Attach to Vol. No.

: TT1CFE-00
CAUTION: Parts numbers on the drawing are provided only for reference purpose.
ZAXIS75UR/135UR ELECTRICAL CIRCUIT DIAGRAM To order parts on the drawing, be sure to consult the Parts Catalog.

COOLANT TEMP. SW.

STARTER SW.

RESISTER S
RESISTER D

EMERGENCY
EVACUATION SW.

K
A
RESISTER
K
STARTER SW.
A

FUSIBLE LINK (45A)

OPT DECEL.
NOT IN SMJ 2-9 OUT 1-32
BATTERY 12V 2 ACC (LOAD) EMERGENCY
BATTERY RELAY
IN 1-18 ACCEL.
ALT (LOAD) EVACUATION
4-2 RECEPTION (+) OUT 1-29
LCD 4-11 TRANSMISSION (+) SW.
FUSIBLE LINK (65A)
IN 1-7 ACCEL.
AUTO LOAD DUMP DISPLAY 4-3 RECEPTION (-)
RE-FUELING 4-12 TRANSMISSION (-) OUT 1-10
SYSTEM RELAY IN 1-5 DECEL.
OUT 1-23
IN 1-16 DECEL.
HORN
LIGHT
WIPER
AIR-CON.
AUX.

ROOM LIGHT, LIGHTER, RADIO

HEATER
BACK-UP
LCD MONITOR
EMERGENCY SW.
GLOW
MONITOR
POWER IN-OUT OUT 1-24
BACK-UP POWER IN-PUT POWER DECEL.
GLOW IN-PUT CIRCUIT
IN 1-17
STARTER SERIAL COMMUNICATION TXD
SAFETY RELAY
GND SERIAL COMMUNICATION RXD OUT 1-11
SERIAL COMMUNICATION 2TXD- IN 1-6
SERIAL COMMUNICATION 2TXD+
DECEL.
WASHER
REG IN-PUT SERIAL COMMUNICATION 2RXD+
GLOW RELAY SERIAL COMMUNICATION 2RXD- 3-10 OFFSET-LEFT OUT 1-30
2-2 OFFSET-RIGHT IN 1-19 ACCEL.
WASHER CAB OUT
RELAY 2-14 RESTRICTION SW. OUT 1-31
CAB IN ROOM LIGHT COOLANT
FUEL

POWER-ON SIGNAL
TEMP. IN 1-20 ACCEL.
LIQUID EC DIAL SIGNAL IN-PUT OPT
CRYSTAL EC DIAL SIGNAL IN-PUT (GND) RIGHT CONTROL OUT 1-22

EC MOTOR
PANEL LEVEL IN 1-15 DECEL.
WIPER L1 : LOAD ALARM
RELAY
L2 : STROKE END 2-12 INITIAL SETTING 5V (PRES.) 2-19
L3 : HOOK
3B
BOOM RAIS. PRES. 3-17 BOOM RAIS. PRES.
ALTERNATOR
L4 : ARM VERTICALITY A 6 GND (PRES.) 2-21
L5 : ENG. OIL PRESS.
DISPLAY CHANGE
2-3 SERVICE SW. ARM DUMP PRES. 3-15 ARM DUMP PRES. 2

LIGHT
L6 : OVER-HEAT
1-25 GND (RELAY) ARM ROLL-IN DECEL. PRES. 3-6
SET L7 : FUEL
BOOM LOWER DECEL. PRES. 3-16 ARM ROLL-IN DECEL. PRES. 5
K

L8 : CHARGE 1-26 BUZZER

WORK MODE
L9 : AIR FILTER 2-4 SWING MODE OFFSET RIGHT ACCEL. PRES. 3-12
A

RADIO LIGHT IC/U BUZZER

GLOW PLUG WIPER MOTOR L10 : GLOW
L11 :HYD. OIL FILTER
OFFSET LEFT ACCEL. PRES. 3-2 BOOM LOWER DECEL. PRES. 6
AUTO M
L12 : SPARE BOOM RAISE ACCEL. PRES. 3-5
TRAVEL SW
REGULATOR HYD. OIL FILTER SW. IN-PUT OFFSET RIGHT ACCEL. PRES. 7
SPARE
CHARGE EXT

WASHER
AIR FILTER SW. IN-PUT OFFSET LEFT ACCEL. PRES. 8
CRANE MODE SW. 2-13 CONNECT DETECTION
FUEL EXT
WIPER
GLOW EXT
4-9 TRANSMISSION
WARNING LAMP LOCATION 4-10 RECEPTION
BOOM RAISE
HIGH- LOW- ACCEL. PRES.
SPEED SPEED FUEL SIGNAL
HORN RELAY COOLANT TEMP SIGNAL 3-11 SLIDE SENSOR
2-15 ARM RETRACT OPT
AUTO - MARCCINO
135UR ONLY 2-6 ARM EXTEND EMERGENCY HYD. OIL TEMP. SENSOR
HORN SW LIGHT TRAVEL MODE
STOP SOL.
AUTO M WIPER
AUTO - IDLE
SLIDE ARM 2-16
HP MODE EMERGENCY STOP
SOL. VALVE
E MODE
HORN SIDE LOAD DUMP RELAY OUT-PUT AUTO - IDLE
SATELLITE / PC LIGHT 1 RELAY OUT-PUT
RELAY DRIVE

MALE ON HORN WORK MODE

WIPER RELAY OUT-PUT
BOTH SIDE WASHER RELAY OUT-PUT ML MODE 1
CURCUIT

LIGHT RELAY 2 ML1 RELAY OUT-PUT BOOM ANGLE SENSOR

ENG. OIL LEVEL
ML2 RELAY OUT-PUT
ML3 RELAY OUT-PUT COOLANT LEVEL
ML4 RELAY OUT-PUT ARM ANGLE SENSOR
ENG. OIL LEVEL SW. IN-PUT
COOLANT LEVEL SW. IN-PUT
(NORMAL OPEN ML CONNECT)
PULL - UP
ML SWITCH
(BOOM LIGHT) ML - MODE 2 OFFSET ANGLE SENSOR
BUCK UP EN
ENG. OIL PRES. SW. IN-PUT
LIGHT RELAY 1 OVER - HEAT SW. IN-PUT
HOUR METER GND.
ENG. SPEED BOOM ROD
PRESSURE (S)
CONTROL DIAL

INITIAL BOOM BOTTOM

(WORK LIGHT) PRESSURE (S)
SETTING SW.
NORMAL OPEN OPT
RADIATOR LEVEL SW.
ENG. OIL LEVEL SW.

ARM ROLL-OUT PRES. (S)

COOLANT TEMP. SENSOR
FUEL SENSOR
ENG. OIL PRESSURE SW.
OVER-HEAT SW.
AIR CLEANER RESTRICTION SW.

HYD. OIL FILTER WARNING (OPT)

LEARNING SW.
ML RELAY

SWING
A NATURAL ALARM
BUCKET LOCK SOL.

ML LIGHT

SOL. PUMP AUTO

AIR BLEED

A
OPTION

SEALED WIRE

CANCEL SW.

PRESSURE SWITCH

HYD. OIL TEMP. SENSOR

ANGLELIMIT
PUMP 1

TORQUE
PUMP

ANGLELIMIT
PUMP 2
AUX. FLOW

OUTSIDE INSIDE N-SENSOR

COMPRESSOR

CONTROL 2
PUMP

CONTROL 1
PUMP
INSIDE OUTSIDE OPTION TRAVEL FRONT SWING SWING ARM BOOM
ROLL-IN RAISE
OPTION