100% found this document useful (1 vote)
1K views3 pages

Trip Circuit Supervisory Relay: Type: ATSR31A

The document describes an ATSR31A trip circuit supervisory relay that monitors trip circuits of circuit breakers. It supervises pre-closing and post-closing conditions, checks the control voltage, interlocks, solenoid coil wiring and health of the trip coil. It can detect a loose or shorted trip coil connection and supervises link cable connections between control relay panels. The relay has self-test functionality, is immune to control voltage dips, and has low auxiliary supply burden.
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF, TXT or read online on Scribd
100% found this document useful (1 vote)
1K views3 pages

Trip Circuit Supervisory Relay: Type: ATSR31A

The document describes an ATSR31A trip circuit supervisory relay that monitors trip circuits of circuit breakers. It supervises pre-closing and post-closing conditions, checks the control voltage, interlocks, solenoid coil wiring and health of the trip coil. It can detect a loose or shorted trip coil connection and supervises link cable connections between control relay panels. The relay has self-test functionality, is immune to control voltage dips, and has low auxiliary supply burden.
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF, TXT or read online on Scribd
You are on page 1/ 3

Type : ATSR31A

Trip Circuit Supervisory Relay


ASHIDA

Features :
• Sensing points are high impedance type and can
be used on any type of trip circuits.
• Supervises both pre closing and post closing
conditions.
• Checks ON : Control voltage, Interlocks, Solenoid
Coil wiring and TRIP coil healthiness.
• Checks the Trip coil loose connection (>300 ohm)
or shorting (< 10 ohms).
• Supervises the link cable between C.R. Panel and
C.R. Panel Trip circuit connections.
• Very low burden on Aux. supply. (Less than 3VA).
• Self function TEST facility for routine maintenance
check.
• Immune to momentary dips in control voltage.

Control and Indications :


• ON : TRIP SUPPLY INDICATOR.
• FAULT : TRIP CIRCUIT FAULTY INDICATORS.
• TEST : SELF TEST OF RELAY.

Operation :
The trip circuit of circuit breaker is normally wired through the protection relay contacts, interlocked with C.B.
auxiliary contacts, and other interlocks (like spring charging full etc.) and then connected to Trip solenoid coil of
circuit breaker and control voltage source through fuse links. ATSR relay continuously senses the voltage at these
junction points. Absence of the required voltage (as per the logic), immediately triggers the internal timer (1.0sec
time delay). After time delay, it is reported as fault by relay operation. The LED lamp “FAULT” gives visual
annunciation and relay contacts (2NC and 1NO) operate. The relay is ON in normal condition and Trips to OFF on
fault annunciation conditions. In Normal Condition NO is shorted and NC is open.

Trip Circuit Faulty Condition:


I. Link between Protection Relay NO and CB Aux. Contact is open
II. TC coil is open or short.
III. Control supply is less than 50%

Technical Specifications:
Sr. No. Specification Particulars
I. Control Supply : 24 / 30 / 110 / 220VDC. Specify while ordering.
II. Aux. annunciation Supply : 24 / 30 / 110 / 220VDC. Specify while ordering.
III. Trip coil DC Resistance : To be less than 200 Ohm. If higher to be specified.
IV. Burden on Aux. supply : Aux. Burden less then 3VA.
V. Control Contacts : 2NC - 1NO SR.
VI. Contact Rating : Alarm Duty - 10 Amp AC at 230VAC.
VII. Operating Time : 1.0 Sec. (± 0.1 Sec.)
VIII. Drawing Reference : For Cabinet Type - CSB ( MAC00202 )
: For Electrical Connection - AXL00602

Note: Due to our policy to upgrade our products constantly, we reserve the right to supply products which may vary
slightly from that indicated above

ASHIDA ELECTRONICS PVT LTD.


Plot No. A-308, Road No. 21,
Wagle Industrial Estate, Ref.: ATSR31A
Thane (W)-400 604. INDIA. Issue: 6 01.12.09
E-mail: [email protected] Page 1/1
Web: www.ashidaelectronics.com

You might also like