CG935H 轮式装载机

MODEL ZL35H WHEEL LOADER

零 件 目 录
PARTS CATALOGUE

四川成都成工工程机械股份有限公司
CHENGDU CHENGGONG CONSTRUCTION MACHINERY CO.，LTD.，SICHUAN

1
 零件目录使用说明
本零件目录包括 CG935H（出口高配）型轮式装载机的零、部件，按照装配使
用位置作了详细的标注和说明。
1.零件目录的使用
1.1 所需的零部件，先在图册上找到它的位置，查出它的序号，然后在对应的目
录表上找到相应序号的那一格，即可查出所需零部件的代号、名称和每台机器所需
的数量。
1.2 一部分组合件没有分别画出所属零件，只标以组合件。
1.3 本零件目录使用了左右位置，均按机器前进方向作基准来区别左右方向。
1.4 目录表中所列数量，是指每台机器装配时应有的件数。
1.5 注：
组——必要时使用体积、厚度或数量加以对照；
△——没有进行图示的零部件；
GB——中国国家标准；
JB——中国机械工业部标准。
2.订购零部件
凡订购本公司机器的零部件时请提供下列说明：
1.写明机器的型号、出厂编号和出厂日期；
2.写明所订零部件的代号、名称、实际所需数量。
3.注意事项
3.1 更换零部件时，除标准件、外购件外，务必使用本公司机器的零部件，而不
要随意使用其它产品零部件，以防止机器遭受严重损坏后不能更换使用。
3.2 产品的结构和性能在不断改进和提高，本零件目录的内容可能会与出厂产品
实际结构稍有差异，除较大变动要补充说明外，一般均在新版时进行修改，请用户
在使用时加以注意。

2
 INSTRUCTIONS FOR THE USE OF
THE PARTS CATALOGUE
All the parts of CG935H Wheel Loader, marked and described in detail, are
included in this parts catalogue.
1. The use of parts catalogue
1.1First, check up the required parts which are marked by sign number from the
figure. Then, in accordance with this sign number, you can the part’s code No., name and
quantity for each machine from the parts catalogue table.
1.2Some assembles are not given the all parts but only the assemble themselves.
1.3The direction of right or left used in this parts catalogue is accordance with the
forward direction of the machine.
1.4The quantity on the parts catalogue table is the possessive quantity for the use of
each machine.
1.5Note:
Group-To contrast with volume, thickness and quantity when it is necessary.
when it is necessary.
△-The parts does not show in figure.
GB-Chinese standard.
JB-Standard of the First Machine-Building Ministry of China.
2.Order the spare parts
Those who orders the spare parts should give the detail contents described below.
1.The model of the grader, the number of manufacture and date production.
2.The code No., the name and required quantity of the parts.
3.Attention
3.1When the parts of the grader need replace, you have to replace them with the parts
made by our work. In order to prevent the machine from damage, don't’ use the parts of
other to vehicle to substitute for with exception of the standard-parts.
3.2The construction of the grader will be given some improvements after a certain
period time. So there will be some differences in the parts catalogue.

3
 目 录
Contents
发动机装置···························································································································· 5
Engine Assembly
变矩器 ································································································································· 18
Torque Converter
变速箱 ································································································································· 24
Transmission
变速油路及操纵系统 ·········································································································· 37
Transmission Lines and Control System
前桥、后桥·························································································································· 45
Front Axle & Rear Axle
前传动轴 ····························································································································· 64
Steering System
转向系统 ····························································································································· 67
Full-Hydraulic Steering System
制动系统 ····························································································································· 73
Braking System
工作液压系统······················································································································ 83
Implement Hydraulic System
后传动轴 ····························································································································· 95
Rear Drive Shaf
车身车架 ····························································································································· 98
Frame Group
驾驶室 ······························································································································· 113
Cab
工作装置 ··························································································································· 122
Implement
电气设备 ··························································································································· 129
Electrical Apparatus
空调系统 ··························································································································· 137
Air-conditioner System

4
 发动机装置
Engine Assembly

5
Z35H01T13 发动机装置（一） Engine Assembly(I)

6
 Z35H01T13 发动机装置（一） Engine Assembly(I)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z35F010000001 调整垫片（一） Washer (I) 4
2 EA300 减振垫 Washer 2
3 Z35F010000002 调整垫片 Washer 4
4 EA220 减振垫 Washer 2
6 TD226B-6G 柴油机 Engine 1
7 油压测试接头 Connector 1
B1 GB5783-86 螺栓M24X50 Bolt M24X50 2
B2 GB93-87 垫圈 24 Washer 24 2
B3 GB5783-86 螺栓M22X55 Bolt M22X55 2
B4 GB93-87 垫圈22 Washer 22 2
B5 GB5783-86 螺栓M14X75 Bolt M14X75 12
B6 GB93-87 垫圈 14 Washer 14 12
B7 GB6170-86 螺母 M14 Nut M14 32
B8 GB93-87 垫圈12 Washer 12 1
B9 CG303.15-95 螺母 6 Nut 6 1

7
Z35H01T13 发动机装置（二） Engine Assembly(II)

8
 Z35H01T13 发动机装置（二） Engine Assembly(II)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
Z35H010300001
1 引风罩 Fan Cowl 1
T13
Z35F010100002
3 水箱支架（二） Support(II) 1
B
5 ZL30B.1-19 螺塞 Threaded Plug 1
Z35F010100001
6 水箱支架（一） Support(I) 1
B
7 CG35B 水箱 Radiator 1
8 2X型 喉箍 Clamp 2
Z35H010400001
9 出水胶管 Water Outlet Pipe 1
T11
B1 GB5783-86 螺栓M8X30 Bolt M8X30 4
B2 GB6170-86 螺母 M8 Nut M8 4
B3 GB93-87 垫圈8 Washer 8 4
B4 GB6170-86 螺母10 Nut 10 8
B5 GB93-87 垫圈10 Washer 10 8
B6 GB5783-86 螺栓M10X30 Bolt M10X30 8
B7 GB95-86 垫圈12 Washer 12 4
B8 GB93-87 垫圈12 Washer 12 4
B9 GB5783-86 螺栓M12X40 Bolt M12X40 4

9
Z35H0101T13 燃油箱 Fuel Tank

10
 Z35H0101T13 燃油箱 Fuel Tank

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 加油盖 Oil Filling Cap 1
2 滤网 Screen 1
3 Z30010100001 油标尺 Dipstick 1
4 Z35H010101T13 燃油箱体 Tank Body 1
5 CG50.1.1-2 法兰盖 Cover 2
6 ZL30B.1.1-10 放油塞 Threaded Plug 1
7 燃油进油管 Pipe 1
8 ZL30B.1.1-4 空心螺栓 Bolt 2
9 燃油出油管 Pipe 1
B1 GB70-86 螺钉 M5X20 Screw M5X20 4
B2 GB93-87 垫圈 5 Washer 5 4
B3 GB5783-86 螺栓 M8X25 Bolt M8X25 12
B4 GB93-87 垫圈 8 Washer 8 12
B5 GB3452.1-82 O型圈132X2.65 O-Ring 132X2.65 2
B6 GB848-86 组合垫圈14 Washer 14 4
B7 GB5783-86 螺栓M12X25 Bolt M12X25 5
B8 GB93-87 垫圈 12 Washer 12 5

11
Z35F0105B 传动轴总成 Drive Shaft

12
 Z35F0105 传动轴总成 Drive Shaft

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z35F010501 联结凸缘 Flange 1
2 ZL30B.1.6.1-2 盖 Cover 1
3 Z35F010500001 垫圈 Washer 30
4 Z35F010502002 轴套 Bushing 12
5 Z35F010502001 橡胶套 Rubber Sleeve 12
6 Z35F010503 传动轴 Drive Shaft 1
7 Z35F0105021B 橡胶盘 Rubber Disc 2
8 Z35F010500002 锁紧钢丝 Lock Wire 3米
B1 GB6178-86 螺母M16X1.5 Nut M16X1.5 9
B2 GB91-86 销4X35 Pin 4X35 9
B3 GB93-87 垫圈16 Washer 16 20
螺 栓
B4 GB5785-86 Bolt M16X1.5X105 6
M16X1.5X105
B5 GB5785-86 螺栓M16X1.5X85 Bolt M16X1.5X85 3
B6 GB5785-86 螺栓M16X1.5X35 Bolt M16X1.5X35 8
螺 栓
B7 GB5785-86 Bolt M16X1.5X115 3
M16X1.5X115

13
Z35H0106T11 油门操纵装置 Governor Control

14
 Z35H0106T11 油门操纵装置 Governor Control

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 XZ型 油门操纵阀 Accelerograph Control Valve 1
2 30E2500 软轴总成 Cable Assembly 1
3 螺母 Bolt M12X25 2
4 螺母 Bolt 10X25 3
5 油门支架 Support 1

15
Z35H0108T11 进水管总成 Inlet Water Pipe Assembly

Z35H0104T11 出水管总成 Outlet Water Pipe Assembly

16
 Z35H0108T11 进水管总成 Inlet Water Pipe Assembly
Z35H0104T11 出水管总成 Outlet Water Pipe Assembly

序号 代号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
Z35H010400001
1 出水胶管 Inlet Water Pipe 1
T11
2 3X 卡箍 Clam 2
Z35H010800001
3 进水胶管 Outlet Water Pipe 1
T11
4 3 卡箍 Clam 2

17
 变矩器
Torque Converter

18
Z3BⅡ02 变矩器（一） Torque Converter(Ⅰ)

19
 Z3BⅡ02 变矩器（一） Torque Converter(Ⅰ)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z3BⅡ020000003 驱动轴 Shaft-Drive 1
O 型 密 封 圈
2 GB1235-76 95X3.1 O-Ring95X3.1 1
3 GB276-93 轴承6210 Bearing 6210 2
4 Z3BⅡ020000002 罩轮 Converter Drive Housing 1
5 Z3BⅡ020100003 一级涡轮罩 1st Turbine Housing 1
6 Z3BⅡ020100001 一级涡轮鼓 1st Turbine Hub 1
7 GB893.1-86 挡圈 52 Snap Ring 52 1
8 GB276-93 轴承 6013 Bearing 6013 1
9 Z3BⅡ0202 二级涡轮 2nd Turbine 1
10 Z3BⅡ020100005 一级涡轮 1st Turbine 1
11 GB894.1-86 挡圈 48 Snap Ring 48 1
12 GB5783-86 螺栓 M10X25 Bolt M10X25 8
13 GB93-87 垫圈10 Washer 10 17
14 GB119-96 销 A10X22 Pin A10X22 1
15 GB6170-86 螺母 M8 Nut M8 25
16 GB93-86 垫圈 8 Washer 8 32
17 Z3BⅡ020100004 弹性销 Lock Pin 9
18 GB869-86 铆钉 8X18 Rivet 8X18 12
20 Z3BⅡ020000012 挡圈 Snap Ring 1
22 Z3BⅡ020000010 导向轮 Stator 1
23 Z3BⅡ020000013 导油环 Oil Catch Ring 1
24 Z3BⅡ020000017 铁丝(d=1.2毫米) Locking Wire 按需
25 Z3BⅡ020000028 螺栓 M8X30 Bolt M8X30 12
26 Z3BⅡ020000019 压紧垫片 Gasket 4
27 Z3BⅡ020000018 调整垫片 Adjusting Shim 12

20
 Z3BⅡ02 变矩器（一） Torque Converter(Ⅰ)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
28 Z3BⅡ020000009 泵轮 Impeller 1
29 GB848-85 垫圈 8 Washer 8 24
30 GB5783-86 螺栓 M8X40 Bolt M8X40 24
31 GB276-93 轴承6017 Bearing 6017 2
32 Z3BⅡ020000027 齿轮 Gear 1
33 Z3BⅡ020000016 密封环 Seal Ring 1
34 Z3BⅡ020000015 导轮座 Stator Seat 1
35 Z3BⅡ020000029 螺栓 M10X25 Bolt M10X25 9
36 YJSW315.6A-9 密封环106.2X3 Seal Ring 1
37 YJSW315.6A-26 O形密封圈 O-Ring 1

21
Z3BⅡ02 变矩器（二） Torque Converter（Ⅱ）

22
 Z3BⅡ02 变矩器（二） Torque Converter（Ⅱ）

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 GB898-88 双头螺柱 M14X35 Stud M14X35 4
2 GB93-87 垫圈 14 Washer14 8
3 GB5783-86 螺栓 M14X80 Bolt M14X80 4
4 Z3BⅡ0312 变速箱支架 Transmission Support 2
5 Z3BⅡ030100066 调整垫片 Adjusting Shim 2组
6 GB97.1-86 垫圈 14 Washer 14 8
7 GB6170-86 螺母 M14 Nut M14 8
8 HG4-692-67 油封 65X90X12 Oil Seal 65X90X12 1
9 GB893.1-86 档圈 90 Snap Ring 90 2
10 GB5781-86 螺栓 M10X30 Bolt M10X0 12
11 GB93-87 垫圈 10 Washer 10 12
12 Z3BⅡ020000001 端盖 End Cover 1
13 Z3BⅡ020000006 垫 Paper Gasked 1
14 Z3BⅡ020000004 垫圈 Washer 2
15 Z3BⅡ020000005 接头 Connector 2
16 Z3BⅡ020000014 壳体 Hosing 1
17 Z3BⅡ020100007 垫 Paper Gasked 1
18 Z3BⅡ020000008 垫板 Plate 1
19 GB93-87 垫圈 8 Washer 8 8
20 GB5783-86 螺栓 M8X16 Bolt M8X16 8
21 Z3BⅡ020000024 垫片 Washer 2
22 Z3BⅡ020000026 弹簧 Spring 1
23 Z3BⅡ020000022 阀杆 VaLer Rod 1
24 Z3BⅡ020000020 阀盖 Valve Cover 1
25 Z3BⅡ020000023 弹簧 Spring 1
26 Z3BⅡ020000025 阀杆 Valve Rod 1
27 Z3BⅡ020000021 垫板 Plate 1
29 Z3BⅡ02003 直接接头 Connector 1
31 CG302.3-95 接头体 22/M27X2 Union 22/M27X2 2
32 JB982-77 垫圈 27 Washer 27 2

23
 变速箱
Transmission

24
Z35F03B 变速箱 Transmission

25
 Z35F03B 变速箱 Transmission

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z3BⅡ030000064 前输入轴 Input Shaft Front 1
2 Z3BⅡ030000003 调整垫片 Adjusting Shim 1组
3 Z3BⅡ030000004 内密封圈 External Seal Ring 1
4 Z3BⅡ030000006 外密封圈 Internal Seal Ring 2
5 Z3BⅡ030000010 隔圈 Spacer 1
6 Z3BⅡ030000005 倒档活塞 Piston-Reverse 1
7 Z3BⅡ030000009 倒档一档从动片 Driven Plate-1st Reverse 8
8 Z3BⅡ0302 一倒档主动摩擦片 Driven Disk-1st Reverse 8
9 Z3BⅡ030400002 摩擦片隔离架 Cage-Friction Disks 1
Return Spring 1st Reverst
10 Z3BⅡ030000007 一倒档活塞回位弹簧 16
Piston
11 Z3BⅡ030400001 摩擦片销 Pin Disks 8
12 Z3BⅡ030000008 弹簧导杆 Spring Guide Rod 16
13 Z3BⅡ030300002 倒档行星架 Planetary Carrier-Reverse 1
14 Z3BⅡ030300006 垫片 Gasket 16
15 Z35F030200001A 行星轮 Gear-Planet 8
16 GB309-84 滚针P3.5X19.8G2 Needle P3.5X19.8G2 200
17 Z3BⅡ030300003 倒档行星轴 Shaft-Reverse 4
18 Z3BⅡ030500001 倒档齿圈 Ring Gear-Reverse 1
19 Z3BⅡ030500003 档圈 Snap Ring 1
Planetary Carrier 1st
20 Z3BⅡ030500002 一档行星架 1
Forward
21 GB276-93 轴承6011 Bearing 6011 1
22 Z3BⅡ030500006 一档行星轴 Shaft-1st Forward 1
23 Z3BⅡ030500004 止动盘 Detent Disk 1
24 Z3BⅡ030500005 传力套 Linkage Sleeve 1
25 Z3BⅡ030500007 键 Key 2

27
 Z35F03B 变速箱 Transmission

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
26 Z3BⅡ0306 一档齿圈总成 Ring Gear Assem 2
27 GB893.1-86 档圈80 Snap Ring 80 1
28 GB32.1-88 螺栓 M8X16 Bolt M8X16 4
29 GB276-93 轴承6010 Bearing 6010 1
30 Z3BⅡ030300005 销圈 Pin Ring 4
31 Z3BⅡ030000012 一档活塞 Piston-1st Forward 1
32 Z35F030000001 太阳轮 Gear-Sun 1
33 Z3BⅡ030000013 内密封圈 Internal Seal Ring 1
34 Z3BⅡ030000014 一档油缸 Cylinder-1st Forward 1
35 Z3BⅡ030000001 O形密封圈 O-Rring 1
36 Z3BⅡ030000049 纸垫 Paper Gasket 1
37 GB93-87 垫圈 12 Washer 12 30
38 GB5781-86 螺栓 M12X35 Bolt M12X35 16
39 GB893.1-86 档圈150 Snap Ring 150 1
40 GB276-93 轴承6020 Bearing 6020 1
41 Z35F030000002 大齿轮 Major Gear 1
42 Z3BⅡ030000024 后输入轴 Input Shaft -Rear 1
43 GB894.1-86 档圈45 Snap Ring 45 2
44 Z3BⅡ0308 二档主动摩擦片 Driven Disk-2nd Forward 3
45 Z3BⅡ030000027 二档从动片 Driven Plate-2nd Forward 3
46 Z3BⅡ0311 二档主动齿轮 Driven Gear-2nd Forward 1
47 Z30030000003 二档活塞回位弹簧 Return Spring 12
48 Z30030000002 二档齿圈 Ring Gear-2nd Forward 1
49 Z3BⅡ030000018 外密封圈 External Seal Ring 1
50 Z3BⅡ030000019 二档活塞 Piston-2nd Forward 1

28
 Z35F03B 变速箱 Transmission

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
51 Z3BⅡ030000025 内密封圈 Internal Seal Ring 1
52 GB276-93 轴承6004 Bearing 6004 1
53 Z3BⅡ030700001 导杆 Guide Rod 3
54 Z3BⅡ030700002 二档油缸 Cylinder-2nd forward 1
55 GB97.1-85 垫圈 10 Washer 10 8
56 GB32.1-88 螺栓 M10X65 Bolt M10X65 8
57 GB276-93 轴承6214 Bearing 6214 1
58 Z3BⅡ030700003 密封环 Seal Ring 2
59 Z3BⅡ030000022 配油套 Oil Sleeve 1
60 CG302.11-95 垫圈 14 Washer 14 1
61 Z3BⅡ030000026 油孔螺塞 Thread Plug 1
62 Z3BⅡ030000028 纸垫 Paper Gasket 1
63 Z3BⅡ030000020 右盖 Right Cover 1
64 Z3BⅡ030000051 纸垫 Paper Gasket 1
65 Z3BⅡ030000023 轴盖 End Cover 1
66 GB93--87 垫圈 8 Washer 8 29
67 GB5781-86 螺栓 M8X20 Bolt M8X20 30
68 GB59-76 螺母 M27X1.5 Bolt M27X1.5 2
69 GB91-76 销 5X50 Pin 5X50 2
70 GB97.2-76 垫圈 27 Washer 27 2
71 GB93-87 垫圈 10 Washer 10 18
72 GB5781-86 螺栓 M10×20 Bolt M10×20 4
73 Z35F030000004 连接凸缘 Flange 2
74 Z3BⅡ030000047 防尘罩 Dust Shroud 1
75 HG4-692-67 油封 60×90×12 Oil Seal 60×90×12 1

29
 Z35F03B 变速箱 Transmission

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
76 Z3BⅡ030000063 油封衬套 Lining—Oil Seal 1
77 Z3BⅡ030000067 O型密封圈 O—Ring 1
78 Z3BⅡ030000046 左压盖 Left Cover 1
79 Z3BⅡ030000045 纸垫 Paper Gasket 1组
80 GB276-93 轴承 6309 Bearing 6309 1
81 GB893.1-86 挡圈 100 Snap Ring 100 1
82 Z3BⅡ030000044 后输出轴 Output Shaft Rear 1
83 Z3BⅡ030000043 定位弹簧 Locating Spring 1
84 GB308-89 钢球 10 Ball 10 2
85 Z3BⅡ030000042 滑套 Sliding Sleeve 1
86 GB894.1-86 挡圈 55 Snap Ring 55 1
87 GB276-93 轴承 6211 Bearing 6211 1
88 Z3BⅡ030000048 隔圈 Spacer 1
89 Z35F030000003 被动齿轮 Driven Gear 1
90 Z3BⅡ030000034 隔离套 Spacer 1
91 GB893.1-86 挡圈 120 Snap Ring 120
92 GB898-88 螺柱 AM12×38 Bolt AM12×38 6
93 GB276-93 轴承 6213 Bearing 6213 1
94 Z3BⅡ030000033 调整垫片 Adjusting Shim 1组
95 Z3BⅡ030000029 右压盖 Right Cover 1
96 GB6170-86 螺母 M12 Nut M12 6
97 Z3BⅡ030000065 键 Key 2
98 Z3BⅡ030000037 支承套 Sleeve 1
99 Z3BⅡ030000052 压圈 Clamping Ring 1
100 HG4-692-67 油封 70×100×13 Oil Seal 70×100×13 1

30
 Z35F03B 变速箱 Transmission

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
101 Z3BⅡ030000041 滑动轴套 Bushing 1
102 Z3BⅡ030000031 前输出轴 Output Shaft—Front 1
103 Z3BⅡ030000010 螺塞 Thread Plug 1
105 Z3BⅡ030000036 法兰盘 Flange 1
106 GB1235-76 O 型 圈 125×5.7 O—Ring 125×5.7 1
107 Z3BⅡ030000039 密封垫 Gasket 1
108 Z3BⅡ030000040 磁铁 Magnet 1
109 Z3BⅡ030000038 挡板 Plate 1
110 GB93-87 垫圈 6 Washer 6 3
111 GB5781-86 螺栓 M6×25 Bolt M6×25 3
112 Z3BⅡ030000011 变速箱壳体 Housing—Transmission 1
113 Z3BⅡ030000062 拨叉轴 Shaft—Shift Fork 1
114 GB1235-76 O 型 圈 22×2.4 O—Ring 22×2.4 1
115 Z3BⅡ030000061 拨叉 Shift Fork 1
116 GB5783-86 螺栓 M14×80 Bolt M14×80 4
117 GB6170-86 螺母 M14 Nut M14 8
118 GB93-87 垫圈 14 Washer 14 8
119 GB97.1-85 垫圈 14 Washer 14 8
120 Z3BⅡ030000066 调整垫片 Adjusting Shim 4组
121 Z300302 变速箱支架 Bracket—Transmission 2
双头螺柱 BM14×
122 GB898-88 Stud BM14×35 4
35
123 Z3BⅡ030000058 销柱盖 Pin End Cover 1
124 Z3BⅡ030000050 纸垫 Paper Gasket 1
125 Z3BⅡ030000059 定位销 Plunger 1
126 GB1235-76 O 型 圈 16×2.4 O—Ring 16×2.4 1

31
 Z35F03B 变速箱 Transmission

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
127 Z3BⅡ030000057 定位螺钉 Set Screw 1
129 GB1235-76 O型密封圈65×3.5 O—Ring 65×3.5 1
130 Z35F0305 加油管总成 Filler Pipe 1
131 Z3BⅡ031501 油标尺 Dipstick 1
135 Z3BⅡ0313 处油口连接管 Connecting Pipe—Outlet 1
136 GB1235-76 O型密封圈85×5.7 O—Ring 85×5.7 1
137 Z3BⅡ0314 滤油器 Filter 1
138 GB5781-86 螺栓 M10×25 Bolt M10×25 6
139 GB5783-86 螺栓 M10×30 Bolt M10×30 8
140 Z3BⅡ030000069 底板 Plate 1
141 GB95-85 垫圈 8 Washer 8 18
142 Z3BⅡ030300007 挡圈 Snap Rinf 16
143 GB5781-86 螺栓 M8×35 Bolt M8×35 18
144 Z3BⅡ030000070 密封垫 Seal Gasket 1
145 Z30030000006 盖板 Plate 1

32
Z35F0301A 同步齿箱 Combining Gear Set

33
 Z35F0301A 同步齿箱 Combining Gear Set

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z3BII030100017 密封垫 Gasket 1
2 GB5783-86 螺栓 M10×30 Bolt M10×30 20
3 GB93-87 垫圈 10 Washer 10 29
4 GB276-93 轴承 6308 Bearing 6308 2
5 Z3BII030100024 齿轮 Gear 2
6 Z3BII030100025 隔套 Spacer 2
7 Z3BII030100021 转向油泵轴 Shaft—Steering Pump 1
8 Z3BII030100010 油泵轴 Shaft—Oil Pump 1
9 Z3BII030100008 箱体 Housing 1
10 GB276-93 轴承 6010 Bearing 6010 1
11 GB1235-76 O型密封圈 26×2.4 O—Ring 26×2.4 1
12 Z3BII030100014 螺母 Nut 2
13 Z3BII030104 通气口 Breather 1
14 Z3BII030100023 垫片 Gasket 1
15 Z3BII030100012 阀罩 Valve Cover 1
16 Z3BII030100022 转向泵连接法兰 Flange—Steering Pump 1
17 GB9000-88 螺栓 M10×50 Bolt M10×50 4
18 GB6170-86 螺母 M10 Nut M10 4
19 GB6170-86 螺母 M12 Nut M12 2
20 GB93-87 垫圈 12 Washer 12 2
21 GB276-93 轴承 6016 Bearing 6016 1
22 GB898-88 螺柱 AM12×70 Stud AM12×70 2
23 Z3BII030100003 二级齿轮油封环 Oil Seal Ring—2nd Gear 1
24 Z3BII030100001 输入二级齿轮 2nd Input Gear 1
25 Z3BII030100004 一级齿轮油封环 Oil Seal Ring—1st Gear 1

34
 Z35F0301A 同步齿箱 Combining Gear Set

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
26 Z3BII030100005 衬套 Bushing 1
27 GB301-93 轴承51111 Bearing 51111 1
28 Z3BII030100002 输入一级齿轮 1st Input Gear 1
29 GB276-93 轴承 6309 Bearing 6309 1
30 GB5781-86 螺栓 M6×10 Bolt M6×10 1
31 GB93-87 垫圈 6 Washer 6 1
32 Z3BII030100018 管卡 Clip 1
33 Z3BII030100007 铜管 Copper Pipe 1
34 Z3BII030102004 外环齿轮 Ring Gear—External 1
35 GB276-93 轴承 6309 Bearing 6309 2
36 GB893.3-86 挡圈 75 Snap Ring 75 2
37 Z3BII030100006 隔离套 Spacer 1
38 Z3BII030102001 弹簧 Spring 3
39 Z3BII030100011 中间隔套 Spacer 1
40 GB276-93 轴承 6210 Bearing 6210 1
41 GB91-86 销 2×16 Pin 2×16 16
42 GB9457-88 螺母 M8×1 Nut M8×1 16
43 GB276-93 轴承 6208 Bearing 6208 1
44 Z3BII030102008 中间输入轴齿轮 Gear—Middle Input 1
45 Z3BII030102006 挡环 Retaining Ring 1
46 Z3BII030102002 压盖 Cap 1
47 Z3BII030102003 隔离环 Spacer 1
48 Z3BII030102007 滚柱 Roller 16
49 Z3BII030102005 内环齿轮 Internal Ring cam 1
50 Z3BII030102009 螺栓 Bolt 16

35
 Z35F0301A 同步齿箱 Combining Gear Set

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
51 Z35F030101 气压表管 Connecting Pipe—Oil Gauge 1
52 GB276-93 轴承 6012 Bearing 6012 1
53 HG4-692-67 油封 60×80×13 Oil Seal 60×80×13 1
54 Z3BII030100009 密封垫片 Gasket 1
55 GB117-86 销 8×28 Pin 8×28 2
56 Z3BII030101005 泵盖 Cover—Pump 1
57 Z3BII030101001 轴 Shaft 1
58 Z3BII030101006 密封垫 Gasket 1
59 Z3BII030101004 轴套 Bushing 1
60 Z3BII030101002 小齿轮 Pinion 1
61 Z3BII030101007 泵体 Pump Body 1
62 GB898-88 螺柱 AM10×50 Stud AM10×50 6
63 GB70-76 螺钉 M10×75 Screw M10×75 2
64 GB5783-86 挡圈 62 Snap RING 62 1
65 Z3BII030101008 挡环 Retaining Ring 1
66 HG4-692-67 油封 45×62×10 Oil Seal 45×65×10 1
67 HG4-692-67 油封 45×6×512 Oil Seal 45×65×12 1
68 GB93-87 垫圈 10 Washer 10 2
69 GB5783-86 螺栓 M10×30 Bolt M10×30 2
70 Z3BII030101003 大齿轮 Major Gear 1
71 JB982-77 垫圈 33 Washer 33 1
72 CG313-80 接头体 28/M33×2 Union 28/M33×2 1
73 GB1235-76 O型密封圈30×3.1 O—Ring 30×3.1 1
74 Z3BII030100013 调整螺钉 Adjusting Screw 1
75 Z3BII030100016 弹簧 Spring 1
76 Z3BII030100019 阀 Valve 1

36
 变速油路及操纵系统
Transmission Oil Line And
Control System

37
 Z35H04T13 双变冷却油路及变速操纵系统
The cooling Line of the Transmission and Speed Control System

38
 Z35H04T13 双变冷却油路及变速操纵系统
The cooling Line of the Transmission and Speed Control System

数
序号 代 号 名 称 备注
量
Item Part No. Parts Name Remark
Q'ty
1 Z35H0402T2 变速操纵机构 Speed Control Machine 1
nd
2 Z300402 二挡油管 Line-2 Forward Pipe 1
3 Z300403 倒挡油管 Line-Reverse Pipe 1
4 Z300404 一挡油管 Line-1st Forward Pipe 1
5 Z3BII0407 变速配油阀 Speed Selector Valve 1
6 Z30040000002 过渡法兰 Flange 1
20411-36-16/20491-36-1
7 胶管总成 Hose 1
6X1T16GTX945
8 FL-16 法兰组件 Flange 1
9 1CL-30-27 接头 Connector 3
20491-30-12/87391-16-
10 胶管总成 Hose 1
12X1T12GTX1120V180
20411-30-12/20491-30-1
11 胶管总成 Hose 1
2X1T12GTX1100
12 1CL-36-33L114 接头 Connector 1
20411-30-12X1T12GTX
13 胶管总成 Hose 1
2100
20411-30-12/20491-30-1
14 胶管总成 Hose 1
2X1T12GTX2300
15 1CFL-30-16 接头 Connector 2
16 CG35-1301000 散热器 Cooler 1
17 Z3BII0406 润滑油管总成 Pipe 1
18 SFM-680 精滤器 Filter 1
19 Z35H040000001 滤油器支架 Bracket 1
变速配油阀进油
20 Z300406 Oil Inlet Line 1
管
21 Z3BII040000001 垫圈 Washer 4
22 K1CH-16-14OG 直角接头 Connector 4
23 K1CH-16-14 直接头 Connector 4

39
 Z35H04T13 双变冷却油路及变速操纵系统
The cooling Line of the Transmission and Speed Control System

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
KCLH-30-12-27OGM12
24 三通接头 Connector 1
C
25 GB5783-86 螺栓M12X25 Bolt M12X25 13
26 GB97.1-85 垫圈12 Washer12 13
27 GB93-87 垫圈12 Washer12 13
28 GB5783-86 螺栓M8X15 Bolt M8X15 4
29 GB93-87 垫圈8 Washer8 4
30 GB97.1-85 垫圈8 Washer8 4
31 2C9-30 接头 Connector 2
32 GB6173-86 螺母M14X1.5 Nut M14X1.5 4
33 GB1235-76 O型密封圈16×2.4 O-ring16×2.4 4
34 Z50E100000001 管夹 Clamp 2
35 GB5783-86 螺栓M8X40 Bolt M8X40 2
36 GB93-87 垫圈8 Washer8 2
37 GB97.1-85 垫圈8 Washer8 2
38 GB6170-85 螺母M8 Nut M8 2
39 1CW-36-28 焊接接头 Connector 1
40 2C9-36 接头 Connector 1
41 1CL-30-27(M27X1.5) 接头 Connector 2
42 Z35H0403 变矩器油压表管 Pipe 1
43 Z35H0401T12 机油压力表管 Pipe 1
44 Z50E0403T46 仪表软管 Pipe 2
45 LCHN-16-14-02OG 三通接头 Connector 1

40
Z35H0402T2 变速操纵机构 Speed Control Machine

41
 Z35H0402T2 变速操纵机构 Speed Control Machine

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
Transmission Control And
1 Z35H040203 上连杆总成 1
Soft Shaft
Transmission Control
2 Z35H040201 中机构 1
Assem.
3 GB/T91-1986 销3.2X50 Connecting Fork 3
4 GB882-86 销轴B8X28 Pin 3X20 3
5 Z35H040201T2 中下机构连杆 Axle Pin B8h11X25 1
6 Z35H040204 下支座总成 1

42
Z3BII0407 变速配油阀 Speed Selector Valve

43
 Z3BII0407 变速配油阀 Speed Selector Valve

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z3BII040701 防尘罩 Dust Shroud 1
2 Z3BII040700001 驱动齿轮 Driving Gear 1
3 Z3BII040700002 调整垫片 Adjusting Shim 1
4 Z3BII040700003 阀杆 Valve Stem 1
5 Z3BII040700004 阀体 Valve Body 1
6 Z3BII040700005 支承轴承 Support 1
7 Z3BII040700006 齿条 Rack 1
8 Z3BII040700007 弹簧 Spring 1
9 Z3BII040700008 螺塞 Thread Plug 1
10 Z3BII040700009 压盖 Cap 1
11 Z3BII040700010 调节螺丝 Adjusting Screw 1
12 GB41-86 螺母M8 Nut M8 1
13 GB93-87 垫圈8 Washer 8 5
14 GB893-86 挡圈30 Snap Ring 30 1
15 GB73-85 螺钉M10X1X10 Screw M10X1X10 1
16 GB5781-86 螺栓M8X25 Bolt M8x25 4
17 GB5781-86 螺栓M6X20 Bolt M6X20 4
18 GB93-87 垫圈6 Washer 6 4
19 GB308-77 钢球10 Ball 10 1
20 GB1152-74 油杯M6 Oil Cup M6 2
21 GB1096-79 键4X8 Key 4X8 1
22 GB1235-76 O型密封圈19X2.4 O-Ring 19X2.4 1
23 GB1235-76 O型密封圈50X3.5 O-Ring 50X3.5 1
24 GB6173-86 螺母M12X1.25 Nut M12X1.25 2
25 GB1235-76 O型密封圈54X3.5 O-Ring 54X3.5 1
26 GB/T276-1994 轴承61903 Bearing 61903 2

44
 前桥、后桥
Front Axle & Rear Axle

45
Z35H05 后桥（一） Rear Axle (I)

Z40F06 前桥 Front Axle

46
 Z35H05 后桥（一） Rear Axle (I)

Z40F06 前桥 Front Axle

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 GB119-86 销A12X120 Pin A12X120 6
2 GB119-86 销A12X100 Pin A12X100 6
3 Z30060000006 制动器活塞 Piston 4
4 Z30060000008 回位弹簧 Spring 12
5 Z35F0602 制动片 Brake Disc 4
6 Z30060000005 支板 Axle 4
7 Z30060000007 太阳轮 Sun Gear 4
8 Z300602 轮边减速器 Hub Reducer 4
9 Z30060000004 内齿圈 Inner Gear Ring 4
10 Z30060000003 锁紧螺母 Nut 4
11 Z30060000002 桥壳 Axle Case 2
12 Z300605 呼吸螺塞总成 Connector 2
13 Z30060000001 半轴 Half Shaft 4
14 Z30060000009 桥壳长螺栓 Bolt 32
15 Z30050000001 桥壳 Axle Case 2
B1 GB894.1-86 挡圈75 Snap Ring 75 4
B2 GB120-86 销B12X55 Pin B12X55 12
B3 GB297-93 轴承32018 Bearing 32018 4
B4 CG325-80 垫圈33 Washer 33 4
B5 CG326-80 螺塞 Plug M33X2 2
B6 GB297-93 轴承32020 Bearing 32020 4

47
Z35H05 后桥（一） Rear Axle (I)

Z40F06 前桥 Front Axle

48
 Z35H05 后桥（一） Rear Axle (I)
Z40F06 前桥 Front Axle
序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
B7 GB13871-92 密封圈FB150180 Seal Ring FB150180 4
B8 GB5786-86 螺栓M24X2X50 Bolt M24X2X50 64
B9 GB97.2-85 垫圈24 Washer 24 80
B10 GB5785-86 螺栓M24X2X180 Bolt M24X2X180 16
螺 栓
B11 GB5785-86 Bolt M16X1.5X100 12
M16X1.5X100
B12 GB97.2-85 垫圈16 Washer 16 64
B13 JB982-77 垫圈14 Washer14 4
B14 CG302.12-95 螺塞M14X1.5 Plug M14X1.5 4

49
Z40F0501
齿轮箱（一） Diferential(I)

Z40F0601

50
 Z40F0501
齿轮箱（一） Differential(I)
Z40F0601
序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 CG50.6.5 磁铁油塞 Plug 2
2 Z30050100001 后支承轴 Shaft 2
3 Z30060100011 制动器油缸 Cylinder 2
4 Z30050100005 齿轮箱壳体 Differential Body 1
5 Z30060100001 齿轮箱壳体 Differential Body 1
Z30060100002 油塞密封圈（II） Seal Ring (II) 4
6
Z30060100003 油塞密封圈（III） Seal Ring (III) 4
7 Z30060100015 油塞密封圈（I） Seal Ring (I) 4
8 Z30060100005 轴承外套（大端） Sleeve 2
9 Z30060100009 调整螺母（大端） Nut 2
10 Z30060100013 轴承外套（小端） Sleeve 2
11 Z30060100014 调整螺母（小端） Nut 2
12 Z30060100006 调整螺母锁紧垫圈 Nut 4
13 Z30060100027 排气塞 Plug 4
14 ZL30B.6.6 排气嘴 Connector 2
15 Z40F050100001 主动锥齿轮（后桥） Drive Bevel Gear 1
16 Z40F060100003 主动锥齿轮（前桥） Drive Bevel Gear 1
17 Z30060100016 主传动调节垫片 Gasket 2
18 Z40F060100002 中壳 Housing 2
19 Z30050100003 轴承压紧垫圈（后桥）Gasket 1
20 Z30060100006 螺母 Nut 1
21 Z30060100024 小盖纸垫 Gasket 2
22 Z40F060100005 小盖 Cap 2
23 CG50.6.1-21 防尘罩 Dust Cowl 2
24 Z40F050100002 连接凸缘（后桥） flange 1

51
Z40F0501
齿轮箱（一） Differential(I)
Z40F0601

52
 Z40F0501
齿轮箱（一） Differential(I)
Z40F0601
序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
25 CG50.6-23S 挡板 Retaining Plate 1
26 Z30060100021 压板 Plate 1
27 Z30060100019 轴承调节垫片 Gasket 1
28 Z30060100020 连接凸缘（前桥） Flange 1
29 Z30060100022 O型圈 o-Ring 1
30 Z30060100018 轴承压盖 Cap 1
B1 GB5786-86 螺栓M16X1.5X35 Bolt M16X1.5X35 6
B2 GB97.2-85 垫圈16 Washer 16 16
B3 CG325-86 垫圈33 Washer 33 4
B4 CG326-80 螺塞M33X2 Plug M33X2 4
B5 GB70-85 螺钉M12X80 Screw M12X80 6
B6 GB297-93 轴承32312 Bearing 32312 2
B7 GB3452.1-92 O形圈140X3.55 O-Ring 140X3.55 4
B8 GB97.2-85 垫圈16 Washer 16 16
B9 GB5786-86 螺栓M16X1.5X40 Bolt M16X1.5X40 16
B10 GB297-93 轴承30311 Bearing 30311 2
B11 GB97.2-85 垫圈8 Washer 8 12
B12 GB5786-86 螺栓M8X1X25 Bolt M8X1X25 12
B13 GB1387.1-92 密封圈075095 Seal Ring 075095 2
B14 GB5786-86 螺栓M12X50 Bolt M12X50 1

53
Z40F0501
齿轮箱（二） Differential(Ⅱ)
Z40F0601

54
 Z40F0501
齿轮箱（二） Differential(Ⅱ)
Z40F0601
序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z30060100025 半壳螺栓 Bolt 12
2 Z40F060100001 从动锥齿轮 Driven Bevel Gear 1
3 Z30060100012 差速器半壳I Differential Case I 1
4 CG50.6.1-9 大锥齿轮垫片 Pinion Gasket 2
5 CG50.6.1-12 大锥齿轮 Bevel Gear 2
6 CG50.6.1-14 小锥齿轮垫 Pinion Gasket 4
7 CG50.6.1-13 小锥齿轮 Pinion 4
8 Z30060100028 十字轴 Cross Shaft 1
9 Z30060100008 差速器半壳（II） Differential Case II 1
B1 GB297-93 轴承32019 Bearing 32019 1
B2 GB297-93 轴承32017 Bearing 32017 1

55
Z300602 轮边减速器 Hub Reducer

56
 Z300602 轮边减速器 Hub Reducer

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z30060200004 防转垫圈 Washer 6
2 Z30060200002 行星齿轮 Gear 3
3 Z30060200005 轴套 Sleeve 3
4 Z30060200003 行星轮轴 Planet Shaft 3
5 Z30060200001 行星架 Planet Carrier 1
B1 GB879-86 销8X35 Pin 8X35 3
B2 GB879-86 销5X35 Pin 5X35 3

57
轮胎总成 Rim Assembly

58
 轮胎总成 Rim Assembly

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
轮胎
1 Tire 17.5-25-12PR (TT) 4
17.5-25-12PR (TT)
2 Z300603 轮辋总成 Rim 4

59
Z35H0502 前支承架总成

Front Support Carrier

60
 Z35H0502 前支承架总成

Front Support Carrier

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z35H050200001 支承架 Support Carrier (Front) 1
2 Z30050200002 衬套 Bushing 1
3 GB893.1-86 挡圈190 Snap Ring 190 2
4 GB13871-92 油封FB160X190 Seal Ring FB160X190 2
5 GB1153-89 油杯M10X1 Oil Cup M10X1 1
6 GB5785-86 螺栓M20X2X150 Bolt M20X2X150 4
7 B97.2-85 垫圈20 Washer 20 4

61
Z35H0503 后支承架总成 Rear Support Carrier
Z35H0503 后支承架总成

Rear Support Carrier

62
 Z35H0503 后支承架总成 Rear Support Carrier

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z35H050300001 支承架 Support Carrier (Rear) 1
2 Z30050300002 端盖 Cover 1
3 Z30050300003 衬套 Bushing 1
4 Z30050300004 耐磨板 Plate 2
5 Z30050300005 转盘 Disc 1
6 ZL30B.6.6 排气嘴 Exhaust Hole 1
7 GB5785-86 螺栓M20X2X140 Bolt M20X2X140 4
8 GB97.2-85 垫圈20 Washer 20 4
9 GB119-86 销A20X60 Pin A20X60 2
10 GB1152-89 油杯M10X1 Oil Cup M10X! 1
11 GB5786-86 螺栓M12X1.5X40 Bolt M12X1.5X40 6
12 GB97.2-85 垫圈12 Washer 12 12
13 GB5786-86 螺栓M12X1.5X30 Bolt M12X1.5X30 6
14 GB3452.1-92 O形圈100X5.3 O-Ring 100X5.3 1

63
 前传动轴
Front Driving Shaft

64
Z35F07 前传动轴

Front Drive Shaft

65
 Z35F07 前传动轴 Front Drive Shaft

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z35F0701 中间轴及支承 Shaft and Support 1
2 Z35F0702 变速箱前轴 Shaft 1
B1 GB889-86 螺母M12 Nut M12 24
B2 GB93-87 垫圈12 Washer 24
B3 GB5783-86 螺栓M12X45 Bolt M12X45 24

66
 转向系统
Steering System

67
Z35H08T13 转向系统 Steering System

68
 Z35H08T13 转向系统(一) Steering System (Cab I)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 ф38X100 耐油胶管 Pipe 1
2 ф38Xф57 喉箍38-57 Hoop 2
3 Z35H0801T13 吸油管总成 Suck Tube Assembly 1
4 P5100-F63CX 齿轮泵(左旋) Gear Pump 1
5 Z35H0802T13 出油管总成 Inlet Pipe 2
20591-42-16T/20511-36-
6 软管总成 Hose 1
16X3M16GTX620
7 1DFL-36-16(L100) 接头 Connector 1
8 NMD-14-36-36 接头 Connector 1
9 Z35H0801 转控阀组总成 Valve Assembly. 1
10 Z35C0803 转控阀支座 Valve Support 1
20491-14-04/20411-14-0
11 软管总成 Hose 1
4X1T04GTX1200
12 1CH-14-12 接头 Connector 1
13 2C9-14 接头 Connector 1
14 BZZ5-630 转向器 Steering Unit 1
15 1CH-26-20 接头 Connector 4
20411-26-12/87391-12-1
16 软管总成 Hose 1
2X2T12GTX900
20411-26-08TX2T08GT
17 软管总成 Hose 1
X2050
18 1CH-26-22 接头 Connector 4
19 BC-26 接头 Connector 2
GO135FZ80/45E-415-
20 油缸80/45-415X803 Cylinder 2
803
21 Z300802 前油缸销总成 Pin Assembly. 2
22 Z300807 后油缸销总成 Pin Assembly. 2
20411-26-08TX2T08GT
23 软管总成 Hose 2
X1850
24 TTPG1-322 双联管夹 Clamp 4

69
 Z35H08T13 转向系统(二) Steering System (Cab II)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
20411-26-12X1T12GTX
25 软管总成 Hose 1
1420
20411-14-04/20491-14-0
26 软管总成 Hose 1
4X1T04GTX1120
87341-16-12/20411-30-1
27 软管总成 Hose 1
2X1T12GTX1030
28 2C9-30 接头 Connector 1
29 Z35H0803 润滑油管总成 Pipe 2
30 TTPG1-428 双联管夹 Clamp 1
31 GQ22 管夹 Clamp 1
32 GB1152-89 油杯M10X1 Oil Cup M10X1 2
33 GB5783-86 螺栓M12X30 Bolt M12X30 4
34 GB5783-86 螺栓M12X60 Bolt M12X60 2
35 GB93-87 垫圈12 Washer12 12
36 GB/T898-1988 双头螺柱AM12X37 Bolt M12X37 2
37 GB41-86 螺母M12 Nut M12 2
38 GB5783-86 螺栓M12X35 Bolt M12X35 4
39 GB5783-86 螺栓M10X45 Bolt M10X45 4
40 GB93-87 垫圈10 Washer10 4

70
 Z35H0801 转控阀组总成 Valve Assembly

Z35H0801 转控阀组总成 Valve Assembly

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
Transmission Control
1 YSF25 转控阀组 1
And Soft Shaft
2 FL-12 法兰直角接头 Connector 1
3 FL-16 法兰 Flange 1
4 1CL-14-12 端直通接头 Connector 2
5 2C9-14 90°过渡接头 Connector 1
6 PT-3 测压接头 Pressure-testing 1
7 GB5783-86 螺栓M10X80 Bolt M10X80 3
8 GB93-87 垫圈10 Washer 10 3

71
 制动系统
Braking System

72
Z35H09T4 制动系统 Brake System

73
 Z35H09T4 制动系统 Brake System

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z35H0901T4 脚制动阀总成 Brake Valve Assembly 1
2 Z35H0902T4 蓄能器支架总成 Accumulator Bracket 1
3 NXQ1-L1/31.5-H 行车蓄能器 Accumulator 2
4 Z35F0901L 充液阀总成 Accumulator Charge Valve 1
5 Z300909 手制动操纵机构 Control machine 1
6 1DO-36-12 过渡接头 Connector 2
20592-36-12T/205
7 92-36-12TX4SM1 胶管总成 Hose Assembly 1
2GJX900V0
20491-18-05T/204
8 11-18-05TX2T05I 胶管总成 Hose Assembly 2
TX1100
9 2C9-18 弯接头 Connector 6
10 CC-18 三通接头 Connector 2
11 1CO-18-08 过渡接头 Connector 3
12 2C-18-30 过渡接头 Connector 2
13 1CL-30-27 过渡接头 Connector 2
20411-18-05T/204
14 91-18-05TX1T05I 胶管总成 Hose Assembly
TX1600 1
20411-18-05TX1T
15 过渡接头 Connector
05ITX900 1
2041-18-05TX1T0
16 过渡接头 Connector
5ITX515 4
2041-18-05TX1T0
17 胶管总成 Hose Assembly
5ITX515 1
18 CC-18 三通接头 Connector 4
19 1CH9-18-14OG 过渡接头 Connector 3
20 1CH-18-14 过渡接头 Connector 1

74
 Z35H09T4 制动系统 Brake System

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
21 LCOM-18-08-14OG 三通接头 Connector 1
20411-18-05T/20491-18-0
22
5TX1T05ITX510 胶管总成 Hose Assembly 1
20411-18-05T/20491-18-0
23
5TX1T05ITX510 胶管总成 Hose Assembly 1
20491-18-06T/20411-18-1
24 Hose Assembly
6X1T06ITX1100 胶管总成 1
低压报警开关总
25 Low -force on-off
Z35H0903T4 成 1
26 Z35F0904L 弯管总成 Guide 1
27 Z35C0903 弯管总成 Guide 1
28 Z35C0904 弯管总成 Guide 1
29 Z300900007A 油管支架 board 1
30 Z300900005A 油管支架 board 1
31 Z35F0911L 前制动弯管总成 Guide 1
32 Z35F0905L 弯管总成 Guide 2
33 Z35F0906L 弯管总成 Guide 1
34 AC-18 三通接头 Connector 1
35 Z35F090000017A 管夹 Clip 2
36 GB5783-86 螺栓 M8X15 Bolt M8X15 2
37 GB93-87 垫圈 8 Washer 8 2
38 GB5783-86 螺栓 M10X30 Bolt M10X30 4
39 GB93-87 垫圈 10 Washer 10 8
40 GB5783-86 螺栓 M10X30 Bolt M10X30 4

75
Z35H0901T4 脚制动阀总成 Service Brake Valve Assembly

76
 Z35H0901T4 脚制动阀总成 Service Brake Valve Assembly

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 BC-18 三通接头 Tee Joint 2
2 1CO-18-06 端通接头 Connector 5
3 2C9-18 直角接头 Connector 2
测 压 接 头
4
1-906-24-30-010 （M14X1.5） Connector 2
5 06-466-210 脚制动阀 Service Brake Valve 1
6 2LC-16-18 直角接头 Connector 2
GLNL-16-02-14C
7 Tee Joint
G 三通接接头体 1
8 GL-16-10-14CG 三通接接头体 Tee Joint 1
9 Z30090200004 螺塞 Stem 1
10 32-580-022 行车制动灯开关 Switch 1
11 4N-02 堵头 Stem 1

77
Z35H0902T4 蓄能器支架总成 Accumulator Bracket

78
 Z35H0902T4 蓄能器支架总成 Accumulator Bracket

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
Z35H090200001T
1
4 蓄能器支架 Accumulator Bracket 1
2 Z35C0902000002 蓄能器支架横板 Accumulator Bracket 1
3 Z30090000013 蓄能器卡箍 Accumulator clip 4
4 Z30090000012 中间卡箍 Middle clip 1
5 GB5783-86 螺栓 M10X30 Bolt M10X30 3
6 GB6170-86 螺母 M10 Nut M10 3
7 GB93-87 垫圈 10 Washer 10 3

79
Z35F0901L 充液阀总成
Accumulator Charge Valve

80
 Z35F0901L 充液阀总成
Accumulator Charge Valve

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 1DO-36-12 端直通接头 Connector 2
LCOM-08-18-14O
2 三通接头 Connector 1
G
测 压 接 头
3 1-906-24-30-010 Connector 2
（M14X1.5）
4 1CO-18-08 端直通接头 Connector 2
5 CC-18 三通接头体 Connector 1
6 06-463-200 充液阀 Accumulator Charge Valve 1
7 Z30090101008 螺栓 Bolt 2
8 GB93-87 垫圈 10 Washer 10 2
9 NMD-14-36-36 三通接头 Connector 1
10 JB982-77 垫圈 14 Washer 14 2

81
 工作液压系统
Implement Hydraulic System

82
Z35H10T13 工作系统 Work hydraulics System

83
 Z35H10T13 工作系统 Work hydraulics System

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z35H1001T13 液压油箱 Hydraulic oil box 1

2 Z35F1001L 油箱吸油管总成 Suck Tube Assembly 1

Pump Suck Tube
3 Z35H1002T13 泵吸油总成 2
Assembly
4 Z35F100000004A 吸油软管 Suck tube 1
20441-36-16/20411-36-1
5 胶管总成 Hose assem 1
6X1T16GTX400
6 1CFL9-36-16W 法兰接头 Flange 1
7 1CFL9-18-08W 法兰接头 Flange 1
P5100-F40TF486
8 双联泵 Unit pump 1
14/P124-GY18G
9 Z35H1006T13 法兰总成 Flange 1
20592-36-12T/20592-36
10 -12 （ H130 ） 胶管总成 Hose assem 1
TX4SM12GJX580V270
11 Z35F1015L 汇流座总成 Value assem 1
87391-20-16T/20591-42
12 胶管总成 Hose assem 1
-16TX3M16GJX2250V0
13 Z35H1003T13 多路阀总成 Value assem 1
14 Z40F1005T13 翻斗缸大腔钢管 Cylinder pipe 1

15 Z40F1004T13 翻斗缸小腔钢管 Cylinder pipe 1

20512-36-12T/20592-36
16 胶管总成 Hose assem 1
-12TX4SM12GJX1170
20512-36-12TX4SM12G
17 胶管总成 Hose assem 1
JX1120
18 Z35F1006L 翻斗缸总成 Cylinder assem 1
87392-12-12/87342-12-1
19 2X4SP12TKX1250V270 胶管总成 Hose assem 1
+RM

84
 Z35H10T13 工作系统 Work hydraulics System

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
87392-12-12(H130)/87
20 342-12-12X4SP12TKX 胶管总成 Hose assem 1
1250V270+RM
87392-12-12/87342-12-
21 12X4SP12TKX1250V9 胶管总成 Hose assem 1
0+RM
87392-12-12(H130)/87
22 342-12-12X4SP12TKX 胶管总成 Hose assem 1
1250V90+RM
23 Z35F1005A 左提升缸总成 Cylinder assem 1
24 Z35F1009A 右提升缸总成 Cylinder assem 1
25 Z35H1006 管卡总成 Clips assem 1
20411-45-20T/87391-2
26 胶管总成 Cylinder assem 1
4-20TX1M20GTX1365
27 FL-24 法兰 Flange 1
28 Z35H1005 回油管夹总成 Clips 1
29 6C-45 隔壁接头 Connector 1
20411-45-20TX1M20G
30 胶管总成 Cylinder assem 1
TX1050
31 Z50F1015A 先导管管夹 Clip 1
32 Z35C1007 回油管夹总成 Clip assem 1
33 Z35H1004T13 先导阀总成 Value assem 1

34 Z5EH1004T4 手柄安装盒 Manul –set box 1

35 Z35H1005T13 回油管总成 Pipe assem 1

20411-30-12/20491-30-
36 胶管总成 Cylinder assem 2
12X1T12GTX1700
37 LH-ZL35F 散热器 Radiator 1
38 2C9-30 弯头 Bowl 2
39 GB93-87 垫圈10 Nut 10 12

85
 Z35H10T13 工作系统 Work hydraulics System

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
40 GB5783-86 螺栓M10X25 Bolt M10X25 8

41 GB5783-86 螺栓M12X35 Bolt M12x35 2

42 GB93-87 垫圈14 Washer 14 2

43 Z35C100000001 纸垫 Paper cushion 1
44 Z50E100000001 管夹 Clip 2
45 GB93-87 垫圈8 Washer 8 4
46 GB5783-86 螺栓M8X30 Bolt M8X30 2
47 GB6170-86 螺母M8 Nut M8 2
48 GB5783-86 螺栓M10X30 Bolt M10x30 4
49 GB6170-86 螺母M10 Nut M10 4
50 1CH-22-33 接头 Connector 1
20411-22-08X1T08GT
51 脱管总成 Hose 1
X1200
52 4C-22 堵头 Bolt 1
53 FL-20 法兰 Flange 1

86
Z35H1001T13 液压油箱 Hydraulic oil box

87
 Z35H1001T13 液压油箱 Hydraulic oil box

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z35H100100001T13 围板 Boarding 1

2 Z35H100100002T4 封板 Cover 1

3 Z35H100100003 回油内管 Pipe 1

4 Z30100100011 回油法兰座 Flange set 1
5 Z30100100001 吸油法兰座 Suck tube set 1
6 Z30100100020 吸油内管（I） Suck tube 1
180 ° 无 缝 弯 头
7 Z30100100023 180° bowl 64X4 1
64X4
8 Z35H100100004 吸油内管 Suck tube 1
9 SFM-679A 吸油滤芯 Filter 1
10 LX331B 回油滤芯 Filter 1
11 Z50E100100010 回油法兰 Flange 1

12 Z50E100100011 密封垫 Sealed washer 1

13 Z50E100100012 盖板 Cover 1
14 CG50.10.4-3 弹簧 Spring 2
15 Z5EH100100001T4 法兰 Flange 1
16 Z35C100100008 密封垫 Sealed washer 1
17 SAF-50A-40/L135 空气滤清器 Air cleaner 1
18 Z35H100101 滤油器壳体总成 Oil cleaner cover 1
19 Z40F100100003T13 清洗法兰座 Cleaner flange 2
20 GB3452.1-92 O形圈180X3.55 O-ring 180X3.55 2
21 Z40F100100002T13 清洗法兰 Flange 2
22 Z35H100100005T13 隔板 Ban 1
23 CG50.10.4.1-6 油标座板 Oil mark seat 1
24 YWZ-150 液位计 Position mark 1
25 Z30100100003 支座 Seat 2

88
 Z35H1001T13 液压油箱 Hydraulic oil box

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
26 PQF-12 放气阀 Deflation valve 1

27 ZL40.10.1.1-16 吊环 Flying rings 2

28 Z30100000002 油箱支座 Oil box seat 2

29 Z30100100014 侧板 Board 2
30 Z30100100013 搭板 Board 1
31 Z30100102 搭板 Board 2
32 Z30100100010A 放油接头座 Connector seat 1
33 Z30100100012 座子 Seat 6
34 GB97.1-85 垫圈4 Washer 4 2
35 GB818-85 螺钉M4X16 Bolt M4X16 2
36 GB93-87 垫圈8 Washer 8 18

37 GB5783-86 螺栓M8X25 Bolt M8X25 6

38 GB5783-86 螺栓M8X20 Bolt M8X20 12

39 GB5783-86 螺栓M20X70 Bolt M8X70 4
40 GB93-87 垫圈20 Washer 20 4
41 1CH-22-33 接头体 Connector 1
90 度 弯 头 DN40
42 90E（S） 90°bwol 1
（OD45）
43 Z35F100100016A 小回油管 Little pipe 1
44 Z35F100100017A 回油接头座 Connector 1
45 2LC-16-18 过渡接头 Connector 1
46 Z35H100100005T4 油箱垫板 Oil-box ban 2

89
Z35H1004T13 先导阀总成 Value assem

90
 Z35H1004T13 先导阀总成 Value assem

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 YLF10 背压阀 Vavle 1

2 DXS-00 单手柄先导阀 Vavle 2

20491-18-06/20411-18-
3 胶管总成 Hose assem 2
06X1T06ITX600
20411-18-06/20491-18-
4 胶管总成 Hose assem 2
06X1T06ITX1200
5 1CH-18-16 端直通接头 Connector 1
6 2LC-16-18 过渡接头 Connector 2

7 RD12-L 单向阀 Valve 1

8 6C-18LN 隔壁接头 Connector 6

9 2ZC-08-18 端直通组合接头 Connector 2
10 PT-3 测压接头 Connector 2
20411-18-06/20491-18-
11 胶管总成 Hose assem 18
06X2T06ITX390
20411-18-06/20491-18-
12 胶管总成 Hose assem 6
06X1T06ITX450
20491-16-04/20411-16-
13 胶管总成 Hose assem 12
04X1T04AGX2750
20411-16-04X1T04AG
14 胶管总成 Hose assem 4
X2250
SBO210-0.32E1/112A-
15 蓄能器 Accumulator 4
210AK60
16 GB93-87 垫圈10 Washer 10 1
17 GB5783-86 螺栓M10X20 Bolt M10X20 1
18 GB5783-86 螺栓M10X50 Bolt M20X50 1
19 BC-18 三通接头 Connector 1
20 1CH-16-14 接头体 Connector 1
21 1CH9-18-14OG 直接头 Connector 2

91
 Z35H1004T13 先导阀总成 Value assem

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
22 1CH-16-14L65CG 过渡接头 Connector

23 1CH9-18OG 过渡接头 Connector

24 1CH9-16-14OG 可调向接头 Connector

25 2C9-18 过渡接头 Connector
20411-18-06X1T06AG
26 胶管总成 Hose assem
X1650
20411-16-04X1T04AG
27 胶管总成 Hose assem
X2750
28 CC-18 三通接头 Connector

92
Z40F1003T13 多路阀总成 Multi-Way Inverter Valve

93
 Z40F1003T13 多路阀总成 Multi-Way Inverter Valve

序号 代 号 名 称 数 量 备注
Item Part No. Parts Name Q’ty Remark
Multi-Way Inverter
1 D32 多路阀 1
Valve
提升缸大腔硬管总
2 Z40F100301T13 Steel tube 1
成
提升缸小腔硬管总
3 Z40F100302T13 Steel tube 1
成
4 Z40F100300001T13 多路阀底板 Board 1

5 GB93-87 垫圈 12 Washer 12 7

6 GB5783-86 螺栓 M12X30 Bolt M12X30 4

7 GB97.1-85 垫圈 12 Washer 12 3

8 GB5782-86 螺栓 M12X150 Bolt M12X150 3

9 1CH-16-14 过渡接头 Connector 5

10 Z40F100300002T13 法兰 Flange 1

11 GB5782-86 螺栓 M12X95 Bolt M12X95 1

12 GB3452.1-92 O 形圈 47.5X3.55 O_Ring 47.5X3.55 1

13 1CH9-16-14OG 可调向接头 Connector 3

94
Z35F1005A 左提升缸总成 Left Lift Cylinder Assembly

95
 Z35F1005A 左提升缸总成 Left Lift Cylinder

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
G0130FJ125/70E
1 提升油缸 Lift Cylinder
.00
左提升缸大腔硬
2 Z30100501 Pipe
管
左提升缸小腔硬
3 Z35F100502A Pipe
管
4 GQ22 标准管卡 Clip
5 GK125A 油缸卡套 Clip

96
Z35F1006L 翻斗缸总成 Tilting Cylinder Assembly

97
 Z35F1006L 翻斗缸总成 Tilting Cylinder Assembly

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
G0130FF150/75
1 翻斗油缸 Tilting Cylinder Assembly 1
E.00
2 Z35F100601L 翻斗缸大腔硬管 Pipe 1
3 Z35F100602L 翻斗缸小腔接头 Connector 1
4 GQ32 标准管卡 Clip 1
5 GK150B 油缸卡套 Clip 1

98
Z35F1009L 右提升缸总成 Right Lift Cylinder Assembly

99
 Z35F1009L 右提升缸总成 Right Lift Cylinder Assembly

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
G0130FJ125/70E
1 提升油缸 Lift Cylinder 1
.00
右提升缸大腔硬
2 Z30100901 Pipe 1
管
右提升缸小腔硬
3 Z35F100902A Pipe 1
管
4 GK125A 油缸卡套 Clip 1
5 GQ22 标准管卡 Clip 1

100
 后传动轴
Rear Driving Axle

101
Z35F11 后传动轴 Rear Drive Shaft

102
 Z35F11 后传动轴 Rear Drive Shaft

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z35F11 后传动轴总成 Rear Drive Shaft 1
B1 GB5783-86 螺栓M12X40 Bolt M12X40 16
B2 GB93-87 垫圈12 Washer 12 16
B3 GB889-86 螺母M12 Nut M12 16

103
 车身车架
Frame Group

104
Z35H12T13 车身车架（一） Frame Group(Ⅰ)

105
 Z35H12T13 车身车架（一） Frame Group(Ⅰ)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z301213 上铰接销轴总成 Pin Shaft 1
2 Z30120000009 上铰接轴承上盖 Bearing Cover 1
3 Z30120000010 调整垫片 Adjusting Shim 1
4 Z30120000011 上铰接轴承下盖 Lower Bearing Cover 1
5 Z30120000002 支撑杆 Support Rod 1
6 Z301202 左前护泥板总成 Left Front Fender Assembly 1
提升油缸销轴总
7 Z301205 Pin Shaft 2
成
8 Z301206 动臂销轴总成 Pin Shaft 2
9 Z35H1201T4 前车架 Front Frame 1
翻斗油缸销轴总
10 Z301204 Pin Shaft 1
成
Z30120000007 5组
11 垫片 Washer
Z30120000008 5组
12 Z301203 右前护泥板总成 Right Front Fender Assembly 1
13 Z30120000005 前封板 Front Seal Plate 1
14 Z30120000001 插销 Pin 2
15 Z35H120000001 垫圈 Washer 5
16 Z30120000024 垫片 Washer 1组
B1 GB5783-86 螺栓 M12X55 Bolt M12X25 1
油 封
B2 HG4-692-67 Oil Seal PD60X80X12 2
PD60X80X12
B3 GB297-94 轴承32012 Bearing 32012 2
B4 GB91-86 销4.5X45 Pin 4.5X45 2
B5 JB/T7940.1-95 油杯M10X1 Oil Cup M10X1 7
B6 GB5783-86 螺栓M12X25 Bolt M12X25 5
B7 GB5783-86 螺栓M12X35 Bolt M12X35 8
B8 GB93-87 垫圈12 Washer 12 8
B9 GB96-85 垫圈12 Washer 12 8

106
Z35H12T13 车身车架（一） Frame Group(Ⅰ)

107
 Z35H12T13 车身车架（一） Frame Group(Ⅰ)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
B10 GB96-85 垫圈6 Washer 6 4
B11 GB93-87 垫圈6 Washer 6 4
B12 GB5783-86 螺栓M6X16 Bolt M6X16 4

108
Z35H12T13 车身车架（二） Frame Group（Ⅱ）

109
 Z35H12T13 车身车架（二） Frame Group（Ⅱ）

序号 代 号 名 称 数量 备注
Item Part No. Part Name Q’ty Remark
1 Z30120903 后侧板组合 Plate 2

2 Z30120903002 密封条 Seal Strip 2

3 Z30120902 上侧板组合 Plate 2

4 Z30120904003 密封条 Seal Strip 2

5 Z35H120904T11 下侧板组合 Plate 2

6 Z301209041 钢丝扣 Wire Rope 2

7 Z35H120901T13 机罩体 Hood 1

8 Z35F1209012T12 门架 Bracket 1

9 Z35F120902T4 格架 Bracket 1

10 Z30120901001 拉钩 Hook 1

B1 GB5781-86 螺栓M8×20 Bolt M8×20 8

B2 GB95-85 垫圈8 Washer 8 30

B3 GB5781-86 螺栓M10×25 Bolt M10×25 32

B4 GB93-87 垫圈10 Washer 10 40

B5 GB5781-86 螺栓M12×30 Bolt M12×30 63

B6 GB93-87 垫圈12 Washer 12 81

B7 GB95-85 垫圈12 Washer 12 57

B8 GB5781-86 螺栓M12×30 Bolt M12×30 14

B9 GB95-85 垫圈12 Washer 12 18

B10 GB95-85 垫圈10 Washer 10 80

B11 GB91-86 销2.5×25 Pin 2.5×25 10

110
Z35H12T13 车身车架（二） Frame Group（Ⅱ）

111
 Z35H12T13 车身车架（二） Frame Group（Ⅱ）

序号 代 号 名 称 数量 备注
Item Part No. Part Name Q’ty Remark
B12 GB5781-86 螺栓M10×20 Bolt M10×20 14

B13 GB5781-86 螺栓M6×12 Bolt M6×12 4

B14 GB819-85 螺钉M5×10 Screw M5×10 2

B15 GB93-87 垫圈6 Washer 6 4

B16 GB95-85 垫圈6 Washer 6 4

112
Z35H12T13 车身车架（三） Frame Group(Ⅲ)

113
 Z35H12T13 车身车架（三） Frame Group(Ⅲ)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z40F1207T13 左后护泥总成 Left Plate Assembly 1
2 Z40F1208T13 右后护泥总成 Right Plate Assembly 1
W50E01-0001 右围板 Right Surrounding Plate
3 1
W50E01-0002 左围板 Leftt Surrounding Plate
4 W50E01-0101 前围板 Front Surrounding Plate 1
7 Z35H1212T2 扶梯 Staircase 1
B3 GB5783-86 螺栓M16X40 Bolt M16X40 4
B4 GB93-87 垫圈16 Washer 16 4
B5 GB96-85 垫圈16 Washer 16 4
B6 GB5783-86 螺栓M10X20 Bolt M10X20 11
B7 GB96-85 垫圈10 Washer 10 11

114
Z35H12T13 车身车架（四） Frame Group(Ⅳ)

115
 Z35H12T13 车身车架（四） Frame Group(Ⅳ)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z30120000012 下铰接销轴 Pin Shaft 1
2 Z30120000013 挡环 Snap Ring 1
3 Z30120000014 下铰接轴承上盖 Bearing Cover 1
4 Z30120000015 上调整垫片 Shim 1组
5 Z30120000016 挡环 Snap Ring 1
6 Z30120000017 下铰接轴承下盖 Bearing Cover 1
7 Z30120000018 挡环 Snap Ring 1
8 Z30120000021 调整垫片 Shim 1组
9 Z30120000019 孔板 Hole Plate 1
10 Z30120000020 止动垫圈 Washer 2
11 Z35H1210T13 后车架总成 Frame Assembly 1
12 Z35F121003 电瓶箱 Battery Box Body 2
13 Z35F121003004 花纹板 Plate 2
14 Z30120000003 牵引销 Pin 1
15 Z35F120000002 加长螺栓 Bolt 4
16 Z35F120000001 附加配重 Ballast 2
17 Z30121011002 限位块 Body 2
B1 GB5782-86 螺栓M12X100 Bolt M12X100 7
B2 GB93-87 垫圈12 Washer 12 13
油 封
B3 HG4-692-67 Oil Seal PD90X110X12 2
PD90X110X12
B4 GB297-93 轴承32214 Bearing 32214 2
B5 GB5783-86 螺栓M16X45 Bolt M16X45 4
B6 GB5783-86 螺栓M12X35 Bolt M12X35 6
B7 GB5783-86 螺栓M8X25 Bolt M8X25 8
B8 GB96-85 垫圈8 Washer 8 8

116
Z35H12T13 车身车架（四） Frame Group(Ⅳ)

117
 Z35H12T13 车身车架（四） Frame Group(Ⅳ)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
B9 GB93-87 垫圈8 Washer8 2
B10 GB5783-86 螺栓M8X27 BoltM8X27 2
B11 GB93-87 垫圈24 Washer24 4

118
驾驶室
Cab

119
FSJ302 仪表台总成 Cab Plateform Assembly

120
 FSJ302 仪表台总成 Cab Plateform Assembly

序号 代 号 名 称 数量 备 注
Item Part No． Parts Name Q'ty Remark
1 FSJ302 仪表台总成 Pannel Assembly 1

2 GB93-87 垫圈8 Washer 12 4

3 GB97.1-86 垫圈8 Washer 12 4

4 GB5783-86 螺栓M8X20 Bolt M8X30 4

121
Z50E130103T38 右车门 Right Door
Z50E130102T38 左车门 Left Door

122
 Z50E130103T38 右车门 Right Door
Z50E130102T38 左车门 Left Door

序号 代 号 名 称 数量 备注
Item Part No Parts Name Q'ty Remark
1 Z50E130103T38 右车门 Right Door 1
2 车门密封条 Seal Strip 1
3 右车门玻璃 Door Glass 1
4 GMS502 左车门锁 Locker 1
5 左车门玻璃 Door Glass 1
6 车门密封条 Seal Strip 1
7 Z50E130102T38 左车门 Door 1

123
Z35H13T13 驾驶室 Cab

124
 Z35H13T13 驾驶室 Cab

序号 代 号 名 称 数量 备注
Item Part No Parts Name Q'ty Remark
1 Z35H1301T13 机棚 Cab Body 1
2 倒车镜 Mirror 2
3 Z50E1304T38 倒车镜支座 Mirror Bracket 2
4 Z50E1306T38 扶手 Handrail 2
5 Z35H130000004T 座椅支架 Seat Bracket 1
12
6 CB2205-72 减振器 Absorber 4
7 Z35H130000001 螺栓 Bolt 4
8 Z3BII130000021 锥形垫 Prick Mat 4
9 前窗玻璃 Front Window Glass 1
10 前侧窗玻璃 Front Side Window Glass 2
11 后侧窗胶条 Rear Side Window Rubber Strip 2
12 后窗玻璃 Rear Window Glass 1
13 后窗玻璃胶条 Rear Window Rubber Strip 1
14 GB825-86 吊环螺栓M16X25 Bolt M8X25 4
15 Z50E130100003T 密封圈 4
10
16 后侧窗玻璃 Rear Side Window Glass 2
17 GB93-87 垫圈8 Washer 8 16
18 GB97.1-86 垫圈8 Washer 8 16
19 GB5783-86 螺栓M8X20 Bolt M8X20 16

125
CGZY—3H 座椅 Seat

126
 CGZY—3H 座椅 Seat

序号 代 号 名 称 数量 备注
Item Part No Parts Name Q'ty Remark
1 CGZY—3H 座椅 Seat 1
B1 GB5781-86 螺栓M8X20 Bolt M8X20 4
B2 GB93-87 垫圈8 Washer 8 4
B3 GB848-85 垫圈8 Washer 8 4

127
 工作装置
Implement

128
Z35F14 工作装置（一） Implement (Ⅰ)

129
 Z35F14 工作装置（一） Implement (Ⅰ)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z35F1402 动臂 Arm 1
2 Z30140000005 垫片 Washer 2
3 Z30140000006 轴套 Bushing 2
4 Z301409 销轴 Pin Shaft 2
5 Z30140000007 轴套 Bushing 2
6 Z301410 销轴 Pin Shaft 2
7 Z30140000009 垫片 Washer 2
8 Z30140000008 轴套 Bushing 2
9 Z30140000001 螺栓套 Bushing 6
骨架式橡胶油封 Skeleton Dust Seal Ring
B1 HG4-692-67 8
PD60X80X12 PD60X80X12
B2 GB5783-86 螺栓 M12X30 Bolt M12X30 4
B3 GB93-87 弹簧垫圈 12 Washer 12 4
骨架式橡胶油封 Skeleton Dust Seal Ring
B4 HG4-692-67 4
PD50X70X12 PD50X70X12
骨架式橡胶油封 Skeleton Dust Seal Ring
B5 HG4-692-67 4
PD55X75X12 PD55X75X12
B6 GB1152-89 油杯 M10X1 Oil Cup M10X1 8

130
Z35F14 工作装置（二） Implement ( II )

131
 Z35F14 工作装置（二） Implement ( II )

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z301405 销轴 Pin Shaft 1
2 Z30140000003 轴套 Bushing 2
3 Z301406 销轴 Pin Shaft 1
4 Z30140000004 摇臂 Rocker 1
5 Z30140000002 轴套 Bushing 2
6 Z301408 销轴 Pin Shaft 1
7 Z301407 拉杆 Pull Rod 1
8 Z301404 销轴 Pin Shaft 1
骨架式橡胶油封 Skeleton Dust Seal Ring
B1 HG4-692-67 4
PD80X100X12 PD80X100X12
B2 GB5783-86 螺栓 M20X35 Bolt M20X35 6
B3 GB1152-89 油杯 M10X1 Oil Cup M10X1 8
骨架式橡胶油封 Skeleton Dust Seal Ring
B4 HG4-692-67 8
PD60X80X12 PD60X80X12

132
Z35F14 工作装置（三） Implement (III)

133
 Z35F14 工作装置（三） Implement (III)

序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty Remark
1 Z35F1401A 铲斗 Bucket 1
2 Z30140100001 右侧斗齿 Teeth 7
3 Z30140100011 螺栓 Bolt 4
4 Z30141000003 卡环 Clip 8
5 Z30140200001 斗齿体 Bucket Tooth 6
6 Z30140100002 销轴 Pin Shaft 8
7 Z30140100004 齿靴 Boot-Bucket Tooth 8
8 Z30141100001 左侧斗齿体 Teeth 1
9 Z30140100010A 螺栓 Bolt 12
10 Z35F140000001 螺栓 Bolt 14
11 Z35F140000002 可卸防磨板 Assemble Bucket Blade 7
B2 GB6170-86 螺母M20 Nut M20 30

134
 电气设备
Electrical Apparatus

135
Z35H15T13 布置图 1 Electrical Layout

136
Z35H15T13 布置图 2 Electrical Layout

137
Z35H15T13 原理图 Electrical Principle Scheme

138
 Z35H15T13 电气元件 Electrical Element
序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty. Remark
1 DK231 电源继电器 Battery disconnect relay 1

2 6-QW-120B 蓄电池 Battery 2

3 QD274/6.6KW 起动机 Starting motor 1

4 HG4735 六檔保险盒 Fuse Box 1

5 MZJ-50A/006 起动继电器 Starting additional relay 1

6 JFZ2904/45A 交流发电机 Alternator 1

7 LED/24V 红 充电指示灯 Battery Charge Indicator 1

8 JK406 预热起动开关 Key switch 1

9 YT-2/0-1.0Mpa 机油压力表 Engine oil pressure gauge 1

10 YT-2/0-3.2Mpa 换档油压表 Trans. oil pressure gauge 1

11 1756ES/24V 停机电磁阀 Shutdown Valve 1

12 DV-2/18-32V 电压表 Voltmeter 1

13 DW-2/40-120ºC 发动机水温表 Coolant Temp. Gauge 1

14 WG-2 发动机水温传感器 Coolant Temp. Sensor 1

15 DW-2/40-140ºC 变矩器油温表 TC. Oil Temp. Gauge 1

16 WG-2 变矩器油温传感器 TC. Oil Temp. Sensor 1

17 DR-2 燃油表 Fuel Gauge 1

18 RG-4/330mm 油位传感器 Fuel level sensor 1

19 WK-3/常闭 手制动灯开关 Hand brake indicator switch 1

139
 Z35H15T13 电气元件 Electrical Element
序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty. Remark
20 2.32/24V LED 手制动指示灯 Hand brake indicator 1

21

22 701DN001 工作小时计 Engine hour meter 1

23 JK981-000-3.67 前工作灯开关 Front working lamp SW. 1

24 CG 70W 前工作灯 Front working lamp 2

25 JK981-000-3.67 后工作灯开关 Rear working lamp switch 1

26 CG 70W 后工作灯 Rear working Lamp 2

27 JQ603B 转向灯闪光器 Turn signal flasher 1

28 JK700 转向灯开关 Turn signal switch 1

29 JK981-196-2.4 危险报警灯开关 Hazard warning lamp SW. 1

30 3.2/24V LED 绿 左转向指示灯 Turn left light indicator 1

31 3.3/24V LED 绿 右转向指示灯 Turn right light indicator 1

32 70W/8W/21W 组合前灯 Combination headlamp 2

33 21W/24V 后转向灯 Rear turn lamp 2

34 JK981-090-5114 大小灯开关 Headlamp/side light switch 1

35 2W/24V 仪表内装灯 Instrument panel lamp 6

36 21W+8W/24V 组合后灯 Combination tail lamp 2

37 32-580-042 制动低压开关 Low brake pressure switch 1

38 11.2/24V LED 制动低压指示灯 Low brake pressure indi. 1

140
 Z35H15T13 电气元件 Electrical Element
序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty. Remark
39 JN150 制动灯开关 Stop lamp switch 1

40

41 DL-224EG 电喇叭 Electric horn 1

42 电喇叭按钮 Electric horn button 1

43 DZ068/10W 带开关顶灯 Ceiling lamp 1

44 24V/5W 点烟器 Cigarette Lighter 1

45 JK981-045-2.5 前刮水器开关 Front wiper switch 1

46 CG30E-B 前刮水器 Front wiper 1

47 空调开关 Air conditioner SW. 1

48 1Ω+1Ω/100W 调速电阻 Rheostat 2

49 鼓风电机 Evaporator fan motor 1

50 储夜瓶压力开关 Cryogen Pressure SW. 1

51 温控器 Temperature Control 1

52 JQ201S-FLO 空调继电器 Air conditioner relay 1

40A
53 LED/24V 绿 制冷指示灯 Refrigeration Indicator 1

54 冷凝器风扇 Condenser Fan 1

55 SD5H14/24V 压缩机离合器 Compressor Clutch 1

56 JK981-000-3.40 工作警示灯开关 Energy warning lamp SW. 1

57 CG21-10W 工作警示灯 Emergency warning lamp 1

141
 Z35H15T13 电气元件 Electrical Element
序号 代 号 名 称 数量 备注
Item Part No. Parts Name Q'ty. Remar
58

59 JK981-045-2.28 后刮水器开关 Rear wiper switch 1

60 CG30E-B 后刮水器 Rear wiper 1

61 JQ603B 倒车闪光器 Back-up lamp flasher 1

62 10W/24V 红色 倒车灯 Back-up lamp 2

63 3T1518 倒车报警器 Back-up buzzer 1

64 JQ201S-PLO 倒车继电器 Back-up lamp relay 1

65 PS61/常开 5bar 倒车压力开关 Back-up pressure switch 1

142
 空调系统
Air-conditioner System

143
Z35H17T12 空调系统 Air-conditioner System

144
 Z35H17T12 空调系统 Air-conditioner System

序号 代 号 名 称 数量 备注
Item Part No Parts Name Q'ty Remark
1 蒸发器总成 Evaporator Assembly 1
2 三角带A型 Three-cornered Strap 1
3 SD5H14/24V 压缩机 Compressor 1
4 Z35H1701T12 支架总成 Compressor Support 1
5 储液瓶支架 Srorage Bottle Support 1
6 储液瓶 Srorage Bottle 1
7 冷凝器总成 Condenser Assembly 1
8 冷凝器出口胶管 Condenser Outlet Pipe 1
9 高压胶管 High Pressure Pipe 1
10 蒸发器进口胶管 Evaporator Inlet Pipe 1
11 低压管 Low Pressure Pipe 1
12 进水管 Inlet Pipe 1
13 出水管 Outlet Pipe 1
B1 GB5783-86 螺栓M12X30 Bolt M12X30 4
B2 GB848-85 垫圈12 Washer 12 4
B3 GB93-87 垫圈12 Washer 12 4
B4 GB93-87 垫圈6 Washer 6 2
B5 GB848-85 垫圈6 Washer 6 2
B6 GB5783-86 螺栓M6X20 Bolt M6X20 2
B7 GB5783-86 螺栓M8X30 Bolt M8X30 3
B8 GB848-86 垫圈8 Washer 8 3
B9 GB93-87 垫圈8 Washer 8 3

145
本手册仅供用户使用时参考，随技术进步、产品结构、参数等将不断改进，恕不另行通告
本书版权归四川成都成工工程机械股份有限公司所有，不得翻印
Structure and specification are subject to any changes without notice

地址：四川成都经济技术开发区洪河中路 1 号
ADDRESS: NO.1 MIDDLE HONGHE RD., CHENGDU ECONOMIC & TECHNOLOGICAL
DEVELOPMENT ZONE, CHENGDU, SICHUAN, P. R.CHINA
咨询电话(CONSULTING TEL.)： 86-28-82854808
服务电话(SERVICE TEL.)： 86-28-82854826
传真(FAX)： 86-28-82854811
邮箱(EMAIL)： [email protected]. NET
网址(NET ADD): HTTP://WWW.CG169.COM
HTTP://WWW.CHINACHENGGONG.COM
邮编(P.C.): 610110

146