Scribd
Upload
1K views62 pages

DX-390 Service Manual

Service Manual for Radio Shack DX 390 shortwave radio

Uploaded by

Manny De GuzmanJr
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF or read online on Scribd
1K views62 pages

DX-390 Service Manual

Service Manual for Radio Shack DX 390 shortwave radio

Uploaded by

Manny De GuzmanJr
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF or read online on Scribd
You are on page 1/ 62
ReaALst7C. Service |\/ain DX-390 AM/FM WORLD-BAND PORTABLE RADIO Catalog Number: 20-214 Specifications o Disassembly Instructions Bock Diagram Alignment Instructions. Alignment For Clock Time Accuracy Alignment For PLL Frequency Alignment For AM 2nd Local OSC Alignment For AM 2nd IF Alignment For FM IF Alignment For AM Sensitivity Alignment For 8FO. Alignment For FM Sensitivity Alignment For MPX : Alignment For Indication Level of Battery Alignment For Signal Strength Level ‘Alignment For 450kHz Trap Alignment For FM Station Detection. ‘Troubleshooting Flow Chart Wiring Diagram : Main PCB Chip Side View Main PCB Top View Control PCB Chip Side View .. Control PCB Top View Electrical Parts List ‘Semiconductor Lead Identifications. Exploded View . Mechanical Parts List IC Circurt Block Diagram ICS" & Transistors’ Voltage List ‘Schematic Diagram CONTENTS SPECIFICATIONS FM Tata SORDTION | —NomNAL | Laat — ‘Tuning Range min are pare Wiss} sg] Max, Sens ssi 0emAz KHz uso 268 Wheompisn) |e cE [3 ining ti sev rt eae sous Sous Raion seve ® THD. (site Gor) aaumis =| r * Wan Outs Povr sour an [ovis Pover roe TAD save 00 [ain Chana Sec Tami seit) ra B Fin eee ne a ap sewn ED soe [Sere Separaion Gin seve % 30 8 Ait Scone soso a a der Orercad Opes Sele io —| “aes AM. Suppression (66dBu) - 98MHz_ 30 dB Win ua oat 3 a | Tone Action (FOkHz) S8MHz “8 38 [size sins bo Seite % it ra ww. TEST ITEM ‘CONDITION | NOMINAL cM UNIT Min. 520 ki omemenea ‘Max. ie20n1710 =8 ke Intermediate Freq pattie esate Ht kite 2k 450 Bo0KHE 38 aBusm Max. Sens. Toonz 56 ca 400K 36 Bute ‘00KHZ 3 oa, Bike Usable Sens. (SIN 2008) o00KHe 56 2 Bulm Ta00KH 56 i Bul ‘oOKHE =5 eH Dial Calibration ooo = kez T400KH2 25 ike ToooKH 150 He ‘Audio Fidlity (648) rene a bo CLA (= ToK2) 000K 28 8 T.H.D. (SRV) 1000KH2 2 4 9% AGC. FOM “000%He 40 8 Image Rejection 1400%He 26 8 ILE. Rejection (450K) “1000KH2 40 8 ‘Whistle Modulation (SmVim) BIFISIE 15 % Lowest Batiory Vortage ToookH ae az v lum Modulation (Srv ToooKH a “Tuning indioator Sens. (2nd. dol “1000KH2 8 Bum “Auto Scanning Stop Sens. o00KHe 60. Bul “Tone Action (SkH2) s000KH 38 SIN Ratio (5mV) 100K 2 8 Current Consumption ‘Output Power At 1086 THD. “000K 700 mW Overload Capacity (30% Mod 103% T.H.D) | 1000KH2 100) ‘a8 ‘Bandwidth 648 (Wide) 1000KH2 a 4-9 kHz ‘Bandwidth 6dB (Narrow) 1000kKi42 48 25~7 kHz Supply Voltage: OC 6V RO: SomW_| Load: & ohm Modulation’ the 309% Mod sw TEST ITEM, CONDITION | NOMINAL oN in, weavirn Hz Tuning Range Max. 29908 ite iat IF 35885 Intermediate Frea, see we r OOK 2 ei Max. Sens. [15100KH2 22 | __ By 25600NFE 2 au ‘2300KHz 22 Ey Bu Usable Sens, (SIN 2048) [toon 2 28 Bu | 2600Kt2 2 28 ay 2300KH2 [5 wiz Dial Catioration 15100KHe zs ke 25600KH2 =5 wz T5i00KHe 150 He ‘Audio Fidelity (848) pe . — : KOA TORRE) ¥5i00KH % THD. (60 84) 7 T5t00Kr2 z z % AG.C. F.0.M, (66 dBu) ‘15100KHz 50 8 image Rejection 15 100KH2 3 20 a8 1. Rejection (450kH2) 45100KH2 50, 3B Wiiatle Modulation (5mV) DIFISIF % Lowest Battery Votiage 15i00KHE aa ae v Hum Modulation (mV) 1000KHE, a8. Tuning indicator Sens. @id- aol) i5100KH2 Ba a8 "Auto Scanning Stop Sens. 75100KH2 2 Bi RF Gain Control 15100KH2 2 =6 8 SIN Ratio (60 481) 15100KH2 40 8 SSBIGW Sens. (SIN= 1048) 151004H2 3 +3 81 ‘Output Power At 1086 T.H.D. 15100kH2 700 mW ‘Overload Capacity (30% Mod TO% THD) | 15100kHz % 20 | Bu Bandwicth 648 (Wide) 15100KH2 7 a~9 KHz Bandwicth 648 (Narrow) 15100KH2 45] 3-7 he Supply Voltage: OC V1 RO SOmW | Load: 4 ohm Modulation: 1kiz 30% Mod LW _ TEST Tem] conbitfon_ | nominal | Una ont Tuning Range | _ Mi = | We Max si He uF 5a Intermediate Freq a a we ~~ T7aKHe | ee aBuim Max. Sens Brahe 5 Bim Dawe ea Bim |" ~ T73KRZ 8 74 CT Usabie Sens (SIN 2008) Bowtie 66 | Bui me et 70 ‘Bu ‘7akHe = He Dia! Caibraton Feit =3 ere : [patie 35 [We Towa Batory Vonage : rows Er] 42 v Hum Modulation (mV) 1000kKH2 | B Tuning Indicator Sens. Gd doi 2ehie 7 Bum Auto Scanning Stop Sens PreK 7 eum Tone Action kHz) 00K | 38 [sv Rano tm) — 216kHe ea 8 Supply Volage: BO6Y RO S0nW | Led ahem Hodalaion” Tate 30H Nod Note : Nominal specs represent the design spocs. A units should be able to approximate these-some wil exceed and some may drop slightly below these specs. Limit specs represent the absolute worst condition that still might be considered acceptable : in no case should a uni fall © meet limit specs. DISASSEMBLY INSTRUCTIONS TO REMOVE BACK COVER | 1— A | J a. Unscrew 5 screws A. . Separate tront and back cabinet. A A A c tr TO REMOVE CONTROL PCB 2 t ‘| a [ La ». Remove Control PCB 0 0 D. = oO. L—_. TO REMOVE MAIN PCB 1, Remove 3 screws C. . Remove Main PCB and 1 screw D, BLOCK DIAGRAM ALIGNMENT INSTRUCTIONS Note: (1) All test points are shown both on schematic diagram and figures 1-13, (2) Load in fresh batteries before any alignment procedures. (1) ALIGNMENT FOR CLOCK TIME ACCURACY ‘a. Required Instrument Frequency Counter b. Alignment Procedure ‘Adjusiment Procedure (1) Turn the radio to SLEEP ON mode. (2) Set the SAFETY switch upward to electrically lock all push buttons. {8} Remove the batteries from the RADIO BATTERY compartment, The monitor TIME Te 401 BASE signal starts functioning. (4) Connect a frequency counter to TP 15. {5} Adjust TC401 to reach a reading 524288 + 4Hz (+ 7.6PPM or + 20sec/month) on counter «. Instrument Connection Toa01 2 Freq. Counter Test Point TPIS e = a ASTIEe yi ae oa Spas ies ae = Bat aoe ee tc si (2) ALIGNMENT FOR PLL FREQUENCY a. Required Instrument Frequency Counter ». Alignment Procedure Wode ‘Adjustment Procedure FM Tos (i) Tamm the radio ON. (2) Select the tuner frequency at 108 MHz. (3) Connect the test probes of frequency counter to TP7 and ground. The ground point should be as near as possible fo the test point TP7 (4) Adjust TC4 to have a reading of 118.69975MH2-118.70025MH2 . Instrument Connection Tea PRINS ge Seay) ay Freq. Counter Test Point 1P7 Hos (3) ALIGNMENT FOR AM 2ND LOCAL OSC ‘a, Required Instrument Frequency counter with higher impedance probe. ’ Alignment Procedure Wode | Adjustment | Procedure Ti) Turn the radio ON. {2} Tune the frequency far away from any station to avoid interference, AM | L141 (3) Connect the test probes of frequency counter to TP8 and ground I (4) Adjust L14 to have a reading of 55.39485MHz-55.39515MHz, Caution : A loading effect could emerge in the circut if inserted with a lower impedance probe of fre quency counter. ¢. Instrument Connection uu to z 10 (4) ALIGNMENT FOR AM 2ND IF 4. Required Instrument AMF Sweep Generator with Scope ». Alignment Procedure Wodk AM Adjustment | Procedure 7 Ti) Tum the radio ON. (2) Set the bandwiath switch to WIDE postion (2) Connect the input terminal of AM IF eweep generator in series with a capacitor of 10uF tothe test point TP. 14 | (4) Connect the RF output terminal of AM IF sweep generator in series witha 16 ceapactor0.1yF to another test point TPA. (6) Adjust T4 to have a max. output with a marker frequency of 450kHz on the sweep ‘scope. (6) Adjust T6 to have a max. output with a marker frequency of 4S0KHz on the sweep scope. (7) Repeat (6) and (6) until a max. 450kHz output is reached. «Instrument Connection 16 4 Test Point| 4 {in Test Point TPS Tes 10uF . AM IF Sweep Generator " (6) ALIGNMENT FOR FM IF 1, Requited Instruments FM IF Sweep Generator with Scope. ». Alignment Procedure Hode | Adjustment Procedure ~ Ti) Turn the radio ON. ~ (2) Connect the input of FIM IF sweep generator in series with a resistor of 1.2K ohm | 18 to the test point TPS. FM v (3) Connect the AF output of FM IF sweep generator in series with a resistor of 2.2K | ‘ohm to another test point TPS. (4) Adjust TS and T7 to have a max output and best symmetrical S curve with respect to the canter marker frequency of 10.7MHz. ¢. Instrument Connection 15. ae Si alin ee aa Gaia Sao st Point TPs Test Point 2 Gi 1.2K ohm! ¥ 2.2K ohm hon FM IF Sweep Generator 2 (6) ALIGNMENT FOR AM SENSITIVITY ‘a. Required Instruments AM Signal Generator ssvM Frequency Counter ». Alignment Procedure Wode | Adjustment Procedure 11) Turn the radio ON. {2) Set the bandwidth switch to WIDE and RF GAIN VR to MAX postion {2) Tune the ragio band frequency to 15.100MHz (4) Feed a signal with modulation from AM signal generator output othe test point 1 ‘TP1 and connect a SSVM to speaker (TP14). AM 3 (6} Tune the generator frequency exactly the same as that of the radio frequency La displayed. (6 Adjust T1 and 79 to have a max, aud output {7} Connect tho probe of frequency counter atthe test point TP4 {@) Adjust L14 to moet the specicaton frequency 460KH = 0.1SkHe LL1e} Remove the counter and repeat (6) to (8) unt the specication frequency is met. «. Instrument Connection La ssvm out Test Point aT TRI go s [AM Signal Generator Test Point TPT Freq. Counter Test Point TR4 (7) ALIGNMENT FOR BFO ‘a, Required Instruments ‘AM Signal Generator SSvM b. Alignment Procedure Mode | Adjustment | Procedure aM Tes Ti) Turn the radio ON. (2) Set the BFO switch to ON and BFO pitch to center position (3) Tune the raido bank frequency to 15.100MHz. (4) Feed a signal without modulation from AM signal generator output tothe test point TP1 and connect ¢ SSVM to speaker (TP14). (6) Tune the generator fequency exactly displayed (6} Adjust TC3 to have @ minimum reading on SSVM, €- Instrument Connection tes ‘SSVM 9 Est Ls orn t AM Signal Generator Test Point 4 (8) ALIGNMENT FOR FM SENSITIVITY 2 Required Instruments, FM Signal Generator ‘SSvVM . Alignment Procedure ode | Adjustment Procedure a Tar ie ras OF (2) Connect a SSVM to speaker (1P14) (8) Connect a FM signal generator tothe input terminal of Rod Ant. (TP2) 11,12. | (6) Setthe signal eneratoro 22 St deviation with 1kiz moda, Fa | TCH TC2 | (5) Tune the aso band trequency to SOMHz and adjust L11, L120 have a max ceasing on SSVM | (6) Return he racio band tequency to 106MHs ane adjust TC1, TC2 ta have a max | "reading on SVM (2) Repeat (5) and (6) unt a best sensitivity on these two frequencies are formed 90 OO4 Tea Late i ssvm +19 FM Signal Gener Test Point TP2 18 9) ALIGNMENT FOR MPX ‘2. Required Instrument Frequency Counter ». Alignment Procedure [Mode] Adjustment Procedure i [Ty Turn the vaio ON. (2) Set the FM mode switch to STEREO position, oF gvpz_ | (9) Inserta plug of headphone into the HEADPHONE JACK (JK2) j (4) Connect the test point TPS in series with a capacitor of 1uF to ground. (5) Connect a frequency counter to TPS. (6) Adjust SVR2 to have a reading of 18.95kH2-19,05kH2 on frequency counter. 6. Instrument Connection Freq. Counter Test Point | ~ 6 (10) ALIGNMENT FOR INDICATION LEVEL OF BATTERY ‘a, Required Instrument DC Power Supply with voltage meter b. Alignment Procedure ‘Adjustment Procedure (iy Remiove batteries away Wom the RADIO BATTERY compariment. ~ {2) Connect a DC power suppiy to the test point TP12 (@) Set the voltage to a reading of 4 4V. VRS (4) Turn the radio ON and adjust SVRS. (5) Push POWER key again to shut off the radio and the BATTERY LEVEL IN. DIGATOR appears for 5 seconds, | (6) Repeat (4) and (5) until the level is indicated on the 2nd. scale, ¢. Instrument Connection SvAS Regulated DC Power Supply Test Point TP12 ql + 7 (11) ALIGNMENT FOR SIGNAL STRENGTH LEVEL ‘a, Required Instrument FM Signal Generator AM Signal Generator », Alignment Procedure Wode | Adjustment Procedure i (Hy Turn the radio ON {2} Connect a FM signal generator to the input terminal of Rod Ant. (TP2) | (2) Sor tne signal generator to @8MHz with TkHlz Mod, 22Hz deviation and 36 emt | om 1484/75 ohm output eve (6) Tune the radio band frequency to 98MHz and adjust SVRS to have a strength level eading of 6h scale 7 Ty Tare ads OW | (2) Set ne vandwicth switch to WIDE and RF GAIN VR to MAX position | {@) Tune the radio band frequency to 15.100MHe am | sung | {@) Feed. signal wit 30% modulation and 36 emf d8y'50 ohm output eve into he AMEXT. ANT. Jack. (5) Tune the generator requency exactly the same as that ofthe radio frequency cisplayed (6) Adjust SVR¢ to have a strength level reading of Sth scale. Caution : Before these signal strength alignment procedures, the SVR (for Battery level) should be in correct position, . Instrument Insert tothe AM Signal Generator AM EXT. ANT. jack JK1 (For SVR4 Alignment) oF 3.50 Plug FM Signal Generator {) rest point tm (For SVR3 Alignment) (12) ALIGNMENT FOR 450kH2 TRAP 2. Required Instruments ‘AM Signal Generator Loop Antenna SSvM . Alignment Procedure Wode | Adjustment Procedure (Turn the radio ON. (2) Set the bandwidth switch to WIDE and RF GAIN VR ro MAX position. (3) Tune the radio band frequency to a50KHz, fa (4) Connect a AM signal generator together with standard loop dummmy antenna and feed a stronger signal to the MW/LW ferrite bar antenna. (5) Tune the generator frequency to 450kHz and set modulation depth to 30%-50% (6) Connect a SVM to speaker (TP14) (7) Adjust T8 to have a min. audio output. AM ¢. Instrument Connection ‘AM Signal Generator» 60 em —+ = r 1 i |_he ae perpendicularly to the Loop Antenna 19 (13) ALIGNMENT FOR FM STATION DETECTION ‘a, Required Instruments FM Signal Generator Volage Meter ». Alignment Procedure Mode FM Rajusiment | Procedure (Turn the radio ON, = (2} Connect a voltage meter between pin (8) and pin (17) of 101 TA775BP. {3} Connect a FM signal generator to the input terminal of Rod Ant. (TP2) SVR1 | (4) Set the signal generator to 98MHz with 1kHz Mod, 22.5kHz deviation and 66 emt {dB,/75 ohm output level (6) Tune the radio band frequency to 98MHz and adjust SVR until the voltage itference between pin(8) and pin (17) is less than 0.3 Volt «. Instrument Connection Voltage Meter Connect to pin 8 and pin 17 of C1 i * [ a 2 TROUBLESHOOTING FLOW CHART Weak sensitivity on FM mode a Check whether the sensitivity is recovered if antenna is, Yes Check the antenna terminal Girectly connected to the [F andantenna circuit point between C17 and C18 No ' No Check IF waveform ge! Check 06 and ic Yes Y No Check 5 and 06 fg! check the PLL eircuit Weak sensitivity in AM band Is the reception in Yes Check the antenna circuit MWILW bank O.K.? > anc antenna terminal Check whether both the Cheek whether born tne Yes Check whether AGC oreuit are normal | . Check whether the circuit of Check C50, C46, C43 and No ca beg] the ana iF stage (asokH) {is normal No Check whether the circuit Check Q7. 4, and 03, beg} ofthe 1st iF stage (55.845MHz) is normal, L Yes | Check O1 and the Low Pass Filter circuit (LS, L7, L8) (8) PLL does not work ils Check whether the gate voltage of O34 is more No Check whether the problem than 14V DC while the > _ notes from oc-ne display is 1OBMHz in converter. FM band Yes Check whether the frequency " Check whether the OSC at the collector of 29 e circuit of 28 and the is within 118,69975~ 118.7005 [| two butter circuits of Miz 27 and 029 are norma vey No Check whether the voltage Check the DC supply circuit. a+} atin @ of 03 is, 2.9V 06. ey No Check whether the circuit Check 092 and 033, ht Seer ey ‘Check the circuits of 163 and Xtal Yes (4) Power cannot be turned on Check whether the pin & of ad Check whether the pin @ 1C403 is 3V DC. [——_ or icaos is sv oc. Yes Yes Check whether the collector voltage of 0404 is less Check the safety switch ‘$404 and the circuits manvavoe othoy mae creck 00 cheek ae Check whether the collector voltage of Q44 is more than 5.8V DC. Check O44. 23 No WIRING DIAGRAM 24 MAIN PCB CHIP SIDE MAIN PCB TOP VIEW CONTROL PCB CHIP SIDE CONTROL PCB TOP VIEW ELECTRICAL PARTS LIST Fat No Deseripion [RS Pan No. Wir Part Wo PCB-A Ass'y (Main Board) [ 706016602 t PCB-A Blank 1610790 ‘CAPACITORS (Al Chip Type. GoramicType-A 2 0x 125 mimctypeB 2x 1.6 min Unless Noted Others cr T00pF 50V NPO-A 7 - 4010107 ce 220F SOV NPO-A | 4072101 co | O.omF — 28v X7RCA | | ov0a67 cw | 6apF SOV NPO-A | 4088001 cs sao Sov SL-A | | 4059119 os OOF sv XTRA 4010367 C8 Elect, 10K teV = 20% Sat | ae10632 ce 82F SOY = 5% NPO-A ; 4082001 C10 | OOF = 25V + 10% X7R-A 4010367, cw ‘SpF S80V + 0.25p NPO-A / 4005001 G2 | 0.0033uF 50V 10% © X7R-A | | aogaz61 cist | 2oF SOY = 0257 —NFOWA 4002001 C1 68pF 50V vi NPO-A | 4068001 ois OOF sv XTRA | 4010967 cre O.001F Sov SL-A | 4010219 a7 | 10pF —50V NPO-A | | 4010002 ce, 22F Sov NPO-A | 022001 cis OOtF —25V 210% = XTRA | 4010367 c20 | O.01mF © 25V = 10% = XTRA | | 4010367 C21 | Not Used / | c2e Oot 25V = 10% XTRA | | eo1o367 c23 OOF 25V = 10% —x7R-A j | cooss7 coe 2oF SOV 0259 -NPOLA | <002001 cas OOF 25 = 100 XTRA 4010967 26 Sof SOY. 0259 —NPO-A 4005001 ca 2200F SOV. <5 NEDA | 2022101 ce, Oot 25v = 10% © XTRA | 4010367 C29 00uF SOV =5% Sia sot02t9 co | O.001:F SOV = 5% SLA i | dor02i9 csi [elect «to t8v oxi a0632 C32 | O.0mWF = 25V X7R-A | 4010367 cat OoWF 25v XTRA 4010367 ca 6pF s0v NPO-A | 4008002 C35, | Not Used 1 ©36 | Not Used | 37 O.0mF — 25V + 10% X7R-A | 4010367 cx | eer SOV NPO-A | 5% 4501020 ica | 47pF SOV. 5% NPO-A 4047001 82 O1nF —-25V_ +80%-20% YSV-A 4010471 cas O.01NF —25V. + 1080 X7R-A 4010367 cas 0.0224F 25V + 20% X7R-A 4022968 cas Elect. 1nF SOV + 20% Sxtt | 4410561 cas Not Used | a7 Elect. 100F = 10V. «+ 20% = SKID | 4410772 cas PS A70pF SOV. 5% 4504710 C89 Elect 471F TOV. 20% = Sx1t 4447620 c90 Elect, 0.22uF SOV + 20% oxtt 4422460 91 Elect. O.47UF_ SOV. + 20% 5x11 4447461 coe Elect. uF SOV + 20% Sxtt 4410561 cos Elect, uF SOV + 20% oxi 4410561 coe Elect, uF 50V + 20% Sxtt 4410561 95 O.018IF 25V + 10% X7R-A 4018367 96 O.018iF —25V + 10% X7R-A 4018367 cor OOF © 25V + 10% X7R-A 4010367 cos O.01NF © 25V 10% X7R-A 4010367 C99 O.0¢7UF 25V +80%-20% YSV-A 4047371 100 | elect. tHE SOV 20% oxtt 4410561 C101 | Elect, uF SOV + 20% Sxtt 4410561 C102 O.0331F —25V + 20% X7R-A 4033968 C103 .033UF 25V + 20% X7R-A 4033368 C108 O.087uF SOV 20% Z5U-A 4047363 cis | O.047uF SOV + 20% Z5U-A 4047363, C106 470pF OV. + 5% NPO-A 4047101 C107 470pF «SOV. + 5% NPO-A 4047101 108 Not Used C109 OOF — 25V + 10% XTR-A 4010367 C110 O.047uF —25V + 80%-20% YSV-A 4047371 cnt O.02auF 25V + 20% X7R-A 4022368 Cr | Elect, «= 10uF_ 18-20% Sxtt 4410632 c113 OIF _25V_+ 10% X7R-A 4010987 20 Ret No. ‘Description AS Pan No. Mir. Part No. iia TOF —25V = 10% x7 4010367 Gis ‘elect, TOF T8V = 20% «= SutT 14410692, cus Oza 25v = 20% © XTRA 4022368 cur ce | 47pF «SOV. -£0.25p —NNPO-A | | 4002001 cn | OOF SOV = 10% XTRA ' 4090261 C120! Not Used cr | SF SOV =05p = NPO-A | | aoo8002 cre 2200F SOV = 84> NPO-A | eo22101 cia OomF —25v =10% XTRA 4010267 Ciz4 Elect. «= 4 7uF_ BDV = 20% Sxtt | 4447562 crs OF 25 = 10% XTRA | 4010067 cw | 20F SOV =0.25p — NPO-A { | 4002001 cr oF —28V = 10% © XTRA. | 4010367 cr28 39F SOV = 5% © NPO-A 4939001 C129 ‘Spr «SOV 5% ©—NPO-A | 4015001 130 OOF 25V = 10% == XTRA | | 4010367 cist 109F —-50V.=0.5p ~—NPO-A ' | aoxo002 132 Metal Poly 0.22uF — S0V. = 506 ' | sa22460 C193. “Mylar O0RqUF SOV = Ste i | 4633360 cio DOO SOV Zs SLA ' | fovaase ras O.047uF 25V + 80%-20% YSV-A | 40s7a71 136. Ooa7uF 28V +8050-20% YEV-A | 4047371 coxa? O0s7uF 25V. +802%-20% YBV-_A \ | aoazsrt 198 Elect TWF eV 220% xt i 4430632 C199 NotUsea \ C140 O.047uF 25V + 80%-20% YSV-A 1 | aoezar1 cra O1uF—25V + 808-200 YSV-A | 4010871 cre 3009F SOV = 5% NPOMA | 4039101 143 O.0mMF = 26V = 10% X7R-A : 4010367 C14 Not Used : cus, O0e7uF SOV = 20% © _Z5U-A i 408736 cus oom Sov Z5u-a i 4067963 Cra7 elect. «RUF 16 x11 | 4422690 Cue Elect. «RUF tev exit | 4422600 C19 Elect, «100 TV 6.3n112 | ae10722 C150 Elect, 100uF 10 63x12 | 4410722 Gis: Elect 100uF TOV eax | aa10722 C152 Elect. «= Y00F_=— OV = 208% = ax11 2 | asi0722 crs 0.0474 28V +8080-20% YEv-A | 4047371 crse OF 25V +80%-20% YEV-A 4010471 C155 9.022F 25V = 20% XTR-A | 4022368 C156 Elect, © YODKF TOV =20% © 10x16 44410820 Crs7 Elect. © -220uF TOV = 20% «= axt2 4422720 C158 Elect. «10uF = 16V = 20% ax 410631 isa [Elect «uF SOY 2 20% x7 4410560 C160 | Elect. 4.7uF SOV + 20% 4x7 4447540, cs | 0.087 uF 25V + 80%-20% YSV-A 4047371 cisz 150F SOV = 5%. NPO-A | 4015101 C163 Elect. © 100uF_—10V = 20% «= .axtt2 | aaio722 cree 0.022pF © 25V =20% © X7R-A 4022368 C165 | Not Used cies | OOWF © 25V 210% XTRA | ao10367 C167 elect. aE SOV = 20% Sxtt | aat0s61 oa | OozzuF 25V 20% © XTRA 022968 C169 ‘Elect. -220F OV 2 20% «= ax 422720 ci | OOmF —25V 10% XTRA | ao10367 Gi71__! Not Used Note: “ Mylar is 2 registered trademark of El. DU PONT de nemours and company. 31 Fat We Bessrpton Le a Ci72 0.047uF B5V + 80%-20% V5V-A ~ 4047377 Give lect. BaD tOY e200 aunt d ‘ozre0 Cire Elec. 20000 TOV tom 12800 ‘22020 cis OomF 25v s 10% XTRA | Soroser cre | Seor SOV 5% NPOLA seas001 cur Sopr «SIV gee NPOLA ‘eco! Giz | Not Usea oie 1005 Sov = 5% —-NPO-A sor0101 Cie Ocsair 25v izoe XTRA | Sozosee cies | soph s0v_igte—_NPOVA 4039001 ZonNecTORS - ONT ONT Houarg TP STORE) 7o0T70 CNT2 | CNT. Housing 15P (STISAE) | 1700120 CNT re Ay 12 usriae) tosote | wt. ve Assy 15° stiAe) 103220 _ SSIS tS aa 775800 _ tooo ts | oon iseteo te ezaue 1soseo _ {seo 16 | 0.39pH. 1130800, tt {ersoo LB | 1-5yH_ | 1131500 (| Not Usog Lio | Teois Goi 7200 1150000 Lit | Ach col ozsestoswoses (EM ANT) haze Liz | Agj COM oasesowwoses (eM AP} | Vazeo0 a tater tre | Adj cotc2sr-aos.wazen (aM OSC) 120300 tis oan 10800 ue [47a | 1133300 ti | ad; Ci 0850 (858 0€7) s20880 te |eanaco! thi ANT) Troe tis | Some thw a) | tiastoo tao foam {sosee tr [eau {isi700 Lae | Aaj col c2se-408-wosoa (veo) Toes ts [eau 1ec00 tr feu tisesoo tes [paul tisi7e0 te | tame tissi00 tar |Aaj'ca ev404oew1208 (OC CONV) tia2200 (ee ts 113st00 Tr | Adjreotces7-ewses aM MCF izat20 rz |Notusea 13 | Aaj con czsraos.wice (aM MCF 122260 tH |instaowoewros tant | tteeoro ts |inarasaonwies trata ezast 38 | aaj cor 0990 (att DEN) 120860 tr |inzeissaonwars eM DEN) tooo Ta___|inzisosoewsere (aM TRAP) 120080 | cnverats TS rar 5 a0gte e500 | x2 [tat soounis | 680030 DIODES : Or aNeraaTa ‘oao0aaT o2__|igsose ioe2o10 Ret. No. Description RS Pari No. [Mir Parts No. 03 | Varactor SVG208 (AATIAA2) 1083060 Da Varactor SvG203 (aAniAg2) 11083060 Ds | aNerasTR | 10400207 D6 | inavaaTR | sosooe0T 7 | aNataaTR, | 10400207 08 aNa148TR | | 10400207 D9 188258 i 1042010 pio | 1ss238 | 1042010 DI1 | Varactor svcz201sP | 1083030 012 | aNnataaTA | toao020T 013 | aneraatR | | 10800207 Dia | aNavaaTR, soaoga0T Dis | assza8 | 1or2010 Dis | rNat4eTA | 1os00z0T 017 | aNavastR | soaooz07 Dig aNataeTAR 10400207 Dig | iNeoP 1040040 020 iN6oP 1040020 D21 | Varactor svoz03 (aasiaagy ‘1043060 022 | iNaTaBTR | sosooe0r 23 | wNaraarTR, | tosoozor pea | rNeoP 1080030 025 1NaTABTR i r040020 026 | ineraerr, 10400207 de? | aNevasTR 10800207 Dea | iNavaaTR | tosoo20T bea iNataaTR, | tosoa20r 30 | wnesaaTR toao020T 031 | aNar4eTR 10400207 32 | Zener UZ- 158H | 1025090 033 | aNatae i 1040020 03 | anataaTR | | toroo20T 035 | aneraaTA | sosooz0T 036 | aNataaTA 0400207 p37 | anasaetR 0400207 | FILTERS: LPFI [UG Filter 0247-096 FM Upp 7122200 MCF1 | MCF 85.e45HHz 1650041 Cxi | Resonator 4stkHiz 1650061 CFI | CF. SFEI0.7MAB-A ‘860060 Cre | GF. SFEI0.7MAB-A 11660080 crs | GF. sFPaso1 1660770 __oFa__| oF, sFRasq) 1660360, INTEGRATED CIRCUITS : ior | TA7758P MIE, AM MIX & IF 1070300 12 aNats AM FMLIC AMP 1010030 ica | cx7e61a Pu io10a01 iC | Te7aHcreaP AID Converter 1011230 ics | TA7s339AP/P ‘AID Converter 1011400 ics | TA7sa39aPiP ‘AIO Converter 1011400 ior | AN714IN Powor AMP | 1017350 ics | aN7iaiN Power AMP 7011350 ico Laso0s 3V Regulator - 1010140 TACKS. Jkt | HSI0RT207028 Ext Ant | 7689027 vk2 | HSu0914-01-020 (Headphone) 1640060 uk3_| HECos7.01.230 (oc IN) 1687000 {JUMP WIRES a ‘8000050 2 | 8000040 33 Het Wo Deseriion TS Park No [Mi Paris No. Ws | Tommoee 7” e000040 St | Tomm o.68 | so00oe0 3s |smmose | scooot0 ie | Smmoeo | eo00ot0 7 | 78mm 0.60 000030 Je | Tommo se 000040 ye | 125mm 060 2000050 Sto | ommase 000080 at |tomm ose 000040 siz | Smmoeo 000070 33 | 75mm 0.50 2000030 Sta |7mm0.0 000030 sts | tommo.60 000040 tie |tommose | | Boo0040 nr | tammoeo 000000 ie | tommoce 000040 tis | tommose 000040 zo | tsmmoo 000000 Yi | tommose 000040 J22 10mm 0.60 | | 8000040, zs | tommoce 000040 za | tommoee | 000040 zs | tomm oe 000040 Sze | tomm oe 000040 zr | tommoee 000040 za |tasmm oo 000050 Yeo [12smmoso 000080 (J30 | 10mm 0.60 | 8000040 isi | tommoce 000040 Jez | tommoce 00000 is |tommoce 000040 toa | tommose 000040 sss | tommose 00000 36 | tommoco 000020 Sor |tommoce 000020 Sas | tomn ose 000040 aso | 10mm o6e 000040 suo | 7.8mm 0.60 000000 Set | tomm 060 | 000040 Siz | 10mm 060 000040 Sis | tommoce 000040 “ta | fomm 9 000040 Sas | tommo60 000040 Jas [7.5mm 060 | 8000030 ver |Yommosse 000040 aa ommo 60 000040 a | 75mm 080 000000 io | 78mmo.e 000000 ist | fommo.o 000080 Bs2 | 7.5mm 0.60 000030 iss |7.5mm0.80 000030 st |7.5mm0.80 2000030 vss | tommoce 00000 se | tomm ace 00000 sr | 10mm oe 000040 88 | 12.5mm 0.60 2000050 s2 | tommase 000020 eo | 7.5mm 0.60 | s000030 Jet | 75mm 0.60 000080 seo | 75mm 0.60 i) el. No. Description AS PartNo. [ir Pars No. Sis |7 rence eee 000000, se 10mm 0.60 8000040 yes | 7.5mm 060 8000090 yes | 7.5mm 0.60 3000030 187 75mm 060 8000030 B68 75mm 060 000080 89 | 10mm 0.60 00080 70 |75mmo.0 000030 775mm 0.60 000030 uv 75mm 0.60 2000030 373 | 7.5mm 0.60 2000030 B78 30mm 060 8000020, B75 7.5mm 0.60 18000030 B76 7.5mm 0.60 3000030 377 Smo 8000010 7a Smmo.60 000010 B79 15mm 0.60 000080 SP. Frame-GNO_ 25mm 0.60 8000140 PCB AGND.GNO 25mm 0.60 000140 ___x3-GNO 25mm 0.60 _ ‘000140 VC JUMPER WIRES PCB AK) 45(9+9)mm Gen (AWGDE 1085) aI70565 PCB AIP) 90194 8)mm Bik (AWG2B 1095) 8171460 PCB AIF) 90(9+9)mm Gen (AWWG26 1085) VCO 8171465 POB ALY) — 90(9+9)mm Wnt (AWG28 1035) VT 8171469 PCB AG) 180(9-+ 9mm Blk (AWG28 1095) AUDIO 8172260 POB A(R) | 180(9+ Simm Brn (AWG28 1095) AUDIO 8173261 POBA(L) | 180(9+ 8mm Gry (AWG28 1095) AUDIO 8173268 Speaker (+) | 120(8+ 6!mm Grn (AWG28 1095) 8172025 Speaker (-) | 120(3 + 6mm Wt (AWG28 1095) 8172028 Back-Up 110(9+ 9mm Wht (AWG25 1095). Bat-)-M.Bat(-) 8171869 150(9 + 9jmm les (AWG26 1095). Bat +) -Batt Contact + 8132662 1609+ 9)mm Bik_(AVWG26 1095}m_ Batt +) ~Bat. Contact +} 8232660 RESISTORS (All Carbon Film T10W = 5% Chip Type A 20x1.25mimTypo-8 8 Te1 SBiin, Unless Noted Otherwise) RI BOK a - ‘6160155. re | a0 6160130 RZ | 330 6160118. ne | 5602 6160121 S| aka 6160181 RE | 3.9ko2, 6160143, a7 | 300K 6160160 re | 2200 6160128 re | 5900 er601a1 Rio | 580 er60121 an | 1500 6160126 m2 | 1800 6160127 a3 10a 160112 ara | 2akn 6160152 RIS | 18K 6160151 Rie | s200 6160125 RI7 | Gaka 6160158 pra! s00K 6160160 Rio take 6160363 R20 | 100K 6160360 rar | s30K0 6160166, Re | 1k 6160198, R23 arch 6160156 Ree 100K 6160160 nos __| 1500 6160126 35 Ref, No. Description RS Part No. [Mir Paris No. Rae | 220. T er60716 R27 | 100. 6160112 Rae | AD 100K) Wz St T | | 60807607 Rog | 8.2k0 6160147 R30 | 330K 6160166 Rs1 | RD 8200 SW = 500 T 60507357 Roz | tka 6160196 Raa | 4700 6160132 Raz | 3.3K 160142 35 | 33k 6160142 Rog =| RD aa V6W + 59% T | 60507237 ray | AD 82a GW + 59% T 60507237 Raa | 2.2k0 6160140, ag—| Not Usea Rao | 3.90 160143, Rat 1000 | erso124 Raz | 2.7K er6o1at Rag | on | 6160194, Raa | 470 6160120, Ras | 5.6k0 6160185 Rae | 22Kn. 6160152 Ray | RO BAKNe ew + 5% SMS 6010847 Rag || RDB2KD © W 5 5% T 6050747 Rag | 4700 6160168 R50 | 3.3K 6160142 R51 | 3.3K 6160142 Rs2 | 27Ko 6160153 Rss | 680, 6160122 R54 | 22k. 6160140 Rss | 3300. | 6160130 Ree | 1.2Ma | 6160173 R57 | 39k0 | er6o1a3 R58 | 3900 6160130 R59 | 3.3k0 6160142 Reo | 33kK 6160154 Fer | 2aKce | 6160152 Re2 | Saka 6160154 R63 | 1000 e160124 Rea | 82k2. 6160159, Res | 39k 6160155, Res | 68k 6160158 R67 | 100Ks2 6160160 Rea | 22k 6160152 Reg | 1.2K. 6160137 R70 | aK 6160152 Art | 470K. 6160168 R72 | 220k. 6160134 7a | 220 6160116, R74 | RDA 7K =e = 5%T 60507447 R75 | 270kQ. 6160165, R76 | 27Ka. 6160153, R77 | 390k. 6160167 ave | 15k0. 6160150 R79 | AD 1.8K 1/6W + 5% T 6050738 Reo | 93Ka. 6160154 Fer | 68ka. | 6160158 Re2 | 5.6k0 er60145, Res | 10K«2 6160128, Rea | 330K0. 6160130 Res | 680K. 6160170 36 Ret. No. Description AS Part No. (Wir. Parts No. 6 Re? Fe ao R90 ax a2 R93 Roa Fas, a6 a7, Roa Rag Roo R101 Ri02 103 Rios R105 R106 Rio7 Rio8 103 An10 ain R12 Ang Rita R15 N16 Rn? Ane Ring R120, rat R122 R123 Riza R125 R126 R127 128 129 130 R131 R192 R133 Risa R135, R136 R1g7 R138 R139 R40 Riat R42 R143 Riad R145 27K | 68D. SK sexe. | kee | aaa | 270k | rooKae ime 4700 3.5K 350k | sear j 27K 30K | Seka aka | seks 22k | ke 10482 00K 1K 47K8 ane | 470K 70K. 10482 0K 6.8K 6m | 39k 29k0 39K0 Beka | ezou | e200 | rox 39ks2 22k 150K. ean 1008 thee ake 22ks2 aakn 1008 aKa. 1a 2200 aon. 3200 a700 aria wa 1K ‘00K | eka 122048 e16018 6160158, 6160146 6160746 6160139 160144 6160165 6160124 6160172 6160132 6160143 6160162 6160136 5160153 6160166, 6160157 6160156 er60121 6160152 6160138 6160148, 6160160, 6160136 160184 ei60148 6160168 6160168 er60148 6160148 160146 6160146 6160155, 6160155, 6160155, 6160155 6160135 6160135 6160148 6160155, 6160152 6160162 6160123 160128 6160138 6160158 6160152 6160159, er60124 6160159 6160136 6160128 6160132 6160130 6160132 6160156 6160172 6160136 6160160 6160151 6160164 a Ret. No. Riss Ria? Ria Rao R150 Rist Ris2 Risa Risa R155 Fi58 Ris7 Rise, R159 160 ret R162 163 Ries Ries: Ries R167 R68 Ries R170 Riv R172 R173 Rize Riz. R176 R17 A178 AY79 R180 Rie Rie2 Riss Risa Ries, R186 Rig? Risa Rigo R190 Rigi R92 A193 Ri94 R195, R196 R197 198 A199 R200 R201 R02 R203 R204 205 100K 100K82 47002 470Ki2 470Ki2 470ks2 | a70Kn | ATO 470K | 47oKs2 J 100K«2 470kQ 1.2K 2700 820) 1200 1802. 1502 1802. 20 2.2Kee 4k 120K 27k Not Used 27K82 Not Used 330k02 100K 10k 10k 100 100ks2 56K 18ka. 47a) 220 Not Used 70 12K9 1K0. | s30K0. | 150k0 [Not Used Description GW + 546 T RS Part No._[Mir, Paris No ere018) 6160164 6160159 | ete0183 ereora4 6160136 6160139 6160157 6160182 6160140 6160134 6160133, 6160133, 6160152 60507127 6160160 6160160 6160160, er60168 er60168 | ete0168 6160168 6160168 6160168 6160168, 6160168, 6160160, 6160168, 6160137, 6160129, 6160123 6160125, 6160127, 6160126 6160127, 6160123 6160140 6160136 6160161 6160153, 6160153, 6160166 6160160 6160148 6160148, 6160712 6160160, 6160157 6160151 | 6160120 6160104, 6160120, 6160149, 6160149, | s160166 | sre0162 Ret. No. Description RS Part No. [Mir. Parts No, R06 ‘| S300 6160130 R207 | 1.8K. 6160139 208 | a30K62 | sre0166 R209 | tka 6160136, Re10 | 15k. 6160150 Rai) | 82k e160147 TRANSISTORS. — ar FET 28K2510 7030060 a2 28033308 lo 1022020 2scascoT R 1022023 as FET 2SK291R | 1030081 as FET 2Sk291R 1030061 a5 FET 28K212E 1030001 a6 2Sc29990 1020181 a7 FET 28K291—R 1030061 a8 2802839E 1022000 a9 2833308 1022020 aro 28c2839E 1022000, on 2SAigt7T Jo to20273, 28A1317U 1020271 are 28¢3330T |o 1022023 28¢3330U R 1022021 13 2SAt3i7T 1020273 2SA1317U R 1020271 ow 2SAi3177 }o to20273 2Sa1317U | 1020271 ars 28033307 (© 1022028 2833300 1022021 ars 2803330T © 1022023 28033300 R 1022021 air 28C2839E 1022000 ais 28C3330T }O 1022028 28¢3330U R 1022021 ars 2scasoT (© 1022023 28C9330U R 1022021 20 28¢3330T fo 1022028 28033300 R 1022021 21 2833307 © 1022023 28033200 |R 1022021 22 FET 28K2910 1030060 23 2scassoT © 1022023 28C3330U R 1022021 2a 28C3330U 1022021 02s 2SA1317T 10 1020273 2813170 R 1020271 26 28A1317T (© 1020273 28A1317U 1020271 er 28C2099E 1020180 228 28C2839E 1022000 29 28C2999E 1020180 30 2SAi3177 1020273 2SA1317U. R 1020271 ast 2SA1317T 1020273 2SA1317U R 1020271 32 FET 28K3818 1030071 33 28033308 1022020 034 FET 2SK3818 1030070 235 28033307 Jo ro22023 2833200 1022021 ass | 2scaas0T (© 1022028 39 Tet No. Description AS Part No. Mir. Parts No. 2scssa0u R 1022021 esr fasatai7T Jo. 1020273 2SA1917U JR 1020271 ase |ascsas0u 022021 ase |ascas30u soz2021 oxo | 2satsi7T © 1020273 28013170 R 1020271 as |ascasa0u | 1022021 as2 — |ascaszou 1022021 043 28D1012G | 1023000 se | 2saroz0y_ ee el _ 1020250 TRIMMERS — Tc1 | WOpF 222.808-23100 T ¥2i0070 To2 ‘TOpF 222-808-23109 | 1210010 tes | 100pF 222-808-3210 +¥210030 ta _|ropF voTsic213a 1210003 [VARIABLE RESISTORS - VARI | VA SOKAK {BKTEKI2A0089-S6) (Volume) 1310730 svnt_— SVR 100kB (0) (FM Scan Stop) +320150 syne [SVR 10K —(E) (MPX VCO) 1920160 svp3 [SVR 10K (€) (FM Strength) +¥320160 svp¢ [SVR 10K (E) (AM Strength) +¥320160 svas [SVR 10kK8 __(E) (Batt. IND) _ i 1320160 ee DCIDC Shield (Up) 2149020 DCIDC Shiels (Down) 2149090 VCO Shield (Frame) 2149040 VCO Shield (Cover) 2149050 1st OSC Shield (W/Mylar Sheet) 2149060 2nd OSC Shield _(WiMyiar Sheet) {2149130 End Of PCB-A Ass'y “PCB-C Ass'y (Control Board) [_osate602 t PCB Bank {= 510800 | CAPACITORS (Ail Chip Capacitor Material Ceramic Uniess Noted Otherwise) ——| 401 OO1uF 25V 2 1006, XTRA | «010367 aoe OomF 25v +1056 X7R-A | soos 403 OTH 25V + 10% X7R-A 4010967 a4 OOmpF 25V = 10% X7R-A 4010367 40s OIF 25V + 1096 X7R-A 4010967 C405 O.047uF 25V +80%-200 YSV-A 4047371 C407 | Not Used 408 ‘OIF 25V + 10% XTRA 4010367 e409 | Not Used ca10 | Not Used carr | Not Used oai2 OanF 25V +80%0-20% YSV-A 4010471 cara OnuF 28V +80%-20% YSV-A 4010471 cata O.01uF 25V + 10% X7A-A 4010367 cars| Elect. 10uF tev 220% = 7 444106318 cate 0.001 Sov SL-A 4010219 car7 Oo 25v X7A-A | 4010367 ca8 oom 25v X7R-A 4010367 cao Ot 25V +80%-20% YSV-A 4010871 420 O.001MF SOV 25% SL-A 4010219 Gaz O.00mIF SOV 5% sta 4010219 cao2 OF 25V +80%-200 YSV-A 4010471 caza O.047uF 25V +.80%-20% YEV-A 4047971 Caza 1SpF BOY = 5% NPO-A 4015001 C425 | Not Used 426 _| Not Used 40 Tet. Wo. Description [LAS Pan No. [Mir Paris No, oar O.001mF SOV 25% SLA | j abioase caze [Elect 4.7uF © 50V + 208 a7 | 4447540 caa9 OF 25V +80%-20%% YSV-A | aoroa71 C430 Elect. 100nF | 6.3V=20% xB | 4410710 cast O.1uF_ 25V. +80%-200% YEV-A 4010871 Cas2_|Sup. 0. 0.047uF _5.5V_ + 60%-208% |_ 4947300 [CONNECTOR — al CNTagt | ONT. Housing 3 USTIAE 1702000 | CNT. Wire Ass'y 15P__ ISTIUAE) 1703128 ‘CRYSTAL pasemceae| | xa01 1 18aa0aRRe 077 BIODES — —_ D401 598-78 |} toasooa' soz | 8898-2 +o46000T eos | 1NaT4eTA s040020T aos | aNa14eTR | | toaozoT 0405. | 1Na14eTR 10460007 0406 AING148TR | | soasoo0r aor | aNai4aTR | | 1oaoc20T D408 | aNa14eTR | tosooe0r Ds09 | iNa14aTR | 10460007 oar | aNataaTR | | 10460007 Davy | anaraaTA | tos0oa0 Dare | 1Na14aTR | 10400207 Dss3 | 1N614aTR 0460007 Dare | NATaaTR 10460007 pars | Not Used | bai __ - _|_10400207_| INTEGRAT — | icao1 Vattage Regulator 1011360 IG4o2 | $81290A0-AB-T2 Voltage Regulator 1011360 ic4a3__|Lsi ywPO7S308GF-508-389 Cmos Single-Chip Microcomputer __|__ 000021 “0% | TOmm 0.56 3000080 sao2 | 10mm 0.60 2000080 aoa | 125mm 0.60 8000050 40s | 125mm 0.60 8000050 aos | 125mm 0.60 8000050 ‘aos | 12.5mm 0.60 000080 407 | 125mm 060 8900050 aoa | 12.5mm 0.60 8000050 ‘409 | Smmn 0.60 000010 aio | 5mm 0.80 00010 Recs | 5mm 0.60 8000010 vat [7.5mm 0.60 900030 a2 | 5mm 0.60 000010 wig [smm0.60 000070 vara | 10mm 0.60 000040 418 | 15mm 0.60 000020 sie [5mm 0.60 wai7— [5mm 0.60 sare | 7.5mm 060 000030 TAMPS [S13 BY COMA L [7800801 [ceo 1600120 PVC JUMPER WIRES | waot | 4Wire 70(6+6) P=2.0GRY B725350 waoz [5 Wire 80 (6+6) P=20GRY 850010 waos | 80 (9+9) WHT (awe28 1085) 8171260 waos [60 (+8) RED (aw28 1085) 8170062 a Ret. No, Description RS Part No. [Mir. Parts No. waos | 60(+8) ORN (AWG26 1085) 8170863 waos | 60(9+9) YE. (Awa2s 1035) 2170864 wao7 | 60(9+9) GRY (Awa26 1035) 8170868 weo8 5 (9+ 9) GN, (AWG28 1095) 8170765, [CRESISTORS (All Carbon Film 1/10W = 58% Chip Type A, Unless Noted Otherwise) aor] 330K Sr60Tes aoe | 330k0 6160166 aos | 330k0 6160168, aos | 22kQ 6160152 j aos | 27k 6160153, R406 | 82k. 6160159 Rao7 | 3.9k0 160142 Raoa | 10K. 6160148, Raog | 10K. 6160148 Raro | 1.20 6160137 rary | 1.5k0 6160138 Raz | 27k. 6160153 Raia | 100k 6160160 Rais | 150k0 6160162 Rais |6.8k0 6160148 aig | 150k | | ereor62 naz [oa 6160194 Raia | 100k 6160160 Raia | 100K | 6160160, Rezo | 100k 6160160, Razr | 560k 6160169, raze | MO 6160172 Raz3—| 100K 6160160, Rave | 470k e160168, R25 | tekKa 6160151 raze | 1.50 6160138, Rag7 | 4.50 6160138, Raza | 15k 6160138, Raza | 10K. 6160148 Rago | 10K 6160148, agi | 10K. 6160148, Razz | 93KQ. 6160154 Rass | 82K 6160159 Rasa | 150k0 6160162 Rass | 1.502 160141 Rage | 930k 6160166 Ras? | 470KQ 6160168 Rasa | 470K 6160168 azo | 10K. 6160148 Rago | 10K 6160148, Raa1 | 930K. | 6160168 Raaz2 | 2200 6160128, Raaz— | 1000 6160124 rasa [a7 | 6160120 Raas | 2700 6160129, R446 | Not Used aay | 15k0. 6160150, Raga | 15k0. 6160150, Raag | 180K0. 6160163, aso | 120k0. 6160161 Rast 120k 6160161 as2 | 120K. 6160161 453 | 120K. 6160161 asa | 120K02 6160161 Rass | 120KQ. 6160161 42 Ret No. Description RS Part No. [Mir Parts No. ase 180K) 160163 RAS? 150K) 160162 | R458 AD 10.n1/eW SMB 6010512 Ra59 | Not Used Reso jan 160198 Ragin 60194 | SWITCHES: ——— —— sa01 (GFO Onior | 1636600 $402 | 2P2C (Wide/Narrow) | 1630600 sas | 226 (Guzz/Radio) 1630600 seos | 4P2ciHy) (Hold) 1630340 sas | 1P9c (FastiSlowiLock) | rea0620 saos__|1P20 (@K/10%) 1630010 ‘ORS = 2SC162IL6 TD 7020280 2SC162916 (T2) 020240 280162916 (72) 1020240 280162316 (72) 1020240 28C162016 (2) 1020240 2SAB12M6 (72) | 1020230 28B81506 | o1020210 29881587 1020211 280182316 (12) 1020240 2SA812M6_(T2) 1920230 _| [ROBE 2202-608 20128 = VARIABLE RESISTORS ~ VR: VR SOKA ‘VR 100KB VR 1008 Rotary Encoder (WIO Detent) [End OFPCB-C Ass'y SEMICONDUCTOR LEAD IDENTIFICATIONS Transistors Cc i ao eee 2sKer2e 28028308 2SAB12M6 28D10126 280162316 2SAIs17T/U 28881586/87 28C29990/E 28C33308/T/U 2SA1020Y 2SK381A/8 28K2910/R {E: Emitter C: Collector B: Base S: Source G: Gate D: Drain) Diodes Cathode Mark N60 188238 uz-168H (A: Anode C: Cathode) q EXPLODED VIEW EXPLODED VIEW Mss y 7 a 4 Mi) 3 RB / 8 F S & MECHANICAL PARTS LIST 24 25 26 Description ‘Ant, Bar Holder (L) | Ant. Bar Holder (R) | Bod Ant. Holder Key Knob Panel Ass'y Key Knob Panel Key Knob Holder Key Knob Ass'y End of Key Knob Panel Ass'y Rod Ant Handle LCD tituminator Slide Knob Holder (8) | Slide Knob Holder (A) | Key Board Shield LCD Shield Plate | PCB Supporter Rod Ant. Connector Battery Terminal (For C-PCB) Shiold Plate (For C-PCB) | LCD Holder |P.C.B. Hemelon (For APCB) | ant. Bat Fixed Sponge EVA Cushion (For Back Supporter 4.5) Lamp EVA Spacer Key Board Rubber | Conductive Rubber (For LCD} Front Cabinet Ass'y | Front Cabinet Homelon Speaker Grill LOD Window Dial Plate End of Front Cabinet Ass'y Back Cover Ass'y (For USA) (For CANIUSA/AUS) Back Cover Battery Housing Case | Battory Contact Battery Contact (+) (For UM Battery) | Battery Contact (+) (For UM-1 Battery) | Ribbon (For UMS Bationy) | Battery Conductor (WiSpring) (For UM-S Battery) | Battery Contact W/Spring) (For UM-1 Battory) TP Screw 2.638 P NI (Battery Contact) Ribbon (UM-1 Battery) PU Foot | PVC Wire 160 (0 + S)BIK(AWG26 M.Bat (-) ~Batt. Contact (-) PVC Wire 150 (3+ 8)Red{AWG26 M.Bat(-) ~Batt. Contac (-) PVC Wire 110 (3+ 8)Whi(AWG26 Back-Up Batt(-}-M. Batt (-) Rating Plate (For USA) (For CAN. U.K. AUS.) | End of Back Cover Ass'y | Battery Cover Ass'y | Battery Cover | PU Foot EVA Cushion | End of Battery Cover Ass'y | Back Supponer No. 2018070 2018080, 2018100, 07916802 2085010 2065030, 3186501 3606901 2065050 2065070 2065080 2065090 2166010, 2165020, 2165040, 2165080, 2165090, 2165150, 2165170, 2256000, 2318000, 2365010, 2365040 2465000 2465010 06416602 3018620 2265000 3496601 3056531 3426520 06516802 06516603 2036501 2085000, 2165060, 2165070 2165140, 2258020, 2104050, 2165130 ‘9102082 2265010 2465030 8132860 8132662 8171869 3406520 3406523, 07916603 3056531 2465030, 2365020, 3066520, 45 28 29 30 31 22 33 34 35 36 37 38 39 40 4” a2 43 "Bower Kab | Volume Knob | Tuning Knob | Band Knob | Side Knob (8) | Slide Knob (A) | Light Knob | Manual Tuning Knob | Time Set Knob | Dual Time Knob | Rotary Knob | Extint Hardware Kit Description (SleoprTime/Dualy [TP Screw 2.6x8 PW NI (C-POB x 6, A-PCB x 3) | TP Screw 3x8 PI | M Screw x6 P NI (Speaker x) (Pod Ant. x 1) | M Screw 2.6x4 PW NI (PCB Supporter x2) | TP Screw 2x6 P NI | TP Screw 2.6x16 P ZK (Back Cover & Front Cabinet x 5) | End of Harawace (Buzzer x2) RS Part No. | Mir, Part No. 3108507 3116501 3128501 3196501 3168501 3176501 3186501 3196501 3206501 3216501 3276501 97906601 9152082, 9153082 9003062 9052042 9101062 oro2t6t IC CIRCUIT BLOCK DIAGRAM (1) 1C1-TA7758P (2) 1C2-AN7415 > s OF 7 oo oe? o Trput “Stereo Output] [Output Oe=Amy Stereo Butfer 4 Signal ‘Amp | |_Amp Schmitt || Lamp ‘amp._| [Demodulator [' Trigger Driver Te] Monaural Veo Kil Wono/Stereo neat Switeh ioe ‘Phase ret [ Detector (eae 1 ‘Stabilized] |_[“Phose Wo 1/2 72 1/2 j~{Dc—Amp }+} +] Divider FY Divider be} Divider gone Detector (76kH2) (BaxHz) | | (19'd2<90)| rl (19kH2<0) eee tl [J )D-@)-43 )—1) 9D (3) IC3-CX7961A-1 (4) IC4-TC74HC148AP woneuneon att or : “DTH 2 4 Lp Lp TO FO te yYYy yi pb 249 io (5) 1C5,6-TA75339AP/P outa [i 1a}our 3 ours [2 13] our vee [3 Ly fe] m-)t [4 411] IV(+)4 m+) [5] [30] Dx(—) 4 m2 eH ) Wi a] ms m2 7p TEL a ny (6) 1C7,8-AN7141N RF Vee + t Power "Oy Das orver input Output "O' Dour ley 7 2 4)- GNO(INY. —GND(OUT) a7 (7) IC9-LA5003, Reference Vatage Starter (8) 1401 ,402-S81230AG-RB-T2 TOP VIEW NO. [s-e0e] s-a12] 1_[Voor [GND 2 [GND] Vor Ve Dodo 3 |Voe_| Voor} (9) IC403-UPD75308GF-508-3B9 > porns | ssi porre cou =>) Ports == rorre Epos no i red = re xr Bx Mi x2 xm ome Ga Od 419M S2KHe oo ICS’ & TRANSISTORS’ VOLTAGE LIST 1c 12 13 PIN ] PIN ] PIN an ee mo fe | aw | my] rw | am | ee poo 1 zee | 208 | 1 138 | 197 | 2 | sa | too | 2 | 04 | ous | 2 ° o | eye eres a|eca [ eas [one | 3 ° ° | : T | oa | 127 | 179 4 o9s | 093 4 300 | 3.00 | | | | 5 | 138 | 1.60 1s | 093 | 093 5 120 | 1.20 { | | 6 | 198 | 160 [6 | 002 | 002 | 6 fan | oun | | | feo eso | [7 | 299 | 290 [7 [| ae | 6s t t T r 1 s | 260 | 2 | | 8 | o | © a | oo | oo | | 1 | 1 + 9 | 505 5.00 | 9 104 | 1.04 | 9 | oor | oor | 1 t [ w | «3 | o | wo | 04s | ons |} w | o | © r T [on 0 o | " wz [17 [aw [m0 | 199 2 4.50 159 | 12 1.32 1.32 ve | 208 | 208 i + 13 0 225 | 13 1.43 1.43 3 | 0 | o | zr | 207 | we [ans | as «fej. | 1s] use | toe | 1s | ous | ass we | use | 108 16 | oz | 002 7 | 20 | 280 | ve | uz | tas | = TESTING CONDITION 1 | 166 | 1.66 | 41. WITHOUT ANY INPUT SIGNAL AND SETTING VOLUME TO MIN. 20 | 166 | 166 | 2. SPEAKER MODE: 3, EXTERNAL ANT. IS NOT USED. 4, AM IS RECEIVED BY 150KHZ AND PUT ON THE WIDE BW, BFO OFF & AM RF GAIN IS MAX. 5. FM IS RECEIVED BY S8MHZ AND PUT ON THE STEREO POSITION, 6. LOAD IN RADIO BATTERY 6.0V AND BACK UP BATTERY 45. 7. UNIT OF MEASURE : VOLTS. 50 ey tappepey Bele /S SiS s 188/818 |S ]o1s 1s 2/8 )°18 18 z/8lojsislejel/sjelsjejs}olsls zi2lolels ZQJe-jajlo}e}alot|n}/olo}/elcol|esl/els ZQ/-|altoale zg e|s|elels zg are | EZ Peet | 3 (ele ]ele]e|e]els]el=/el2]- [8/3 a|- [als E/PISISISlZ{BlSLSIR Rls lo[sis z}°)8/8 ja ae i ||| | : tf |" zg|-|slolefolel~felolelejelels glesl- | «f° Sj) or a 3 || ZIS/SIS |S le 18/8 o/s lois) sis joys is] jel leis 2/8/8/8]slolslglolglolgisielolels z{o|#]/38 a - SE} Ee | FE eee eee ee ee ee ee ela Siler ee seh | I Flee pee *| gee 51 17 e403 cao PIN PIN PIN | ] Se reat (Pant no. | Fm | am {no | FM | aM 1 ° ° t=15 | LcD SEGMENT | a [ 205 | 298 | | - - | 2 ° ° w | ser | 187 285 | 285 3 ° ° [a7 | a0 ° ° ° ] i 3 4 ° ° 18 ° so | “7 ° | ; 3 ° ° Nero) ° o | 48 ° ° | t | 6 ° ° a | o ° | a9 ° ol | | _l | 7 ° ° zi~26 | LoD back plane | 50 ° ° I 1 8 ° ° 2 | 3228 I 3.22 } ost o | o 9 ° ° 26 3.22 | 328 82 o | o | eae | os ss | s00 | 300 23 | 108 | 1.08 | s+ | 300 | 00 | 1c. | i [PT ew [am 2 | s00 | 300 55 o | 0 No. | } 1 95 | 595 30 ° ° j 56 | 300 | 300 2 ° ° at ° o 87 o | o 3 | 35 | ats 32 ° ° sa] as | tas — 4 + [4 | 062 | ose 33 ° o so | 150 | 150 Poros 1S ° ° 6 | s00 | 300 6 5:90 5.90 | oo o 61 300 | 300 | 7 ° 0 36 ° ° ez | 300 | 300 8 193 | 1.33 Se les ze 300 | 300 2 | oo2 | o02 | 38 | 305 | 305 | 6 | 300 | 300 | se | 300 | a0 es | 300 | 300 | 40 3.00 | 3.00 66 3.00 | 3.00 { ie a1 | 300 | 3.00 67 | s00 | 300 | a | 300 | 300 es | 300 | 300 | t t | 43 | 300 | 300 63-60 | LEO SEGMENT 82 AM a 0.43 10 0.65 3.85 a2 491 0.64 an 4.35 0.01 0.01 a3 0.92 an 3.55 4.35 at 0.82 3.00 ais 2.32 3.55 2.98 as 298 ana 2.92 296 | a6 ans 225 a7 078 Issercw 434 ae 0.74 a8 0.09 2.03 0.74 1.95 a7 0.89 1.75 0.29 3.00 aw 0.62. 0.01 alels/s/o]s/aie]s |e /asl> [aja /el>fat|alelal=lo[ele/alg ELELS/SlojS]$/2/ Blo l2/ s/s lsalsizlolsleisielsljolaly o/8 EE ETE PEPE wielolwlalolwjojolwlelolofelolwsalolwlalol{ulalolulalo 8 § 8 8 8 g g 8 8 a —_ _— ——s - Z/8/2 18/5/28 /2/8/8]218]o/8fols[sjolslolslsislalsisfel(sis ESS ISIElSISIRLS|Slolelelofelelolelolejelololojolole]s wlololulalolwlale elwlofofulafofujafolwlalolwlalo § § § § 8 g 8 (0406 one 8 ° ° c ° 0 6.00 6.00 E 5.10 5.05 0407 5.99 5.99) oss 8 584 5.83 ° 0 c 597 597 0 0 e 6.00 6.00 0408 ° ° ona 8 a1 531 5.98 5.99 L c 897 597 389 3.53 409 3.00 3.00 3.95 3.95 SCHEMATIC DIAGRAM (Cd i at No.20-214) wong [Eas oh seay eae WERTH Notes : 11) Ali capacitance values are indicated in “uF* (P= 10-* uF. {2} Al resistance values are indicated in “ohm” (K=10* ohm, M= 10* ohm), ‘To conta. 223 SCHEMATIC DIAGRAM (Cat No.20-214)

You might also like