GROUP 4 ELECTRICAL COMPONENT SPECIFICATION

Part name Symbol Specifications Check

Ɠ Check specific gravity

12V ź 100Ah 1.280 Over : Over charged
Battery
(2EA) 1.280 ~ 1.250 : Normal
1.250 Below : Recharging

Ɠ Check coil resistance

Rated load : 24V Normal : About 50‫װ‬
Battery relay 100A(Continuity) Ɠ Check contact
1000A(30sec) Normal : ſ‫װ‬

CR-1

Ɠ Check disconnection
2 Normal : 0‫װ‬
Fusible link 24V 60A (Connect ring terminal and
1 check resistance between
CN-60 terminal 1 and 2)
105 BW
036 GY

001 LW
603 LR

Ɠ Check contact
OFF : ſ‫(װ‬For each terminal)
6 5 4 3 2 1
ON : 0‫(װ‬For terminal 1-3)
Start key -
ST
ſ‫(װ‬For terminal 1-5)
ACC START : 0‫(װ‬For terminal 1-3
OFF
HT and 1-5)
C R2 R1 IG BR B OFF CS-2

Pa Ɠ Check contact
Pressure switch N.C TYPE
Normal : 0‫(װ‬Close)

CD-3 CD-26
CD-25 CD-39

Pa
Ɠ Check contact
Pressure switch N.O TYPE
Normal : ſ‫(װ‬Open)
CD-4 CD-5
CD-40

7-35
 Part name Symbol Specifications Check

1 Pa
Pressure switch 0.5kg/cm2 Ɠ Check contact
(For engine oil) 2 (N.C TYPE) Normal : 0‫(װ‬Close)

CD-18

T Ɠ Check resistance
Coolant temp
- Normal : ſ‫װ‬
sensor
225Ş
F Over : 0‫װ‬

CD-9

Ş
Coolant - Ɠ Check resistance
temp sensor 192Ź13.5‫ װ‬at 73.9Ş
C
CD-8

1 Ɠ Check LED lamp

Parking
24V 1.2A Ɠ Check Resistance
solenoid
2 About 24‫װ‬
CN-71

1 Ɠ Check resistance
Reed switch : Full : About 30‫װ‬
Fuel sender
2 Magnetic type Low level : About 300‫װ‬

CD-2

Transmission °C
1/2 P.T.F Ɠ Check resistance
oil temperatur
137.2Ź14.5‫ װ‬at 87.8Ş
C
sender
CD-29

7-36
 Part name Symbol Specifications Check

1 2 1
Ɠ Check resistance
2
Normal : About 200‫װ‬
Relay 3 24V 20A (For terminal 1-3)
(4pin) 4 4 3 : ſ‫װ‬
CR-2 CR-7 AC RY1 (For terminal 2-4)
CR-5 CR-10 CR-30 AC RY2

Ɠ Check resistance
1 Normal : About 160‫װ‬
3 4 6
2 (For terminal 2-6)
Relay 4 24V 20A : 0‫װ‬
(5pin) 6 (For terminal 1-3)
3 1 2
: ſ‫װ‬
CR-4 CR-26 CR-35 CR-36 (For terminal 1-3)

1 B
Proximate -
2 S 24V 400mA
switch
3 E

CN-100 CN-101

Ɠ Check resistance
Hydraulic - Normal : ſ‫װ‬
temperature
105Ş
C Over : 0‫װ‬
CD-1

Ɠ Check contact
2 Lo 1 Normal : 1.12‫װ‬
4
(For terminal 2-4)
Hi 2
Air conditioner - : 2.07‫װ‬
3 ML 3
resistor (For terminal 3-4)
1 MH 4 : 3.17‫װ‬
(For terminal 4-1)

Ɠ Check resistance
Speaker 4‫ װ‬20W
Normal : 50‫װ‬
CN-23(LH)
CN-24(RH)

7-37
 Part name Symbol Specifications Check

10 9 8 7 6 5 4 3 2 1
Ɠ Check contact
10 6 5
OFF : ſ‫װ‬
Switch 24V 8A (For terminal 1-5, 2-6)
(Locking type) 9 8 2 7 1 : 0‫װ‬
CS-17 CS-21 CS-41 CS-50 (For terminal 5-7, 6-8)
CS-20 CS-23 CS-42 CS-54

10 9 8 7 6 5 4 3 2 1

Switch 10 4 1 Ɠ Check contact

(Non-locking 24V 8A OFF : ſ‫װ‬
type) (For terminal 2-4, 1-7)
9 2 7 5

CS-3 CS-39

Work lamp
Work lamp, 2 24V 70W
Room lamp, Number plate Ɠ Check disconnection
Number plate 1 lamp Normal : A few‫װ‬
lamp Room lamp
CL-1 CL-6 CL-22
CL-5 CL-21 CL-23 24V 10W

Beacon lamp M 24V 70W Ɠ Check disconnection

(H1 TYPE) Normal : A few‫װ‬

CL-7

Ɠ Check operation
1
Supply power(24V) to
Hour meter
2
h -
terminal No.2 and contact
terminal No.1 and ground
CN-48

Ɠ Check operation
22-28V 2A Supply power(24V) to each
Horn
110dB terminal and connect ground
CN-20 CN-25

7-38
 Part name Symbol Specifications Check

PA 1 Ɠ Check contact
Receiver dryer 24V 2.5A
2 Normal : ſ‫װ‬

CN-29

1 SL+
2 ACC
3 NC
4 SR+ Ɠ Check resistance
Cassette radio 5 NC 24V 20W+20W Power ON : 4‫װ‬+4‫װ‬
6 SL-
7 B+
(For terminal 1-6, 4-8)
8 SR-
9 NC CN-27

Back up buzzer 24V 0.5A 110dB -

CN-65

M 1 Ɠ Check contact
Washer pump 24V 2.5A Normal : 26.4 ‫װ‬
2 (For terminal 1-2)
CN-103 CN-22

24V 1.5A
Wiper motor
Hi
2-speed -
E
Lo M
Auto parking
CN-21 CN-102

Cigar lighter 2 24V 5A -

CL-2

7-39
 Part name Symbol Specifications Check

B+
G
W
3~ Ɠ Check voltage
Alternator D+ 24V 55A
Normal : 24-28V

CN-74

B+
M
Starter Bosch 24V Ɠ Operating or not
M
CN-45

1
Air conditioner Ɠ Check contact
24V 79W
compressor 2 Normal : 13.4‫װ‬

CN-28

1 Ɠ Check contact
Start relay 24V 200A
2 Normal : 11.3‫װ‬

CR-23

M 1
-
Blower 24V 9A
2 2900Ź150rpm

1 GND
2 COM 2 4 5 3 6
Ɠ Check resistance
3 MH
Blower switch 4
- Normal : 0‫(װ‬For terminal 1-2,
LOW
5 ML
3, 4, 5, 6)
1
6 HI CS-58

7-40
 Part name Symbol Specifications Check

M+ 1

Mode actuator S+ 2
M DC Servo motor
3
and M-
-
4
9-16V 300mA
FS
temperature
5
Max
S-
actuator
NC 6

R 2
12V Ɠ Check resistance
Intake actuator M Normal : 2.0‫װ‬
F 1

Working
1 temperature of
Thermostat contact point -
2 A/C ON : 4.5Ş C
A/C OFF : 1.5ŞC

3 E
G 24V
Flasher unit 2 B 85 ~ 190 C/M -
1 L 50dB

CR-11

1 Lo
2 Hi 24V 75W/70W
Head lamp Ɠ Check disconnection
3 E (H4 TYPE) Normal : A few‫װ‬
24V 4W(T4W)
4 C
CL-3 CL-4

4 C
3 T 24V 5W(R5W)
Combi lamp 2 E 2ź24V 21W -
1 S (P21W)

CL-15 CL-16

7-41
 Part name Symbol Specifications Check

1
Turn lamp 24V 21W -
2 (P21W)

CL-24 CL-25

Continuous
Capacity :
Master switch 180Amp -
Push in capacity:
1000Amp

2
Warning buzzer 24V 200mA -
1 90Ź5dB(ֻm)

CN-26

M 1
Air conditioner 24V -
fan 2
CN-83

1
2
Buzzer stop 3
4 Ɠ Check contact
switch 5 5 1
6 24V 8A OFF : ſ‫װ‬
(Rocker switch 7 6 2 (For terminal 1-5, 2-6)
push button) 8
9
10 10 9 CS-34

1 Ɠ Check contact
5 BL- BL+ 1
2
6 BK- BK+ 2 Normal : 80~90‫װ‬
3

Joy stick lever

7 FL- FL+ 3
4 (For terminal 1-5, 2-6
5
-
3-7, )
6
4 8
7 : ſ‫װ‬
8 CN-144 (For terminal 4-8)

7-42
 Part name Symbol Specifications Check

10 9 8 7 6 5 4 3 2 1

Switch Ɠ Check contact

10

6
(Non-locking 24V 8A OFF : ſ‫װ‬
type) (For terminal 2-6)
9

2
CS-52 CS-53

7-43