
34

42

13 33
ADJUST RELIEF
57160582

VALVE TO 3000 PSI

7

34

42

13

FRONT JACK
CAB SIDE
INLET REAR JACK
PORT
FRONT JACK
ROD CHANGER SIDE
TOWER RAISING

ROD CHANGER

Figure 164 :9 SPOOL VALVE

E57160582 REV 01
page 331 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57160582 9 SPOOL VALVE

44

9 SPOOL VALVE
1

6 ROD INDEXING

ROD WRENCH
5
44

4 1

57160582

Figure 165 :9 SPOOL VALVE

E57160582 REV 01
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 332
 Serial Number: 4133
FAMILY,DM50

57160582 9 SPOOL VALVE

VAPOSOL

35 3
9 SPOOL VALVE

39

2
57160582

35

39

DUST
COLLECTOR

SLOW ROTATION

Figure 166 :9 SPOOL VALVE

E57160582 REV 01
page 333 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57160582 9 SPOOL VALVE

REF. PART NO. QTY. UNIT DESCRIPTION

001 95419594 4 EA FITTING, HYD

9 SPOOL VALVE
002 95364949 1 EA FITTING, HYD
003 95323465 1 EA PLUG HEAD
004 95934592 4 EA SCREW, CAP---3/8---16 X2---1/4
005 95937413 4 EA WASHER, LOCK---3/8 PLATED
006 95922894 4 EA NUT, HEX---3/8---16
007 95356903 10 EA FITTING, HYD
013 57160053 1 EA VALVE, BARE, 9---SPOOL (See figure 167)
033 50696731 10 EA CAP, PLASTIC---9/16---18THDS
034 50696756 3 EA CAP,PLASTIC---1---1/2---12THDS
035 50696012 2 EA CAP, PLASTIC---3/4---16THDS
039 95303368 2 EA ADAPTER, STR---JIC/O---RING
042 95433264 2 EA ELBOW
044 50699297 4 EA CAP, PLASTIC---7/16---20THDS

57160582

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 334
 Serial Number: 4133
FAMILY,DM50

57160053 VALVE, BARE, 9---SPOOL

9 SPOOL VALVE

4 8 3 3 4 4 4 5 4
9 9 9 9 9 9 9 9 9
10 10 10 10 10 10 10 10 10
11 11 11 11 11 11 11 11 11
Torque to 33 Ft/Lbs --- 1
Outlet Port

2
9
Torque to 14 Ft/Lbs --- 1 6

12

1 2 3 4 5 6 7 8 9
7
Inlet Port 13
14
57160582

Plunger Out

Plunger In

In Out

3000
PSI

SCHEMATIC

Figure 167 :VALVE, BARE, 9--- SPOOL

D57160053 REV 02
page 335 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57160053 VALVE, BARE, 9---SPOOL

REF. PART NO. QTY. UNIT DESCRIPTION

001 50613769 1 EA ROD ASSY

9 SPOOL VALVE
002 50617091 1 EA SECTION,VALVE INLET (See figure 168)
003 50613199 2 EA SECTION, VALVE SPOOL (See figure 170)
004 50613207 5 EA SECTION, VALVE SPOOL (See figure 171)
005 50613215 1 EA SECTION, VALVE SPOOL (See figure 172)
006 50613181 1 EA SECTION, VALVE OUTLET
50634328 2 EA D PLUG
95018081 2 EA D O---RING
007 50613728 9 EA HANDLE ASSY (See figure 173)
008 57159691 1 EA SPOOL,SECTION
009 50619014 10 EA O RING
010 50618990 9 EA POPPET
011 50619006 9 EA SPRING
012 50627918 3 EA BALL, KNOB
013 95067591 18 EA SCREW, CAP---1/4---20 X 5/8
014 95934766 18 EA WASHER, LOCK---1/4 PLATED

57160582

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 336
 Serial Number: 4133
FAMILY,DM50

50617091 SECTION,VALVE INLET

9 SPOOL VALVE

INLET
PORT

4 R
57160582

Figure 168 :SECTION,VALVE INLET

B50613165 REV 003
page 337 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50617091 SECTION,VALVE INLET

REF. PART NO. QTY. UNIT DESCRIPTION

002 50619014 1 EA O RING

9 SPOOL VALVE
003 50634328 1 EA PLUG
004 50605682 1 EA O---RING
005 50634336 1 EA VALVE, RELIEF (See figure 169)

57160582

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 338
 Serial Number: 4133
FAMILY,DM50

50634336 VALVE, RELIEF

9 SPOOL VALVE

7 11 2 5 6 18 12 17 1

8
4

9 15

10

16

13
57160582

3 14 14

Figure 169 :VALVE, RELIEF

ILLUSTRAT REV 000
page 339 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50634336 VALVE, RELIEF

REF. PART NO. QTY. UNIT DESCRIPTION

001 50634344 1 EA CAP

9 SPOOL VALVE
002 50605682 1 EA O---RING
003 50634351 1 EA SECTION, PILOT
004 50605732 1 EA O---RING
005 50605690 1 EA O---RING
006 50605724 1 EA RING,BACK---UP
007 50605708 1 EA O---RING
008 50605716 1 EA RING, BACK---UP
009 50634369 1 EA POPPET
010 50634377 1 EA PISTON
011 50634385 1 EA SPRING
012 50634393 1 EA POPPET
013 50635945 1 EA NUT
014 50635952 2 EA WASHER
015 50635960 1 EA NUT
016 50635978 1 EA SCREW
017 50635986 1 EA SPRING
018 50635994 1 EA POPPET

57160582

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 340
 Serial Number: 4133
FAMILY,DM50

50613199 SECTION, VALVE SPOOL

9 SPOOL VALVE

13
8

9
10
11
10
12
6 4
7 5

7
6
57160582

Figure 170 :SECTION, VALVE SPOOL

Y347387 REV 00
page 341 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50613199 SECTION, VALVE SPOOL

REF. PART NO. QTY. UNIT DESCRIPTION

003 50619014 1 EA O RING

9 SPOOL VALVE
004 50619006 1 EA SPRING
005 50618990 1 EA POPPET
006 50605740 2 EA SEAL
007 50605757 2 EA O---RING
008 50636018 1 EA CAP
009 50636026 1 EA SCREW, ADJUSTING
010 50636034 2 EA SEAT
011 50636042 1 EA SPRING
012 50636059 1 EA PLATE
013 50636000 2 EA SCREW

57160582

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 342
 Serial Number: 4133
FAMILY,DM50

50613207 SECTION, VALVE SPOOL

9 SPOOL VALVE

11
9
8
6
7
6 10
5
3
4

4
3
57160582

Figure 171 :SECTION, VALVE SPOOL

Y347390 REV 00
page 343 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50613207 SECTION, VALVE SPOOL

REF. PART NO. QTY. UNIT DESCRIPTION

003 50605740 2 EA SEAL

9 SPOOL VALVE
004 50605757 2 EA O---RING
005 50636059 1 EA PLATE
006 50636034 2 EA SEAT
007 50636042 1 EA SPRING
008 50636026 1 EA SCREW, ADJUSTING
009 50636018 1 EA CAP
010 50619014 1 EA O RING
011 50636000 2 EA SCREW

57160582

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 344
 Serial Number: 4133
FAMILY,DM50

50613215 SECTION, VALVE SPOOL

9 SPOOL VALVE

14
17
15

10
11
13
16
9 3 4
8
6
7
6
5
57160582

4
3

Figure 172 :SECTION, VALVE SPOOL

Y347385 REV 00
page 345 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50613215 SECTION, VALVE SPOOL

REF. PART NO. QTY. UNIT DESCRIPTION

003 50605740 2 EA SEAL

9 SPOOL VALVE
004 50605757 2 EA O---RING
005 50636059 1 EA PLATE
006 50636034 2 EA SEAT
007 50636042 1 EA SPRING
008 52141736 1 EA PIN
009 52141744 1 EA SPRING
010 52141751 1 EA BALL
011 52141769 7 EA BALL
013 52141785 1 EA SPACER
014 52141793 1 EA RING,RETAING
015 52141801 1 EA CAP
016 50619014 1 EA O RING
017 50636000 2 EA SCREW

57160582

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 346
 Serial Number: 4133
FAMILY,DM50

50613728 HANDLE ASSY

9 SPOOL VALVE

9 5
2

1
7
57160582

6
4
8

Figure 173 :HANDLE ASSY

Y347391 REV 01
page 347 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50613728 HANDLE ASSY

REF. PART NO. QTY. UNIT DESCRIPTION

001 50668078 1 EA PIN, ROLL

9 SPOOL VALVE
002 50668060 1 EA LINK
003 58176207 1 EA BRACKET, LEVER
004 95780060 1 EA RING, RETAINING
005 50830322 1 EA PIN
006 50830348 1 EA LEVER
007 50830355 1 EA KNOB, BLACK
008 50830363 1 EA SCREW
009 95929782 1 EA NUT, HEX---5/16---18

57160582

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 348
 Serial Number: 4133
FAMILY,DM50

57155384 FAN ASSEMBLY---SUCTION

30
FAN ASSEMBLY, SUCTION

1
DANGER
6 25
27
26
27

Rotating blade.
Will cause 3
severe injury.
Keep hands clear.
Do not operate
without guard
in place
57155384

Figure 174 :FAN ASSEMBLY--- SUCTION

E52231693 REV07
page 349 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57155384 FAN ASSEMBLY---SUCTION

21

FAN ASSEMBLY, SUCTION

20 22
21

14
19
18 12
10 23
13
11

8 2
9
29
14

15

28
24
7

57155384
4

16

17

Figure 175 :FAN ASSEMBLY--- SUCTION

E52231693 REV07
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 350
 Serial Number: 4133
FAMILY,DM50

57155384 FAN ASSEMBLY---SUCTION

REF. PART NO. QTY. UNIT DESCRIPTION

001 52246477 1 EA GUARD

FAN ASSEMBLY, SUCTION

002 57098147 1 EA FAN,6---BLADE

003 95920724 8 EA SCREW, CAP---1/4---20 X 1---1/2
004 56984131 1 EA BUSHING
005 95923298 8 EA NUT, ELASTIC LOCK---1/4---20
006 52231347 8 EA CLIP, MOUNTING
007 52223872 16 EA SHIM
008 57155376 1 EA MOTOR, HYDRAULIC
52234879 1 EA D CAM RING
009 52220712 1 EA ADAPTER
010 95055315 8 EA SCREW,CAP---3/8---16 X 2---1/4
011 95922639 8 EA LOCKWASHER (HD)
012 95104170 2 EA SCREW, CAP---1/2---13 X 1---1/2
013 95081824 2 EA WASHER, LOCK---1/2
014 95280194 2 EA FITTING, HYD---90 JIC/ORING
015 95934592 4 EA SCREW, CAP---3/8---16 X 2---1/4
016 95937413 4 EA WASHER, LOCK---3/8 PLATED
017 95922894 4 EA NUT, HEX---3/8---16
57155384

018 95341665 1 EA FITTING, HYD---90 DEG

019 56964166 1 EA HOSE ASSY
020 56947682 1 EA HOSE ASSY
021 95278925 2 EA ADAPTER, 45 DEG---JIC/JIC
022 95371704 1 EA FITTING, HYD
023 56950488 1 EA HOSE ASSY
024 50518364 1 EA BRACKET, MOUNTING
025 95922324 8 EA WASHER, FLAT---1/4
026 52237187 8 EA SPACER
027 52237179 16 EA WASHER
028 95934592 3 EA SCREW, CAP---3/8---16 X 2---1/4
029 95086518 2 EA O---RING
030 57140469 2 EA DECAL,WARNING---ROT.BLADE

page 351 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57155384 FAN ASSEMBLY---SUCTION

FAN ASSEMBLY, SUCTION

57155384

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 352
 Serial Number: 4133
FAMILY,DM50

57116774 PIPING, JACKS

10
9
10 10 10
JACKS PIPING

13

E 14
R 1

14 8
2
B
FRONT JACK ROD
B
B CHANGER SIDE
8
A
A A LEFT FRONT
JACK CAB
A
SIDE
REAR
JACK
RIGHT FRONT
JACK ROD
CHANGER SIDE
9--- SPOOL 14
VALVE E
R 1

10 14 11
13
2
9 FRONT JACK
57116774

10 CAB SIDE
11
A B

BULKHEA 14
D CAB E
FLOOR R 1

14 7
2
7 7
8 8 REAR
11 11 JACK 7

Figure 176 :PIPING, JACKS

E57116774 REV 01
page 353 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57116774 PIPING, JACKS

REF. PART NO. QTY. UNIT DESCRIPTION

001 57116758 3 EA ADAPTER,GENERIC JACK---LONG

JACKS PIPING
002 57116766 3 EA ADAPTER,GENERIC JACK---SHRT
007 57229965 2 EA HOSE ASSY
008 57330284 2 EA HOSE ASSY
009 56961824 1 EA HOSE ASSY
010 56961816 4 EA HOSE ASSY
011 57311912 2 EA HOSE ASSY
013 56992514 1 EA HOSE ASSY
014 95209888 6 EA O---RING, HYD

57116774

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 354
 Serial Number: 4133
FAMILY,DM50

52222171 O PRESS CONT

7 ---FITTING, HYD
O PRESS CONT

Left Front Jack

1
2
3
3
52222171

17 18
26

To Port In Supercharge Manifold

Built In the Hydraulic Reservoir

Figure 177 :O PRESS CONT

E52206174 REV04
page 355 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52222171 O PRESS CONT

O PRESS CONT
Right Front Jack

2 1

3 3

52222171
16 19

To Post in Supercharge Manifold

Built In the Hydraulic Reservoir

Figure 178 :O PRESS CONT

E52206174 REV04
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 356
 Serial Number: 4133
FAMILY,DM50

52222171 O PRESS CONT

REF. PART NO. QTY. UNIT DESCRIPTION

001 50429356 2 EA VALVE, 2---WAY

O PRESS CONT

002 50429455 2 EA BRACKET, VALVE

003 95365086 4 EA FITTING, HYD
007 95371258 2 EA FITTING, HYD
016 57020810 1 EA HOSE ASSY
017 57413551 1 EA HOSE ASSY
018 52225547 1 EA HOSE ASSY
019 52225547 1 EA HOSE ASSY
026 56964133 1 EA HOSE ASSY
52222171

page 357 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52222171 O PRESS CONT

O PRESS CONT
52222171

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 358
 Serial Number: 4133
FAMILY,DM50

57421307 PIPING,MAIN PROP---325---F55

32
29
27 54
31 30

PROPEL MOTOR
PIPING,MAIN PROP---325---F55

VIEW D---D

SUP--- 17
D
SUP--- 7
D
21

D
28 53

D
ATM--- 6 ATM--- 4
D

D
17

SUP---13
36
6 20 19
14 18
21 21
19 19 15

63
51 52
15

1 1 2 25
8 41 37 3
4 9
55 63
41
37 37 37
1
2

35 37
16

1T
40 38

11
35 37

2
9
57421307

VIEW ”A--- A”

VIEW ”B--- B”
A

22 40 38
34 34 22
B

23
1

35
35 37 37 23 64
B

B
A

A
RETURN MANIFOLD

10
10
TURN DOWN

TURN DOWN

26
26 11
DOWN

45
REVERSE FORWARD
45

ROTATION PUMP
REVERSE

24 24
25
12 33
UP
FEED PUMP
CAB SIDE

Figure 179 :PIPING,MAIN PROP--- 325--- F55

E57421307 REV 03
page 359 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57421307 PIPING,MAIN PROP---325---F55

7 67
PROPEL
ALARM
66

3
1
2

PIPING,MAIN PROP---325---F55
B
13 60
13 A
13
59
CAT TRACK 42
C-- C 44 43
57
DOUBLE PUMP
PIPING

54

B
60
A
59
AMERICAN TRACK
44 42
43
F-- F
Y

56
T
Y
BP

BP

X
A

A
X

68 69

60

57421307
60
TO MAIN VALVE TO MAIN VALVE
61

59
62
59
TO PORT “A” TO PORT “A”

C;F C;F

C;F TO PORT “B” TO PORT “B”

TOP
C;F
TOP
45 45
46 58 46
57 65
65 127
127

Figure 180 :PIPING,MAIN PROP--- 325--- F55

E57421307 REV 03
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 360
 Serial Number: 4133
FAMILY,DM50

57421307 PIPING,MAIN PROP---325---F55

3
4
PIPING,MAIN PROP---325---F55

38
39

5 E
57421307

47 5
48
49
50
MAIN FRAME

STOP BLOCK YOKE

VIEW E-- E

Figure 181 :PIPING,MAIN PROP--- 325--- F55

E57421307 REV 03
page 361 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57421307 PIPING,MAIN PROP---325---F55

REF. PART NO. QTY. UNIT DESCRIPTION

001 57035529 2 EA VLV.ASY.DVT (See figure 182)

PIPING,MAIN PROP---325---F55
002 95055315 8 EA SCREW,CAP---3/8---16 X 2---1/4
003 95937413 8 EA WASHER, LOCK---3/8 PLATED
004 95922894 8 EA NUT, HEX---3/8---16
005 57244980 2 EA PLATE, MTG
006 52167756 1 EA VLV ASSY CK (See figure 184)
007 52214368 1 EA VLV ASSY PRO
52217247 1 EA D VLV SELECT
95403580 1 EA D TEE
95381158 3 EA D FITTING, HYD
008 57034712 2 EA HOSE ASSY
009 57345126 2 EA HOSE ASSY
010 57044612 2 EA HOSE ASSY
011 57183832 1 EA HOSE ASSY
012 57043788 1 EA HOSE ASSY
013 57044521 3 EA HOSE ASSY
014 56972680 1 EA HOSE ASSY
015 56964208 2 EA HOSE ASSY

57421307
016 56964141 1 EA HOSE ASSY
017 95266433 2 EA O---RING
018 57167132 2 EA DISCONNECT
019 95219853 2 EA FITTING, HYD
020 95219762 2 EA FITTING, HYD
021 95371258 3 EA FITTING, HYD
022 57102097 4 EA ADAPTER,FLANGE
023 95329983 2 EA FITTING, HYD---JIC/O---RING
024 95280194 2 EA FITTING, HYD---90JIC/ORING
025 95280186 1 EA FITTING, HYD
026 95341665 2 EA FITTING, HYD---90 DEG
027 95209094 1 EA FITTING, HYD
028 95279923 1 EA TEE
029 95315230 2 EA FITTING, HYD
030 95667820 2 EA TEE, NPT/JIC
031 56927445 2 EA VALVE, CHECK
032 95652970 2 EA FITTING HYD
033 95356960 1 EA FITTING, HYD
034 95280194 2 EA FITTING, HYD---90JIC/ORING
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 362
 Serial Number: 4133
FAMILY,DM50

57421307 PIPING,MAIN PROP---325---F55

REF. PART NO. QTY. UNIT DESCRIPTION

035 57328676 4 EA FITTING, TEST

PIPING,MAIN PROP---325---F55

036 95293403 1 EA FITTING, HYD

037 95303368 4 EA ADAPTER, STR---JIC/O---RING
037 95329975 4 EA FITTING, HYD
038 57244352 2 EA VALVE, PUMP RELIEF
039 95958989 8 EA SCREW, CAP---3/8---16 X1---3/4
040 57337123 2 EA HOSE ASSY
041 95303368 2 EA ADAPTER, STR---JIC/O---RING
042 95081824 16 EA WASHER, LOCK---1/2
043 50926062 16 EA SCREW, HEX M12X1.75X45MM
044 52226115 4 EA KIT, SPLIT FLANGE (See figure 185)
045 57391559 2 EA CONNECTOR, MALE
046 57072423 2 EA ADAPTER
047 95104147 2 EA SCREW, CAP---1/2---13 X 1
048 95081824 2 EA WASHER, LOCK---1/2
049 95077798 2 EA NUT, HEX---1/2---13
050 95654216 2 EA CLAMP, HOSE
051 95473443 1 EA FITTING, HYD
57421307

052 56964141 1 EA HOSE ASSY

053 57100281 1 EA HOSE ASSY
054 58144528 1 EA HOSE ASSY
055 57044711 1 EA HOSE ASSY
056 57330284 1 EA HOSE ASSY
057 95415667 2 EA FITTING, HYD
058 57168387 1 EA HOSE ASSY
059 57421273 2 EA HOSE ASSY
060 57421240 2 EA HOSE ASSY
061 56992118 1 EA HOSE ASSY
062 56954365 1 EA HOSE ASSY
063 56955651 1 EA HOSE ASSY
063 56994528 1 EA HOSE ASSY
063 57345332 2 EA HOSE ASSY
064 57414179 2 EA HOSE ASSY
065 95402806 2 EA FITTING
066 57392912 1 EA HOSE ASSY
067 95365078 1 EA FITTING, HYD
068 56947674 1 EA HOSE ASSY
page 363 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57421307 PIPING,MAIN PROP---325---F55

REF. PART NO. QTY. UNIT DESCRIPTION

069 57044588 1 EA HOSE ASSY

PIPING,MAIN PROP---325---F55
127 56919004 2 EA FITTING, HYD
127 59767483 2 EA FITTING,HYD.METRICSTRTHD
127 95415667 2 EA FITTING, HYD

57421307

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 364
 Serial Number: 4133
FAMILY,DM50

57035529 VLV.ASY.DVT

14
PIPING,MAIN PROP---325---F55

8 6 2

16

10
57421307

12

9
1
15

Figure 182 :VLV.ASY.DVT

C57035529 REV 01
page 365 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57035529 VLV.ASY.DVT

REF. PART NO. QTY. UNIT DESCRIPTION

001 57106429 1 EA VALVE, DIVERTER (See figure 183)

PIPING,MAIN PROP---325---F55
002 56927445 1 EA VALVE, CHECK
006 95315230 1 EA FITTING, HYD
008 95702627 1 EA FITTING,HYD
009 95329983 1 EA FITTING, HYD---JIC/O---RING
010 95371258 1 EA FITTING, HYD
012 50700814 1 EA ADAPTER
014 95408183 1 EA FITTING, HYD
015 95326955 1 EA PLUG W/O RNG
016 95280160 1 EA FITTING, HYD

57421307

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 366
 Serial Number: 4133
FAMILY,DM50

57106429 VALVE, DIVERTER

8 KIT,SEAL NOT SHOWN

PIPING,MAIN PROP---325---F55

5
2
3
3

1 4

B
6
7
A

1
57421307

Figure 183 :VALVE, DIVERTER

D57106429 REV02
page 367 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57106429 VALVE, DIVERTER

REF. PART NO. QTY. UNIT DESCRIPTION

001 57106460 1 EA VALVE, 4---WAY

PIPING,MAIN PROP---325---F55
57107914 1 EA D KIT,SEAL
002 57106965 1 EA SUBPLATE
003 51076271 1 EA BOLT KIT
004 57107906 2 EA O---RING
005 51076156 2 EA O---RING
006 51076172 2 EA O---RING
007 51076164 4 EA O---RING
008 57107914 0 EA KIT,SEAL

57421307

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 368
 Serial Number: 4133
FAMILY,DM50

52167756 VLV ASSY CK

PIPING,MAIN PROP---325---F55

5
7

3
4

2 4
57421307

8
2

Figure 184 :VLV ASSY CK

X353460 REV 00
page 369 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52167756 VLV ASSY CK

REF. PART NO. QTY. UNIT DESCRIPTION

001 50820950 1 EA CK VALVE

PIPING,MAIN PROP---325---F55
002 50422930 2 EA VALVE,CHECK
003 95302998 1 EA FITTING, HYD
004 95279998 2 EA FITTING, HYD
005 95048914 2 EA NIPPLE
006 95655064 1 EA ADAPTER, INT NPT/O---RING
007 95293403 1 EA FITTING, HYD
008 95263380 2 EA FITTING, HYD---NPT/JIC

57421307

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 370
 Serial Number: 4133
FAMILY,DM50

52226115 KIT, SPLIT FLANGE

PIPING,MAIN PROP---325---F55

2
1

4
3
57421307

Figure 185 :KIT, SPLIT FLANGE

B58235128 REV002
page 371 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52226115 KIT, SPLIT FLANGE

REF. PART NO. QTY. UNIT DESCRIPTION

001 57404147 2 EA FLANGE HALF,SIZE 16---CD62

PIPING,MAIN PROP---325---F55
002 56883614 1 EA O---RING
003 95934592 4 EA SCREW, CAP---3/8---16 X2---1/4
004 95937413 4 EA WASHER, LOCK---3/8 PLATED

57421307

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 372
 Serial Number: 4133
FAMILY,DM50

ELECTRICAL SYSTEM
SECTION
ELECTRICAL SYSTEM

page 373 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
ELECTRICAL SYSTEM

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 374
 Serial Number: 4133
FAMILY,DM50

57276800 WIRING, BASIC---CAT

SEE DETAIL --- B---

WIRING, BASIC---CAT

VARNISH, INSULATING(NOT SHOWN)

30
SEE DETAIL --- A---
60

TO LIGHT ON
57276800

TOWER

24

49
20
21
22
23
29
20

BREAK--- OUT SWITCH

40
41

59

TO HYDRAULIC
C

Figure 186 :WIRING, BASIC--- CAT

D57276800 REV01
page 375 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57276800 WIRING, BASIC---CAT

#22 TO
LIGHT

JACK
ON

WIRING, BASIC---CAT
30
COMPRESSOR
ON FLYWHEEL HOUSING
TO MAGNETIC SENSOR

TEMP

21
22
23
29
25
26
27
28
29
TO FUEL PRIMER PUMP

ENGINE
TEMP.

24

WRENCH SOLENOID

57276800
TO BREAK--- OUT
19
TO TOWER
PINNING

Figure 187 :WIRING, BASIC--- CAT

D57276800 REV01
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 376
 Serial Number: 4133
FAMILY,DM50

57276800 WIRING, BASIC---CAT

21
WIRING, BASIC---CAT

22
23

2
4

5
8

15 33
14
BARE

17

21

25
22
EXT. 8
30
39
38
57276800

36

32

40

25
26
27
28 DETAIL ---A ---

Figure 188 :WIRING, BASIC--- CAT

D57276800 REV01
page 377 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57276800 WIRING, BASIC---CAT

42

49

WIRING, BASIC---CAT
RED WIRE

17 GROUND

RED WIRE 43

DETAIL ---B---

69

25

57276800
DETAIL ---E---
FUEL PRIMER PUMP

BREAK--- OUT
WRENCH
SOLENOID
VALVE

40
VIEW C---C 20

Figure 189 :WIRING, BASIC--- CAT

D57276800 REV01
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 378
 Serial Number: 4133
FAMILY,DM50

57276800 WIRING, BASIC---CAT

35
EMERGENCY STOP
DISCHARGE TEMP WATER TEMP
WIRING, BASIC---CAT

TACH &
HOURS NC NO 65

OIL PRESSURE AMMETER

CIRCUIT BREAKERS

LOAD BATT

34 56
5 4 3 2 1
34

PRIMER START BYPASS

TOWER PINNING KEY
SWITCH

22
23
54
10 55
57276800

70

72
TO BATT. + POST

69 TO GROUD TO BATT. --- POST

71

DETAIL G---G
STARTER ENG.

Figure 190 :WIRING, BASIC--- CAT

D57276800 REV01
page 379 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57276800 WIRING, BASIC---CAT

22

WIRING, BASIC---CAT
21 45

48
47
46

11
SPEED
SWITCH

24 V
SIG
CONNECT TO A/C IF 22
EQUIPT.
21
66 14 15
21
1,2,4,5,8,17,25,22,30,
SHIELD CABLE
5

5,24,40,41
53

57276800
52
19
HYD. B.O.
SWITCH
5

10
50
20
51
BHD. #12
BHD. #12
CAB FLOOR

Figure 191 :WIRING, BASIC--- CAT

D57276800 REV01
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 380
 Serial Number: 4133
FAMILY,DM50

57276800 WIRING, BASIC---CAT

68 35
59 EMERGENCY STOP
DISCHARGE TEMP WATER TEMP
WIRING, BASIC---CAT

TACH & HOURS

66

CIRCUIT BREAKERS
OIL PRESSURE AMMETER 35
35

56 35
34
34
56
START
57 PRIMER KEY
BYPASS
SWITCH

56 58 34 56 8
3,5,7,10,11,12,13,14,15,16 58 35

14
15
16
13
57276800

35

52
66 35

35
SPEED 12
SWITCH
49
BARE WIRE

SHIELDED CABLE 7,11,5

35
52
35

Figure 192 :WIRING, BASIC--- CAT

D57276800 REV01
page 381 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57276800 WIRING, BASIC---CAT

15
13 8
16
14
65 15

WIRING, BASIC---CAT
16
68
12
46

B 13 48

47

14

12 VIEW B---B

57276800
WIRE DESCRIPTION
COLOR GAGE (AWG) WIRE NUMBERS CIRCUIT

1 RED . . . . . . . . . . . . 8 . . . . . . . . . . . . . . 1,2 (+) POSITIVE MAIN FEEDER

2 GREEN . . . . . . . . . 14 . . . . . . . . . . . . . . 3,4,7,8,10,11, . . . . START & STOP EMERG. S70P
12,13,16 & 25
3 BLUE . . . . . . . . . . . 14 . . . . . . . . . . . . . . 10,17,40 & 41 . . TACH. & ENGINE SHUT DOWN
4 PURPLE . . . . . . . . . 14 . . . . . . . . . . . . . . 18,22,23, & 24 . . . LIGHTS
WHITE . . . . . . . . . . 14 . . . . . . . . . . . . . . 19,20 & 21 . . . . . . A/C
6 BLACK . . . . . . . . . . 14 & 10 . . . . . . . . . . 5 . . . . . . . . . . . . . . . GROUN
7 SHLD.CABLE . . . . 18/2 CON. . . . . . . . 14 (CLR), 15 (BLK MAGNETIC PICKU
RED . . . . . . . . . . . . 10 . . . . . . . . . . . . . . 6 & 35 . . . . . . . . . . JUMPER WIRE OR BUSS BAR

9 IDENTIFY BOTH ENDS OF ALL WIRES USING ITEMS 9

Figure 193 :WIRING, BASIC--- CAT

D57276800 REV01
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 382
 Serial Number: 4133
FAMILY,DM50

57276800 WIRING, BASIC---CAT

REF. PART NO. QTY. UNIT DESCRIPTION

001 50465293 48.00 IN WIRE, 8AWG---RED

WIRING, BASIC---CAT

002 50625938 60.00 IN WIRE, 14AWG---GREEN

003 50812429 36.00 IN WIRE, 14AWG---BLUE
004 50623065 24.00 IN WIRE, 14AWG---VIOLET
006 50249655 36.00 IN WIRE, 14AWG---BLACK
007 85771715 36.00 IN CABLE, 18/2
008 52238318 1 EA RELAY,N.O. POWER
009 57093080 100 EA MARKER, WIRE
010 56762198 2 EA SWITCH, TOGGLE---SPST
011 95922092 2 EA SCREW, ROUNDHD---8---32X3/4
012 56762248 1 EA CONNECTOR, SPLICE
013 58150152 1 EA TERMINAL,RING
014 56944101 1 EA TERMINAL
015 95922183 2 EA WASHER, FLAT---1/4
016 95865937 2 EA SCREW,CAP---1/4---20X1/2ZINC
019 57138216 1 EA HARNESS,WIRE
020 57138240 1 EA HARNESS,WIRE
021 95928982 18 EA SCREW, CAP---1/4---20 X 3/4
57276800

022 95934766 19 EA WASHER, LOCK---1/4 PLATED

023 95931564 17 EA NUT, HEX---1/4---20
024 52236791 3 EA CLAMP ASSY, 3/4
52240439 1 EA D PLATE,TAPPED
95256749 1 EA D CLAMP---3/4
95934766 1 EA D WASHER, LOCK---1/4 PLATED
95865937 1 EA D SCREW,CAP---1/4---20X1/2ZINC
025 95920682 2 EA SCREW, CAP---3/8---16 X1---1/4
026 95937413 2 EA WASHER, LOCK---3/8 PLATED
027 95922894 2 EA NUT, HEX---3/8---16
028 95338356 2 EA WASHER, BEVEL---3/8
029 95371092 6 EA CLAMP, HOSE
030 57138232 1 EA HARNESS,WIRE
032 52236569 1 EA GASKET, 3/4
033 57138166 1 EA JUNCTION BOX ASSY,8 X 6 (See figure 194)
034 56951858 4 EA TERMINAL
035 95329249 32 EA TERMINAL

page 383 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57276800 WIRING, BASIC---CAT

REF. PART NO. QTY. UNIT DESCRIPTION

036 50619915 1 EA NUT, LOCK---1/2 CONDUIT

WIRING, BASIC---CAT
038 50625839 1 EA BUSHING, CONDUIT
039 56991193 1 EA CONNECTOR
040 57022196 1 EA BRACKET, MOUNTING
042 57366395 1 EA ALARM KIT, BACKUP
57366387 1 EA D ALARM, BACKUP---12 TO36VDC
57014672 1 EA D ANGLE
95922365 2 EA D WASHER, FLAT---5/16
95929782 2 EA D NUT, HEX---5/16---18
95934303 2 EA D WASHER, LOCK---5/16 PLATED
95922225 4 EA D WASHER, FLAT---5/16
043 56782014 1 EA BRACKET
045 57276768 1 EA SWITCH, SPEED, CAT
046 57137606 1 EA RELAY
047 57137614 1 EA SCREW TERMINAL SOCKET
048 57137622 1 EA SPRING, HOLD DOWN
049 95373841 7 EA TERMINAL
050 95360996 1 EA BUSHING,MALE
051 50628726 1 EA BUSHING

57276800
052 95484408 5 EA TERMINAL
053 52232428 1 EA SWITCH,PRESSURE
054 95958849 1 EA SCREW,FLAT HD---1/4---20X7/8
055 95351904 1 EA CLAMP, HOSE
056 95329256 16 EA TERMINAL
057 57036881 1 EA BAR, COPPER
058 95359600 3 EA TERMINAL
059 95748802 25 EA TIE, CABLE
060 57168916 6.00 OZ VARNISH, INSULATING
065 57196677 3 EA DIODE, 3A, 600V
066 95843371 16 EA TERMINAL
068 50247709 48.00 IN TUBING, VINYL
069 57139131 2 EA MOUNT, FLEX---BOLTSANDWICH
070 57141939 2 EA FASTENER,1/4---20 TEENUT
071 59956466 1 EA RELAY,SOLENOID---24VMARINE
072 52246519 1 EA CABLE, GROUND---1/0 X 36

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 384
 Serial Number: 4133
FAMILY,DM50

57138166 JUNCTION BOX ASSY,8 X 6

WIRING, BASIC---CAT

3 4

1
5
57276800

Figure 194 :JUNCTION BOX ASSY,8 X 6

C57138166 REV00
page 385 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57138166 JUNCTION BOX ASSY,8 X 6

REF. PART NO. QTY. UNIT DESCRIPTION

001 88001599 1 EA PANEL

WIRING, BASIC---CAT
002 57032963 1 EA BOX,ELEC.JIC
003 57073645 2 EA HOLDER, END
004 95924155 2 EA SCREW, TAP.---#6---20 X 1/2
005 57073637 14 EA TERMINAL

57276800

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 386
 Serial Number: 4133
FAMILY,DM50

57157869 LIGHTS, NIGHT

LIGHTS, NIGHT

8
1
2
3 14
REAR JACK 13
12
11 1
2
3
4
1
4 2
57157869

6 1
5

Figure 195 :LIGHTS, NIGHT

D57157869 REV 006
page 387 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57157869 LIGHTS, NIGHT

LIGHTS, NIGHT
1
5
2
3
10

7 TRAP
1 CAB END
6
FLOOD CAB SIDE
2
20A TRAM WALKWAY
18 22 FLOOD
3 3 REC/SEP END

57157869
DRILL
23 TRAP
4 POWER PACK

TRAP
5 TOWER TOP

FLOOD 6 TOWER BOTTOM

Figure 196 :LIGHTS, NIGHT

D57157869 REV 05
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 388
 Serial Number: 4133
FAMILY,DM50

57157869 LIGHTS, NIGHT

REF. PART NO. QTY. UNIT DESCRIPTION

001 57157885 6 EA HOUSING, 4X6 LIGHT

LIGHTS, NIGHT

002 57157893 3 EA LAMP, TRAP---70W HALOGEN

003 57147282 3 EA LAMP, FLOOD---70W HALOGEN
004 56790330 1 EA ANGLE
005 95935185 6 EA CAPSCREW,HEX HEAD,PLATED
006 95077814 6 EA NUT, HEX 5/8---11
007 95934741 6 EA WASHER,LOCK HELICAL
008 57330110 1 EA BAR, W/HOLES, 3/8X2X11
009 95094314 6 EA WASHER, FLAT---5/8
010 56944101 6 EA TERMINAL
011 95301834 7 EA CLAMP,HOSE
012 95934550 7 EA SCREW, CAP---3/8---16 X 3/4
013 95922894 7 EA NUT, HEX---3/8---16
014 95937413 7 EA WASHER, LOCK---3/8 PLATED
57157869

page 389 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57157869 LIGHTS, NIGHT

LIGHTS, NIGHT
57157869

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 390
 Serial Number: 4133
FAMILY,DM50

OPTIONS
SECTION
OPTIONS

page 391 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
OPTIONS

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 392
 Serial Number: 4133
FAMILY,DM50

57404725 DUST COLLECTR INSTL---3600

DUST COLLECTR INSTL---3600

HOSE TIES

5 4 5
1
57404725

2 3
20

Figure 197 :DUST COLLECTR INSTL--- 3600

E57284317 REV 06
page 393 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57404725 DUST COLLECTR INSTL---3600

TO FILTER MANIFOLD
RETURN PORT ON
TO BULKHEAD INSIDE ON HYDRAULIC TANK

21 OF CONSOLE IN CAB
15 11
13
13 TO PORT ON BOTTOM

DUST COLLECTR INSTL---3600

OF HYDRAULIC TANK

12
16
14 TO RECIEVER
PIPING

2
3

1 22

57404725
23
6

17

Figure 198 :DUST COLLECTR INSTL--- 3600

E57284317 REV 06
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 394
 Serial Number: 4133
FAMILY,DM50

57404725 DUST COLLECTR INSTL---3600

TO HYDRAULIC DUST
COLLECTOR MOTOR
15
DUST COLLECTR INSTL---3600

CAB FLOOR
IN SIDE CONSOLE
BULKHEAD

18
57404725

Figure 199 :DUST COLLECTR INSTL--- 3600

E57284317 REV 06
page 395 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57404725 DUST COLLECTR INSTL---3600

DUST COLLECTR INSTL---3600

HYDRAULIC RESERVOIR
TANK

RETURN MANIFOLD
MAINIFOLD PORT RET --- 1

TANK PORT RET --- 14

57404725
21
TO HYDRAULIC DUST
COLLECTOR MOTOR

21 TO HYDRAULIC DUST
COLLECTOR MOTOR

Figure 200 :DUST COLLECTR INSTL--- 3600

E57284317 REV 06
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 396
 Serial Number: 4133
FAMILY,DM50

57404725 DUST COLLECTR INSTL---3600

DUST COLLECTR INSTL---3600

RECEIVER TANK
57404725

12

AIR CONNECTION FOR

HP UNITS

Figure 201 :DUST COLLECTR INSTL--- 3600

E57284317 REV 06
page 397 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57404725 DUST COLLECTR INSTL---3600

DUST COLLECTR INSTL---3600

RECEIVER TANK

10

12

AIR CONNECTION FOR XL TANKS

12

57404725
RECEIVER TANK

AIR CONNECTION FOR XL VERTICAL TANKS

Figure 202 :DUST COLLECTR INSTL--- 3600

E57284317 REV 06
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 398
 Serial Number: 4133
FAMILY,DM50

57404725 DUST COLLECTR INSTL---3600

REF. PART NO. QTY. UNIT DESCRIPTION

001 57284309 1 EA DUST COLLECTOR---IR 3600 (See figure 203)

DUST COLLECTR INSTL---3600

002 57076507 1 EA HOSE, SUCTION---8 X 8’---4

003 56958523 2 EA CLAMP, HOSE
004 56989338 6.00 IN HOSE, RADIATOR---BULK
005 56780729 2 EA TIE, CABLE
006 95104162 8 EA SCREW, CAP---1/2---13 X1---3/8
007 95922902 8 EA NUT,HEX,FINISHED,PLATED
008 95934733 8 EA WASHER,LOCK
009 95219721 1 EA FITTING, HYD
010 95303335 1 EA FITTING, HYD
011 95279501 1 EA FITTING, HYD
012 57057929 1 EA HOSE ASSY
013 95219747 2 EA FITTING, HYD
014 95341665 1 EA FITTING, HYD---90 DEG
015 57249096 1 EA HOSE ASSY
016 57097909 1 EA HOSE ASSY
017 95081667 8 EA WASHER, FLAT---1/2
018 56957780 1 EA HOSE ASSY
57404725

020 57059644 1 EA TRANSITION---8

021 57311920 1 EA HOSE ASSY
022 50625946 1 EA CONNECTOR,CORD GRIP
023 95371092 9 EA CLAMP, HOSE

page 399 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57404725 DUST COLLECTR INSTL---3600

DUST COLLECTR INSTL---3600

57404725

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 400
 Serial Number: 4133
FAMILY,DM50

57284309 DUST COLLECTOR ---IR 3600

20
DUST COLLECTR INSTL---3600

7
18
17

22
5 6
4
3
19 2

11

8 23
21
10

1
57404725

14

9 16
13

12 15

Figure 203 :DUST COLLECTOR--- IR 3600

C57284309 REV 004
page 401 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57284309 DUST COLLECTOR ---IR 3600

REF. PART NO. QTY. UNIT DESCRIPTION

001 57284630 1 EA LOWER HSG SECTION

DUST COLLECTR INSTL---3600

002 57284648 1 EA UPPER HSG SECTION
003 51024792 1 EA BLOWER MOUNT
57173254 1 EA D PLATE, BOTTOM MOUNT
57173262 1 EA D PLATE, TOP MOUNT
57173270 1 EA D PLATE, SIDE MOUNT
004 57284655 1 EA BLOWER WHEEL 20
005 57063711 1 EA HOUSING, BLOWER
006 57284663 1 EA BLOWER HSG
007 57003782 1 EA MOTOR,HYDRAULIC (See figure 204)
008 57284671 1 EA TIMER, DC ELECTRIC
57514804 1 EA D TIMER BOX, BARE
009 57284689 1 EA MANIFOLD, AIR IMPULSE
010 57284697 4 EA ELEMENT, FILTER
011 57063877 4 EA ELEMENT,RETENTION
012 56934185 4 EA VALVE,IMPULSE
013 57003790 4 EA VALVE,SOLENOID
014 57060154 1 EA CHUTE,TRANSITION
015 57446437 1 EA HOSE, DROPOUT

57404725
016 52230794 1 EA CLAMP,HOSE
017 57082455 1 EA FILTER & REGULATOR
57082463 1 EA D ELEMENT, FILTER
57112963 1 EA D GAUGE,PRESSURE
018 50829605 1 EA VALVE,BALL---1/2
019 57018673 1 EA VALVE,SAFETY
020 57284705 1 EA VALVE, FLOW CONTROL
021 57290264 1 EA DOOR,FILTER ACCESS
57301202 2 EA D HANDLE---D/C DOOR
022 57116519 1 EA BUSHING, MODIFIED
39115035 1 EA D BUSHING
023 54416557 1 EA PLATE,WEAR

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 402
 Serial Number: 4133
FAMILY,DM50

57003782 MOTOR,HYDRAULIC
DUST COLLECTR INSTL---3600

8 9
7 10
5 6
3
2 4

16
57404725

13 14
15
12
11

17 (NOT SHOWN) INCLUDES:

ITEMS 3, 9, 10, 13 AND 14

Figure 204 :MOTOR,HYDRAULIC

B57003782 REV 001
page 403 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57003782 MOTOR,HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

001 54426135 4 EA SCREW,CAP SOCKET HEAD

DUST COLLECTR INSTL---3600

002 50709666 1 EA END CAP
003 50815794 1 EA SEAL,SQ SECT
004 50815802 1 EA BEARING, NEEDLE
005 50815810 1 EA PIN, DOWEL
006 52233194 1 EA CAM RING ASM (See figure 205)
007 50815810 1 EA PIN, DOWEL
008 52179488 1 EA PLATE,PORT (See figure 206)
009 50815851 1 EA SEAL,SQ SECT
010 52179496 1 EA SEAL, SECTION
011 50815901 1 EA RING, SNAP
012 52230869 1 EA SHAFT ASSY
50806223 2 EA D RING,SNAP
52179504 1 EA D BEARING, BALL
52234887 1 EA D SHAFT
013 51079176 1 EA SEAL, SHAFT
014 54426226 1 EA WIPER,FELT
015 54426242 1 EA BODY
016 50816339 1 EA KEY

57404725
017 52179595 1 EA SEAL KIT (See figure 207)

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 404
 Serial Number: 4133
FAMILY,DM50

52233194 CAM RING ASM

DUST COLLECTR INSTL---3600

CAM RING ASSEMBLY 4

2
1
57404725

Figure 205 :CAM RING ASM

B52233194 REV 00
page 405 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52233194 CAM RING ASM

REF. PART NO. QTY. UNIT DESCRIPTION

001 54465646 1 EA RING,CAM

DUST COLLECTR INSTL---3600

002 52179587 10 EA VANE
003 52179579 30 EA VANE SPRING
004 54426150 1 EA ROTOR

57404725

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 406
 Serial Number: 4133
FAMILY,DM50

52179488 PLATE,PORT
DUST COLLECTR INSTL---3600

1
3

PORT PLATE ASSY.

57404725

Figure 206 :PLATE,PORT

B52179488 REV 000
page 407 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52179488 PLATE,PORT

REF. PART NO. QTY. UNIT DESCRIPTION

001 54426168 1 EA PLATE,PORT

DUST COLLECTR INSTL---3600

002 54426176 1 EA SCREW,SET,SOCKET
003 54426184 1 EA VALVE,ADAPTER
004 52155371 1 EA BALL

57404725

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 408
 Serial Number: 4133
FAMILY,DM50

52179595 SEAL KIT

DUST COLLECTR INSTL---3600

2 3
1
57404725

4 5

Figure 207 :SEAL KIT

B52179595 REV 000
page 409 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52179595 SEAL KIT

REF. PART NO. QTY. UNIT DESCRIPTION

001 50815794 1 EA SEAL,SQ SECT

DUST COLLECTR INSTL---3600

002 50815851 1 EA SEAL,SQ SECT
003 52179496 1 EA SEAL, SECTION
004 51079176 1 EA SEAL, SHAFT
005 54426226 1 EA WIPER,FELT

57404725

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 410
 Serial Number: 4133
FAMILY,DM50

57391039 DUST CURTAIN INSTL.

14 ---SCREW,CAP---1/4---20X1/2ZINC
DUST CURTAIN INSTL.

12 11 5
11 15
16 16
57391039

16
16 11
11 18
17 8
10

7
7
18
11
16 9

17 3
11
16
4

Figure 208 :DUST CURTAIN INSTL.

E57391039 REV 01
page 411 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57391039 DUST CURTAIN INSTL.

16 16
11 11
18 17

16 12
11

DUST CURTAIN INSTL.

11 16
12 12
11 4
16 7 7
3

4
1
16
11
15
1 3
8 5
18
16
11 6
11 2
15
11
16

57391039
2
7 15
11
16
16
11
12 6

18
11
16
1

Figure 209 :DUST CURTAIN INSTL.

E57391039 REV 01
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 412
 Serial Number: 4133
FAMILY,DM50

57391039 DUST CURTAIN INSTL.

REF. PART NO. QTY. UNIT DESCRIPTION

001 57181034 1 EA EXTENSION, TOWER BOTTOM

DUST CURTAIN INSTL.

002 57181026 1 EA FRAME, DUST CURTAIN

003 57390668 1 EA DUST CURTAIN---REAR DCSIDE
004 57391021 1 EA DUST CURTAIN---R.CAB SIDE
005 57184491 1 EA DUST CURT. FRNT DUSTSIDE
006 57184483 1 EA DUST CURTAIN, FRONT CAB
007 57184103 2 EA STRAP, CURTAIN---TWRBOTTOM
008 57120677 1 EA STRAP, REAR
009 57134942 1 EA STRAP, DUST CURTAIN
010 57075426 1 EA STRAP
011 95922183 60 EA WASHER, FLAT---1/4
012 95958849 12 EA SCREW,FLAT HD---1/4---20X7/8
014 95865937 2 EA SCREW,CAP---1/4---20X1/2ZINC
015 95934816 19 EA SCREW, CAP---1/4---20 X 1
016 95923298 45 EA NUT, ELASTIC LOCK---1/4---20
017 95934782 4 EA SCREW, CAP---1/4---20 X1---3/4
018 95934857 10 EA SCREW, CAP---1/4---20 X1---1/4
57391039

page 413 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57391039 DUST CURTAIN INSTL.

DUST CURTAIN INSTL.

57391039

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 414
 Serial Number: 4133
FAMILY,DM50

57144099 WATER INJ 3GPM/100 GAL

36 1
3 4
5
6 7
WATER INJ 3GPM/100 GAL

9
48
49
50 8
10
11
12

13 39
38
14
15
2 TO WATER PORT
ON TOWER PIPING

16

31 1
34 17
19
57144099

33
32
20
21
24 22
18
23

25
26

27
28
29 37

30

Figure 210 :WATER INJ 3GPM/100 GAL

D57144099 REV 00
page 415 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57144099 WATER INJ 3GPM/100 GAL

35

WATER INJ 3GPM/100 GAL

HYDRAULIC
36
RESERVOIR
36

57144099
36 41

42 42

44 43
45
46
47 47

42

NINE SPOOL VALVE

Figure 211 :WATER INJ 3GPM/100 GAL

D57144099 REV 00
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 416
 Serial Number: 4133
FAMILY,DM50

57144099 WATER INJ 3GPM/100 GAL

REF. PART NO. QTY. UNIT DESCRIPTION

001 57048977 1 EA PUMP, 3GPM WATER INJ. (See figure 212)

WATER INJ 3GPM/100 GAL

002 57250250 1 EA MOTOR, HYDRAULIC (See figure 213)

003 57144032 1 EA BASE MTG, WTR INJECTION
004 95934816 4 EA SCREW, CAP---1/4---20 X 1
005 95934766 4 EA WASHER, LOCK---1/4 PLATED
006 95922324 4 EA WASHER, FLAT---1/4
007 95101705 1 EA PLUG, PIPE---HEXSOCKET,3/8
008 95279493 1 EA FITTING, HYD
009 57144305 1 EA COUPLING, CHAIN
010 95928982 2 EA SCREW, CAP---1/4---20 X 3/4
011 95934766 2 EA WASHER, LOCK---1/4 PLATED
012 52231107 1 EA GUARD, COUPLING
013 95934469 2 EA CAPSCREW,HEX HEAD
014 95922902 2 EA NUT,HEX,FINISHED,PLATED
015 95934733 2 EA WASHER,LOCK
016 52146883 1 EA VALVE, RELIEF
017 95279493 1 EA FITTING, HYD
018 95315214 1 EA FITTING, HYD
57144099

019 95063475 1 EA TEE

020 95286563 1 EA ADAPTER
021 56962368 1 EA HOSE ASSY
022 95037347 1 EA BUSHING
023 95267092 1 EA PETCOCK
024 95030763 1 EA ELBOW, STREET
025 50247709 17.00 IN TUBING, VINYL
026 50364199 2 EA FITTING, TUBE
027 95934733 6 EA WASHER,LOCK
028 95104170 6 EA SCREW, CAP---1/2---13 X1---1/2
029 95922902 6 EA NUT,HEX,FINISHED,PLATED
030 95101051 1 EA PLUG, PIPE---1---1/4 SQ HEAD
031 95219721 2 EA FITTING, HYD
032 57113714 1 EA TANK,WATER---100 GAL HORIZ
95446571 1 EA D COUPLING
95446563 2 EA D COUPLING
95446522 1 EA D COUPLING
033 95101044 1 EA PLUG, PIPE---1 SQ HEAD
034 50067479 1 EA CAP
page 417 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57144099 WATER INJ 3GPM/100 GAL

REF. PART NO. QTY. UNIT DESCRIPTION

035 95330692 2 EA ADAPTER,90DEG---O---RING/JIC

WATER INJ 3GPM/100 GAL

036 57009367 2 EA HOSE ASSY
037 95219853 1 EA FITTING, HYD
038 57053761 1 EA HOSE ASSY
039 95338406 1 EA FITTING, HYD
041 57011306 1 EA HOSE ASSY
042 56954167 3 EA HOSE ASSY
043 50518984 1 EA VALVE, FLOW CONTROL
044 95958732 2 EA SCREW,FLAT HD---1/4---20X3
045 95931564 2 EA NUT, HEX---1/4---20
046 95934766 2 EA WASHER, LOCK---1/4 PLATED
047 95279501 3 EA FITTING, HYD
048 58153271 1 EA HUB
049 58121286 1 EA CHAIN
050 58123399 1 EA COVER

57144099

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 418
 Serial Number: 4133
FAMILY,DM50

57048977 PUMP, 3GPM WATER INJ.

311 ---COVER,CRANK CASE (NOT SHOWN)

WATER INJ 3GPM/100 GAL

305
305
305
57144099

305
306
300 302
302 302
302
302
300 302
302 302
302 310
302
300
302
310

310
300
302
305
306

Figure 212 :PUMP, 3GPM WATER INJ.

A57048977 REV 002
page 419 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57048977 PUMP, 3GPM WATER INJ.

REF. PART NO. QTY. UNIT DESCRIPTION

300 57047995 1 EA KIT,CUP

WATER INJ 3GPM/100 GAL

302 57070559 1 EA KIT,PISTON
305 57070534 1 EA KIT,SLVE SEL
306 57048001 1 EA KIT,SEAL
310 57070542 1 EA KIT,VALVE
311 54503743 1 EA COVER,CRANK CASE

57144099

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 420
 Serial Number: 4133
FAMILY,DM50

57250250 MOTOR, HYDRAULIC

28 ---Plug
WATER INJ 3GPM/100 GAL

000
000
000

000
9
7 8
000
000 18

13 14

000
10
57144099

12

1 4

Figure 213 :MOTOR, HYDRAULIC

C57250250 REV01
page 421 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57250250 MOTOR, HYDRAULIC

REF. PART NO. QTY. UNIT DESCRIPTION

000 57250276 1 EA KIT, SEAL

WATER INJ 3GPM/100 GAL

001 50491729 4 EA SCREW, CAP---5/16 X 7/8
004 52188851 1 EA FLANGE, MOUNTING
007 52188885 1 EA RACE, BEARING
008 56001118 1 EA BEARING, MOTOR
009 52188893 1 EA KEY,WOODRUFF
010 52188901 1 EA SHAFT, OUTPUT
012 59671081 1 EA HOUSING
013 52188935 1 EA DRIVE SHAFT
014 59671107 1 EA PLATE, SPACER
018 50998145 1 EA CAP, END
028 50998103 1 EA PLUG

57144099

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 422
 Serial Number: 4133
FAMILY,DM50

57112955 LUBRICATOR ---AIR LINE(PIG)

LUBRICATOR---AIR LINE(PIG)

6 12
13

8
1

5
2
57112955

Figure 214 :LUBRICATOR--- AIR LINE(PIG)

D57112955 REV00
page 423 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57112955 LUBRICATOR ---AIR LINE(PIG)

REF. PART NO. QTY. UNIT DESCRIPTION

001 52211679 1 EA BODY LUB

LUBRICATOR---AIR LINE(PIG)
002 52215233 1 EA NOZZLE,COMPLETE,ASM (See figure 215)
003 95033700 1 EA PLUG,PIPE
004 50118694 1 EA PLUG,OIL
005 95087052 1 EA O---RING
006 57095069 1 EA HOSE ASSY
007 52214384 1 EA VENTURI,BSHG
008 95209094 1 EA FITTING,HYD
012 95279071 1 EA FITTING,HYD
013 50068279 1 EA PIN,NOZZLE

57112955

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 424
 Serial Number: 4133
FAMILY,DM50

52215233 NOZZLE,COMPLETE,ASM

4
5
LUBRICATOR---AIR LINE(PIG)

3
6

9
57112955

8
10

Figure 215 :NOZZLE,COMPLETE,ASM

C356764 REV 002
page 425 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

52215233 NOZZLE,COMPLETE,ASM

REF. PART NO. QTY. UNIT DESCRIPTION

001 95018651 1 EA O’RING

LUBRICATOR---AIR LINE(PIG)
002 95213427 1 EA WASHER,LOCK---5/8 EXT.
003 50109198 2 EA SPRING
004 50064096 1 EA NEEDLE VALVE
005 50007384 1 EA CAP
006 95000253 1 EA O’RING
007 50068253 1 EA NOZZLE COLLR
008 95076808 1 EA NUT,HEX
009 50306315 1 EA NOZZLE
010 52215225 1 EA TUBE,OIL

57112955

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 426
 Serial Number: 4133
FAMILY,DM50

57390601 CENTRAL LUB SYSTEM ---25 FT

21 21 65
23 ---NOT SHOWN
24 ---NOT SHOWN
26 ---NOT SHOWN
29 ---NOT SHOWN
CENTRAL LUB SYSTEM---25 FT

64

SEE DETAIL C
51 ---NOT SHOWN

TOWER
48 20
50
6 47
49
SEE DETAIL G

31 57 22
55 20
53 34 52
33

56

SEE DETAIL E
54
TOWER RAISING CYL. 30
SEE DETAIL J

20 61 60

32
20 20
1

46 TO THE YOKE

45 20 44
57390601

74
78
82
83
44
42
73
78
82
SEE DETAIL D
83
43
CAROUSELBLOCK

4
ROD CHANGER

7
35
70
69
71
WINCH
74 20 SEE DETAIL A
78 17
82 72 68 20
83 7

Figure 216 :CENTRAL LUB SYSTEM--- 25 FT

E57390601 REV 00
page 427 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57390601 CENTRAL LUB SYSTEM ---25 FT

20
67

4 SEE DETAIL F

CENTRAL LUB SYSTEM---25 FT

6
66
63

62
31

9 4
18 6 SEE DETAIL B
19 20
61 37 14
15
60 36
17
57

58

35

74
78

57390601
82
83 SEE DETAIL L

92
46
K

20
43

20 71 20
70
69
76
84 68
85
86 20
7

Figure 217 :CENTRAL LUB SYSTEM--- 25 FT

E57390601 REV 00
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 428
 Serial Number: 4133
FAMILY,DM50

57390601 CENTRAL LUB SYSTEM ---25 FT

13
77
82 13
18
CENTRAL LUB SYSTEM---25 FT

83 17
77
82
18 83
35
7

20
TOWER
8
DETAIL A

12 10
77 77
82 4 82
11 83 83 16

33
18
6
12 5 20
77 8
82
83 DETAIL B
6
16 18
57390601

34
20

8
13 10
DETAIL C 77
82 77
32 11 4 82
83 83 27 41
16
7
20
5

8
DETAIL D

Figure 218 :CENTRAL LUB SYSTEM--- 25 FT

E57390601 REV 00
page 429 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57390601 CENTRAL LUB SYSTEM ---25 FT

12
77
81 12 10
10 77 77

CENTRAL LUB SYSTEM---25 FT

82 6
16 16 17 82 82 18
37 83 11
83

36
37
20 20
6
8 4
8
8
DETAIL E DETAIL F

9 18
19
81

35
79 80 17 36 16 15
14 31

57390601
DETAIL G

32
30 16 34 31
78 17
82
83 14
14
15
73 79 9
74 15
33 16 80 19 18
75 81

DETAIL H TYP. ALL PLACES DETAIL J

Figure 219 :CENTRAL LUB SYSTEM--- 25 FT

E57390601 REV 00
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 430
 Serial Number: 4133
FAMILY,DM50

57390601 CENTRAL LUB SYSTEM ---25 FT

98 97 1.4
97 1.1 95
107
107
CENTRAL LUB SYSTEM---25 FT

1.6 DETAIL L
2
1.6 107 25

107 1.2
1.3

97

DETAIL M
40
25
1.5 41
28
85
86
87 98
94 104
85
86 25 VIEW K -- K
87
93
39
25 3 1.7 108 109
57390601

25 85 109 98
86
N

SEE DETAIL M
110 98
108 97
N

97 96

106
102 101
103 101 98 41
98
4

101 99
100
101 DETAIL D

Figure 220 :CENTRAL LUB SYSTEM--- 25 FT

E57390601 REV 00
page 431 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57390601 CENTRAL LUB SYSTEM ---25 FT

REF. PART NO. QTY. UNIT DESCRIPTION

001 57166795 1 EA PUMP/TIMER,LINCOLNCENTRL (See figure 221)

CENTRAL LUB SYSTEM---25 FT

002 56967292 1 EA SWITCH ASSY
003 56799125 1 EA VENT, FILTER
004 57070757 3 EA INJECTOR, SL1/2 BANK
005 57137036 6 EA TUBE---CROSS PORT CONNECT.
006 57070773 5 EA INJECTOR, SL1/4 BANK
007 57070781 2 EA INJECTOR,SL1/5 BANK
008 57070849 38 EA CAP, COVER
009 57083883 2 EA MANIFOLD,HYD
56849672 1 EA D MANIFOLD
010 57071383 4 EA BRACKET
011 95056412 4 EA NIPPLE
012 57071409 5 EA BRACKET
013 57071417 2 EA BRACKET
014 85597904 3 EA FITTING, HYD
015 95286563 3 EA ADAPTER
016 95279519 8 EA FITTING, HYD
017 50814581 4 EA FITTING, HYD

57390601
018 95408167 8 EA PLUG, PIPE
019 95033585 8 EA PLUG, PIPE---1/8 SQ HEAD
020 95209086 58 EA FITTING, HYD
021 95287629 2 EA FITTING, HYD
022 95302170 2 EA FITTING, HYD
023 95048377 1 EA NIPPLE
024 50829605 1 EA VALVE,BALL---1/2
025 95279535 5 EA FITTING, HYD
026 95219721 1 EA FITTING, HYD
027 95219713 1 EA FITTING, HYD
028 95316972 1 EA FITTING, HYD---NPT/JIC
029 95286902 1 EA FITTING
030 57249088 1 EA HOSE ASSY
031 F16X000J--- ---/J--- --- 1 EA FC310---16 HOSE INDICATOR
032 57022246 1 EA HOSE ASSY
033 56987936 1 EA HOSE ASSY
034 56955115 1 EA HOSE ASSY
035 57429573 1 EA HOSE ASSY
036 52228475 1 EA HOSE ASSY
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 432
 Serial Number: 4133
FAMILY,DM50

57390601 CENTRAL LUB SYSTEM ---25 FT

REF. PART NO. QTY. UNIT DESCRIPTION

037 56954282 1 EA HOSE ASSY

CENTRAL LUB SYSTEM---25 FT

039 56954159 1 EA HOSE ASSY

040 56956139 1 EA HOSE ASSY
041 56961824 1 EA HOSE ASSY
042 58170465 1 EA HOSE ASSY
043 52226479 1 EA HOSE ASSY
044 56964299 1 EA HOSE ASSY
045 57005688 1 EA HOSE ASSY
046 56964315 1 EA HOSE ASSY
047 56970627 1 EA HOSE ASSY
048 58081662 1 EA HOSE ASSY
049 57043218 1 EA HOSE ASSY
050 56966211 1 EA HOSE ASSY
051 58140328 1 EA HOSE ASSY
052 56964190 1 EA HOSE ASSY
053 56973621 1 EA HOSE ASSY
054 56964273 1 EA HOSE ASSY
055 56972698 1 EA HOSE ASSY
57390601

056 56974579 1 EA HOSE ASSY

057 57044711 1 EA HOSE ASSY
058 56964141 1 EA HOSE ASSY
060 52244449 1 EA HOSE ASSY
061 58081662 1 EA HOSE ASSY
062 56970627 1 EA HOSE ASSY
063 56974579 1 EA HOSE ASSY
064 57020760 1 EA HOSE ASSY
065 52226768 1 EA HOSE ASSY
066 56964240 1 EA HOSE ASSY
067 57004020 1 EA HOSE ASSY
068 56975980 1 EA HOSE ASSY
069 56964216 1 EA HOSE ASSY
070 57036600 1 EA HOSE ASSY
071 57043200 1 EA HOSE ASSY
072 56975980 1 EA HOSE ASSY
073 95301859 30 EA CLAMP, HOSE
074 95378873 12 EA CLAMP, HOSE
075 95445664 6 EA CLAMP,HOSE
page 433 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57390601 CENTRAL LUB SYSTEM ---25 FT

REF. PART NO. QTY. UNIT DESCRIPTION

076 50034826 12 EA CLAMP,HOSE,HALF

CENTRAL LUB SYSTEM---25 FT

077 95935128 17 EA SCREW, CAP---3/8---16 X 2
078 95934550 48 EA SCREW, CAP---3/8---16 X 3/4
079 95035465 2 EA SCREW, CAP---3/4---10 X2---1/2
080 95934691 2 EA WASHER,LOCK,HELICAL
081 95922928 2 EA NUT,HEX,FINISHED
082 95937413 68 EA WASHER, LOCK---3/8 PLATED
083 95922894 68 EA NUT, HEX---3/8---16
084 95920724 12 EA SCREW, CAP---1/4---20 X1---1/2
085 95934766 18 EA WASHER, LOCK---1/4 PLATED
086 95931564 18 EA NUT, HEX---1/4---20
087 95430229 2 EA U---BOLT
092 56924764 2 EA GUSSET
093 57518003 1 EA BRACKET,MTG---CENTRO LUBE
094 57070732 1 EA FILTER REG.
57516700 1 EA D GUAGE 0---300 PSI
095 56976954 2 EA GREASE,EP0
096 52175809 1 EA BOX, 1/2 STONCO
097 95368536 4 EA CONNECTOR, 1/2 45 DEG

57390601
098 95245049 120.00 IN CONDUIT,FLEX---1/2SEALTITE
099 95344719 1 EA OUTLET BODY
100 57358830 240.00 IN CONDUIT, 3/8 NYLON
101 95245221 5 EA CONNECTOR, STRAIGHT---1/2
102 39116819 1 EA COVER
103 50625888 1 EA BOX, HANDY
104 95361390 1 EA CONNECTOR, 1/2 90 DEG
106 95011094 1 EA COUPLING
107 95256723 6 EA CLAMP---1/2
108 56992191 2 EA CONNECTOR
109 58150103 60.00 IN CORD,14/2
110 52231792 1 EA U---BOLT

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 434
 Serial Number: 4133
FAMILY,DM50

57166795 PUMP/TIMER,LINCOLNCENTRL
CENTRAL LUB SYSTEM---25 FT

5
7
57390601

Figure 221 :PUMP/TIMER,LINCOLNCENTRL

A57166795 REV002
page 435 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57166795 PUMP/TIMER,LINCOLNCENTRL

REF. PART NO. QTY. UNIT DESCRIPTION

001 56964869 1 EA PUMP,50 TO 1

CENTRAL LUB SYSTEM---25 FT

57420127 1 EA D KIT, PUMP REPAIR
57420135 1 EA D KIT, PUMP TUBE REPAIR
002 57420085 1 EA VENT ASSEMBLY
003 57420093 1 EA PLATE, FOLLOWER
004 57420101 1 EA COVER,DRUM & TIE DN ASSY
005 57209884 1 EA SWITCH, PRESSURE
006 57530446 1 EA CONTROLLER,SENTRYMONITOR
57530453 1 EA D BOARD, SENTRY PROCESSOR
57530461 1 EA D BOARD, SENTRY PWR SUPPLY
007 57312563 1 EA VALVE,SOLENOID---3WAY/2POS

57390601

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 436
 Serial Number: 4133
FAMILY,DM50

57143513 FIRE PROTECTION SYSTEM

111
112
119
FIRE PROTECTION SYSTEM

12

18
13
11

16
2
113
10
57143513

15
15

98
14

17

Figure 222 :FIRE PROTECTION SYSTEM

D57143513 REV02
page 437 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57143513 FIRE PROTECTION SYSTEM

5 104 102 101

103
110

FIRE PROTECTION SYSTEM

VIEW K
109 SEE DETAIL H
107 106
108 2 105 25

24

25
16
15

116 NOT SHOWN

57143513
117 NOT SHOWN 17
18
118 NOT SHOWN
115 105 23 28 6
25
23

28

114

23 28
28
109 30
114 26 31
6 32
DETAIL H

Figure 223 :FIRE PROTECTION SYSTEM

D57143513 REV02
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 438
 Serial Number: 4133
FAMILY,DM50

57143513 FIRE PROTECTION SYSTEM

19 20 21
8 21 3 7
22
FIRE PROTECTION SYSTEM

113

VIEW B 4
9 10
101
4
101

1
10

VIEW E
57143513

101

4
5
101
11

VIEW G
VIEW F

Figure 224 :FIRE PROTECTION SYSTEM

D57143513 REV02
page 439 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57143513 FIRE PROTECTION SYSTEM

FIRE PROTECTION SYSTEM

5
103

5
101
9

VIEW C

57143513
103

33

VIEW D

Figure 225 :FIRE PROTECTION SYSTEM

D57143513 REV02
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 440
 Serial Number: 4133
FAMILY,DM50

57143513 FIRE PROTECTION SYSTEM

REF. PART NO. QTY. UNIT DESCRIPTION

001 57140048 1 EA KIT, FIRE SUPPRESSION

FIRE PROTECTION SYSTEM

101 50583236 6 EA D NOZZLE

102 50844059 8 EA D BRACKET, NOZZLE
103 56997166 2 EA D NOZZLE
104 56997141 8 EA D LOCKWASHER
105 56997109 2 EA D ACTUATOR, PNEUMATIC
106 52168259 2 EA D CARTRIDGE
107 52168374 2 EA D BRACKET, TANK MOUNTING
108 52168234 2 EA D TANK, CHEMICAL
56997679 1 EA D DISC, BURST
109 52168267 2 EA D BRACKET, CARTRIDGE
110 52168325 8 EA D CAP, BLOW OFF
111 57065427 2 EA D ACTUATOR
112 57065435 2 EA D BRACKET, ACTUATOR
113 50844067 2 EA D TEE,TRIPLE
114 56990849 2 EA D VALVE, CHECK
115 50583228 2 EA D VALVE, SAFETY VENT
116 56997216 1 EA D LABEL, OPERATING INSTRUCT
57143513

117 56997224 2 EA D SEAL, LEAD WIRE

118 56997679 4 EA D DISC, BURST
119 50583251 2 EA D CARTRIDGE
002 57224347 1 EA MOUNT, FIRE PROTECTION
003 95324117 4 EA U---BOLT, 3/8RODX 1---1/4PIPE
004 95386959 4 EA FITTING, HYD
005 95279212 4 EA FITTING, HYD
006 95675880 2 EA TEE---INT NPT/JIC/INT NPT
007 56954159 1 EA HOSE ASSY
008 56956147 1 EA HOSE ASSY
009 56955628 1 EA HOSE ASSY
010 56959836 1 EA HOSE ASSY
011 57004053 1 EA HOSE ASSY
012 58146622 1 EA HOSE ASSY
013 57009367 1 EA HOSE ASSY
014 57004053 1 EA HOSE ASSY
015 56960826 1 EA HOSE ASSY
016 56957822 1 EA HOSE ASSY
017 57107450 1 EA HOSE ASSY
page 441 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57143513 FIRE PROTECTION SYSTEM

REF. PART NO. QTY. UNIT DESCRIPTION

018 56954217 1 EA HOSE ASSY

FIRE PROTECTION SYSTEM

019 95922894 8 EA NUT, HEX---3/8---16
020 95937413 8 EA WASHER, LOCK---3/8 PLATED
021 95279535 8 EA FITTING, HYD
022 95264974 2 EA FITTING, HYD
023 95679593 3 EA FITTING, HYD
024 95219721 2 EA FITTING, HYD
025 95293403 5 EA FITTING, HYD
026 95323457 2 EA FITTING, HYD
028 56964133 4 EA HOSE ASSY
030 95335154 2 EA U---BOLT, 1/4ROD X 1” PIPE
031 95242368 4 EA NUT, HEX JAM---1/4---20
032 95934766 4 EA WASHER, LOCK---1/4 PLATED
033 56956139 1 EA HOSE ASSY

57143513

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 442
 Serial Number: 4133
FAMILY,DM50

57340317 DEI INSTL---DM45 MULTIPASS

16
DEI INSTL---DM45 MULTIPASS

16

TO DEI

12
13
14 10 8
15
57340317

11

Figure 226 :DEI INSTL--- DM45 MULTIPASS

C57340317 REV 02
page 443 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57340317 DEI INSTL---DM45 MULTIPASS

REF. PART NO. QTY. UNIT DESCRIPTION

001 57191082 1 EA INDICATOR, DRILLING EFF. (See figure 227)

DEI INSTL---DM45 MULTIPASS

008 57340333 1 EA KIT,ANSI 25 SPROCKET 96T
010 95293403 1 EA FITTING, HYD
011 F04X000J--- ---/J--- --- 1 EA FC310---04 HOSE INDICATOR
012 57130577 1 EA HOLDER, FUSE
013 52279338 1 EA FUSE
014 58150103 300.00 IN CORD,14/2
015 57394603 1 EA RELAY, DPDT 24V COIL
016 56981459 1 EA BAR, FLAT

57340317

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 444
 Serial Number: 4133
FAMILY,DM50

57191082 INDICATOR, DRILLING EFF.

DEI INSTL---DM45 MULTIPASS

5
7
57340317

4
2

6 POWER CABLE CONNECT TO ITEM 5

BY WAY OF CONSOLE TERMINAL
BLOCKS.

8 OPERATOR’S MANUAL

Figure 227 :INDICATOR, DRILLING EFF.

A57191082 REV 004
page 445 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57191082 INDICATOR, DRILLING EFF.

REF. PART NO. QTY. UNIT DESCRIPTION

001 57146037 1 EA DIGITAL DISPLAY

DEI INSTL---DM45 MULTIPASS

002 57146045 1 EA ENCODER, OPTICAL SHAFT
003 57191462 1 EA CABLE,60 FT. ENCODER
004 57146060 1 EA HARDWARE, ENCODER MTG.
005 57301038 1 EA SWITCH, ADJ. AIR
006 57146086 1 EA CABLE, 8 FT. POWER
007 57146094 1 EA CABLE, AIR SWITCH---10 FT
008 57146102 1 EA MANUAL, OPERATORSSERVICE

57340317

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 446
 Serial Number: 4133
FAMILY,DM50

57379349 INSTL---BATTERY EQUALIZER

3
INSTL---BATTERY EQUALIZER

15

1 4
5
6
BATTERY 7
BOX
2

14
8 12
13 11
2LV (12V)
TO POSITIVE TERMINAL
ON STARTER
(12V) (GND)
10
(GND)
9 TO NEGATIVE TERMINAL
ON STARTER 10
13
57379349

12

Figure 228 :INSTL--- BATTERY EQUALIZER

D57379349 REV00
page 447 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57379349 INSTL---BATTERY EQUALIZER

REF. PART NO. QTY. UNIT DESCRIPTION

001 57175804 1 EA EQUALIZER, 20A. BATTERY

INSTL---BATTERY EQUALIZER
002 50625888 1 EA BOX, HANDY
003 39116819 1 EA COVER
004 95934816 4 EA SCREW, CAP---1/4---20 X 1
005 95922324 8 EA WASHER, FLAT---1/4
006 95934766 4 EA WASHER, LOCK---1/4 PLATED
007 95931564 8 EA NUT, HEX---1/4---20
008 50249689 84.00 IN WIRE, 10AWG---RED
009 50628809 24.00 IN WIRE, 10AWG---WHITE
010 50249697 240.00 IN WIRE, 10AWG---BLACK
011 58180076 150.00 IN WIRE, 10 AWG---PINK
012 58150194 6 EA TERMINAL,RING
013 95359329 2 EA TERMINAL, RING
014 95239216 2 EA JOINT, WIRE
015 57379174 1 EA NAMEPLATE---12V DC POWER

57379349

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 448
 Serial Number: 4133
FAMILY,DM50

TOOLS/ACCESSORIES
SECTION
TOOLS/ACCESSORIES

page 449 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

SECTION
TOOLS/ACCESSORIES

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 450
 Serial Number: 4133
FAMILY,DM50

50814516 BASIC TOOLS---6.25/4.0BECO

BASIC TOOLS---6.25/4.0BECO

List only, no drawing required.

50814516

Figure 229 :BASIC TOOLS--- 6.25/4.0BECO

NONE REV 000
page 451 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50814516 BASIC TOOLS---6.25/4.0BECO

REF. PART NO. QTY. UNIT DESCRIPTION

003 57036527 1 EA BUSHING ASSY---6---1/4 ROD

BASIC TOOLS---6.25/4.0BECO
57029092 1 EA D BUSHING,CENT
57029126 1 EA D TUBING
57029118 1 EA D PLATE
57029100 2 EA D BAR,FLAT
57029027 1 EA D SLEEVE,WEAR---6---1/4 ROD
008 52237096 1 EA LIFTING BAIL---4 BECO
009 50260314 1 EA WRENCH,CHAIN---5.313---6.25 (See figure 230)
010 50243088 1 EA REST, WRENCH
011 50621325 1 EA BIT REST---20 TABLE
95269536 1 EA D SCREW,CAP
020 52230786 1 EA WRENCH, CHAIN ADJUSTING
10040541 1 EA D SOCKET
57024218 1 EA D TUBING,RND
027 50219955 1 EA PIN, LOCKING

50814516

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 452
 Serial Number: 4133
FAMILY,DM50

50260314 WRENCH,CHAIN---5.313---6.25
BASIC TOOLS---6.25/4.0BECO

1
2

3
50814516

Figure 230 :WRENCH,CHAIN--- 5.313--- 6.25

V339177 REV 01
page 453 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50260314 WRENCH,CHAIN---5.313---6.25

REF. PART NO. QTY. UNIT DESCRIPTION

001 50021120 1 EA TONG ASSY---W/FLAT INSERTS (See figure 231)

BASIC TOOLS---6.25/4.0BECO
002 50021138 1 EA CHAIN ASSY (See figure 232)
003 50021377 2 EA CHAIN SECT---2 LINKS
004 58229790 2 EA BOLT AND NUT

50814516

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 454
 Serial Number: 4133
FAMILY,DM50

50021120 TONG ASSY---W/FLAT INSERTS

BASIC TOOLS---6.25/4.0BECO

9 11

6
50814516

13 7

12
2
4 3
5 10

Figure 231 :TONG ASSY--- W/FLAT INSERTS

W287976 REV 00
page 455 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50021120 TONG ASSY---W/FLAT INSERTS

REF. PART NO. QTY. UNIT DESCRIPTION

001 50209675 1 EA HANDLE, CHAIN TONG

BASIC TOOLS---6.25/4.0BECO
002 50021187 1 EA JAW---CHAIN TONG
003 50024397 4 EA INSERT,JAW---FLAT
004 50024389 4 EA KEY,INSERT---CHAIN TONG
005 50024371 4 EA SPRING, CHAIN TONG
006 50014414 1 EA BOLT,JAW---CHAIN TONG
007 50021229 1 EA SPRING, CHAIN TONG
008 50024512 1 EA PIN,SPRING---CHAIN TONG
009 50021237 1 EA BUSHING, CHAIN TONG
010 50209501 1 EA GUIDE,SPRING---CHAIN TONG
011 50021202 1 EA PIN,HANDLE---CHAIN TONG
012 95076907 1 EA NUT,HEX,JAM
013 95002697 1 EA PIN, COTTER

50814516

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 456
 Serial Number: 4133
FAMILY,DM50

50021138 CHAIN ASSY

2
BASIC TOOLS---6.25/4.0BECO

5
50814516

5
9

11

10

Figure 232 :CHAIN ASSY

D293175 REV 03
page 457 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50021138 CHAIN ASSY

REF. PART NO. QTY. UNIT DESCRIPTION

001 50024447 1 EA MASTER LINK

BASIC TOOLS---6.25/4.0BECO
57082349 1 EA D BURNOUT
002 50021195 1 EA PIN
003 50021393 1 EA CHAIN,MASTER
004 50021377 2 EA CHAIN SECT---2 LINKS
005 58229790 2 EA BOLT AND NUT
008 50021195 1 EA PIN
009 50021161 1 EA NUT
010 95033932 1 EA PIN, ROLL
011 50021153 1 EA SCREW,CHAIN
57082331 1 EA D BURNOUT

50814516

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 458
 Serial Number: 4133
FAMILY,DM50

57059453 DECALS---DM50 COMMONS

DECALS---DM50 COMMONS

2
57059453

1
3

RADIATOR

Figure 233 :DECALS--- DM50 COMMONS

E57059370 REV 007
page 459 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57059453 DECALS---DM50 COMMONS

DECALS---DM50 COMMONS
7

57059453
TOWER 5

Figure 234 :DECALS--- DM50 COMMONS

E57059370 REV 007
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 460
 Serial Number: 4133
FAMILY,DM50

57059453 DECALS---DM50 COMMONS

REF. PART NO. QTY. UNIT DESCRIPTION

001 57095895 1 EA DECAL,MACHINE---DM50E

DECALS---DM50 COMMONS

002 57093478 1 EA DECAL,MACHINE---DM50E

003 57497927 2 EA DECAL, CORP. NAMEPLATE
005 57621310 2 EA DECAL,IR BUG
007 35861269 2 EA DECAL,CORPORATENAMEPLATE
57059453

page 461 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57059453 DECALS---DM50 COMMONS

DECALS---DM50 COMMONS
57059453

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 462
 Serial Number: 4133
FAMILY,DM50

50623867 SEAL, ROD---6.25 IN ROD

ROD SEAL 6.25”
50623867

13

13

3
1

Figure 235 :SEAL, ROD--- 6.25 IN ROD

C50622596 REV02
page 463 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

50623867 SEAL, ROD---6.25 IN ROD

REF. PART NO. QTY. UNIT DESCRIPTION

001 95081659 4 EA WASHER,FLAT---7/8

ROD SEAL 6.25”

002 95433819 4 EA CLIP
003 50453729 1 EA HOLDER, ROD SEAL
013 50461904 2 EA SEAL,ROD

50623867

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 464
 Serial Number: 4133
FAMILY,DM50

57328205 FILTER KIT,FIELD REPLACE

FILTER KIT,FIELD REPLACE

List only, no drawing required.

57328205

Figure 236 :FILTER KIT,FIELD REPLACE

NONE REV 000
page 465 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57328205 FILTER KIT,FIELD REPLACE

REF. PART NO. QTY. UNIT DESCRIPTION

001 52263183 2 EA ELEMENT, FILTER---MAIN HYD

FILTER KIT,FIELD REPLACE

004 36860336 2 EA ELEMENT,OIL FILTER
005 57336406 1 EA ELEMENT,KF3 FILTER S3

57328205

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 466
 Serial Number: 4133
FAMILY,DM50

57147910 DECALS, SAFETY

1
2
DECALS, SAFETY

HYDRAULIC TANK
TOWER RAISING CYLINDER

4
57147910

ENGINE ASSEMBLY /COUPLING GUARD

6
5
7

COOLER

Figure 237 :DECALS, SAFETY

D57147910 REV 009
page 467 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57147910 DECALS, SAFETY

9
10

DECALS, SAFETY
SPUR GEAR
POWER HEAD

8
BATTERY BOX ON RIG
8
11

57147910
RECEIVER TANK
( END VIEW )

12

TOWER BOTTOM

Figure 238 :DECALS, SAFETY

D57147910 REV 009
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 468
 Serial Number: 4133
FAMILY,DM50

57147910 DECALS, SAFETY

13
DECALS, SAFETY

ROD CHANGER CYLINDER

14
57147910

JACK ASSEMBLY

15

HYDRAULIC TANK
(TOP VIEW)

Figure 239 :DECALS, SAFETY

D57147910 REV 009
page 469 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57147910 DECALS, SAFETY

18 000 DECAL & MANUAL SET(Not Shown)

20 MANUAL, SAFETY(Not Shown)
21 RIVET, DRIVE(Not Shown)

DECALS, SAFETY
19

25 SCREW,CAP---1/4---20 X 1/2(Not Shown)

24
26 WASHER, FLAT---1/4(Not Shown)

16

57147910
17 22

Figure 240 :DECALS, SAFETY

D57147910 REV 009
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 470
 Serial Number: 4133
FAMILY,DM50

57147910 DECALS, SAFETY

REF. PART NO. QTY. UNIT DESCRIPTION

DECALS, SAFETY

000 57404295 1 EA DECAL & MANUALSET---DM45/5

57140360 2 EA D DECAL,WARNING---FALLDERRIC
57140477 1 EA D DECAL, CAUTION---EXCESSOIL
57140345 2 EA D DECALWARNING---ROTAT.PARTS
57140337 2 EA D DECAL,WARNING---ROTATINGPT
57140469 2 EA D DECAL,WARNING---ROT.BLADE
57140444 1 EA D DECAL, ENG.FAILURECOOLSY
57140402 1 EA D DECAL, WARNING---HOT FLUID
57140352 2 EA D DECAL,WARNING---HIGH PRESS
57140394 1 EA D DECALWARNING---COMBUST.GAS
57140410 1 EA D DECAL,WARNING---POWERHEAD
57140428 1 EA D DECAL, WARNING---HIGHPRESS
57140329 2 EA D DECAL,WARNING---FALL PWRHD
57140386 2 EA D DECAL,WARNING---FALLCAROUS
57140378 1 EA D DECAL,WARNING---FALL DRLPI
57156465 1 EA D DECAL,NOTICE---HYD.FAILURE
57310831 1 EA D DECAL,WARNING---DON’TALTER
57147910

57311086 1 EA D DECAL, DANGER---HAZ. VOLT.

57335192 1 EA D DECAL, WARNING---FANBLADES
57335200 1 EA D DECAL, NOTICE---DUST
57311151 1 EA D MANUAL,SAFETY---DM45/50/L(See figure 241)
57318040 2 EA D DECAL, WARNING---NOCLIMBNG
57345878 2 EA D DECAL, NOTICE
001 57140360 0 EA DECAL,WARNING---FALLDERRIC
002 57140477 0 EA DECAL, CAUTION---EXCESSOIL
003 57140345 0 EA DECALWARNING---ROTAT.PARTS
004 57140337 0 EA DECAL,WARNING---ROTATINGPT
005 57140469 0 EA DECAL,WARNING---ROT.BLADE
006 57140444 0 EA DECAL, ENG.FAILURECOOLSY
007 57140402 0 EA DECAL, WARNING---HOT FLUID
008 57140352 0 EA DECAL,WARNING---HIGH PRESS
009 57140394 0 EA DECALWARNING---COMBUST.GAS
010 57140410 0 EA DECAL,WARNING---POWERHEAD
011 57140428 0 EA DECAL, WARNING---HIGHPRESS
012 57140329 0 EA DECAL,WARNING---FALL PWRHD
013 57140386 0 EA DECAL,WARNING---FALLCAROUS
page 471 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57147910 DECALS, SAFETY

REF. PART NO. QTY. UNIT DESCRIPTION

014 57140378 0 EA DECAL,WARNING---FALL DRLPI

DECALS, SAFETY
015 57156465 0 EA DECAL,NOTICE---HYD.FAILURE
016 57310831 0 EA DECAL,WARNING---DON’TALTER
017 57311086 0 EA DECAL, DANGER---HAZ. VOLT.
018 57335192 0 EA DECAL, WARNING---FANBLADES
019 57335200 0 EA DECAL, NOTICE---DUST
020 57311151 0 EA MANUAL,SAFETY---DM45/50/L (See figure 241)
021 57318693 1 EA RIVET, DRIVE
022 57318040 0 EA DECAL, WARNING---NOCLIMBNG
024 57345878 0 EA DECAL, NOTICE
025 95934774 2 EA SCREW,CAP---1/4---20 X 1/2
026 95922183 2 EA WASHER, FLAT---1/4

57147910

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 472
 Serial Number: 4133
FAMILY,DM50

57311151 MANUAL,SAFETY---DM45/50/L
DECALS, SAFETY

List only, no drawing required.

57147910

Figure 241 :MANUAL,SAFETY--- DM45/50/L

A57311151 REV 003
page 473 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57311151 MANUAL,SAFETY---DM45/50/L

REF. PART NO. QTY. UNIT DESCRIPTION

001 57311169 1 EA PAGE,COVER

DECALS, SAFETY
57377236 1 EA D DECAL, NOTICE
002 57311649 1 EA PAGE, ORDER INFORMATION
003 57311656 1 EA PAGE,LABEL REFERENCE
004 57324154 1 EA PAGE, TABLE---DM 45/50/DML
005 57299422 1 EA PAGE, EXCESSIVE HYD. OIL
006 57299430 1 EA PAGE, ROTATING PARTS
007 57299448 1 EA PAGE, ROTATING PARTS
008 57299455 1 EA PAGE ROTATING BLADE
009 57299463 1 EA PAGE, PRESSURIZED FLUID
011 57299489 1 EA PAGE, HIGH PRESSURE
012 57299497 1 EA PLATE, COMBUSTIBLE GAS
013 57299505 1 EA PAGE,FALL OR CRUSHHAZARD
014 57299513 1 EA PAGE, HIGH PRESSURE
015 57299521 1 EA PAGE, FALLING POWER HEAD
016 57299539 1 EA PAGE,FALLING RODCAROUSEL
017 57299547 1 EA PAGE,FALLING DRILL PIPE
018 57299554 1 EA PAGE,COMBINED WARNING
019 57299562 1 EA PAGE, HAZARDOUS VOLTAGE

57147910
021 57299588 1 EA PAGE, HIGH PRESSURE
022 57299596 1 EA PAGE, HIGH PRESSURE
023 57318834 1 EA PAGE, DON’T CLIMB
024 57299414 1 EA PAGE, FALLING DERRICK
025 57338329 1 EA PAGE, FAN BLADES
026 57755225 1 EA PAGE,TABLE,DMLSP

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 474
 Serial Number: 4133
FAMILY,DM50

57243073 NAMEPLATES, COMMONS

13
NAMEPLATES, COMMONS

12

11

10

7
57243073

15

Figure 242 :NAMEPLATES, COMMONS

E57132649 REV 09
page 475 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

57243073 NAMEPLATES, COMMONS

NAMEPLATES, COMMONS
4 3

6
5

57243073

Figure 243 :NAMEPLATES, COMMONS

E57132649 REV 09
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. page 476
 Serial Number: 4133
FAMILY,DM50

57243073 NAMEPLATES, COMMONS

REF. PART NO. QTY. UNIT DESCRIPTION

001 57082125 0 EA NAMEPLATE---XL W/WATER INJ

NAMEPLATES, COMMONS

001 57086431 0 EA NAMEPLATE---HP W/WATER INJ

001 57094849 0 EA NAMEPLATE---HP W/O WATER
001 57094856 0 EA NAMEPLATE---XL W/O WATER
002 57243065 0 EA NAMEPLATE,LOWER---HPDM45/5
002 57347171 0 EA NAMEPLATE,LOWER---XLDM45/5
003 57082133 1 EA NAMEPLATE---ENG. FUNCTIONS
004 57082109 0 EA NAMEPLATE---W/ TORQUELIMIT
004 57094831 0 EA NAMEPLATE---W/O TORQUELIMT
005 52231271 4 EA METAL TACK
006 57497687 1 EA NAMEPLATE, MODEL I.D.
007 57233181 1 EA NAMEPLATE,25’ INDICATOR
008 57233124 24 EA NAMEPLATE,DEPTHINDICATOR
009 57233173 1 EA NAMEPLATE,20’ INDICATOR
010 57233165 1 EA NAMEPLATE,15’ INDICATOR
011 57233157 1 EA NAMEPLATE,10’ INDICATOR
012 57233140 1 EA NAMEPLATE,5’ INDICATOR
013 57233132 1 EA NAMEPLATE,O’ INDICATOR
57243073

015 57233199 1 EA NAMEPLATE,30’ INDICATOR

page 477 WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

ADJUSTMENT ROD, 57319212, 109

ADPT. CROSS, 52167905, 137
ADPTR, DRL RD, 57032955, 162
A AIR CLEANER
50616028, 238
ACCESS COVER, 50816537, 242 59302752, 72
ACTUATOR AIR END---1050HR2, 36001535, 251
57065427, 441 AIR FILTER, 50825504, 238
PNEUMATIC, 56997109, 441
ALARM
ADAPTER BACKUP---12 TO36VDC, 57366387, 384
45DEG. NPT/JIC, 95326922, 224 DIRT, 52224144, 320
45DEG---ORING/JIC, 95280152, 307 DIRTY FILTER, 50815646, 318
50335843, 137
50691690, 306 ALARM KIT, BACKUP, 57366395, 384

INDEX
50696384, 326 ALTERATION INSTRUCTION, 57425415, 282
50700814, 366 ANCHOR CHAIN, 52249448, 151
50710532, 198
52220712, 351 ANCHOR D, 50105832, 42
52245461, 150 ANGLE
57064776, 266 56790330, 389
57072423, 363 57014672, 384
57096521, 95 57097933, 108
57552929, 27 57147092, 144
57552952, 27 57198285, 207
90DEG---O---RING/JIC 57319196, 109
95330692, 418 CYLINDER, 50350461, 180
95365094, 140, 192 SUPPORT, CONDENSER, 57097917, 108
95371209, 307 ANTI---FREEZE, 50262526, 229
90DEG---ORING/JIC, 95357604, 307, 322
90DG---EXT/EXTNPT, 95317426, 273 AQ SEAL ASSY, 57245177, 48, 49
95141511, 95 ARM
95282422, 59, 259 ADJUSTABLE, 57194987, 206
95286563, 417, 432 JIB HOIST---FIXED, 57120271, 195
95332599, 59 LOWER, 57037392, 167
95364964, 59 UPPER---SPUR HEAD, 50704519, 168
95650149, 322
ARM ASSY, SEAT, 57096968, 65
FLANGE, 57102097, 362
GENERIC JACK---LONG, 57116758, 354 ASSEMBLY, RADIATOR, 57150450, 229
GENERIC JACK---SHRT, 57116766, 354 ASSY TOOL & INSTRUCT KIT, 57239436, 49
INPUT SHAFT, 57198111, 285
INT NPT/O---RING, 95655064, 260, 370
MOTOR, 57368052, 150
SAE B, 59572917, 285
B
SAE C, 50597624, 285 B0LT---NUT, 52140423, 198
STR.---JIC/O---RING, 95371241, 307
BACK UP
STR---JIC/O---RING, 95303368, 95, 100, 334, 363
57247405, 132
UPPER---6.25 RODS, 50461797, 164
57429276, 132
ADAPTER---90DEG, ORING/JIC, 95376141, 246 BACK UP RING
ADAPTER---MIDDLE, 6.25 RODS, 50461789, 57115727, 48, 49
164 57192130, 291
ADAPTERENGINE/DRIVESHAFT, 57173692, BACK---UP
282 57245516, 48
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index i
 Serial Number: 4133
FAMILY,DM50

Index

57520850, 44 BEARING
57520876, 44 50446327, 288
57520918, 44 50447374, 288
57520934, 44 52155041, 157
52209939, 151
BACK---UP RING
54407317, 296
57183592, 48
57171910, 285
57183600, 48, 49
57367385, 285
BALL 95200663, 285
52141751, 346 95214037, 150
52141769, 346 95434874, 150
52155371, 300, 408 BALL, 52179504, 404
52249646, 104 BARREL, 57026395, 296
KNOB, 50627918, 336 LOWER, 50248210, 167
BAND MOTOR, 56001118, 202, 422
MOUNTING, 58044744, 238 MOTOR SHAFT, 57117772, 157
INDEX

NEEDLE, 50815802, 404

MOUNTING---AIRCLEANR, 50279413, 221
ROLLER
BAR 95434551, 150
BOLTING 95434569, 150
57247298, 234 SPHERICALROLLER, 95711156, 150
57247322, 234 TAP ROLLER, 57552523, 26
COPPER, 57036881, 384 THRUST, 50458959, 167
FLAT
BEARING --- PUMP DRIVE, 59904268, 285
56901853, 16
56981459, 444 BEARING ASSY, 50243518, 167
57003634, 195 BEARING BALL, 50632538, 291
57029100, 452
BEARING CONE, 50710490, 199
57076267, 176
57083198, 136 BEARING CUP, 50710508, 198
57083206, 136, 168 BEARING---CARR RLR
57097925, 108 57563025, 22
57147118, 144 57563033, 22
ROUND
57082497, 59 BEARING---FRAME IDLER, 57356750, 34
57093197, 138 BEARING---IDLER, 57563447, 34
57119810, 80 BIT REST---20 TABLE, 50621325, 452
SLIDING, 57090953, 42
SQ., 57100125, 261 BLOCK
STIFFNER, 52172384, 164 50816941, 288
TAP, 57229924, 206 57315574, 109
TAPPED, 57054991, 174 BEARING
TOWER, PIPING MOUNT, 57326431, 136 57083974, 4
W/HOLES 57209066, 167
3/8X2X11, 57330110, 389 58235698, 6
57045296, 143, 190 GUIDE, 52147543, 129
SUPPORT, 57165185, 167
BAR W/HOLES, 57229056, 224 VALVE, 57520967, 44
BARRIER, 57097461, 65 VALVE---BUTTERFLY, 57100091, 260
BARRL/SLEEVE, 52201696, 157, 296 BLOCK EXP. VALVE---A/C, 57413106, 116
BASE MTG, WTR INJECTION, 57144032, 417 BLOWER ASSY., 57096836, 68

BASEPLATE---3/8X4X4FLATBAR, 57113144, 10 BLOWER HSG, 57284663, 402

BATTERY, 12V---8DW/ELECTROL, 57113177, BLOWER MOUNT, 51024792, 402

218 BLOWER WHEEL 20, 57284655, 402
Index ii WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

BOARD BOX
SENTRY PROCESSOR, 57530453, 436 1/2 STONCO, 52175809, 434
SENTRY PWR SUPPLY, 57530461, 436 BATTERY, 58231887, 218
ELEC.JIC, 57032963, 386
BODY
HANDY, 50625888, 434, 448
54426242, 404
VALVE, 50370808, 278 BRACE COOLER REAR, 57201741, 229

BODY ASSY---AIR CLEANER, 50816529, 242 BRACKET

50248871, 80
BODY LUB, 52211679, 424 50456946, 168
50626605, 282
BOLT
52174240, 95
50815638, 316
52208253, 95
52140431, 199
52222510, 215
52263563, 314
52231818, 260
57355026, 18
52234457, 326
57356461, 18 56782014, 384

INDEX
57356479, 18 56976616, 136
57356511, 30 57050718, 259
57356776, 20 57052623, 143, 190
57356800, 20 57065021, 224
57357683, 24 57071383, 432
57456790, 20 57071409, 432
57457772, 18 57071417, 432
57563173, 24 57082984, 136
ADAPTER, 57367310, 285 57082992, 136
CHAIN, 50339043, 129 57097941, 109
FLY WHEEL 57102279, 206
57238602, 215 58232737, 199
57238610, 215 ACTUATOR, 57065435, 441
HEX HEAD CARTRIDGE, 52168267, 441
57552556, 26 FILTER, 57420846, 307
57552739, 26 FILTER MTG, 57235491, 238
57552879, 27 INDEXING CYLIND, 50456896, 168
57552903, 27 LEVER, 58176207, 348
57552911, 27 LIMIT SWITCH, 57445694, 206
JAW---CHAIN TONG, 50014414, 456 MOUNTING
ROD CHUCK, 50519578, 164 50518364, 351
SOCKET HEAD 52208691, 192
57552564, 26 57022196, 384
57552853, 27 58160458, 259
MOUNTING---AMOT, 57139982, 254
BOLT AND NUT, 58229790, 454, 458 MTG---CENTRO LUBE, 57518003, 434
BOLT KIT, 51076271, 368 NOZZLE, 50844059, 441
OIL, 52235363, 215, 308
BOLT---SOCKETHEAD REAR LOWER, 57202475, 229
57356701, 32 TANK MOUNTING, 52168374, 441
57356875, 22 VALVE
BOLT---TRACK, 57356974, 36 50429455, 357
52167848, 96
BOSS VALVE---JIBCONTRL, 57120354, 196
O---RING
BRACKET WELDMENT, 57357311, 108
57132250, 312
57132268, 312 BRACKET---CABLE MTG, 52153210, 330
SAE O---RING 9/16---18, 57179277, 312 BRACKET---THRTLE VLV MTG, 50626977, 276
BOWL, 57371841, 72 BRAKE, DISC, 57141079, 168
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index iii
 Serial Number: 4133
FAMILY,DM50

Index

BRAKE BAND, ROD CHANGER, 57141061, 168

C
BRAKE LINING---ROD CHANGER, 57141053,
168 CAB, SWG’DR, DM45HPCONSOLE, 57411621,
59
BREAKER CAB HALF --- DM45/50, 57283236, 65
15---AMP CIRCUIT, 57084055, 76
CABLE
CIRCUIT---15 AMP, 57084055, 109 18/2, 85771715, 383
BREAKOUT KIT, RODCHANGER, 57213597, 60 FT. ENCODER, 57191462, 446
164 8 FT. POWER, 57146086, 446
AIR SWITCH---10 FT, 57146094, 446
BREAKOUT PLATERODCHANGER, 57213563, BATTERY
164 30441570, 218
56893365, 218
BREAKOUTBLOCK, RODCHANGER, BATTERY---2/0, 56770001, 218
57213555, 164 CONTRL, 50457050, 330
INDEX

BREATHER GROUND---1/0 X 36, 52246519, 384

50903236, 306 WHIP CHECK, 56933732, 138
59677831, 285 CABLE ASSEMBLY, PULLDOWN, 57424137,
129
BURNOUT
CABLE ASSY---BATTERY, 50623735, 218
57082331, 458
57082349, 458 CABLE CLAMP, 50830587, 199
CABLE---PUSH/PULL, 50612530, 80
BUSHING
39115035, 402 CAM, MOTOR, 54471917, 157
50412626, 129 CAM ASSEMBLY, 57150278, 291
50628726, 384 CAM ASSEMBLY (14), 57053522, 291
50830397, 199
52224151, 320 CAM RING
56984131, 351 52234879, 351
57192080, 291
58232604, 198
57419939, 291
95002002, 246
CENT, 57029092, 452 CAM RING ASM, 52233194, 404
CENTER, 57180184, 16 CAM STROKER ASSY, 57123283, 296
CHAIN, 50530286, 152 CAP
CHAIN ANCHOR, 50702927, 151 50007384, 426
CHAIN TONG, 50021237, 456 50067479, 417
CONDUIT, 50625839, 384 50173467, 42
MALE, 95360996, 384 50634344, 340
MODIFIED, 57116519, 402 50636018, 342, 344
REDUCER, 57367377, 285 52141801, 346
ROD CHUCK---STEEL, 57083479, 167 57045494, 291
SPLIT TAPER, 35103852, 251 BEARING
SWING CYLINDER, 50248459, 167 57083966, 6
WEAR, 50694934, 151 57191025, 150
YOKE END, 57309791, 16 BLOW OFF, 52168325, 441
COVER, 57070849, 432
BUSHING ASSY---6---1/4 ROD, 57036527, 452 CROSSHE, 50427863, 46
END
BUSHING---MASTER, 57357055, 38
50998145, 422
BUSHING---TRACK, 57357014, 38 52188968, 202
JIC---6, 95257341, 144, 190
BUSHINGHOUSING---ROTARYHEA, 57367922, REPLACEMENT, 57244113, 167
154 SPINDLE---SPUR HEAD, 57347379, 151
Index iv WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

SWIVEL, 57183329, 151 HOSE

VALVE, 50308766, 278 50034826, 174, 190, 192
WEATHER, 52215506, 221 50428564, 266
50743731, 273
CAPSCREW
52230794, 402
57192023, 291
52230810, 224
HEX HEAD, 95157731, 129
56958523, 399
CARRIER, PLANET 57371809, 72
57552424, 26 58086141, 232
57552671, 26 95220844, 224
57552770, 27 95264776, 113
95301834, 224, 389
CARRIER ROLLER GROUP, 57457566, 20 95301859, 109, 433
CARTRIDGE 95351904, 108, 113, 384
50583251, 441 95368338, 229
52168259, 441 95371092, 383, 399

INDEX
57102311, 143, 190 95378873, 433
95445664, 433
CASTING, MACHINED---HOUSING, 57367906, 95654216, 363
154
HALF, 50034826, 196, 434
CHAIN SEAL, 56778699, 221
58121286, 418 STANDPIPE
58148446, 261 57085607, 136
MACH., 57100117, 260 57247181, 138
MASTER, 50021393, 458 T---BOLT, 4.50, 57277808, 224
UPPER, 50707025, 129 CLAMP ASSY
CHAIN ASSY, 50021138, 454 1---1/4 PIPE, 57092728, 136
1/2”, 52236783, 207
CHAIN SECT---2 LINKS, 50021377, 454, 458 3 TUBE, 56943699, 143
CHAMBER, 50817113, 240 3/4, 52236791, 383
3/4” PIPE, 57083156, 136
CHANNEL---48 LG., 57305500, 65
CLAMP---1/2, 95256723, 434
CHECK VALVE, 57150617, 300
CLAMP---3/4, 95256749, 120, 383
CHUCK
CLEVIS
5 HEX ROD, 50415496, 164
50248236, 167
50380799, 180 50248848, 80, 330
CHUTE, TRANSITION, 57060154, 402 50258276, 206
CYLINDER, 57351728, 182
CK VALVE, 50820950, 370
TOWERPINNING---DML, 57359036, 143
CLAMP CLIP
50816487, 240, 242 57067563, 182
50816511, 240, 242 LOCKING, 50692086, 130
52223070, 224 MOUNTING, 52231347, 351
57040016, 168
57083552, 137 CLUTCH
CABLE 57241721, 198
50248863, 80 A/C, 57324105, 108
58060179, 195 COIL
CONSTANT TORQUE CONDENSER, 57364358, 108
57439267, 238 SOLENOID---24VDC, 57305377, 206
57440562, 238 COIL S/A, 57102329, 143, 190
DRIER AIR COND., 57095515, 108
FEED CYL---5 OD, 57315780, 129 COLLAR---RLR END, 57562993, 22
HALF, 50034818, 195 COMPOUND, SILICONE, 50700731, 152
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index v
 Serial Number: 4133
FAMILY,DM50

Index

COMPRESSOR, W/ORINGPORTS, 57364341, BATTERY, 57143505, 218

108 BRAKE HOUSING, 57419020, 198
CONDUIT CONTROL, 52155330, 300
3/8 NYLON, 57358830, 65, 434 CRANK CASE, 54503743, 420
FLEX---1/2SEALTITE, 95245049, 434 DRUM & TIE DN ASSY, 57420101, 436
NUT, 57104895, 298
CONE, 52155686, 104 PRE---CLEANER, 57371833, 72
CONNECTOR RING GEAR, 57552655, 26
1/2 45 DEG, 95368536, 434 TOP---COOLING PKG, 57113029, 221
1/2 90 DEG, 95361390, 434 COVER ASSY, 50817121, 240
56991193, 384
COVER TOP, 50820307, 310
56992191, 434
CORD GRIP COVER---CARRIER ROLLER, 57356834, 22
50625946, 399 CPSCRW/LCWSH
50696939, 330 50647767, 199
MALE, 57391559, 363 52140480, 198
INDEX

STRAIGHT---1/2, 95245221, 434

CRADLE, 52203718, 300
CONTROL CROSS, PIPE---1---1/2 NPT, 95446480, 270
52158094, 330
ENG, ETR, CAT, 57316184, 74 CROSS KIT, 57227787, 282
CONTROL CHAMBER, 54408364, 300 CROSSHEAD, 50425958, 4
CONTROLLER, SENTRYMONITOR, 57530446, CUP ASSY, 50816479, 240, 242
436 CUSHION
COOLER, OIL---SAE O RINGPRT, 57101941, 229 BOTTOM, 57301814, 65
SEAT BACK, 57301822, 65
COOLER CORE --- HOC ONLY, 57499634, 229
CYLINDER
CORD, 14/2, 58150103, 434, 444 57563371, 30
CORE HYDRAULIC
52218054, 68 57018343, 206
COOLER--- COC ONLY, 57498719, 229 57039620, 168
RADIATOR, 57181448, 234 57039638, 176
57054009, 180
COUPLER, 57552416, 26 57199093, 167
COUPLING 57224669, 46
95446563, 417 CYLINDER HYDRAULIC, 57488868, 42
95446571, 417
ASSY, 36783710, 251
CHAIN, 57144305, 417
MIN, 59713438, 327
D
V---RETAINER, 50622745, 221 DECAL
A/C HEATER FILTER, 57290041, 59, 109
COUPLING SAE HALF, 57348146, 312
A/C SWITCH, 57147852, 118
COVER BLOWER, 57147860, 118
39116819, 434, 448 CAUTION---EXCESSOIL, 57140477, 471
52155322, 300 CORP. NAMEPLATE, 57497927, 461
52231008, 154 CORPORATENAMEPLATE, 35861269, 461
54407499, 298 DANGER---HAZ. VOLT., 57311086, 471, 472
57095945, 12 DRAIN MANIFOLD, 50829712, 306
57095952, 12 ENG.FAILURECOOLSY, 57140444, 471
57151144, 302 HYD.OIL LEVEL, 50810993, 306
57552812, 27 HYDRAULIC OIL, 52223807, 307
57563132, 18 IR BUG, 57621310, 461
58123399, 418 MACHINE---DM50E
58232562, 198 57093478, 461
Index vi WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

57095895, 461 DRAWING

NOTICE ANGLE PKG, 0---30, 57510133, 207
57345878, 471, 472 KIT AIR COND., 57451932, 113
57377236, 474 DRIER, RECEIVER, 57364366, 108
NOTICE---DUST, 57335200, 471, 472
NOTICE---HYD.FAILURE, 57156465, 471, 472 DRILL PLUG, 57244972, 44, 49
VENT MANIFOLD, 50829704, 306 DRIVE GROUP
WARNING---DON’TALTER, 57310831, 471, 58025818, 18
472 AUX, 52182763, 109
WARNING---FALL DRLPI, 57140378, 471, 472
DRIVE SHAFT
WARNING---FALL PWRHD, 57140329, 471
52188935, 202, 422
WARNING---FALLCAROUS, 57140386, 471
57368524, 282
WARNING---FALLDERRIC, 57140360, 471
WARNING---FANBLADES, 57335192, 471, 472 DRIVE SHAFT ASSY, 57300212, 296
WARNING---HIGH PRESS, 57140352, 471 DRUM, 58232711, 199
WARNING---HIGHPRESS, 57140428, 471
DUCT, AIR, 57079105, 238

INDEX
WARNING---HOT FLUID, 57140402, 471
WARNING---NOCLIMBNG, 57318040, 471, 472 DUCT ASSY, 57371775, 72
WARNING---POWERHEAD, 57140410, 471 DUST COLLECTOR---IR 3600, 57284309, 399
WARNING---ROT.BLADE, 57140469, 351, 471
WARNING---ROTATINGPT, 57140337, 471 DUST CURT. FRNT DUSTSIDE, 57184491, 413
DUST CURTAIN, FRONT CAB, 57184483, 413
DECAL & MANUALSET---DM45/5, 57404295,
471 DUST CURTAIN---R.CAB SIDE, 57391021, 413
DECALWARNING---COMBUST.GAS, 57140394, DUST CURTAIN---REAR DCSIDE, 57390668,
471 413
DECALWARNING---ROTAT.PARTS, 57140345, DUST SHIELD, 57138760, 129
471
DECK, 56988280, 8
E
DECKING, MIDDLE---COOLER, 57208969, 8
ELBOW
DECKING LEFT REAR, 57213589, 8 1/2 BARB---LASCO, 57451361, 113
DECKING RIGHT REAR, 57213571, 8 45 DEG. EXHAUST, 57229791, 221
90 DEGREE, 57367369, 285
DIGITAL DISPLAY, 57146037, 446 90DEG MALE 37DGFL, 95279402, 120
DIODE, 3A, 600V, 57196677, 384 90DEG---EXT/INT NPT, 95264909, 120
95433264, 334
DISC LONG---JIC/ORING---90, 57117491, 254
BURST, 56997679, 441 PIPE, 95737086, 138
VALVE, 50308758, 278 RUBBER, 57059636, 238
RUBBER---90 DEG, 56761554, 238
DISC 25, 57242588, 170
ELBOW 4511/4, 95489282, 137
DISC SPRING, 57300816, 157
ELBOW---EXHAUST 8 90 DEG, 57412611, 221
DISCONNECT, 57167132, 306, 362
ELEMENT
DOOR 57170839, 254
A/C FLT, 57097479, 65 BUSHING, 50815653, 318
FILTER ACCESS, 57290264, 402 FILTER
FRONT, 57096893, 65 57082463, 402
57284697, 402
DOWEL PIN
57301780, 72
50604479, 291
FILTER---3 MICRON, 50343490, 318
50830660, 198
FILTER---MAIN HYD, 52263183, 316, 466
DRAIN COCK, 95250692, 282 FLTR, 57059404, 108
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index vii
 Serial Number: 4133
FAMILY,DM50

Index

FLTR---3 MICRON, 52214178, 320 FILTER REG., 57070732, 434

KF3 FILTER S3, 57336406, 466 FINAL DRIVE, 58025800, 18
MAINTENANCE, 57212011, 215
OIL FILTER, 36860336, 466 FINAL DRIVE GROUP---U/C, 57415929, 18
OIL SEPARATOR, 57101636, 268 FITTING
PRIMARY 57084287, 206
50616390, 242 95201299, 180
52146958, 240 95286902, 326, 432
RETENTION, 57063877, 402 95302733, 273
SAFETY 95315289, 307
50616408, 242 95371217, 307
52146966, 240 95402806, 363
TEMP, 37189511, 326 HYD
49833478, 261
ENCODER, OPTICAL SHAFT, 57146045, 446
50814581, 432
END CAP 52177623, 96
INDEX

50709666, 404 52187465, 260

57191991, 291 56919004, 364
ENGINE, CAT 3412DIT---575, 57220717, 215 56920903, 224
56947534, 260
ENGINE MOUNT REAR, 57171159, 215 56956220, 59
EQUALIZER, 20A. BATTERY, 57175804, 448 57080251, 254
57136897, 196
EVAPORATOR, FILTER KIT, 57440943, 116 59669713, 100
EVAPORATOR COIL---A/C, 57413114, 116 85597904, 432
95209086, 95, 432
EVAPORATOR W/THERMOSTAT, 57448086,
95209094, 140, 144, 259, 362, 424
113
95219713, 260, 432
EXCLUDER 95219721, 259, 326, 399, 417, 432
57245466, 132 95219739, 327
57245565, 48, 49 95219747, 120, 215, 308, 399
EXTENSION, TOWER BOTTOM, 57181034, 413 95219754, 307, 326
95219762, 326, 362
95219770, 306, 307
95219853, 362, 418
F 95221107, 273
95231031, 140, 259
FACEPLATE, BARREL---13/32, 52201712, 157, 95264941, 260
296 95264966, 140, 259
FAN, 6---BLADE, 57098147, 351 95279071, 190, 196, 424
95279105, 120, 308
FC310---04 HOSE INDICATOR,
F04X000J--- ---/J--- ---, 444 95279162, 195
95279329, 326
FC310---16 HOSE INDICATOR, 95279378, 196
F16X000J--- ---/J--- ---, 432 95279428, 307
FILLER, TANK---2.5 NPT, 50219518, 246 95279436, 327
95279451, 259
FILTER 95279493, 143, 260, 417
FUEL SECONDARY, 57294829, 215 95279501, 399, 418
HYDRAULIC, 52254885, 306 95279519, 432
MAGNETIC, 50630656, 306 95279527, 140
OIL---ENGINE, 52183233, 215 95279535, 246, 327, 432
FILTER & REGULATOR, 57082455, 402 95279543, 195, 246
95279881, 326
FILTER ASSY---HYD, 52259363, 314
95279998, 370
FILTER MNT BKT, 57350449, 310 95280160, 308, 326, 366
Index viii WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

95280186, 307, 362 LUBE, 95201547, 129

95287629, 238, 246, 432 LUBE---90 DEG, 95208971, 168
95293403, 190, 259, 363, 370, 444 MALE---FEMALE NPT, 57237380, 224
95302121, 246 STR---EXT NPT RUN, 95377156, 190
95302170, 432 TEE---INT NPT, 95280095, 326
95302998, 140, 370 TEST, 57328676, 363
95303335, 307, 399 TUBE
95315214, 273, 417 50364199, 306, 417
95315222, 120 95663803, 306
95315230, 327, 362, 366 95702015, 95
95324273, 307 FITTING HYD
95329975, 140, 260, 363 95279238, 326
95330023, 246 95323481, 260
95335980, 190 95652970, 362
95338372, 327
95338406, 418 FITTING HYD---90, 95676417, 327

INDEX
95341079, 190, 259 FLANGE
95356721, 322 1NPTF, 57059701, 327
95356853, 322 50691989, 326
95356903, 334 57052599, 138
95356960, 307, 308, 362 MOUNTING, 52188851, 202, 422
95356986, 306, 307 PIPE, 50622729, 221
95357570, 307, 322 FLANGE EXHAUST, 57229783, 221
95364949, 100, 334
95364972, 59, 259 FLANGE HALF
95365078, 195, 260, 363 SIZE 16---CD62, 57404147, 372
95365086, 357 SIZE 20---CD62, 57405185, 98
95370045, 196 FOOT, JACK, 50346436, 42, 46
95371258, 102, 357, 362, 366
FORK CHUCK---4.5 FLATS, 50348317, 180
95381158, 259, 362
95396404, 190 FRAME, DUST CURTAIN, 57181026, 413
95408183, 366 FRAME ASSY, RH, 57516601, 18
95415667, 363, 364
95415774, 100 FRAME ASSY---LH, 57563272, 18
95419594, 192, 334 FRONT DECKING, 57139313, 8
95423331, 260
FRONT IDLER GROUP
95431292, 307, 308
57354961, 18
95473443, 363
57356503, 18
95647806, 307, 308
95666996, 140 FRONT SIDE PLATE, 57173973, 310
95678041, 254 FUEL, DIESEL, 52246774, 246
95702627, 307, 366
95735346, 306, 307 FUSE, 52279338, 444
95775623, 273
95829362, 308
HYD.METRICSTRTHD, 59767483, 364 G
HYD---90 DEG, 95341665, 102, 362, 399
HYD---90JIC/ORING, 95280194, 362 GAGE ASSY, 57078263, 76
HYD---JIC/O---RING, 95329983, 362, 366 GASKET
HYD---NPT/JIC 3/4, 52236569, 383
95263380, 140, 190, 370 50636513, 198
95316972, 143, 259, 327, 432 50816925, 288
HYD---TEE ADAPTER, 56924962, 137 50819192, 310
L90---120FSX12SAE, 57167934, 129 50830546, 198
L90---160FSX12SAE, 57296394, 130 52154499, 296
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index ix
 Serial Number: 4133
FAMILY,DM50

Index

52154952, 296 EP0, 56976954, 434

52240132, 198 GREASE PLUG, 52140464, 198
52240140, 198
52260734, 198 GROMMET, RUBBER
52263787, 251 56773708, 108
54418090, 246 56987456, 108
54471768, 157 57098022, 108
56953045, 196 GUAGE 0---300 PSI, 57516700, 434
FLAN, 50622752, 221
GUARD
HOUSING, 52155033, 296
52246477, 351
RADIATOR, 57362774, 234
COMPRESSOR, 57077562, 251
RETAINING, 52154531, 296
COUPLING, 52231107, 417
SQ.SECTION, 57307720, 291
DRIVESHAFT, 57273765, 282
TOP, 50819200, 310
HOSE
GASKET --- MATERIAL, 57371825, 72 57095986, 12
57095994, 12
INDEX

GASKET RING
95214524, 251 WELDMENT, 57319154, 108
95225116, 266 GUARD ASSEMBLY
57563199, 24
GASKET---SEPR ELEMENT, 57212409, 268
57563207, 24
GAUGE
GUARD ASSY
AIR PRESS---400 PSI, 56951395, 86, 88
57563157, 24
AMMETER, 57515314, 76
57563165, 24
FUEL, 50616762, 246
PRESSURE, 57112963, 402 GUARD GROUP---TCK MOT, 57563124, 18
PRESSURE---0---160PSI, 50262492, 259 GUARD GROUP---TRK GDE, 57563140, 18
PRESSURE---0---5000PSI, 56930688, 82, 84
SIGHT GUARDS, CABLE, 57411381, 130
35516749, 268 GUIDE
52253176, 152 50383017, 180
TEMP, 57093155, 76 FINISHEDPOWERHEAD, 57143778, 151
ROD, 50821321, 206
GAUGE ASSY
SLIDING, 50422997, 180
400 PSI AIR, 57429920, 74
SLIDING SPROCKET, 57137382, 129
57092686, 74
SPRING---CHAIN TONG, 50209501, 456
57092694, 74
57092702, 74 GUIDE BLOCK---LONG, R.H., 57376816, 151
GEAR GUIDE BLOCK---SHORT, R.H., 57376824, 151
56T, 50817618, 285 GUSSET
INTERMEDIATE, 57159113, 150 56924764, 434
OUTPUT, 52202736, 150 57083149, 136
PINION, 57367583, 285 57083172, 136
RING, 57552648, 26 57083180, 136
SET HR2, 900, 1050CFM, 36765113, 251 57097263, 136
SUN, 57552762, 26 57165177, 167
GEAR/SPIDER, 52259769, 198
GEARBOX --- 4 HOLE, 57367179, 282
H
GEROTOR ASSY, 52163474, 296
HANDLE
GEROTOR SET, 52188950, 202
CHAIN TONG, 50209675, 456
GLASS, 35277151, 316 RECESSED, OUTSIDE, 57486987, 65
GREASE VALVE, 50730613, 278
52180957, 152, 232 HANDLE ASSY, 50613728, 336
Index x WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

HANDLE---D/C DOOR, 57301202, 402 52226453, 88

HANDRAIL 52226479, 433
52226768, 433
56939416, 10
52228475, 432
56939424, 10
52244449, 174, 433
REAR---CURBSIDE, 57113110, 10
56947609, 137
HANDRAIL---REAR D.C. SIDE, 57113128, 10 56947674, 363
HARDWARE, ENCODER MTG., 57146060, 446 56947682, 351
56949407, 140
HARNESS, WIRE 56950454, 306
57138216, 383 56950488, 351
57138232, 383 56953896, 206
57138240, 383 56953961, 206
ENG. CAT, 57311979, 215 56954050, 143
HEAD 56954100, 140
4---1/4 X 3---1/4, 57245581, 132 56954159, 326, 433, 441

INDEX
5 X 4, 57245318, 49 56954167, 100, 418
57242604, 170 56954217, 137, 442
57520975, 44 56954233, 215
58233800, 182 56954282, 433
CYLINDER, 57060360, 143 56954365, 363
56954589, 206
HEAD ASSY, FILLER---2.5NPT, 57497190, 246 56955107, 190, 192
HEADCAP, 57242596, 170 56955115, 432
56955651, 363
HEATER, ASSY---LESS CABLE, 57276909, 65 56955776, 137
HOIST, JIB, 52263159, 195 56956139, 259, 433, 442
56956147, 441
HOLD DOWN---VANE, 57181307, 300
56956154, 327
HOLDER 56956675, 307
END, 57073645, 386 56956915, 137
FUSE, 57130577, 444 56956931, 136
ROD SEAL, 50453729, 464 56957780, 399
56957798, 270
HOLDER ASSY, 57141871, 167
56957830, 327
HOOK, SWIVEL---2 TON, 57138950, 195 56957889, 254
HOSE 56959836, 441
AIR 56959844, 100
57323826, 273 56960826, 136, 441
95433330, 136 56961782, 174
AIR---R32 BULK, 95313961, 273 56961816, 354
AIR---U48 BULK, 57137986, 266 56961824, 140, 354, 433
DROPOUT, 57446437, 402 56962368, 254, 417
56964133, 96, 357, 442
HYD---A06 BULK, 57053183, 59
56964141, 362, 363, 433
HYD---E32 BULK, 56961287, 232
56964166, 351
RADIATOR
56964182, 192
56989353, 224
56964190, 192, 433
57135253, 224
56964208, 362
57229031, 224
56964216, 433
RADIATOR---BULK, 56989338, 224, 399
56964224, 140, 326
SUCTION---8 X 8’---4, 57076507, 399
56964240, 433
WATER, 52249828, 229
56964273, 433
HOSE ASSY 56964299, 327, 433
52198173, 190 56964315, 433
52225547, 357 56964349, 78
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xi
 Serial Number: 4133
FAMILY,DM50

Index

56965759, 102 57043341, 95

56966211, 102, 433 57043697, 259
56966948, 326 57043788, 362
56970627, 433 57043804, 270
56972680, 102, 362 57043812, 259
56972698, 433 57043820, 259
56972706, 327 57044521, 322, 362
56973027, 307 57044554, 95
56973035, 326 57044588, 364
56973126, 137 57044612, 362
56973621, 433 57044620, 307
56974223, 259, 270 57044661, 307
56974579, 433 57044711, 363, 433
56975980, 433 57044752, 174, 190
56976590, 327 57053761, 418
56981509, 195 57053787, 136
INDEX

56981632, 254 57053829, 95, 322

56987910, 327 57057408, 259
56987936, 327, 432 57057929, 399
56987951, 326 57095069, 424
56988033, 326 57097081, 259
56988850, 137 57097107, 259
56989197, 224 57097115, 259
56992092, 195 57097750, 137
56992118, 363 57097891, 192
57097909, 399
56992357, 136
57099061, 259
56992514, 137, 354
57100182, 137
56992522, 143, 195
57100208, 322
56994528, 363
57100232, 120
56994569, 307
57100281, 192, 363
56996036, 143
57100935, 120
57004020, 174, 190, 238, 433 57100943, 120
57004053, 441 57107450, 441
57005662, 327 57117244, 100
57005688, 433 57138893, 137
57005696, 327 57140188, 326
57007528, 326 57158958, 95
57009367, 418, 441 57162646, 254
57011306, 418 57168387, 363
57011355, 190 57183832, 308, 362
57011363, 207 57229965, 354
57015752, 259 57249088, 432
57015836, 246 57249096, 399
57020661, 143 57311912, 354
57020760, 433 57311920, 399
57020810, 357 57330284, 354, 363
57022246, 432 57337123, 363
57025926, 273 57345126, 362
57034308, 259 57345332, 363
57034357, 190, 246 57377939, 108
57034712, 362 57377947, 108
57036600, 433 57377954, 108
57042921, 143 57392912, 363
57043200, 433 57410466, 259
57043218, 433 57413551, 357
Index xii WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

57414179, 363
57421240, 363
I
57421273, 363 IDLER, FRONT, 57563413, 18
57429573, 432
57437154, 326 IDLER & BEARING ASSY, 57563421, 34
57438574, 327 IDLER ASSEMBLY, 57563439, 34
58042730, 137 INDEXER, 50411602, 168
58081662, 433
58140328, 433 INDICATOR
58144528, 363 54407473, 302
58146267, 224 DRILLING EFF., 57191082, 444
58146622, 78, 441 RESTRICTION, 52265311, 238
58147356, 246 INJECTOR
58154337, 207 SL1/2 BANK, 57070757, 432
58170465, 433 SL1/4 BANK, 57070773, 432
58183468, 246 SL1/5 BANK, 57070781, 432

INDEX
58217902, 137, 326 INLET, AIR, 50816503, 240, 242
6X312, R134A, 57413486, 108
A/C---SUCTION, 57413254, 116 INPUT SHAFT, 57153793, 285
INSERT, JAW---FLAT, 50024397, 456
HOSE ASSY., 57149353, 307
INSTL INSTR---SEAL, 57239444, 48, 49
HOSE ASSY---A/C, LIQUID, 57413130, 116
INSTRUCTIONS, KIT, 57245110, 48
HOSE HUMP
INSULATION
50463645, 224
PIPE---3/4, 57451320, 113
52145836, 238 STRIP7.75WX40, 57451338, 113
REDUCING, 58044561, 238
INTAKE, COMPRESSOR---7.50LG, 57318388,
HOSE RADIATOR, 57229049, 224 238
HOSE TRAY
57083008, 136
57083016, 136 J
HOSE---DRAIN, 57144156, 113, 116 JAW---CHAIN TONG, 50021187, 456
HOUSING JOINT, WIRE, 95239216, 448
1/2 NPT PORTS, 52188927, 202 JUNCTION BOX ASSY, 8 X 6, 57138166, 383
35251529, 316
4X6 LIGHT, 57157885, 389
50816966, 288
52224219, 320
K
54472113, 157 KEY
57192007, 291 INSERT---CHAIN TONG, 50024389, 456
59671081, 422 INTERMEDIATE SHAFT, 57159139, 150
BLOWER, 57063711, 402 SQUARE, 95308573, 167
BRAKE, 57419012, 199 WOODRUFF, 52188893, 202, 422
HALF, 52240090, 198 KEY DRIVE COUPLING, 35364975, 251
LOWER SEAL, 57578023, 150
SINGLE ELEMENT, 50815703, 318 KIT
UPPER SEAL, 52248150, 150 AIR COND.---SGM, 57451353, 108
W/BUSH---ROTARYHD, 57367914, 150 ANSI 25 SPROCKET 96T, 57340333, 444
CAB HEATER, RETROFIT, 57245631, 68
HOUSING --- GEARBOX, 57367302, 285 CARTRDGE, 50427699, 288
HUB, 58153271, 418 CUP, 57047995, 420
FIRE SUPPRESSION, 57140048, 441
HYD TANK ASY, 57084311, 196 GASKET---AIR CLEANER, 50621796, 240, 242
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xiii
 Serial Number: 4133
FAMILY,DM50

Index

LATCH, 57138968, 195 LED, LIGHT EMMITTING DIODE, 57364010,

PISTON 76
50816958, 288 LEVEL
57070559, 420 50046861, 90
PUMP REPAIR, 57420127, 436 57100075, 74
PUMP TUBE REPAIR, 57420135, 436
REPAIR REGULATOR, 56275977, 259 LEVER
REPAIR UL---88 ASSY, 36037471, 264 50830348, 348
RETAINING RING, 54472170, 157 57093619, 95
INPUT, 57086381, 95
SEAL
50823707, 288 LIFTING BAIL---4 BECO, 52237096, 452
57018350, 210 LIGHT, DOME, 58235250, 65
57032997, 291
57039810, 176 LIMITER, LIFT, 50446350, 288
57039828, 168 LINK
57048001, 420 50668060, 348
INDEX

57107914, 368 52177706, 95

57250276, 422 52208162, 260
57269227, 143 MAIN PUMP CONTROLS, 57503682, 215, 330
SEAL M6F, 54472147, 157 SLING, 57146474, 196
SHAFT, 57053555, 291 LINK---LH TRACK, 57357030, 38
SLVE SEL, 57070534, 420
SPLIT FLANGE LINK---RH TRACK, 57357071, 38
52226115, 363 LINKAGE, 52227733, 260
56783020, 95
LOCK, SPINDLE, 50628007, 162
56883572, 95
58235128, 96 LOCKNUT
VALVE, 57070542, 420 35104082, 251
VALVE CONVERSION, 57346850, 100 57181240, 44, 49
57183584, 132
KIT---DISC(BRAKE), 57457293, 26 57220295, 210
KIT---REPAIR, 57514846, 273 57242554, 170
BRG, 95209987, 150
KIT---SEAL(BRAKE), 57457301, 26
LOCKWASHER, 56997141, 441
KIT---SHIM, 57153090, 296
LOUVER & BEZEL ASSY, 57147845, 118
KNOB LOWER HSG SECTION, 57284630, 402
50135888, 276
BLACK, 50830355, 348 LUG, 56770027, 218
CONTROL
52249588, 104
58235268, 68, 118 M
TRANS. SHFTCONTROL, 57115503, 330
MAGNET ASSY
KNOB & HANDLE ASM, 57172082, 195 50815661, 318
52224177, 320
MAIN VLV ASY, 57096398, 92
L MANIFOLD
50691658, 306
LABEL, OPERATING INSTRUCT, 56997216, 441 52162138, 259, 327
LAMP 52223690, 276
52263530, 314
FLOOD---70W HALOGEN, 57147282, 389
52263548, 314
TRAP---70W HALOGEN, 57157893, 389
56849672, 432
LATCH---DOOR, 57240822, 12 AIR IMPULSE, 57284689, 402
Index xiv WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

HYD, 57083883, 432 NAMEPLATE---12V DC POWER, 57379174, 448

RETURN SAEPORTS, 57431983, 306
NAMEPLATE---ENG. FUNCTIONS, 57082133,
MANIFOLD---SUCTION, 57306680, 310 477
MANUAL NAMEPLATE---HP W/O WATER, 57094849, 477
OPERATORSSERVICE, 57146102, 446
NAMEPLATE---HP W/WATER INJ, 57086431,
SAFETY---DM45/50/L, 57311151, 471, 472 477
MARKER, WIRE, 57093080, 383
NAMEPLATE---W/ TORQUELIMIT, 57082109,
MASTER LINK, 50024447, 458 477
MOTOR NAMEPLATE---W/O TORQUELIMT, 57094831,
24V, 58234501, 68, 116 477
HYD. TRACK/DR, 57415044, 18 NAMEPLATE---XL W/O WATER, 57094856, 477
HYDRAULIC
50820935, 195 NAMEPLATE---XL W/WATER INJ, 57082125,
57003782, 402 477

INDEX
57117764, 150 NEEDLE VALVE, 50064096, 426
57155376, 351
57250250, 417 NIPPLE
50691831, 306
MOUNT 95048559, 276
57083032, 136
ENG, REAR W/BKT, 57185498, 215 NOZZLE
FIRE PROTECTION, 57224347, 441 50306315, 426
FLEX---BOLTSANDWICH, 57139131, 384 50583236, 441
FRONT ENGINE, 57172736, 215 56997166, 441
HOIST, 57119968, 195 COMPLETE, ASM, 52215233, 424
ROD CHANGER CYL, 57141913, 167, 168 NOZZLE COLLR, 50068253, 426
SEAT, 57096950, 65
SHAFT TBG NUT
INSIDE, 57325060, 16 50021161, 458
OUTSIDE, 57315426, 16 50635945, 340
YOKE END, 57309809, 16 50635960, 340
50816420, 242
MOUNTING CAP, 57192015, 291 57356677, 32
MTG.PLATE---RV, HYD. TANK, 57352304, 310 57357691, 24
58232679, 198
58232752, 199
N ACORN, 57239725, 298
ADJUSTING, 57291304, 150
HEX
NAMEPLATE
95076808, 426
10’ INDICATOR, 57233157, 477
95929774, 129
15’ INDICATOR, 57233165, 477
STOP, 95077319, 129
20’ INDICATOR, 57233173, 477
JAM
25’ INDICATOR, 57233181, 477
57104929, 298
30’ INDICATOR, 57233199, 477
57104937, 298
5’ INDICATOR, 57233140, 477
LOCK
50560077, 288
52263571, 314
52145489, 195
57060345, 143
DEPTHINDICATOR, 57233124, 477
58233719, 182
JIB HOIST, 57097974, 195
LOCK---1/2 CONDUIT, 50619915, 330, 384
LOWER---HPDM45/5, 57243065, 477
SHAFT, 57552515, 26
LOWER---XLDM45/5, 57347171, 477
WING, 50816446, 240, 242
MODEL I.D., 57497687, 477
O’ INDICATOR, 57233132, 477 NUT---TRACK, 57356990, 36
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xv
 Serial Number: 4133
FAMILY,DM50

Index

O 58233727, 184
95000477, 254
O RING 95017984, 104
50619014, 336, 338, 342, 344, 346 95018081, 336
57416950, 157 95018271, 167
95412870, 48 95086625, 152
95868014, 48, 49 95086724, 150
95868030, 48, 49 95087052, 424
95097689, 298, 302
O RING---SEAL, 57356594, 30 95097929, 152
O’RING 95266433, 362
58233784, 184 SHUTOFF VALVE, 57440661, 108
58233834, 184 SPLIT FLANGE (20), 56940281, 98
95000253, 426 OIL
95018651, 426 GEAR
O---RING 50416544, 282
INDEX

35251511, 316 58209651, 152

50597434, 285 HYDRAULIC, 52223781, 306
50605682, 338, 340 OIL COOLER(LOW PROFILE), 57187585, 229
50605690, 340
OIL SEAL COVER, 35856467, 251
50605708, 340
50605732, 340 ORIFICE
50605757, 342, 344, 346 .09, 35306984, 260
50636547, 202 .125, 57221475, 206
50715507, 95 35517234, 270
50815695, 318 OUTLET BODY, 95344719, 434
50816974, 288
51076156, 368
51076164, 368
51076172, 368
P
52154937, 298 P1 ROTOR ASSY., 57192122, 291
52154994, 157 P2 ROTOR ASSY., 57192163, 291
52155314, 300
52203767, 300 PACKING
52215696, 157 SWIVEL, 50694876, 151
52224201, 320 SWIVEL---30XV, 57336067, 151
52263555, 314 PAGE
54407416, 298, 302 COMBINED WARNING, 57299554, 474
56883614, 372 COVER, 57311169, 474
57107906, 368 DON’T CLIMB, 57318834, 474
57192197, 291 EXCESSIVE HYD. OIL, 57299422, 474
57207078, 48, 49 FALL OR CRUSHHAZARD, 57299505, 474
57224081, 170, 178 FALLING DERRICK, 57299414, 474
57242562, 170 FALLING DRILL PIPE, 57299547, 474
57244832, 44, 49 FALLING POWER HEAD, 57299521, 474
57245086, 132 FALLING RODCAROUSEL, 57299539, 474
57247397, 132 FAN BLADES, 57338329, 474
57300329, 157 HAZARDOUS VOLTAGE, 57299562, 474
57326795, 178 HIGH PRESSURE
57367344, 285 57299489, 474
57520868, 44 57299513, 474
57520884, 44 57299588, 474
57520900, 44 57299596, 474
57552721, 26 LABEL REFERENCE, 57311656, 474
57552887, 27 ORDER INFORMATION, 57311649, 474
Index xvi WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

PRESSURIZED FLUID, 57299463, 474 ROLL

ROTATING PARTS 50668078, 348
57299430, 474 95002564, 6
57299448, 474 ROLL---3/8 X 3---3/4, 95246062, 129
TABLE, DMLSP, 57755225, 474 SPRING---CHAIN TONG, 50024512, 456
TABLE---DM 45/50/DML, 57324154, 474 SPROCKET
50338987, 129
PAGE ROTATING BLADE, 57299455, 474
52227337, 129
PANEL TIEBAR--- 0---30 DEG, 57145468, 206
57078008, 70 TOWER LOCKING, 57141715, 143
57095960, 12 PIN---PUMP, 57305948, 298
57096000, 12
88001599, 386 PIN---TRACK
A/C FR, 57097487, 108 57357022, 38
FRONT A/C, 57147878, 118 57357048, 38
MOUNTING, 57078032, 70 PINION, INPUT, 57170110, 150

INDEX
PANEL ASSY, ETR---CAT, 57276784, 74 PINS, 50817089, 157
PANEL CONTROL, 57243768, 65 PIPE
2NPT, 57097131, 137
PETCOCK, 95267092, 246, 417 57563181, 24
PIN 95341798, 42
50021195, 458 EXHAUST, 52190733, 221
50067834, 42, 46 WATER INLET, 57228074, 224
50293737, 288 PIPE ASSY
50345677, 180 57083057, 136
50446392, 288 57083065, 136
50456912, 168 57083073, 136
50514074, 246 PIPE FUEL TK, 52225075, 246
50816289, 291
PIPE PLUG, 52201811, 298, 302
50821362, 206
50830322, 348 PIST/SHOEASY, 52218690, 296
52141736, 346 PISTON
52155348, 300 50634377, 340
52155454, 298 52249604, 104
54407606, 298 57060378, 143
57067555, 182 57220279, 210
57356735, 34 57242612, 170
ANCHOR, 50171941, 42, 46 57356560, 30
ANCHOR---ROTARY HEAD, 57367930, 151 57429318, 132
CENTER, 57180168, 16 57520983, 44
CLEVIS, 56975964, 143 57552572, 26
CLIP, 56975972, 143 58233743, 182
CYLINDER CYLINDER, 57245201, 49
50339001, 129 PISTON SPACER, 57183618, 49
50813567, 140
PLANET BEARING
DOWEL, 50815810, 404
57552473, 26
DOWELL, 54472105, 157
57552697, 26
END YOKE, 57188112, 16
57552796, 27
HANDLE---CHAIN TONG, 50021202, 456
HINGE---1.13X5X4.5 GRP, 95866232, 206 PLANET GEAR
HINGE---HEAD END, 50248467, 167 57552465, 26
HINGE---ROD END, 50248475, 167 57552689, 26
JIB ARM, 57120339, 195 57552788, 27
LOCKING, 50219955, 452 PLATE
NOZZLE, 50068279, 424 50348804, 306
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xvii
 Serial Number: 4133
FAMILY,DM50

Index

50462332, 42 SPACER, 59671107, 422

50559913, 288 SPRING, 52224185, 320
50622257, 129 SWASH, 50447366, 288
50636059, 342, 344, 346 TAPPED, 52240439, 383
50650399, 198 TOP MOUNT, 57173262, 402
57029118, 452 UPPER REAR, 57202467, 229
57147100, 144 WEAR, 54416557, 402
57165946, 168 PLATE ASSY
57165953, 168 LH, WARNING, 57563363, 30
57319162, 108 RH, WARNING, 57563355, 30
57319170, 109
BACK UP, 57552580, 26 PLATE TOP, 57243750, 70
BACK---UP, 57552432, 26 PLATE VAL. MOUNT, 57192619, 70
BOTTOM, 57173999, 310 PLATFORM, CAB, 57082786, 59
BOTTOM MOUNT, 57173254, 402
BRASS, 50650381, 198 PLUG
INDEX

CAM, 57206831, 206 1---1/16---12, 95664934, 307

COMBUSTIBLE GAS, 57299497, 474 30395610, 268
COVER 50318534, 288
52180106, 151 50634328, 336, 338
52247657, 251 50998103, 202, 422
52267408, 152 52155306, 300
CREEP 54408059, 157
52203668, 157 57240574, 298
58232612, 198
57026478, 296
58232638, 198
END, 57191033, 152
CAP, 57552622, 26
EXTENSION, 52158961, 129
EXPANDING, 57552630, 26
FILTER MOUNTING, 57185464, 215
JIC---6, 95415584, 196
FILTER MTG, 57273138, 215
MAGNETIC, 59514976, 285
FOLLOWER, 57420093, 436
MINI, 57093775, 306
FRONT, 57082042, 70
NYLON, 57012676, 170, 176
GUIDE, 50821313, 206
OIL, 50118694, 424
KEEPER, 50415249, 168
PIPE
LOCK, 57137416, 130 57367328, 285
LOCKING 95033700, 424
50339019, 129 95408167, 432
50813575, 140 PIPE---3/8 SQ HEAD, 95249587, 151
MOTOR, 57240764, 300 PIPE---HEXSOCKET, 3/8, 95101705, 417
MOUNTING PORT
50258193, 192, 195 57224156, 44, 49
50462514, 180 57244915, 44
MTG, 57244980, 362 57245292, 132
PINNING---ANGLDRILL, 57359135, 144 SCREW
PORT 57552747, 26
52179488, 404 57552895, 27
54426168, 408 VENT, 57094526, 306
57181372, 157 WITH O---RING, 95343596, 307
FRONT, 54494018, 291
REAR, 54494026, 291 PLUG HEAD, 95323465, 152, 260, 334
PORT---RH 13/32, 52201845, 296 PLUG PIPE, 95101457, 42
RETAINING, 50248434, 167 PLUG W/O RNG, 95326955, 306, 366
ROTAT, 50816909, 288
SEAL VANE, 54408372, 300 PLUG---PIPE, 57356768, 22, 34
SHOE, 50447341, 288 POPPET
SIDE MOUNT, 57173270, 402 50618990, 336, 342
Index xviii WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

50634369, 340 RELIEF VLV, 52223765, 92

50634393, 340 RESERVOIR, HYDRAULIC, 57173957, 306
50635994, 340
RESISTOR, 24V, 58234519, 68
PORT BLOCK, W/O SHUTTLE, 54471321, 157
REST
PORT PLUG, 57244915, 49 CYLINDER, 52264272, 129
PRE---CLEANER, 57371759, 72 WRENCH, 50243088, 452
PRE---CLEANER/FILTER KIT, 57312001, 65 RETAINER
57356859, 22
PRESSURE PLATE, 57185217, 291 57416943, 157
PRESSURE PLATE---CLUTCH, 57241747, 198 BEARING, 50248368, 167
PUMP CABLE, 57411092, 130
3GPM WATER INJ., 57048977, 417 SEAL, 57164592, 157
TRACK, 52264652, 16
50 TO 1, 56964869, 436
DOUBLE HYDRAULIC, 57058356, 282 RETAINER PISTON & SHOE, 54413646, 157

INDEX
FUEL, 50258441, 246 RIM AS---CARR RLR, 57563017, 22
HYDRAULIC
50421213, 282 RING
52245065, 282 50046846, 90
52247111, 282 50715499, 95
57356578, 30
PUMP/TIMER, LINCOLNCENTRL, 57166795, 57356586, 30
432 BACK UP, 57163529, 178
PUSHBUTTON, 2---POSITION, 57358855, 76 BACK---UP
50605716, 340
50605724, 340
R 57224099, 170
BACKUP, 58233735, 184
RACE CAM, 54465646, 406
BEARING, 52188885, 202, 422 CAST IRON, 57242570, 170
THRUST, 50219534, 130, 167 CONTAMINATION, 57520942, 44
INGRESSION, 57520892, 44
RADIATOR CORE KIT, 57247264, 229 LOCATING, 57552457, 26
RADIATOR TUBE SUPPORT, 57236226, 224 LOCK, 50650407, 198
O, 57552549, 26
RADIATOR---LARGE MODINE, 57156945, 229 RETAING
REAR PLATE, 57173965, 310 50815711, 318
52141793, 346
REDUCER, 57371791, 72
52201803, 298, 302
REFRIGERANT, R134A, 57364473, 108 57026403, 296
REGULATOR 57026411, 296
56275969, 259 57026429, 296
PRESSURE, 57442477, 273 RETAINING
UL---88 ASSY, 36887396, 264 52155140, 160
52155157, 160
REGULATOR ASSY, UL---88, 57530917, 259 52155165, 160
RELAY 52155751, 296
57137606, 384 52155843, 157
DPDT 24V COIL, 57394603, 444 52204864, 160, 296
N.O. POWER, 52238318, 383 52204872, 160, 296
SOLENOID---24VMARINE, 59956466, 384 52224227, 320
54408299, 160
RELEASE, INSIDE---SWINGDOOR, 57425522, 54472469, 160
65
57060337, 143
RELIEF VALVE, 52221678, 96 57068215, 210
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xix
 Serial Number: 4133
FAMILY,DM50

Index

58233792, 182 ROTOR, 54426150, 406

95780060, 348
SEAL
57552754, 26, 27
57552937, 27
S
SNAP SCREW
50005909, 288 50477926, 288
50446343, 288 50559848, 288
50559830, 288 50635978, 340
50597442, 285 50636000, 342, 344, 346
50806223, 291, 404 50816271, 291
50815901, 404 50830363, 348
57552440, 26 52155256, 300
57552481, 26 52215613, 157
57552507, 26 52252053, 198
57552598, 26 54407390, 298, 302
INDEX

57552705, 26 54408331, 300

57552713, 26 54408349, 300
57552804, 27 54408356, 300
THREAD LOCKING, 50415231, 168 58232554, 198
THREADED, 50610971, 151 58232588, 198
WEAR, 57157653, 48 58232620, 198
RING BACKUP, 58233826, 184 58232687, 198
ADJ, 54407580, 298
RING SNAP, 50644558, 291 ADJUSTING, 50636026, 342, 344
ROCKER AND PLUG, 54408406, 300 CAP
95378667, 98
ROD HEX
57060386, 143 95104394, 129
57168544, 182 95920674, 129
57563405, 32 95934550, 130
ROD ARBOR, 52182151, 95 HEXHEAD, PLATED, 95934451, 130
CAP SOCKET HEAD, 54426135, 404
ROD ASSY CAP---1---8 X 4, 95105136, 6
50613769, 336 CAP---1/4---20 X3---1/4, 95103990, 196
57242638, 170 CAP---5/16 X 1---1/2, 50799170, 202
FEED CYLINDER, 57376659, 132 CAP---5/16 X 7/8, 50491729, 202, 422
ROD CHANGER, 57174138, 164 CAP---5/16---18X1---1/4, 95079984, 278
CAP---7/16---14X2---1/4, 95357232, 190
ROD CLEVIS, 57220303, 143 CAP---M16X2 X 40MM, 35272541, 251
ROD PACKING, 57115750, 48 CHAIN, 50021153, 458
FLAT HD---1/4---20X3/4, 95917696, 260
ROD TUBE, 57181232, 44, 49 HEX HD CAP, 54472139, 157
ROD WIPER, 57115768, 48 MOTOR, 57240749, 300
SET
ROD---TUBE, 57181059, 44, 49 57012684, 170, 176
ROLL PIN, 50650449, 198 57067571, 182
57239717, 298
ROLLER & BEARING ASSY, 57457608, 22
57240756, 300, 302
ROLLER ARRANGEMENT, 57562977, 18 SOCKET, 54426176, 408
SET---1/2---13 X 1/2, 95065868, 282
ROLLER GROUP---SFLG, 57563041, 20
SET---1/4---28 X 2, 57244907, 132
ROPE SET---CLEVIS, 57060352, 44, 143
WIRE---3/8 BULK, 57360059, 195 SET---M12 X 25MM, 92304435, 251
WIRE---3/8 X 59’, 58231812, 195 SOCKET HD CAP, 54472121, 157
Index xx WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

STOP, 50527308, 264 SEAL---LIP TYPE, 57356552, 30

SCREW TERMINAL SOCKET, 57137614, 384 SEAL---SHAFT, 35593516, 251
SEAL SEALER, 56776792, 12
50605740, 342, 344, 346 SEAT
50727429, 22 50636034, 342, 344, 346
52155363, 300 50798891, 104
52218500, 199 51218287, 65
57027310, 34
57429250, 132 SECTION
58232661, 198 PILOT, 50634351, 340
BRAKE, 57308009, 199 VALVE INLET, 50617091, 336
ELEMENT, 37187085, 326 VALVE OUTLET, 50613181, 336
FACE, 57552531, 26 VALVE SPOOL
HOUSING, 37184280, 326 50613199, 336
LEAD WIRE, 56997224, 441 50613207, 336
50613215, 336

INDEX
OIL
52146784, 150 SENSOR, MAGNETICCAT3406TA, 57212813,
52164282, 150 215
57171928, 285 SEPARATOR, 52217874, 307
58229915, 150
ROD SERVICE KIT, 50603869, 273
50461904, 464 SERVO, PUMP---INPUT, MANUAL, 57480386,
57520926, 44 296
ROD WIPER, 50170422, 167 SERVO OUTPUT, 57052631, 296
SECTION, 52179496, 404, 410
SHAFT SERVO PLATE, 52201738, 300
50816982, 288 SERVO SHAFT ASSY, 54409123, 302
51079176, 404, 410
SERVO---CONT.COVER GASKET, 57417339,
52154515, 296
298, 302
57117780, 157
SHEAR, 52201761, 298, 302 SET SCREW, 1/4---28UNF---2, 57244907, 49
SQ SECT SHAFT
50815794, 404, 410 50721174, 288
50815851, 291, 404, 410 52234887, 404
SEAL ASSY, 57245177, 44 57037350, 167
57037400, 167
SEAL GROUP, 57563009, 22 57240806, 157
SEAL GROUP---METAL FACE, 57563454, 34 58232703, 199
ANCHOR, 50219617, 176
SEAL KIT
CLEVIS ASSY., 57209090, 167
52179595, 404
INPUT, 57552838, 27
52188976, 202
INTERMEDIATE, 57191017, 150
57242547, 170 MOTOR, 57300220, 296
57248171, 48 OUTPUT, 52188901, 202, 422
57429292, 132 PIPE ASSY, 57148090, 167
58231119, 182 SPLINED #3, 57192213, 291
FIELD SERVICE, 57248189, 48 SUN GEAR
VALVE, 57240814, 44 57552499, 26
VITON, 57379984, 270 57552663, 26
SEAL KIT---CYLINDER, 57510927, 44 TCK ROLLER, 57562985, 22
TOWER SUPPORT, 50245604, 4
SEAL KIT---VALVE, 57240814, 49
SHAFT ASSY
SEAL SHAFT, 50495860, 291
52230869, 404
SEAL VANE, 54408380, 300 57457590, 22
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xxi
 Serial Number: 4133
FAMILY,DM50

Index

SHAFT LINK, 52201746, 298 SPACER

50244060, 129
SHAFT---IDLER, 57563462, 34
50248426, 167
SHEAR SEAL, 57153108, 298, 302 50350644, 180
50560135, 288
SHEAVE, WIRE, 50245810, 195 52141785, 346
SHEAVE WITH BUSHING, 57360448, 129 52209798, 150
52269883, 198
SHIELD 56970429, 113
A/C---UPPER, 57139727, 229 57120347, 196
AIR CLEANER, 57279135, 229 57208746, 46
SHIM 57245474, 132
50244086, 129, 168 57357063, 38
50248889, 80 CAB, 50693308, 59
52223872, 351 CHAIN, 50338482, 151
BLOCK---BEARING, 57357618, 6 INTERMEDIATEGEAR, 57159121, 150
INDEX

GUIDE PISTON, 57183618, 44

50339027, 129 SWIVEL PACKING, 57371163, 151
50624691, 151 VANE, 54408398, 300
50624709, 151 SPACER PLATE, 52188943, 202
PINANCHOR---ROT.HEAD, 57368243, 152
SPIDER KEY, 50830421, 199
POWERHEAD---SPURGEAR, 57243719, 151
SPINDLE
SHIM SET 57552408, 26
50518083, 215, 251 DRIVE, 52210275, 150
52210317, 151 VALVE, 50622463, 278
SHOE, TRACK, 57563496, 36 SPOOL
SHRINK DISCS, 52210291, 150 CENT LUBE GROOVES, 54407630, 298
SECTION, 57159691, 336
SHROUD, INLET, 56899669, 238, 242
SPRING
SIGNAL, SAFETY, 52248127, 240 35251552, 316
50109198, 426
SILENCER
50446368, 288
35132299, 270
50456938, 168
ALUMINIZED 8”, 57574162, 221
50619006, 336, 342
SLEEVE 50634385, 340
52249620, 104 50635986, 340
ADAPTER, 52143195, 285 50636042, 342, 344, 346
LOCATING, 57552820, 27 50650456, 198
PRE---CLEANER, 57371858, 72 50798925, 104
SHIFT, 57552846, 27 52141744, 346
SPLINE, 59516096, 285 52249638, 104
WEAR, 50822097, 151 57240566, 298
WEAR---6---1/4 ROD, 57029027, 452 57241739, 198
57356644, 32
SLIDE, 50072347, 42, 46 CHAIN TONG
SLINGER, 52187804, 151 50021229, 456
50024371, 456
SLYDRING COMPR, 52224193, 320
57245185, 44, 48, 49 COMPRESSION, 50709336, 318
57245441, 132 DISC, 50555697, 278
57245540, 44, 48, 49 HOLD DOWN, 57137622, 384
57247413, 132 RETAINER, 57514903, 157
SOCKET, 10040541, 452 SPRING GROUP RECOIL, 57563397, 18
Index xxii WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

SPRING GUIDE, PISTON SEAL, 52155660, 104 SUPPORT

57138141, 167
SPRING PLATE, 50815679, 318
57356685, 32
SPROCKET CAB, 50693290, 59
50334242, 129 COMPRESSOR, 57170896, 251
TRACK, 57355018, 18 FEED CYL---5 OD, 57315798, 129
SPROCKET GROUP, 57354946, 18 ROD, 50821347, 206
SIDE PLATE, 57055899, 152
SQUARE SECTION GASKET, 57192148, 291 TOWER PINNINGCYL, 57359127, 143
STANDPIPE TWR, 58235615, 4
57082554, 136 SUPPORT ASSY, 57356636, 32
57085573, 136
SUPPRT A.C., 57235574, 238
57085581, 136
57085599, 136 SWING DOOR, 57425704, 65
STEM SWITCH
52218146, 68, 118

INDEX
50023910, 273
HOSE, 57085128, 268 52218161, 65
52218294, 108
STEP, CAB, 57096794, 59 ADJ. AIR, 57301038, 446
STEPSEAL KEY, 56993678, 76
57245433, 132 LIMIT, 50518653, 206
57245458, 132 PRESSURE
57245532, 44, 48, 49 52232428, 384
57245557, 48, 49 57209884, 436
PUSH BUTTON, 52185832, 76
STOP SPEED, CAT, 57276768, 384
ANCHOR, 50704485, 152 SPST TOGGLE, 56762198, 76
BARREL, 54471792, 157 TOGGLE---SPST, 56762198, 118, 144, 190, 383
ROD CHANGER, 50829589, 168
ROD CHUCK, 50519594, 164 SWITCH ASSY, 56967292, 432

STRAINER, OIL, 50247691, 306 SWITCHGAGE

57018533, 76
STRAP OIL PRESSURE, 56993702, 78
57075426, 413
CURTAIN---TWRBOTTOM, 57184103, 413 SWIVEL, 52248176, 151
DUST CURTAIN, 57134942, 413 SWIVEL NUT, 95704839, 143, 190
REAR, 57120677, 413 SWIVELS, 57176737, 330
STRAPS --- MTG, 57371817, 72
STRIKER, DOOR LATCH, 57240921, 65
STRIP, 57356693, 32
T
SUB 57294944---VALVE KIT, 50527332, 260 TACHOMETER, CAT, 57276776, 76

SUB 57488942---CYLINDER, 57224628, 140 TANK

210 GAL. FUEL, 52225190, 246
SUB 57492563 CYLINDER, 57425209, 129 CHEMICAL, 52168234, 441
SUB 57531683, KIT, 56942600, 143 OIL SEPARATOR, 57159212, 268
WATER---100 GAL HORIZ, 57113714, 417
SUB 95077814 NUT, 95239539, 109, 221
TANK---RAD. BOTTOM, 57242117, 229
SUB 95223475---RING, RETAIN, 50597459, 285
TANK---RAD. TOP, 57242109, 229
SUBPLATE
TEE
57106965, 368
1/2 BARB---LASCO, 57451379, 113
57232589, 207
95279923, 190, 362
SUCTION MANIFOLD, 57173981, 310 95279956, 326
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xxiii
 Serial Number: 4133
FAMILY,DM50

Index

95403580, 362 57242620, 170

JIC, 95754651, 326 57245573, 44, 49
NPT/JIC FEED CYLINDER, 57376667, 132
95667820, 362 TUBE ASSY., 57168551, 182
95748927, 143, 224
SERVICE, 95221065, 260 TUBE REAR LOWER, 57202483, 232
TRIPLE, 50844067, 441 TUBE WATER OUTLET, 57228348, 224
TEE---INT NPT/JIC/INT NPT, 95675880, 327 TUBE---CROSS PORT CONNECT., 57137036,
TERMINAL 432
56769995, 218 TUBING
56921398, 109 57029126, 452
56921406, 65 MTG. HANDRAILS, 57119018, 10
56921471, 109 RND, 57024218, 452
56944101, 383, 389 ROUND
57073637, 386 57037319, 168
INDEX

95329249, 65, 383 57154692, 167

95329256, 384 SHAFTOSCILLATION, 57376618, 16
95359600, 384 VINYL, 50247709, 306, 384, 417
RING, 95359329, 448 TUBING---FLEXIBLE EXH.8, 57412603, 221
THERMOMETER, 50463454, 306
THERMOSTAT, EVAPORATOR, 57276891, 116
THRUST WASHER, 57300824, 157
U
TIE, CABLE, 56780729, 399 U---BOLT, 50424134, 238

TIE BAR, O---30 DEGREES, 57429326, 206 U---CUP

57163453, 178
TIEBAR, 52156916, 152 57326803, 178
TIMER, DC ELECTRIC, 57284671, 402 LOADED, 57224115, 170
TIMER BOX, BARE, 57514804, 402 UNDERCARRIAGE, 325L---L&S, 57388076, 16

TONG ASSY---W/FLAT INSERTS, 50021120, 454 UNION, PIPE---1---1/2 NPT, 95532271, 270

TOOL, 5” BORE SIZING, 57239469, 49 UPPER HSG SECTION, 57284648, 402

TOWER WELD, STD BOTTOM---25, 57479784,

129
V
TRACK ADJUSTMENT GROUP, 57563348, 18
V---BELT, 57324097, 108
TRACK GROUP, 57563470, 18
VALVE
TRACK LINK ASSY, 57563488, 36 2---WAY, 50429356, 357
TRANSITION---8, 57059644, 399 3---WAY, 50258128, 259
4---WAY
TUBE
57080319, 195
AIR---ALUM.6X74, 57314395, 238
57106460, 368
COOLANT, 57054793, 224
4---WAY SELECTOR, 57346843, 100
COPPER---1/2DIAX14 LG, 57451387, 113
50416551, 30
DEAERATION
50459155, 137
57350944, 224
57232571, 206
57351769, 224
ADAPTER, 54426184, 408
OIL, 52215225, 426
AIR---2 WAY, 52158714, 276
REAR UPPER, 57204232, 232
AUTO BLOWDOWN, 35849215, 270
RECT., 57369969, 143
BALL, 57417156, 68
TUBE ASSY BALL---1/2, 50829605, 273, 402, 432
52171931, 95 BALL---3/4, 50212224, 120
Index xxiv WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

BARE, 9---SPOOL, 57160053, 334 THROTTLE---INSTL, 52223666, 273

BUTTERFLY, 52206547, 251 VALVE BLOCK
BY PASS, 57113367, 316 52233145, 296
CHECK 57182883, 49
36843720, 266
50247733, 306 VALVE STOP D, 50058072, 276
50261825, 306, 307 VALVE---PRESS RELIEF, 57486565, 326
50347889, 136
VANE
50422930, 370
52179587, 406
50829480, 246 57192098, 291
56927445, 362, 366
56990849, 441 VANE HOLD DOWN SPRING, 57064065, 300
56996382, 137 VANE PIN, 57192106, 291
CHECK---DBL PILOT OP, 50462944, 174
VANE SPRING, 52179579, 406
CHECK---DBL PILOTOP, 50462944, 192
COUNTERBALANCE, 57205007, 44, 49 VARNISH, INSULATING, 57168916, 384

INDEX
DIVERTER, 57106429, 366 VENT
FEED, 52178779, 92 50811173, 306
FILL, 57563389, 30 FILTER, 56799125, 432
FLOW CONTROL
50518984, 418 VENT ASSEMBLY, 57420085, 436
57284705, 402 VENTURI, BSHG, 52214384, 424
IMPULSE, 56934185, 402 VLV ASSY CK, 52167756, 362
MAIN, 57096232, 95
MANUAL SHUTOFF, 52172723, 270 VLV ASSY PRO, 52214368, 362
MIN.PRESSURE, 57391047, 273 VLV SELECT, 52217247, 362
NEEDLE, 52210986, 259 VLV.ASY.DVT, 57035529, 362
OVERRUNNING LOAD, 57225302, 207
PILOT OPERATED, 57079204, 270
PLATE, 50747310, 288
POPPET---ANTIRUMBLE, 35316405, 259
W
PRESS. REDUCING, 52182623, 143, 190 WASHER
PRESSURE---REMOTE, 52236932, 102 50446400, 288
PUMP RELIEF, 57244352, 363 50635952, 340
RELIEF 50650415, 198
50514967, 190 52201779, 298, 302
50622273, 270 56986599, 282
50634336, 338 57357006, 38
52146883, 417 57357097, 18
57352825, 308 58232695, 199
58232596, 198 58232745, 199
RELIEF---75 PSI, 35321645, 254 58232760, 199
SAFETY FLAT, WIDE, 95094314, 129
50621986, 270 FLAT HARDFACED, 57238628, 215
57018673, 402 GSKT, 35251545, 316
SAFETY VENT, 50583228, 441 LOCK
SHUTOFF 95934733, 130
DISCHGPORT, 57440646, 108 HELICAL, 95937413, 129
SUCTIONPRT, 57440653, 108 HELICAL SPRG, 95939948, 129
SOLENOID TONGUED, 57291296, 150
57003790, 402 LOCK HELICAL, 95934741, 129
57039752, 143, 190 LOCK---3/8, 95959151, 95
SOLENOID---3WAY/2POS, 57312563, 436 LOCK---5/8 EXT., 95213427, 426
TEMP, 52159183, 326 LOCK---TONGUED, 57291288, 150
TEMPERATURE BYPASS, 57170821, 254 NYLITE, 52154622, 296, 298, 302
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xxv
 Serial Number: 4133
FAMILY,DM50

Index

RETAINING, 50219609, 176 WIRE

SPR, 50447333, 288 10 AWG---PINK, 58180076, 448
THRST, 50816933, 288 10AWG---BLACK, 50249697, 448
THRU, 50334457, 129 10AWG---RED, 50249689, 448
THRUST 10AWG---WHITE, 50628809, 448
52204856, 157, 296 14AWG---BLACK, 50249655, 383
54407457, 298, 302 14AWG---BLUE, 50812429, 383
54407481, 298, 302 14AWG---GREEN, 50625938, 383
57552861, 27 14AWG---VIOLET, 50623065, 383
14AWG---WHITE, 50249671, 109
WASHER---HARD, 57356669, 32 56809395, 130
WASHER---PLATED, 57355075, 18, 20, 24 8AWG---RED, 50465293, 383
LOCK, 50344605, 151, 152
WASHER---THRUST, 57356867, 22
WIRING, ENGINE, CAT, 57311987, 215
WHEEL, C.W., 57096844, 68, 116 WORM, 50830520, 199
INDEX

WINDOW WORM KEY, 50830413, 198

57425480, 65
WORMSHAFT, 50830538, 199
57425498, 65
WRENCH
WINDOW---DM45/50 CHAIN ADJUSTING, 52230786, 452
57119604, 65 CHAIN---5.313---6.25, 50260314, 452
57119620, 65
57119638, 65
57119646, 65
57119653, 65
Y
57119661, 65 YOKE, OSCILLATION, 57309783, 16
WIPER YOKE END, 52174232, 95
57224123, 170
57520959, 44
58233818, 184
59322677, 178
Z
FELT, 54426226, 404, 410 ZERK FITTING, 50830553, 199

Index xxvi WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

49833478, FITTING, HYD, 261

50005909, RING, SNAP, 288
50007384, CAP, 426
Numbers 50014414, BOLT, JAW---CHAIN TONG, 456
10040541, SOCKET, 452 50021120, TONG ASSY---W/FLAT INSERTS, 454
30395610, PLUG, 268 50021138, CHAIN ASSY, 454
30441570, CABLE, BATTERY, 218 50021153, SCREW, CHAIN, 458

35103852, BUSHING, SPLIT TAPER, 251 50021161, NUT, 458

35104082, LOCKNUT, 251 50021187, JAW---CHAIN TONG, 456

50021195, PIN, 458
35132299, SILENCER, 270
50021202, PIN, HANDLE---CHAIN TONG, 456
35251511, O---RING, 316
50021229, SPRING, CHAIN TONG, 456
35251529, HOUSING, 316

INDEX
50021237, BUSHING, CHAIN TONG, 456
35251545, WASHER, GSKT, 316
50021377, CHAIN SECT---2 LINKS, 454, 458
35251552, SPRING, 316
50021393, CHAIN, MASTER, 458
35272541, SCREW, CAP---M16X2 X 40MM, 251
50023910, STEM, 273
35277151, GLASS, 316
50024371, SPRING, CHAIN TONG, 456
35306984, ORIFICE, .09, 260
50024389, KEY, INSERT---CHAIN TONG, 456
35316405, VALVE, POPPET---ANTIRUMBLE,
50024397, INSERT, JAW---FLAT, 456
259
50024447, MASTER LINK, 458
35321645, VALVE, RELIEF---75 PSI, 254
50024512, PIN, SPRING---CHAIN TONG, 456
35364975, KEY DRIVE COUPLING, 251
50034818, CLAMP, HALF, 195
35516749, GAUGE, SIGHT, 268
50034826, CLAMP, HOSE, 174, 190, 192
35517234, ORIFICE, 270 HALF, 196, 434
35593516, SEAL---SHAFT, 251 50046846, RING, 90
35849215, VALVE, AUTO BLOWDOWN, 270 50046861, LEVEL, 90
35856467, OIL SEAL COVER, 251 50058072, VALVE STOP D, 276
35861269, DECAL, CORPORATENAMEPLATE, 50064096, NEEDLE VALVE, 426
461
50067479, CAP, 417
36001535, AIR END---1050HR2, 251
50067834, PIN, 42, 46
36037471, KIT, REPAIR UL---88 ASSY, 264
50068253, NOZZLE COLLR, 426
36765113, GEAR, SET HR2, 900, 1050CFM, 251
50068279, PIN, NOZZLE, 424
36783710, COUPLING, ASSY, 251 50072347, SLIDE, 42, 46
36843720, VALVE, CHECK, 266 50105832, ANCHOR D, 42
36860336, ELEMENT, OIL FILTER, 466 50109198, SPRING, 426
36887396, REGULATOR, UL---88 ASSY, 264 50118694, PLUG, OIL, 424
37184280, SEAL, HOUSING, 326 50135888, KNOB, 276
37187085, SEAL, ELEMENT, 326 50170422, SEAL, ROD WIPER, 167
37189511, ELEMENT, TEMP, 326 50171941, PIN, ANCHOR, 42, 46
39115035, BUSHING, 402 50173467, CAP, 42
39116819, COVER, 434, 448 50209501, GUIDE, SPRING---CHAIN TONG, 456
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xxvii
 Serial Number: 4133
FAMILY,DM50

Index

50209675, HANDLE, CHAIN TONG, 456 50262526, ANTI---FREEZE, 229

50212224, VALVE, BALL---3/4, 120 50279413, BAND, MOUNTING---AIRCLEANR,
221
50219518, FILLER, TANK---2.5 NPT, 246
50293737, PIN, 288
50219534, RACE, THRUST, 130, 167
50306315, NOZZLE, 426
50219609, WASHER, RETAINING, 176
50308758, DISC, VALVE, 278
50219617, SHAFT, ANCHOR, 176
50308766, CAP, VALVE, 278
50219955, PIN, LOCKING, 452
50318534, PLUG, 288
50243088, REST, WRENCH, 452
50334242, SPROCKET, 129
50243518, BEARING ASSY, 167
50334457, WASHER, THRU, 129
50244060, SPACER, 129 50335843, ADAPTER, 137
50244086, SHIM, 129, 168 50338482, SPACER, CHAIN, 151
50245604, SHAFT, TOWER SUPPORT, 4
INDEX

50338987, PIN, SPROCKET, 129

50245810, SHEAVE, WIRE, 195 50339001, PIN, CYLINDER, 129
50247691, STRAINER, OIL, 306 50339019, PLATE, LOCKING, 129
50247709, TUBING, VINYL, 306, 384, 417 50339027, SHIM, GUIDE, 129
50247733, VALVE, CHECK, 306 50339043, BOLT, CHAIN, 129
50248210, BEARING, LOWER, 167 50343490, ELEMENT, FILTER---3 MICRON, 318
50248236, CLEVIS, 167 50344605, WIRE, LOCK, 151, 152
50248368, RETAINER, BEARING, 167 50345677, PIN, 180
50248426, SPACER, 167 50346436, FOOT, JACK, 42, 46
50248434, PLATE, RETAINING, 167 50347889, VALVE, CHECK, 136

50248459, BUSHING, SWING CYLINDER, 167 50348317, FORK CHUCK---4.5 FLATS, 180

50248467, PIN, HINGE---HEAD END, 167 50348804, PLATE, 306

50350461, ANGLE, CYLINDER, 180
50248475, PIN, HINGE---ROD END, 167
50350644, SPACER, 180
50248848, CLEVIS, 80, 330
50364199, FITTING, TUBE, 306, 417
50248863, CLAMP, CABLE, 80
50370808, BODY, VALVE, 278
50248871, BRACKET, 80
50380799, CHUCK, 180
50248889, SHIM, 80
50383017, GUIDE, 180
50249655, WIRE, 14AWG---BLACK, 383
50411602, INDEXER, 168
50249671, WIRE, 14AWG---WHITE, 109
50412626, BUSHING, 129
50249689, WIRE, 10AWG---RED, 448
50415231, RING, THREAD LOCKING, 168
50249697, WIRE, 10AWG---BLACK, 448 50415249, PLATE, KEEPER, 168
50258128, VALVE, 3---WAY, 259 50415496, CHUCK, 5 HEX ROD, 164
50258193, PLATE, MOUNTING, 192, 195 50416544, OIL, GEAR, 282
50258276, CLEVIS, 206 50416551, VALVE, 30
50258441, PUMP, FUEL, 246 50421213, PUMP, HYDRAULIC, 282
50260314, WRENCH, CHAIN---5.313---6.25, 452 50422930, VALVE, CHECK, 370
50261825, VALVE, CHECK, 306, 307 50422997, GUIDE, SLIDING, 180
50262492, GAUGE, PRESSURE---0---160PSI, 259 50424134, U---BOLT, 238
Index xxviii WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

50425958, CROSSHEAD, 4 50514967, VALVE, RELIEF, 190

50427699, KIT, CARTRDGE, 288 50518083, SHIM SET, 215, 251
50427863, CAP, CROSSHE, 46 50518364, BRACKET, MOUNTING, 351
50428564, CLAMP, HOSE, 266 50518653, SWITCH, LIMIT, 206
50429356, VALVE, 2---WAY, 357 50518984, VALVE, FLOW CONTROL, 418
50429455, BRACKET, VALVE, 357 50519578, BOLT, ROD CHUCK, 164
50446327, BEARING, 288 50519594, STOP, ROD CHUCK, 164
50446343, RING, SNAP, 288 50527308, SCREW, STOP, 264
50446350, LIMITER, LIFT, 288 50527332, SUB 57294944---VALVE KIT, 260
50446368, SPRING, 288 50530286, BUSHING, CHAIN, 152

50446392, PIN, 288 50555697, SPRING, DISC, 278

50446400, WASHER, 288 50559830, RING, SNAP, 288

INDEX
50447333, WASHER, SPR, 288 50559848, SCREW, 288
50559913, PLATE, 288
50447341, PLATE, SHOE, 288
50560077, NAMEPLATE, 288
50447366, PLATE, SWASH, 288
50560135, SPACER, 288
50447374, BEARING, 288
50583228, VALVE, SAFETY VENT, 441
50453729, HOLDER, ROD SEAL, 464
50583236, NOZZLE, 441
50456896, BRACKET, INDEXING CYLIND, 168
50583251, CARTRIDGE, 441
50456912, PIN, 168
50597434, O---RING, 285
50456938, SPRING, 168
50597442, RING, SNAP, 285
50456946, BRACKET, 168
50597459, SUB 95223475---RING, RETAIN, 285
50457050, CABLE, CONTRL, 330
50597624, ADAPTER, SAE C, 285
50458959, BEARING, THRUST, 167
50603869, SERVICE KIT, 273
50459155, VALVE, 137
50604479, DOWEL PIN, 291
50461789, ADAPTER---MIDDLE, 6.25 RODS,
164 50605682, O---RING, 338, 340

50461797, ADAPTER, UPPER---6.25 RODS, 164 50605690, O---RING, 340

50605708, O---RING, 340
50461904, SEAL, ROD, 464
50605716, RING, BACK---UP, 340
50462332, PLATE, 42
50605724, RING, BACK---UP, 340
50462514, PLATE, MOUNTING, 180
50605732, O---RING, 340
50462944, VALVE
CHECK---DBL PILOT OP, 174 50605740, SEAL, 342, 344, 346
CHECK---DBL PILOTOP, 192 50605757, O---RING, 342, 344, 346
50463454, THERMOMETER, 306 50610971, RING, THREADED, 151
50463645, HOSE HUMP, 224 50612530, CABLE---PUSH/PULL, 80
50465293, WIRE, 8AWG---RED, 383 50613181, SECTION, VALVE OUTLET, 336
50477926, SCREW, 288 50613199, SECTION, VALVE SPOOL, 336
50491729, SCREW, CAP---5/16 X 7/8, 202, 422 50613207, SECTION, VALVE SPOOL, 336
50495860, SEAL SHAFT, 291 50613215, SECTION, VALVE SPOOL, 336
50514074, PIN, 246 50613728, HANDLE ASSY, 336
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xxix
 Serial Number: 4133
FAMILY,DM50

Index

50613769, ROD ASSY, 336 50634369, POPPET, 340

50616028, AIR CLEANER, 238 50634377, PISTON, 340
50616390, ELEMENT, PRIMARY, 242 50634385, SPRING, 340
50616408, ELEMENT, SAFETY, 242 50634393, POPPET, 340
50616762, GAUGE, FUEL, 246 50635945, NUT, 340
50617091, SECTION, VALVE INLET, 336 50635952, WASHER, 340
50618990, POPPET, 336, 342 50635960, NUT, 340
50619006, SPRING, 336, 342 50635978, SCREW, 340
50619014, O RING, 336, 338, 342, 344, 346 50635986, SPRING, 340
50619915, NUT, LOCK---1/2 CONDUIT, 330, 384 50635994, POPPET, 340
50621325, BIT REST---20 TABLE, 452 50636000, SCREW, 342, 344, 346
50621796, KIT, GASKET---AIR CLEANER, 240, 50636018, CAP, 342, 344
INDEX

242 50636026, SCREW, ADJUSTING, 342, 344

50621986, VALVE, SAFETY, 270 50636034, SEAT, 342, 344, 346
50622257, PLATE, 129 50636042, SPRING, 342, 344, 346
50622273, VALVE, RELIEF, 270 50636059, PLATE, 342, 344, 346
50622463, SPINDLE, VALVE, 278 50636513, GASKET, 198
50622729, FLANGE, PIPE, 221 50636547, O---RING, 202
50622745, COUPLING, V---RETAINER, 221 50644558, RING SNAP, 291
50622752, GASKET, FLAN, 221 50647767, CPSCRW/LCWSH, 199
50623065, WIRE, 14AWG---VIOLET, 383 50650381, PLATE, BRASS, 198
50623735, CABLE ASSY---BATTERY, 218 50650399, PLATE, 198
50624691, SHIM, GUIDE, 151 50650407, RING, LOCK, 198
50624709, SHIM, GUIDE, 151 50650415, WASHER, 198
50625839, BUSHING, CONDUIT, 384 50650449, ROLL PIN, 198
50625888, BOX, HANDY, 434, 448 50650456, SPRING, 198
50625938, WIRE, 14AWG---GREEN, 383 50668060, LINK, 348
50625946, CONNECTOR, CORD GRIP, 399 50668078, PIN, ROLL, 348
50626605, BRACKET, 282 50691658, MANIFOLD, 306
50626977, BRACKET---THRTLE VLV MTG, 276 50691690, ADAPTER, 306
50627918, BALL, KNOB, 336 50691831, NIPPLE, 306
50628007, LOCK, SPINDLE, 162 50691989, FLANGE, 326
50628726, BUSHING, 384 50692086, CLIP, LOCKING, 130
50628809, WIRE, 10AWG---WHITE, 448 50693290, SUPPORT, CAB, 59
50630656, FILTER, MAGNETIC, 306 50693308, SPACER, CAB, 59
50632538, BEARING BALL, 291 50694876, PACKING, SWIVEL, 151
50634328, PLUG, 336, 338 50694934, BUSHING, WEAR, 151
50634336, VALVE, RELIEF, 338 50696384, ADAPTER, 326
50634344, CAP, 340 50696939, CONNECTOR, CORD GRIP, 330
50634351, SECTION, PILOT, 340 50700731, COMPOUND, SILICONE, 152
Index xxx WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

50700814, ADAPTER, 366 50816271, SCREW, 291

50702927, BUSHING, CHAIN ANCHOR, 151 50816289, PIN, 291
50704485, STOP, ANCHOR, 152 50816420, NUT, 242
50704519, ARM, UPPER---SPUR HEAD, 168 50816446, NUT, WING, 240, 242
50707025, CHAIN, UPPER, 129 50816479, CUP ASSY, 240, 242
50709336, SPRING, COMPRESSION, 318 50816487, CLAMP, 240, 242
50709666, END CAP, 404 50816503, INLET, AIR, 240, 242
50710490, BEARING CONE, 199 50816511, CLAMP, 240, 242
50710508, BEARING CUP, 198 50816529, BODY ASSY---AIR CLEANER, 242
50710532, ADAPTER, 198 50816537, ACCESS COVER, 242
50715499, RING, 95 50816909, PLATE, ROTAT, 288
50715507, O---RING, 95 50816925, GASKET, 288

INDEX
50721174, SHAFT, 288 50816933, WASHER, THRST, 288
50727429, SEAL, 22 50816941, BLOCK, 288
50730613, HANDLE, VALVE, 278 50816958, KIT, PISTON, 288
50743731, CLAMP, HOSE, 273 50816966, HOUSING, 288
50747310, VALVE, PLATE, 288 50816974, O---RING, 288
50798891, SEAT, 104 50816982, SEAL, SHAFT, 288
50798925, SPRING, 104 50817089, PINS, 157
50799170, SCREW, CAP---5/16 X 1---1/2, 202 50817113, CHAMBER, 240
50806223, RING, SNAP, 291, 404 50817121, COVER ASSY, 240
50810993, DECAL, HYD.OIL LEVEL, 306 50817618, GEAR, 56T, 285
50811173, VENT, 306 50819192, GASKET, 310
50812429, WIRE, 14AWG---BLUE, 383 50819200, GASKET, TOP, 310
50813567, PIN, CYLINDER, 140 50820307, COVER TOP, 310
50813575, PLATE, LOCKING, 140 50820935, MOTOR, HYDRAULIC, 195
50814581, FITTING, HYD, 432 50820950, CK VALVE, 370
50815638, BOLT, 316 50821313, PLATE, GUIDE, 206
50815646, ALARM, DIRTY FILTER, 318 50821321, GUIDE, ROD, 206
50815653, ELEMENT, BUSHING, 318 50821347, SUPPORT, ROD, 206
50815661, MAGNET ASSY, 318 50821362, PIN, 206
50815679, SPRING PLATE, 318 50822097, SLEEVE, WEAR, 151
50815695, O---RING, 318 50823707, KIT, SEAL, 288
50815703, HOUSING, SINGLE ELEMENT, 318 50825504, AIR FILTER, 238
50815711, RING, RETAING, 318 50829480, VALVE, CHECK, 246
50815794, SEAL, SQ SECT, 404, 410 50829589, STOP, ROD CHANGER, 168
50815802, BEARING, NEEDLE, 404 50829605, VALVE, BALL---1/2, 273, 402, 432
50815810, PIN, DOWEL, 404 50829704, DECAL, VENT MANIFOLD, 306
50815851, SEAL, SQ SECT, 291, 404, 410 50829712, DECAL, DRAIN MANIFOLD, 306
50815901, RING, SNAP, 404 50830322, PIN, 348
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xxxi
 Serial Number: 4133
FAMILY,DM50

Index

50830348, LEVER, 348 52146958, ELEMENT, PRIMARY, 240

50830355, KNOB, BLACK, 348 52146966, ELEMENT, SAFETY, 240
50830363, SCREW, 348 52147543, BLOCK, GUIDE, 129
50830397, BUSHING, 199 52153210, BRACKET---CABLE MTG, 330
50830413, WORM KEY, 198 52154499, GASKET, 296
50830421, SPIDER KEY, 199 52154515, SEAL, SHAFT, 296
50830520, WORM, 199 52154531, GASKET, RETAINING, 296
50830538, WORMSHAFT, 199 52154622, WASHER, NYLITE, 296, 298, 302
50830546, GASKET, 198 52154937, O---RING, 298
50830553, ZERK FITTING, 199 52154952, GASKET, 296
50830587, CABLE CLAMP, 199 52154994, O---RING, 157
50830660, DOWEL PIN, 198 52155033, GASKET, HOUSING, 296
INDEX

50844059, BRACKET, NOZZLE, 441 52155041, BEARING, 157

50844067, TEE, TRIPLE, 441 52155140, RING, RETAINING, 160
50903236, BREATHER, 306 52155157, RING, RETAINING, 160
50998103, PLUG, 202, 422 52155165, RING, RETAINING, 160
50998145, CAP, END, 422 52155256, SCREW, 300
51024792, BLOWER MOUNT, 402 52155306, PLUG, 300
51076156, O---RING, 368 52155314, O---RING, 300
51076164, O---RING, 368 52155322, COVER, 300
51076172, O---RING, 368 52155330, COVER, CONTROL, 300
51076271, BOLT KIT, 368 52155348, PIN, 300
51079176, SEAL, SHAFT, 404, 410 52155363, SEAL, 300
51218287, SEAT, 65 52155371, BALL, 300, 408
52140423, B0LT---NUT, 198 52155454, PIN, 298
52140431, BOLT, 199 52155660, SPRING GUIDE, PISTON SEAL, 104
52140464, GREASE PLUG, 198 52155686, CONE, 104
52140480, CPSCRW/LCWSH, 198 52155751, RING, RETAINING, 296
52141736, PIN, 346 52155843, RING, RETAINING, 157
52141744, SPRING, 346 52156916, TIEBAR, 152
52141751, BALL, 346 52158094, CONTROL, 330
52141769, BALL, 346 52158714, VALVE, AIR---2 WAY, 276
52141785, SPACER, 346 52158961, PLATE, EXTENSION, 129
52141793, RING, RETAING, 346 52159183, VALVE, TEMP, 326
52141801, CAP, 346 52162138, MANIFOLD, 259, 327
52143195, SLEEVE, ADAPTER, 285 52163474, GEROTOR ASSY, 296
52145489, NAMEPLATE, 195 52164282, SEAL, OIL, 150
52145836, HOSE HUMP, 238 52167756, VLV ASSY CK, 362
52146784, SEAL, OIL, 150 52167848, BRACKET, VALVE, 96
52146883, VALVE, RELIEF, 417 52167905, ADPT. CROSS, 137
Index xxxii WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

52168234, TANK, CHEMICAL, 441 52190733, PIPE, EXHAUST, 221

52168259, CARTRIDGE, 441 52198173, HOSE ASSY, 190
52168267, BRACKET, CARTRIDGE, 441 52201696, BARRL/SLEEVE, 157, 296
52168325, CAP, BLOW OFF, 441 52201712, FACEPLATE, BARREL---13/32, 157,
296
52168374, BRACKET, TANK MOUNTING, 441
52201738, SERVO PLATE, 300
52171931, TUBE ASSY, 95
52201746, SHAFT LINK, 298
52172384, BAR, STIFFNER, 164
52201761, SEAL, SHEAR, 298, 302
52172723, VALVE, MANUAL SHUTOFF, 270
52201779, WASHER, 298, 302
52174232, YOKE END, 95
52201803, RING, RETAING, 298, 302
52174240, BRACKET, 95 52201811, PIPE PLUG, 298, 302
52175809, BOX, 1/2 STONCO, 434 52201845, PLATE, PORT---RH 13/32, 296
52177623, FITTING, HYD, 96

INDEX
52202736, GEAR, OUTPUT, 150
52177706, LINK, 95 52203668, PLATE, CREEP, 157
52178779, VALVE, FEED, 92 52203718, CRADLE, 300
52179488, PLATE, PORT, 404 52203767, O---RING, 300
52179496, SEAL, SECTION, 404, 410 52204856, WASHER, THRUST, 157, 296
52179504, BEARING, BALL, 404 52204864, RING, RETAINING, 160, 296
52179579, VANE SPRING, 406 52204872, RING, RETAINING, 160, 296
52179587, VANE, 406 52206547, VALVE, BUTTERFLY, 251
52179595, SEAL KIT, 404 52208162, LINK, 260
52180106, PLATE, COVER, 151 52208253, BRACKET, 95

52180957, GREASE, 152, 232 52208691, BRACKET, MOUNTING, 192

52182151, ROD ARBOR, 95 52209798, SPACER, 150

52209939, BEARING, 151
52182623, VALVE, PRESS. REDUCING, 143, 190
52210275, SPINDLE, DRIVE, 150
52182763, DRIVE GROUP, AUX, 109
52210291, SHRINK DISCS, 150
52183233, FILTER, OIL---ENGINE, 215
52210317, SHIM SET, 151
52185832, SWITCH, PUSH BUTTON, 76
52210986, VALVE, NEEDLE, 259
52187465, FITTING, HYD, 260
52211679, BODY LUB, 424
52187804, SLINGER, 151
52214178, ELEMENT, FLTR---3 MICRON, 320
52188851, FLANGE, MOUNTING, 202, 422
52214368, VLV ASSY PRO, 362
52188885, RACE, BEARING, 202, 422
52214384, VENTURI, BSHG, 424
52188893, KEY, WOODRUFF, 202, 422 52215225, TUBE, OIL, 426
52188901, SHAFT, OUTPUT, 202, 422 52215233, NOZZLE, COMPLETE, ASM, 424
52188927, HOUSING, 1/2 NPT PORTS, 202 52215506, CAP, WEATHER, 221
52188935, DRIVE SHAFT, 202, 422 52215613, SCREW, 157
52188943, SPACER PLATE, 202 52215696, O---RING, 157
52188950, GEROTOR SET, 202 52217247, VLV SELECT, 362
52188968, CAP, END, 202 52217874, SEPARATOR, 307
52188976, SEAL KIT, 202 52218054, CORE, 68
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xxxiii
 Serial Number: 4133
FAMILY,DM50

Index

52218146, SWITCH, 68, 118 52231818, BRACKET, 260

52218161, SWITCH, 65 52232428, SWITCH, PRESSURE, 384
52218294, SWITCH, 108 52233145, VALVE BLOCK, 296
52218500, SEAL, 199 52233194, CAM RING ASM, 404
52218690, PIST/SHOEASY, 296 52234457, BRACKET, 326
52220712, ADAPTER, 351 52234879, CAM RING, 351
52221678, RELIEF VALVE, 96 52234887, SHAFT, 404
52222510, BRACKET, 215 52235363, BRACKET, OIL, 215, 308
52223070, CLAMP, 224 52236569, GASKET, 3/4, 383
52223666, VALVE, THROTTLE---INSTL, 273 52236783, CLAMP ASSY, 1/2”, 207
52223690, MANIFOLD, 276 52236791, CLAMP ASSY, 3/4, 383
52223765, RELIEF VLV, 92 52236932, VALVE, PRESSURE---REMOTE, 102
INDEX

52223781, OIL, HYDRAULIC, 306 52237096, LIFTING BAIL---4 BECO, 452

52223807, DECAL, HYDRAULIC OIL, 307 52238318, RELAY, N.O. POWER, 383
52223872, SHIM, 351 52240090, HOUSING, HALF, 198
52224144, ALARM, DIRT, 320 52240132, GASKET, 198
52224151, BUSHING, 320 52240140, GASKET, 198
52224177, MAGNET ASSY, 320 52240439, PLATE, TAPPED, 383
52224185, PLATE, SPRING, 320 52244449, HOSE ASSY, 174, 433
52224193, SPRING, COMPR, 320 52245065, PUMP, HYDRAULIC, 282
52224201, O---RING, 320 52245461, ADAPTER, 150
52224219, HOUSING, 320 52246477, GUARD, 351
52224227, RING, RETAINING, 320 52246519, CABLE, GROUND---1/0 X 36, 384
52225075, PIPE FUEL TK, 246 52246774, FUEL, DIESEL, 246
52225190, TANK, 210 GAL. FUEL, 246 52247111, PUMP, HYDRAULIC, 282
52225547, HOSE ASSY, 357 52247657, PLATE, COVER, 251
52226115, KIT, SPLIT FLANGE, 363 52248127, SIGNAL, SAFETY, 240
52226453, HOSE ASSY, 88 52248150, HOUSING, UPPER SEAL, 150
52226479, HOSE ASSY, 433 52248176, SWIVEL, 151
52226768, HOSE ASSY, 433 52249448, ANCHOR CHAIN, 151
52227337, PIN, SPROCKET, 129 52249588, KNOB, CONTROL, 104
52227733, LINKAGE, 260 52249604, PISTON, 104
52228475, HOSE ASSY, 432 52249620, SLEEVE, 104
52230786, WRENCH, CHAIN ADJUSTING, 452 52249638, SPRING, 104
52230794, CLAMP, HOSE, 402 52249646, BALL, 104
52230810, CLAMP, HOSE, 224 52249828, HOSE, WATER, 229
52230869, SHAFT ASSY, 404 52252053, SCREW, 198
52231008, COVER, 154 52253176, GAUGE, SIGHT, 152
52231107, GUARD, COUPLING, 417 52254885, FILTER, HYDRAULIC, 306
52231347, CLIP, MOUNTING, 351 52259363, FILTER ASSY---HYD, 314
Index xxxiv WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

52259769, GEAR/SPIDER, 198 54418090, GASKET, 246

52260734, GASKET, 198 54426135, SCREW, CAP SOCKET HEAD, 404
52263159, HOIST, JIB, 195 54426150, ROTOR, 406
52263183, ELEMENT, FILTER---MAIN HYD, 54426168, PLATE, PORT, 408
316, 466 54426176, SCREW, SET, SOCKET, 408
52263530, MANIFOLD, 314 54426184, VALVE, ADAPTER, 408
52263548, MANIFOLD, 314 54426226, WIPER, FELT, 404, 410
52263555, O---RING, 314 54426242, BODY, 404
52263563, BOLT, 314 54465646, RING, CAM, 406
52263571, NUT, LOCK, 314 54471321, PORT BLOCK, W/O SHUTTLE, 157
52263787, GASKET, 251 54471768, GASKET, 157
52264272, REST, CYLINDER, 129 54471792, STOP, BARREL, 157

INDEX
52264652, RETAINER, TRACK, 16 54471917, CAM, MOTOR, 157
52265311, INDICATOR, RESTRICTION, 238 54472105, PIN, DOWELL, 157
52267408, PLATE, COVER, 152 54472113, HOUSING, 157
52269883, SPACER, 198 54472121, SCREW, SOCKET HD CAP, 157
52279338, FUSE, 444 54472139, SCREW, HEX HD CAP, 157
54407317, BEARING, 296 54472147, KIT, SEAL M6F, 157
54407390, SCREW, 298, 302 54472170, KIT, RETAINING RING, 157
54407416, O---RING, 298, 302 54472469, RING, RETAINING, 160
54407457, WASHER, THRUST, 298, 302 54494018, PLATE, PORT, FRONT, 291
54407473, INDICATOR, 302 54494026, PLATE, PORT, REAR, 291
54407481, WASHER, THRUST, 298, 302 54503743, COVER, CRANK CASE, 420
54407499, COVER, 298 56001118, BEARING, MOTOR, 202, 422
54407580, SCREW, ADJ, 298 56275969, REGULATOR, 259
54407606, PIN, 298 56275977, KIT, REPAIR REGULATOR, 259
54407630, SPOOL, CENT LUBE GROOVES, 298 56761554, ELBOW, RUBBER---90 DEG, 238
54408059, PLUG, 157 56762198, SWITCH
SPST TOGGLE, 76
54408299, RING, RETAINING, 160 TOGGLE---SPST, 118, 144, 190, 383
54408331, SCREW, 300 56769995, TERMINAL, 218
54408349, SCREW, 300 56770001, CABLE, BATTERY---2/0, 218
54408356, SCREW, 300 56770027, LUG, 218
54408364, CONTROL CHAMBER, 300 56773708, GROMMET, RUBBER, 108
54408372, PLATE, SEAL VANE, 300 56776792, SEALER, 12
54408380, SEAL VANE, 300 56778699, CLAMP, SEAL, 221
54408398, SPACER, VANE, 300 56780729, TIE, CABLE, 399
54408406, ROCKER AND PLUG, 300 56782014, BRACKET, 384
54409123, SERVO SHAFT ASSY, 302 56783020, KIT, SPLIT FLANGE, 95
54413646, RETAINER PISTON & SHOE, 157 56790330, ANGLE, 389
54416557, PLATE, WEAR, 402 56799125, VENT, FILTER, 432
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xxxv
 Serial Number: 4133
FAMILY,DM50

Index

56809395, WIRE, 130 56954217, HOSE ASSY, 137, 442

56849672, MANIFOLD, 432 56954233, HOSE ASSY, 215
56883572, KIT, SPLIT FLANGE, 95 56954282, HOSE ASSY, 433
56883614, O---RING, 372 56954365, HOSE ASSY, 363
56893365, CABLE, BATTERY, 218 56954589, HOSE ASSY, 206
56899669, SHROUD, INLET, 238, 242 56955107, HOSE ASSY, 190, 192
56901853, BAR, FLAT, 16 56955115, HOSE ASSY, 432
56919004, FITTING, HYD, 364 56955651, HOSE ASSY, 363
56920903, FITTING, HYD, 224 56955776, HOSE ASSY, 137
56921398, TERMINAL, 109 56956139, HOSE ASSY, 259, 433, 442
56921406, TERMINAL, 65 56956147, HOSE ASSY, 441
56921471, TERMINAL, 109 56956154, HOSE ASSY, 327
INDEX

56924764, GUSSET, 434 56956220, FITTING, HYD, 59

56924962, FITTING, HYD---TEE ADAPTER, 137 56956675, HOSE ASSY, 307
56927445, VALVE, CHECK, 362, 366 56956915, HOSE ASSY, 137
56930688, GAUGE, PRESSURE---0---5000PSI, 82, 56956931, HOSE ASSY, 136
84 56957780, HOSE ASSY, 399
56933732, CABLE, WHIP CHECK, 138 56957798, HOSE ASSY, 270
56934185, VALVE, IMPULSE, 402 56957830, HOSE ASSY, 327
56939416, HANDRAIL, 10 56957889, HOSE ASSY, 254
56939424, HANDRAIL, 10 56958523, CLAMP, HOSE, 399
56940281, O---RING, SPLIT FLANGE (20), 98 56959836, HOSE ASSY, 441
56942600, SUB 57531683, KIT, 143 56959844, HOSE ASSY, 100
56943699, CLAMP ASSY, 3 TUBE, 143 56960826, HOSE ASSY, 136, 441
56944101, TERMINAL, 383, 389 56961287, HOSE, HYD---E32 BULK, 232
56947534, FITTING, HYD, 260 56961782, HOSE ASSY, 174
56947609, HOSE ASSY, 137 56961816, HOSE ASSY, 354
56947674, HOSE ASSY, 363 56961824, HOSE ASSY, 140, 354, 433
56947682, HOSE ASSY, 351 56962368, HOSE ASSY, 254, 417
56949407, HOSE ASSY, 140 56964133, HOSE ASSY, 96, 357, 442
56950454, HOSE ASSY, 306 56964141, HOSE ASSY, 362, 363, 433
56950488, HOSE ASSY, 351 56964166, HOSE ASSY, 351
56951395, GAUGE, AIR PRESS---400 PSI, 86, 88 56964182, HOSE ASSY, 192
56953045, GASKET, 196 56964190, HOSE ASSY, 192, 433
56953896, HOSE ASSY, 206 56964208, HOSE ASSY, 362
56953961, HOSE ASSY, 206 56964216, HOSE ASSY, 433
56954050, HOSE ASSY, 143 56964224, HOSE ASSY, 140, 326
56954100, HOSE ASSY, 140 56964240, HOSE ASSY, 433
56954159, HOSE ASSY, 326, 433, 441 56964273, HOSE ASSY, 433
56954167, HOSE ASSY, 100, 418 56964299, HOSE ASSY, 327, 433
Index xxxvi WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

56964315, HOSE ASSY, 433 56991193, CONNECTOR, 384

56964349, HOSE ASSY, 78 56992092, HOSE ASSY, 195
56964869, PUMP, 50 TO 1, 436 56992118, HOSE ASSY, 363
56965759, HOSE ASSY, 102 56992191, CONNECTOR, 434
56966211, HOSE ASSY, 102, 433 56992357, HOSE ASSY, 136
56966948, HOSE ASSY, 326 56992514, HOSE ASSY, 137, 354
56967292, SWITCH ASSY, 432 56992522, HOSE ASSY, 143, 195
56970429, SPACER, 113 56993678, SWITCH, KEY, 76
56970627, HOSE ASSY, 433 56993702, SWITCHGAGE, OIL PRESSURE, 78
56972680, HOSE ASSY, 102, 362 56994528, HOSE ASSY, 363
56972698, HOSE ASSY, 433 56994569, HOSE ASSY, 307
56972706, HOSE ASSY, 327 56996036, HOSE ASSY, 143

INDEX
56973027, HOSE ASSY, 307 56996382, VALVE, CHECK, 137
56973035, HOSE ASSY, 326 56997109, ACTUATOR, PNEUMATIC, 441
56973126, HOSE ASSY, 137 56997141, LOCKWASHER, 441
56973621, HOSE ASSY, 433 56997166, NOZZLE, 441
56974223, HOSE ASSY, 259, 270 56997216, LABEL, OPERATING INSTRUCT, 441
56974579, HOSE ASSY, 433 56997224, SEAL, LEAD WIRE, 441
56975964, PIN, CLEVIS, 143 56997679, DISC, BURST, 441
56975972, PIN, CLIP, 143 57003634, BAR, FLAT, 195
56975980, HOSE ASSY, 433 57003782, MOTOR, HYDRAULIC, 402
56976590, HOSE ASSY, 327 57003790, VALVE, SOLENOID, 402
56976616, BRACKET, 136 57004020, HOSE ASSY, 174, 190, 238, 433
56976954, GREASE, EP0, 434 57004053, HOSE ASSY, 441
56981459, BAR, FLAT, 444 57005662, HOSE ASSY, 327
56981509, HOSE ASSY, 195 57005688, HOSE ASSY, 433
56981632, HOSE ASSY, 254 57005696, HOSE ASSY, 327
56984131, BUSHING, 351 57007528, HOSE ASSY, 326
56986599, WASHER, 282 57009367, HOSE ASSY, 418, 441
56987456, GROMMET, RUBBER, 108 57011306, HOSE ASSY, 418
56987910, HOSE ASSY, 327 57011355, HOSE ASSY, 190
56987936, HOSE ASSY, 327, 432 57011363, HOSE ASSY, 207
56987951, HOSE ASSY, 326 57012676, PLUG, NYLON, 170, 176
56988033, HOSE ASSY, 326 57012684, SCREW, SET, 170, 176
56988280, DECK, 8 57014672, ANGLE, 384
56988850, HOSE ASSY, 137 57015752, HOSE ASSY, 259
56989197, HOSE ASSY, 224 57015836, HOSE ASSY, 246
56989338, HOSE, RADIATOR---BULK, 224, 399 57018343, CYLINDER, HYDRAULIC, 206
56989353, HOSE, RADIATOR, 224 57018350, KIT, SEAL, 210
56990849, VALVE, CHECK, 441 57018533, SWITCHGAGE, 76
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xxxvii
 Serial Number: 4133
FAMILY,DM50

Index

57018673, VALVE, SAFETY, 402 57043200, HOSE ASSY, 433

57020661, HOSE ASSY, 143 57043218, HOSE ASSY, 433
57020760, HOSE ASSY, 433 57043341, HOSE ASSY, 95
57020810, HOSE ASSY, 357 57043697, HOSE ASSY, 259
57022196, BRACKET, MOUNTING, 384 57043788, HOSE ASSY, 362
57022246, HOSE ASSY, 432 57043804, HOSE ASSY, 270
57024218, TUBING, RND, 452 57043812, HOSE ASSY, 259
57025926, HOSE ASSY, 273 57043820, HOSE ASSY, 259
57026395, BEARING, BARREL, 296 57044521, HOSE ASSY, 322, 362
57026403, RING, RETAING, 296 57044554, HOSE ASSY, 95
57026411, RING, RETAING, 296 57044588, HOSE ASSY, 364
57026429, RING, RETAING, 296 57044612, HOSE ASSY, 362
INDEX

57026478, PLATE, CREEP, 296 57044620, HOSE ASSY, 307

57027310, SEAL, 34 57044661, HOSE ASSY, 307
57029027, SLEEVE, WEAR---6---1/4 ROD, 452 57044711, HOSE ASSY, 363, 433
57029092, BUSHING, CENT, 452 57044752, HOSE ASSY, 174, 190
57029100, BAR, FLAT, 452 57045296, BAR, W/HOLES, 143, 190
57029118, PLATE, 452 57045494, CAP, 291
57029126, TUBING, 452 57047995, KIT, CUP, 420
57032955, ADPTR, DRL RD, 162 57048001, KIT, SEAL, 420
57032963, BOX, ELEC.JIC, 386 57048977, PUMP, 3GPM WATER INJ., 417
57032997, KIT, SEAL, 291 57050718, BRACKET, 259
57034308, HOSE ASSY, 259 57052599, FLANGE, 138
57034357, HOSE ASSY, 190, 246 57052623, BRACKET, 143, 190
57034712, HOSE ASSY, 362 57052631, SERVO OUTPUT, 296
57035529, VLV.ASY.DVT, 362 57053183, HOSE, HYD---A06 BULK, 59
57036527, BUSHING ASSY---6---1/4 ROD, 452 57053522, CAM ASSEMBLY (14), 291
57036600, HOSE ASSY, 433 57053555, KIT, SHAFT, 291
57036881, BAR, COPPER, 384 57053761, HOSE ASSY, 418
57037319, TUBING, ROUND, 168 57053787, HOSE ASSY, 136
57037350, SHAFT, 167 57053829, HOSE ASSY, 95, 322
57037392, ARM, LOWER, 167 57054009, CYLINDER, HYDRAULIC, 180
57037400, SHAFT, 167 57054793, TUBE, COOLANT, 224
57039620, CYLINDER, HYDRAULIC, 168 57054991, BAR, TAPPED, 174
57039638, CYLINDER, HYDRAULIC, 176 57055899, SUPPORT, SIDE PLATE, 152
57039752, VALVE, SOLENOID, 143, 190 57057408, HOSE ASSY, 259
57039810, KIT, SEAL, 176 57057929, HOSE ASSY, 399
57039828, KIT, SEAL, 168 57058356, PUMP, DOUBLE HYDRAULIC, 282
57040016, CLAMP, 168 57059404, ELEMENT, FLTR, 108
57042921, HOSE ASSY, 143 57059636, ELBOW, RUBBER, 238
Index xxxviii WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

57059644, TRANSITION---8, 399 57078032, PANEL, MOUNTING, 70

57059701, FLANGE, 1NPTF, 327 57078263, GAGE ASSY, 76
57060154, CHUTE, TRANSITION, 402 57079105, DUCT, AIR, 238
57060337, RING, RETAINING, 143 57079204, VALVE, PILOT OPERATED, 270
57060345, NUT, LOCK, 143 57080251, FITTING, HYD, 254
57060352, SCREW, SET---CLEVIS, 44, 143 57080319, VALVE, 4---WAY, 195
57060360, HEAD, CYLINDER, 143 57082042, PLATE, FRONT, 70

57060378, PISTON, 143 57082109, NAMEPLATE---W/ TORQUELIMIT,

477
57060386, ROD, 143
57082125, NAMEPLATE---XL W/WATER INJ,
57063711, HOUSING, BLOWER, 402 477
57063877, ELEMENT, RETENTION, 402 57082133, NAMEPLATE---ENG. FUNCTIONS,
477
57064065, VANE HOLD DOWN SPRING, 300

INDEX
57082331, BURNOUT, 458
57064776, ADAPTER, 266
57082349, BURNOUT, 458
57065021, BRACKET, 224
57082455, FILTER & REGULATOR, 402
57065427, ACTUATOR, 441
57082463, ELEMENT, FILTER, 402
57065435, BRACKET, ACTUATOR, 441
57082497, BAR, ROUND, 59
57067555, PIN, 182
57082554, STANDPIPE, 136
57067563, CLIP, 182
57082786, PLATFORM, CAB, 59
57067571, SCREW, SET, 182
57082984, BRACKET, 136
57068215, RING, RETAINING, 210 57082992, BRACKET, 136
57070534, KIT, SLVE SEL, 420 57083008, HOSE TRAY, 136
57070542, KIT, VALVE, 420 57083016, HOSE TRAY, 136
57070559, KIT, PISTON, 420 57083032, MOUNT, 136
57070732, FILTER REG., 434 57083057, PIPE ASSY, 136
57070757, INJECTOR, SL1/2 BANK, 432 57083065, PIPE ASSY, 136
57070773, INJECTOR, SL1/4 BANK, 432 57083073, PIPE ASSY, 136
57070781, INJECTOR, SL1/5 BANK, 432 57083149, GUSSET, 136
57070849, CAP, COVER, 432 57083156, CLAMP ASSY, 3/4” PIPE, 136
57071383, BRACKET, 432 57083172, GUSSET, 136
57071409, BRACKET, 432 57083180, GUSSET, 136
57071417, BRACKET, 432 57083198, BAR, FLAT, 136
57072423, ADAPTER, 363 57083206, BAR, FLAT, 136, 168
57073637, TERMINAL, 386 57083479, BUSHING, ROD CHUCK---STEEL,
167
57073645, HOLDER, END, 386
57083552, CLAMP, 137
57075426, STRAP, 413
57083883, MANIFOLD, HYD, 432
57076267, BAR, FLAT, 176
57083966, CAP, BEARING, 6
57076507, HOSE, SUCTION---8 X 8’---4, 399
57083974, BLOCK, BEARING, 4
57077562, GUARD, COMPRESSOR, 251
57084055, BREAKER
57078008, PANEL, 70 15---AMP CIRCUIT, 76
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xxxix
 Serial Number: 4133
FAMILY,DM50

Index

CIRCUIT---15 AMP, 109 57096836, BLOWER ASSY., 68

57084287, FITTING, 206 57096844, WHEEL, C.W., 68, 116
57084311, HYD TANK ASY, 196 57096893, DOOR, FRONT, 65
57085128, STEM, HOSE, 268 57096950, MOUNT, SEAT, 65
57085573, STANDPIPE, 136 57096968, ARM ASSY, SEAT, 65
57085581, STANDPIPE, 136 57097081, HOSE ASSY, 259
57085599, STANDPIPE, 136 57097107, HOSE ASSY, 259
57085607, CLAMP, STANDPIPE, 136 57097115, HOSE ASSY, 259

57086381, LEVER, INPUT, 95 57097131, PIPE, 2NPT, 137

57086431, NAMEPLATE---HP W/WATER INJ, 57097263, GUSSET, 136

477 57097461, BARRIER, 65
57090953, BAR, SLIDING, 42 57097479, DOOR, A/C FLT, 65
INDEX

57092686, GAUGE ASSY, 74 57097487, PANEL, A/C FR, 108

57092694, GAUGE ASSY, 74 57097750, HOSE ASSY, 137
57092702, GAUGE ASSY, 74 57097891, HOSE ASSY, 192
57092728, CLAMP ASSY, 1---1/4 PIPE, 136 57097909, HOSE ASSY, 399
57093080, MARKER, WIRE, 383 57097917, ANGLE, SUPPORT, CONDENSER,
108
57093155, GAUGE, TEMP, 76
57097925, BAR, FLAT, 108
57093197, BAR, ROUND, 138
57097933, ANGLE, 108
57093478, DECAL, MACHINE---DM50E, 461
57097941, BRACKET, 109
57093619, LEVER, 95 57097974, NAMEPLATE, JIB HOIST, 195
57093775, PLUG, MINI, 306 57098022, GROMMET, RUBBER, 108
57094526, PLUG, VENT, 306 57098147, FAN, 6---BLADE, 351
57094831, NAMEPLATE---W/O TORQUELIMT, 57099061, HOSE ASSY, 259
477
57100075, LEVEL, 74
57094849, NAMEPLATE---HP W/O WATER, 477
57100091, BLOCK, VALVE---BUTTERFLY, 260
57094856, NAMEPLATE---XL W/O WATER, 477
57100117, CHAIN, MACH., 260
57095069, HOSE ASSY, 424
57100125, BAR, SQ., 261
57095515, CLAMP, DRIER AIR COND., 108
57100182, HOSE ASSY, 137
57095895, DECAL, MACHINE---DM50E, 461
57100208, HOSE ASSY, 322
57095945, COVER, 12 57100232, HOSE ASSY, 120
57095952, COVER, 12 57100281, HOSE ASSY, 192, 363
57095960, PANEL, 12 57100935, HOSE ASSY, 120
57095986, GUARD, HOSE, 12 57100943, HOSE ASSY, 120
57095994, GUARD, HOSE, 12 57101636, ELEMENT, OIL SEPARATOR, 268
57096000, PANEL, 12 57101941, COOLER, OIL---SAE O RINGPRT, 229
57096232, VALVE, MAIN, 95 57102097, ADAPTER, FLANGE, 362
57096398, MAIN VLV ASY, 92 57102279, BRACKET, 206
57096521, ADAPTER, 95 57102311, CARTRIDGE, 143, 190
57096794, STEP, CAB, 59 57102329, COIL S/A, 143, 190
Index xl WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

57104895, COVER, NUT, 298 57119968, MOUNT, HOIST, 195

57104929, NUT, JAM, 298 57120271, ARM, JIB HOIST---FIXED, 195
57104937, NUT, JAM, 298 57120339, PIN, JIB ARM, 195
57106429, VALVE, DIVERTER, 366 57120347, SPACER, 196
57106460, VALVE, 4---WAY, 368 57120354, BRACKET, VALVE---JIBCONTRL, 196
57106965, SUBPLATE, 368 57120677, STRAP, REAR, 413
57107450, HOSE ASSY, 441 57123283, CAM STROKER ASSY, 296
57130577, HOLDER, FUSE, 444
57107906, O---RING, 368
57132250, BOSS, O---RING, 312
57107914, KIT, SEAL, 368
57132268, BOSS, O---RING, 312
57112963, GAUGE, PRESSURE, 402
57134942, STRAP, DUST CURTAIN, 413
57113029, COVER, TOP---COOLING PKG, 221
57135253, HOSE, RADIATOR, 224
57113110, HANDRAIL, REAR---CURBSIDE, 10

INDEX
57136897, FITTING, HYD, 196
57113128, HANDRAIL---REAR D.C. SIDE, 10
57137036, TUBE---CROSS PORT CONNECT.,
57113144, BASEPLATE---3/8X4X4FLATBAR, 10 432
57113177, BATTERY, 12V---8DW/ELECTROL, 57137382, GUIDE, SLIDING SPROCKET, 129
218
57137416, PLATE, LOCK, 130
57113367, VALVE, BY PASS, 316 57137606, RELAY, 384
57113714, TANK, WATER---100 GAL HORIZ, 57137614, SCREW TERMINAL SOCKET, 384
417
57137622, SPRING, HOLD DOWN, 384
57115503, KNOB, TRANS. SHFTCONTROL, 330
57137986, HOSE, AIR---U48 BULK, 266
57115727, BACK UP RING, 48, 49
57138141, SUPPORT, 167
57115750, ROD PACKING, 48
57138166, JUNCTION BOX ASSY, 8 X 6, 383
57115768, ROD WIPER, 48
57138216, HARNESS, WIRE, 383
57116519, BUSHING, MODIFIED, 402 57138232, HARNESS, WIRE, 383
57116758, ADAPTER, GENERIC JACK---LONG, 57138240, HARNESS, WIRE, 383
354
57138760, DUST SHIELD, 129
57116766, ADAPTER, GENERIC JACK---SHRT,
354 57138893, HOSE ASSY, 137
57117244, HOSE ASSY, 100 57138950, HOOK, SWIVEL---2 TON, 195
57117491, ELBOW, LONG---JIC/ORING---90, 254 57138968, KIT, LATCH, 195

57117764, MOTOR, HYDRAULIC, 150 57139131, MOUNT, FLEX---BOLTSANDWICH,

384
57117772, BEARING, MOTOR SHAFT, 157
57139313, FRONT DECKING, 8
57117780, SEAL, SHAFT, 157 57139727, SHIELD, A/C---UPPER, 229
57119018, TUBING, MTG. HANDRAILS, 10 57139982, BRACKET, MOUNTING---AMOT, 254
57119604, WINDOW---DM45/50, 65 57140048, KIT, FIRE SUPPRESSION, 441
57119620, WINDOW---DM45/50, 65 57140188, HOSE ASSY, 326
57119638, WINDOW---DM45/50, 65 57140329, DECAL, WARNING---FALL PWRHD,
57119646, WINDOW---DM45/50, 65 471

57119653, WINDOW---DM45/50, 65 57140337, DECAL, WARNING---ROTATINGPT,

471
57119661, WINDOW---DM45/50, 65
57140345, DECALWARNING---ROTAT.PARTS,
57119810, BAR, ROUND, 80 471
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xli
 Serial Number: 4133
FAMILY,DM50

Index

57140352, DECAL, WARNING---HIGH PRESS, 57147092, ANGLE, 144

471
57147100, PLATE, 144
57140360, DECAL, WARNING---FALLDERRIC, 57147118, BAR, FLAT, 144
471
57147282, LAMP, FLOOD---70W HALOGEN, 389
57140378, DECAL, WARNING---FALL DRLPI,
471, 472 57147845, LOUVER & BEZEL ASSY, 118
57140386, DECAL, WARNING---FALLCAROUS, 57147852, DECAL, A/C SWITCH, 118
471 57147860, DECAL, BLOWER, 118
57140394, DECALWARNING---COMBUST.GAS, 57147878, PANEL, FRONT A/C, 118
471
57148090, SHAFT, PIPE ASSY, 167
57140402, DECAL, WARNING---HOT FLUID,
471 57149353, HOSE ASSY., 307
57140410, DECAL, WARNING---POWERHEAD, 57150278, CAM ASSEMBLY, 291
471 57150450, ASSEMBLY, RADIATOR, 229
INDEX

57140428, DECAL, WARNING---HIGHPRESS, 57150617, CHECK VALVE, 300

471
57151144, COVER, 302
57140444, DECAL, ENG.FAILURECOOLSY, 471
57153090, KIT---SHIM, 296
57140469, DECAL, WARNING---ROT.BLADE, 57153108, SHEAR SEAL, 298, 302
351, 471
57153793, INPUT SHAFT, 285
57140477, DECAL, CAUTION---EXCESSOIL,
471 57154692, TUBING, ROUND, 167
57141053, BRAKE LINING---ROD CHANGER, 57155376, MOTOR, HYDRAULIC, 351
168 57156465, DECAL, NOTICE---HYD.FAILURE,
57141061, BRAKE BAND, ROD CHANGER, 168 471, 472
57141079, BRAKE, DISC, 168 57156945, RADIATOR---LARGE MODINE, 229
57141715, PIN, TOWER LOCKING, 143 57157653, RING, WEAR, 48
57141871, HOLDER ASSY, 167 57157885, HOUSING, 4X6 LIGHT, 389

57141913, MOUNT, ROD CHANGER CYL, 167, 57157893, LAMP, TRAP---70W HALOGEN, 389
168 57158958, HOSE ASSY, 95
57143505, COVER, BATTERY, 218 57159113, GEAR, INTERMEDIATE, 150
57143778, GUIDE, FINISHEDPOWERHEAD, 57159121, SPACER, INTERMEDIATEGEAR,
151 150
57144032, BASE MTG, WTR INJECTION, 417 57159139, KEY, INTERMEDIATE SHAFT, 150
57144156, HOSE---DRAIN, 113, 116 57159212, TANK, OIL SEPARATOR, 268
57144305, COUPLING, CHAIN, 417 57159691, SPOOL, SECTION, 336
57145468, PIN, TIEBAR--- 0---30 DEG, 206 57160053, VALVE, BARE, 9---SPOOL, 334
57146037, DIGITAL DISPLAY, 446 57162646, HOSE ASSY, 254
57146045, ENCODER, OPTICAL SHAFT, 446 57163453, U---CUP, 178
57146060, HARDWARE, ENCODER MTG., 446 57163529, RING, BACK UP, 178

57146086, CABLE, 8 FT. POWER, 446 57164592, RETAINER, SEAL, 157

57146094, CABLE, AIR SWITCH---10 FT, 446 57165177, GUSSET, 167

57146102, MANUAL, OPERATORSSERVICE, 57165185, BLOCK, SUPPORT, 167

446 57165946, PLATE, 168
57146474, LINK, SLING, 196 57165953, PLATE, 168
Index xlii WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

57166795, PUMP/TIMER, LINCOLNCENTRL, 57181372, PLATE, PORT, 157

432
57181448, CORE, RADIATOR, 234
57167132, DISCONNECT, 306, 362
57182883, VALVE BLOCK, 49
57167934, FITTING, L90---120FSX12SAE, 129 57183329, CAP, SWIVEL, 151
57168387, HOSE ASSY, 363 57183584, LOCKNUT, 132
57168544, ROD, 182 57183592, BACK---UP RING, 48
57168551, TUBE ASSY., 182 57183600, BACK---UP RING, 48, 49
57168916, VARNISH, INSULATING, 384 57183618
57170110, PINION, INPUT, 150 PISTON SPACER, 49
SPACER, PISTON, 44
57170821, VALVE, TEMPERATURE BYPASS,
254 57183832, HOSE ASSY, 308, 362
57170839, ELEMENT, 254 57184103, STRAP, CURTAIN---TWRBOTTOM,
413

INDEX
57170896, SUPPORT, COMPRESSOR, 251
57184483, DUST CURTAIN, FRONT CAB, 413
57171159, ENGINE MOUNT REAR, 215
57184491, DUST CURT. FRNT DUSTSIDE, 413
57171910, BEARING, 285
57185217, PRESSURE PLATE, 291
57171928, SEAL, OIL, 285
57185464, PLATE, FILTER MOUNTING, 215
57172082, KNOB & HANDLE ASM, 195
57185498, MOUNT, ENG, REAR W/BKT, 215
57172736, MOUNT, FRONT ENGINE, 215 57187585, OIL COOLER(LOW PROFILE), 229
57173254, PLATE, BOTTOM MOUNT, 402 57188112, PIN, END YOKE, 16
57173262, PLATE, TOP MOUNT, 402 57191017, SHAFT, INTERMEDIATE, 150
57173270, PLATE, SIDE MOUNT, 402 57191025, CAP, BEARING, 150
57173692, ADAPTERENGINE/DRIVESHAFT, 57191033, PLATE, END, 152
282
57191082, INDICATOR, DRILLING EFF., 444
57173957, RESERVOIR, HYDRAULIC, 306
57191462, CABLE, 60 FT. ENCODER, 446
57173965, REAR PLATE, 310
57191991, END CAP, 291
57173973, FRONT SIDE PLATE, 310
57192007, HOUSING, 291
57173981, SUCTION MANIFOLD, 310
57192015, MOUNTING CAP, 291
57173999, PLATE, BOTTOM, 310
57192023, CAPSCREW, 291
57174138, ROD CHANGER, 164
57192080, CAM RING, 291
57175804, EQUALIZER, 20A. BATTERY, 448 57192098, VANE, 291
57176737, SWIVELS, 330 57192106, VANE PIN, 291
57179277, BOSS, SAE O---RING 9/16---18, 312 57192122, P1 ROTOR ASSY., 291
57180168, PIN, CENTER, 16 57192130, BACK UP RING, 291
57180184, BUSHING, CENTER, 16 57192148, SQUARE SECTION GASKET, 291
57181026, FRAME, DUST CURTAIN, 413 57192163, P2 ROTOR ASSY., 291
57181034, EXTENSION, TOWER BOTTOM, 413 57192197, O---RING, 291
57181059, ROD---TUBE, 44, 49 57192213, SHAFT, SPLINED #3, 291
57181232, ROD TUBE, 44, 49 57192619, PLATE VAL. MOUNT, 70
57181240, LOCKNUT, 44, 49 57194987, ARM, ADJUSTABLE, 206
57181307, HOLD DOWN---VANE, 300 57196677, DIODE, 3A, 600V, 384
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xliii
 Serial Number: 4133
FAMILY,DM50

Index

57198111, ADAPTER, INPUT SHAFT, 285 57225302, VALVE, OVERRUNNING LOAD, 207
57198285, ANGLE, 207 57227787, CROSS KIT, 282
57199093, CYLINDER, HYDRAULIC, 167 57228074, PIPE, WATER INLET, 224
57201741, BRACE COOLER REAR, 229 57228348, TUBE WATER OUTLET, 224
57202467, PLATE, UPPER REAR, 229 57229031, HOSE, RADIATOR, 224
57202475, BRACKET, REAR LOWER, 229 57229049, HOSE RADIATOR, 224
57202483, TUBE REAR LOWER, 232 57229056, BAR W/HOLES, 224

57204232, TUBE, REAR UPPER, 232 57229783, FLANGE EXHAUST, 221

57229791, ELBOW, 45 DEG. EXHAUST, 221
57205007, VALVE, COUNTERBALANCE, 44, 49
57229924, BAR, TAP, 206
57206831, PLATE, CAM, 206
57229965, HOSE ASSY, 354
57207078, O---RING, 48, 49
57232571, VALVE, 206
57208746, SPACER, 46
INDEX

57232589, SUBPLATE, 207

57208969, DECKING, MIDDLE---COOLER, 8
57233124, NAMEPLATE, DEPTHINDICATOR,
57209066, BLOCK, BEARING, 167 477
57209090, SHAFT, CLEVIS ASSY., 167 57233132, NAMEPLATE, O’ INDICATOR, 477
57209884, SWITCH, PRESSURE, 436 57233140, NAMEPLATE, 5’ INDICATOR, 477
57212011, ELEMENT, MAINTENANCE, 215 57233157, NAMEPLATE, 10’ INDICATOR, 477
57212409, GASKET---SEPR ELEMENT, 268 57233165, NAMEPLATE, 15’ INDICATOR, 477
57212813, SENSOR, MAGNETICCAT3406TA, 57233173, NAMEPLATE, 20’ INDICATOR, 477
215 57233181, NAMEPLATE, 25’ INDICATOR, 477
57213555, BREAKOUTBLOCK, RODCHANG- 57233199, NAMEPLATE, 30’ INDICATOR, 477
ER, 164
57235491, BRACKET, FILTER MTG, 238
57213563, BREAKOUT PLATERODCHANGER,
164 57235574, SUPPRT A.C., 238
57236226, RADIATOR TUBE SUPPORT, 224
57213571, DECKING RIGHT REAR, 8
57237380, FITTING, MALE---FEMALE NPT, 224
57213589, DECKING LEFT REAR, 8
57238602, BOLT, FLY WHEEL, 215
57213597, BREAKOUT KIT, RODCHANGER,
164 57238610, BOLT, FLY WHEEL, 215
57220279, PISTON, 210 57238628, WASHER, FLAT HARDFACED, 215
57220295, LOCKNUT, 210 57239436, ASSY TOOL & INSTRUCT KIT, 49

57220303, ROD CLEVIS, 143 57239444, INSTL INSTR---SEAL, 48, 49

57239469, TOOL, 5” BORE SIZING, 49
57220717, ENGINE, CAT 3412DIT---575, 215
57239717, SCREW, SET, 298
57221475, ORIFICE, .125, 206
57239725, NUT, ACORN, 298
57224081, O---RING, 170, 178
57240566, SPRING, 298
57224099, RING, BACK---UP, 170
57240574, PLUG, 298
57224115, U---CUP, LOADED, 170
57240749, SCREW, MOTOR, 300
57224123, WIPER, 170
57240756, SCREW, SET, 300, 302
57224156, PLUG, PORT, 44, 49
57240764, PLATE, MOTOR, 300
57224347, MOUNT, FIRE PROTECTION, 441
57240806, SHAFT, 157
57224628, SUB 57488942---CYLINDER, 140 57240814
57224669, CYLINDER, HYDRAULIC, 46 SEAL KIT, VALVE, 44
Index xliv WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

SEAL KIT---VALVE, 49 57245292, PLUG, PORT, 132

57240822, LATCH---DOOR, 12 57245318, HEAD, 5 X 4, 49
57240921, STRIKER, DOOR LATCH, 65 57245433, STEPSEAL, 132
57241721, CLUTCH, 198 57245441, SLYDRING, 132
57241739, SPRING, 198 57245458, STEPSEAL, 132
57241747, PRESSURE PLATE---CLUTCH, 198 57245466, EXCLUDER, 132
57242109, TANK---RAD. TOP, 229 57245474, SPACER, 132
57242117, TANK---RAD. BOTTOM, 229 57245516, BACK---UP, 48
57242547, SEAL KIT, 170 57245532, STEPSEAL, 44, 48, 49
57242554, LOCKNUT, 170 57245540, SLYDRING, 44, 48, 49
57242562, O---RING, 170 57245557, STEPSEAL, 48, 49
57242570, RING, CAST IRON, 170 57245565, EXCLUDER, 48, 49

INDEX
57242588, DISC 25, 170 57245573, TUBE ASSY, 44, 49
57242596, HEADCAP, 170 57245581, HEAD, 4---1/4 X 3---1/4, 132
57242604, HEAD, 170 57245631, KIT, CAB HEATER, RETROFIT, 68
57242612, PISTON, 170 57247181, CLAMP, STANDPIPE, 138
57242620, TUBE ASSY, 170 57247264, RADIATOR CORE KIT, 229
57242638, ROD ASSY, 170 57247298, BAR, BOLTING, 234
57243065, NAMEPLATE, LOWER---HPDM45/5, 57247322, BAR, BOLTING, 234
477 57247397, O---RING, 132
57243719, SHIM, POWERHEAD---SPURGEAR, 57247405, BACK UP, 132
151
57247413, SLYDRING, 132
57243750, PLATE TOP, 70
57248171, SEAL KIT, 48
57243768, PANEL CONTROL, 65
57248189, SEAL KIT, FIELD SERVICE, 48
57244113, CAP, REPLACEMENT, 167
57249088, HOSE ASSY, 432
57244352, VALVE, PUMP RELIEF, 363
57249096, HOSE ASSY, 399
57244832, O---RING, 44, 49
57250250, MOTOR, HYDRAULIC, 417
57244907
57250276, KIT, SEAL, 422
SCREW, SET---1/4---28 X 2, 132
SET SCREW, 1/4---28UNF---2, 49 57269227, KIT, SEAL, 143
57244915 57273138, PLATE, FILTER MTG, 215
PLUG, PORT, 44 57273765, GUARD, DRIVESHAFT, 282
PORT PLUG, 49
57276768, SWITCH, SPEED, CAT, 384
57244972, DRILL PLUG, 44, 49
57276776, TACHOMETER, CAT, 76
57244980, PLATE, MTG, 362
57276784, PANEL ASSY, ETR---CAT, 74
57245086, O---RING, 132
57276891, THERMOSTAT, EVAPORATOR, 116
57245110, INSTRUCTIONS, KIT, 48
57276909, HEATER, ASSY---LESS CABLE, 65
57245177
AQ SEAL ASSY, 48, 49 57277808, CLAMP, T---BOLT, 4.50, 224
SEAL ASSY, 44 57279135, SHIELD, AIR CLEANER, 229
57245185, SLYDRING, 44, 48, 49 57283236, CAB HALF --- DM45/50, 65
57245201, PISTON, CYLINDER, 49 57284309, DUST COLLECTOR---IR 3600, 399
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xlv
 Serial Number: 4133
FAMILY,DM50

Index

57284630, LOWER HSG SECTION, 402 57301038, SWITCH, ADJ. AIR, 446
57284648, UPPER HSG SECTION, 402 57301202, HANDLE---D/C DOOR, 402
57284655, BLOWER WHEEL 20, 402 57301780, ELEMENT, FILTER, 72
57284663, BLOWER HSG, 402 57301814, CUSHION, BOTTOM, 65
57284671, TIMER, DC ELECTRIC, 402 57301822, CUSHION, SEAT BACK, 65
57284689, MANIFOLD, AIR IMPULSE, 402 57305377, COIL, SOLENOID---24VDC, 206
57284697, ELEMENT, FILTER, 402 57305500, CHANNEL---48 LG., 65
57284705, VALVE, FLOW CONTROL, 402 57305948, PIN---PUMP, 298
57290041, DECAL, A/C HEATER FILTER, 59, 57306680, MANIFOLD---SUCTION, 310
109 57307720, GASKET, SQ.SECTION, 291
57290264, DOOR, FILTER ACCESS, 402 57308009, SEAL, BRAKE, 199
57291288, WASHER, LOCK---TONGUED, 150 57309783, YOKE, OSCILLATION, 16
INDEX

57291296, WASHER, LOCK, TONGUED, 150 57309791, BUSHING, YOKE END, 16

57291304, NUT, ADJUSTING, 150 57309809, MOUNT, YOKE END, 16
57294829, FILTER, FUEL SECONDARY, 215 57310831, DECAL, WARNING---DON’TALTER,
471, 472
57296394, FITTING, L90---160FSX12SAE, 130
57311086, DECAL, DANGER---HAZ. VOLT., 471,
57299414, PAGE, FALLING DERRICK, 474 472
57299422, PAGE, EXCESSIVE HYD. OIL, 474 57311151, MANUAL, SAFETY---DM45/50/L, 471,
57299430, PAGE, ROTATING PARTS, 474 472
57299448, PAGE, ROTATING PARTS, 474 57311169, PAGE, COVER, 474
57299455, PAGE ROTATING BLADE, 474 57311649, PAGE, ORDER INFORMATION, 474
57299463, PAGE, PRESSURIZED FLUID, 474 57311656, PAGE, LABEL REFERENCE, 474

57299489, PAGE, HIGH PRESSURE, 474 57311912, HOSE ASSY, 354

57299497, PLATE, COMBUSTIBLE GAS, 474 57311920, HOSE ASSY, 399

57311979, HARNESS, WIRE, ENG. CAT, 215
57299505, PAGE, FALL OR CRUSHHAZARD,
474 57311987, WIRING, ENGINE, CAT, 215
57299513, PAGE, HIGH PRESSURE, 474 57312001, PRE---CLEANER/FILTER KIT, 65
57299521, PAGE, FALLING POWER HEAD, 474 57312563, VALVE, SOLENOID---3WAY/2POS,
436
57299539, PAGE, FALLING RODCAROUSEL,
474 57314395, TUBE, AIR---ALUM.6X74, 238
57299547, PAGE, FALLING DRILL PIPE, 474 57315426, MOUNT, SHAFT TBG, OUTSIDE, 16
57299554, PAGE, COMBINED WARNING, 474 57315574, BLOCK, 109
57299562, PAGE, HAZARDOUS VOLTAGE, 474 57315780, CLAMP, FEED CYL---5 OD, 129
57299588, PAGE, HIGH PRESSURE, 474 57315798, SUPPORT, FEED CYL---5 OD, 129
57299596, PAGE, HIGH PRESSURE, 474 57316184, CONTROL, ENG, ETR, CAT, 74

57300212, DRIVE SHAFT ASSY, 296 57318040, DECAL, WARNING---NOCLIMBNG,

471, 472
57300220, SHAFT, MOTOR, 296
57318388, INTAKE, COMPRESSOR---7.50LG,
57300329, O---RING, 157 238
57300816, DISC SPRING, 157 57318834, PAGE, DON’T CLIMB, 474
57300824, THRUST WASHER, 157 57319154, GUARD, WELDMENT, 108
Index xlvi WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

57319162, PLATE, 108 57355018, SPROCKET, TRACK, 18

57319170, PLATE, 109 57355026, BOLT, 18
57319196, ANGLE, 109 57355075, WASHER---PLATED, 18, 20, 24
57319212, ADJUSTMENT ROD, 109 57356461, BOLT, 18
57323826, HOSE, AIR, 273 57356479, BOLT, 18
57324097, V---BELT, 108 57356503, FRONT IDLER GROUP, 18
57324105, CLUTCH, A/C, 108 57356511, BOLT, 30
57324154, PAGE, TABLE---DM 45/50/DML, 474 57356552, SEAL---LIP TYPE, 30
57325060, MOUNT, SHAFT TBG, INSIDE, 16 57356560, PISTON, 30
57326431, BAR, TOWER, PIPING MOUNT, 136 57356578, RING, 30
57326795, O---RING, 178 57356586, RING, 30
57326803, U---CUP, 178 57356594, O RING---SEAL, 30

INDEX
57328676, FITTING, TEST, 363 57356636, SUPPORT ASSY, 32
57330110, BAR, W/HOLES, 3/8X2X11, 389 57356644, SPRING, 32

57330284, HOSE ASSY, 354, 363 57356669, WASHER---HARD, 32

57335192, DECAL, WARNING---FANBLADES, 57356677, NUT, 32

471, 472 57356685, SUPPORT, 32
57335200, DECAL, NOTICE---DUST, 471, 472 57356693, STRIP, 32
57336067, PACKING, SWIVEL---30XV, 151 57356701, BOLT---SOCKETHEAD, 32
57336406, ELEMENT, KF3 FILTER S3, 466 57356735, PIN, 34
57337123, HOSE ASSY, 363 57356750, BEARING---FRAME IDLER, 34
57338329, PAGE, FAN BLADES, 474 57356768, PLUG---PIPE, 22, 34
57340333, KIT, ANSI 25 SPROCKET 96T, 444 57356776, BOLT, 20
57345126, HOSE ASSY, 362 57356800, BOLT, 20
57345332, HOSE ASSY, 363 57356834, COVER---CARRIER ROLLER, 22
57345878, DECAL, NOTICE, 471, 472 57356859, RETAINER, 22
57346843, VALVE, 4---WAY SELECTOR, 100 57356867, WASHER---THRUST, 22
57346850, KIT, VALVE CONVERSION, 100 57356875, BOLT---SOCKETHEAD, 22
57347171, NAMEPLATE, LOWER---XLDM45/5, 57356974, BOLT---TRACK, 36
477 57356990, NUT---TRACK, 36
57347379, CAP, SPINDLE---SPUR HEAD, 151 57357006, WASHER, 38
57348146, COUPLING SAE HALF, 312 57357014, BUSHING---TRACK, 38
57350449, FILTER MNT BKT, 310 57357022, PIN---TRACK, 38
57350944, TUBE, DEAERATION, 224 57357030, LINK---LH TRACK, 38
57351728, CLEVIS, CYLINDER, 182 57357048, PIN---TRACK, 38
57351769, TUBE, DEAERATION, 224 57357055, BUSHING---MASTER, 38
57352304, MTG.PLATE---RV, HYD. TANK, 310 57357063, SPACER, 38
57352825, VALVE, RELIEF, 308 57357071, LINK---RH TRACK, 38
57354946, SPROCKET GROUP, 18 57357097, WASHER, 18
57354961, FRONT IDLER GROUP, 18 57357311, BRACKET WELDMENT, 108
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xlvii
 Serial Number: 4133
FAMILY,DM50

Index

57357618, SHIM, BLOCK---BEARING, 6 57368524, DRIVE SHAFT, 282

57357683, BOLT, 24 57369969, TUBE, RECT., 143
57357691, NUT, 24 57371163, SPACER, SWIVEL PACKING, 151
57358830, CONDUIT, 3/8 NYLON, 65, 434 57371759, PRE---CLEANER, 72
57358855, PUSHBUTTON, 2---POSITION, 76 57371775, DUCT ASSY, 72
57359036, CLEVIS, TOWERPINNING---DML, 57371791, REDUCER, 72
143 57371809, CLAMP, HOSE, 72
57359127, SUPPORT, TOWER PINNINGCYL, 57371817, STRAPS --- MTG, 72
143
57371825, GASKET --- MATERIAL, 72
57359135, PLATE, PINNING---ANGLDRILL, 144
57371833, COVER, PRE---CLEANER, 72
57360059, ROPE, WIRE---3/8 BULK, 195
57371841, BOWL, 72
57360448, SHEAVE WITH BUSHING, 129
57371858, SLEEVE, PRE---CLEANER, 72
INDEX

57362774, GASKET, RADIATOR, 234

57376618, TUBING, SHAFTOSCILLATION, 16
57364010, LED, LIGHT EMMITTING DIODE,
57376659, ROD ASSY, FEED CYLINDER, 132
76
57376667, TUBE ASSY, FEED CYLINDER, 132
57364341, COMPRESSOR, W/ORINGPORTS,
108 57376816, GUIDE BLOCK---LONG, R.H., 151
57364358, COIL, CONDENSER, 108 57376824, GUIDE BLOCK---SHORT, R.H., 151
57364366, DRIER, RECEIVER, 108 57377236, DECAL, NOTICE, 474
57364473, REFRIGERANT, R134A, 108 57377939, HOSE ASSY, 108
57366387, ALARM, BACKUP---12 TO36VDC, 57377947, HOSE ASSY, 108
384 57377954, HOSE ASSY, 108
57366395, ALARM KIT, BACKUP, 384 57379174, NAMEPLATE---12V DC POWER, 448
57367179, GEARBOX --- 4 HOLE, 282 57379984, SEAL KIT, VITON, 270
57367302, HOUSING --- GEARBOX, 285 57388076, UNDERCARRIAGE, 325L---L&S, 16
57367310, BOLT, ADAPTER, 285 57390668, DUST CURTAIN---REAR DCSIDE,
413
57367328, PLUG, PIPE, 285
57391021, DUST CURTAIN---R.CAB SIDE, 413
57367344, O---RING, 285
57391047, VALVE, MIN.PRESSURE, 273
57367369, ELBOW, 90 DEGREE, 285
57391559, CONNECTOR, MALE, 363
57367377, BUSHING, REDUCER, 285
57392912, HOSE ASSY, 363
57367385, BEARING, 285
57394603, RELAY, DPDT 24V COIL, 444
57367583, GEAR, PINION, 285
57404147, FLANGE HALF, SIZE 16---CD62, 372
57367906, CASTING, MACHINED---HOUSING,
154 57404295, DECAL & MANUALSET---DM45/5,
471
57367914, HOUSING, W/BUSH---ROTARYHD,
150 57405185, FLANGE HALF, SIZE 20---CD62, 98

57367922, BUSHINGHOUSING---ROTARYHEA, 57410466, HOSE ASSY, 259

154 57411092, RETAINER, CABLE, 130
57367930, PIN, ANCHOR---ROTARY HEAD, 151 57411381, GUARDS, CABLE, 130
57368052, ADAPTER, MOTOR, 150 57411621, CAB, SWG’DR, DM45HPCONSOLE,
59
57368243, SHIM, PINANCHOR---ROT.HEAD,
152 57412603, TUBING---FLEXIBLE EXH.8, 221
Index xlviii WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

57412611, ELBOW---EXHAUST 8 90 DEG, 221 57429573, HOSE ASSY, 432

57413106, BLOCK EXP. VALVE---A/C, 116 57429920, GAUGE ASSY, 400 PSI AIR, 74
57413114, EVAPORATOR COIL---A/C, 116 57431983, MANIFOLD, RETURN SAEPORTS,
306
57413130, HOSE ASSY---A/C, LIQUID, 116
57437154, HOSE ASSY, 326
57413254, HOSE ASSY, A/C---SUCTION, 116
57438574, HOSE ASSY, 327
57413486, HOSE ASSY, 6X312, R134A, 108
57439267, CLAMP, CONSTANT TORQUE, 238
57413551, HOSE ASSY, 357
57440562, CLAMP, CONSTANT TORQUE, 238
57414179, HOSE ASSY, 363
57440646, VALVE, SHUTOFF, DISCHGPORT,
57415044, MOTOR, HYD. TRACK/DR, 18 108
57415929, FINAL DRIVE GROUP---U/C, 18 57440653, VALVE, SHUTOFF, SUCTIONPRT,
57416943, RETAINER, 157 108

57416950, O RING, 157 57440661, O---RING, SHUTOFF VALVE, 108

INDEX
57440943, EVAPORATOR, FILTER KIT, 116
57417156, VALVE, BALL, 68
57442477, REGULATOR, PRESSURE, 273
57417339, SERVO---CONT.COVER GASKET,
298, 302 57445694, BRACKET, LIMIT SWITCH, 206
57419012, HOUSING, BRAKE, 199 57446437, HOSE, DROPOUT, 402
57419020, COVER, BRAKE HOUSING, 198 57448086, EVAPORATOR W/THERMOSTAT,
113
57419939, CAM RING, 291
57451320, INSULATION, PIPE---3/4, 113
57420085, VENT ASSEMBLY, 436
57451338, INSULATION, STRIP7.75WX40, 113
57420093, PLATE, FOLLOWER, 436
57451353, KIT, AIR COND.---SGM, 108
57420101, COVER, DRUM & TIE DN ASSY, 436
57451361, ELBOW, 1/2 BARB---LASCO, 113
57420127, KIT, PUMP REPAIR, 436
57451379, TEE, 1/2 BARB---LASCO, 113
57420135, KIT, PUMP TUBE REPAIR, 436
57451387, TUBE, COPPER---1/2DIAX14 LG, 113
57420846, BRACKET, FILTER, 307
57451932, DRAWING, KIT AIR COND., 113
57421240, HOSE ASSY, 363
57456790, BOLT, 20
57421273, HOSE ASSY, 363
57457293, KIT---DISC(BRAKE), 26
57424137, CABLE ASSEMBLY, PULLDOWN, 57457301, KIT---SEAL(BRAKE), 26
129
57457566, CARRIER ROLLER GROUP, 20
57425209, SUB 57492563 CYLINDER, 129
57457590, SHAFT ASSY, 22
57425415, ALTERATION INSTRUCTION, 282
57457608, ROLLER & BEARING ASSY, 22
57425480, WINDOW, 65
57457772, BOLT, 18
57425498, WINDOW, 65
57479784, TOWER WELD, STD BOTTOM---25,
57425522, RELEASE, INSIDE---SWINGDOOR, 129
65
57480386, SERVO, PUMP---INPUT, MANUAL,
57425704, SWING DOOR, 65 296
57429250, SEAL, 132 57486565, VALVE---PRESS RELIEF, 326
57429276, BACK UP, 132 57486987, HANDLE, RECESSED, OUTSIDE, 65
57429292, SEAL KIT, 132 57488868, CYLINDER HYDRAULIC, 42
57429318, PISTON, 132 57497190, HEAD ASSY, FILLER---2.5NPT, 246
57429326, TIE BAR, O---30 DEGREES, 206 57497687, NAMEPLATE, MODEL I.D., 477
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index xlix
 Serial Number: 4133
FAMILY,DM50

Index

57497927, DECAL, CORP. NAMEPLATE, 461 57552465, PLANET GEAR, 26

57498719, CORE, COOLER--- COC ONLY, 229 57552473, PLANET BEARING, 26
57499634, COOLER CORE --- HOC ONLY, 229 57552481, RING, SNAP, 26
57503682, LINK, MAIN PUMP CONTROLS, 215, 57552499, SHAFT, SUN GEAR, 26
330 57552507, RING, SNAP, 26
57510133, DRAWING, ANGLE PKG, 0---30, 207 57552515, NUT, SHAFT, 26
57510927, SEAL KIT---CYLINDER, 44 57552523, BEARING, TAP ROLLER, 26
57514804, TIMER BOX, BARE, 402 57552531, SEAL, FACE, 26
57514846, KIT---REPAIR, 273 57552549, RING, O, 26
57514903, SPRING, RETAINER, 157 57552556, BOLT, HEX HEAD, 26
57515314, GAUGE, AMMETER, 76 57552564, BOLT, SOCKET HEAD, 26
57516601, FRAME ASSY, RH, 18 57552572, PISTON, 26
INDEX

57516700, GUAGE 0---300 PSI, 434 57552580, PLATE, BACK UP, 26

57518003, BRACKET, MTG---CENTRO LUBE, 57552598, RING, SNAP, 26
434
57552622, PLUG, CAP, 26
57520850, BACK---UP, 44
57552630, PLUG, EXPANDING, 26
57520868, O---RING, 44 57552648, GEAR, RING, 26
57520876, BACK---UP, 44 57552655, COVER, RING GEAR, 26
57520884, O---RING, 44 57552663, SHAFT, SUN GEAR, 26
57520892, RING, INGRESSION, 44 57552671, CARRIER, PLANET, 26
57520900, O---RING, 44 57552689, PLANET GEAR, 26
57520918, BACK---UP, 44 57552697, PLANET BEARING, 26
57520926, SEAL, ROD, 44 57552705, RING, SNAP, 26
57520934, BACK---UP, 44 57552713, RING, SNAP, 26
57520942, RING, CONTAMINATION, 44 57552721, O---RING, 26
57520959, WIPER, 44 57552739, BOLT, HEX HEAD, 26
57520967, BLOCK, VALVE, 44 57552747, PLUG, SCREW, 26
57520975, HEAD, 44 57552754, RING, SEAL, 26, 27
57520983, PISTON, 44 57552762, GEAR, SUN, 26
57530446, CONTROLLER, SENTRYMONITOR, 57552770, CARRIER, PLANET, 27
436 57552788, PLANET GEAR, 27
57530453, BOARD, SENTRY PROCESSOR, 436 57552796, PLANET BEARING, 27
57530461, BOARD, SENTRY PWR SUPPLY, 436 57552804, RING, SNAP, 27
57530917, REGULATOR ASSY, UL---88, 259 57552812, COVER, 27
57552408, SPINDLE, 26 57552820, SLEEVE, LOCATING, 27
57552416, COUPLER, 26 57552838, SHAFT, INPUT, 27
57552424, CARRIER, PLANET, 26 57552846, SLEEVE, SHIFT, 27
57552432, PLATE, BACK---UP, 26 57552853, BOLT, SOCKET HEAD, 27
57552440, RING, SNAP, 26 57552861, WASHER, THRUST, 27
57552457, RING, LOCATING, 26 57552879, BOLT, HEX HEAD, 27
Index l WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

57552887, O---RING, 27 57563496, SHOE, TRACK, 36

57552895, PLUG, SCREW, 27 57574162, SILENCER, ALUMINIZED 8”, 221
57552903, BOLT, HEX HEAD, 27 57578023, HOUSING, LOWER SEAL, 150
57552911, BOLT, HEX HEAD, 27 57621310, DECAL, IR BUG, 461
57552929, ADAPTER, 27 57755225, PAGE, TABLE, DMLSP, 474
57552937, RING, SEAL, 27 58025800, FINAL DRIVE, 18
57552952, ADAPTER, 27 58025818, DRIVE GROUP, 18
57562977, ROLLER ARRANGEMENT, 18 58042730, HOSE ASSY, 137
57562985, SHAFT, TCK ROLLER, 22 58044561, HOSE HUMP, REDUCING, 238
57562993, COLLAR---RLR END, 22 58044744, BAND, MOUNTING, 238
57563009, SEAL GROUP, 22 58060179, CLAMP, CABLE, 195
57563017, RIM AS---CARR RLR, 22 58081662, HOSE ASSY, 433

INDEX
57563025, BEARING---CARR RLR, 22 58086141, CLAMP, HOSE, 232
57563033, BEARING---CARR RLR, 22 58121286, CHAIN, 418
57563041, ROLLER GROUP---SFLG, 20 58123399, COVER, 418
57563124, GUARD GROUP---TCK MOT, 18 58140328, HOSE ASSY, 433
57563132, COVER, 18 58144528, HOSE ASSY, 363
57563140, GUARD GROUP---TRK GDE, 18 58146267, HOSE ASSY, 224
57563157, GUARD ASSY, 24 58146622, HOSE ASSY, 78, 441
57563165, GUARD ASSY, 24 58147356, HOSE ASSY, 246
57563173, BOLT, 24 58148446, CHAIN, 261
57563181, PIPE, 24 58150103, CORD, 14/2, 434, 444
57563199, GUARD ASSEMBLY, 24 58153271, HUB, 418
57563207, GUARD ASSEMBLY, 24 58154337, HOSE ASSY, 207
57563272, FRAME ASSY---LH, 18 58160458, BRACKET, MOUNTING, 259
57563348, TRACK ADJUSTMENT GROUP, 18 58170465, HOSE ASSY, 433
57563355, PLATE ASSY, RH, WARNING, 30 58176207, BRACKET, LEVER, 348
57563363, PLATE ASSY, LH, WARNING, 30 58180076, WIRE, 10 AWG---PINK, 448
57563371, CYLINDER, 30 58183468, HOSE ASSY, 246
57563389, VALVE, FILL, 30 58209651, OIL, GEAR, 152
57563397, SPRING GROUP RECOIL, 18 58217902, HOSE ASSY, 137, 326
57563405, ROD, 32 58229790, BOLT AND NUT, 454, 458
57563413, IDLER, FRONT, 18 58229915, SEAL, OIL, 150
57563421, IDLER & BEARING ASSY, 34 58231119, SEAL KIT, 182
57563439, IDLER ASSEMBLY, 34 58231812, ROPE, WIRE---3/8 X 59’, 195
57563447, BEARING---IDLER, 34 58231887, BOX, BATTERY, 218
57563454, SEAL GROUP---METAL FACE, 34 58232554, SCREW, 198
57563462, SHAFT---IDLER, 34 58232562, COVER, 198
57563470, TRACK GROUP, 18 58232588, SCREW, 198
57563488, TRACK LINK ASSY, 36 58232596, VALVE, RELIEF, 198
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index li
 Serial Number: 4133
FAMILY,DM50

Index

58232604, BUSHING, 198 59677831, BREATHER, 285

58232612, PLUG, 198 59713438, COUPLING, MIN, 327
58232620, SCREW, 198 59767483, FITTING, HYD.METRICSTRTHD,
364
58232638, PLUG, 198
59904268, BEARING --- PUMP DRIVE, 285
58232661, SEAL, 198
59956466, RELAY, SOLENOID---24VMARINE,
58232679, NUT, 198 384
58232687, SCREW, 198 85597904, FITTING, HYD, 432
58232695, WASHER, 199 85771715, CABLE, 18/2, 383
58232703, SHAFT, 199 88001599, PANEL, 386
58232711, DRUM, 199 92304435, SCREW, SET---M12 X 25MM, 251
58232737, BRACKET, 199 95000253, O’RING, 426
58232745, WASHER, 199 95000477, O---RING, 254
INDEX

58232752, NUT, 199 95002002, BUSHING, 246

58232760, WASHER, 199 95002564, PIN, ROLL, 6
58233719, NUT, LOCK, 182 95017984, O---RING, 104
58233727, O---RING, 184 95018081, O---RING, 336
58233735, RING, BACKUP, 184 95018271, O---RING, 167

58233743, PISTON, 182 95018651, O’RING, 426

58233784, O’RING, 184 95033700, PLUG, PIPE, 424

95048559, NIPPLE, 276
58233792, RING, RETAINING, 182
95065868, SCREW, SET---1/2---13 X 1/2, 282
58233800, HEAD, 182
95076808, NUT, HEX, 426
58233818, WIPER, 184
95077319, NUT, HEX, STOP, 129
58233826, RING BACKUP, 184
95079984, SCREW, CAP---5/16---18X1---1/4, 278
58233834, O’RING, 184
95086625, O---RING, 152
58234501, MOTOR, 24V, 68, 116
95086724, O---RING, 150
58234519, RESISTOR, 24V, 68
95087052, O---RING, 424
58235128, KIT, SPLIT FLANGE, 96
95094314, WASHER, FLAT, WIDE, 129
58235250, LIGHT, DOME, 65
95097689, O---RING, 298, 302
58235268, KNOB, CONTROL, 68, 118
95097929, O---RING, 152
58235615, SUPPORT, TWR, 4
95101457, PLUG PIPE, 42
58235698, BLOCK, BEARING, 6 95101705, PLUG, PIPE---HEXSOCKET, 3/8, 417
59302752, AIR CLEANER, 72 95103990, SCREW, CAP---1/4---20 X3---1/4, 196
59322677, WIPER, 178 95104394, SCREW, CAP, HEX, 129
59514976, PLUG, MAGNETIC, 285 95105136, SCREW, CAP---1---8 X 4, 6
59516096, SLEEVE, SPLINE, 285 95141511, ADAPTER, 95
59572917, ADAPTER, SAE B, 285 95157731, CAPSCREW, HEX HEAD, 129
59669713, FITTING, HYD, 100 95200663, BEARING, 285
59671081, HOUSING, 422 95201299, FITTING, 180
59671107, PLATE, SPACER, 422 95201547, FITTING, LUBE, 129
Index lii WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

95208971, FITTING, LUBE---90 DEG, 168 95279162, FITTING, HYD, 195

95209086, FITTING, HYD, 95, 432 95279238, FITTING HYD, 326
95209094, FITTING, HYD, 140, 144, 259, 362, 424 95279329, FITTING, HYD, 326
95209987, LOCKNUT, BRG, 150 95279378, FITTING, HYD, 196
95213427, WASHER, LOCK---5/8 EXT., 426 95279402, ELBOW, 90DEG MALE 37DGFL, 120
95214037, BEARING, 150 95279428, FITTING, HYD, 307
95214524, GASKET RING, 251 95279436, FITTING, HYD, 327
95219713, FITTING, HYD, 260, 432 95279451, FITTING, HYD, 259
95219721, FITTING, HYD, 259, 326, 399, 417, 432 95279493, FITTING, HYD, 143, 260, 417
95219739, FITTING, HYD, 327 95279501, FITTING, HYD, 399, 418
95219747, FITTING, HYD, 120, 215, 308, 399 95279519, FITTING, HYD, 432

95219754, FITTING, HYD, 307, 326 95279527, FITTING, HYD, 140

INDEX
95279535, FITTING, HYD, 246, 327, 432
95219762, FITTING, HYD, 326, 362
95279543, FITTING, HYD, 195, 246
95219770, FITTING, HYD, 306, 307
95279881, FITTING, HYD, 326
95219853, FITTING, HYD, 362, 418
95279923, TEE, 190, 362
95220844, CLAMP, HOSE, 224
95279956, TEE, 326
95221065, TEE, SERVICE, 260
95279998, FITTING, HYD, 370
95221107, FITTING, HYD, 273
95280095, FITTING, TEE---INT NPT, 326
95225116, GASKET RING, 266
95280152, ADAPTER, 45DEG---ORING/JIC, 307
95231031, FITTING, HYD, 140, 259
95280160, FITTING, HYD, 308, 326, 366
95239216, JOINT, WIRE, 448
95280186, FITTING, HYD, 307, 362
95239539, SUB 95077814 NUT, 109, 221
95280194, FITTING, HYD---90JIC/ORING, 362
95245049, CONDUIT, FLEX---1/2SEALTITE, 434
95282422, ADAPTER, 59, 259
95245221, CONNECTOR, STRAIGHT---1/2, 434
95286563, ADAPTER, 417, 432
95246062, PIN, ROLL---3/8 X 3---3/4, 129
95286902, FITTING, 326, 432
95249587, PLUG, PIPE---3/8 SQ HEAD, 151
95287629, FITTING, HYD, 238, 246, 432
95250692, DRAIN COCK, 282
95293403, FITTING, HYD, 190, 259, 363, 370, 444
95256723, CLAMP---1/2, 434 95301834, CLAMP, HOSE, 224, 389
95256749, CLAMP---3/4, 120, 383 95301859, CLAMP, HOSE, 109, 433
95257341, CAP, JIC---6, 144, 190 95302121, FITTING, HYD, 246
95263380, FITTING, HYD---NPT/JIC, 140, 190, 95302170, FITTING, HYD, 432
370
95302733, FITTING, 273
95264776, CLAMP, HOSE, 113
95302998, FITTING, HYD, 140, 370
95264909, ELBOW, 90DEG---EXT/INT NPT, 120
95303335, FITTING, HYD, 307, 399
95264941, FITTING, HYD, 260
95303368, ADAPTER, STR---JIC/O---RING, 95,
95264966, FITTING, HYD, 140, 259 100, 334, 363
95266433, O---RING, 362 95308573, KEY, SQUARE, 167
95267092, PETCOCK, 246, 417 95313961, HOSE, AIR---R32 BULK, 273
95279071, FITTING, HYD, 190, 196, 424 95315214, FITTING, HYD, 273, 417
95279105, FITTING, HYD, 120, 308 95315222, FITTING, HYD, 120
WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index liii
 Serial Number: 4133
FAMILY,DM50

Index

95315230, FITTING, HYD, 327, 362, 366 95361390, CONNECTOR, 1/2 90 DEG, 434
95315289, FITTING, 307 95364949, FITTING, HYD, 100, 334
95316972, FITTING, HYD---NPT/JIC, 143, 259, 95364964, ADAPTER, 59
327, 432 95364972, FITTING, HYD, 59, 259
95317426, ADAPTER, 90DG---EXT/EXTNPT, 273 95365078, FITTING, HYD, 195, 260, 363
95323465, PLUG HEAD, 152, 260, 334 95365086, FITTING, HYD, 357
95323481, FITTING HYD, 260 95365094, ADAPTER, 90DEG---O---RING/JIC,
95324273, FITTING, HYD, 307 140, 192
95326922, ADAPTER, 45DEG. NPT/JIC, 224 95368338, CLAMP, HOSE, 229
95326955, PLUG W/O RNG, 306, 366 95368536, CONNECTOR, 1/2 45 DEG, 434
95329249, TERMINAL, 65, 383 95370045, FITTING, HYD, 196

95329256, TERMINAL, 384 95371092, CLAMP, HOSE, 383, 399

INDEX

95329975, FITTING, HYD, 140, 260, 363 95371209, ADAPTER, 90DEG---O---RING/JIC,

307
95329983, FITTING, HYD---JIC/O---RING, 362,
95371217, FITTING, 307
366
95371241, ADAPTER, STR.---JIC/O---RING, 307
95330023, FITTING, HYD, 246
95371258, FITTING, HYD, 102, 357, 362, 366
95330692, ADAPTER, 90DEG---O---RING/JIC,
418 95376141, ADAPTER---90DEG, ORING/JIC, 246
95332599, ADAPTER, 59 95377156, FITTING, STR---EXT NPT RUN, 190
95335980, FITTING, HYD, 190 95378667, SCREW, CAP, 98
95338372, FITTING, HYD, 327 95378873, CLAMP, HOSE, 433
95338406, FITTING, HYD, 418 95381158, FITTING, HYD, 259, 362
95341079, FITTING, HYD, 190, 259 95396404, FITTING, HYD, 190
95341665, FITTING, HYD---90 DEG, 102, 362, 95402806, FITTING, 363
399 95403580, TEE, 362
95341798, PIPE, 42 95408167, PLUG, PIPE, 432
95343596, PLUG, WITH O---RING, 307 95408183, FITTING, HYD, 366
95344719, OUTLET BODY, 434 95412870, O RING, 48
95351904, CLAMP, HOSE, 108, 113, 384 95415584, PLUG, JIC---6, 196
95356721, FITTING, HYD, 322 95415667, FITTING, HYD, 363, 364
95356853, FITTING, HYD, 322 95415774, FITTING, HYD, 100
95356903, FITTING, HYD, 334 95419594, FITTING, HYD, 192, 334
95356960, FITTING, HYD, 307, 308, 362 95423331, FITTING, HYD, 260
95356986, FITTING, HYD, 306, 307 95431292, FITTING, HYD, 307, 308
95357232, SCREW, CAP---7/16---14X2---1/4, 190 95433264, ELBOW, 334
95357570, FITTING, HYD, 307, 322 95433330, HOSE, AIR, 136

95357604, ADAPTER, 90DEG---ORING/JIC, 307, 95434551, BEARING, ROLLER, 150

322 95434569, BEARING, ROLLER, 150
95359329, TERMINAL, RING, 448 95434874, BEARING, 150
95359600, TERMINAL, 384 95445664, CLAMP, HOSE, 433
95360996, BUSHING, MALE, 384 95446480, CROSS, PIPE---1---1/2 NPT, 270
Index liv WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133.
 Serial Number: 4133
FAMILY,DM50

Index

95446563, COUPLING, 417 95754651, TEE, JIC, 326

95446571, COUPLING, 417 95775623, FITTING, HYD, 273
95473443, FITTING, HYD, 363 95780060, RING, RETAINING, 348
95489282, ELBOW 4511/4, 137 95829362, FITTING, HYD, 308
95532271, UNION, PIPE---1---1/2 NPT, 270 95866232, PIN, HINGE---1.13X5X4.5 GRP, 206
95647806, FITTING, HYD, 307, 308 95868014, O RING, 48, 49
95650149, ADAPTER, 322 95868030, O RING, 48, 49
95652970, FITTING HYD, 362 95917696, SCREW, FLAT HD---1/4---20X3/4, 260
95654216, CLAMP, HOSE, 363
95920674, SCREW, CAP, HEX, 129
95655064, ADAPTER, INT NPT/O---RING, 260,
370 95929774, NUT, HEX, 129

95663803, FITTING, TUBE, 306 95934451, SCREW, CAP, HEXHEAD, PLATED,

130

INDEX
95664934, PLUG, 1---1/16---12, 307
95934550, SCREW, CAP, HEX, 130
95666996, FITTING, HYD, 140
95934733, WASHER, LOCK, 130
95667820, TEE, NPT/JIC, 362
95934741, WASHER, LOCK HELICAL, 129
95675880, TEE---INT NPT/JIC/INT NPT, 327
95937413, WASHER, LOCK, HELICAL, 129
95676417, FITTING HYD---90, 327
95939948, WASHER, LOCK, HELICAL SPRG,
95678041, FITTING, HYD, 254
129
95702015, FITTING, TUBE, 95
95959151, WASHER, LOCK---3/8, 95
95702627, FITTING, HYD, 307, 366
95704839, SWIVEL NUT, 143, 190
95711156, BEARING, SPHERICALROLLER, F
150
F04X000J--- ---/J--- ---, FC310---04 HOSE INDICA-
95735346, FITTING, HYD, 306, 307 TOR, 444
95737086, ELBOW, PIPE, 138
F16X000J--- ---/J--- ---, FC310---16 HOSE INDICA-
95748927, TEE, NPT/JIC, 143, 224 TOR, 432

WARNING: This manual contains data SPECIFIC to the drilling rig with serial number: 4133. Index lv