ATA CHAPTER 05

DATE TASK DESCRIPTION REFERENCE

05/09/12 STEERING SYSTEM DETAILED AMM 05-12-03
INSPECTION.
28/09/14 GENERAL VISUAL INSPECTION OF AMM
OUTBOARD FIXED TRAILING EDGE 05-25-70-200-00
STRUCTURE FROM RIB 9 TO 27 (EWIS) 5-A
28/09/14 GENERAL VISUAL INSPECTION OF LEFT AMM
WING INBOARD FIXED TRAILING EDGE 05-25-70-200-00
STRUCTURE FROM SHROUD BOX TO RIB 3-A
9 (EWIS)
19/08/16 INSPECTION OF AIRFRAME AFTER BIRD AMM
STRIKE 05-21-51-14-200
-803-A
ATA CHAPTER 10
DATE TASK DESCRIPTION REFERENCE
07/01/15 INSTALLATION OF APU EXHAUST AMM
DUCT COVER. 10-11-00-555-013
-A
ATA CHAPTER 11
DATE TASK DESCRIPTION REFERENCE
24/05/12 REMOVAL AND INSTALLATION OF AMM 11-00-00
EXTERIOR PLACARDS
25/04/12 REMOVAL AND INSTALLATION OF AMM 11-00-00
EXTERIOR PLACARDS
ATA CHAPTER 12
DATE TASK DESCRIPTION REFERENCE
08/11/11 TEST OF REFUEL PANEL 800 VU AMM
PRIOR TO REFUELLING. 12-11-28-740-051-A

08/11/11 PRESSURE REFUEL WITH MANUAL AMM

CONTROL DURING AIRCRAFT 12-11-28-650-004-A
TRANSIT.

15/12/11 PRESSURE REFUEL WITH AMM

AUTOMATIC CONTROL DURING 12-11-28-650-003-A
AIRCRAFT TRANSIT.

22/01/12 CHECK OF HYDRAULIC SYS QTY IN AMM

ECAM HYD SD PAGE. 12-12-29-611-001-A

08/03/12 AIRCRAFT CHROME POLISHING, AMM 12-26-00

AIRCRAFT WASH, EXTERIOR
SURFACE AERO WAXING AND PAINT
POLISHING
19/03/12 SERVICING OF EXTERNALLY FLUSH AMM 12-05-02
TOILET
20/03/12 FULL AIRCRAFT WASH AMM 12-26-00
26/03/12 FULL AIRCRAFT WASH AMM 12-26-00
14/05/12 FLAP SYSTEM LUBRICATION, AMM 12-21-00
INCLUDING FLAP FLEX SHAFT
LUBRICATION, FLAP ACTUATOR
HOUSING LUBRICATION, FLAP
ACTUATOR BALL SCREW
LUBRICATION AND FLAP ROLLER
BEARING LUBRICATION
06/10/12 LUBRICATION OF MAIN LANDING AMM
GEAR AND DOOR 12-22-32-640-001-A
06/10/12 LUBRICATION OF NOSE LANDING AMM
GEAR AND DOOR 12-22-32-640-002-A
18/12/12 REPLENISH LH ENGINE OIL SYSTEM AMM
12-13-80-610-002-B
09/06/14 INSTALLATION OF RACK 93VU AND AMM 12-21-13
RELATED COMPUTERS.

30/01/15 DRAIN AND REFILL FLAP ACTUATOR AMM

ASSEMBLIES WITH SEMI FLUID. 12-13-27-612-005-A
02/12/15 HYDRAULIC SAMPLING OF GREEN, AMM
BLUE AND YELLOW SYSTEMS. 12-32-29-281-001-A

CHECK OF FLUID LEVEL IN AMM

RESERVOIRS 12-32-29-611-050-A
04/01/16 LUBRICATION OF THE FWD LH AMM
PAX/CREW DOOR HINGE ARM 12-22-52-640-016-A
SUPPORT FITTING BEARINGS.

SAFETY PRECAUTION C/OUT ON AMM

FWD LH DOOR AFTER 52-10-00-860-002
MAINTENANCE
01/08/16 FILLING OF GREEN HYDRAULIC AMM
FLUID RESERVOIR WITH HAND 12-12-29-611-001-A
PUMP
ATA CHAPTER 20
DATE TASK DESCRIPTION REFERENCE
07/08/12 INSTALLATION OF ADF ANTENNA AMM 20-10-05
COAX CABLE CONNECTOR.
07/11/14 BLUE HYDRAULIC POWER FLIGHT AMM 20-23-11
CONTROL LINE SEAL REPLACEMENT
AND REINSTALLATION OF THE
CONTROL LINE.
30/07/14 REPLACEMENT AND SWAGING OF AMM
HYDRAULIC BLUE SYSTEM SUPPLY 20-23-11-300-001
LINE.

RUDDER OPS CHECK AND LEAK AMM

CHECK. 27-24-00-710-001
20/03/15 TO C/OUT ELECTRICAL BONDING OF AMM
THE RADOME MOUNTING BOLTS. 20-28-00-912-004
04/09/15 REPLACEMENT OF TERMINAL LUG AT ESPM 20-48-19
GROUNDING STUD GD9954DC.
24/09/15 REPLACEMENT OF CENTRE TANK HI ESPM 20-45-12
LVL ANNUNCIATOR LIGHT AT
REFUEL PANEL 800 VU.
21/01/16 REPLACEMENT OF CONNECTOR ESPM 20-44-11
50MGH-A ON LAVATORY E UNIT.. AWM 38-31-03
26/11/15 REPAIR OF WIRE 3154-0648 BY USING ESPM 20-52-21
HIGH TEMPERATURE BUTT SPLICE.

OPERATIONAL TEST OF FLOW AMM

CONTROL AND INDICATING SYSTEM. 21-51-00-710-002-A
03/04/16 REPLACEMENT OF EFCS WIRE ESPM 20-33-20
(TERMINATION AT SEC 3 AND 1958 VC ESPM 20-48-34
CONNECTOR). ESPM 20-53-21
28/04/16 REPLACEMENT OF MAIN LANDING ESPM 20-44-10
GEAR DOOR UPLOCK PROXIMITY ESPM 20-51-10-02
SWITCH.
29/04/16 REPLACEMENT OF PTT SWITCH. ESPM 20-25-42
ESPM 20-48-24
28/05/16 REPLACEMENT OF 14HQ PUSH ESPM 20-45-11
BUTTON SWITCH AND BLOWER 13HQ
PUSH BUTTON SWITCH.

OPS TEST OF AVIONICS EQUIPMENT AMM

VENTILATION. 21-26-00-710-001-A
05/06/16 REPLACEMENT OF WIRE 3154-0679 ESPM 20-48-22
AND 3154-0684. AWM 31-54-60

CONTINUITY CHECK BETWEEN PIN ESPM 20-52-21

10D OF SDAC 1 AND PIN 10D OF SDAC
2.
AMM
OPS TEST OF AEVC. 21-26-00-710-001-A
ATA CHAPTER 21
DATE TASK DESCRIPTION REFERENCE

23/04/16 CABIN PRESSURIZATION TEST TO TEST THE AMM 21-30-00

SERVICEABILITY OF SECONDARY DOOR SEAL.

01/06/12 REPLACEMENT OF CABIN DUCT AMM 21-61-00

TEMPERATURE SENSOR.

28/11/13 PRE-CONDITIONING WITH THE APU. AMM

12-33-21-618-001-A02
OPS TEST OF PACK TEMPERATURE CONTROL AMM
SYSTEM. 21-61-00-710-001-A

30/11/13 REPLACEMENT OF COMPRESSOR OUTLET AMM 21-61-11

TEMPERATURE.

OPS TEST OF PACK TEMPERATURE CONTROL AMM

SYSTEM. 21-61-00-710-001-A

16/05/14 OPS CHECK OF MANUAL MODE SELECTION AMM

AND MANUAL MODE PRESSURE CONTROL 21-31-00-710-003-A
AND FUNCTIONAL CHECK OF MANUAL MODE
CABIN ALTITUDE INDICATION AND OUTFLOW
VALVE POSITION INDICATOR.

16/05/14 OPS CHECK OF PRESSURE CONTROL AND AMM

MONITORING SYSTEM VIA MCDU. 21-31-00-710-002-A

24/03/15 INSTALLATION OF QUARTER SHELL ASSY. AMM

21-52-24-400-001-A
OPS CHECK OF COCKPIT AND CABIN AMM
TEMPERATURE CONTROL. 21-63-00-710-004

12/11/15 REPLACEMENT OF PRIMARY HEAT AMM 21-52-21

EXCHANGER.
AMM
OPS CHECK OF COCKPIT AND CABIN 21-63-00-710-004
TEMPERATURE CONTROL.
13/11/15 REPLACEMENT OF COMPRESSOR INLET AMM 21-52-21
GASKET.

OPS CHECK OF COCKPIT AND CABIN AMM

TEMPERATURE CONTROL. 21-63-00-710-004

21/10/15 REPLACEMENT OF PRESSURE SWITCH 19HQ. AMM 21-26-11

OPS TEST OF VENTILATION SYSTEM OF AMM

AVIONICS EQUIPMENT. 21-26-00-710-001-A

13/03/16 CLEANING OF TEMPERATURE SENSOR 21HK. AMM

21-63-17-210-052-A
OPS CHECK OF COCKPIT AND CABIN AMM
TEMPERATURE CONTROL. 21-63-00-710-004

28/05/16 TROUBLESHOOT VENT AVNCS SYS FAULT TSM

FAULT AFTER ENGINE SHUTDOWN. 21-26-00-810-829-A

OPS TEST OF VENTILATION SYSTEM OF AMM

AVIONICS EQUIPMENT. 21-26-00-710-001-A

REPLACEMENT OF AEVC. AMM 21-26-34

09/04/16 TROUBLESHOOT PACK 2 REG FAULT. TSM

21-61-00-810-821-A
REPLACEMENT OF DIFFERENTIAL PRESSURE AMM 21-51-11
SENSOR 24HB2.

OPS TEST OF THE FLOW CONTROL AND AMM

INDICATING SYSTEM 21-51-00-710-002

02/10/16 MAINT PROCEDURE 21-26-05A FOR AIR AMM

CONDITIONING INLET VALVE OPEN ON 21-26-00-040-004-A
GROUND.

OPS TEST OF AVIONICS EQUIPMENT AMM

VENTILATION FROM MCDU. 21-26-00-710-001
ATA CHAPTER 22
DATE TASK DESCRIPTION REFERENCE

02/09/13 OPS TEST OF AFS. AMM 22-96-00-710-001

TROUBLESHOOT MAINT MESSAGE AFS:FMGC TSM

2/AP ENGD FDBK. 22-11-00-810-816-A

REPLACEMENT OF FMGC. AMM 22-83-34

FMS DATA LOADING. AMM

22-70-00-610-008-C

13/05/14 OPERATIONAL CHECK OF AMM

ENGINE/AUTOTHRUST SYSTEM ISOLATION. 22-30-00-710-003-A

13/05/14 OPERATIONAL CHECK OF FAC 2 FUNCTION AMM

22-60-00-710-001-A

15/03/16 RESET OF FLIGHT CONTROL UNIT DUE TO AMM

FCU 2 FAULT. 22-81-12-865-050-A

OPS TEST OF AFS. AMM 22-96-00-710-001

17/03/16 REPLACEMENT OF FLIGHT CONTROL UNIT AMM 22-81-12

OPS TEST OF AFS. AMM 22-96-00-710-001

AMM 22-97-00-710-001
LAND CAT 3 CAPABILITY TEST
ATA CHAPTER 23
DATE TASK DESCRIPTION REFERENCE

17/05/14 REPLACEMENT OF COCKPIT VOICE AMM 23-71-35

RECORDER.

OPS TEST OF CVR. AMM 23-71-00-710-001

20/06/14 REPLACEMENT OF STATIC DISCHARGERS. AMM 23-61-41

RESISTANCE TEST BTW STATIC AMM 23-61-00-200-001

DISCHARGER AND RETAINER.

01/07/14 OPS CHECK OF CVR UNDER WATER AMM 23-71-00-720-001-A

LOCATOR BEACON.

02/07/14 OPERATIONAL CHK OF CVR AND CVR AMM 23-71-00-710-001-A

CHANNEL RECORDING.

02/07/14 OPS CHK OF CVR RECORDING LOGIC AMM 23-71-00-710-002-A

INCLUDING TIME DELAY RELAY.

09/07/14 REPLACEMENT OF PASSENGER SERVICE AMM 23-73-45

UNIT.

CIDS INTERFACE AND POWER UP TEST AMM 23-73-00-740-005-B

12/10/14 REMOVAL AND INSTALLATION OF AMM 23-44-41

ENGINE AIR INTAKE COWL INTERPHONE
JACK.
AMM 23-44-00-710-001
OPS TEST OF SERVICE INTERPHONE SYS.

08/07/16 REPLACEMENT OF BOOMSET ON CAPTAIN AMM 23-51-01

SIDE.

OPS TEST OF AUDIO MANAGEMENT AMM 23-51-00-710-001-A

12/07/16 REPLACEMENT OF RADIO MANAGEMENT AMM 23-13-13

PANEL NO 1.

BITE TEST OF RADIO MANAGEMENT. AMM 23-13-00-740-001-A

ATA CHAPTER 24
DATE TASK DESCRIPTION REFERENCE

05/04/12 STANDBY BATTERY LEVEL CHK AS REQUIRED AMM 24-32-00

BY MAINTENANCE SCHEDULE.

04/06/12 REPLACEMENT OF BATTERIES- DUE FOR AMM 24-31-00

CAPACITANCE CHK.

28/08/12 REPLACEMENT OF BATTERIES- DUE FOR AMM 24-31-00

CAPACITANCE CHK.

30/08/12 C/OUT AIRCRAFT BATTERIES CAPACITANCE CMM 24-34-00

CHECK (MARATHON NICKEL CADMIUM
BATTERY)

10/02/14 REPLACEMENT OF ENGINE INTEGRATED DRIVE AMM 24-21-51

GENERATOR UNIT.

SERVICING OF IDG. AMM

12-13-24--612-041
TEST OF IDG DISCONNECT SYSTEM. AMM
24-21-00-720-041

10/02/14 REPLACEMENT OF GCU. AMM 24-22-34

OPS TEST OF GAPCU WITH CFDS. AMM

24-41-00-740-002

24/11/14 APPLICATION OF TEMPORARY PROTECTION TO AMM

END FITTINGS OF ELECTRICAL CONDUITS IN 24-92-00-210-014-A
THE MAIN LANDING BAY AND FALSE SPAR
BOX.

18/02/15 TROUBLESHOOTING OF IDG DIFFERENTIAL TSM

PRESSURE INDICATOR EXTENDED. 24-21-00-810-815-A

CHK OF IDG FILTER AND OIL COVER FOR AMM

 METAL PARTICLES. 24-21-00-210-044

OIL FILTER REPLACEMENT AND OIL SERVICING. AMM

24-21-00-920-040

24/04/16 TROUBLESHOOTING BCL #2 FAULT. TSM

24-38-00-810-810-A
REPLACEMENT OF BCL #2. AMM 24-38-34

OPS TEST OF BCL. AMM

24-38-00-710-001

29/05/16 TROUBLESHOOTING ELEC-DC BAT BUS FAULT. TSM

24-60-00-810-803-A
RESET TR 1,2, AND 3 VIA MCDU. AMM
24-60-00-710-054-A
OPS TEST OF DC GENERATION SWITCHING AMM
24-32-00-710-001-A

28/08/16 TROUBLESHOOTING BCL #1 FAULT. TSM

24-38-00-810-803-A
OPS TEST OF BCL AMM
24-38-00-710-001

30/08/16 TROUBLESHOOT ELEC TR 1 FAULT. TSM

24-30-00-810-801-A
TEST OF TR. AMM
24-30-00-710-051-A

ATA CHAPTER 25
DATE TASK DESCRIPTION REFERENCE

05/04/12 REMOVAL AND INSTALLATION OF SEAT BELT. AMM 25-21-02

23/04/12 PILOT SEAT REMOVAL AND INSTALLATION. AMM 25-11-01

21/06/12 PASSENGER SEAT INSTALLATION AMM 35-21-01

15/06/12 LEATHER POLISHING OF PASSENGER SEATS AMM 25-20-00

15/12/13 INSTALLATION OF COVER AT FWD CABIN AMM 25-23-42

CEILING PANEL.

12/06/14 REMOVAL OF FIXED ELT PROGRAMMING AMM

DONGLE. 25-65-35-000-003-A

REMOVAL OF SURVIVAL ELT PROGRAMMING AMM

DONGLE. 25-65-32-000-001-A

INSTALLATION OF FIXED ELT PROGRAMMING AMM

DONGLE. 25-65-35-400-003-A

INSTALLATION OF SURVIVAL ELT AMM

PROGRAMMING DONGLE. 25-65-32-400-001-A

BITE TEST OF FIXED ELT. AMM

25-65-00-740-001-A
BITE TEST OF SURVIVAL ELT. AMM
25-65-00-740-002-A

09/07/14 INSTALLATION OF CABIN ATTENDANT SEAT. AMM

25-22-42-400-001-A

06/11/14 REPAIR OF FWD CARGO PROTECTION PANELS. AMM

25-50-00-340-003-A
INSTALLATION OF PANELS AFTER REPAIR AMM 25-54-12
COMPLETED.

30/11/14 REPLACEMENT OF OVEN AFT GALLEY. AMM 25-35-19

OPS TEST OF OVEN. AMM

25-35-00-710-015

08/12/14 REPLACEMENT OF FWD GALLEY WATER AMM 25-35-27

BOILER.
AMM
 OPS TEST OF WATER BOILER. 25-35-00-710-023

25/03/15 REPAIR OF FWD CARGO PROTECTIVE AMM

ASSEMBLY PANEL. FILLER REPAIR METHOD 25-50-00-340-003-A
(DAMAGE NOT THROUGH.

INSTALLATION OF PANEL. AMM 25-54-12

14/07/15 REPLACEMENT OF LAVATORY A JAMB POST. CMM 25-41-54

15/07/15 REPLACEMENT OF PHOTOLUMINESCENT STRIP. AMM 33-51-21

20/07/15 INSTALLATION OF PANEL FIN: 211LW. AMM

25-13-41-400-002-A

21/07/15 REPLACEMENT OF DOOR UPPER HANDLE. AMM 25-23-45

21/08/15 REPLACEMENT OF ELT ANTENNA. AMM 25-65-14

BITE TEST ELT SYSTEM. AMM

35-65-00-740-001-A

26/09/15 REPLACEMENT OF SPRING AT SEAT 4D AMM 25-21-00

LITERATURE POCKET.

29/10/15 REPLACEMENT OF F/O SEAT REAR SHROUD CMM 25-11-46

EQUIP.

17/02/16 REMOVAL OF PASSENGER SEAT ROWS 9 ABC, 10 AMM

ABC, AND 11 ABC. 25-21-41-000-001-A

17/02/16 REMOVAL OF CABIN UPPER SIDEWALL PANELS AMM

BETWEEN FR 35-36 25-23-43-000-001-A

19/02/16 INSTALLATION OF PASSENGER SEAT ROWS 9 AMM

ABC, 10 ABC, AND 11 ABC. 25-21-41-400-001-A

19/02/16 INSTALLATION OF CABIN UPPER SIDEWALL AMM

PANELS BETWEEN FR 35-36 25-23-43-400-001-A

25/04/16 REPLACEMENT OF EMERGENCY LOCATOR AMM 25-65-18

TRANSMITTER ELT REMOTE CONTROL PANEL .
 BITE TEST ELT. AMM
25-65-00-740-001

05/06/16 REPLACEMENT OF CAPTAIN SEAT VERTICAL AMM 25-11-00

ADJUSTMENT ELECTRICAL CONTROL SWITCH.

OPS TEST OF ELECTRICAL CONTROL. AMM

25-11-00-710-001A
ATA CHAPTER 26
DATE TASK DESCRIPTION REFERENCE

22/04/14 MPD TASK CHECK FIRING CIRCUIT AMM 26-23-00-710-003-A

CONTINUITY AND OPERATIONAL CHECK
OF PRIORITY SWITCHING.

HANDLING PRECAUTION OF AMM 20-15-00-910-001-A

ELECTROSTATIC DISCHARGE SENSITIVE
DEVICE.

10/10/14 TRANSFER OF FAN FIRE DETECTOR AMM 26-12-15-000-026-A

DURING ENGINE CHANGE. AMM 26-12-15-400-026-A

OPS CHECK OF ENGINE FIRE AND

OVERHEAT DETECTION (LOOP/SQUIB) AMM 26-12-00-710-001

10/10/14 TRANSFER OF CORE FIRE DETECTOR AMM 26-12-16-000-002-A

DURING ENGINE CHANGE. AMM 26-12-16-400-002-A

OPS CHECK OF ENGINE FIRE AND AMM 26-12-00-710-001

OVERHEAT DETECTION (LOOP/SQUIB)

23/11/14 MPD TASK CONTINUITY CHECK OF THE AMM 26-22-00-720-001-A

APU FIRE EXTINGUISHING FIRING
CIRCUIT
AMM 26-22-00-710-001
OPS TEST OF THE APU EXTINGUISHING
LOOP/SQUIB..

23/02/15 MPD TASK OPS CHECK OF APU FIRE PUSH AMM 26-22-00-710-004-A
BUTTON SWITCH FUNCTIONS (IN SINGLE
CHANNEL CONFIG) AND TEST APU LP
FUEL VALVE OPERATION USING EACH
INDIVIDUAL MOTOR IN TURN AND TEST
APU EMERGENCY SHUTDOWN CIRCUIT.

18/01/16 TROUBLESHOOT ECAM MESSAGE ENGINE TSM 26-12-00-810-806-A

2 FIRE LOOP B FAULT.

OPS TEST OF ENGINE FIRE AND AMM 26-12-00-710-002

 OVERHEAT DETECTION FROM MCDU

ATA CHAPTER 27
DATE TASK DESCRIPTION REFERENCE

19/03/12 AILERON TRIM TAB CHECK AS A AMM 27-30-00

PRE-FLIGHT SAFETY CHECK.

10/05/12 TROUBLESHOOT PITCH TRIM SYSTEM AMM 27-40-00

DEFECT “STAB TRIM MONITOR WARNING”
MESSAGE ON CREW ALERTING SYSTEM
MESSAGE DISPLAY.

15/05/12 ELEVATOR TRIM TAB SYSTEM AMM 27-40-00-641

LUBRICATION.

30/05/12 REPLACEMENT OF LHS FLAP ACTUATOR AMM 27-51-03

MOTOR DUE TO MOTOR SEIZED.

30/05/12 REPLACEMENT OF THE RHS FLAP AMM 27-51-03

ACTUATOR GEARBOX DUE TO GEARBOX
INOPERATIVE.

18/06/12 RUDDER AND RUDDER TRIM TAB AMM 27-21-00-210

INSPECTION.

18/06/12 FLAP INSPECTION AS REQUIRED IN THE AMM 27-51-00-211

INSPECTION PHASE 2.

30/06/13 REPLACEMENT OF SPOILER ELEVATOR AMM 27-94-34

COMPUTER SEC #3 DUE TO ECAM
WARNING F/CTL GND SPOILER 1+2.

OPS TEST OF SEC #3. AMM 27-94-00-710-001

09/02/14 REPLACEMENT OF BUFFER AT THE AMM 27-21-43-000-002-A

CAPTAIN SIDE PEDAL POSITION ADJUSTER AMM 27-21-43-400-002-A
ASSEMBLY DUE TO CAPTAIN REPORTED
RUDDER PEDAL DOES NOT SPRING BACK
TO NEUTRAL.
AMM 27-21-43-710-051-A
 OPS TEST.

20/08/14 REMOVAL OF ELEVATOR FOR THE AMM 27-34-41-000-001-A

REPLACEMENT OF HINGE FITTING AND
BUSHING.

INSTALLATION OF SIDE STICK LOCKING

PIN AT SIDE STICK CONTROLLER AS
SAFETY PROCEDURE.

20/08/14 INSTALLATION OF ELEVATOR AFTER AMM 27-34-41-400-001-A

COMPLETION OF HINGE FITTINGS AND
BUSHES REPLACEMENT.

ADJUSTMENT OF ELEVATOR TO NEUTRAL AMM 27-34-00-820-003-B

SETTING.

OPS TEST OF ELEVATORS. AMM 27-34-00-710-001

23/10/14 INSPECTION OF RHS WING INBOARD FLAP EI-06-010-A322 REV I

TRUNNION AND SLIDING WINDOW PANEL
TO DETECT DAMAGES AT EARLY STAGE
THAT WILL AVOID EXTENSIVE REPAIR.

SLIDING PANEL FOUND DAMAGED AND MM 53-35-00

REPLACED.

TRUNNION FOUND WORN AND SRM 51-73-00

REWORKED. AND RE-PROTECTED WITH SRM 51-21-00
ORIGINAL SURFACE FINISH.\

OPS TEST OF FLAP SYSTEM. AMM 27-54-00-710-001-A

15/11/14 REPLACEMENT OF LH BLUE ELEVATOR AMM 27-34-51

SERVO CONTROL DUE TO FAILED THE
CHECK OF THE ELEVATOR SERVO
CONTROLS AND HINGE BEARINGS FOR
TOO MUCH PLAY.

ADJUSTMENT TEST. AMM 27-34-51-710-050-B

17/11/14 TROUBLESHOOT AIRFRAME VIBRATION TSM 27-20-00-810-802-A

DUE TO RUDDER, FOUND RUDDER #1 AND
#3 FITTING ATTACHMENT WOR, REQUIRE
 REPLACEMENT.

25/11/14 REMOVAL OF RUDDER SERVO CONTROL AMM 27-24-51-000-001-A

UNIT FOR REPLACEMENT OF BEARINGS.

BLANKING CAPS INSTALLED ON

DISCONNECTED PIPES AND UNIONS.

25/11/14 INSTALLATION OF RUDDER SERVO AMM 27-24-51-400-001-A

CONTROL UNIT AFTER REPLACEMENT OF
BEARINGS.

OPS TEST OF RUDDER SYSTEM. AMM 27-24-00-710-001

11/12/14 REPLACEMENT OF SLAT FLAP CONTROL AMM 27-51-34

COMPUTER SFCC DUE TO F/CTL SLAT SYS 1
FAULT.

OPS TEST OF SLAT AND FLAP SYSTEM. AMM 27-54-00-710-002

24/06/15 INSTALLATION OF RHS WING TORQUE AMM 27-54-45

SHAFT ASSY AFTER THE COMPLETION OF
RHS MLG INSTALLATION.

OPS TEST OF FLAP SYSTEM. AMM 27-54-00-710-001

20/08/15 REPLACEMENT OF RUDDER SERVO AMM 27-21-49

CONTROL SPRING ROD END DUE TO
DAMAGED ROD END BEARING.

OPS TEST OF RUDDER SERVO CONTROL. AMM 27-24-00-710-002

11/12/15 INSTALLATION OF HYDRAULIC MOTOR OF AMM 27-84-54-400-001-A

THE SLAT POWER CONTROL.

OPS TEST OF SLAT AND FLAP SYSTEM. AMM 27-54-00-710-002

11/12/15 INSTALLATION OF PRESSURE OFF BRAKES AMM 27-84-52-400-001-A

OF THE SLAT POWER CONTROL UNIT.

OPS TEST OF SLAT AND FLAP SYSTEM. AMM 27-54-00-710-002

13/12/15 OPS TEST AND LEAK AFTER SLAT POWER AMM 27-84-53-710-050-A
 CONTROL UNIT VALVE BLOCK
REPLACEMENT.
OPS TEST OF SLAT AND FLAP SYSTEM. AMM 27-54-00-710-002

29/12/15 REMOVAL OF LHS SPOILER #2 FOR THE AMM 27-64-42-000-001-A

REPLACEMENT OF PLAIN BEARING DUE TO
EXCESSIVE PLAY.

19/01/16 INSTALLATION OF LHS SPOILER #2 AFTER AMM 27-64-42-400-001-A

THE REPLACEMENT OF PLAIN BEARING.

OPS TEST OF SPOILER. AMM 27-64-00-710-001-A

02/02/16 TROUBLESHOOTING FLT CTL FLAP SYS 1 TSM 27-51-00-810-809-A

FAULT.

ASYMMETRY POSITION PICK OFF UNIT AMM 27-51-18

REPLACED AS SUGGESTED BY TSM.

OPS TEST OF FLAP SYSTEM. AMM 27-54-00-710-001

BITE TEST OF SFCC. AMM 27-51-00-740-002

03/08/16 DEACTIVATION OF ELEVATOR AILERON AMM 27-93-00-040-001-A

COMPUTER #1 DUE TO ELAC #1 FAULT.

FLT CTL/ELAC 1 PUSH BUTTON SWITCH AMM 27-93-00-040-050-A

RELEASED AND WARNING NOTICE PUT ON.

CIRCUIT BREAKER 15CE1 AND 16CE1 AMM 27-93-00-860-050-A

OPENED.
ATA CHAPTER 28
DATE TASK DESCRIPTION REFERENCE

10/06/14 TROUBLESHOOTING IDG NO 1 HIGH TSM 28-16-00-810-801-A

TEMPERATURE ADVISORY INDICATION
FAULTING FUEL LEVEL SENSING LH INNER
TEMP SENSOR 29 QJ1.
 REPLACE LH INNER TEMP SENSOR 29 QJ1. AMM 28-46-17

TANK LEVEL SENSING FUNCTIONAL TEST. AMM 28-46-00-740-001

28/09/14 MPD TASK DETAILED INSPECTION OF AMM 28-25-41-200-001-A

REFUEL AND DEFUEL COUPLING.

29/09/14 MPD TASK VISUAL INSPECTION OF LH AMM 28-21-00-790-002-A

WING PIPES, COUPLINGS, AND LP VALVE
EXTERNAL TO TANK FROM FRONT SPAR
TO DISCONNECT PANEL FOR LEAKS WITH
BOOSTER PUMP ON AND LP VALVE OPENS.

01/10/14 INSTALLATION OF REFUEL AND DEFUEL AMM 28-25-41

COUPLING LANYARD.

FUEL SAFETY PROCEDURES. AMM 28-00-00-910-001

24/02/15 MPD TASK DISCARD O RINGS ON PYLON AMM 28-20-00-960-001-A

ENGINE FUEL FEED PIPE CONNECTORS
AND REPLACE BY NEW O RING.

VISUAL CHECK TO ENSURE NIL FUEL AMM 28-20-00-960-001-A.

LEAKS.

02/01/15 MPD TASK OPERATIONAL CHECK OF LP AMM 28-24-00-790-003-A

SHUT OFF VALVES AND THEIR CONTROLS
TO ENSURE NO FLOW WHEN SELECTED
CLOSED WITH WITH BOOSTER PUMP ON.

30/08/15 MPD TASK OPERATIONAL CHECK OF FUEL AMM 28-16-00-710-002-A

RECIRCULATION CHECK VALVE TO
ENSURE VALVE NOT FAILED OPEN.

LEAK TEST OF FUEL RETURN VALVE. AMM 73-11-50-360-002

27/12/15 RESECURING WATER DRAIN VALVE TO AMM 28-11-41

CLOSED POSITION DUE TO INSPECTION
FOUND LH WING #1 WATER DRAIN VALVE
NOT PROPERLY CLOSED, CAUSING SIGN
ON FUEL LEAK.
 LEAK TEST BY EXAMINING WATER DRAIN
VALVE AND BOTTOM SKIN JOINT.

19/08/16 FUEL TRANSFER TO EQUALIZE FUEL ON AMM 28-25-00-869-001-A

BOTH TANKS.
ATA CHAPTER 29
DATE TASK DESCRIPTION REFERENCE

11/06/13 MPD TASK 291000-14 CHECK NITROGEN AMM 29-10-00-200-008-A

CHARGE PRESSURE ON HYDRAULIC
POWER ACCUMULATORS.

11/06/14 MPD TASK OPS CHK OF PTU INHIBITION AMM 29-23-00-710-006-A

LOGIC.

14/01/15 ENG #2 PUMP CASE DRAIN FILTER AMM 29-13-43-610-041-A

SERVICING AFTER PUMP REPLACEMENT.

OPS TEST, LEAK CHECK. AMM 29-13-43-710-054-A

20/04/15 REPLACEMENT OF BLUE HYDRAULIC AMM 29-12-22

ACCUMULATOR CHARGING VALVE.

07/05/15 MPD TASK FUNCTIONAL CHECK OF AMM 29-10-00-720-002-A

PRIORITY VALVES.

15/01/16 REPLACEMENT OF ENG #1 HYDRAULIC AMM 29-14-49

RESERVOIR PRESSURIZATION HOSE.

FUNCTIONAL TEST OF THE RESERVOIR AMM 29-14-00-720-002-A

PRESSURIZATION SYSTEM.

08/10/16 CHECK OF BLUE RESERVOIR HYDRAULIC AMM 29-31-00-040-001-A

QUANTITY THRU MECHANICAL
INDICATOR AS REQUIRED BY MEL
29-07-05A DEACTIVATION OF RESERVOIR
HYD QTY IN ECAM.
ATA CHAPTER 30
DATE TASK DESCRIPTION REFERENCE

01/11/12 REPLACEMENT OF RAIN REPELLENT FLUID AMM 30-45-43

GAGE ASSY DUE TO RAIN REPELLENT
FLUID LEVEL LOW.
 FUNCTIONAL TEST OF RAIN REPELLENT AMM 30-45-00-720-002-A
SYSTEM

01/12/13 REPLACEMENT OF LHS RAIN REPELLENT AMM 30-45-41

SOLENOID VALVE DUE TO RAIN
REPELLENT UNSERVICEABLE.

FUNCTIONAL TEST OF RAIN REPELLENT AMM 30-45-00-720-002-A

SYSTEM.

01/10/14 REPLACEMENT OF LH WING ANTI ICE AMM 30-11-51

CONTROL VALVE. DUE TO AIR LEAK.

OPS TEST OF WING ICE PROTECTION AMM 30-11-00-710-001

SYSTEM.

09/03/15 MPD TASK FUNCTIONAL CHECK OF THE AMM 30-31-00-720-001-A

INSULATION RESISTANCE OF THE PITOT
PROBE HEATER.

18/02/16 RESET OF WINDOW HEAT COMPUTER #1 AMM 30-42-00-710-001-A

SYSTEM CIRCUIT BREAKER X13 AND
WINDOW LEFT CIRCUIT BREAKER X14 DUE
TO ECAM MESSAGE ANTI ICE: L WINDOW
INOP.

OPS CHK OF WINDSHIELD ANTI ICING AND

DEFOGGING.
ATA CHAPTER 31
DATE TASK DESCRIPTION REFERENCE

26/11/12 REPLACEMENT OF COMPACT FLASH CARD AMM 31-36-00

ON FLIGHT DATA INTERFACE AND
MANAGEMENT UNIT (FDIMU)

12/05/14 MPD TASK OPS CHECK OF CORRECT AMM 31-60-00-710-005-A

OPERATION OF EFIS AND ECAM DMC
AUTOMATIC AND MANUAL TRANSFER.

16/05/14 REPLACEMENT OF DISPLAY MANAGEMENT AMM 31-63-34

COMPUTER DMC #2.

SOFTWARE CROSS LOADING. AMM 31-60-00-610-003

OPS TEST OF EIS. AMM 31-60-00-710-001

12/06/14 PIN PROGRAMMING OF CFDIU CODING ASM 31-34-03
PLUG IN ORDER TO CHANGE THE FDIU
REPORT HEADER TO THE CORRECT
IDENTIFICATION AFTER A CHANGE OF
AIRCRAFT REGISTRATION.

PRIOR TO PIN PROGRAMMING, PRINT OUT AMM 31-36-00-740-015

OF ENGINE HOURS AND CYCLES STORED IN
FDIMU.

POST PIN PROGRAMMING, CHK OF AMM 31-32-00-860-008

CORRECT AIRCRAFT CODING.

17/01/15 REPLACEMENT OF FLIGHT WARNING AMM 31-53-34

COMPUTER NO 1 DUE TO ECAM 1 AND 2
GROUND SCANNING FAILURE MESSAGE:
FWC 1 : NO DATA FROM FMGC 1 /FGC
22-83-34
AMM 31-50-00-710-001
GROUND SCANNING OF CENTRAL
WARNING SYSTEM.

03/06/16 RE-RACK OF FLIGHT DATA INTERFACE AMM 31-36-34

MANAGEMENT UNIT FDIMU DUE TO
RECORDER SYSTEM FAULT.

TROUBLESHOOTING OF RECORDER SYS TSM 31-36-00-810-898-A

FAULT.

TEST OF FDIMU. AMM 31-36-00-740-012

ATA CHAPTER 32
DATE TASK DESCRIPTION REFERENCE

15/12/11 INSPECTION/ CHK OF WHEELS AND TIRES AMM 32-41-00-210-002-A

DURING TRANSIT CHECK.

03/05/12 TYRE REPLACEMENT DUE TO TYRE AMM 32-41-20

 PRESSURE LEAKAGE.

07/05/12 REPLACEMENT OF PARKING BRAKE AMM 32-42-70

PRESSURE SWITCH.

07/05/12 BRAKE BLEEDING AFTER REPLACEMENT AMM 32-42-10

OF PARKING BRAKE PRESSURE SWITCH.

11/05/12 LUBRICATION OF LANDING GEARS AS AMM 32-00-00-640

REQUIRED IN INSPECTION DOC 6

05/01/13 TROUBLESHOOTING STEERING DEVIATION TSM 32-51-00-810-823-A

DURING TAXI.

REPLACEMENT OF STEERING SERVO AMM 32-51-51

VALVE AS SUGGESTED BY TSM.

FUNCTIONAL TEST OF THE NOSEWHEEL AMM 32-51-00-720-003-A

STEERING.

21/01/13 TROUBLESHOOT BRAKE FAN #2 TSM 32-48-00-810-801-A

INOPERATIVE.

REPLACEMENT OF LH MAIN LANDING AMM 32-11-43

GEAR 2M HARNESS. ASM 32-48-01

OPS TEST OF BRAKE FAN. AMM 32-48-00-860-055-A

09/08/13 TROUBLESHOOTING INCORRECT TSM 32-47-00-810-817-A

TEMPERATURE INDICATION OF THE BRAKE
#2.

CLEANING OF BRAKE TEMPERATURE AMM 32-47-00-740-078-A

SENSOR.
INSPECTION OF BRAKE TEMPERATURE AMM 32-47-18
MONITORING SYSTEM.

RESET OF BSCU WITH ANTISKID AND NOSE AMM 32-47-00-740-078-A

WHEEL SWITCH.

OPS TEST OF THE BRAKE TEMPERATURE AMM

SYSTEM. 32-47-00-710-001-A.

27/10/13 TROUBLESHOOTING ECAM MESSAGE TSM 32-42-00-810-815-A

BRAKE RELEASED.
 REPLACEMENT OF NO 4 TACHOMETER. AMM 32-42-57

FUNCTIONAL TEST OF TACHOMETER. AMM 32-42-00-720-003

02/08/14 INSTALLATION OF RHS MLG TRANSFER AMM 32-11-12-400-001-A

BLOCK AND HYDRAULIC DRESSING.

02/08/14 FUNCTIONAL TEST OF NORMAL BRAKING AMM 32-42-00-710-001-A

SYSTEM AND ALTERNATE BRAKING AMM 32-43-00-710-001-A
SYSTEM
AFTER REPLACEMENT OF RH MLG MANUAL
TRANSFER BLOCK.

02/08/14 RE-INSTALLATION OF RH MLG SECONDARY AMM 32-12-13-400-002-A

HINGE DOOR AFTER INSTALLATION OF
MANUAL TRANSFER BLOCK.

25/08/14 TROUBLESHOOTING LH MLG DOES NOT TSM 32-31-00-810-866-A

UPLOCK.

CHECK OF LH MLG UPLOCK ASSY, TSM 32-31-00-810-846-A

PROXIMITY SENSORS AND TARGETS.

DETAILED DIMENSION CHECK OF AMM 32-11-00-220-003

LOCKSTAY ASSY.

FUNCTIONAL TEST OF NORMAL EXTENSION AMM 32-31-00-720-002

AND RETRACTION OF LANDING GEAR.

29/08/14 TROUBLESHOOTING VIBRATION FELT TSM 321-20-00-810-803-A

DURING CLIMB BECAUSE OF INCORRECT
CLEARANCE OF NLG AFT DOOR.

CHECK OF AFT NOSE GEAR DOOR GAP. AMM 32-22-00-220-002-A

12/09/14 NLG PROXIMITY SENSOR 24GA AND 25GA AMM 32-31-73-200-002-A

DIMENSION CHECK.

BITE TEST OF NLG. AMM 32-69-00-740-001

12/09/14 RHS MLG PROXIMITY SENSOR 22GA AMM 32-31-73-820-002-A

DIMENSION CHECK.

BITE TEST OF LANDING GEAR. AMM 32-69-00-740-001

03/10/14 REMOVAL OF LH COMPLETE SIDESTAY AS AMM 32-11-16-000-001-A

 ITS DUE FOR OVERHAUL.

05/10/14 INSTALLATION OF LH COMPLETE AMM 32-11-16-400-001-A

SIDESTAY.
AMM 32-31-00-720-002
FUNCTIONAL TEST OF NORMAL EXTENSION
AND RETRACTION OF LANDING GEAR.
AMM 32-33-00-720-001
FUNCTIONAL TEST OF FREE FALL
EXTENSION.

05/10/14 REPLACEMENT OF LH MLG RETRACTION AMM 32-31-46.

ACTUATOR DUE FOR OVERHAUL.

FUNCTIONAL TEST OF NORMAL EXTENSION AMM 32-31-00-720-002

AND RETRACTION OF LANDING GEAR.

05/10/14 REPLACEMENT OF LH MLG REAR PINTLE AMM 32-11-11

PIN DUE FOR OVERHAUL.

FUNCTIONAL TEST OF NORMAL EXTENSION AMM 32-31-00-720-002

AND RETRACTION OF LANDING GEAR.

05/10/14 REPLACEMENT OF LH MLG LEG ASSEMBLY AMM 32-11-11

AND MLG HYDRAULIC DRESSINGS DUE FOR AMM 32-11-12
OVERHAUL.

FUNCTIONAL TEST OF NORMAL EXTENSION AMM 32-31-00-720-002

AND RETRACTION OF LANDING GEAR.

23/10/14 REPLACEMENT OF MAIN LANDING GEAR AMM 32-31-35

DOOR ACTUATING CYLINDER.

FUNCTIONAL TEST OF DOOR ACTUATING AMM 32-31-35-710-051-A

CYLINDER

05/11/14 INSPECTION OF RH LG DOOR ACTUATOR AMM 32-31-35

FITTING ON KEEL BEAM FOR EARLY
DETECTION OF CRACKS IN THE ACTUATOR SB A320-53-1195
FITTING ON THE KEEL BEAM.
05/11/14 INSPECTION OF LH LG DOOR ACTUATOR AMM 32-31-35
FITTING ON KEEL BEAM FOR EARLY
DETECTION OF CRACKS IN THE ACTUATOR SB A320-53-1195
FITTING ON THE KEEL BEAM.

14/11/14 INSPECTION OF NLG PROXIMITY SENSORS AMM 32-31-73-200-002

AND TARGET CLEARANCES AFTER NLG
OLEO SERVICING.

14/11/14 TROUBLESHOOT NLG SHOCK ABSORBER TSM 32-31-00-810-876A

FAULT.

14/11/14 PERFORM INDUCTANCE CHECK OF AMM 32-31-73-820-008-A

PROXIMITY SENSORS 24GA AND 25GA DUE
TO NLG SHOCK ABSORBER FAULT.

BITE TEST OF LANDING GEAR. AMM 32-31-71-400-001-A

01/12/14 REPLACEMENT OF BRAKE ASSY #4 DUE TO AMM 32-42-27.

FOUND LEAK AT SELF SEALING COUPLING.

BLEEDING PROCEDURE OF THE NORMAL AMM 32-42-00-870-001

BRAKING AT THE BRAKE UNITS.

BLEEDING PROCEDURE OF THE HIGH AMM 32-43-00-870-002

PRESSURE ALTERNATE BRAKING SYSTEM.

OPERATIONAL TEST OF BRAKE SYSTEM.. AMM 32-42-27-710-050-A

05/12/14 REPLACEMENT OF NLG RETRACTION AMM 32-31-22

ACTUATING CYLINDER.

TEST OF NLG NORMAL EXTENSION AND AMM 32-31-00-720-003

RETRACTION.

30/01/15 INSTALLATION OF CHECK VALVE AT AMM 32-44-17-400-001-A

BRAKE MANIFOLD.

17/03/15 INSTALLATION OF REDUCER ON NLG DOOR AMM 32-31-15-400-001

GROUND OPENING BYPASS VALVE.

OPS TEST OF NLG DOOR. AMM 32-31-00-710-002

20/03/15 REPAIR OF PITTING CORROSION ON LH RDAS/M-DG/00138299/20

MLG MAIN FITTING INNER BORE AT 4 15
 O’CLOCK AND 8 O’CLOCK DIRECTION.

BLENDING OF PITTING CORROSION. SRM 51-74-00

28/06/15 REMOVAL OF NLG AFT DOOR ASSY. AMM 32-22-13-000-001-A

28/06/15 INSTALLATION OF NLG AFT DOOR ASSY. AMM 32-22-13-400-001-A

TEST OF NLG NORMAL EXTENSION AND AMM 32-31-00-720-003

RETRACTION.

08/09/15 ADJUSTMENT OF PLAY OF TORQUE LINK AMM 32-31-00-200-804-A

BY REPLACING EXISTING WASHER WITH
BIGGER WASHER.

15/09/15 ADJUSTMENT OF FREE FALL MECHANISM AMM 32-33-00-820-001.

CABLE TENSION.

10/07/15 REPLACEMENT OF MLG SHOCK ABSORBER AMM 32-11-13

GLAND SEALS DUE TO ACTIVATION OF
SECONDARY SEAL TO STOP LEAK.

11/10/15 FUNCTIONAL CHECK OF FREE FALL AMM 32-33-00-720-001-A

EXTENSION AFTER THE COMPLETION OF
ADJUSTMENT OF FREE FALL MECHANISM
CABLE TENSION.

15/10/15 TRANSFER OF NLG NOSE WHEEL STEERING AMM 32-51-51-000-001-A

SERVO CONTROL DURING NLG AMM 32-51-51-400-001-A
REPLACEMENT.

FUNCTIONAL TEST OF NOSE WHEEL AMM 32-51-00-720-003-A

STEERING.

29/08/16 TROUBLESHOOT ECAM MESSAGE BRAKE TSM 32-43-00-810-822-A

FAN ALTN FAULT.

BITE TEST OF BSCU (GROUND SCANNING). AMM 32-46-00-740-002

OPERATIONAL CHECK OF ALTERNATE AMM 32-43-00-710-001-A

BRAKING SYSTEM.
06/09/16 REPLACEMENT OF MAIN WHEEL #3 AND #4 AMM 32-41-11
DUE TO DEFLATION.

PRESSURE OF INSTALLED TIRES CHECKED. AMM 32-41-00-210-003

FUNCTIONAL TEST OF BRAKE FANS AMM 32-48-00-720-001

ATA CHAPTER 33
DATE TASK DESCRIPTION REFERENCE

24/06/12 REMOVAL OF EMERGENCY LIGHTING AMM 33-50-10

BATTERY PACKS DUE TO EXPIRY OF
BATTERY PACKS.

19/10/13 REPLACEMENT OF BTM, BEACON LIGHT AMM 33-48-37

POWER SUPPLY UNIT.

OPS TEST OF LOWER BEACON LIGHT. AMM 33-48-12-700-001

20/10/13 REPLACEMENT OF F/O SIDE DOME LIGHT. AMM 33-12-11

OPS TEST OF DOME LIGHT. AMM 33-12-00-710-001

20/10/13 REPLACEMENT OF THE RHS WING AND AMM 33-49-11

ENGINE SCAN LIGHT ASSEMBLY.

OPS CHECK OF WING AND ENGINE SCAN AMM 33-49-00-710-001

LIGHT.

21/10/13 REPLACEMENT OF THE RHS LOGO LIGHT. AMM 33-47-11

OPS CHECK OF RHS LOGO LIGHT. AMM 33-47-00-710-002

06/06/14 REMOVAL OF EMERGENCY POWER AMM 33-51-38-000-001-A

SUPPLY UNIT.

21/10/14 INSTALLATION OF CAPT AND F/O SIDE AMM 33-12-00

READING LIGHT KNOB DUE TO REPORTED
MISSING.

OPS TEST OF MAIN INSTRUMENT PANEL AMM 33-12-00-710-001

LIGHT.

15/12/14 REPLACEMENT OF AFT CARGO LIGHT AMM 33-34-11

COVER ASY DUE TO CRACKED.

OPS CHECK OF AFT CARGO AMM 33-34-00-710-001-A

COMPARTMENT LIGHTING.

06/06/16 TROUBLESHOOTING OF DEFECT LH TSM 33-42-00-810-801-A

LANDING LIGHT NOT ILLUMINATING.
REPLACE THE LDG LIGHT SWITCH AS AMM 33-42-00
SUGGESTED BY TSM. ESPM 20-45-21

OPS TEST OF THE LANDING LIGHT. AMM 33-42-00-710-001

ATA CHAPTER 34
DATE TASK DESCRIPTION REFERENCE

04/04/12 NAVIGATION DATA AND CHART DATA AMM 34-23-10

LOADING.

08/05/12 NAVIGATION DATA AND CHART DATA AMM 34-23-10

LOADING.

22/05/12 REPLACEMENT OF STANDBY FLIGHT AMM 34-22-00

DISPLAY DUE TO FAULTY.

25/05/12 ADJUSTMENT /TEST OF ADF TO AMM 34-51-00

TROUBLESHOOT ADF FAILURE.

26/06/12 EPIC SOFTWARE LOADING DUE TO EXPIRY AMM 34-23-10

OF NAVIGATION AND CHART DATA BASES.

16/08/12 REPLACEMENT OF NAVIGATION AMM 34-61-04

COMPUTER UNIT DUE TO DEFECTIVE.

16/08/12 REPLACEMENT OF SOLID STATE DATA AMM 34-61-04

TRANSFER UNIT TO TROUBLESHOOT THE
CAUSE OF FAILURE TO LOAD NAVIGATION
DATA INTO DATA BANK #2.

18/09/13 REPLACEMENT OF INTEGRATED STANDBY AMM 34-22-25

INSTRUMENT SYSTEM ISIS INDICATOR DUE
TO PERMANENT GREEN LINE.

OPS TEST OF ISIS INDICATOR. AMM 34-22-25-710-050-A

BITE TEST OF ISIS INDICATOR. AMM 34-22-25-740-001

03/04/14 MPD TASK FLUSHING OF TOTAL AIR DATA AMM

PRESSURE LINES. 34-10-100-170-001-A
25/04/14 REMOVAL OF TCAS ANTENNA. AMM 34-43-11-000-004-A

25/04/14 INSTALLATION OF TCAS ANTENNA. AMM 34-43-11-400-004-A

BITE TEST OF T2CAS. AMM 34-43-00-740-004.

10/06/14 REPLACEMENT OF CAPT PITOT PROBE DUE AMM 24-11-15

TO OUT OF LIMIT INSULATION RESISTANCE
VALUE.

OPS TEST OF PROBE ICE PROTECTION. AMM 30-31-0-710-001

01/07/14 MPD TASK FUNCTIONAL CHECK OF ATC AMM 34-52-00-710-003-A

ANTENNA USING IFR 6000.

01/07/14 MPD TASK OPS CHK OF THE OVERSPEED AMM 34-13-00-710-007-A

WARNINGS IN THE SLATS/FLAPS AND
LANDING GEAR EXTENDED
CONFIGURATION USING CFDS.

02/07/14 MPD TASK OPS CHK OF AIR DATA AMM 34-13-00-710-001-A

SWITCHING FUNCTION.

09/10/14 FUNCTIONAL TEST OF AIR DATA MODULE AMM 34-13-00-720-001-A

ACCURACY AFTER ADM REPLACEMENT
DUE TO ALTIMETRY SYS ERROR.

09/10/14 FUNCTIONAL TEST OF THE ALTITUDE AND AMM 34-13-00-720-009-B

AIRSPEED DATA (AIRCRAFT WITH RVSM
CAPABILITY ON THREE ADIRUs) AFTER
REPLACEMENT DUE TO ALTIMETRY SYS
ERROR.

POST TEST ENSURE PITOT DRAIN HOLES AMM 34-13-00-080-052-A

ARE OPERATIONAL AND AOA SENSORS
MOVE FREELY.

23/08/15 REPLACEMENT OF STANDBY COMPASS. AMM 34-22-23

OPS TEST OF INSTRUMENT AND PANEL AMM 33-13-00-710-001-A

INTEGRAL LIGHTING

23/08/15 COMPENSATION ADJUSTMENT/TEST OF AMM 34-22-00-730-001-A

THE STANDBY COMPASS AFTER THE
REPLACEMENT OF STANDBY COMPASS.
(COMPASS SWING)
29/05/16 ASSESSMENT OF THE LEVEL OF AM FIGURE
PERFORMANCE OF AN INERTIAL SYSTEM 34-14-00-22800-05-A/SHE
BASED ON CAPTAIN REPORTED IRS DRIFT ET 1/1
AGAINST AMM FIGURE.

08/09/16 OPS CHK OF ELECTRICAL FLIGHT CONTROL AMM 27-96-00-740-001-A

SYSTEM EFCS BY BITE (GROUND
SCANNING), FAULTED RADIO ALTIMETER
#2.
AMM 34-72-00-740-002-A
BITE TEST OF RA #2.
ATA CHAPTER 35
DATE TASK DESCRIPTION REFERENCE

17/05/14 REPLACEMENT OF F/O SIDE FULL AMM 35-12-41-000-002-A

FACE/QUICK DONNING OXYGEN MASK AMM 35-12-41-400-002-A
DUE TO RO LEAKING.

OPS TEST OF FULL FACE/QUICK DONNING AMM 35-12-41-710-001

OXYGEN MASKS.

04/09/14 REPLACEMENT OF CREW OXYGEN AMM 35-11-41

STORAGE CYLINDER AND VALVE ASSY
DUE TO CREW OXYGEN REG LO PR.

LEAK TEST. AMM 35-11-41-790-050-A

OPS TEST OF CREW OXYGEN AMM 35-12-00-710-001

DISTRIBUTION.

SAFETY PRECAUTION WHEN WORKING AMM 35-00-00-860-001

ON OXYGEN SYSTEM.

08/03/15 MPD TASK OPS CHECK OF LP SOLENOID AMM 35-12-00-710-001-A

VALVE CONTROL (CLOSING MODE) AND
LP INDICATION OF FLT CREW OXYGEN
SYSTEM.

20-03/15 REPLACEMENT OF EMERGENCY OXYGEN AMM 35-12-41

CONTAINER AT ROW 11 ABC, 8 DEF, 22
DEF AND 14 DEF DUE TO FAILED
 OPERATIONAL CHECK OF MANUAL
RELEASE.

OPS CHK OF MANUAL MASK RELEASE. AMM 35-23-00-710-001-A

28/09/15 REPLACEMENT OF PROTECTIVE AMM 35-32-52

BREATHING EQUIPMENT (SMOKE HOODS)
DUE TO EXPIRED.

ATA CHAPTER 36
DATE TASK DESCRIPTION REFERENCE

26/06/12 BLEED AIR FLEXIBLE CONNECTOR AMM 36-10-00-220

DETAILED INSPECTION AS REQUIRED IN
INSPECTION PHASE 5.
01/11/12 REMOVAL OF SENSE LINE BETWEEN AMM 36-11-49-000-026
PRESSURE REGULATOR VALVE AND
PYLON INTERFACE.
PLUGS TO BE INSTALLED AT THE
DISCONNECTED ENDS, AND CORRECTLY
TORQUED.

LEAK CHECK OF THE BLEED PRESSURE AMM 36-11-52-790-001

REGULATOR VALVE.

06/10/14 TRANSFER OF BLEED PRESSURE AMM 36-11-52-000-042-A

REGULATOR VALVE DURING ENGINE AMM 36-11-52-400-042-A
CHANGE.

LEAK CHECK OF THE BLEED PRESSURE AMM 36-11-52-790-001

REGULATOR VALVE.

06/10/14 TRANSFER OF HIGH PRESSURE BLEED AMM 36-11-51-000-042-A

VALVE DURING ENGINE CHANGE. AMM 36-11-51-400-042-A

OPS TEST OF HP BLEED VALVE. AMM 36-11-51-720-053-A

26/11/14 REMOVAL OF THERMOSTAT FILTER FOR AMM 36-11-43-000-003-A

CLEANING.

INSTALLATION OF THERMOSTAT FILTER AMM 36-11-43-400-003-A

AFTER CLEANING.

16/07/15 REPLACEMENT OF APU BLEED DUCT DUE AMM 36-12-41

TO INSPECTION FOUND HEAT SHIELD OF
PNEUMATIC DUCT CORRODED.

LEAK TEST OF APU BLEED AIR SYSTEM. AMM 36-12-41-410-051-C

25/07/15 TROUBLESHOOTING MAINT STATUS AIR TSM 36-00-00-810-802-A

BLEED.

BITE TEST OF BLEED MONITORING AMM 36-11-00-740-001-A

COMPUTER.

10/12/15 REPLACEMENT OF O RING ON BLEED AMM 36-11-55

PRESSURE REGULATOR VALVE CONTROL
SOLENOID DUE TO AIR LEAK.

REPLACEMENT OF O RING ON LHS FAN AIR AMM 36-11-43

 VALVE CONTROL THERMOSTAT DUE TO
AIR LEAK.

FUNCTIONAL TEST OF BLEED PRESSURE AMM 36-11-55-720-001

REGULATOR VALVE CONTROL SOLENOID.

01/01/16 REPLACEMENT OF OVER PRESSURE VALVE AMM 36-11-53.

DUE TO TEST PORT BLANKING PLUG
SEIZED.

TEST OF OVER PRESSURE VALVE. AMM 36-11-53-710-050-A

ATA CHAPTER 38
DATE TASK DESCRIPTION REFERENCE

07/07/13 INSPECTION OF CONTROL LEVER UNIT AMM 38-31-73

DUE TO TOILET SERVICE DRAIN VALVE
NOT FUNCTIONING.

ROD ASSY REPLACED. AMM 38-31-73

POST INSTALLATION INSPECTION. AMM 38-31-73-210-050-A

28/06/13 OPERATIONAL TEST OF LAVATORY A AMM 38-31-00-710-002-A

VACUUM SYSTEM.

BITE TEST OF VACUUM TOILET SYSTEM. AMM 38-31-00-740-001-A

11/10/13 REPLACEMENT OF DRAIN VALVE (AIR AMM 38-32-41

STOP VALVE) IN LAVATORY E DUE TO
WATER LEAKING.

OPS TEST OF WASTE/WATER DRAIN AMM 38-32-00-710-002

SYSTEM.

16/01/15 MPD TASK 383100-07 CORRECTIVE AMM 38-31-00-100-004-A

VACUUM WASTE LINE CLEANING.

LEAK TEST OF VACUUM SYSTEM. AMM 38-31-00-790-002

OPS TEST OF TOILET ASSEMBLIES. AMM 38-31-00-710-009

03/02/15 REPLACEMENT OF TOILET ASSY AT AMM 38-31-41

LAVATORY A.

OPERATION OF TOILET TO ENSURE AMM 38-31-00-710-009

CORRECT FLUSHING.
 LEAK TEST OF VACUUM SYSTEM. AMM 38-31-00-790-002

16/04/15 MPD TASK DISINFECTION OF WATER AMM 38-10-00-670-006-A

TANK AND DISTRIBUTION SYSTEM.
INSTALLATION OF NEW GALLEY FILTERS. AMM 38-12-23.

06/09/15 REPLACEMENT OF AIR SUPPLY BOOST AMM 38-42-00

SYSTEM COMPRESSOR INLET FILTER.

05/11/15 REPLACEMENT OF PORTABLE WATER AIR AMM 38-42-51

SUPPLY COMPRESSOR DUE TO CIRCUIT
BREAKER TRIPPED.

OPS TEST OF THE COMPRESSOR. AMM 38-42-00

ATA CHAPTER 46
DATE TASK DESCRIPTION REFERENCE.

16/02/15 REPLACEMENT OF AIR TRAFFIC SERVICE AMM 46-21-34

UNIT ATSU DUE TO COMPANY DATA LINK
FAULT AND CO, VHF #3 DATA FAULT.

UPLOADING OF ATSU SOFTWARE. AMM 46-21-00-610-001-C

INITIALIZATION PROCEDURE OF ATSU AMM 46-21-00-860-001-A

ROUTER.

VHF #3 LINK TEST OF ATSU. AMM 46-21-00-710-002-A

BITE TEST OF ATIMS (AIR TRAFFIC AND AMM 46-21-00-740-001-A

INFO MANAGEMENT SYSTEM).

05/07/16 RESET OF ATSU CB L16 AND L15 DUE TO AMM 46-21-00-740-001-A

ATSU FLT LOG NOT LOGGING TIMINGS,

BITE TEST OF ATIMS.

BITE TEST OF CENTRALIZED FAULT AMM 31-32-00-740-002-A

DISPLAY INTERFACE UNIT.
ATA CHAPTER 47
DATE TASK DESCRIPTION REFERENCE

18/02/16 BITE TEST OF THE INERT GAS AMM 47-31-34-740-001-A

GENERATION SYSTEM IGGS WITH BLEED
AIR DUE TO FUEL: INERT SYS FAULT.
ATA CHAPTER 49
DATE TASK DESCRIPTION REFERENCE
24/10/11 CHECK OF APU OIL LEVEL AMM 49-90-00-600-007-A

31/07/13 REPLACEMENT OF APU IGNITER PLUG. AMM 49-41-41

OPS TEST OF THE APU. AMM 49-00-00-710-010

31/07/13 REPLACEMENT OF FUEL CONTROL UNIT. AMM 49-32-11

PURGING OF FUEL LINE. AMM 28-22-00-710-001

OPS TEST OF THE APU. AMM 49-00-00-710-010

22/12/14 REPLACEMENT OF INLET GUIDE VANE TSM 49-00-81-810-891-A

ACTUATOR DUE TO NEGATIVE RESULT OF AMM 49-23-51
PUSH PULL TEST.

OPS TEST OF THE APU. AMM 49-00-00-710-010

22/12/14 REPLACEMENT OF FUEL FLOW DIVIDER AMM 49-32-13

AND SOLENOID VALVE TO RECTIFY ENGINE
IGNITION FAULT DUE TO LO START AIR
PRESSURE FROM APU.

OPS TEST OF THE APU. AMM 49-00-00-710-010

18/01/15 TROUBLESHOOTING APU AUTO TSM 49-00-81-810-825-A

SHUTDOWN.
MAINT MESSAGE: NO FLAME IGNITION
UNIT (8030KM) ASSOCIATED WITH FAULT
CODE (FCN) 146,

WIRING CHECK FROM ECB TO IGNITION ASM 49-61-04

UNIT.

REPLACEMENT OF IGNITION UNIT. AMM 49-41-38

OPS TEST OF THE APU. AMM 49-00-00-710-010

24/05/15 REPLACEMENT OF APU 131-9(A) DUE TO OIL AMM 49-11-11

LEAKAGE AT LOAD COMPRESSOR SEAL.

TEST OF ECB. AMM 49-00-00-710-009-A

 BLEEDING OF FUEL LINE. AMM 28-22-00-710-001.

VISUAL INSPECTION OF APU AIR INTAKE AMM 49-16-00-200-002

SYSTEM.

OPS TEST OF THE APU. AMM 49-00-00-710-010

19/07/15 TROUBLESHOOTING APU AUTO TSM 49-00-81-810-849-A

SHUTDOWN.
MAINT MESSAGE: CLOGGED OIL FILTER
AND GEN SCAV + LUBE FILTER.

REPLACEMENT OF OIL FILTERS. AMM 49-00-00-860-008

RECHECK FILTER ELEMENTS. AMM 49-91-41-200-002

30/09/15 REPLACEMENT OF BELLOW LOCATED AT AMM 49-81-41

APU EXHAUST MUFFLER DUE TO FOUND
TORN.
ATA CHAPTER 51
DATE TASK DESCRIPTION REFERENCE

06/08/14 PAINT STRIP OF DENT BELOW CARGO SRM 51-75-11.

DOOR BETWEEN FR 60-62, STGR 36R TO 37L.

11/08/14 DETAILED VISUAL INSPECTION ON SRM 51-90-00

SURROUNDING STRUCTURE AFTER SKIN
CUT OUT ON FR60-61 TO INSPECT ANY
SIGNS OF FURTHER DAMAGES.

15/08/14 SURFACE REPROTECTION OF REPAIRED SRM 51-75-12

AREA FR 61-62 STGR 39RH - 41LH.

IDENTIFICATION OF GENERAL PAINT SRM FIGURE 002

SCHEME WITH BASECOAT AND SHEET 1/51-75-12
CLEARCOAT.

23/08/14 FUEL LEAK RECTIFICATION BY CARRY OUT SRM 51-76-12

REPAIR ON LH WING RIB 5 AND RIB 6 WET
BAY AND OUTER DRY BAY DUE TO FUEL
LEAKAGE FOUND INSIDE THE OUTER DRY
 BAY.

REPAIR OF FUEL TANK SEALING C/OUT.

05/02/15 REWORK OF SCRATCHES FOUND AT LHS SRM 51-73-00

REAR FUSELAGE FR 68-69, STGR 18-19.

CHK OF ALLOWABLE REWORK LIMIT AND SRM 53-41-11

CLASSIFICATION OF REPAIR CATEGORY.

IDENTIFICATION OF REPETITIVE SRI 53-41-11-205-001

INSPECTION REQUIRED. IIR 53-41-11-1-002-00

12/02/15 REWORK OF SCRATCH FOUND AT LHS SRM 51-73-00

REAR FUSELAGE FR 66-67, STGR 25-26.

CHECK OF POST REWORK DIMENSION SRM 53-41-11-283-001

AGAINST ALLOWABLE REWOK LIMIT.
CLASSIFICATION OF REPAIR CATEGORY.
IDENTIFICATION OF REPETITIVE SRI 53-41-11-205-008
INSPECTION REQUIRED. IIR 53-41-11-1-007-00

19/03/15 APPLICATION OF ANTI EROSION TAPE ON SRM 51-75-12

VHF ANTENNA.

24/03/15 APPLICATION OF TEMPORARY AMM

PROTECTION SYSTEM TPS AT FWD CARGO 51-78-00-916-001-A
DOOR CUTOUT LOWER STRUCTURAL
AREA.

16/10/15 REPLACEMENT OF NOSE LANDING GEAR SRM 51-72-12

RHS SWIVEL BEARING DUE TO CORROSION.

POST INSTALLATION CHK OF BUSH FIG 002 SHEET 1

INTERFERENCE FIT. 51-72-12

31/12/15 REWORK OF TRIMMABLE HORIZONTAL SRM 51-73-00

STABILISER LHS AND RHS TIP DUE TO
EROSION DAMAGE.

19/01/16 REPLACEMENT OF RHS WING FLAP TRACK SRM 51-42-21

FAIRING NO 3 AFT FIXED FAIRING
INBOARD SEAL AND OUTBOARD SEAL.

30/04/16 CUT OUT REPAIR OF RUDDER SIDE PANEL TD _G2_S2_02665_ 2016

DUE TO MOISTURE INGRESSION. ISSUE A, RDAS REF
 80149425/003/2016

MAKING A PRE-CURED SHEET FOR INNER SRM 51-77-11-911-031

SKIN REPAIR BY WET LAY UP, USING DRY
CARBON FABRIC AND LAMINATING RESIN.

CURING UNDER VACUUM PRESSURE 2H AT SRM 51-77-11-911-031

80 DEGREE CELSIUS.

PREPARATION OF A CYLINDRICAL BLOCK SRM 51-77-11-911-031

MADE FROM LOW DENSITY COMPOUND
MATERIAL, CURED.

CLEANING OF REPAIR AREA. SRM 51-77-11-911-010

REMOVAL OF OUTER SKIN AND INNER SRM 51-77-11-911-018

SKIN AROUND HOIST POINT.

DRYING OF REPAIR AREA AT 60 DEGREE SRM 51-77-11-911-012

CELSIUS FOR AT LEAST 2 HOURS.

WATER BREAK TEST TO ENSURE REPAIR SRM 51-77-11-911-011

AREA GREASE FREE.

PREPARATION OF REPAIR CORE WITH SRM 51-77-11-911-014

ORIGINAL THICKNESS AND HONEYCOMB
CORE PLUG RIBBON DIRECTION ALIGNED
WITH ORIGINAL HONEYCOMB.

REPARATION OF INNER SKIN REPAIR PLY. SRM 51-77-11-911-013

WET LAY UP OF REPAIR PLIES USING SRM 51-77-11-911-019

LAMINATING RESIN.

INSTALLATION OF PREPARED CORE. SRM 51-77-11-911-024

POST CURE INSPECTION. SRM 51-77-11-911-004

TAP TEST PERFORMED TO ENSURE NO NTM 51-10-03

DELAMINATION.

RESTORATION OF SURFACE PROTECTION. SRM 51-75-12

ATA CHAPTER 52
DATE TASK DESCRIPTION REFERENCE

14/03/12 REPLACEMENT OF DOOR STEPS ANTI SKID AMM 52-10-20

PAD.

27/03/12 REPLACEMENT OF DOOR STEPS ANTI SKID AMM 52-10-20

PAD.

02/04/12 REPAIR OF SECONDARY DOOR SEAL. AMM 52-10-01

20/04/12 LUBRICATION OF DOOR LOCKING AMM 52-10-01

MECHANISM DUE TO STIFFNESS.

27/05/12 REPLACEMENT OF BAGGAGE ACCESS AMM 52-30-01

DOOR GAS SPRING EXTENDER.

21/12/12 INSPECTION OF BOTH PORT SIDE AMM 52-21-00

EMERGENCY EXIT HATCHES SEAL.

PRESSURIZATION TEST OF FUSELAGE TO AMM 05-53-00

CONFIRM ANY AIR LEAKAGE FROM
EMERGENCY EXIT HATCHES.

08/08/13 TROUBLESHOOTING: CAPTAIN REPORTED TSM 52-51-00-810-801-A

COCKPIT DOOR ANNUNCIATOR LIGHT ON
CENTRE PEDESTAL INDICATED FAULT.

RESET C/OUT. TSM 52-51-00-810-051-C

OPS TEST OF THE COCKPIT DOOR LOCK AMM 52-51-00-710-002

SYSTEM.

26/11/13 INSPECTION OF FWD DOOR RHS DOOR AMM 52-11-00

SKIN, INTERNAL AND EXTERNAL
STRUCTURE/SURFACE.

VISUAL INSPECTION ON DOOR SEAL. AMM 52-11-18

PRESSURIZATION TEST OF FUSELAGE AT A AMM 05-53-00

DIFFERENTIAL PRESSURE OF 406 PSI.

24/01/14 TROUBLESHOOT DEFECT: DISAGREE TSM 52-11-00-810-804-A.

BETWEEN DOOR/OXY PAGE INDICATION
AND THE LOCKED POSITION OF THE LHS
PAX DOOR.
 ADJUSTMENT OF PROXIMITY SWITCH AMM 52-71-00-820-002-A
13WV1.

TEST. TSM 52-11-00-710-060-A

15/05/14 REPLACEMENT OF PROX SENSOR 13WVI. AMM 52-71-11

OPS TEST OF WARNING SYSTEM. AMM 52-71-00-710-001

10/08/14 REMOVAL OF FWD LH PAX DOOR. AMM 52-11-11-000-001-A

INSTALLATION OF SAFETY BARRIER IN AMM 52-00-00-481-001

THE OPENING OF THE REMOVED DOOR.

11/08/14 INSTALLATION OF LH FWD PAX DOOR. AMM 52-11-11-400-001-A

CHECK AND ADJUSTMENT OF CLEARANCE
BTW ROLLER AND GUIDE FITTINGS,
ADJUSTMENT OF UPPER HOOKS, SAFETY
PIN, DOOR DAMPER, EMERGENCY DOOR
OPERATION CYLINDER.

OPS TEST OF PAX DOOR. AMM 52-71-00-710-001.

10/03/15 REPLACEMENT OF BULK CARGO DOOR AMM 52-33-18

SEAL.

17/07/15 REPLACEMENT OF AFT PAX ENTRANCE AMM 52-13-31-000-007-A

RHS AND LHS GIRT BAR FITTING BLANKET AMM 52-13-31-400-007-A
PLATES DUE TO CORROSION.

15/08/15 ADJUSTMENT OF GROUND SERVICE PANEL AMM 52-42-25-820-050-A

DOOR OF BLUE HYDRAULIC SYSTEM.

CHK CLEARANCE BETWEEN ACCESS DOOR AMM FIGURE

AND PANEL 197BB. 52-42-25-991-00200-00-C/
SHEET 1/1

24/01/16 REPLACEMENT OF COCKPIT DOOR LOWER AMM 52-51-21

LATCH ASSEMBLY.
OPS TEST. AMM 52-51-21-710-050-C

16/02/16 TROUBLESHOOT: D2R SLIDE DISARMED AMM 52-13-22

DURING FLIGHT.
 ADJUSTMENT OF D2R RELEASE
MECHANISM OF THE EMERGENCY ESCAPE
SLIDES.

OPS TEST OF THE EMERGENCY ESCAPE AMM 52-73-00-710-001-A

SLIDE RELEASE SYSTEM OF PAX DOOR.

16/02/16 TROUBLESHOOT: D2R SLIDE DISARMED AMM 52-13-00-820-001-A

DURING FLIGHT.

ADJUSTMENT OF AFT PAX DOOR FOUND

CLEARANCE F1 AND F2 OUT OF LIMIT.

ADJUSTMENT OF ESCAPE SLIDE AND GIRT AMM 52-13-00-820-057-A

BAR FITTINGS.

PRESSURIZATION TEST. AMM 05-53-00

20/03/16 ASSESSMENT OF DENT ON AFT LH PAX SRM 52-10-00-283-003.

DOOR LOCATED AT XPT12 BETWEEN BEAM
2 AND 3.

SKIN THICKNESS, DEPTH, DISTANCE FROM FIGURE 001 SHEET

EDGE MEASUREMENTS C/OUT FOUND 1/52-10-00
DAMAGE WITHIN ALLOWABLE LIMIT.

FIRST INSPECTION IDENTIFIED TO BE SRI 52-10-00

REQUIRED AT 60000 FC/120000 FH. IIR 52-10-00-1-001-00
ATA CHAPTER 53
DATE TASK DESCRIPTION REFERENCE

28/11/1 INSTALLATION OF 3M BOOT ON RADOME AT AMM 53-15-11-400-007-A

3 TIP AREA AFT OF LIGHTNING STRIPS
LEADING EDGE TO REDUCE THE CHANCE OF
EROSION.

27/05/1 REPLACEMENT OF RADOME. AMM 53-15-11

4
CLEARANCE CHECK BETWEEN THE BOLTS AMM
AND SUPPORT FITTINGS. 53-15-11-991-03700-00-A/
SHEET 1/1.
CLEARANCE CHECK BETWEEN RADOME AMM 53-15-11-220-053-A
AND AIRCRAFT STRUCTURE.

18/07/1 REPLACEMENT OF RHS FILLET FAIRING AMM 53-35-11

4 ASSY REPLACEMENT.
 CLEARANCE CHECK BETWEEN FILLET
FAIRING AND FAIRING PANEL 192BT.

APPLICATION OF SEALANT TO FILL

PLUGGED FASTENER HOLES TO ENSURE
SMOOTH SURFACE.

23/12/1 REMOVAL OF RH AFT PASSENGER DOOR AMM 53-43-15-000-001-A

4 SCUFF PLATE.

25/12/1 INSTALLATION OF RH AFT PASSENGER AMM 53-43-15-400-001-A

4 DOOR SCUFF PLATE.

APPLICATION OF VACUUM FOR CORRECT

BONDING OF SCUFF PLATE TO UNDERNEATH
SILL BEAM.

APPLICATION OF SEALANT AROUND THE

EDGE OF SCUFF PLATE FOR AERODYNAMIC
SMOOTHNESS.

18/03/1 REPAIR OF FWD CARGO FLOOR PANEL. SRM 53-02-00 PB201

5 REPAIR 8C
INSTALLATION OF PANEL AFTER REPAIR. AMM53-22-14-400-001-A

12/03/1 REPLACEMENT OF RH WING TO BODY AMM 53-35-11-420-052-B

5 FAIRING SEALING PLATE.

FILLING THE CLEARANCE WITH

POLYSULPHIDE SEALANT FOR SMOOTH
CONTOUR.

19/09/1 REMOVAL OF SCUFF PLATE AT BIL CARGO AMM 53-45-15-000-002-A

5 COMPARTMENT.

14/10/1 INSTALLATION OF SCUFF PLATE AT BIL AMM 53-45-15-400-002-A

5 CARGO COMPARTMENT.

25/10/1 ASSESSMENT OF MULTIPLE DENTS FOUND SRM 53-41-11 PB101

5 AT AFT LH PAX DOOR FR 68-70, STGR PARA 4B
18LH-19LH, FOUND DENTS WITHIN
ALLOWABLE DAMAGE LIMIT.
26/10/1 REWORK OF NICKS AT LOWER FUSELAGE SRM 53-21-11 PB101
5 BELOW FORWARD CARGO DOOR CUTOUT FR PARA 4E.
26-27, STGR 42RH-43RH.

DEPTH OF REWORK AS PERCENTAGE OF

NOMINAL MATERIAL THICKNESS AND
LENGTH OF REWORK WITHIN ALLOWABLE
REWORK LIMIT.

IDENTIFICATION OF RE-INSPECTION SRI-53-21-11-1-003-00

INTERVALS.

20/03/1 ASSESSMENT OF DENT FOUND ON RHS SRM 53-11-11

6 FUSELAGE SKIN AT STA 8966 FR 23-24, STGR
22-23.

MEASUREMENT OF ALLOWABLE DENT IN FIGURE 001 SHEET

SKIN. 1/53-11-11
CLASSIFICATION OF DENTS AS ALLOWABLE DIAGRAM 001 SHEET
DAMAGE, AND FALL UNDER REPAIR CAT C 1/53-11-11

IDENTIFICATION OF NEXT INSPECTION SRI 53-11-11-205-001

REQUIRED. IIR 53-11-11-1-001-00
ATA CHAPTER 54
DATE TASK DESCRIPTION REFERENCE

12/11/14 ASSESSMENT OF BURN MARK AND SRM 54-30-00 REPAIR 13

DELAMINATION FOUND AT ENG #2
THRUST REVERSER 6’O CLOCK POSITION
AFT LOOKING FORWARD AND PERFORM
CAT A PERMANENT REPAIR.

12/05/15 REPLACEMENT OF LOWER AFT PYLON AMM 54-56-00 PB401

FAIRING.

05/09/15 REPLACEMENT OF RHS AFT PYLON AMM 54-56-00

LOWER FAIRING DUE TO CRACK.

POST REPLACEMENT, CHECK OF

CLEARANCE BETWEEN PRIMARY
STRUCTURE AND FAIRING.

07/12/15 DETAILED INSPECTION OF LH AFT PYLON AMM 54-55-00-200-001-A

MOVEABLE FAIRING.
13/01/16 REPLACEMENT OF ENG #1 REAR KEEL AMM 54-56-00
DUE TO CRACK.

02/01/16 REPLACEMENT OF LHS WING AFT FIXED AMM 54-54-00

FAIRING MOUNTING PLATE ASSY DUE TO
FOUND CRACKED.
ATA CHAPTER 55
DATE TASK DESCRIPTION REFERENCE

25/04/12 HORIZONTAL STABILIZER AFT SPAR AMM 55-10-00

ASSEMBLY GENERAL VISUAL INSPECTION
(CORROSION INSPECTION).

03/08/12 HORIZONTAL STABILIZER AFT SPAR AMM 55-10-00

ASSEMBLY GENERAL VISUAL INSPECTION
(CORROSION INSPECTION).

03/08/12 HORIZONTAL VERTICAL AFT SPAR AMM 55-00-00-210

ASSEMBLY GENERAL VISUAL INSPECTION
(CORROSION INSPECTION).

21/11/14 CHECK OF LEFT HAND ELEVATOR AMM 55-26-00-200-002

ATTACHMENT FITTING FOR WEAR TO
TROUBLESHOOT CAUSE OF AIRFRAME
VIBRATION.

21/11/14 CHECK OF LEFT HAND ELEVATOR AMM 55-26-00-200-002

ATTACHMENT FITTING FOR WEAR TO
TROUBLESHOOT CAUSE OF AIRFRAME
VIBRATION.

06/01/15 REMOVAL OF RUDDER TIP FOR STATIC AMM

DISCHARGER RETAINER REPLACEMENT. 55-44-11-000-001-A

DEPRESSURIZE HYDRAULIC SYSTEM AND AMM

PUT INTO MAINT CONFIGURATION PRIOR 29-00-00-864-001-A
TO GROUND MAINTENANCE.

07/01/15 INSTALLATION OF RUDDER TIP UPON AMM

CLEARANCE GRANTED. 55-44-11-400-001-A
ATA CHAPTER 56
DATE TASK DESCRIPTION REFERENCE

27/01/15 REPLACEMENT OF CABIN WINDOW OUTER AMM 56-21-13

PANES DUE TO CRAZING AND SCRATCHES.

CLEANING OF OUTER SURFACE OF THE AMM 56-21-13-100-002

OUTER PANE.

02/01/16 REPAIR OF WINDSHIELD WEATHER SEAL. AMM 56-11-11-300-001-A

REMOVAL OF WIPER ARM PRIOR TO AMM 30-45-52-000-002

REPAIR TO FACILITATE REPAIR.

INSTALLATION OF WIPER ARM AFTER AMM 30-45-52-400-002

REPAIR COMPLETED.

CLEANING OF WINDSHIELD AFTER SEAL AMM 56-10-00-110-001

REPAIR.
ATA CHAPTER 57
DATE TASK DESCRIPTION REFERENCE

03/08/12 AFT WING SPAR ASSEMBLY GENERAL AMM 57-00-00-210

VISUAL INSPECTION (CORROSION
INSPECTION).
23/09/13 INSPECTION OF OUTER WING MAIN AMM 57-00-00
LANDING GEAR SUPPORT RIB 5 FITTING.

02/09/14 INSTALLATION OF OUTER WING ACCESS AMM 57-27-11-400-002-A

PANELS AND REPLACEMENT OF DAMAGED
SEALING RING AFTER FUEL LEAK
RECTIFICATION.

LEAK TEST OF FUEL TANK. AMM 57-27-11-790-051-A

06/12/14 REMOVAL OF RH #4 FLAP TRACK FAIRING AMM 57-55-11-000-001-A

FOR REPAIR.

14/12/14 INSTALLATION OF RH #4 FLAP TRACK AMM 57-55-11-400-001-A

FAIRING AFTER REPAIR.

CHECK OF FLAP TRACK FAIRING LATERAL AMM 57-55-11-200-001-A

MOVEMENT.

OPS TEST OF FLAP SYSTEM. AMM 27-54-00-710-001

27/01/15 REPLACEMENT OF FLAP TRACK FAIRING SRM 57-55-11

SEAL.

14/03/15 REPLACEMENT OF FLAP TRACK FAIRING AMM 57-55-11

CONTROL ROD ASSEMBLY EYE END
BEARING.

19/06/15 REPLACEMENT OF SPECIAL NUT AT MAIN AMM 57-26-13

LANDING GEAR ACTUATOR BEARING
ASSEMBLY.

30/06/15 MPD TASK DETAILED VISUAL INSPECTION AMM 57-41-00-200-005-A

OF THE OUTER WING BOTTOM SKIN LOWER
SURFACE AT FUEL TANK WATER DRAIN
HOLES BETWEEN RIB 15-16 AND RIB 22-23.

06/07/15 MPD TASK DETAILED INSPECTION OF RH AMM 57-26-00-200-006A

OUTER WING, FLAP TRACK BEAM 2,3,4,
FORWARD SPIGOT PINS, BOLTS AND
FITTINGS.

22/10/15 DAMAGE ASSESSMENT OF MULTIPLE SRM 57-52-00 PB201

SMALL DENTS AT RHS WING INBOARD PARAGRAPH 8L
 FLAP LOWER SURFACE ZONE 2 BETWEEN
RIB 1-8.

10/12/15 LHS INBOARD FLAP LOWER SURFACE SKIN SRM 57-52-00

REPAIR - FILL DENT WITH RESIN.

04/05/16 REPAIR OF LH WING SHARKLET UPPER SRM 57-31-23-283-007

SURFACE LIGHTNING STRIKE. PARAGRAPH 2A

IDENTIFICATION OF DAMAGE ZONE. SRM 57-31-223

ADHESIVE TAPE APPLIED TO BOTH SRM 51-77-12-911-001

SURFACES EXTENDING OVER THE
INBOARD TRAILING EDGE PANEL WITH
MINIMUM OF 25mm OVERLAP
SURROUNDING THE DAMAGE.
ATA CHAPTER 61
DATE TASK DESCRIPTION REFERENCE

23/05/16 REPLACEMENT OF PROPELLER BLADE. HAMILTON SUNSTRAND

MM 61-10-00
SETTING PROPELLER TO BETWEEN FLAT
PITCH AND REVERSE RANGE PRIOR TO
REMOVAL AND INSTALLATION.

BLADE SHANK CLEANING WITH MEK,

ASTM D740.

LUBRICATION OF TRUNNION AND BLADE

ROLLER WITH LUBRICATION OIL
MIL-PRF-7808, MIL-PRF-23699.

23/05/16 REPLACEMENT OF PROPELLER BLADE. HAMILTON SUNSTRAND

MM 61-10-00

24/05/16 MPD TASK OPERATIONAL TEST OF AMM JIC

FEATHERING PUMP ACTIVATION BY 612200-OPT-10015
ATPCS LOGIC (ENGINE OFF).

24/05/16 MPD TASK OPERATIONAL TEST OF PEC AMM JIC

NP CANCEL-ACTIVATION (PEC ON 612163-OPT-10030
CONFIGURATION).
ATA CHAPTER 71
DATE TASK DESCRIPTION REFERENCE

30/11/11 VISUAL INSPECTION OF THE ENGINE FAN AMM 71-13-11-200-804-C

COWL DOOR.

30/11/11 VISUAL INSPECTION OF DRAIN MAST AMM 71-71-42-210-041-A

OUTLET.

22/03/12 ENGINE NO 1 COMPRESSOR WASHING DUE AMM 71-00-00

TO ENGINE BIRD STRIKE

05/04/12 HAMNDWASH OF ENGINE FAN BLADES AMM 71-00-00

DUE TO ENGINE BIRD STRIKE.

17/05/12 ENGINE VIBRATION SURVEY USING TEC AMM 71-00-00

MODEL 4040 VIPER ANALYZER.

25/06/12 GENERAL INSPECTION OF ENGINE NO 1 AMM 71-01-02-210

AND ENGINE NO 2

19/0614 REMOVAL OF FAN COWL DOOR AMM 71-13-11-000-041-A

28/0614 INSTALLATION OF FAN COWL DOOR AMM 71-13-11-400-041-A

12/10/14 TRANSFER IDG CONTROL AND ANTI ICE AMM 71-51-43

HARNESS 4215 KS DURING ENGINE
CHANGE.

12/10/14 TRANSFER HARNESS 4216 KS DURING AMM 71-51-43

ENGINE CHANGE.

12/01/15 TRANSFER OF AFT ENGINE MOUNT AMM 71-22-11

DURING ENGINE CHANGE.

13/01/15 TRANSFER OF AFT ENGINE MOUNT AMM 71-21-11

DURING ENGINE CHANGE.

26/02/15 REPLACEMENT OF CLAMP AT LOWER AMM 71-51-43

LEFT FAN ZONE ELECTRICAL HARNESS.
01/09/15 MPD TASK SPECIAL DETAILED AMM 71-22-11-210-803-B
INSPECTION OF RHS AFT ENGINE MOUNT
PYLON BOLTS.

01/09/15 MPD TASK SPECIAL DETAILED AMM 71-22-11-210-803-B

INSPECTION OF RHS FWD ENGINE MOUNT
PYLON BOLTS.

22/11/15 POWER ASSURANCE CHECK OF BOTH AMM 71-00-00-710-008-B

ENGINES AFTER ENGINE CHANGE.

22/11/15 VIBRATION CHECK OF BOTH ENGINES AMM 71-00-00-710-009-B

AFTER ENGINE CHANGE.

22/11/15 ACCELERATION CHECK OF BOTH ENGINES AMM 71-00-00-710-025-A

AFTER ENGINE CHANGE.

29/03/16 REPLACEMENT OF ENGINE DRIVEN PUMP CMM 71-50-03 REPAIR NO

HARNESS ASSY PLUG AND REPAIR OF 7
BACKSHELL.

29/03/16 REPLACEMENT OF BOOT DUE TO ENGINE CMM 71-50-03 REPAIR NO

DRIVEN PUMP HARNESS ASSY PLUG 11
CORRODED.
ATA CHAPTER 72
DATE TASK DESCRIPTION REFERENCE

06/12/11 INSPECTION OF THE FAN ROTOR BLADES AMM 72-21-00-210-009-A

INSTALLED ON THE FAN DISK.

17/05/12 FAN BLADES REMOVAL FOR BLADES AMM 72-30-01

DOVETAIL ROOT LUBRICATION.

16/03/13 MPD TASK DETAILED INSPECTION AND AMM 72-21-00-210-004

RE-LUBRICATION OF FAN BLADES
DOVETAILS, MIDSPAN SHROUDS,
RETAINERS, SPACERS, DAMPERS AND FAN
DISC DOVETAIL SLOTS.

30/08/13 INSPECTION OF FOREIGN OBJECT AMM 72-00-00-200-006-A

DAMAGE DUE TO BIRD STRIKE.
03/10/14 REPLACEMENT OF TRANSFER GEARBOX. AMM 72-62-00-000-002-A

IDLE CHECK. AMM 71-00-00-710-006

LEAK CHECK AT TGB AND TUBES. AMM 79-00-00-210-003

12/12/14 MPD TASK WASHING OF THE ENGINE GAS AMM 72-00-00-100-026-A

PATH WITH PURE WATER.

10/09/15 REPLACEMENT OF ENGINE FAN DUCT AMM 72-23-00

PANEL DUE TO CRACKED.

ATA CHAPTER 73
DATE TASK DESCRIPTION REFERENCE

07/09/12 OPS TEST OF FADEC ON THE GROUND AMM

(WITH ENGINE NON-MOTORING. 73-29-00-710-040-B02.

20/11/15 PROGRAMMING OF THE IDENTIFICATION AMM 73-21-90.

PLUG DUE TO ENGINE CHANGE.

REMOVAL OF IDENT PLUG FROM ECU FOR AMM 73-21-90-000-002

PIN PROGRAMMING.

INSTALLATION OF OF IDENT PLUG AFTER AMM 73-21-90-400-002

PIN PROGRAMMING COMPLETED.

FUNCTIONAL TEST OF ECU. AMM 73-21-60-720-040

READ LRU IDENTIFICATION REPORT. AMM 73-21-60-740-006

TEST TO ENSURE CONFIGURED IDENT

PLUG INPUTS ARE CORRECTLY READ AMM 73-21-90-710-056-A
THROUGH THE ECU AND AGREE WITH THE
APPLICABLE ENGINE CONFIG.

30/03/16 REMOVAL OF SERVO FUEL HEATER. AMM 73-11-20-000-002-A

INSTALLATION OF SERVO FUEL HEATER. AMM 73-11-20-400-002-A

ATA CHAPTER 74
DATE TASK DESCRIPTION REFERENCE

26/06/12 OPERATIONAL CHECK OF ENGINE AMM 74-31-00-210

IGNITORS.
ATA CHAPTER 75
DATE TASK DESCRIPTION REFERENCE

03/01/13 REPLACEMENT OF VARIABLE BLEED AMM 75-31-60

VALVE AND BALL SCREW ACTUATOR
ASSEMBLY.
AMM 75-31-00-200-002
POST INSTALLATION ADJUSTMENT OF VBV
AND BALL SCREW ACTUATOR TO MAKE AMM 75-31-60-820-051-A
SURE VBV ENGAGES IN THE FAN FRAME.
AMM 75-31-00-820-001
SETTING OF VBV DOOR REFERENCED
CLOSED POSITION.
AMM 73-29-00-710-040
MANUAL CHECK OF VBV DOORS.

OPS TEST OF FADEC.

06/02/13 REGREASING OF THE VBV SYSTEM. AMM 75-31-00-640-801-A

REMOVAL AND INSTALLATION OF ALL AMM 72-23-00-000-27

FAN DUCT PANELS. AMM 72-23-00-400-27

MAKE SURE VBV BALLSCREW ACTUATORS AMM 75-31-00-820-001

ARE IN THE FULLY CLOSED POSITION.

CHECK THE VBV POSITION SENSOR. AMM 75-31-70-400-002

13/01/15 TRANSFER OF VARIABLE STATOR VANE AMM 75-32-10-100-002-A

ACTUATOR DURING ENGINE CHANGE. AMM 75-32-10-400-002-A

LEAK CHECK OF VSV ACTUATOR. AMM 75-32-10-790-051-A

ATA CHAPTER 77
DATE TASK DESCRIPTION REFERENCE

10/02/16 TROUBLESHOOTING PILOT REPORTS OF TSM 77-00-00-810-852-A

ENG 1 N1 DISCREPANCY (70% TO 89%)
WHILE ENG 2 N1 STEADY AT 82%.

REPLACEMENT OF HYDROMECHANICAL AMM 73-21-10

UNIT.

OPS TEST OF FADEC ON THE GROUND AMM 73-29-00-710-040

(WITH ENGINE MOTORING).
ATA CHAPTER 78
DATE TASK DESCRIPTION REFERENCE

27/06/12 INSPECTION OF THRUST REVERSER. AMM 78-31-00-210

27/06/12 LUBRICATION OF THRUST REVERSER AMM 78-31-00-641

GUIDE RODS (D-5100NS AEROSOL SPRAY
LUBRICATION METHOD).

27/06/12 LUBRICATION OF THRUST REVERSER AMM 78-31-00-640

PIVOT POINTS (WC-393 NON AEROSOL
SPRAY LUBRICATION METHOD).

27/06/14 REPLACEMENT OF THRUST REVERSER AMM 78-36-51

HALF DOOR OPENING ACTUATOR.

03/03/15 MPD TASK DETAILED INSPECTION OF AMM 78-31-41-210-042-B

ACTUATOR ROD END ATTACHMENT
(BLOCKER DOOR DEPLOYED).

MANUAL EXTENSION OF THRUST AMM 78-32-00-860-010-12

REVERSER TRANSLATING SLEEVES.

MANUAL EXTENSION OF THRUST AMM 78-32-00-860-011-12

REVERSER TRANSLATING SLEEVES.

11/03/15 REPLACEMENT OF THRUST REVERSER AMM 78-31-51-920-001-A.

HYDRAULIC CONTROL UNIT FILTER.

DEACTIVATION OF HCU FOR GROUND AMM 78-30-00-040-012-A

MAINTENANCE.

REACTIVATION OF HCU AFTER GROUND AMM 78-30-00-440-012-A

MAINTENANCE.

OPS TEST OF THRUST REVERSER AMM 78-31-00-710-042

SYSTEM.
ATA CHAPTER 79
DATE TASK DESCRIPTION REFERENCE

22/04/1 CHECK OF OIL SYSTEM FOR OIL QUANTITY AMM 79-31-00-040-042-A

2 ON THE ENGINE SYSTEM DISPLAY PAGE.

CHK MASTER MAGNETOR CHIP DETECTOR AMM 79-00-00-281-002-A

11/06/1 FOR PARTICLES MPD TASK: 792000-C8
3

14/09/1 INSTALLATION OF LOW OIL PRESSURE AMM 79-34-15-400-041-A

4 SWITCH DURING ENGINE CHANGE.

MINIMUM IDLE LEAK CHECK. AMM 71-00-00-710-006

14/09/1 INSTALLATION OF OIL PRESSURE AMM 79-33-15-400-041-A

4 TRANSMITTER DURING ENGINE CHANGE.

MINIMUM IDLE LEAK CHECK. AMM 71-00-00-710-006

14/09/1 INSTALLATION OF OIL QUANTITY AMM 79-33-15-400-041-A

4 TRANSMITTER DURING ENGINE CHANGE.

OPS CHECK. AMM 31-60-00.

14/09/1 INSTALLATION OF OIL TEMPERATURE AMM 79-32-15-400-041-A

4 SENSOR DURING ENGINE CHANGE.

OPS CHECK. AMM 31-60-00.

30/03/1 REMOVAL OF MAIN OIL/FUEL HEAT AMM 79-21-20-000-002-A

6 EXCHANGER.

INSTALLATION OF MAIN OIL/FUEL HEAT AMM 79-21-20-400-002-A

EXCHANGER.
ATA CHAPTER 80
DATE TASK DESCRIPTION REFERENCE

29/03/12 REMOVAL AND INSTALLATION OF AMM 80-10-00

STARTER GENERATORS.

18/12/12 CHECK CHIP DETECTOR AS PER MPD TASK AMM 80-11-10-210-001-C

801110-C1.

REMOVAL OF STARTER MAGNETIC PLUG AMM 80-11-00-020-052-B

FOR INSPECTION.

INSTALLATION OF MAGNETIC PLUG AMM 80-11-00-420-052-B

AFTER INSPECTION.

13/10/14 INSTALLATION OF PNEUMATIC STARTER. AMM 80-11-10-400-002-A

POST INSTALLATION FILLING STARTER AMM 12-13-80-610-001

WITH ENGINE OIL.
 MINIMUM LEAK CHECK AND OIL LEAK AMM 71-00-00-710-006
CHECK AT STARTER DRIVE PAD AND AIR
LEAK CHECK AT STARTER TO AIR DUCT
CONNECTION.

14/08/15 REPLACEMENT OF PNEUMATIC STARTER AMM 80-11-00

DUE TO FINDING OF METAL PARTICLES

POST INSTALLATION FILLING STARTER AMM 12-13-80-610-001

WITH ENGINE OIL..

MINIMUM LEAK CHECK AND OIL LEAK AMM 71-00-00-710-006

CHECK AT STARTER DRIVE PAD AND AIR
LEAK CHECK AT STARTER TO AIR DUCT
CONNECTION.