Service Manual

Buses
Group 37
Release 01

Multiplex electrical system Version 2

Wiring Diagram

B11R (3), D11K, COACH

Chassie nr: 175795 -

Valid from: 2015-09-28

NR:20026
 Foreword

The products are under continuous development. This may affect the correctness of the information in
this manual. If the differences are significant, new editions of this manual will be released to cover the
changes.

Volvo Bus Corporation, Gothenburg, Sweden

All rights reserved. No part of this publication may be reproduced, stored in retrieval system, or transmitted in any
forms by any means, electronic, mechanical, photocopying, recording or otherwise, without the prior written
permission of Volvo Bus Corporation.
 D

A
C

B
E
Engineering Release Location Change Description A = Added W = Was Document Release Status
Notice (ERN) D = Deleted RELEASED
Date Modification Count

See DCN
0

0
WIRING DIAGRAM INDEX
VOLUME 1
NAME PAGE
INSTRUCTIONS 2
ABBREVIATION LIST, 24V 6

VOLUME 2
NAME DESCRIPTION PAGE NAME DESCRIPTION PAGE
1

1
AA2 Power Supply 1 FB4 Regeneration control 49
AB2 Ignition System 2 FC2−1 Volvo Dynamic Steering 50
AC1 Alternators for MDE8 and MDE11 3 FC2−2 Volvo Dynamic Steering Gateway 51
AD1 I−Start 4 FD1 Steerable Boogie Axle 52
BA1 VECU, Power and Ground 5 GA1 SLCM, Light Control Module 53
BB1 BBM Power and Ground 6 GB1−1 Headlights, Halogen/Xenon 54
BC1 BIO Power and Ground 7 GB1−2 Headlights, Bixenon 55
BD1−1 Instrument Cluster Mating 8 GB2 Fog Lights 56
BD1−2 Instrument Cluster Control 9 GC1−1 Direction Indicators, Front 57
BD1−3 Instrument Cluster Control 10 GC1−2 Direction Indicator, Rear 58
BE1 Tachograph for I−shift and ZF Ecolife 11 GC2 Side Marker Lights 59
BE2 UTachograph for I−shift and ZF Ecolife 12 GD1 Brake Lights 60
BF1 Alcolock for Carling 13 GD2−1 Park Lights, Front 61
BG1 On Board Diagnostic (OBD) 14 GD2−2 Park Lights, Rear 62
BH2 Adaptive Cruise Control 15 GD3 Reverse Lights 63
BI1 Accelerator pedal 16 ID1 Engine Room Light 64
CA1−1 Engine Interface MDE8 and MDE11 17 ID3 Luggage Lights 65
CA1−2 Engine Interface MDE8 and HDE11 18 JA1 Radio 66
CA1−3 Engine Interface MDE8 and HDE11 19 JB1 Steering Wheel Switches 67
CB1−1 Aftertreatment System 20 JD2 AIC − POWER SUPPLY & GROUNDING 68
CB1−2 Aftertreatment System 21 JE1 TGW2−POWER SUPPLY & GROUNDING 69
2

2
CB1−3 NOX Sensors 22 JF1 FMS−GW3 70
CB1−4 UREA 23 OG1 WWS, Windshield Wiper System 71
CB1−5 Fuel Quality Sensor FQS 24 OH1 Windscreen and Headlight Washer 72
CE1 Fuel Cut OFF 25 VA2 Active Safety 73
CE2 Heater Water Separator for MDE8 26 VD4 Engine Room Hatch 74
CF1 Heat Sensors x2 27 XA1 CAN, Backbone 1 75
CI1 Water Heater for Regeneration 28 XB1 CAN, Backbone 2 76
DA1 I−Shift gearbox 29 XC1 CAN, PT Subnet 77
DA2−1 ZF Ecolife 30 XD1 CAN, Engine Subnet 78
DA2−2 GSS with Gear Mode Switch 31 XE1−1 BUS, J1939−2−3 79
EA1−1 EBS, Electronic Brake System 32 XE1−2 CAN J1939, FMS 80
EA1−2 EBS, Valves and Sensors 33 XF1 CAN, D−BUS 81
EA2 EBS, 3rd_Axle 34 XG1 CAN, E−BUS 82
EB1 EBS, Diff Lock 35 XH1 BUS, J1587/1708 83
EC1 EBS without Electric Steering 36 XJ1 BUS, ZF Ecolife 84
ED1 EBS, Hill Start Aid 37 XM1 CAN, Active Safety 85
EF1 APBE 38 XO1 CAN, VDS 86
EG1 Park Brake 39 YA1−1 BBI, Body Builder Interface 87
EH1 Retarder Controls 40 YA1−2 BBI, Body Builder Interface 88
EH3 Retarder Voith 41 YA1−3 BBI, Body Builder Interface 89
YA1−4 BBI, Body Builder Interface 90
3

3
FA1−1 ECS, Air Suspension 42
FA1−2 ECS, 1st Axle 43 YA1−5 BBI, Body Builder Interface 91
FA2 ECS, Switches 44 YA1−6 BBI, Body Builder Interface 92
FA3 ECS, Second Axle 45 YA1−7 BBI, Body Builder Interface 93
FA5 ECS, Extra Axle (Boogie) 46 ZA1 Ground 94
FB1 Air Dryer 47
FB2 Air Sensor Wet Tank 48

Document title
The copying, distribution and utilization of this document as well as the
communication of its contents to others without expressed authorization WIRING DIAGRAM
is prohibited. Offenders will be held liable for payment of damages. All
rights reserved in the event of the grant of a patent, utility model or
CHASSSIS B8R & B11R
ornamental design registration. FOR BODY 9508R|9511R|9711R|9911R
Document type
4

PRODUCT SCHEMATICS
Owner domain:Document prefix

Document No Issue Volume Sheet No

70402006 05 01(03) 1(7)

D

A
C

B
E
 D

A
C

B
E
Example of Wiring Diagram
0

0
Componenet wiring diagram title, variant/subtitle and
sheet number.

Coordinates (B 1).
1

1
0.75VO/W

0.75VO/W
0.75GR/W

0.75GR/W

0.75GR/W

0.75GR/W

0.75P

0.75GR
0.75BL/SB
0.75GR
0.75P
0.75BL/R

B+ Voltage battery with switch in ON position.

30 Voltage battery with main switch on, kl.30.
15 Voltage with starter key in drive position, kl.15.
DR Voltage with starter key in drive position,
preheat position and start position, kl.DR.
2

2
Splice.
4.0W

Fuse.
3

3
0.75GR/W
0.75SB
0.75SB

0.75SB 0.75GR/W

Reference arrow, for Diagram BA, coordinates 0 C,

0.75BN 0.75BN
component A17, connector PA pin 29.

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 01(03) 2(7)

D

A
C

B
E
 D

A
C

B
E
The maximum of variants are drawn, think about
that all wires and components are not standard for
0

0
all markets or vehicle models.

1.5R/W

1.5R/W

0.75R/W

1.5R/W

Switch.
1

1
Relay with position.
Relay
POS_SC100:C

Conductor on circuit card.

2

2
0.75GR/W
0.75SB 0.75SB

0.75GN/W

Connector MB terminal 9.

0.75GR/W
0.75SB
0.75SB

0.75GN/W
3

Wire area, colour and equipotencial.

0.75RD
2003

0.75RD
2003

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 01(03) 3(7)

D

A
C

B
E
 D

A
C

B
E
0

0
Thin lines, wires.

0.75GR/W

0.75SB 0.75SB

0.75GN/W

Earth connection to circuit card.

1

1
Earth connection without wire.
2

2
XSCG11
Same splice can be drawn on several diagrams.
XSCG11 4.0W
The wire from the splice to the earth connection
point will only be drawn and coded on one
GND1 diagram. On the other diagrams will only the
earth connection point be written besides the
splice.

BIO
3

An ECU symbol with a dashed box describes

that the ECU exists in several different sheets.
HDI Req_Sign

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 01(03) 4(7)

D

A
C

B
E
 D

A
C

B
E
0

0
XC005:15 Twisted wires.
XC005:16
XC005:14

inline connector symbol for power cable ring

terminal.
1

1
70BK

Interface symbol.
XCB602M

Splice with dotted line indicates that wire already

XC022:31
exists in some other sheet and splice is shared.
2

2
INSTRUMENT

XS−2003_11

1.0RD

2003

ELECTRICAL_CENTER The text on either side of the inline incates that

0.5RD/YE INSTRUMENT
wire belongs to stated harness.
2076
3

ELECTRICAL_CENTER
XC022:18
INSTRUMENT
0.5RD/YE

2076

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 01(03) 5(7)

D

A
C

B
E
 D

A
C

B
E
ABBREVIATION LIST, 24V
0

0
SHELL_CAVITY HARNESSES
+15 VOLTAGE_WITH_STARTER_KEY_IN_DRIVE_POSITION
+30 VOLTAGE_BATTERY_WITH_MAIN_SWITCH_ON
+30C VOLTAGE_BATTERY_WITH_MAIN_SWITCH_ON
AC AIR_CONDITION
Acp ACCELERATOR_PEDAL
AI ANALOG_INPUT
AIC ADVANCED_INFORMATION_CENTER
Amb AMBIENT
An.IN ANALOGUE_INPUT
AO ANALOG_OUTPUT
APBE AUTOMATIC_PARKING_BRAKE_EVACUATION
ARC AIR_REGENERATION_CONTROL
ARMS AUTOMATIC_RESET_MAIN_SWITCH
B+ VOLTAGE_BATTERY_WITH_SWITCH_IN_ON_POSITION
BB BODY_BUILDER
BBM BODY_BUILDER_MODULE
BHSA BRAKE_HILL_START_AID
Bpole BATTERY_POSITIVE_BEFORE_MAIN_SWITCH
Brk BRAKE
1

1
Buf BUFFERED
C CLOSING
CampL CAMPIGN_LIGHTS
Cent CENTERING
CICU Charging
Ctrl CONTROL
Cyl CYLINDER
Dash DASHBOARD
Deliv DELIVERY
DI DIGITAL_INPUT
Diag DIAGNOSTIC
Dig.OUT DIGITAL_OUTPUT
Dir DIRECTION
Dis DISABLE
DO DIGITAL_OUTPUT
DRL_RMC DAYTIME_RUNNING_LIGTH/REDUCED_MODE_CONTROL
EACC ELECTRIC_AIR_COMPRESSOR_CONTROL
EBS ELECTRONIC_BRAKE_SYSTEM
ECB VBC_ENGINE_COMPRESSOR_BRAKE
ECU ELECTRONIC_CONTROL_UNIT
ECU_GND EXTERNAL_GROUND
2

2
EGR EXHAUST_REDIRECTION_VALVE
ELC ELECTRICAL_CENTER
EMT EXHAUST_MANIFOLD_TEMPERATURE
Eng ENGINE
EPG EXHAUST_PRESSURE_GOVERNOR
ES ENGINE_SYNCRONIZATION
ESS ENERGY_STORAGE_SYSTEM
ETCC EXHAUST_TEMPERATURE_CATALYTIC_CONVERTER
Ext EXTERNAL
FRC FRONT_RELAY_CENTER
GECU GEAR_SELECTOR_ELECTRONIC_CONTROL_UNIT
GND SIGNAL_GROUND
H HIGH
Haz HAZARD
HDI HIGH_DIGITAL_INPUT
HDO HIGH_DIGITAL_OUTPUT
HLa HEADLAMPS
HPCU HYBRID_POWER_TRAIN_CONTROL_UNIT
HS HIGH_SIDE
HSA HILL_START_AID
HSD HIGH_SIDE_DRIVER
3

3
HVAC HEATING_VENTILATION_AIR_CONDITION_SYSTEM
Hyd HYDRAULIC
IJ INLET_JET
Ind INDICATOR
Inj INJECTION
JK JACK_KNIFE
KL KEY_LINE
L LOW
LCM LIGHT_CONTROL_MODULE
LCP LIGHT_CONTROL_PANEL
LDI LOW_DIGITAL_INPUT
LDO LOW_DIGITAL_OUTPUT
LS LOW_SIDE
Nd NEEDLE
O OUTPUT
OBD ON_BOARD_DIAGNOSTIC

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 01(03) 6(7)

D

A
C

B
E
 D

A
C

B
E
0

0
SHELL_CAVITY HARNESSES
OLS OIL_LEVEL_SENSOR
OP OPENING
OV OVERFLOW
PCM POWER_TRAIN_CONTROL_MODULE
PCS PRESSURE_CONTROL_SOLENOID
PCV PRESSURE_CONTROL_VALVE
Plo PLOUGH
Pos POSITION
PR PRESSURE_REGULATOR
Pres PRESSURE
PS PRESSURE
PWM PULSE_WIDTH_MODULATION
Rad RADIATOR
RAI RESISTANCE_ANALOGUE_INPUT
Red REDUCTOR
Rel RELAY
Req REQUEST
RES INPUT_FOR_SENSORS_WITH_VARIABLE_RESISTANCE
Ret RETARDER
1

1
RX SIGNAL_RECEIVER
Sen SENSOR
Sign SIGNAL
Sno SNOW
Sp SPEED
SS SENSOR_SUPPLY
St START
Stp STOP
SV SUPPLY_VOLTAGE
Sw SWITCH
TCC TORQUE_CONVERTER_CLUTCH
Temp TEMPERATURE
Tor TORQUE
TX SIGNAL_TRANSMITTER
UBat FEED_DIRECTLY_FROM_BATTERY
VEB VOLVO_ENGINE_BRAKE
Veh VEHICLE
2

2
3

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 01(03) 7(7)

D

A
C

B
E
 0 1 2 3 4
Power Supply AA2
Bpol+
B+
+30

A +DR
+15
A

FH1:2S

FH1:3S

FH4:1S

FH4:2S
FH2:1S

FH2:3S

FH3:1S

FH3:2S

FH3:3S

FH4:3S
FH2:2S
FH1:1S XO:1 XG:1 XT:1
ELECTRICAL_CENTER ELECTRICAL_CENTER
4.0RD 4.0RD 4.0RD 4.0RD 4.0RD 4.0RD 4.0RD 4.0RD 4.0RD 4.0RD 4.0RD 4.0RD

10RD
2003 10RD
2003
XS−2002_01 XS−2002_02 10RD
2003
16RD
2002
16RD F104 F121
2002 C 1 D 1 A 1
150A 5A
3 2 XJB102
1
XJB101 XC100C:1 XC100B:1
B 1

BBOX
16RD
XJB201 2002
35RD 100 Ohm 25RD
2 3 2001
B 50RD
2001
XJB201_TO_XC100

A A1 D
2002
B
1 K102 1 XC100F:1

50RD Body Relay 86 88 Fuse

Check
300A

BBOX
2001 Main Relay
POS_XC100:A 85 88A F101

XC100_TO_S41
G01A_TO_XJB201
XJB201_TO_X47

B A2 XC100:12 150A
E 1 C 1 C 2

A
XJB202 1
B 1
0.75BK
1
C 1A 1 S41 B 1 F100
G01A 35RD
Switch, battery 400A
2002
Battery 1 main switch control A 1
XSCG2−21
B
1

G01A_TO_G01B
XC100G:1
S41_TO_XJB202

C C

XC100_TO_XC200
50RD
2072
K103
85
C 1 A 1 Relay ARMS 87 87A
G01B (Automatic Reset Main Switch)
50RD 1.0RD 0.75RD Battery 2 30
2001 2001 2082 86
B 1 POS_XC100:D 70RD
2002
B 1
A
B250
+
12V XC100:11 XC100:8 XC200A:1
X47 A 2
Sensor, Battery FRONT_AXLE
External 1 A
0.75WH/YE 0.75WH/BU
Plug, Battery charging charger 24V
0224 0215
−
outlet B 3
1 A

50BK FRONT_AXLE 0.75GY 7035 LIN GND F207

D 1 XC001:16
INSTRUMENT
1
1 C XC003:12
INSTRUMENT
XC001:2
INSTRUMENT
400A D
X47_TO_GND

G01B_TO_GND

0.75GY

VPDUR
7035 0.75WH/YE 0.75WH/BU
0224 0215

XC026:1 XC028:4 XC026:2

ELECTRICAL_CENTER 50BK ELECTRICAL_CENTER ELECTRICAL_CENTER
1
0.75GY 0.75WH/YE 0.75WH/BU
7035 0224 0215
GND21:1 LC1 3

A27 B 4 B 15
LIN

GND21:1 A36

ARMS

Main switch relay

Control unit, LCM
( Light Control Module ) Control unit, BBM
(Body Builder Module)
SLCM
E BBM E

70402006 05 02(03) 1(94)

0 1 2 3 4
 0 1 2 3 4
Ignition System AB2
Bpol+
B+
+30
+DR

A +15
Relay Relay
A
F87 F115 F68 Ignition +15 Ignition +DR F59
0.75RD/GY 2075 POS_FRC:K01 POS_FRC:K03
5A 10A 5A 5A

XC100:15
FRONT_AXLE 86 30 86 30
FRC:68
K73 FRC:59
ELECTRICAL_CENTER
FH4:2P 0.75RD ELECTRICAL_CENTER K22
ELECTRICAL_CENTER 2001
85 87 87A 85 87 87A 0.5RD/GN
XC001:25 2004
INSTRUMENT
0.75RD F30
2002 20A
0.5RD
86 XM:4 XM:3 XM:1 XM:2 XS:1
2003 XC022:8
30 K81 ELECTRICAL_CENTER INSTRUMENT
0.75RD
0.5BK 4.0RD/GN
Relay 2001 XM:11 FRC:30 XH:1 0.5RD/GN
ELECTRICAL_CENTER 2004 1 4.0RD/GN 2004 10RD 0.5RD/GN
87a 87 Main Switch 2004 2004 2004
B 85
POS_RHF
B 1
4.0RD/GN
2005
XD:3 XS−2004_01
B
0.75BK
0.5VT 1 S322 0.75BU
XS−2004_18

0178 ELECTRICAL_CENTER 5004

XD:1
Switch 0 1
Emergency Cut−Out
XCB401B.5
C 1 A 1 INSTRUMENT ELECTRICAL_CENTER
YA1−1:0 D
XC022:2
XS−0178_01 ELECTRICAL_CENTER XS−5004_01

XC023:35 0.75BU 5004 0.75BU 5004

INSTRUMENT 0.75BU
5004
S15
Switch
Key switch
86
30 K80 0
ELECTRICAL_CENTER R
XS−6001_01 XC022:3 Relay
INSTRUMENT 87 87a Emergency Switch I
0.5VT
0.75RD/GY 0.75RD/GY 0.75GN 0.5BU 0.5VT 0.5VT 85
POS_RHE
0178 2075 2075
C 5003 6001 0178 0178
0.5BK
0.5RD/YE III
II
C
2073
X1 2 X1 8 X1 10 1

C
R
S12 30
XD:2
Switch, Main Control 19
ELECTRICAL_CENTER
0 1 XC022:4
INSTRUMENT
X1 1 X1 3 X1 7 X1 9 P
XCB401B.4
YA1−1:0 D INSTRUMENT ELECTRICAL_CENTER
0.5BK 0.5BK B+ XC022:5
15
1 1 0.5RD/YE 2073 0.5RD/GN 2005 0.5RD/GN 2005
XSCG1−32 XC022:6
DR
0.5RD/GN 2004 0.5RD/GN 2004 XS−2004_02

50
0.5RD/YE
2006
D D
INSTRUMENT
XC022:7
0.75BU 5004 ELECTRICAL_CENTER 0.5RD/GN
2004
0.5RD/YE 2006
0.5RD/GN 2004
0.5RD/YE
2006

LC2 1 A 6 A 14

A27 A17

Key_Sw_Crank

Key_Sw_Ignit
+50_Crank
A36 Control unit, LCM
Ignition Key (+DR)
Emergency switch
Main switch

Control unit, VECU

Control unit, BBM ( Light Control Module ) (Vehicle ECU)
(Body Builder Module)

E BBM SLCM VECU E

70402006 05 02(03) 2(94)

0 1 2 3 4
 0 1 2 3 4
Alternators for MDE8 and MDE11 AC1
B+
+30

+DR

A +15

From K102:C2 AA
A
F201 BA1:B1
200A
F120
5A 86
K200
30 86
Relay, Heater/CCIOM 30

XC200F:1 XC200G:1 87a (Central Chassis IO Module) K72

87
XC100:6 85 87a
FRONT_AXLE 87
85
0.75RD
2003
F208
35RD 35RD 70RD 10A
2003 2003 2003
F06
XC001:1 5A
INSTRUMENT
XC200_TO_XJB601_ALT1_2

XC200:18
ENGINE_BAY
XC200_TO_XJB601_ALT3

0.75RD
2003 2.5RD/GN

B 2004
B
XC200_TO_G02C

XS−2004_03
XC007:1
CENTER 2.5RD/GN 2.5RD/GN
2004
2004
0.75RD
XJB601 2003 X4
B 1 A 1 X4 1 2
+DR +DR A163
XC080:15 CCIOM
ENGINE_BAY PWR PWR Backbone 2 (XB1) Control unit, CCIOM,
G02A
MDE11

Central Chassis IO Module

HDE11
MDE8

MDE8

Alternator 1

LIN GND
MDE

HDE
CM

A
XCA020A

LIN
LIN

LGND Connector, Engine Interface 1 GND GND

S
0.75RD
X2 25 X2 11 X1 29 X2 29
2003

HDE
HDE
S1

C 12 0.75RD 2003
0.75RD 2003 XS−2003_01
C

45

45
11 2.5BK 2.5BK
HDE11

0.75GY 0.75WH 1 1
0.75GY 7052
MDE 7052 1022
10
0.75GY 7052
HDE XS−7052_01 B 15
45

G02B 9 A17 LDO Rel_Ctrl

0.75WH 1022
HDE XS−1022_01
Alternator 2
0.75WH 1022
MDE
Control unit, VECU

45
CM (Vehicle ECU)

A
LIN

LGND

S
0.75WH 0.75RD 0.75GY 0.75WH
XSCG6−21
VECU
0335 2003 7052 1022
S1

D D

G02C
MDE8

Alternator 3

D1
CM
D2

A
LIN
B D3
LGND
1 D4
S
D5
C 1 S1
35BK
1 0.75BK
1

E GND62:1 XSCG6−31
E

70402006 05 02(03) 3(94)

0 1 2 3 4
 0 1 2 3 4
I−Start AD1
Bpol+
B+
+30

A +DR
+15
A

F109 A36
20A
BBM
Control unit, BBM

DC/DC−status
(Body Builder Module)
XC100:16
FRONT_AXLE
A 10

2.5RD 0.75GN
2001 0076

XC002:21 XC027:1
INSTRUMENT ELECTRICAL_CENTER

B 2.5RD
2001
0.75GN
0076
B
XC004:10 XC004:5
CENTER
0.75GN
2.5RD
2001 0076

XC080:57 XC080:16
ENGINE_BAY
2.5RD 0.75GN
2001 0076
A 1 A 5

U38 BAT+ Status

C Voltage converter
I−Start DC/DC
C
Battery
temp. sensor

+24V +12V GND

A 2 A A 4
3

2.5RD
G10A_TO_XJB601
70RD 2081 2084
1.0BK

C 1 A 1
G10A
Battery, I−Start
Battery 1
XJB601 F 1 B 1
G10A_TO_G10B
D E 1
2082 D
50RD
C A
G10B
A
Battery, I−Start
30

M
Battery 2
B D
M04
G10B_TO_GND

Motor, starter motor

C 31

70BK

E GND61:1
E

70402006 05 02(03) 4(94)

0 1 2 3 4
 0 1 2 3 4
VECU, Power and Ground BA1
B+
+30

+DR

A +15
A
VPDUR
XC200:14

0.75RD/BU
2007
86 86

K72 30
ENGINE_BAY K201 30 86
K200
XC080:19 30
Relay VECU 87
87a Relay, EMS 87 87a Relay, Heater/CCIOM
(Vehicle ECU) 85 0.75RD/BU
(Engine Management System) 85 87a 87 (Central Chassis IO Module)
2007 85
POS_XC200:A
POS_FRC:K02 POS_XC200:B
CENTER
XC006:24

F07 F06 0.75RD/BU

5A 5A 2007

B B
INSTRUMENT
XL:1 XL:5 XL:3 XC027:3
ELECTRICAL_CENTER ELECTRICAL_CENTER
0.75RD/BU
2007

C C

0.75WH/BN 0.75RD/BU
0179 2007

B 15 A 13

Rel_Ctrl A17
VECU
+30
PWR Control unit, VECU
(Vehicle ECU)

(T) J1939−2/3 (XE1−1)

D Gnd
Backbone 1 (XA1)
J1587 (XH1)
D
A 12

0.75BK
1

XC:2
ELECTRICAL_CENTER

E E

70402006 05 02(03) 5(94)

0 1 2 3 4
 0 1 2 3 4
BBM Power and Ground BB1
B+
+30

+DR

A +15
A
F51
5A

FRC:51
ELECTRICAL_CENTER

B B
0.75RD
2003

A 13

+30 A36
PWR BBM Control unit, BBM
(Body Builder Module)
C C
J1587 (XH1)
Backbone 1 (XA1)
(T) D−BUS (XF1)
GND
A 12

0.75BK
1

ELECTRICAL_CENTER
XC:3

D D

E E

70402006 05 02(03) 6(94)

0 1 2 3 4
 0 1 2 3 4
BIO Power and Ground BC1
B+
+30

+DR

A +15
A

F63 F55
10A 5A

FRC:63 FRC:55
ELECTRICAL_CENTER

1.0RD 0.75RD/GN
2003 2004

B XC022:28
INSTRUMENT
XC022:29
B

1.0RD 0.75RD/GN
2003 2004

C XS−2003_13 C
0.75RD 0.75RD
2003 2003
A 13 A 18 A 1

+30 +30 +DR A195

PWR PWR PWR Control unit, BIO
Bus I/O ECU
BIO
J1587 (XH1)
D−BUS (XF1)
(T) E−BUS (XG1)
GND GND
A 12

D D
0.75BK
1

XSCG1−34

E E

70402006 05 02(03) 7(94)

0 1 2 3 4
 0 1 2 3 4
Instrument Cluster Mating BD1−1
B+
+30

+DR

A +15
A
F86 F08 F05
5A 5A 5A

FH4:1P XL:8 XM:18

ELECTRICAL_CENTER

0.75RD 0.5RD/GN 0.5RD

2002 2004 2003

B B
XC023:1 XC023:2 XC023:3
INSTRUMENT

0.75RD 0.5RD/GN 0.5RD

2002 2004 2003

XS−2004_04 XS−2003_02

C C
0.5RD/GN 0.5RD

2004 2003

A 1 A 3 A 9

B+ +DR +30 A03

PWR PWR PWR
IC Instrument cluster

Backbone 1 (XA1)

D Gnd
(T) J1939−2/3 (XE1−1)
J1587 (XH1)
D
A 2

0.5BK
1

XSCG1−36

E E

70402006 05 02(03) 8(94)

0 1 2 3 4
 0 1 2 3 4
Instrument Cluster Control BD1−2
B+
+30

+DR

A +15
A
F05 F62
5A 10A

FRC:62
ELECTRICAL_CENTER
XM:18
ELECTRICAL_CENTER XC028:9
INSTRUMENT

XC005:6
XC023:3
CENTER
INSTRUMENT
XC080:34
ENGINE_BAY

B XS−2003_02
B
XS−2004_06
0.5RD
2003 0.75RD/GN
2003

XS−2004_05

A 12 0.75RD/GN 0.75RD/GN
2003 2003
S06
Stalk switch, windscreen SELECT ESC UP DOWN A 2 2
wiper, selector type B274 B275B
Sensor, Hydraulic oil level
Sensor, Hydraulic oil level
Mechanical Power steering
Engine fan
C A 8 A 9 A 10 A 11 A 1 1 C
0.75WH/YE 0.75WH/GN
0018 0019

XC080:27 XC080:28
0.75WH/YE 0.75WH/BU CENTER
0169 0171

0.75WH/YE 0.75WH/GN
0.75WH/BN 0.75WH/GN 0018 0019
0168 0170

XC005:7 XC006:16
INSTRUMENT INSTRUMENT

0.75WH/YE 0.75WH/GN
0018 0019

B
D A 4
HDI Select
A 5

Escape Up
A 6 A 7 28
HDI Hydr_Syst1
C 20

HDI Hydr_Syst2 A03 D

Down
Instrument cluster

IC
Instrument Switch Selector Hydraulic System

E E

70402006 05 02(03) 9(94)

0 1 2 3 4
 1 2 3 4 5
Instrument Cluster Control BD1−3

A A

A03
IC Fuel level
Instrument cluster
PWR PWR PWR

A/D_PU Sig_1 Sign_Gnd GND Redundant A/D_PU Sig_1 A/D_PU Sig_2

B 9 A 12 B 1 B 3 B 11

0.75WH/BK 0.75WH/BK
0.75WH/BN 0.75WH/YE
1021 1021
0113 0114
B XS−1021_02 B
0.75WH/GN 0.75WH/BK
8019 1021

INSTRUMENT INSTRUMENT INSTRUMENT INSTRUMENT

XC002:14 XC001:10 XC001:8 XC001:9
FRONT_AXLE FRONT_AXLE FRONT_AXLE FRONT_AXLE

0.75WH/BN 0.75WH/YE
0113 0114

0.75WH/GN 0.75WH/BK
8019 1021
A 1 A 1

C B07 B279 C
Sensor, Fuel Level
Sensor, fuel level Second
A 2 A 2

0.75WH/BK 0.75WH/BK
1021 1021

XS−1021_01
0.75WH/BK 1021
A 1 A 2

B22
Amb_Temp

Rtn

Sensor, outdoor temperature ~

D D

E E

70402006 05 02(03) 10(94)

1 2 3 4 5
 0 1 2 3 4
Tachograph for I−shift and ZF Ecolife BE1
Bpol+
B+
+30
+DR

A +15
A
A17
F08
5A
F115
10A
VECU
Control unit, VECU
(Vehicle ECU)

f
XL:8 XC100:15
ELECTRICAL_CENTER FRONT_AXLE HZ_PU Weh_Spd
B 6

XC023:2 XC001:25
INSTRUMENT INSTRUMENT XC022:24

XS−2004_04

B B
0.5RD/GN 0.75RD
2004 2001 0.75WH/BN 0223

A3 A1 B7

+DR BPOL+ A33

Spd_Sign
PWR PWR TACHO Tachograph

Speed_Sig

Data_Sig
GND
Sply
(T) J1939−2/3 (XE1−1)
Gnd Gnd
A5 A6 B1 B3 B2 B4

C 0.75BK
1
0.75RD/GY
2090
0.75BK
1
C
0.75WH/BN 0.75WH/VT
0223 0227

45

45
XC005:16

XC005:15
INSTRUMENT
0.75BK
XC005:14 XC005:17
1 CENTER
0.75RD/GY 0.75BK
2090 1
0.75WH/BN 0.75WH/VT
XSCG1−31
0223 0227
45

45
XC080:44

XC080:45

XC080:43 XC080:46
ENGINE_BAY
2090
0.75RD/GY 0.75BK
0.75WH/BN1
D 0.75WH/VT
0223 0227 D
45

45

26 24 7 16 XCA021
Connector
Gearbox Interface
0.75RD/GY 0.75BK
2090 1
0.75WH/BN 0.75WH/VT
0223 0227
45

45

A 1 A 3 A 2 A 4
B12
Sensor, tachograph /
speedometer
E E

70402006 05 02(03) 11(94)

0 1 2 3 4
 0 1 2 3 4
UTachograph for I−shift and ZF Ecolife BE2

A A
VECU A17
Control unit, VECU
(Vehicle ECU)
6−9V

SRC SPLY HZ_PU Weh_Spd

B 25 B 6

0.75RD/GY 0.75WH/BN
2090 0223

45
B ELECTRICAL_CENTER
XC022:23 XC022:24
B
INSTRUMENT

45
0.75RD/GY 0.75WH/BN 0.75BK
2090 0223 1

XSCG1−31

XC005:14 XC005:16 XC005:15

Can be seen on BE1

C C

XC080:44
XC080:43 XC080:45

XCA021
7
Connector
26 24
Gearbox Interface

D D

A 1 A 3 A 2
B12
Sensor, tachograph /
speedometer

E E

70402006 05 02(03) 12(94)

0 1 2 3 4
 0 1 2 3 4
Alcolock for Carling BF1
B+
+30

+DR

A +15
A
F20
10A

XJ:11
ELECTRICAL_CENTER

XC022:31
INSTRUMENT

B XS−2003_11
XS−6001_01
B
1.0RD
2003

XS−2003_03 0.75RD 2003

0.75BU
6001
1.0RD 0.75RD
2003 2003

X132
Interface, External Customer X1 1 X1 3 X1 8 X1 10
Alcolock S324
0 1

C 1 3 0.75WH/YE
0180
Switch
Driver Change
C
C Alcolock
X1 2 X1 7 X1 9

0.5BK
1
0.75WH/YE 0.75WH/YE 0.75BK
5007 0180 1

XSCG1−31

A 1 A 9 A 8
SRC +30 A132
Driv_Chng_Req
Mode Req

PWR Control unit, alcolock

D D
Alcohol
Interlock D_BUS (XF1)
GND Gnd
A 7

1.0BK
1

XSCG1−31

E E

70402006 05 02(03) 13(94)

0 1 2 3 4
 0 1 2 3 4
On Board Diagnostic (OBD) BG1
B+
+30

+DR

A +15
A
F08 F05
5A 5A

XL:8 XM:18
ELECTRICAL_CENTER

B B
XC023:2 XC023:3
INSTRUMENT

XS−2004_04 XS−2003_02

0.5RD/GN 0.5RD
2004 2003

C C
1 16

+30
+DR
OBD X43
PWR PWR Connector, OBD
(On−Board Diagnostics)

Backbone 2 (XB1)

J1587 (XH1)
Gnd Gnd
4 5

0.5BK 0.5BK
1 1

D D

XSCG1−36

E E

70402006 05 02(03) 14(94)

0 1 2 3 4
 0 1 2 3 4
Adaptive Cruise Control BH2

A A

A17
Control unit, VECU
(Vehicle ECU)

VECU
B B

OUT_Supply4
Time Gap (+)

CC_ON/OFF
Time Gap (−)

CC_Resume
CC_Set (−)

CC_Set (+)
B 7 A 17 A 1 A 2 A 30 A 3 B 5

0.5BN 0.5YE 0.5WH/VT 0.5WH/BU 0.5WH/GY 0.5BN

EH1:2 B
0174 0175 0183 0182 0184 0185
S24.1
ELECTRICAL_CENTER
XC025:26 XC025:27 XC022:12 XC022:11 XC022:10 XC022:9
INSTRUMENT

0.5BN 0.5YE 0.5WH/VT 0.5WH/BU 0.5WH/GY 0.5BN 0.5RD/YE

0174 0175 0183 0182 0184 0185 2076

C C

7 8 4 5 3 2
S02 SET− SET+ RES. ON OFF
Stalk switch, full− /
dipped beams

1
D D

E E

70402006 05 02(03) 15(94)

0 1 2 3 4
 0 1 2 3 4
Accelerator pedal BI1

A A
A17
VECU Control unit, VECU
(Vehicle ECU)
5V PWR

SRC SPLY A/D Pedal_Pos Low_ref HDI IVS_In IVS_SPLY

B 10 B 8 B 22 A 23 B 19

0.5WH/RD 0.5YE 0.5WH 0.5GN 0.5BN

2040 0079 1024 0080 0081

30
B B

XC022:14

XC022:15
ELECTRICAL_CENTER
XC022:13 XC022:16 XC022:17

INSTRUMENT

30
0.5WH/RD 0.5WH 0.5GN 0.5BN
2040 1024 0080 0081
0.5YE
0079

EH1:2 B EH1:2 B
S24.4 S24.5

0.5WH/RD 0.5WH
2040 1024

C C
XS−2040_01 XS−1024_01

30
0.5WH/RD 0.5WH
2040 1024

D D
A 1 A 2 A 5 A 3 A 4

B25
Sensor, accelerator pedal

E E

70402006 05 02(03) 16(94)

0 1 2 3 4
 0 1 2 3 4
Engine Interface MDE8 and MDE11 CA1−1
B+
+30

+DR

A +15
A
From K102:C2 AA

86 86
K201 30 30 K72
Relay, EMS
(Engine Management System) 87a 87 87a
87 Relay VECU
POS_XC200:B 85 85 (Vehicle ECU)
POS_FRC:K02
F06
XC200:8 5A

F215 F210 F211 F212 F213

10A 15A 15A 10A 10A 0.75BK

B 1
B
XC200:10 XC200:20 XC200:19 XC200:17 XC200:16
ENGINE_BAY XSCG6−31

MDE
1.5RD 1.5RD 1.5RD 2.5RD 2.5RD B 15
2042 2042 2042 2042 2042
LDO Rel_Ctrl A17

HDE
1.5RD

XS−2042_01
2042
XS−2042_03 VECU Control unit, VECU
XS−2042_02 (Vehicle ECU)
PWR
1.5RD 1.5RD
2042 2042
MDE HDE

HSD IVS_Out
Y162B.A:1 Y37.A:1 Y147.1
CA1−3:1 B CA1−2:3 B CA1−3:3 B B 17

C 0.75GN
0098
C
ELECTRICAL_CENTER
XC027:15
INSTRUMENT
0.75GN
0098

XC005:1
CENTER

1.5RD 1.5RD 1.5RD 2.5RD 0.75GN

2042 2042 2042 2042 0098

2.5RD XC080:29

2042 ENGINE_BAY

D 0.75GN 0098
D

(T) Engine Subnet (XD1)

21 33
XCA020A
(T) PT Subnet (XC1) 13 15 25 8
(T) backbone 2 (XB1)
Power Supply VPDUR

Power Supply VPDUR

Power Supply VPDUR

Power Supply VPDUR

Power Supply VPDUR

Connector, Engine Interface 1

IVS Out

Heat sensor +

(T) backbone 1 (XA1)

E E

70402006 05 02(03) 17(94)

0 1 2 3 4
 0 1 2 3 4
Engine Interface MDE8 and HDE11 CA1−2

A A
XCA020B
8 Connector
Engine Interface 2 CA1−1:2 C

START
S315 S316 START ENABLE XS−2042_02

Switch Switch
Engine Start Engine Start Enable
Rear Rear

A 2 A 1 A 3 A 1

0.75WH/BK 1.5RD
0.75BN 1023 2042
0085

B B

MDE
A 1

SRC +30
0.75WH/BK 1023 U U 24V Y37
I P
XS−1023_01 Solenoid Valve Unit
Elect Engine brake / AVU
LSD
EPG Gnd (Air Valve Unit)
PWM LSD Wastegate GND

A 2 A 6 A 7
0.75WH/BK 0.75WH/BK
1023 1023

MDE

MDE
0.75WH/BK
1023
MDE

A 2 A 3 A 1 A 3 2.5BK
B52 B39 S68 1

C Sensor, water level,

θP
Sensor, air filter pressure Proximity switch, C
water separator and air filter temperature coolant level, NC.
A 1 A 2 A 4 A 1
MDE

0.75GN 0.75GN 0.75YE 2.5BK 2.5BK 2.5BK

0.75WH/BK 0.75WH/GY 0.75BU 0.75WH/VT 0.75WH/BK
0110 0087 0334 1 1 1 XSCG6−22
1023 0107 0111 0106 1025

D D

27 31 39
XCA020A
18 20 30 19 24 Coolant Level sensor 28 7 32

Switch Engine Stop

GND

GND

GND
Water level sensor

Air Inlet Temp Signal

Air Filter Indicator Signal

Air Filter pressure Sensor

AVU Control 2
Start / Start Enable / Stop

Connector, Engine Interface 1

E E

70402006 05 02(03) 18(94)

0 1 2 3 4
 0 1 2 3 4
Engine Interface MDE8 and HDE11 CA1−3

A A

CA1−1:1 B CA1−1:2 C
XC200:10 XS−2042_03

1.5RD 1.5RD
2042 2042

B A 1
B
SRC +30 Y162B
U 24V
I Solenoid Valve Unit
Elect
Body Heating /AVU B32 A 1
(Air Valve Unit) Y147
LSD
PWM EPG GND Gnd n Sensor, engine cooling Solenoid Valve
fan speed 2 Cooling Fan / Shut off Valve
A 2 A 7 A

A 1 A 2

1.5WH/GY 1.5BK 0.75VT 0.75WH/BK 0.75BN

0272 1 0089 1026 0273

C C
XSCG6−22

45
D D
XCA020B
12 2 3 11
Connector
Engine Interface 2

E E

70402006 05 02(03) 19(94)

0 1 2 3 4
 0 1 2 3 4
Aftertreatment System CB1−1
B+
+30

+DR

A +15
A

F224 F62
30A 10A

XC200:12 XC200:15 FRC:62

ENGINE_BAY ELECTRICAL_CENTER

0.75RD/GN
2004

B XC028:9
B
INSTRUMENT

0.75RD/GN
2004

XC005:6
CENTER

2.5RD 2.5RD 0.75RD/GN

2003 2003 2004

XC080:34
ENGINE_BAY
C C
0.75RD/GN
2004

XS−2004_06

0.75RD/GN
2004

A 60 A 57 A 3

SRC +30 SRC +30 SRC +DR A174

PWR PWR PWR
ACM Control unit, ACM
D (Aftertreatment Control Module) D
Backbone 2 (XB1)
(T) Engine Subnet (XD1)

GND Gnd Gnd Backbone 1 (XA1)

A 58 A 61

2.5BK 2.5BK
1 1

XSCG6−23

E E

70402006 05 02(03) 20(94)

0 1 2 3 4
 0 1 2 3 4
Aftertreatment System CB1−2

A A

A174

DPF Pressure Sensor

ACM CAT Temp Sensor Control unit, ACM

DPF Temp Sensor

Temp Sensor Gnd

V5EXT1&2 Gnd

V5EXT1 Supply
(Aftertreatment Control Module)

Downstream

Upstream
A 54 A 50 A 26 A 39 A 34 A 42 A 56

B B
0.75RD/BU
2050
0.75WH/BK 0.75WH/GN 0.75WH/BU 0.75WH/VT 0.75WH/GY 0.75WH/BK
1051 0036 0037 0038 0039 1050

XS−1051_01 XS−2050_01 XS−1050_01

A 2 A 2 A 2
B98 B97
C B85
Sensor, exhaust temp,
Sensor, exhaust temp,
Sensor, exhaust temp,
C
T downstream catalyst T T
0.75RD/BU downstream DPF upstream catalyst
2050 A 1 A 1 A 1
0.75WH/BK
1051

A 2 A 1
B115
Sensor, DPF pressure
P
(Diesel particulate filters)
A 3

0.75WH/BK 0.75WH/BK 0.75WH/BK 0.75WH/BK

1050 1050
D 1050 1050
D

XS−1050_02

E E

70402006 05 02(03) 21(94)

0 1 2 3 4
 0 1 2 3 4
NOX Sensors CB1−3

A A

A174
ACM
Control unit, ACM
(Aftertreatment Control Module)

Signal_Nox
A 49

B B
1.5RD
2108

XS−2018_01

1.0RD 1.0RD
2108 2108

C A 4 A 4
B96B
C
B96A Sensor, NOx
NOx Sensor, NOx NOx

A 3 A 3

1.0BK 1.0BK
1 1

XSCG6−23 XSCG6−23

D D

E E

70402006 05 02(03) 22(94)

0 1 2 3 4
 0 1 2 3 4
UREA CB1−4

A174

Heat_Valve_AdBlue

AdBlue_Temp_Sens
AdBlue_Temp_Sen
ACM

AdBlue_Level_Sen
A A

AdBlue_Press_Sen
Dosage pump AdBlue Heater Hose

Air _Pressure_Sen

Air _Pressure_Sen
Control unit, ACM
PWR 5V 5V PWR (Aftertreatment Control Module)

Air_Valve
Output 2

Output 1

Output 3
PWM Gnd Gnd
HSD Xxx GND LSD LSD LSD SRC SPLY SRC SPLY LSD LSD A/D GND A/D A/D A/D A/D A/D SRC SPLY
A 20 A 16 A 28 A 32 A 24 A 59 A 62 A 4 A 21 A 35 A 54 A 27 A 47 A 23 A 18 A 46 A 51

0.75WH/VT
0.75WH/VT 0.75RD/BU 0.75RD/YE
0083
0.75YE 0.75WH/GY 0.75WH/GY 0.75WH/BU 0.75WH/GN 0.75WH/YE 0.75WH/BN
0097 0095 0095 0094 2098 2097 0093 0092 0091 0.75WH/GY 0.75RD/GY
0090
0084 2096

XS−0095_01

B B
0.75BN 0.75WH/GY
0096 0095 0.75BU 0.75BU
0088 0088

Biodiesel
Diesel
XS−1051_01 XS−2096_01

C XS−2098_01
XS−2097_01
0.75WH/BK
0.75RD/GY
2096
0.75RD/GY
2096 0.75RD/GY
C
1051 2096
A 1
A 1 A 2 A 1 A 2
0.75RD/YE
2097 B262 B263
Sensor, Urea Pressure P P Sensor, Urea Air Pressure
Y80B Y81C
A 1
M
Solenoid valve, Solenoid valve, 3
A 3 A
AdBlue dosing unit AdBlue tank heating A 2

0.75RD/BU 0.75RD/BU 0.75RD/YE 0.75WH/BK 0.75WH/BK

A 3 A 2 A 1
2098 2098 2097 1051 1051
A 3 B142B
Sensor, AdBlue level and
temperature
A 4

D A 1 A 2 A 1 A 2 0.75WH/BK 1051 D
R56 R57
Heater, AdBlue hose, Heater, AdBlue hose,
White Black XS−1051_03

0.75WH/BK
1051
A 1 A 2
A
A 3

T
Air valve Urea temp

A190
E Component group urea E

70402006 05 02(03) 23(94)

0 1 2 3 4
 0 1 2 3 4
Fuel Quality Sensor FQS CB1−5

A A

B B

A174

Fuel_Quality_sens
Control unit, ACM

Nox_Supply
(Aftertreatment Control Module)
PWR

SRC A/D Gnd Gnd

A 49 A 47 A 58 A 61

C 0.75VT C
0349

XS−2018_01 XSCG6−23

Biodiesel
0.75RD 0.75BK
2108

A 3 A 1 A 2

REF VAR RTN B307

D Sensor
Fuel Quality
D

E E

70402006 05 02(03) 24(94)

0 1 2 3 4
 0 1 2 3 4
Fuel Cut OFF CE1
B+
+30

+DR
+15

A A

K72 86
30
Relay VECU
(Vehicle ECU) 87a
87
POS_FRC:K02 85

F43
5A
B B
FRC:43
ELECTRICAL_CENTER
0.75RD/BU
2007

XC026:3
INSTRUMENT
B 15 A 13
0.75RD/BU

A17 Rel_Ctrl +30

2007

Control unit, VECU PWR

XC001:3
(Vehicle ECU) FRONT_AXLE

0.75RD/BU

C VECU
2007
C
A 2
Y160
Solenoid Valve
Fuel Cut Off A 1

0.75BK
1

XSCG2−21

D D

E E

70402006 05 02(03) 25(94)

0 1 2 3 4
 0 1 2 3 4
Heater Water Separator for MDE8 CE2

B+
+30

A +DR
+15
A

86 86
K200 30 30
K72
Relay VECU
Relay, Heater/CCIOM 87a 87 87a 87 (Vehicle ECU)
(Central Chassis IO Module) 85 85
POS_FRC:K02
POS_XC200:A
F06
F209 5A
B 20A
B

XC200:21
ENGINE_BAY

B 15
2.5RD/GN
2004 LDO Rel_Ctrl A17
Control unit, VECU

MDE
(Vehicle ECU)

A 1
VECU
C R06 C
Heater, fuel
water separator

A 2
MDE

2.5BK
1

D XSCG6−21
D

E E

70402006 05 02(03) 26(94)

0 1 2 3 4
 0 1 2 3 4
Heat Sensors x2 CF1

XCA020A
14 Connector, Engine Interface 1
A A

U_3RD_ALT

3RD_ALT
0.75WH/GN 0.75WH/GN
5008 5008

B280A 1 1 B280B
Sensor, Heat Sensor Sensor, Heat Sensor
2 2
Air Filter Air Filter

U_3RD_ALT
Note! Note!

3RD_ALT
Cavity 2 are Cavity 2 are

B variant only variant only

B
0.75WH/BK 0.75WH/BU
1023 5009

A 1 B281
A 2 Sensor, Heat Sensor
Third Alternator

3RD_ALT
0.75WH/BK
1023

C C
ENGINE_BAY
XCB604M:1
ENGINE_BAY

0.75WH/BK
Body builder 1023
XCB604M_1−3
heat sensor

0.75WH/BK
1023

ENGINE_BAY
XCB604M:3
ENGINE_BAY

D 0.75WH/BK
1023 D
XS−1023_01

18 XCA020A
Connector, Engine Interface 1

E E

70402006 05 02(03) 27(94)

0 1 2 3 4
 0 1 2 3 4
Water Heater for Regeneration CI1
B+
+30

+DR
+15

A F206
A
A163 300A
CCIOM Control unit, CCIOM,
Central Chassis IO Module
XC200B:1
PWR PWR

XC200_TO_XC300
HDO WH_Rel_1 HDO WH_Rel_2 Note:

X2 28 X2 2 it’s only for 8L engine

with ZF Ecolife

70RD
0.75WH/VT 0.75WH/GY 2003
0315 0316

ENGINE_BAY
B XC300:21 XC300:5 XC300D:1
B
Extra Rear Fuse Box

VPDU − XC300

K106 K107
86

88

86

88
100 Ohm
Relay Relay, Note:

Water Heater 1 Water Heater 2 The Fuse Check are for the fuses

88A

88A
85

85
POS_XC300:A Fuse in the Extra Rear Fuse and Relay Box
POS_XC300:B
Check

F300 F301
C 125A 125A C

XC300G:1 XC300A:1 XC300:8

ENGINE_BAY
25RD 25RD
0317 0318

XC300_TO_E136_E137
XC300_TO_E136_E137

0.75BK
1

D SRC
X1 1
SRC
X1 1 XSCG6−31
D
Sply E136 Sply E137
Heater, Regeneration, Heater, Regeneration,
Water Tank 1 Water Tank 2

GND Gnd GND Gnd

X2 1 X2 1

25BK 25BK
1 1

E136_E137_TO_GND E136_E137_TO_GND

E GND65:1 GND65:1
E

70402006 05 02(03) 28(94)

0 1 2 3 4
 0 1 2 3 4
I−Shift gearbox DA1
B+
+30

+DR

A +15
A

86 (1) K74 F57

30 (3)
Relay
V43 5A
I−shift
(4) 87a 87 (5)
85 (2)

FRC:57
XL:7
ELECTRICAL_CENTER

0.5WH/GY 0.5RD/GN
0140 2004

B B
F12 F11
5A 5A
XC027:21 XC027:22
INSTRUMENT INSTRUMENT

XK:12 XK:9
0.5WH/GY 0.5RD/GN
0.75RD 0140 2004
2.5RD 2003
2003
XC027:20
INSTRUMENT
XC027:19
INSTRUMENT
0.5RD
2003
2.5RD
2003 A 1 A 5 A 2

SRC +30 HSD Rel_Ctrl SRC +DR Backbone 1 (XA1) A79

Control unit,
C XC007:19
CENTER
PWR
PWR
PWR
J1587 (XH1) I−shift gateway C
2.5RD
2003

PMO PMI Gearshift

XC080:58 GND Gnd
ENGINE_BAY
A 3 A 7 A 8 A 9 A 10 A 11 A 12 A 13 A 14
2.5BK
2.5RD 1 0.5RD 0.5BK 0.75BN 0.75GN 0.75VT 0.75WH/YE
2003 XSCG6−21
2003 1 0141 0143 0145 0147

0.75YE 0.75BU 0.75WH/BN 0.75WH/GN

0142 0144 0146 0148

13
XCA021
39
Connector
Gearbox Interface
XSCG1−31

D 0.5BK
D
1

A 20 A 21 A 17 A 18 A 1 A 2 A 3 A 4 A 5 A 6 A 11 A 12 A 15 A 16
A13A
Control unit, TECU
(Transmission ECU)

SRC SPLY SPLY Gnd Gnd A19C

PWR PWR
TECU Gear selector ECU Control unit,
GECU I−shift
Backbone 1 (XA1)
Backbone 2 (XB1)
PT Subnet (XC1)

E E

70402006 05 02(03) 29(94)

0 1 2 3 4
 0 1 2 3 4
ZF Ecolife DA2−1
B+
+30

+DR

A +15
A
F53 F57
10A 5A

FRC:53 FRC:57
ELECTRICAL_CENTER ELECTRICAL_CENTER
2.5RD
2003

XC027:23 XC027:22
INSTRUMENT
INSTRUMENT
2.5RD
2003
XS−2003_04
0.75RD/GN
2004
B XS−2004_07 B

2.5RD 0.75RD/GN
2003 2004

XC007:19 XC007:20
CENTER

0.75RD/GN 0.5RD/GN 0.75RD

2004 2004 2003

C C
XC080:58 XC080:59
ENGINE_BAY

A 7 A 1
0.75RD/GN
2004
SRC +DR +30 X69
PWR PWR
Plug, ZF diagnostics

13 17 39
XCA021
Connector
GND Gnd DIA2
Gearbox Interface
2.5RD
2003 1.0RD/GN 2.5BK
0.75BK
2004 1 1
D XS−2003_05
XS−GND_01 D
2.5RD 2.5RD 2.5BK 2.5BK
2003 2003 1 1
XSCG1−31
A 8 A 9 A 25 A 17 A 18

SRC +30 SRC +30 SRC +DR Gnd Gnd A200

PWR PWR PWR
Control unit, TECU
(Transmission ECU)
Backbone 1 (XA1) ZF Ecolife

EcoLife
J1587 (XH1)
(T) ZF CAN (XJ1)

E E

70402006 05 02(03) 30(94)

0 1 2 3 4
 0 1 2 3 4
GSS with Gear Mode Switch DA2−2
B+
+30

+DR

A +15
A
F57
5A

FRC:57
ELECTRICAL_CENTER

XC027:22
INSTRUMENT

XS−2004_07

B B
0.75RD/GN
0.75RD/GN
2004
2004

S321
1

Switch
2
Alternative Gearshift Program
ZF Ecolife
C 0.75RD/GN
2004 C
0.75RD/GN
2004

A 8 A 10 A 1
A19_A +DR +DR +DR
PWR PWR PWR
Control unit, GECU
(gear selector ECU)
GSS 1 2 D N R
Geartronic GND Gnd
A 2

0.75BK
1

D D
XSCG1−31

E E

70402006 05 02(03) 31(94)

0 1 2 3 4
 0 1 2 3 4
EBS, Electronic Brake System EA1−1
B+
+30

+DR

A +15
A
F48 F28
5A 20A
B03
Sensor,
FRC:48 FRC:28
footbrake valve

5V_SPLY
ELECTRICAL_CENTER

Sign_2

Sign_1
Switch
GND
A 2 A 5 A 1 A 6 A 4

0.75RD/GY 0.75BU 0.75WH/BK 0.75VT 0.75WH/BN

2029 0043 1012 0044 0045

B B
FRONT_AXLE
XC001:11 XC001:12 XC001:13 XC001:14 XC001:15
INSTRUMENT
IC A03
0.75RD/GY 0.75BU 0.75WH/BK 0.75VT 0.5WH/BN
0.5RD/GN 2.5RD
2029 1012 0045 5V PWR 5V PWR Instrument cluster
0043 0044
2004 2003

GND Rend Gnd SRC A/D_PU Sign_F SRC A/D_PU Sign_R

XC023:8 XC023:9 XC023:10 XC023:11 XC023:12 B 1 A 12 B 20 B 13 B 21 B 14
ELECTRICAL_CENTER

0.75RD/GY 0.75BU 0.75WH/BK 0.75VT 0.75WH/BN 0.5RD/YE 0.5BU 0.5RD/BU 0.5VT

XS−1021_02
XS−2003_06 2029 0043 1012 0044 0045 2037 0066 2038 0067

C 2.5RD
2003
2.5RD C
2003 INSTRUMENT INSTRUMENT
XC001:10 XC001:4 XC001:5 XC001:6 XC001:7
X1 13 X1 17 X1 16 X1 7 X1 8 X1 4 X1 6 X1 5 FRONT_AXLE FRONT_AXLE
SRC +DR SRC +30 SRC +30 SRC Sply GND Gnd A21
Sign_2

Sign_1
Switch 0.75RD/YE 0.75RD/BU 0.75VT
0.75BU
PWR PWR PWR 5V Control Unit, EBS 2037 0066 2038 0067
(Electronic Brake System)

EBS Backbone 1 (XA1)

J1587 (XH1)
GND Gnd Gnd A 1 A 2 A 1 A 2
X1 12 X1 11 B152 P P B153
Sensor, Brake Sensor, Brake
Air Pressure 1 Air Pressure 2
0.75BK 0.75BK A 4
A 4
1 1
D D
ELECTRICAL_CENTER 0.75WH/BK 0.75WH/BK
XC:5 XC:6
1021 1021

XS−1021_01

E E

70402006 05 02(03) 32(94)

0 1 2 3 4
 0 1 2 3 4
EBS, Valves and Sensors EA1−2

A21
EBS
Control Unit, EBS
A (Electronic Brake System) A

Outlet_Vlv_R

Outlet_Vlv_L
PWR PWR PWR PWR

Inlet_Vlv_R

Inlet_Vlv_L
f f

GND Gnd SRC Sply SRC High HZ_PD Low GND Gnd SRC Sply SRC High HZ_PD Low GND Gnd
X2 15 X2 7 X2 8 X2 9 X2 12 X2 4 X2 5 X2 6 X2 18 X2 14 X2 16 X2 10 X2 13

0.75WH/GY 0.75GN
45
0062 0065

45
1.5WH/BK 1.5RD/BU 0.75YE 0.75GN 1.5WH/BK 1.5RD/GY 0.75YE 0.75GN 0.75WH/BK 0.75BN 0.75YE
1014 2035 7029 7030 1015 2036 7031 7032 1020 0063 0064

ELECTRICAL_CENTER ELECTRICAL_CENTER
XC026:20
XC026:19 XC026:18 XC026:17 XC028:20 XC028:19 XC028:18 XC028:17 XC026:8 XC026:4 XC026:5 XC026:6 XC026:7
ELECTRICAL_CENTER ELECTRICAL_CENTER
B B
0.75WH/GY 0.75GN
45

45
0062 0065

1.5WH/BK 1.5RD/BU 0.75YE 0.75GN

1.5WH/BK 1.5RD/GY 0.75YE 0.75GN 0.75WH/BK 0.75BN 0.75YE
1014 2035 7029 7030 2036 7031 7032 1020
1015 0063 0064

INSTRUMENT INSTRUMENT INSTRUMENT INSTRUMENT

XC001:20 XC001:19 XC001:18 XC001:17 XC008:19 XC008:18 XC008:17 XC002:25 XC002:1 XC002:2 XC002:3 XC002:4
XC008:20
FRONT_AXLE FRONT_AXLE FRONT_AXLE
45

45
0.75WH/GY 0.75GN
0062 0065

C 1.5WH/BK
1014
1.5RD/BU
2035
0.75YE
7029
0.75GN
7030
1.5WH/BK
1015
1.5RD/GY
2036
0.75YE
7031
0.75GN
7032
0.75WH/BK
1020
0.75BN
0063
0.75YE
0064 C
CENTER
XC070:9 XC070:10 XC070:11 XC070:12
REAR_AXLE 45

1.5WH/BK 1.5RD/GY 0.75YE 0.75GN

1015 2036 7031 7032

C 1 C 2 C 3 C 4 C 1 C 2 C C 4 A 1 A 3 A 1 A 3
U08 U03 Y12 Y11
GND S H +24 L GND S H +24 L
SPL 3 Solenoid valve unit, Solenoid valve unit,
SPL Modulator, EBS,
Modulator, EBS, ABS, front right ABS, front left
D4 6 5 D1 2 3 A1 A2 B 1 B 2 D4 6 5 D1 2 3 A1 A2 B 1 B2 A 2
one front axle rear axle A 2

D 0.75YE
0056
0.75YE
0057
0.75BK 0.75WH
0058 0059
0.75BK 0.75WH
0060 0061
D
0.75WH 0.75RD 0.75WH 0.75RD
1018 2033 1019 2034

0.5WH/BK 0.5WH/BK
1020 1020

A 3A 1 A 2 A 3A 1A 2 A 1 A 2 A 2
A 3A 1A 2 A 3A 1 A 2
A 1 A 2 A A 2
A 1 1
0.75W

0.75W

0.75W

0.75W
0.75Y

0.75Y

0.75Y

0.75Y
0.75R

0.75R

0.75R

0.75R

0.75SB 0.75SB 0.75SB 0.75SB

0.75W 0.75W 0.75W 0.75W XS−1020_01

U U n n U U n n
S S S S

B40A B40B B13B B14B B43 B42 B15 B16

E E

70402006 05 02(03) 33(94)

0 1 2 3 4
 0 1 2 3 4
EBS, 3rd_Axle EA2

A EBS A21
BBM
A36
A
Control Unit, EBS Control unit, BBM
PWR PWR (Electronic Brake System) PWR (Body Builder Module)

GND Gnd SRC +30 SRC High HZ_PD Low GND Gnd SRC Sply A/D 3rd_Br_Pr
X3 2 X3 12 X3 8 X3 5

1.5WH/BK 1.5RD/YE 0.75YE 0.75GN 0.75WH/BK 0.75RD/YE 0.75GN

1004 2021 7023 7024 1007 2024 0031

45
ELECTRICAL_CENTER ELECTRICAL_CENTER
XC028:22 XC028:21 XC028:16 XC028:15 XC027:14 XC027:12 XC027:13

B 1.5WH/BK 0.75WH/BK 0.75RD/YE 0.75GN

B
1.5RD/YE 0.75YE 0.75GN
1004 2021 7023 7024 1007 2024 0031

45
INSTRUMENT INSTRUMENT
XC004:1 XC004:2 XC004:3 XC004:4 XC006:10 XC006:8 XC006:9

1.5WH/BK 1.5RD/YE 0.75YE 0.75GN 0.75WH/BK 0.75RD/YE 0.75GN

1004 2021 7023 7024 1007 2024 0031

45

C C
CENTER CENTER
XC070:13 XC070:14 XC070:15 XC070:16 XC070:28 XC070:30 XC070:29
REAR_AXLE REAR_AXLE

1.5WH/BK 1.5RD/YE 0.75YE 0.75GN 0.75WH/BK 0.75RD/YE 0.75GN

1004 2021 7023 7024 1007 2024 0031
45

A 1 A 2
C 1 C 2 C 3 C 4 B278
U36 P
GND S H +24
SPL
L Sensor, Brake
Modulator, EBS Air Pressure 3
D4 6 5 D 1 2 3 A 1 A 2 A 4
B 1 B 2
Additional axle

D D

A 3A 1 A 2 A 3A 1A 2 A 1 A 2 A 2
A 1
0.75W

0.75W
0.75Y

0.75Y
0.75R

0.75R

0.75SB 0.75SB
0.75W 0.75W

B291R U U B292R
n n
S S Sensor, Speed EBS
Sensor Indicator EBS
Additional Brake Lining Wear Additional Wheel
Right B291L B292L Right

Sensor Indicator EBS Sensor, Speed EBS

E Additional Brake Lining Wear
Left
Additional Wheel
Left
E

70402006 05 02(03) 34(94)

0 1 2 3 4
 0 1 2 3 4
EBS, Diff Lock EB1
XS−6001_01 XS−2004_18 XS−6001_01 XS−2004_18

0.5BU 0.5RD/GN
A 6001 2004 A
0.5RD/GN
2004 Variant: EBS−MED Variant: EBS−STD
3−way 2−Way
X1 10 X1 8 X1 5 X1 2 X1 10 X1 8 X1 5 X1 2

S08 C S08
Switch, differential
C
Switch, differential
gear lock, rear wheels
gear lock, rear wheels
2 0 1 1 0

X1 9 X1 7 6 X1 4 3 X1 1 X1 9 X1 7 6 3

1 0.5BK
0.5BK
1
0.5WH/GN 0.5WH/YE 0.75WH/GN
0047 0046 0047
XSCG1−32

B XSCG1−32
B

INSTRUMENT
XC023:15
ELECTRICAL_CENTER
0.5WH/YE
0046

X1 10

A21 EBS
C 10

Diff_Lck_In
Control Unit, EBS IC HDI Interaxle
A03
Instrument cluster
(Electronic Brake System)

PWR
C C

Diff_Lck_out
LDI Wheels
C 11
X1 14
0.75WH/BU 0.75WH/VT
0048 0049

ELECTRICAL_CENTER
XC027:18
INSTRUMENT
0.75WH/BU
0048

XC007:12
INSTRUMENT
XC007:13
CENTER CENTER
D 0.75WH/BU
0048
0.75WH/VT D
0049

XC070:7 XC070:8
REAR_AXLE REAR_AXLE
0.75WH/BU 0.75WH/VT
0048 0049

S45
A 1
Y02 1
Position switch,
Solenoid valve, differential gear lock
differential lock, rear wheels A 4 indicator, rear wheels
0.75BK
0.75BK
1
1

E XSCG5−31 XSCG5−31
E

70402006 05 02(03) 35(94)

0 1 2 3 4
 0 1 2 3 4
EBS without Electric Steering EC1

A A
A21
EBS
Control Unit, EBS
5V ESP Bus (Electronic Brake System)

CAN H

CAN L
SRC Sply GND Gnd
X3 10 X3 1 X3 7 X3 4

45
0.75RD/YE 0.75WH/BK 0.75YE 0.75GN
2030 1013 7027 7028

B ELECTRICAL_CENTER
XC023:26 XC023:27 XC023:28 XC023:29
B
INSTRUMENT

C 0.75RD/YE 0.75WH/BK
2030 1013
0.75YE
7027
0.75GN
7028 C

45

45
INSTRUMENT
XC002:5 XC002:6 XC002:7 XC002:8
FRONT_AXLE

0.75RD/YE 0.75WH/BK 0.75YE 0.75GN 0.75RD/YE 0.75WH/BK 0.75YE 0.75GN

2030 1013 7027 7028 2030 1013 7027 7028

45
D D

A 1A 2A 3A 4
A2 A 1 A3 A 4

B50
B49 Sensor, yaw−rate
Sensor, steering angle

E E

70402006 05 02(03) 36(94)

0 1 2 3 4
 0 1 2 3 4
EBS, Hill Start Aid ED1

A A

XS−6001_02 XS−2004_18
XS−6001_02 XS−2004_18

0.5BU 0.5RD/GN
0.5BU 0.5RD/GN 6001 2004
6001 2004

0.5BK 0.5BK
1 1

B X1 2 X1 8 X1 10 X1 2 X1 8 X1 10
B
C S32
Switch, brake hold
C S31
Switch, TCS
( Traction Control System )
0 1 0 1

X1 1 X1 3 7 X1 9 X1 1 X1 3 7 X1 9

0.5BK 0.5BK
1 1

XSCG1−33 XSCG1−33

C 0.5WH/BN
0068
0.5WH/YE
0069
0.5WH/GN
0070
0.5WH/BU
0071
C

INSTRUMENT INSTRUMENT
XC023:17 XC023:16 XC023:13 XC023:14
ELECTRICAL_CENTER ELECTRICAL_CENTER

0.5WH/BN 0.5WH/YE 0.5WH/GN 0.5WH/BU

0068 0069 0070 0071

X3 14 X3 13 X3 9 X3 11

LDI BHRA_Sw LSD BHRA_lamp LDI TCS_Sw LSD TCS_lamp A21

Control Unit, EBS
D PWR PWR (Electronic Brake System) D
EBS

E E

70402006 05 02(03) 37(94)

0 1 2 3 4
 0 1 2 3 4
APBE EF1
B+
+30

+DR

A +15
A
F01
5A

XL:4
ELECTRICAL_CENTER
0.5RD
2003

0.5RD
2003
86
K84
B 30
B
Relay, APBE
(Automatic Park Brake Engine) 87 87a

POS_RHG 85

0.5WH/GY 0.5RD/GY
0022 2020

ELECTRICAL_CENTER
XC022:30
INSTRUMENT

C 0.5RD/GY 0.5RD/GY
C
2020 2020

XS−0022_01
A 1 A 1
0.5WH/GY Y158 Y159
0022
Solenoid Valve, Solenoid Valve,
Automat Park Break Evac Automat Park Break Evac
Valve 1 Valve 2
XCB801F.B:30
YA1−4:1 D A 4 A 4

0.5WH/GY 0.5BN 0.5YE

0022 0023 0024
D D

B 3 B 3 B 4
A/D_PD Weh_Spd LSD Prk_Br_Evc1 LSD Prk_Br_Evc2 A195
A17 PWM PWM
Control unit, BIO
Control unit, VECU Bus I/O ECU
(Vehicle ECU)
BIO
VECU

E E

70402006 05 02(03) 38(94)

0 1 2 3 4
 0 1 2 3 4
Park Brake EG1

A A

A17
VECU BBM A36
Control unit, VECU Control unit, BBM
(Vehicle ECU) PWR PWR (Body Builder Module)

LDI Prk_Br_Sw LDI Prk_Br_Sw

B 11 B 11

B B
0.75WH/VT 0.75WH/VT
0072 0072

D1
Diode
Parkbrake
−

C C
0.75WH/GY 0.75WH/GY
0073 0073

ELECTRICAL_CENTER
XC022:25
INSTRUMENT XCB801F.B:32
YA1−4:1 D
0.75WH/GY
0073

A 2

S43
P
Switch Indicator
Parking Brake Pressure NC A 1
D D

0.75BK
1

XSCG1−36

E E

70402006 05 02(03) 39(94)

0 1 2 3 4
 0 1 2 3 4
Retarder Controls EH1

A A

BH2:2 D
S02.1
XS−6001_02 XS−2004_18

0.75BU 0.5RD/GN
6001 2004
0.5RD/YE

B 2076
B
0.5BK
0.5BK A 1
1 1
X1 2 X1 8 X1 10
S24
XSCG1−33
C S314
Switch Stalk switch, retarder,
Retarder SET− SET+ selector type
0 1
X1 1 X1 3 7 X1 9 A 3 A 2 A 4 A 5 A 6

0.5YE 0.5GN 0.5YE

0186 0187 0075

45
0.5BN
0074
0.5RD/YE 0.5WH/RD
C 0.75BN
2076 2040
0.5WH
1024 C
0074

XS−2040_01 XS−1024_01
BI1:2 C BI1:2 C
INSTRUMENT
XC022:26 INSTRUMENT INSTRUMENT
ELECTRICAL_CENTER XC022:18 XC022:19 XC022:20 XC022:21
ELECTRICAL_CENTER ELECTRICAL_CENTER

0.5RD/YE 0.5YE 0.5GN 0.5YE

0.75BN
2076 0186 0187 0075
0074
D A 28 B 5 A 21 A 20 B 10 B 22 B 24
D
A17
Supply_1

Retarder_SET (−)

Retarder_SET (+)

Analog_GND

Retarder_Stlk_Sig
Supply_2
Ret_Enabl_Req

VECU Control unit, VECU

(Vehicle ECU)

E E

70402006 05 02(03) 40(94)

0 1 2 3 4
 0 1 2 3 4
Retarder Voith EH3

A A
ACM

Retard_Water_temp
A174

V5EXT_1&2_Gnd

Temp_Sens_GND
Retard_Air_Press
Retard_Solenoid

Retard_Oil_temp
Actuat_Sply 1

V5EXT1_Sply
Control unit, ACM
(Aftertreatment Control Module)

A 62 A 36 A 50 A 19 A 15 A 54 A 11 A 56

B B
XS−2097_01 XS−2050_01 XS−1051_01 XS−1050_01

0.75RD/YE 0.75RD/BU 0.75VT 0.75WH/BN

2097 2050 0101 0102
0.75GN 0.75BU 0.75WH/BK 0.75WH/BK
0099 0100 1051 1050

C C
XCA021
35 23 15 12 28 21 29 27 Connector
Gearbox Interface

A 3
B69
Sensor, coolant
T temperature, retarder
A 1

D A 1 A 2 A 3 A 4 A 6
D
A41
Component group transmission.
Contains B23, B138 and Y17
P T

Y17A
B138A B23A

A 5 A 7

E E

70402006 05 02(03) 41(94)

0 1 2 3 4
 0 1 2 3 4
ECS, Air Suspension FA1−1
B+
+30

+DR

A +15
A
F49 F23
5A 5A

86
FRC:49 XF:15 (86) 1
ELECTRICAL_CENTER 30
(30) 3 K76
Relay, ECS
(87) 5 4 (87a) (Electronic Controlled Suspension)
87 87a
(85) 2 POS_FRC:K11
85

XF:1
ELECTRICAL_CENTER
B B

0.75RD/GN 0.75RD/YE 0.75RD/BU 0.75RD/BU

2004 2085 2086 2086

C C

X2 4 X2 5 X2 2 X2 12

SRC +DR LSD REL_CTL SRC +30 SRC +30 A16

PWR PWR PWR
PWR Control unit, ECS
(Electronic Controlled air Suspension)

ECS Backbone 1 (XA1)

J1587 (XH1)
GND Gnd GND Gnd
X2 3 X2 22

D 0.75BK
1
0.75BK
1
D

ELECTRICAL_CENTER
XC:7 XC:8

E E

70402006 05 02(03) 42(94)

0 1 2 3 4
 0 1 2 3 4
ECS, 1st Axle FA1−2

A A
A16
Front Axle Solenoid Valve
ECS Control unit, ECS
(Electronic Controlled air Suspension)
PWR PWR PWR 5V 5V
LHD RHD

HSD Vlv_FR Vlv_FL Vlv_Ext_Mult Gnd SRC SPLY A/D Sens_Sign SRC SPLY A/D Sens A/D Sens Gnd
X1 6 X1 3 X1 8 X1 7 X1 30 X1 19 X1 17 X1 24 X1 25 X1 11

0.75WH/BN 0.75VT 0.75BU 0.75WH/BK 0.75RD/BU 0.75WH/YE 0.75RD/GY 0.75WH/BU 0.75WH/BU 0.75WH/BK
0190 0189 0188 1037 2077 0191 2078 0193 0193 1038

B B
ELECTRICAL_CENTER

XC025:28

XC027:25
ELECTRICAL_CENTER
XC023:20 XC023:21 XC023:22 XC023:31 XC023:32 XC023:33 XC025:30 XC025:29
INSTRUMENT INSTRUMENT

0.75WH/BN 0.75VT 0.75BU 0.75WH/BK 0.75RD/BU

0.75RD/GY 0.75WH/BU 0.75WH/BU 0.75WH/BK
0190 0189 0188 1037 2077 1038
2078 0193 0193

XS−0190_01

0.75WH/BN 0.75WH/YE
0190 0191

XC002:16
XC002:11 XC002:10 XC002:9 XC001:21 XC001:22 XC002:13 XC001:23 XC001:24
FRONT_AXLE FRONT_AXLE FRONT_AXLE FRONT_AXLE

C C
0.75VT 0.75RD/BU
0189 2077 0.75RD/GY 0.75WH/BU 0.75WH/BK
2078 0193 1038
0.75WH/BN 0.75BU 0.75WH/BK 0.75WH/YE
0190 0188 1037 0191

A 1 A 2

P B56
Sensor, air pressure,
suspension bellows front axle
A 3 A 2 A 1
Y40 A 4
A 1 A 4 A 2
Solenoid valve unit, + / −
B28
front axle, air suspension
A 4
Sensor, chassis level,
D 0.75BK
front axle
D
1

XSCG2−21

E E

70402006 05 02(03) 43(94)

0 1 2 3 4
 0 1 2 3 4
ECS, Switches FA2

A A

A16
ECS Control unit, ECS
(Electronic Controlled air Suspension)
Kneel Axle Levelling
PWR PWR PWR PWR PWR

HSD Vlv_Ind_FR LDI Activate LDI Cancel LDI Axle_Parallell LDI Axle_Fr
X1 6 X1 15 X1 1 X1 16 X1 2

B 0.75BN 0.75YE
B
0.75WH/YE 0.75WH/GN 0218 0219
0213 0214

ELECTRICAL_CENTER ELECTRICAL_CENTER ELECTRICAL_CENTER

XC023:20 XC023:18 XC023:19 XC023:24 XC023:25
INSTRUMENT INSTRUMENT INSTRUMENT

0.75WH/YE 0.75WH/GN
0213 0214
0.75BN 0.75YE
XS−0190_01 0218 0219

0.75WH/BN 0190
XS−6001_02
XS−2004_18

0.5BU
6001
C XS−6001_02
0.5RD/GN
2004
C

0.5BU
6001

X1 1 X1 3 X1 10 X1 8

S304
X1 8 X1 10 X1 1 X1 3
0
1 0 2 C S325
1 2

Switch Switch
Air Suspension
Air Suspension
Kneeling
C X1 4 X1 6 X1 5 X1 2 X1 9 X1 7 Raise/Lower Level
X1 9 X1 7 X1 2 0.5GN 0.5BK 0.5BK
0220 0.5BK
1 1 1
0.75BK
0.75BK 1
D 0.75BK
1
D
1

XSCG1−33

XSCG1−33

0.5GN 0220

E E

70402006 05 02(03) 44(94)

0 1 2 3 4
 0 1 2 3 4
ECS, Second Axle FA3

A A
A16
Second Axle Solenoid Valve ECS Control unit, ECS
(Electronic Controlled air Suspension)
PWR PWR PWR PWR PWR

HSD Vlv_RR Vlv_RL HSD Vlv_Centr GND Gnd SRC SPLY A/D Sens_sign A/D Sens_sign SRC SPLY A/D Sign_RL A/D Sign_RR GND Gnd
X1 5 X1 4 X2 10 X1 7 X1 30 X1 22 X1 23 X1 17 X1 26 X1 28 X1 11

0.75WH/GY
0195 0.75YE 0.75GN 0.75BU 0.75VT
0.75BN 0.75WH/VT 0197 0198 0199 0200
0196 0194
ELECTRICAL_CENTER ELECTRICAL_CENTER ELECTRICAL_CENTER ELECTRICAL_CENTER
XC028:3 XC028:2 XC028:1 XC023:31 XC023:32 XC027:16 XC027:17 XC025:30 XC025:31 XC025:32 XC025:29
INSTRUMENT INSTRUMENT INSTRUMENT INSTRUMENT
B B
0.75BN 0.75WH/VT 0.75YE
0196 0194 0197
0.75WH/BK INSTRUMENT 0.75RD/BU INSTRUMENT 0.75GN 0.75RD/GY INSTRUMENT INSTRUMENT 0.75WH/BK
0.75WH/GY
1037 XC001:21 2077 XC001:22 0198 2078 XC001:23 XC001:24 1038
0195 0.75BU 0.75VT
0199 0200
INSTRUMENT
XC007:16 XC007:15 XC007:14 XC008:21 XC008:22 XC008:13 XC008:14 XC008:23 XC008:15 XC008:16 XC008:24
CENTER CENTER

0.75BN 0.75WH/VT 0.75WH/BK 0.75RD/BU 0.75YE 0.75GN

0196 0194 1037 2077 0197 0198 0.75RD/GY 0.75BU 0.75VT 0.75WH/BK
2078 0199 0200 1038
0.75WH/GY
0195

XC070:19 XC070:18 XC070:17 XC070:25 XC070:24 XC070:26 XC070:27 XC070:20 XC070:22 XC070:23 XC070:21
REAR_AXLE
C XS−2077_01 0.75GN 0.75RD/GY 0.75BU 0.75VT 0.75WH/BK
C
0.75RD/BU 0198 2078 0199 0200 1038
2077
0.75BN 0.75WH/VT XS−2078_01 XS−1038_01
0196 0194 0.75RD/BU 0.75RD/BU
2077 2077
0.75YE
0.75WH/GY 0.75WH/BK 0197
0195 1037
A 1 A 2 A 1 A 2
B57 B58
Y25 A 3 A 2 A 1 P P
Sensor, air pressure, Sensor, air pressure,
suspension bellows, lhs. Rear suspension bellows, rhs. Rear 0.75WH/BK 0.75WH/BK
Solenoid valve unit, A 4 A 4 1038 1038
level control, air suspension A 4
0.75RD/GY 0.75RD/GY
0.75WH/BK 0.75WH/BK 2078 2078
0.75BK 1037 1037
1
D XS−1037_01 D
A 1 A 4 A 2 A 1 A 4 A 2

XSCG5−21 B29 + / − + / −
B30
Sensor, chassis level,
lhs. rear axle Sensor, chassis level,
rhs.rear axle

E E

70402006 05 02(03) 45(94)

0 1 2 3 4
 0 1 2 3 4
ECS, Extra Axle (Boogie) FA5

A A

A16
ECS Extra Axle (Boogie) Control unit, ECS
(Electronic Controlled air Suspension)
PWR PWR

HDI Vlv_Extra_Ind LDI Ext_Axle_Dwn

X2 9 X2 19

0.75WH/YE 0.5WH/VT
0202 0216
B B
ELECTRICAL_CENTER
XC023:23 XC023:30
INSTRUMENT

0.75WH/YE 0.5WH/VT
0202 0216

XS−0202_01

0.75WH/YE
0202

C XC006:22
CENTER
XS−6001_02
C

0.75WH/YE 0.5BU
0202 6001

XC070:31
REAR_AXLE
0.5WH/YE 0202

0.75WH/YE
0202
X1 10 X1 8 X1 3 X1 1

S11 C 1 0

A 1
Y163 Switch, bogie lift,
Solenoid Valve Unit selector type
D Air Suspension
A 2 9 X1 7 X1 2
D
Boogie Lift X1

0.5BK 0.5BK
0.75BK
1 1
1
0.5BK
1 XSCG1−33

XSCG5−21

E E

70402006 05 02(03) 46(94)

0 1 2 3 4
 0 1 2 3 4
Air Dryer FB1
B+
+30

+DR

A +15
A

86 86
K201 30 30
K72
Relay, EMS
Relay VECU
(Engine Management System) 87a 87
87a
87 (Vehicle ECU)
POS_XC200:B 85 85
POS_FRC:K02

F214 F06
10A 5A

B MDE
XC200:13
ENGINE_BAY B
0.75RD
2042

HDE
XS−2042_04

0.75RD 0.75RD
2042 2042
MDE

B 4

A80
Y51A Y51B
Airdryer, electronical controlled

C B 1 B 3 C
0.75BN 0.75YE
0372 0002

ENGINE_BAY
XC080:17 XC080:18
CENTER
0.75BN 0.75YE
0372 0002

XC006:34 XC006:33
INSTRUMENT
0.75BN 0.75YE
0372 0002

D XC027:5
ELECTRICAL_CENTER
XC027:4
D
0.75BN 0.75YE
0372 0002

B 16 B 4 B 15

LDO Reg_Vlv LDO Comp_CTL LDO Rel_Ctrl

A17
Control unit, VECU
(Vehicle ECU)

VECU

E E

70402006 05 02(03) 47(94)

0 1 2 3 4
 0 1 2 3 4
Air Sensor Wet Tank FB2

A A

VECU A17
Control unit, VECU
5V
(Vehicle ECU)

SRC Sply A/D Signal GND Gnd

B B 26 B 9 B 23 B
0.5RD/BU 0.75GN 0.5WH/BK
2010 0003 1001

ELECTRICAL_CENTER
XC027:8 XC027:7 XC027:6
INSTRUMENT

0.5RD/BU 0.75GN 0.5WH/BK

2010 0003 1001

C XC007:11
CENTER
XC007:10 XC007:9
C
0.75RD/BU 0.75GN 0.75WH/BK
2010 0003 1001

XC070:1 XC070:2 XC070:3

REAR_AXLE

0.75RD/BU 0.75GN 0.75WH/BK

2010 0003 1001

D A 1 A 2 A 4
D
B06
Sensor, air pressure,
P air tank

E E

70402006 05 02(03) 48(94)

0 1 2 3 4
 0 1 2 3 4
Regeneration control FB4

B+
+30

A +DR
+15
A

K201 86
30
86

30
Relay, EMS K72
(Engine Management System) 87a
87
Relay VECU
POS_XC200:B 87
85
87a (Vehicle ECU)
85
POS_FRC:K02

F214 F06
10A 5A

B XC200:13
B
ENGINE_BAY

XS−2042_04

0.75RD
2042 B 15

LDO Rel_Ctrl A17 A163

CCIOM

REGEN_AIR
Control unit, VECU Control unit, CCIOM,
(Vehicle ECU) Central Chassis IO Module
PWR

A 1 A 3

VECU HDO Air_Outlet

Y169A 27
X2

C Valve
Air Inlet
C
0.75WH/BU
A 2 0314
0.75WH/BK
0313

ENGINE_BAY
XC080:54
CENTER
0.75WH/BK A 1
0313 Y170
Valve
XC005:18
A 4
Air Outlet
INSTRUMENT
0.75WH/BK
0313
0.75BK
D B 18
1 D
LDO Air_Inlet
A195
Control unit, BIO XSCG6−31

Bus I/O ECU

BIO

E E

70402006 05 02(03) 49(94)

0 1 2 3 4
 0 1 2 3 4
Volvo Dynamic Steering FC2−1

A Bpol+ Bpol+
A
B+ B+
+30 +30
+DR +DR
+15 +15

F88
30A

FH4:3P

B 4.0RD
2002 B

XC094A:3

4.0RD
2002

C XC096:1
C

4.0RD
2002

A 1
B+ A235
PWR
VDS Control Unit, VDS
(Volvo Dynamic Steering)

D ECU GND
D

A 2

4.0BK

XSCG2−21

E E

70402006 05 02(03) 50(94)

0 1 2 3 4
 0 1 2 3 4
Volvo Dynamic Steering Gateway FC2−2

A Bpol+ Bpol+
A
B+ B+
+30 +30
+DR +DR
+15 +15

F50
5A

FRC:50

B 2003
0.75RD
B

XC027:24

0.75RD
2003

XS−2003_14

0.75RD 0.75RD
C 2003 2003
C
A 2 A 30
+30 +30 A234
Control Unit, VDS GW
PWR PWR (Volvo Dynamic Steering Gateway)

VDS Gateway

ECU GND
D D
A 26

0.75BK

XSCG1−31

E E

70402006 05 02(03) 51(94)

0 1 2 3 4
 0 1 2 3 4
Steerable Boogie Axle FD1
B+
+30

+DR

A +15
A
F223
10A

86
(86) 1
30
A36 K202
BBM (30) 3

Control unit, BBM Relay

Hydraulic_Press
(87) 5 4 (87a) Steerable Axle
PWR (Body Builder Module) 87a
(85) 2 87
POS_XC200:C
85

B LDI
B
A 27

0.75WH/BU
0020

ELECTRICAL_CENTER
XC027:11 XC200:11 XC200:6
INSTRUMENT ENGINE_BAY
0.75WH/BU
0020

XC006:15
CENTER
0.75WH/BU
C 0020
0.75WH/VT
0021
0.75RD/BU
2019 C

XC070:4
REAR_AXLE

0.75WH/BU
0020

B276 A 1 S70 A 1 A 1
Y36
P
Sensor, Hydraulic oil pressure A 2 A 2 Solenoid valve,
Boogie Position switch, steerable axle
A 2
flow sensor, power−steering, NC
0.75BK 0.75BK 0.75BK

D 1 1 1 D

XSCG5−31 XSCG6−31 XSCG6−21

E E

70402006 05 02(03) 52(94)

0 1 2 3 4
 0 1 2 3 4
SLCM, Light Control Module GA1
B+
+30
+DR
+15
A +50
A

F77 F78 F79 F80 F81 F82 F38

25A 25A 25A 25A 25A 25A 5A XS−2004_18

0.5RD/GN
2004
FH1:1P FH1:2P FH1:3P FH2:1P FH2:2P FH2:3P FRC:38
ELECTRICAL_CENTER A 12

S01 IC A03
Instrument cluster

Haz_Warn_Ind
OFF
PARK.LIGHT
HEADLAMP
Switch, main lighting,
ADD.DRIV.LIGHT

B A 13 A 16 A 9 A 8 A 6 A 4 A 5 A 7 A 11 A 1 A 2
HDI
B
4.0RD 4.0RD 4.0RD 4.0RD 4.0RD 4.0RD 0.75RD/GN 0.5VT 0.75BK 0.5BU 0.5WH/GY 0.5WH/VT
2002 2002 2002 2002 2002 2002 2005 0167 1 6001 0162 0161
XS−6001_02 XS−6001_01

0.75BU
6001
0.5BU 0.5GN 0.5YE 0.5YE 0.5BN 0.5WH/GN XS−6001_01 0.75BU 0.75BN
0166 0165 3026 0164 0163 3046 6001 5012
XSCG1−33

XC025:11
INSTRUMENT

XC025:10
INSTRUMENT

XC025:9
XC025:15 XC025:14 XC025:13 XC025:12 XC025:8 XC025:7 XC025:6 XC022:27
ELECTRICAL_CENTER ELECTRICAL_CENTER ELECTRICAL_CENTER

0.75RD/GN 0.5VT 0.5BU 0.5GN 0.5YE 0.5YE 0.5BN 0.5WH/GN 0.5WH/GY 0.5WH/VT
0166 0.75BU 0.75BN
2005 0167 0165 3026 0164 0163 3046 0162 0161
6001 5012

C PC1 1 PC1 9 PC1 16 PC2 15 PC2 19 PC2 2 PC1 3

LC2 3 LC2 7 LC2 15 LC1 11 PC1
LC1 14
13 LC1 8
PC2 6
LC1 10 LC1 4 PC2 12 PC2 21
C
B+_4 B+_1 B+_6 B+_5 B+_2 B+_3 +15 A27

Light_Input_1
Haz_Sw

Fog_Rear_Ind

Fog_Front

Dash_Dim
Fog_Rear
Haz_Ind
Main_Light_Sw_Pot

Light_Input_2
Fog_Front_Ind
Cornering

Haz_Warn
PWR PWR PWR PWR PWR PWR PWR Control unit, LCM

Direct_Ind_Right
High/Low_Beam

Direct_Ind_Left
( Light Control Module )
Camp_light_rel

Flash_To_Pass
Backbone 1 (XA1)
SLCM
GND Gnd Gnd J1587 (XH1)

PC2 9 PC1 21 PC1 2 LC2 12 LC1 13 LC1 16

LC1 17
1.0WH/GY
0.5BU 0.5YE 0.5WH 0.5GN
3002
0157 0158 0159 0160
0.75BK 0.75BK
1 1
ELECTRICAL_CENTER ELECTRICAL_CENTER
XC026:16 XC025:1 XC025:2 XC025:3 XC025:4
INSTRUMENT INSTRUMENT
D ELECTRICAL_CENTER
XC:9 XC:10
D
1.0WH/GY
0.5YE 0.5WH 0.5GN
3002 0.5BU
0157 0158 0159 0160

3 A 10 A 11 A 12 A 13

XCB805 S02 L R

Connector Stalk switch, full− /

Parking lights dipped beams
A 14
Front
0.75BK
1

E XSCG1−32
E

70402006 05 02(03) 53(94)

0 1 2 3 4
 0 1 2 3 4
Headlights, Halogen/Xenon GB1−1

A E83L E83R A
HEADLAMP E916 E02 E01 E01 E01 E01 E02 E916 HEADLAMP
LEFT RIGHT

DRL LOW HIGH X_HIGH GND GND X_HIGH HIGH LOW DRL

XCB501BLF (FL2A) (FL3A) XCB501BRF

Connector 3 4 5 7 5 1 3 Connector
1 7 Front Lights Front Lights 4
Front lights 2 Front lights 2
Left Right
Left Right

B B
1.5WH/GN 1.0BN 1.0WH/VT 1.0WH/VT 2.5BK
3032 3003 1.0GN
3001 3048 1 2.5BK 1.0WH/VT 1.0WH/BN 1.5WH/GN
1 3048 3030 3016 3032

XSCG−EXTL−31 XSCG−EXTL−32

C C
XS−3032_01

1.5WH/GN
3032

XCB502
XCB502 +30
Front 15 11 7 10 13 17 9
Connector
Body interface
Front lights

D K77 D

PC2 5 PC2 20
PC2 4 PC2 7 PC1 11 PC2 18

A27
Extra High Beam LH/RH
Low_Beam_L

High_Beam_R

DRL
High_Beam_L

Low_Beam_R
Control unit, LCM
( Light Control Module )

SLCM

E E

70402006 05 02(03) 54(94)

0 1 2 3 4
 0 1 2 3 4
Headlights, Bixenon GB1−2
E83L E916 E01 E02/E01 E02/E01 E01 E916 E83R
HEADLAMP HEADLAMP
A LEFT
M M
RIGHT
A
SOLENOID SOLENOID

DRL GND Extra Low/High Shutter Shutter Low/High Extra GND DRL

XCB501BLF FL2A FL3A XCB501BRF

Connector 3 7 1 4 5 4 1 7 3
5 Connector
Front lights 2
Left Front lights 2
Right

1.5WH/GN 2.5BK 1.0WH/VT 1.0BN 1.0WH/BU 1.0WH/VT 1.0GN 1.0WH/VT 2.5BK 1.5WH/GN
3032 1 3048 3003 3036 3037 3016 3048 1 3032
1.5BK
1
B A 10 A 3 A 11
B
U37 XSCG−EXTL−34
XSCG−EXTL−31 24 V 12 V XSCG−EXTL−32
Voltage converter
A 1 A 2 12V Bi−Xenon
1.0WH/BU 1.0WH/VT
3036 3037

V03 V04
Diode Diode

A1

B1
1.0BK
1

C 1.0BK
C
1

XSCG−EXTL−34

XS−3032_02

1.5RD 1.0WH/VT 1.5WH/GN

2003 3001 3032
+30
XCB502 XCB502
+30 Front 8 11 15 17 7 10 9
Connector
Body interface
D Front lights D

K77

PC2 20 PC2 5 PC1 11 PC2 4 PC2 18

A27
Low/High_Beam_L

Flash to pass
Low/High_Beam_R

DRL
High Beam/Shutter

Control unit, LCM

( Light Control Module )

SLCM

E E

70402006 05 02(03) 55(94)

0 1 2 3 4
 0 1 2 3 4
Fog Lights GB2

A 1.0BK
1
1.0BK
1 A
A 2 A 2
XSCG−EXTL−31 XSCG−EXTL−32
E07L E07R
Lamp, fog light, left A 1 A 1 Lamp, fog light, right

1.0WH/GN 1.0WH/BU
3046 3047

Front
XCB502
B 2 1
Connector B
Body interface
Front lights
PC1 8 PC2 14
A27
SLCM

Fog_Camp_RH
Fog_Camp_LH
Control unit, LCM
( Light Control Module )

Fog_Rear
PC1 13

C Right side XCB801F C

1
Connector
Body interface 1
1.0YE
3026

INSTRUMENT
XC008:7
CENTER
1.0YE
3026

XC080:7
ENGINE_BAY
1.0YE
3026
XS−3026_01
D D
1.0BK 1.0YE 1.0YE 1.0YE 1.0BK
1 3026 3026 3026 1

Rear Light Left

XCB723R Rear Light
XCB703R Rear Light Left
XCB722R
2 1 10 1 2

Connector Connector Connector

Rear lights 1 Rear lights 2 Rear lights 1 XSCG6−32
XSCG6−33
Left Left Right
E21LR
E21R E21RR
Lamp, rear fog light Lamp, rear fog light
Lamp, Rear Fog light, Right
Left Right

E E

70402006 05 02(03) 56(94)

0 1 2 3 4
 0 1 2 3 4
Direction Indicators, Front GC1−1

FRONT
A A
E83L E13 E13
E83R
HEADLAMP HEADLAMP
LEFT RIGHT
E13LS
Lamp, direction indicator, DIR_IND GND_DIR GND_DIR DIR_IND
E13RS
left side Lamp, direction indicator,
right side

XCB601F Left XCB501BLF FL2A FL3A XCB501BRF Right

XCB602F
Connector 2 1 Connector 2 7 7 2 Connector 1 2
Side Front lights Front lights 2 Connector
Front lights 2
Left Right Front lights
Left
B Right B
1.0BK 1.0YE 1.0BK
1.0YE 1.0GN 1.0GN
1 3059 3059 3060 3060 1

XSCG−EXTL−33 XSCG−EXTL−33

C XS−3029_01 XS−3028_04
C
1.0YE 1.0GN
3059 3060

Front XCB502
4 3
Connector
Body interface
Front lights

PC1 20 PC1 19

D A27 D

Direct_Ind_FR
Direct_Ind_FL

Control unit, LCM

( Light Control Module )

SLCM

E E

70402006 05 02(03) 57(94)

0 1 2 3 4
 0 1 2 3 4
Direction Indicator, Rear GC1−2

A A27 A
SLCM Control unit, LCM

Direct_Ind_Side/High_R
Direct_Ind_Side/High_L
( Light Control Module )

Direct_Ind_RR
Direct_Ind_RL
PC2 10 PC2 16 PC1 4 PC2 13

Right side
XCB801F
4 6 7 5
Connector
Body interface 1
B 1.0YE
3059
1.0YE
3059
1.0GN
3060
1.0GN
3060 B
XS−3006_01 XS−3007_01

1.0YE 1.0GN
3059 3060
INSTRUMENT INSTRUMENT
XC008:3 XC008:9 XC008:10 XC008:4
CENTER CENTER
1.0YE 1.0YE 1.0GN 1.0GN
3059 3059 3060 3060

XC080:3 XC080:9 XC080:10 XC080:4

ENGINE_BAY

C C
1.0YE 1.0YE 1.0YE 1.0GN 1.0GN 1.0GN
3059 3059 3059 3060 3060 3060

1.0BK 1.5BK
1.5BK
1 1
1

Left XCB721R XCB703R Rear Light XCB720R Right

1 4 3 4 12 4 1
Connector
Connector Connector
XSCG6−33 Rear lights 2 XSCG6−33 XSCG6−32
Rear lights 3 Rear lights 3
Left
Left Right

E27L E13RL E27R

D Tail lamp module, left
E13
Lamp, direction indicator,
left rear E13 Tail lamp module, right D
XCB503 XCB503
Extra Light
XCB503
Connector 1 Extra Light 2
Connector
Extra lights Extra lights
Rear Rear

E13LS2
E13RS2
Lamp, direction indicator,
left side Lamp, direction indicator,
right side

E E

70402006 05 02(03) 58(94)

0 1 2 3 4
 0 1 2 3 4
Side Marker Lights GC2
A03
IC SLCM A27
Instrument cluster Control unit, LCM

Sidemarker_L/R
A A

Park_Light_In
( Light Control Module )

HDI
B 27 PC1 10

XCB503 XCB503
Extra Light Extra Light

Connector 3 4 Connector
Extra lights Extra lights
Rear Rear
E11LA E11RA
Lamp, side marker Lamp, side marker
light, left side 1 light, right side 1
B B
Right side XCB801F
16 17
Connector
Body interface 1
1.0GN 1.0GN 1.0GN 1.0GN
3027 3027 3027 3027

XS−3027_01 XS−3028_01

1.0GN 1.0GN
XS−3027_04 XS−3028_03
3027 3027

INSTRUMENT
XC008:11 XC008:12
CENTER
C 1.0GN
3027
1.0GN
3027
C

XC080:11 XC080:12
ENGINE_BAY
1.0GN 1.0GN 1.0GN 1.0GN
1.0GN 1.0GN 1.0GN 1.0GN 3027 3027 3027 3027
3027 3027 3027 3027

1.0BK 1.0BK
1 1

D XSCG6−21 XSCG6−21
D
Park and designation

lights left 5 4 3 7 XCB601M XCB602M 7 3 4 5

Park and designation

lights right

Connector Connector
Side−marker lights Side−marker lights
Left Right

E11LB E11RB
Lamp, side marker E11LF E11LC E11LC2 E11RC2 E11RC E11RF Lamp, side marker
light, left side 2 light, right side 2

E E

70402006 05 02(03) 59(94)

0 1 2 3 4
 0 1 2 3 4
Brake Lights GD1
A17
VECU Control unit, VECU
A (Vehicle ECU) A

Brake_Press
B 27

0.75WH/GN
3017

LC1 18

A27

Brake_Press
Control unit, LCM
( Light Control Module )

B B

Brake_RL

Brake_RR
SLCM
PC2 17 PC1 5

Right side XCB801F

8 9 Connector
Body interface 1

1.0WH/YE
3009
1.0WH/BN
3008
XS−3009_02

1.0WH/YE
3009
C C
INSTRUMENT INSTRUMENT
XC008:5 XC008:6
CENTER CENTER
1.0WH/BN 1.0WH/YE
3008 3009

XC080:6
XC080:5
ENGINE_BAY
ENGINE_BAY
1.0WH/BN 1.0WH/YE 1.0WH/YE
3008 3009 3009

XS−3008_02

D 1.0WH/BN
3008
1.0WH/BN
3008
D

XCB703R XCB503 XCB720R

XCB721R Left Rear Light XCB503 Right
1 5 7 Connector Extra Light 5 Connector 5 1 Connector
Connector Rear lights 2
Rear lights 3 Extra lights Rear lights 3
Left Rear Right
Left

Gnd Brake E09 E09R Brake Gnd

E27L E27R
Lamp, brake light Lamp, brake light
Tail lamp module, left Tail lamp module, right
E09 E09

E E

70402006 05 02(03) 60(94)

0 1 2 3 4
 0 1 2 3 4
Park Lights, Front GD2−1

A A
E83L E83R
HEADLAMP HEADLAMP
LEFT RIGHT
E08 E08

PARK GND GND PARK

XCB501BLF FL2A FL3A XCB501BRF

E08FSL1 E08FSR1
Connector 6 7 7 6 Connector
Lamp, parking light Lamp, parking light
Front side left Front lights 2 Front lights 2 Front side right
Left Right
B E08FSL2 E08FSR2
B
Lamp, parking light Lamp, parking light
Front side left Front side right

Front Lights

Side Left
XCB601F XCB602F Front Lights

4 3 Side Right
6 3 5 Connector 5 4 6
Connector Front lights
Side Front lights 1.0BN 1.0YE Right
1.0BN 1.0YE 1.0YE 1.0BK
1.0BK 1.0BK 1.0BN
3014 Left 3014 3015 3015 3015
1.0BK
1 1 3014 1 1

1.0BN 3014 XS−3014_01 XS−3015_01 1.0YE 3015

XS−3014_02 XS−3015_02
1.0YE
1.0BN 3015
C XSCG−EXTL−33
3014
XSCG−EXTL−33
C

Front XCB502
6 5 Connector
Body interface
Front lights

1.0BN 1.0YE
3014 3015

ELECTRICAL_CENTER ELECTRICAL_CENTER
D XC026:14
INSTRUMENT
XC026:15
INSTRUMENT
D
A27

Park_FR
Park_FL

1.0BN Control unit, LCM 1.0YE

3014 ( Light Control Module ) 3015
SLCM
Rear Axle XCB805 XCB805 Rear Axle
1 2
Connector Connector
Parking lights Parking lights
E08FSL3 Front Front E08FSR3
Lamp, parking light Lamp, parking light
Front side left Front side left

E E

70402006 05 02(03) 61(94)

0 1 2 3 4
 0 1 2 3 4
Park Lights, Rear GD2−2

A A
A27
SLCM

Park_RR
Control unit, LCM

Park_RL
( Light Control Module )

PC2 11 PC2 8

Right side
XCB801F
12 13
Connector
Body interface 1

1.0WH/VT 1.0WH/GY

B 3012 3013
B
INSTRUMENT
XC008:1 XC008:2
CENTER

1.0WH/VT 1.0WH/GY
3012 3013

XC080:1 XC080:2
ENGINE_BAY

1.0WH/VT 1.0WH/GY
3012 3013

C C
XS−3012_01 XS−3013_01

1.0WH/VT 1.0WH/GY
3012 3013

Left XCB721R XCB720R Right

1.0WH/VT 1.0WH/GY
1 2 2 1
Connector 3012 3013
Connector
Rear lights 3 Rear lights 3
Left Right

E27L E27R
Tail lamp module, left Tail lamp module, right
E10 E10
Rear Light
XCB703R
D 1 2
Connector D
Rear lights 2
Left

E E

70402006 05 02(03) 62(94)

0 1 2 3 4
 0 1 2 3 4
Reverse Lights GD3

A A
Reverse Light Relay

A27
SLCM Control unit, LCM
( Light Control Module )

Rev_Light_Rel

Rev_Light
Rev relay
XCB503
7
Connector
PC2 1 PC1 7
Extra lights
Rear
Right side XCB801F
11 10 Connector
B Body interface 1 B
1.0WH/BU
3011 1.0WH/GN
3010

INSTRUMENT
XC008:8
CENTER
1.0WH/GN
3010

XC080:8
ENGINE_BAY

C 1.0WH/GN
3010 C

XS−3010_01
1.0WH/GN 3010 1.0WH/GN 3010

1.0WH/GN
Left XCB721R 3010 XCB720R Right
1 3 3 1
Connector
Connector Rear lights 3
Rear lights 3 Right
Left
Rear Light XCB703R
D E27L 6 E27R D
Connector
Tail lamp module, left Rear lights 2
E06 E06 Tail lamp module, right
Left

E06
Lamp, reversing light

E E

70402006 05 02(03) 63(94)

0 1 2 3 4
 0 1 2 3 4
Engine Room Light ID1

B+
+30

A +DR
+15
A

F218
10A

XC200:2
ENGINE_BAY

B B
XS−2003_08

1.0RD
2003

C C

XCB703R
5
Connector
Rear lights 2
Left

Engine Room Light

D D

E E

70402006 05 02(03) 64(94)

0 1 2 3 4
 0 1 2 3 4
Luggage Lights ID3

B+
+30

A +DR
+15
A

F218
10A

B 30
XC200:2
HDI ENGINE_BAY
A36

Lugg_Door_Sw
Control unit, BBM
(Body Builder Module)
K75
Relay
30 86 BBM
B Luggage Door Switch B
POS_FRC:K10 87A 87 85
1.0RD
2003

Right side
XCB801F
14 15
Connector
Body interface 1
1.0VT 1.0WH/BN
6002 5006

INSTRUMENT INSTRUMENT
XC007:25 XC008:25
CENTER CENTER
XS−2003_08

1.0VT 1.0WH/BN
C 6002 5006 1.0RD
2003
1.0RD
2003
C
XC080:32
ENGINE_BAY
XC080:33
XCB601M XCB602M
ENGINE_BAY
6 6 Connector
Connector
Side−marker lights Side−marker lights
Left Right
1.0VT
6002 1.0WH/BN
5006 S57L2 S57R2
XS−6002_01
Position switch, Position switch,
luggage compartment lighting, NO luggage compartment lighting, NO
1.0VT 1.0VT
6002 6002

D XCB601M XCB602M D
XCB601M XCB602M XCB601M XCB602M
1 1
Connector 2 Park and designation 2 Connector Connector
Park and designation Connector
Side−marker lights lights left
lights Right
Side−marker lights Side−marker lights Side−marker lights
Left Right Left Right

1.0WH/BN 1.0WH/BN
E23L E23R 5006 5006

Lamp, luggage compartment Lamp, luggage compartment

illumination, left illumination, right
XS−5006_01

E E

70402006 05 02(03) 65(94)

0 1 2 3 4
 0 1 2 3 4
Radio JA1

B+
+30

A +DR
+15
A
F67 F85
5A 20A

FRC:67 FH3:3P
ELECTRICAL_CENTER
0.75RD 1.5RD
2003 2002

XC025:24 XC024:25
INSTRUMENT
1.0BK 0.75RD 1.5RD

B 1 2003 2002
B
A 11 A 3 A 7
BB10A X130
U06 7 5 3 1 9
24 V 12 V Connector, BB
XSCG1−31 Voltage converter (Body Builder)
A 8 A 5 A Radio Interface 1
1.5BK 1.5RD 1.5RD/GN 0.5WH/VT 0.5WH/BU
2.5BK 2.5RD 2.5RD/GN
2102 2103 1 2102 2103 4192 4191
1

XS−GND_03

XS−6001_01

C XS−2003_10
C
XS−2005_02

2.5BK 1.5RD 1.5RD/GN 1.5RD/GN 0.75BU

1 2102 2103 2103 6001

A 7 A 4 A 3 A 5 C 4 A 6

SRC B+ SRC +30 SRC +30 LDI Mute A07

Ant_Out

Dash_Dim
PWR PWR PWR
Control unit, Audio
PWR

AUDIO
J1939−2/3 (XE1−1)

D GND Gnd J1587 (XH1)

D

E E

70402006 05 02(03) 66(94)

0 1 2 3 4
 0 1 2 3 4
Steering Wheel Switches JB1

A A

A03
IC Instrument cluster

PWR

PWM
GND Gnd LSD Sw_In SRC SPLY

B 0.5WH/BK
1036
0.5WH/GY
0173
0.5RD/BU
2071
B

XS−6001_01

0.75BU
6001

C A 1 A 4 A 3 A 2
C
Coil Spring
Internal Steering Wheel Harness

S34

D uPC
Switch unit,
steering wheel push buttons
D
DOWN

UP
YES

RIGHT
NO

LEFT

SWS

E E

70402006 05 02(03) 67(94)

0 1 2 3 4
 0 1 2 3 4
AIC − POWER SUPPLY & GROUNDING JD2

Bpol+
B+
A +30 A
+DR
+15

F20 F39 F84

10A 5A 5A

XJ:11 FRC:39 FH3:2P

1.0RD 0.75RD
2003 2002

B B
XC022:31 XC024:18 XC022:32

1.0RD
2003

XS−2003_11 XS−2005_06

0.75RD 0.75RD/GN 0.75RD

2003 2005 2002

C B 2

+30 SRC
A 3

+15 SRC
A 1

+B A201
C
PWR PWR PWR Control unit, AIC
(Advanced Information Cluster)
AIC
USB Ethernet RJ−45

E:1 E:2 E:3 E:4 E:5 F:1 F:2 F:3 F:6 GND GND
A 2

0.75BK
1

External Cable XSCG1−34

External Cable
D D
XC931

USB
ENET:1

ENET:2

ENET:3

ENET:6

Ethernet RJ−45

E E

70402006 05 02(03) 68(94)

0 1 2 3 4
 0 1 2 3 4
TGW2−POWER SUPPLY & GROUNDING JE1
Bpol+
B+
+30
+DR
A +15 A

F54 F61
10A 5A

FRC:54 FRC:61 A33

TACHO Tachograph
0.75RD 0.5RD/GN

Dig_Info_Int
2003 2004

XC022:35 XC022:33

B 0.75RD
2003
0.5RD/GN
2004
D 8 B
XS−2003_15 XS−2004_09
0.5VT
0222
0.75RD 0.5RD/GN 0.5RD/GN
2003 2004 2004

X1 1 X1 2 X1 24 X1 27
A125

INFO−IF
SRC SRC +DR SRC +R

TGWII
+30

Control unit, TGW PWR PWR PWR

(Telematics Gateway) GPS

GSM
C USB Ethernet
WLAN
C
Gnd VBUS D− D+ GND ID TX+ TX− Wake−Up Reset RX+ RX−
GND

X1 35 X2 1 X2 8 X2 9 X2 5 X2 4 X3 3 X3 4 X3 5 X3 6 X3 7 X3 8

0.5BK
1
XSCG1−36

D D

E E

70402006 05 02(03) 69(94)

0 1 2 3 4
 0 1 2 3 4
FMS−GW3 JF1
Bpol+
B+
+30
A +DR A
+15

F54 F39
10A 5A

FRC:54 FRC:39

0.75RD/GN
2005

XC022:35 XC024:18

0.75RD/GN
B 2005 B
XS−2003_15 XS−2005_06

0.75RD 0.75RD/GN
2003 2005

A 1 A 3

SRC kl.30 SRC kl.15 A22

PWR PWR
Control unit, FMS
(Fleet Management System)

C GND Gnd
FMS gateway C
A 16

0.75BK
1
XSCG1−34

D D

E E

70402006 05 02(03) 70(94)

0 1 2 3 4
 0 1 2 3 4
WWS, Windshield Wiper System OG1
B+
+30

+DR
+15

A A
F13
15A

1.5RD/GN
2005

87a
85 K05
XK:3 XJ:1 87
Relay
ELECTRICAL_CENTER
Front wiper
A 1 30
S06 1.5RD/GN 1.0YE On/Off
2005 86
0109 POS_FRC:K07
B Stalk switch, windscreen
XC024:23 XC024:22 XJ:2 XK:6
B
wiper, selector type
INSTRUMENT ELECTRICAL_CENTER
2 1 0 1 1.5RD/GN 2095

A 2 A5 1.5RD/GN 0.5WH/YE 4015

A 3 A 4 2005 1.0YE 1.0GN
ELECTRICAL_CENTER 0109 4009
XC024:21 XC025:5
XS−2005_03 INSTRUMENT
1.5RD/GN 1.0WH/BN 1.5RD/GN 0.5WH/YE LC2 10 LC2 11 PC1 14
4016 4001 2095 4015
A27

Wip_Sig_Pos
Wip_Sw_Int

Wip_Int_Rel
1.5RD/GN 1.0YE Control unit, LCM
2005 0109 ( Light Control Module )

SLCM
C C

0.75BK
V41 1
Diode
1.0WH/BN Windscreen Wiper
4001 1.5BK
1

XCB500 XCB500
1 4 3 2 5
Connector
Wiper motor
Windscreen System
D A 4 A 5 A 2 A 3
XSCG1−22
D
53A 31B 53 53B
M01
M
Motor, windscreen wiper

31

A 1

E E

70402006 05 02(03) 71(94)

0 1 2 3 4
 0 1 2 3 4
Windscreen and Headlight Washer OH1
B+
+30

+DR

A +15
A
F74 F13
15A 15A

FRC:74 XK:3
ELECTRICAL_CENTER ELECTRICAL_CENTER

XC024:23
1.5RD/GN
2005 INSTRUMENT

XS−2005_03

XC024:19 A 1
INSTRUMENT S06
B Stalk switch, windscreen
wiper, selector type
B
0 P

A 6

1.5RD/GN 1.5RD/YE
2005 4002

XS−4002_01
XS−2005_04

1.5RD/GN 1.5RD/GN 1.5RD/YE 1.5RD/YE 1.5RD/YE

2005 2005 4002 4002 4002

INSTRUMENT
XC024:20

XSCG1−22
ELECTRICAL_CENTER

C 1.5BK 1.5BK 1.5BK

1.5RD/YE
4002
C
1 1 1
XS−4002_02

XCB500
XCB500 6 9 14 11 13 8 12
1.5RD/YE 1.5RD/YE
4002 4002
Connector
Wiper motor
Windscreen System
XCB803F.B:5
87 87A 86 A 2 YA1−6:0 D
30 56 S
K85 LC2 5
Relay Disconnect A27

Wiper_SW
Headlight wash M M02
Control unit, LCM
P 31 Motor, windscreen
( Light Control Module )
30 85 washer pump
D D
A 2
A 1
SLCM
M03
M
Motor, headlamp high
pressure washer pump

A 1

E E

70402006 05 02(03) 72(94)

0 1 2 3 4
 0 1 2 3 4
Active Safety VA2
B+
+30

+DR
+15

A A176 B238
A
Control unit, LPOS, Sensor, FLS F64 F42
Lane Position and Object Sensor (Forward Looking Sensor) 10A 5A

K401 K402
FLS Relay
Seat Haptic 12V
Relay
Seat Haptic 24V

CAN_High_Term
CAN_Low_Term
FRC:64 FRC:42
POS_RHA POS_RHB
LPOS
GND PWR PWR GND 0.75RD 2003 0.75RD 2003
(1) 86 86 (1)
Rc Rc
(3) 30 30 (3)
Active Safety Subnet 2 (XM1) SRC +30 Euro6 Control unit, BIO
SRC +30
A 7 A 12 A 1 A 5
(5) 87 87a (4) only! Bus I/O ECU (4) 87a 87 (5)

(T) Active Safety Subnet 2 (XM1)

0.75BU
(2) 85

0.75WH/BN 0.75RD/GY
BIO 85 (2)

0.75VT 0.75RD
0.75RD/BU 0232 0234 2099 A195 0.75RD/YE 0.75WH/YE
2100 0235 0233 2003
B 2028
0.75WH/BK
B
A 25 A 26
1008 XC025:33 XC025:34 XC026:10 XC026:11 XC025:36 XC025:35 XC025:17
0.75RD/GY 2099 0.75RD/YE 2100
XC002:19 XC002:20 0.75BU 0.75WH/BN 0.75RD/GY 2099
0232 0234 0.75BK 0.75RD/YE 0.75WH/YE 0.75VT 0.75RD
0.75BK
2100 0235 0233 2003

0.75WH/BK 0.75RD/YE
1008 2027 A 1 A 2 A 9 A 8
0.75RD/BU 0.75WH/BK
2028 1008
0.75RD/GY 2017
M M
A224
XS−2004_18
Seat Haptic
XSCG1−31
Vibration
A 5 A 7 A 2 A 3 A A 6 A 8 A 11 A 1 A 12
C HSD HSD HSD
9
HSD HSD SRC +30
0.75RD/GN C
PWM 2004
PWR
PWR PWR PWR PWR PWR

PWM_2 GND LPOS_PWR FLS_PWR GND GND GND SUPPLY

A
1
LCS_PWR 12V SPARE

A26 J1939−1/Backbone 1 (XA2/XA1) PWM_1 R89

PWR GND
J1939−7/ Backbone 2 (XB2/XCB1)
Resistor
Control unit, DACU (T) Active Safety CAN (XM1)
DACU FCW LED, Pull−up

B
1
(Driver Assistance Active Safety OBD2 Subnet (XN1) Digital Digital
PWM
Control Unit) Spare_2 HSD
Spare_1

B 7 A 4 B 16 A 10
0.75BK
2
A

0.75WH/GY
XS−6001_01 0239
0.75WH/GN 0.75WH/VT
D 0.75WH/BU
0236 0238
XSCG1−31
D
0237 0.5BU
6001
0.5BU XC025:23
6001
0.75WH/GY 0239 0.75WH/GY 0239
X1 2 X1 8 X1 10 X1 2 X1 8 X1 10 B 18

E111 C C LDO
LED Module, BBM
(Forward Collision Warning)
0 1 0 1
1
A

X1 1 X1 3 X1 7 X1 9 X1 1 X1 3 X1 7 X1 9
0.75BK
0.75BK 0.75BK
0.75BK 0.75BK
0.75BK 0.75BK

S202 A36
S348
Switch, LDWS, Lane Control unit, BBM
Switch AEBS XSCG1−31
(Body Builder Module)
E Departure Warning System (Advanced Emergency Braking System) E

70402006 05 02(03) 73(94)

0 1 2 3 4
 0 1 2 3 4
Engine Room Hatch VD4

B+
+30

A +DR
+15
A

F217
5A
BBM A36

Eng_Door_Sw
PWR Control unit, BBM
XC200:7
(Body Builder Module) ENGINE_BAY

LDI
B 29

Right side XCB801F

18
Connector
B Body interface 1 B
0.75BN 0.75RD
5001 2003

INSTRUMENT
XC005:5
CENTER

0.75BN
5001

XC080:24
ENGINE_BAY

C 0.75BN
C
5001

Rear XCB703R
8 12 11
Connector
Rear lights 2
Left

D D

Starter Inhibitor Starter Inhibitor

Engine Hatch Switch Engine Hatch

E E

70402006 05 02(03) 74(94)

0 1 2 3 4
 1 2 3 4 5
CAN, Backbone 1 XA1

A XSC−7001_01 XSC−7001_02 XSC−7001_03 XSC−7001_04 XSC−7001_05

ELECTRICAL_CENTER INSTRUMENT
XSC−7001_06
A
1 XC024:6
0.5YE 7001 0.5YE 7001 0.5YE 7001 0.5YE 7001 0.5YE 7001 0.5YE 7001 0.5YE 7001 0.5YE 7001
45 45 45 45 45 45 45

XSC−7002_01 XSC−7002_02 XSC−7002_03 XSC−7002_04 XSC−7002_05 XSC−7002_06

XC024:7
0.5GN 7002 0.5GN 7002 0.5GN 7002 0.5GN 7002 0.5GN 7002 0.5GN 7002 0.5GN 7002 0.5GN 7002
2

R66
Resistor, CAN termin
Backbone 1
45

45

45

45

45

45
0.5YE 0.5GN 0.5YE 0.5GN 0.5YE 0.5GN 0.5YE 0.5GN 0.5YE 0.5GN
0.5GN
7001 7002 7001 7002 7001 7002 7001 7002 7001 7002 0.5YE
7001 7002

B C 4 C 5 C 4 C 5 X1 3 X1 1 X2 14 X2 13 LC2 16 LC2 13
A 7 A 6
B

CAN H

CAN L
CAN L
CAN H

CAN L

CAN H

CAN L
CAN H
CAN H

CAN L

CAN H

CAN L

45
A36 A17 A21 A27
Control Unit, EBS Control unit, LCM
Control unit, BBM Control unit, VECU (Electronic Brake System) A16 ( Light Control Module )
A22
(Body Builder Module) (Vehicle ECU) Control unit, FMS
Control unit, ECS
(Fleet Management System)
(Electronic Controlled air Suspension)

ENGINE_BAY
CENTER INSTRUMENT
XSC−7001_11 XSC−7001_10 XSC−7001_12 XSC−7001_09 XSC−7001_08 XSC−7001_07
XC080:14 XC005:32
0.75YE 7001 45 45
0.75YE 7001 45
0.75YE 7001 45 0.5YE7001 0.5YE 7001 45 0.5YE 7001 45 0.5YE 7001 45

C C
XSC−7002_11 XSC−7002_10 XC080:13 XC005:31 XSC−7002_12 XSC−7002_09 XSC−7002_08 XSC−7002_07
0.75GN 7002 0.75GN 7002 0.75GN 7002 0.5GN 7002 0.5GN 7002 0.5GN 7002 0.5GN 7002

0.75YE 0.75GN 0.5YE 0.5GN 0.5YE 0.5GN 0.5YE 0.5GN 0.5YE 0.5GN
0.75YE 0.75GN 0.75YE 0.75GN
7001 7002 7001 7002 7001 7002 7001 7002 7001 7002 7001 7002
7001 7002
45

45

45

45

45

45

45
XCA021
Connector 1 4 A 14 A 10 B 1 B 10 A 15 A 16 A 17 A 18 A 8 A 9

Gearbox Interface
CAN L

CAN L
CAN H
CAN H

CAN H

CAN H
CAN H

CAN L
CAN L

CAN L
1 4

D D
XCA020A A 3 A 4
0.75YE 0.75GN A174 A26 A03 A79
Control unit,
X69
7001 7002
Control unit, ACM Control unit, DACU Instrument cluster I−shift gateway Plug, ZF diagnostics
45

Connector, Engine Interface 1 (Aftertreatment Control Module) (Driver Assistance

A 23 A 5 Control Unit)
CAN L
CAN H
CAN L
CAN H

A200
A13A
Control unit, TECU
Control unit, TECU
E (Transmission ECU)
(Transmission ECU)
ZF Ecolife
E

70402006 05 02(03) 75(94)

1 2 3 4 5
 1 2 3 4 5
CAN, Backbone 2 XB1

A MDE
45
0.75OG 7003
45
7003 0.75OG
A
R67
Resistor, CAN termin MDE
0.75GN 7004 7004 0.75GN
Backbone 2
Resistor 120 ohm_1%_1W
CENTER ENGINE_BAY
XSC−7003_01 XSC−7003_05 XSC−7003_06 XSC−7003_07 XC005:34 XC080:40 HDE XSC−7003_03 XSC−7003_04
0.5OG 7003 45 0.5OG 7003 45 45 0.5OG 7003 0.5OG 7003 45 45
0.5OG 0.75OG 7003 45 0.75OG 7003 45 0.75OG 7003
A 1 7003 45
XSC−7003_02

XSC−7004_01 XSC−7004_05 XSC−7004_06 XSC−7004_07 XC005:33 XC080:39 XSC−7004_03 XSC−7004_04

B 1 HDE
0.5GN 7004 0.5GN 7004 0.5GN 7004 0.5GN 7004 0.5GN 0.75GN 7004 0.75GN 7004 0.75GN 7004
7004
XSC−7004_02

B B
0.5OG 0.5GN 0.5OG 0.5GN 0.5OG 0.5GN 0.5OG 0.5GN 0.75OG 0.75GN 0.75OG 0.75GN 0.75GN 0.75OG 0.75OG 0.75GN 0.75OG 0.75GN
7003 7003 7004 7003 7004 7003 7004 7004 7004 7003 7003 7004 7003 7004
0.75GN 0.75OG
7003 7004 7004 7003 7004 7003
45

45

45

45

45

45

45

45

45
MDE

MDE
MDE

HDE

MDE

HDE
HDE

HDE
A 6 A 14 B 2 B 11 X1 36 X1 37 B 1 B 2
CAN L

CAN H

CAN L
CAN H

CAN L
CAN H
CAN H

CAN L

A 6 A 2 X2 22 X2 26

XCA021

CAN L
CAN H

CAN H

CAN L
5 2 8 10
Connector
Gearbox Interface
X43 A26 A125 A234
C Connector, OBD
Control unit, DACU Control unit, TGW Control Unit, VDS GW C

I−Shift

I−Shift
(Driver Assistance (Telematics Gateway) (Volvo Dynamic Steering Gateway) A174 A163

ZF

ZF
(On−Board Diagnostics) Control Unit) 0.75OG X2 X2 26
Control unit, ACM Control unit, CCIOM, 22
7003 45
(Aftertreatment Control Module) Central Chassis IO Module

CAN H

CAN L
0.75GN
7004

45
A163

MDE

MDE
HDE

HDE
Control unit, CCIOM,
Central Chassis IO Module
A 6 A 5

5 2

D D

CAN L

CAN H
XCA020A
Connector, Engine Interface 1

A13A
Control unit, TECU
(Transmission ECU)

E E

70402006 05 02(03) 76(94)

1 2 3 4 5
 0 1 2 3 4
CAN, PT Subnet XC1

A A

B B

45
0.75OG
7005
0.75GN
7006

XCA021 XCA020A
3 6 6 3
Connector
Gearbox Interface Connector, Engine Interface 1
C C
A 7 A 8

A13A

CAN L
CAN H
Control unit, TECU
(Transmission ECU)

D D

E E

70402006 05 02(03) 77(94)

0 1 2 3 4
 1 2 3 4 5
CAN, Engine Subnet XD1

A A
XSC−7007_01 XSC−7007_02
0.75YE 7007 45

XSC−7008_01 XSC−7008_02
0.75GN 7008

0.75YE 0.75GN 0.75YE 0.75GN 0.75YE 0.75GN 0.75GN 0.75YE

7007 7008 7007 7008 7007 7008 7008 7007

45

45

45

45
B A 5 A 1 A 1 A 2 A 1 A 2
B

CAN L
CAN H

CAN H

CAN H
CAN L

CAN L
36 34

A174 B96A B96B XCA020A

Control unit, ACM Sensor, NOx
Sensor, NOx
(Aftertreatment Control Module) Connector, Engine Interface 1

C C

D D

E E

70402006 05 02(03) 78(94)

1 2 3 4 5
 1 2 3 4 5
BUS, J1939−2−3 XE1

A A

ELECTRICAL_CENTER INSTRUMENT
XSC−7015_01 XC024:8 XSC−7015_04 XSC−7015_05 XSC−7015_02 XSC−7015_03
0.5YE 7015 45 45 0.5YE 7015 0.5YE7015 45 0.5YE 7015 45 0.5YE 7015 45

XSC−7016_01 XC024:9 XSC−7016_04 XSC−7016_02

XSC−7016_05 XSC−7016_03
0.5GN 7016 0.5GN 7016 0.5GN 7016 0.5GN 7016 0.5GN 7016

B B
0.5GN 0.5YE 0.5GN 0.5YE 0.5GN 0.5YE 0.5GN 0.5YE 0.5GN
0.5YE
7016 7015 7016 7015 7016 7015 7016 7015 7016
7015

0.5YE 0.5GN 0.5YE 0.5GN

7015 7016 7015 7016

45

45

45

45
45

45

45
A 15 A 16 C 17 C 18 X1 15 X1 16 A 10 A 22 AB A4 AB A8
C 1 C 5
CAN H CAN L A03
CAN H

CAN L

CAN H
CAN H

CAN L

CAN H

CAN L

CAN L

CAN H

CAN L
24 25 Instrument cluster
XCVR
60 Ohm 60 Ohm

C A17 XCB801F A125 A07 A33 C

Control unit, VECU Connector A201 Control unit, TGW Control unit, Audio Tachograph
(Vehicle ECU) Body interface 1
Control unit, AIC (Telematics Gateway)
CAN H CAN H CAN L CAN L
(Advanced Information Cluster) A 13 A 8 A 20 A 14

0.5GN

45
0.5YE
7015 7016
wo Tacho

(wire less than 100 mm

no need for twist)

D D

E E

70402006 05 02(03) 79(94)

1 2 3 4 5
 0 1 2 3 4
CAN J1939, FMS XE1

A A

B B
XSC−7021_01 INSTRUMENT ELECTRICAL_CENTER
XC024:17
45 0.5YE 7021 45 0.5YE 7021
FMS

1
Resistor
XSC−7022_01
XC024:16 FMS CAN

2
0.5GN 7022 0.5GN 7022 120 Ohm

0.5YE 0.5GN
C 7021 7022 0.5YE
7021
0.5GN
7022
C
45

45

A 14 A 13
C 14 C 16
CAN L
CAN H

CAN L

CAN H

A22 A201
Control unit, FMS
D (Fleet Management System)
Control unit, AIC
(Advanced Information Cluster)
D

E E

70402006 05 02(03) 80(94)

0 1 2 3 4
 1 2 3 4 5
CAN, D−BUS XF1

A A

ELECTRICAL_CENTER INSTRUMENT
XSC−7013_01 XC024:12 XSC−7013_02 XSC−7013_05 XSC−7013_04
0.5YE 7013 45
0.5YE 7013
45 0.5YE 7013 45
0.5YE 7013 45 45

XSC−7014_01 XC024:13 XSC−7014_02 XSC−7014_05 XSC−7014_04

0.5GN 7014 0.5GN 7014 0.5GN 7014 0.5GN 7014

0.5YE 0.5GN 0.5YE 0.5GN 0.5YE 0.5GN 0.5YE 0.5GN 0.5YE 0.5GN 0.5GN 0.5YE
7013 7014 7013 7014 7013 7014 7013 7014 7013 7014 7014 7013

B B
45

45

45

45

45
XSC−7013_06

0.5YE 0.5YE
7013 7013

A 15 A 16 C 4 C 5 B 5 B 6 A 10 A 11 A 13 A 11 A 12

C C

CAN L
CAN H

CAN L

CAN H
CAN H

CAN L

TERM.
CAN L
CAN H

CAN L

CAN H
4 5

XCB403
A36 Connector A195 A234 A132
Control unit, BBM Body interface Control unit, alcolock A201
Control unit, BIO Control Unit, VDS GW
(Body Builder Module) Horn Bus I/O ECU Control unit, AIC
(Volvo Dynamic Steering Gateway)
(Advanced Information Cluster)

D D

E E

70402006 05 02(03) 81(94)

1 2 3 4 5
 0 1 2 3 4
CAN, E−BUS XG1

A A

B INSTRUMENT
XC024:14 XC024:15
B
ELECTRICAL_CENTER

45

45
0.75YE 0.75GN 0.75YE 0.75GN
7019 7020 7019 7020

A 15 A 16
Right side
A195 XCB801F

CAN H

CAN L
C 26 27
Connector C

CAN H

CAN L
Control unit, BIO Body interface 1
Bus I/O ECU

Body

D D

E E

70402006 05 02(03) 82(94)

0 1 2 3 4
 1 2 3 4 5
BUS, J1587/1708 XH1
ELECTRICAL_CENTER
XC024:5 XSC−7012_02 XSC−7012_03
30 0.5OG 7012 0.5OG 7012 30

A XSC−7011_03
A
XC024:4 XSC−7011_02
0.5GY 7011 0.5GY 7011

0.5OG 0.5GY 0.5OG 0.5GY 0.5OG 0.5GY 0.5OG 0.5GY

0.5OG 0.5GY
7012 7011 7012 7011 7012 7011 7012 7011
7012 7011

30

30

30

30

30

30
C 1 C 2 C 1 C 2 X3 3 X3 6 X2 1 X2 11 LC2 18 LC2 17

CAN B

CAN A
CAN B

CAN A

CAN B

CAN A

CAN B

CAN A
CAN B

CAN A
0.5GY 0.5OG
7011 7012

ELECTRICAL_CENTER
A17 A36 A21 A16 A27 XC024:10 XC024:11
INSTRUMENT
B Control unit, VECU Control unit, BBM
Control Unit, EBS Control unit, ECS Control unit, LCM
B
(Vehicle ECU) (Body Builder Module)
(Electronic Brake System) (Electronic Controlled air Suspension) ( Light Control Module )

30
0.5GY 0.5OG
7011 7012
XSC−7012_06 XSC−7012_05 XSC−7012_04
30 7012
0.5OG 0.5OG 7012 30 30 0.5OG 7012

XSC−7011_06 XSC−7011_05 XSC−7011_04

0.5GY 7011 0.5GY 7011 0.5GY 7011

INSTRUMENT
30

30

30

30

30

30

30

30

30

30
XC005:30 XC005:29
CENTER

C C
0.75OG 0.75GY 0.5OG 0.5GY 0.5OG 0.5GY 0.5OG 0.5GY 0.5OG 0.5GY 0.5OG 0.5GY 0.5OG 0.5GY 0.5OG 0.5OG 0.5GY 0.5OG 0.5GY 0.5OG 0.5GY
0.5GY
7012 7011 7012 7011 7012 7011 7012 7012 7011 7012 7011 7012 7012 7011 7012 7011 7012 7011
7012 7011 7011 7011

C 3 C 2 X1 5 X1 6 A 18 A 17 A 13 A 12 A 16 A 15 C 1 C 2
A 9 A 8 A 4 A 2 A 5 A 4

CAN B

CAN A
CAN B
CAN B

CAN A

CAN A
CAN A
CAN A

CAN A

CAN A

CAN B
CAN B

CAN B

CAN B
CAN A
CAN B

CAN B

CAN A
2 1
30

CENTER XCB401B
XC080:38 XC080:37
ENGINE_BAY Connector
A07 A125 A03 X43 A79 Body Interface 3 A195 A201 X69 A22
Control unit,
Control unit, Audio Control unit, TGW Instrument cluster Connector, OBD Control unit, BIO Plug, ZF diagnostics Control unit, FMS
0.75OG 0.75GY I−shift gateway Control unit, AIC
7012 7011 (Telematics Gateway) (On−Board Diagnostics) Bus I/O ECU (Fleet Management System)
(Advanced Information Cluster)
30

D XCA021
D
18 14
Connector
Gearbox Interface
0.75OG 0.75GY
7012 7011
30

A 19 A 10

A200
CAN B

CAN A

Control unit, TECU

(Transmission ECU)
ZF Ecolife

E E

70402006 05 02(03) 83(94)

1 2 3 4 5
 0 1 2 3 4
BUS, ZF Ecolife XJ1

A A

XSC−7044_01

XSC−7045_01

0.75YE 0.75GN
7044 7045

45

45
45
0.75GN 0.75YE
0.75YE 0.75GN
B 7044 7045 7045 7044
B
INSTRUMENT
XC007:21 XC007:22
CENTER

0.75YE 0.75GN
7044 7045

45

XC080:47 XC080:48 0.75WH

ENGINE_BAY 7067

C 0.75YE 0.75GN C
7044 7045
45

A 5 A 6 A 3 A 5 A 6 A 7

XCA021 X69 A19_A

CAN term

CAN H
CAN L

CAN H
CAN L
20 22
Connector Control unit, GECU
Gearbox Interface (gear selector ECU)
Plug, ZF diagnostics
Geartronic
45

0.75YE 0.75GN
7044 7045

D D
A 11 A 2

A200
CAN H

CAN L

Control unit, TECU

(Transmission ECU)
ZF Ecolife

E E

70402006 05 02(03) 84(94)

0 1 2 3 4
 0 1 2 3 4
CAN, Active Safety XM1

A A

XSC−7017_01

XSC−7018_01
B B
0.75OG 0.75GN
7017 7018

45
XC002:17

XC002:18
45

45

45
0.75OG 0.75GN 0.75OG 0.75GN
7017 7018 7017 7018
0.75OG 0.75GN

C 7017 7018
C
B 3 B 12 A 10 A 9 A 4 A 7

CAN_L
CAN_H
CAN_L
CAN_H

CAN_H

CAN_L
A26 A176 B238
Control unit, DACU Control unit, LPOS, Sensor, FLS
(Driver Assistance Lane Position and Object Sensor (Forward Looking Sensor)
Control Unit)

D D

E E

70402006 05 02(03) 85(94)

0 1 2 3 4
 1 2 3 4 5
CAN, VDS XO1

A A

XC003:9 XSC−7097_02
B 45
0.75OG 7097
45
0.75OG 7097
45 B

1
120 Ohm R91
XC003:10 XSC−7098_02

2
0.75GN 7098 0.75GN 7098

0.75OG 0.75GN

45
7097 7098

0.75OG 0.75GN
XSC−7097_01 XSC−7098_01
7097 7098
C C
45

0.75OG 0.75GN
7097 7098
B 9 B 10
CAN L

A234
CAN H

B 3 B 1
A235

VDS_CAN L
VDS_CAN H
Control Unit, VDS GW
(Volvo Dynamic Steering Gateway) Control Unit, VDS
(Volvo Dynamic Steering)
0.75OG 0.75GN
7097 CAN Term 7098

B 8 B 11

D D
45

E E

70402006 05 02(03) 86(94)

1 2 3 4 5
 0 1 2 3 4
BBI, Body Builder Interface YA1−1
B+
+30

+DR

A +15
A
A27
SLCM F35

Extra_High_Beam_LH_RH
Control unit, LCM 20A
( Light Control Module )

Fog/Cornering_Right

Fog/Cornering_Left

High_Beam_Right

Low_Beam_Right
High_Beam_Left

Low_Beam_Left
Direct_Ind_FR

Park_Light_FR

Park_Light_FL
Direct_Ind_FL

DRL_Rel_Ctrl
XG:1 FRC:35
ELECTRICAL_CENTER

PC2 14 PC1 8 PC1 19 PC1 20 PC2 3 PC1 17 PC2 4 PC2 20 PC2 7 PC2 5 PC1 11 PC2 18

0.5WH/GN
3032

B S322 ELECTRICAL_CENTER B
XF:18
Switch
0 1 Emergency Cut−Out
C 1 A 1
86 30
K77
85 87 87A
Relay
Day Light Running
POS_FRC:K12

AB2:1 B
S322.A1 F36
15A
AB2:0 C 1.0WH/VT
1.0WH/BU 1.0WH/GN 1.0GN 1.0YE 1.0YE 1.0BN 1.0WH/VT 1.0WH/VT 1.0WH/BN 1.0BN 1.0GN
XC023:35 3047 3046 3060 3059 3015 3014 3048 3048 3001 3030 3003 3016

C FRC:36
ELECTRICAL_CENTER
C

1.5WH/GN 2.5RD
3032 2003

0.75GN 0.75BU 0.75RD/GY

5003 5004 2075

D Front XCB502 D
1 2 3 4 5 6 7 10 11 13 15 17 9 8
Instrument
XCB401B Connector

Headlamp Low Beam Left

Headlamp Low Beam Right

Fog/Cornering Front Left

Day Light Running Light

Voltage Converter feed +30

Headlamp Xenon/Halogen High Beam Right
Park Lights Front/Side Right

Park Lights Front/Side Left

Fog/Cornering Front Right

Direction Indicator Front Right

Direction Indicator Front Left

Headlamp Xenon/Halogen High Beam Left

Extra High beam LH/RH
J1587 (XH1) 3 5 4 Body interface
Connector Front lights
Body Interface 3
Emergency Switch
External Main Switch

Battery Switch main Control

E E

70402006 05 02(03) 87(94)

0 1 2 3 4
 0 1 2 3 4
BBI, Body Builder Interface YA1−2

Bpol+
B+

A +30
+DR
A
+15

F52 F46 F110 F108 F118

10A 10A 20A 15A 15A

FRC:52 FRC:46 XC100:13 XC100:9 XC100:2

ELECTRICAL_CENTER FRONT_AXLE

B B
X09
Slip contact
Horn

3
2.5RD 2.5RD 1.5RD
1
2001 2001 2001

0.75RD 0.75RD 0.75WH/GN 0.75WH/GN

2003 2003 4003 4003

INSTRUMENT XS−2002_03
C XC023:36 XC024:1
ELECTRICAL_CENTER C
0.75WH/GN 0.75WH/GN
1
S14A S16 S14B 1.5RD 1.5RD
4003 4003 A 2001 2001
Air Horn A 1
Elect Horn
A 1
Air Horn
Left Center Right
A 2 A 2 A 2
Horn XCB403 FUSE XCB906
D−BUS (XF1) 6 7 8 9 1 2 3 5
Connector
Connector Body Interface 4

B+

B+
B+

B+
Power Supply +30

Body interface
Horn

D D
A 1
H01
Horn, air−operated
A 2
A 1

H02
A 2 Horn

E E

70402006 05 02(03) 88(94)

0 1 2 3 4
 0 1 2 3 4
BBI, Body Builder Interface YA1−3

A A
SLCM A27

Direct_Ind_Side/High_L

Direct_Ind_Side/High_R
Extra High Beam Relay
Control unit, LCM
( Light Control Module )

Sidemarker_L/R
Fog_Light_Rear

Direct_Ind_RR

Rev_Light_Rel
Direct_Ind_RL

Dash_Dim
Brake_RL

Brake_RR

Rev_Light

Park_RR
Park_RL
PC1 13 PC1 2 PC2 10 PC2 13 PC2 16 PC1 4 PC2 17 PC1 5 PC1 7 PC2 1 PC2 11 PC2 8 PC1 10 PC2 12

0.75GN
3027

XS−3027_03

B B
0.75GN 0.75GN 0.75GN
3027 3027 3027

ELECTRICAL_CENTER
FH5:1S FH5:2S XC023:4
INSTRUMENT
0.75GN
3027
F89 F90
5A 5A

B 27
FH5:1P FH5:2P
HDI A03

Park_Light_In
Instrument cluster

1.0YE 1.0WH/GY 1.0YE 1.0GN 1.0YE 1.0GN 1.0WH/BN 1.0WH/YE 1.0WH/GN 1.0WH/BU 1.0WH/VT 1.0WH/GY 0.75GN 0.75GN 1.0BU
3026 3002 3059 3060 3059 3060 3008 3009 3010 3011 3012 3013 3027 3027 6001
C C
IC

Right side
XCB801F
J1939−2/3 (XE1) 1 2 4 5 6 7 8 9 10 11 12 13 16 17 21
E−BUS (XG1) Connector

Designator Light Right

Brake Light Left

Brake Light Right

Direction Indicator Side/High Left

Designator Light Left

Reverse Light

Park Light Rear Left

Park Light Rear Right

Fog Light Rear

Direction Indicator Side/High Right

Dimmer, Dashboard Illumination

Direction Indicator Rear Left

Body interface 1

Reverse Warning Signal, Relay Output

Direction Indicator Rear Right
Extra Main Beam, Relay Output

D D

E E

70402006 05 02(03) 89(94)

0 1 2 3 4
 0 1 2 3 4
BBI, Body Builder Interface YA1−4
B+
+30

+DR

A +15
A
F03 F60
10A 5A

A17 VECU EBS

A21
Control unit, VECU Control Unit, EBS

Speed_Sig_C3
FRC:60
(Vehicle ECU) (Electronic Brake System) ELECTRICAL_CENTER

Door_Sw
Speed_X
Speed_5
PWM
LSD LDO LDO
K75 86 30
B 28 B 3 B 2 X3 15
Relay
Luggage Door Switch
85 87 87A
B A36
POS_FRC:K10
B
EF1:2 C
XS−0022_01 BBM

Lugg_Door_SW
Control unit, BBM

Eng_Door_SW
PWR

Body_Ind_4
(Body Builder Module)

Body_Ind_3
XF:12 XF:4
ELECTRICAL_CENTER
LDI HDI HDI HDI
B 29 A 18 A 19 B 30

0.5WH/BN 0.5WH/BN
5006 5006
1.0VT
6002

XS−5006_02

A33
C EG1:2 C TACHO Tachograph C
D1.−

Speed_Sig_C6
A03
IC Instrument cluster

Seat_Belt_Rem
PWR PWM

Alter_Charg
LSD

AB B8

LDI
C 19 A 19

0.5WH/VT 0.5BN 0.75YE

0.5WH/GY 0.5VT 0.75BN 0.75BU 0.75VT 0.5WH/BN 5010 8001 8002
0.5WH/GY 0.5GN 0.75WH/GY
0011 0073 5005 5001 8004 8005 5006
0022 8003
INSTRUMENT INSTRUMENT
XC023:5 XC023:6 XC023:7
ELECTRICAL_CENTER ELECTRICAL_CENTER
D 0.75YE
D
0.5WH/VT 0.5BN 0.75RD/GN
5010 8001 2004 8002

Right side
28 30 31 32 33 34 35 15 14 36 20 19 29
XCB801F
18
Connector
Door Brake Request
Parking Brake Applied

Luggage Compartment Lamp

Speed Signal X km/h
Speed Signal 5 km/h

Speed Signal C6
+DR Ignition
Alternator Charging
Toilet Occupied

Safety belt Indicator

Starter Inhibitor Engine hatch
Speed Signal C3

Toilet Fluid level

Body interface 1
Luggage Hatch Open

E E

70402006 05 02(03) 90(94)

0 1 2 3 4
 0 1 2 3 4
BBI, Body Builder Interface YA1−5

B+
+30

A +DR
+15
A

F14
10A

XK:14
ELECTRICAL_CENTER

B A36 A27 B
BBM SLCM

Direct_Ind_Sw_L

Direct_Ind_Sw_R

Head_Lamp_OFF
Door_Brake_Stat

Alarm/haz_Lght
Control unit, BBM
Body_Fire_Sens

Control unit, LCM

Haz_Activation
Prev_ECS_Act
Start_Disable

(Body Builder Module)

Door_Failure
Low_Priority

AC_1_50_%
( Light Control Module )

Wip_Sw_Int
Disable_AC

Glass_Heat

DRL_Out
Host_Call
AC_1

LSD HDI HDI HDI LSD HDI HDI HDI HDI LSD HDI
B 3 A 7 A 21 A 3 B 2 A 6 A 8 A 17 A 20 B 1 A 5
LC2 6 5 LC1 16 LC1 17 LC2 10 LC2 4 PC2 18
LC1

0.5WH/BN 0.5WH/GN 0.5WH/BU 0.5WH/VT 0.5WH/GY 0.5BN 0.5YE 0.5GN 0.5BU 0.5VT 0.5WH/BN 0.75RD/GN 0.75WH/GN 0.75WH/BU 0.5WH 0.5GN 0.5WH/YE 0.75VT 0.5WH/GN
C 8006 8008 8009 8010 8011 8012 8013 8014 8015 8016 8017 2005 3021 3022 0159 0160 4015 8027 3032
C

D Right side XCB803F

D
3 7 8 11 12 13 14 15 16 17 18 30 20 24 1 2 4 34 35
Connector
AC 1 − 50%
Window Defroster

Head Lamps Off

Alarm/Harzard Light
Disable AC

Hazard Activation
Low Priority Loads

Fire Alarm Body

AC 1
Start Disable

Stalk Direction Indicator Left

Host Call

Door Failure

DRL Output
Prevent ECS action

Door Brake Status

Wiper SW Signal
Stalk Direction Indicator Right
Starter Motor not Active +15
Body interface 2

E E

70402006 05 02(03) 91(94)

0 1 2 3 4
 0 1 2 3 4
BBI, Body Builder Interface YA1−6

A A

A17 VECU ECS A16

Sw_2_Mult_Func

Sw_3_Mult_Inhib
Control unit, VECU
(Vehicle ECU) PWR Control unit, ECS
B B

Valve_FR
(Electronic Controlled air Suspension)

LSD IVS_1 HSD HDI HDI

IC
B 1 X1 6 X2 16 X2 6
A03

Wash_Fluid_Lev

Any_Door_Open
Instrument cluster

Next_Stop_Ind
Indoor_Temp
PWR PWR

Peram_Ind
A/D_PU GND Red GND Gnd LDI HDI HDI HDI
B C
B 10 1 A 12 29 C 6 C 23 C 13 ELECTRICAL_CENTER
XC023:20

C OH1:3 C
XS−4002_02
XS−1021_02
C
0.5GN 0.5BU
0.5WH/YE 0.5BN 0.5WH/VT 0.5WH/GY 0.5BN 0.5WH/YE 0.75WH/BN
8025 8026
8018 0229 8021 8022 8023 8007 0190

0.5WH/BK
1021

INSTRUMENT
XC025:18 XC025:16 XC025:22 XC025:19 XC025:21 XC025:20
ELECTRICAL_CENTER

0.5WH/YE 0.5WH/BK 0.5BN 0.5WH/VT 0.5WH/GY 0.5BN

1.5RD/YE
8018 1021 0229 8021 8022 8023
4002

D D
Right side
XCB803F
5 21 23 25 26 27 28 6 31 32 33
Connector
Indoor Temp (−)
Wash Pmp − Hdlp Ctrl

Any Door Open

Pram Indicator
Indoor Temp (+)

Washer Fluid Low level

Body interface 2
Next Stop Indicator

Kneeling Position
Idle Switch

Full Dump

Pinch Protection
E E

70402006 05 02(03) 92(94)

0 1 2 3 4
 E
C
B

D
A
Fog Light Rear

0.5YE
3026

1
1
Extra Main Beam, Relay Output

3002

2
2

1.0WH/GY

0
0

Direction Indicator Rear Left

3059
0.5YE

4
4
Direction Indicator Rear Right

3060
0.5GN

5
5

Direction Indicator Side/High Left

3059
0.5YE

6
6

Direction Indicator Side/High Right

3060
0.5GN

7
7

Brake Light Left 3008

8
8

Brake Light Right

3009

9
0.5WH/BN 0.5WH/YE
9

Reverse Light
3010

10
0.5WH/GN
10

Reverse Warning Signal, Relay Output

1
1

3011

11
11

Park Light Rear Left

3012

12
12

Park Light Rear Right

3013

13
0.5WH/BU 0.5WH/VT 0.5WH/GY
13

Luggage Compartment Lamp

6002
0.5VT

14
14

Luggage Hatch Open

5006

15
0.5WH/BN
15
BBI, Body Builder Interface

Designator Light Left

3027
0.5GN

16
16

Designator Light Right

0.5GN
3027

17
17

Starter Inhibitor Engine hatch

5001

18
18

2
2

+DR Ignition
2004

19
0.75BN 0.75RD/GN
19

Alternator Charging
8001
0.5BN

20
20

Dimmer, Dashboard Illumination

1.0BU
6001

21
21

E−BUS CAN High

7015
0.5YE

45
24
24

E−BUS CAN Low

7016
0.5GN

25
25

0.5YE

J1939−2/3 CAN High

7019

45
26
26

J1939−2/3 CAN Low

0.5GN
7020

27
27

Speed Signal C3
0011

28
0.5WH/GY
28

3
3

Speed Signal C6
8002
0.75YE

29
29

Speed Signal 5 km/h

0022

30
0.5WH/GY
30

Speed Signal X km/h

8003
0.5GN

31
31

70402006

Parking Brake Applied

0073

32
0.75WH/GY
32

Door Brake Request

0.5VT
5005

33
33

Toilet Fluid level

8004
0.5BU

34
34

05

Toilet Occupied
8005
0.75VT

35
35

4
4

Safety belt Indicator

5010

36
0.5WH/VT
36

02(03)
Connector
Connector

XCB801x
XCB801F
Body interface 1

Body interface 1x
YA1−7

93(94)
E
C
B

D
A
 0 1 2 3 4
Ground ZA1

SIGNAL CURRENT
GROUND
A A
100mA > I
(ECU SIGNAL)

Xenon Relays

LOW CURRENT
K17
K16
K03

GROUND
B 1A > I > 100mA
B
XD:10
XD:11
XD:12
XD:1
XD:2
XD:3
XD:4
XD:5
XD:6

XD:7
XD:8
XD:9

(RELAY COIL) FRC XE:1 Switch, Boogie oil pressure

ELECTRICAL_CENTER XSCG1−31 XSCG1−32 XSCG1−33 XSCG1−34 XSCG1−36

Switch, Diff lock

XSCG−EXTL−31 XSCG−EXTL−32 XSCG−EXTL−33 XSCG−EXTL−34 XSCG5−31 XSCG6−31 XSCG6−32 XSCG6−33

EXTL EXTL EXTL EXTL Solonoid, Difflock VPDUR EXTL EXTL

Engine door

Switch, Boogie flow

Regeneration

2.5BK 2.5BK
2.5BK
1
2.5BK
1
2.5BK
1
2.5BK 2.5BK Alternator regulator
1 1 1 1 2.5BK 2.5BK 2.5BK 2.5BK 2.5BK 2.5BK
2.5BK 2.5BK
1 1 1 1 1 1 1 1
VECU

SLCM
SLCM
BBM

ECS
ECS
EBS
EBS

MEDIUM CURRENT
GROUND
Solonoid, FA Air Suspension
XC:10
XC:11
XC:12

C C
XC:1
XC:2
XC:3
XC:4
XC:5
XC:6

XC:7
XC:8
XC:9

30A > I > 1A Side lights

BodyBuilder Interface
(CONSUMERS) FRC XB:1 Powersteering
ELECTRICAL_CENTER 4.0BK 1
XSCG1−21
XSCG1−22 XSCG−EXTL−21 XSCG2−21 XSCG5−21 XSCG6−21 XSCG6−22 XSCG6−23

Solonoid, Fuel Cut Off Solonoid, RA Air Susp CCIOM EMS ACM
VPDUF, VDS Solonoid, Bogie Air Susp Oilmaster GBX 3xNOX
Heater waterseparator PEC DC/DC
Solonoid, Boogie flow Pump
6.0BK
1
4.0BK 4.0BK 6.0BK 6.0BK 6.0BK
1 1 1 1 1
6.0BK
1 6.0BK
1

HIGH CURRENT
GROUND XCG11
D D C
D
I > 30A B E

XSCG6−11
A

ROH_TO_RA_GND
16BK
1
50BK 25BK
1 1

CHASSIS
FRAME
GND1:1 GND2:1 GND5:1 GND63:1 GND64:1 GND6:1

E INSTRUMENT FRONT AXLE REAR AXLE ROH ENGINE BAY

E

70402006 05 02(03) 94(94)

0 1 2 3 4
 D

A
C

B
E
BILL OF MATERIALS INDEX (VOL 3)
0

0
NAME PAGE
GROUNDS 2
FUSES AND CIRCUIT BREAKERS 3
COMPONENTS 5
INLINES 12
SPLICES 14
SHELLS 16
REFERENCES 20
EQUIPOTENTIAL LIST 42
1

1
2

2
3

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 1(44)

D

A
C

B
E
 D

A
C

B
E
GROUNDS
0

0
NAME PAGE
GND1:1 ZA1 1 E
GND2:1 ZA1 3 E
GND5:1 ZA1 3 E
GND6:1 ZA1 4 E
GND21:1 AA2 1 E
GND21:1 AA2 0 D
GND61:1 AD1 2 E
GND62:1 AC1 0 E
GND63:1 ZA1 4 E
GND64:1 ZA1 4 E
GND65:1 CI1 2 E
GND65:1 CI1 1 E
1

1
2

2
3

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 2(44)

D

A
C

B
E
 D

A
C

B
E
FUSES AND CIRCUIT BREAKERS
0

0
FUSE DESCRIPTION PAGE
F01 (5A) Fuse, APBE Automatic parking brake evacua EF1 2 A
F03 (10A) Fuse, Luggage light YA1−4 3 A
F05 (5A) Fuse, Instrument cluster & On Board Diagn BD1−1 2 A
F05 (5A) Fuse, Instrument cluster & On Board Diagn BD1−2 1 A
F05 (5A) Fuse, Instrument cluster & On Board Diagn BG1 2 A
F06 (5A) Fuse, Alternator ECU & Engine Components AC1 4 B
F06 (5A) Fuse, Alternator ECU & Engine Components BA1 1 B
F06 (5A) Fuse, Alternator ECU & Engine Components CA1−1 3 B
F06 (5A) Fuse, Alternator ECU & Engine Components CE2 2 B
F06 (5A) Fuse, Alternator ECU & Engine Components FB1 3 B
F06 (5A) Fuse, Alternator ECU & Engine Components FB4 2 B
F07 (5A) Fuse, Vehicle ECU Feed BA1 1 B
F08 (5A) Fuse, Instrument cluster & On Board Diagn BD1−1 2 A
F08 (5A) Fuse, Instrument cluster & On Board Diagn BE1 1 A
F08 (5A) Fuse, Instrument cluster & On Board Diagn BG1 2 A
F11 (5A) Fuse, Transmission, I−shift GECU DA1 2 B
F12 (5A) Fuse, Transmission, TECU DA1 1 B
F13 (15A) Fuse, Wiper & Washer OG1 3 A
F13 (15A) Fuse, Wiper & Washer OH1 2 A
1

1
F14 (10A) Fuse, Body +15 YA1−5 2 A
F20 (10A) Fuse, Alcolock & Advanced information clu BF1 1 A
F20 (10A) Fuse, Alcolock & Advanced information clu JD2 3 A
F23 (5A) Fuse, Electronic Controlled Air Suspensio FA1−1 2 A
F28 (20A) Fuse, Electronic brake system EA1−1 1 A
F30 (20A) Fuse, Ignition +15 AB2 3 B
F35 (20A) Fuse, Front external light YA1−1 4 A
F36 (15A) Fuse, Day running light YA1−1 3 C
F38 (5A) Fuse, Light Control Module GA1 1 A
F39 (5A) Fuse, Fleet Management System Gate Way (T JD2 4 A
F39 (5A) Fuse, Fleet Management System Gate Way (T JF1 2 A
F42 (5A) Fuse, DACU VA2 4 A
F43 (5A) Fuse, Fuel Cut Off Valve CE1 2 B
F46 (10A) Fuse, Horn YA1−2 0 A
F48 (5A) Fuse, Electronic Brake System EA1−1 1 A
F49 (5A) Fuse, Electronic Control Suspension FA1−1 1 A
F50 (5A) Fuse, GW (Gate Way) FC2−2 2 B
F51 (5A) Fuse, BBM ECU BB1 2 A
F52 (10A) Fuse, Body System +30 YA1−2 0 A
F53 (10A) Fuse, Gearbox, TECU ZF Ecolife DA2−1 1 A
F54 (10A) Fuse, Dynafleet & Fleet Management System JE1 1 A
2

2
F54 (10A) Fuse, Dynafleet & Fleet Management System JF1 2 A
F55 (5A) Fuse, Bus I/O ECU BC1 2 A
F57 (5A) Fuse, Gearbox, TECU ZF Ecolife DA1 3 A
F57 (5A) Fuse, Gearbox, TECU ZF Ecolife DA2−1 2 A
F57 (5A) Fuse, Gearbox, TECU ZF Ecolife DA2−2 2 A
F59 (5A) Fuse, Dashboard Switch Feed AB2 4 A
F60 (5A) Fuse, +DR Body YA1−4 4 A
F61 (5A) Fuse, Infotainment AIC (Telematics Interf JE1 2 A
F62 (10A) Fuse, After treatment Control Module (AMC BD1−2 3 A
F62 (10A) Fuse, After treatment Control Module (AMC CB1−1 2 A
F63 (10A) Fuse, Bus I/O ECU BC1 1 A
F64 (10A) Fuse, Active Safety Seat Haptic VA2 3 A
F67 (5A) Fuse, Radio, Audio JA1 1 A
F68 (5A) Fuse, Ignition Key AB2 2 A
F74 (15A) Fuse, Windscreen & Headlamp Washer OH1 1 A
F77 (25A) Fuse, Light Control Module Feed GA1 0 A
F78 (25A) Fuse, Light Control Module Feed GA1 0 A
F79 (25A) Fuse, Light Control Module Feed GA1 0 A
F80 (25A) Fuse, Light Control Module Feed GA1 0 A
F81 (25A) Fuse, Light Control Module Feed GA1 0 A
F82 (25A) Fuse, Light Control Module Feed GA1 1 A
3

3
F84 (5A) Fuse, Infotainment, AIC (Telematics Inter JD2 4 A
F85 (20A) Fuse, Radio (Audio) JA1 1 A
F86 (5A) Fuse, Instrument Cluster BD1−1 1 A
F87 (5A) Fuse, Main Switch AB2 0 A
F88 (30A) Fuse, VDS (Volvo Dynamic steering) FC2−1 2 B
F89 (5A) Fuse, Sidemarkers Left YA1−3 3 B
F90 (5A) Fuse, Sidemarkers Right YA1−3 3 B
F100 (400A) Fuse, VPDUR AA2 4 C
F101 (150A) Fuse, +30 Chassis AA2 4 B
F104 (150A) Fuse, B+ AA2 3 B
F108 (15A) Fuse, Body Builder YA1−2 4 A
F109 (20A) Fuse, I−Start AD1 2 A
F110 (20A) Fuse, Bodybuilder YA1−2 3 A
F115 (10A) Fuse, Tachograph AB2 1 A
F115 (10A) Fuse, Tachograph BE1 1 A
F118 (15A) Fuse, Spare Body YA1−2 4 A

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 3(44)

D

A
C

B
E
 D

A
C

B
E
0

0
FUSE DESCRIPTION PAGE
F120 (5A) Fuse, Battery Sensor AC1 2 A
F121 (5A) Fuse, ARMS AA2 3 B
F200 (300A) Fuse, Alternator / DCDC AC1 0 A
F201 (200A) Fuse, Alternator AC1 0 A
F206 (300A) Fuse, +30 CI1 2 A
F207 (400A) Fuse, VPDUF AA2 4 D
F208 (10A) Fuse, CCIOM AC1 2 B
F209 (20A) Fuse, Fuel Heater CE2 1 B
F210 (15A) Fuse, EMS Supply CA1−1 1 B
F211 (15A) Fuse, EMS Supply CA1−1 2 B
F212 (10A) Fuse, EMS Supply CA1−1 2 B
F213 (10A) Fuse, EMS Supply CA1−1 2 B
F214 (10A) Fuse, Air Compressor/Dryer FB1 2 B
F214 (10A) Fuse, Air Compressor/Dryer FB4 1 B
F215 (10A) Fuse, UQS Sensor CA1−1 1 B
F217 (5A) Fuse, Engine Hatch VD4 2 A
F218 (10A) Engine Room Light ID1 2 A
F218 (10A) Engine Room Light ID3 3 A
F223 (10A) Fuse, Hydraulic Steering FD1 2 A
1

1
F224 (30A) Fuse, ACM Supply CB1−1 1 A
F300 (125A) Fuse, Water Heater 1 CI1 1 C
F301 (125A) Fuse, Water Heater 2 CI1 2 C
2

2
3

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 4(44)

D

A
C

B
E
 D

A
C

B
E
COMPONENTS
0

0
COMPONENT DESCRIPTION PAGE
A03 Instrument cluster BD1−1 1 D
A03 Instrument cluster BD1−2 2 D
A03 Instrument cluster BD1−3 3 B
A03 Instrument cluster EA1−1 3 B
A03 Instrument cluster EB1 2 C
A03 Instrument cluster GA1 3 B
A03 Instrument cluster GC2 1 A
A03 Instrument cluster JB1 2 B
A03 Instrument cluster XA1 4 D
A03 Instrument cluster XE1−1 4 C
A03 Instrument cluster XH1 2 C
A03 Instrument cluster YA1−3 3 C
A03 Instrument cluster YA1−4 3 C
A03 Instrument cluster YA1−6 2 C
A07 Control unit, Audio JA1 1 D
A07 Control unit, Audio XE1−1 3 C
A07 Control unit, Audio XH1 1 C
A13A Control unit, TECU (Transmission ECU) DA1 1 D
A13A Control unit, TECU (Transmission ECU) XA1 1 E
1

1
A13A Control unit, TECU (Transmission ECU) XB1 4 D
A13A Control unit, TECU (Transmission ECU) XC1 2 C
A16 Control unit, ECS (Electronic Controlled FA1−1 1 C
A16 Control unit, ECS (Electronic Controlled FA1−2 2 B
A16 Control unit, ECS (Electronic Controlled FA2 3 B
A16 Control unit, ECS (Electronic Controlled FA3 2 A
A16 Control unit, ECS (Electronic Controlled FA5 2 B
A16 Control unit, ECS (Electronic Controlled XA1 3 B
A16 Control unit, ECS (Electronic Controlled XH1 3 B
A16 Control unit, ECS (Electronic Controlled YA1−6 3 B
A17 Control unit, VECU (Vehicle ECU) AB2 4 E
A17 Control unit, VECU (Vehicle ECU) AC1 4 C
A17 Control unit, VECU (Vehicle ECU) BA1 1 D
A17 Control unit, VECU (Vehicle ECU) BE1 2 A
A17 Control unit, VECU (Vehicle ECU) BE2 2 A
A17 Control unit, VECU (Vehicle ECU) BH2 2 B
A17 Control unit, VECU (Vehicle ECU) BI1 2 A
A17 Control unit, VECU (Vehicle ECU) CA1−1 3 C
A17 Control unit, VECU (Vehicle ECU) CE1 1 C
A17 Control unit, VECU (Vehicle ECU) CE2 2 C
A17 Control unit, VECU (Vehicle ECU) EF1 2 E
2

2
A17 Control unit, VECU (Vehicle ECU) EG1 2 B
A17 Control unit, VECU (Vehicle ECU) EH1 2 D
A17 Control unit, VECU (Vehicle ECU) FB1 2 E
A17 Control unit, VECU (Vehicle ECU) FB2 2 B
A17 Control unit, VECU (Vehicle ECU) FB4 2 B
A17 Control unit, VECU (Vehicle ECU) GD1 2 A
A17 Control unit, VECU (Vehicle ECU) XA1 2 B
A17 Control unit, VECU (Vehicle ECU) XE1−1 1 C
A17 Control unit, VECU (Vehicle ECU) XH1 2 B
A17 Control unit, VECU (Vehicle ECU) YA1−4 1 B
A17 Control unit, VECU (Vehicle ECU) YA1−6 3 B
A19_A Control unit, GECU (gear selector ECU) G DA2−2 2 D
A19_A Control unit, GECU (gear selector ECU) G XJ1 3 C
A19C Control unit, GECU I−shift DA1 3 E
A21 Control Unit, EBS (Electronic Brake Syste EA1−1 1 C
A21 Control Unit, EBS (Electronic Brake Syste EA1−2 2 A
A21 Control Unit, EBS (Electronic Brake Syste EA2 1 A
A21 Control Unit, EBS (Electronic Brake Syste EB1 2 C
A21 Control Unit, EBS (Electronic Brake Syste EC1 2 A
A21 Control Unit, EBS (Electronic Brake Syste ED1 1 D
A21 Control Unit, EBS (Electronic Brake Syste XA1 2 B
3

3
A21 Control Unit, EBS (Electronic Brake Syste XH1 3 B
A21 Control Unit, EBS (Electronic Brake Syste YA1−4 2 B
A22 Control unit, FMS (Fleet Management Syst JF1 2 C
A22 Control unit, FMS (Fleet Management Syst XA1 5 B
A22 Control unit, FMS (Fleet Management Syst XE1−2 0 C
A22 Control unit, FMS (Fleet Management Syst XH1 5 C
A26 Control unit, DACU (Driver Assistance Con VA2 0 C
A26 Control unit, DACU (Driver Assistance Con XA1 3 D
A26 Control unit, DACU (Driver Assistance Con XB1 1 C
A26 Control unit, DACU (Driver Assistance Con XM1 1 C
A27 Control unit, LCM ( Light Control Module AA2 1 E
A27 Control unit, LCM ( Light Control Module AB2 3 E
A27 Control unit, LCM ( Light Control Module GA1 2 C
A27 Control unit, LCM ( Light Control Module GB1−1 2 E
A27 Control unit, LCM ( Light Control Module GB1−2 2 E
A27 Control unit, LCM ( Light Control Module GB2 2 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 5(44)

D

A
C

B
E
 D

A
C

B
E
0

0
COMPONENT DESCRIPTION PAGE
A27 Control unit, LCM ( Light Control Module GC1−1 2 D
A27 Control unit, LCM ( Light Control Module GC1−2 2 A
A27 Control unit, LCM ( Light Control Module GC2 2 A
A27 Control unit, LCM ( Light Control Module GD1 2 B
A27 Control unit, LCM ( Light Control Module GD2−1 2 D
A27 Control unit, LCM ( Light Control Module GD2−2 2 A
A27 Control unit, LCM ( Light Control Module GD3 2 B
A27 Control unit, LCM ( Light Control Module OG1 3 C
A27 Control unit, LCM ( Light Control Module OH1 3 D
A27 Control unit, LCM ( Light Control Module XA1 3 B
A27 Control unit, LCM ( Light Control Module XH1 4 B
A27 Control unit, LCM ( Light Control Module YA1−1 2 B
A27 Control unit, LCM ( Light Control Module YA1−3 1 B
A27 Control unit, LCM ( Light Control Module YA1−5 3 B
A33 Tachograph BE1 1 B
A33 Tachograph JE1 2 B
A33 Tachograph XE1−1 5 C
A33 Tachograph YA1−4 4 C
A36 Control unit, BBM (Body Builder Module) AA2 3 E
1

1
A36 Control unit, BBM (Body Builder Module) AB2 0 E
A36 Control unit, BBM (Body Builder Module) AD1 2 A
A36 Control unit, BBM (Body Builder Module) BB1 2 C
A36 Control unit, BBM (Body Builder Module) EA2 3 A
A36 Control unit, BBM (Body Builder Module) EG1 2 B
A36 Control unit, BBM (Body Builder Module) FD1 1 B
A36 Control unit, BBM (Body Builder Module) ID3 2 B
A36 Control unit, BBM (Body Builder Module) VA2 4 E
A36 Control unit, BBM (Body Builder Module) VD4 1 B
A36 Control unit, BBM (Body Builder Module) XA1 1 B
A36 Control unit, BBM (Body Builder Module) XF1 1 C
A36 Control unit, BBM (Body Builder Module) XH1 3 B
A36 Control unit, BBM (Body Builder Module) YA1−4 2 B
A36 Control unit, BBM (Body Builder Module) YA1−5 1 B
A41 Component group transmission. Contains B EH3 1 D
A79 Control unit, I−shift gateway DA1 2 C
A79 Control unit, I−shift gateway XA1 4 D
A79 Control unit, I−shift gateway XH1 3 C
A80 Airdryer, electronical controlled FB1 2 C
A125 Control unit, TGW (Telematics Gateway) JE1 1 C
A125 Control unit, TGW (Telematics Gateway) XB1 2 C
2

2
A125 Control unit, TGW (Telematics Gateway) XE1−1 3 C
A125 Control unit, TGW (Telematics Gateway) XH1 2 C
A132 Control unit, alcolock BF1 1 D
A132 Control unit, alcolock XF1 4 C
A163 Control unit, CCIOM, Central Chassis IO M AC1 2 B
A163 Control unit, CCIOM, Central Chassis IO M CI1 1 B
A163 Control unit, CCIOM, Central Chassis IO M FB4 3 C
A163 Control unit, CCIOM, Central Chassis IO M XB1 3 C
A174 Control unit, ACM (Aftertreatment Control CB1−1 1 D
A174 Control unit, ACM (Aftertreatment Control CB1−2 3 B
A174 Control unit, ACM (Aftertreatment Control CB1−3 1 B
A174 Control unit, ACM (Aftertreatment Control CB1−4 4 A
A174 Control unit, ACM (Aftertreatment Control CB1−5 2 C
A174 Control unit, ACM (Aftertreatment Control EH3 2 A
A174 Control unit, ACM (Aftertreatment Control XA1 2 D
A174 Control unit, ACM (Aftertreatment Control XB1 3 C
A174 Control unit, ACM (Aftertreatment Control XD1 2 B
A176 Control unit, LPOS, Lane Position and Obj VA2 1 B
A176 Control unit, LPOS, Lane Position and Obj XM1 2 C
A190 Component group urea CB1−4 2 E
A195 Control unit, BIO Bus I/O ECU BC1 1 C
3

3
A195 Control unit, BIO Bus I/O ECU EF1 2 E
A195 Control unit, BIO Bus I/O ECU FB4 1 D
A195 Control unit, BIO Bus I/O ECU VA2 3 B
A195 Control unit, BIO Bus I/O ECU XF1 2 C
A195 Control unit, BIO Bus I/O ECU XG1 2 C
A195 Control unit, BIO Bus I/O ECU XH1 4 C
A200 Control unit, TECU (Transmission ECU) ZF DA2−1 1 D
A200 Control unit, TECU (Transmission ECU) ZF XA1 2 D
A200 Control unit, TECU (Transmission ECU) ZF XH1 1 E
A200 Control unit, TECU (Transmission ECU) ZF XJ1 0 D
A201 Control unit, AIC (Advanced Information C JD2 1 C
A201 Control unit, AIC (Advanced Information C XE1−1 2 C
A201 Control unit, AIC (Advanced Information C XE1−2 1 C
A201 Control unit, AIC (Advanced Information C XF1 4 C
A201 Control unit, AIC (Advanced Information C XH1 5 C
A224 Seat Haptic Vibration VA2 3 C

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 6(44)

D

A
C

B
E
 D

A
C

B
E
0

0
COMPONENT DESCRIPTION PAGE
A234 Control Unit, VDS GW (Volvo Dynamic Steer FC2−2 2 D
A234 Control Unit, VDS GW (Volvo Dynamic Steer XB1 2 C
A234 Control Unit, VDS GW (Volvo Dynamic Steer XF1 3 D
A234 Control Unit, VDS GW (Volvo Dynamic Steer XO1 2 D
A235 Control Unit, VDS (Volvo Dynamic Steering FC2−1 2 D
A235 Control Unit, VDS (Volvo Dynamic Steering XO1 3 D
B03 Sensor, footbrake valve EA1−1 1 B
B06 Sensor, air pressure, air tank FB2 2 D
B07 Sensor, fuel level BD1−3 3 C
B12 Sensor, tachograph / speedometer BE1 1 E
B12 Sensor, tachograph / speedometer BE2 2 D
B13B Sensor, wheel speed, lhs. front axle EA1−2 0 D
B14B Sensor, wheel speed, rhs. front axle EA1−2 1 D
B15 Sensor, wheel speed, lhs. 1:st driven re EA1−2 2 D
B16 Sensor, wheel speed, rhs. 1:st driven re EA1−2 2 D
B22 Sensor, outdoor temperature BD1−3 2 D
B25 Sensor, accelerator pedal BI1 2 D
B28 Sensor, chassis level, front axle FA1−2 2 D
B29 Sensor, chassis level, lhs. rear axle FA3 3 D
1

1
B30 Sensor, chassis level, rhs.rear axle FA3 3 D
B32 Sensor, engine cooling fan speed CA1−3 2 C
B39 Sensor, air filter pressure and air filt CA1−2 1 C
B40A Sensor, brake lining wear indicator, lhs EA1−2 0 D
B40B Sensor, brake lining wear indicator, lhs EA1−2 0 D
B42 Sensor, brake lining wear indicator, lhs EA1−2 1 D
B43 Sensor, brake lining wear indicator, rhs EA1−2 1 D
B49 Sensor, steering angle EC1 2 D
B50 Sensor, yaw−rate EC1 2 D
B52 Sensor, water level, water separator CA1−2 0 C
B56 Sensor, air pressure, suspension bellows FA1−2 2 C
B57 Sensor, air pressure, suspension bellows FA3 2 C
B58 Sensor, air pressure, suspension bellows FA3 2 C
B69 Sensor, coolant temperature, retarder EH3 2 D
B85 Sensor, exhaust temp, downstream DPF CB1−2 1 C
B96A Sensor, NOx CB1−3 1 C
B96A Sensor, NOx XD1 2 B
B96B Sensor, NOx CB1−3 2 C
B96B Sensor, NOx XD1 3 B
B97 Sensor, exhaust temp, upstream catalyst CB1−2 2 C
B98 Sensor, exhaust temp, downstream catalyst CB1−2 2 C
2

2
B115 Sensor, DPF pressure (Diesel particulate CB1−2 1 C
B142B Sensor, AdBlue level and temperature CB1−4 4 D
B152 Sensor, Brake Air Pressure 1 EA1−1 3 D
B153 Sensor, Brake Air Pressure 2 EA1−1 3 D
B238 Sensor, FLS (Forward Looking Sensor) VA2 2 B
B238 Sensor, FLS (Forward Looking Sensor) XM1 3 C
B250 Sensor, Battery AA2 1 D
B262 Sensor, Urea Pressure CB1−4 3 C
B263 Sensor, Urea Air Pressure CB1−4 3 C
B274 Sensor, Hydraulic oil level Engine fan BD1−2 3 C
B275B Sensor, Hydraulic oil level Mechanical Po BD1−2 3 C
B276 Sensor, Hydraulic oil pressure Boogie FD1 1 D
B278 Sensor, Brake Air Pressure 3 EA2 3 D
B279 Sensor, Fuel Level Second BD1−3 3 C
B280A Sensor, Heat Sensor Air Filter CF1 2 B
B280B Sensor, Heat Sensor Air Filter CF1 2 B
B281 Sensor, Heat Sensor Third Alternator CF1 2 C
B291L Sensor Indicator EBS Additional Brake Lin EA2 1 D
B291R Sensor Indicator EBS Additional Brake Lin EA2 1 D
B292L Sensor, Speed EBS Additional Wheel Left EA2 1 D
B292R Sensor, Speed EBS Additional Wheel Right EA2 2 D
3

3
B307 Sensor Fuel Quality CB1−5 2 D
B349 Sensor, Hatch Engine VD4 1 D
D1 Diode Parkbrake EG1 2 C
E06 Lamp, reversing light GD3 2 D
E07L Lamp, fog light, left GB2 2 A
E07R Lamp, fog light, right GB2 2 A
E08FSL1 Lamp, parking light Front side left GD2−1 0 B
E08FSL2 Lamp, parking light Front side left GD2−1 0 B
E08FSL3 Lamp, parking light Front side left GD2−1 1 E
E08FSR1 Lamp, parking light Front side right GD2−1 4 B
E08FSR2 Lamp, parking light Front side right GD2−1 4 B
E08FSR3 Lamp, parking light Front side left GD2−1 4 E
E09 Lamp, brake light GD1 1 E
E09R Lamp, brake light GD1 2 E
E11LA Lamp, side marker light, left side 1 GC2 0 B
E11LB Lamp, side marker light, left side 2 GC2 0 E

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 7(44)

D

A
C

B
E
 D

A
C

B
E
0

0
COMPONENT DESCRIPTION PAGE
E11RA Lamp, side marker light, right side 1 GC2 4 B
E11RB Lamp, side marker light, right side 2 GC2 3 E
E13LS Lamp, direction indicator, left side GC1−1 1 B
E13LS2 Lamp, direction indicator, left side GC1−2 1 E
E13RL Lamp, direction indicator, left rear GC1−2 2 D
E13RS Lamp, direction indicator, right side GC1−1 4 B
E13RS2 Lamp, direction indicator, right side GC1−2 3 E
E21LR Lamp, rear fog light Left GB2 1 E
E21R Lamp, Rear Fog light, Right GB2 2 E
E21RR Lamp, rear fog light Right GB2 3 E
E23L Lamp, luggage compartment illumination, l ID3 0 D
E23R Lamp, luggage compartment illumination, r ID3 1 D
E27L Tail lamp module, left GC1−2 1 D
E27L Tail lamp module, left GD1 0 E
E27L Tail lamp module, left GD2−2 1 D
E27L Tail lamp module, left GD3 1 D
E27R Tail lamp module, right GC1−2 4 D
E27R Tail lamp module, right GD1 3 E
E27R Tail lamp module, right GD2−2 3 D
1

1
E27R Tail lamp module, right GD3 3 D
E83L HEADLAMP LEFT GB1−1 1 A
E83L HEADLAMP LEFT GB1−2 1 A
E83L HEADLAMP LEFT GC1−1 2 B
E83L HEADLAMP LEFT GD2−1 2 B
E83R HEADLAMP RIGHT GB1−1 2 A
E83R HEADLAMP RIGHT GB1−2 3 A
E83R HEADLAMP RIGHT GC1−1 3 B
E83R HEADLAMP RIGHT GD2−1 2 B
E111 LED Module, (Forward Collision Warning) VA2 0 D
E136 Heater, Regeneration, Water Tank 1 CI1 1 D
E137 Heater, Regeneration, Water Tank 2 CI1 2 D
G01A Battery 1 AA2 1 C
G01B Battery 2 AA2 1 C
G02A Alternator 1 AC1 0 C
G02B Alternator 2 AC1 0 D
G02C Alternator 3 AC1 0 D
G10A Battery, I−Start Battery 1 AD1 2 D
G10B Battery, I−Start Battery 2 AD1 2 D
H01 Horn, air−operated YA1−2 1 D
H02 Horn YA1−2 1 E
2

2
K05 Relay Front wiper On/Off OG1 3 B
K22 Relay Ignition +15 AB2 3 A
K72 Relay VECU (Vehicle ECU) AC1 4 A
K72 Relay VECU (Vehicle ECU) BA1 1 A
K72 Relay VECU (Vehicle ECU) CA1−1 3 A
K72 Relay VECU (Vehicle ECU) CE1 1 A
K72 Relay VECU (Vehicle ECU) CE2 2 B
K72 Relay VECU (Vehicle ECU) FB1 3 A
K72 Relay VECU (Vehicle ECU) FB4 2 A
K73 Relay Ignition +DR AB2 4 A
K74 Relay I−shift DA1 1 A
K75 Relay Luggage Door Switch ID3 1 B
K75 Relay Luggage Door Switch YA1−4 3 B
K76 Relay, ECS (Electronic Controlled Suspens FA1−1 2 B
K77 Relay Day Light Running YA1−1 3 B
K80 Relay Emergency Switch AB2 2 C
K81 Relay Main Switch AB2 0 B
K84 Relay, APBE (Automatic Park Brake Engine) EF1 2 B
K85 Relay Disconnect Headlight wash OH1 1 D
K102 Relay Main Relay AA2 4 B
3

K103 Relay ARMS (Automatic Reset Main Switch) AA2 3 C

3
K106 Relay Water Heater 1 CI1 1 C
K107 Relay, Water Heater 2 CI1 2 C
K200 Relay, Heater/CCIOM (Central Chassis IO M AC1 2 A
K200 Relay, Heater/CCIOM (Central Chassis IO M BA1 3 A
K200 Relay, Heater/CCIOM (Central Chassis IO M CE2 1 B
K201 Relay, EMS (Engine Management System) BA1 2 A
K201 Relay, EMS (Engine Management System) CA1−1 2 A
K201 Relay, EMS (Engine Management System) FB1 2 A
K201 Relay, EMS (Engine Management System) FB4 1 A
K202 Relay Steerable Axle FD1 2 B
K401 Relay Seat Haptic 12V VA2 3 B
K402 Relay Seat Haptic 24V VA2 3 B
M01 Motor, windscreen wiper OG1 1 D
M02 Motor, windscreen washer pump OH1 2 D
M03 Motor, headlamp high pressure washer pum OH1 1 D
M04 Motor, starter motor AD1 1 D

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 8(44)

D

A
C

B
E
 D

A
C

B
E
0

0
COMPONENT DESCRIPTION PAGE
R06 Heater, fuel water separator CE2 1 C
R56 Heater, AdBlue hose, White CB1−4 0 D
R57 Heater, AdBlue hose, Black CB1−4 1 D
R66 Resistor, CAN termin Backbone 1 XA1 1 A
R67 Resistor, CAN termin Backbone 2 XB1 1 B
R88 Resistor FMS CAN XE1−2 3 C
R89 Resistor FCW LED, Pull−up VA2 4 D
R91 Resistor, VDS−CAN CAN Termination XO1 4 B
S01 Switch, main lighting, GA1 2 B
S02 Stalk switch, full− / dipped beams BH2 2 D
S02 Stalk switch, full− / dipped beams GA1 3 D
S06 Stalk switch, windscreen wiper, selector BD1−2 0 C
S06 Stalk switch, windscreen wiper, selector OG1 1 B
S06 Stalk switch, windscreen wiper, selector OH1 2 B
S08 Switch, differential gear lock, rear whe EB1 2 B
S11 Switch, bogie lift, selector type FA5 2 D
S12 Switch, Main Control AB2 1 C
S14A Switch, push button, horn YA1−2 1 C
S14B Switch, push button, horn YA1−2 2 C
1

1
S15 Switch Key switch AB2 3 C
S16 Switch, push button, air horn YA1−2 2 C
S24 Stalk switch, retarder, selector type EH1 2 B
S31 Switch, TCS ( Traction Control System ) ED1 2 B
S32 Switch, brake hold ED1 1 B
S34 Switch unit, steering wheel push buttons JB1 2 D
S41 Switch, battery main switch control AA2 3 C
S43 Switch Indicator Parking Brake Pressure N EG1 2 D
S45 Position switch, differential gear lock i EB1 2 E
S57L2 Position switch, luggage compartment lig ID3 3 D
S57R2 Position switch, luggage compartment lig ID3 4 D
S68 Proximity switch, coolant level, NC. CA1−2 2 C
S70 Position switch, flow sensor, power−stee FD1 2 D
S202 Switch, LDWS, Lane Departure Warning Sys VA2 3 E
S304 Switch Air Suspension Kneeling FA2 2 D
S314 Switch Retarder EH1 1 C
S315 Switch Engine Start Rear CA1−2 1 B
S316 Switch Engine Start Enable Rear CA1−2 2 B
S321 Switch Alternative Gearshift Program ZF E DA2−2 2 C
S322 Switch Emergency Cut−Out AB2 1 B
S322 Switch Emergency Cut−Out YA1−1 0 B
2

2
S324 Switch Driver Change Alcolock BF1 2 C
S325 Switch Air Suspension Raise/Lower Level FA2 3 C
S348 Switch AEBS (Advanced Emergency Braking S VA2 3 E
U03 Modulator, EBS, rear axle EA1−2 1 D
U06 Voltage converter JA1 1 B
U08 Modulator, EBS, one front axle EA1−2 0 D
U36 Modulator, EBS Additional axle EA2 1 D
U37 Voltage converter 12V Bi−Xenon GB1−2 2 B
U38 Voltage converter I−Start DC/DC AD1 2 C
V03 Diode GB1−2 2 C
V04 Diode GB1−2 2 C
V41 Diode Windscreen Wiper OG1 2 C
V43 Diode Supply Control I−Shift transmission DA1 3 A
X43 Connector, OBD (On−Board Diagnostics) BG1 2 D
X43 Connector, OBD (On−Board Diagnostics) XB1 1 C
X43 Connector, OBD (On−Board Diagnostics) XH1 3 C
X47 Plug, Battery charging AA2 0 D
X69 Plug, ZF diagnostics DA2−1 3 C
X69 Plug, ZF diagnostics XA1 5 D
X69 Plug, ZF diagnostics XH1 5 C
X69 Plug, ZF diagnostics XJ1 2 C
3

3
X130 Connector, BB (Body Builder) Radio Interf JA1 2 B
X132 Interface, External Customer Alcolock BF1 1 C
XCA020A Connector, Engine Interface 1 AC1 1 C
XCA020A Connector, Engine Interface 1 CA1−1 1 D
XCA020A Connector, Engine Interface 1 CA1−2 0 D
XCA020A Connector, Engine Interface 1 CF1 2 A
XCA020A Connector, Engine Interface 1 XA1 1 D
XCA020A Connector, Engine Interface 1 XB1 5 D
XCA020A Connector, Engine Interface 1 XC1 2 C
XCA020A Connector, Engine Interface 1 XD1 4 B
XCA020B Connector Engine Interface 2 CA1−2 0 A
XCA020B Connector Engine Interface 2 CA1−3 2 D
XCA021 Connector Gearbox Interface BE1 1 D
XCA021 Connector Gearbox Interface BE2 2 D
XCA021 Connector Gearbox Interface DA1 1 D
XCA021 Connector Gearbox Interface DA2−1 1 D

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 9(44)

D

A
C

B
E
 D

A
C

B
E
0

0
COMPONENT DESCRIPTION PAGE
XCA021 Connector Gearbox Interface EH3 1 C
XCA021 Connector Gearbox Interface XA1 2 D
XCA021 Connector Gearbox Interface XB1 4 C
XCA021 Connector Gearbox Interface XC1 2 C
XCA021 Connector Gearbox Interface XH1 1 D
XCA021 Connector Gearbox Interface XJ1 1 C
XCB401B Connector Body Interface 3 XH1 3 C
XCB401B Connector Body Interface 3 YA1−1 0 D
XCB403 Connector Body interface Horn XF1 1 C
XCB403 Connector Body interface Horn YA1−2 0 C
XCB500 Connector Wiper motor Windscreen System OG1 2 D
XCB500 Connector Wiper motor Windscreen System OH1 1 C
XCB501BLF Connector Front lights 2 Left GB1−1 1 B
XCB501BLF Connector Front lights 2 Left GB1−2 0 B
XCB501BLF Connector Front lights 2 Left GC1−1 2 B
XCB501BLF Connector Front lights 2 Left GD2−1 2 B
XCB501BRF Connector Front lights 2 Right GB1−1 3 B
XCB501BRF Connector Front lights 2 Right GB1−2 3 B
XCB501BRF Connector Front lights 2 Right GC1−1 3 B
1

1
XCB501BRF Connector Front lights 2 Right GD2−1 3 B
XCB502 Connector Body interface Front lights GB1−1 2 C
XCB502 Connector Body interface Front lights GB1−2 1 D
XCB502 Connector Body interface Front lights GB2 2 B
XCB502 Connector Body interface Front lights GC1−1 2 C
XCB502 Connector Body interface Front lights GD2−1 2 C
XCB502 Connector Body interface Front lights YA1−1 2 D
XCB503 Connector Extra lights Rear GC1−2 1 D
XCB503 Connector Extra lights Rear GC2 0 A
XCB503 Connector Extra lights Rear GD1 2 D
XCB503 Connector Extra lights Rear GD3 1 B
XCB601F Connector Side Front lights Left GC1−1 1 B
XCB601F Connector Side Front lights Left GD2−1 0 C
XCB601M Connector Side−marker lights Left GC2 0 D
XCB601M Connector Side−marker lights Left ID3 3 D
XCB602F Connector Front lights Right GC1−1 4 B
XCB602F Connector Front lights Right GD2−1 4 C
XCB602M Connector Side−marker lights Right GC2 4 D
XCB602M Connector Side−marker lights Right ID3 4 D
XCB703R Connector Rear lights 2 Left GB2 2 D
XCB703R Connector Rear lights 2 Left GC1−2 2 D
2

2
XCB703R Connector Rear lights 2 Left GD1 1 D
XCB703R Connector Rear lights 2 Left GD2−2 2 D
XCB703R Connector Rear lights 2 Left GD3 2 D
XCB703R Connector Rear lights 2 Left ID1 2 C
XCB703R Connector Rear lights 2 Left VD4 2 C
XCB720R Connector Rear lights 3 Right GC1−2 4 D
XCB720R Connector Rear lights 3 Right GD1 3 D
XCB720R Connector Rear lights 3 Right GD2−2 3 C
XCB720R Connector Rear lights 3 Right GD3 3 D
XCB721R Connector Rear lights 3 Left GC1−2 0 D
XCB721R Connector Rear lights 3 Left GD1 0 D
XCB721R Connector Rear lights 3 Left GD2−2 1 C
XCB721R Connector Rear lights 3 Left GD3 1 D
XCB722R Connector Rear lights 1 Right GB2 3 D
XCB723R Connector Rear lights 1 Left GB2 1 D
XCB801F Connector Body interface 1 GB2 2 C
XCB801F Connector Body interface 1 GC1−2 1 B
XCB801F Connector Body interface 1 GC2 2 B
XCB801F Connector Body interface 1 GD1 1 C
XCB801F Connector Body interface 1 GD2−2 2 B
XCB801F Connector Body interface 1 GD3 2 B
3

3
XCB801F Connector Body interface 1 ID3 1 B
XCB801F Connector Body interface 1 VD4 1 B
XCB801F Connector Body interface 1 XE1−1 1 C
XCB801F Connector Body interface 1 XG1 2 C
XCB801F Connector Body interface 1 YA1−3 1 C
XCB801F Connector Body interface 1 YA1−4 1 D
XCB801F Connector Body interface 1 YA1−7 0 B
XCB801x Connector Body interface 1x YA1−7 0 C
XCB803F Connector Body interface 2 YA1−5 0 D
XCB803F Connector Body interface 2 YA1−6 0 D
XCB805 Connector Parking lights Front GA1 1 D
XCB805 Connector Parking lights Front GD2−1 4 D
XCB906 Connector Body Interface 4 YA1−2 3 C
XCG11 Pass Through ELC junction GND ZA1 1 D
XJB101 Pass Through ELC junction B+ AA2 2 B
XJB102 Pass Through ELC junction +30 AA2 4 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 10(44)

D

A
C

B
E
 D

A
C

B
E
0

0
COMPONENT DESCRIPTION PAGE
XJB201 Junction Box, Interface Batt/Front Fuse B AA2 1 B
XJB202 Junction Box, Interface BBox/Battery Main AA2 2 B
XJB601 Junction, I−Start Batt/Starter Motor AC1 0 B
XJB601 Junction, I−Start Batt/Starter Motor AD1 1 D
Y02 Solenoid valve, differential lock, rear EB1 2 E
Y11 Solenoid valve unit, ABS, front left EA1−2 3 D
Y12 Solenoid valve unit, ABS, front right EA1−2 3 D
Y25 Solenoid valve unit, level control, air FA3 1 D
Y36 Solenoid valve, steerable axle FD1 2 D
Y37 Solenoid Valve Unit Engine brake / AVU (A CA1−2 3 B
Y40 Solenoid valve unit, front axle, air sus FA1−2 1 D
Y80B Solenoid valve, AdBlue dosing unit CB1−4 0 C
Y81C Solenoid valve, AdBlue tank heating CB1−4 1 C
Y147 Solenoid Valve Cooling Fan / Shut off Val CA1−3 3 B
Y158 Solenoid Valve, Automat Park Break Evac V EF1 2 C
Y159 Solenoid Valve, Automat Park Break Evac V EF1 3 C
Y160 Solenoid Valve Fuel Cut Off CE1 2 C
Y162B Solenoid Valve Unit Body Heating /AVU (Ai CA1−3 1 B
Y163 Solenoid Valve Unit Air Suspension Boogie FA5 1 D
1

1
Y169A Valve Air Inlet FB4 1 C
Y170 Valve Air Outlet FB4 3 D
2

2
3

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 11(44)

D

A
C

B
E
 D

A
C

B
E
INLINES
0

0
INLINE PAGE INLINE PAGE INLINE PAGE INLINE PAGE INLINE PAGE
FH1:1P GA1 0 B XC001:6 EA1−1 3 C XC006:15 FD1 1 C XC022:32 JD2 4 B XC025:7 GA1 2 C
FH1:1S AA2 1 A XC001:7 EA1−1 3 C XC006:16 BD1−2 3 D XC022:33 JE1 2 B XC025:8 GA1 2 C
FH1:2P GA1 0 B XC001:8 BD1−3 3 C XC006:22 FA5 1 C XC022:35 JE1 1 B XC025:9 GA1 2 C
FH1:2S AA2 2 A XC001:9 BD1−3 3 C XC006:24 BA1 1 B XC022:35 JF1 2 B XC025:10 GA1 2 C
FH1:3P GA1 0 B XC001:10 BD1−3 2 C XC006:33 FB1 2 D XC023:1 BD1−1 1 B XC025:11 GA1 2 C
FH1:3S AA2 2 A XC001:10 EA1−1 2 C XC006:34 FB1 2 D XC023:2 BD1−1 2 B XC025:12 GA1 2 C
FH2:1P GA1 0 B XC001:11 EA1−1 1 B XC007:1 AC1 2 B XC023:2 BE1 1 B XC025:13 GA1 1 C
FH2:1S AA2 2 A XC001:12 EA1−1 1 B XC007:9 FB2 2 C XC023:2 BG1 2 B XC025:14 GA1 1 C
FH2:2P GA1 0 B XC001:13 EA1−1 1 B XC007:10 FB2 2 C XC023:3 BD1−1 2 B XC025:15 GA1 1 C
FH2:2S AA2 2 A XC001:14 EA1−1 1 B XC007:11 FB2 2 C XC023:3 BD1−2 1 B XC025:16 YA1−6 2 C
FH2:3P GA1 1 B XC001:15 EA1−1 2 B XC007:12 EB1 2 D XC023:3 BG1 2 B XC025:17 VA2 4 B
FH2:3S AA2 2 A XC001:16 AA2 1 D XC007:13 EB1 2 D XC023:4 YA1−3 3 B XC025:18 YA1−6 1 C
FH3:1S AA2 2 A XC001:17 EA1−2 1 C XC007:14 FA3 1 B XC023:5 YA1−4 3 D XC025:19 YA1−6 2 C
FH3:2P JD2 4 B XC001:18 EA1−2 1 C XC007:15 FA3 1 B XC023:6 YA1−4 3 D XC025:20 YA1−6 2 C
FH3:2S AA2 2 A XC001:19 EA1−2 0 C XC007:16 FA3 1 B XC023:7 YA1−4 4 D XC025:21 YA1−6 2 C
FH3:3P JA1 1 A XC001:20 EA1−2 0 C XC007:19 DA1 1 C XC023:8 EA1−1 1 C XC025:22 YA1−6 2 C
FH3:3S AA2 2 A XC001:21 FA1−2 2 C XC007:19 DA2−1 1 C XC023:9 EA1−1 1 C XC025:23 VA2 4 D
FH4:1P BD1−1 1 A XC001:21 FA3 1 B XC007:20 DA2−1 2 C XC023:10 EA1−1 1 C XC025:24 JA1 1 B
FH4:1S AA2 2 A XC001:22 FA1−2 2 C XC007:21 XJ1 1 B XC023:11 EA1−1 1 C XC025:26 BH2 1 C
XC001:22 FA3 2 B XC007:22 XJ1 1 B XC023:12 EA1−1 2 C XC025:27 BH2 1 C
1

1
FH4:2P AB2 0 A
FH4:2S AA2 2 A XC001:23 FA1−2 2 C XC007:25 ID3 1 C XC023:13 ED1 3 C XC025:28 FA1−2 2 B
FH4:3P FC2−1 2 B XC001:23 FA3 2 B XC008:1 GD2−2 2 B XC023:14 ED1 3 C XC025:29 FA1−2 3 B
FH4:3S AA2 2 A XC001:24 FA1−2 3 C XC008:2 GD2−2 2 B XC023:15 EB1 2 B XC025:29 FA3 3 B
FH5:1P YA1−3 3 C XC001:24 FA3 3 B XC008:3 GC1−2 1 B XC023:16 ED1 1 C XC025:30 FA1−2 2 B
FH5:1S YA1−3 3 B XC001:25 AB2 1 B XC008:4 GC1−2 2 B XC023:17 ED1 1 C XC025:30 FA3 2 B
FH5:2P YA1−3 3 C XC001:25 BE1 1 B XC008:5 GD1 1 C XC023:18 FA2 1 B XC025:31 FA3 3 B
FH5:2S YA1−3 3 B XC002:1 EA1−2 3 C XC008:6 GD1 2 C XC023:19 FA2 2 B XC025:32 FA3 3 B
FRC:28 EA1−1 1 A XC002:2 EA1−2 3 C XC008:7 GB2 2 C XC023:20 FA1−2 1 B XC025:33 VA2 2 B
FRC:30 AB2 3 B XC002:3 EA1−2 3 C XC008:8 GD3 2 B XC023:20 FA2 1 B XC025:34 VA2 2 B
FRC:35 YA1−1 4 B XC002:4 EA1−2 3 C XC008:9 GC1−2 2 B XC023:20 YA1−6 3 C XC025:35 VA2 4 B
FRC:36 YA1−1 3 C XC002:5 EC1 2 C XC008:10 GC1−2 2 B XC023:21 FA1−2 1 B XC025:36 VA2 3 B
FRC:38 GA1 1 B XC002:6 EC1 2 C XC008:11 GC2 2 C XC023:22 FA1−2 1 B XC026:1 AA2 1 D
FRC:39 JD2 4 B XC002:7 EC1 3 C XC008:12 GC2 2 C XC023:23 FA5 1 B XC026:2 AA2 3 D
FRC:39 JF1 2 B XC002:8 EC1 3 C XC008:13 FA3 2 B XC023:24 FA2 3 B XC026:3 CE1 2 C
FRC:42 VA2 4 A XC002:9 FA1−2 1 C XC008:14 FA3 2 B XC023:25 FA2 3 B XC026:4 EA1−2 3 B
FRC:43 CE1 2 B XC002:10 FA1−2 1 C XC008:15 FA3 3 B XC023:26 EC1 1 B XC026:5 EA1−2 3 B
FRC:46 YA1−2 0 B XC002:11 FA1−2 1 C XC008:16 FA3 3 B XC023:27 EC1 2 B XC026:6 EA1−2 3 B
FRC:48 EA1−1 1 A XC002:13 FA1−2 2 C XC008:17 EA1−2 2 C XC023:28 EC1 2 B XC026:7 EA1−2 3 B
FRC:49 FA1−1 1 B XC002:14 BD1−3 2 C XC008:18 EA1−2 2 C XC023:29 EC1 2 B XC026:8 EA1−2 2 B
FRC:50 FC2−2 2 B XC002:16 FA1−2 2 C XC008:19 EA1−2 2 C XC023:30 FA5 2 B XC026:10 VA2 3 B
2

2
FRC:51 BB1 2 B XC002:17 XM1 3 C XC008:20 EA1−2 1 C XC023:31 FA1−2 2 B XC026:11 VA2 3 B
FRC:52 YA1−2 0 B XC002:18 XM1 3 C XC008:21 FA3 1 B XC023:31 FA3 1 B XC026:14 GD2−1 1 D
FRC:53 DA2−1 1 A XC002:19 VA2 2 B XC008:22 FA3 1 B XC023:32 FA1−2 2 B XC026:15 GD2−1 4 D
FRC:54 JE1 1 B XC002:20 VA2 2 B XC008:23 FA3 2 B XC023:32 FA3 2 B XC026:16 GA1 1 D
FRC:54 JF1 2 B XC002:21 AD1 2 B XC008:24 FA3 3 B XC023:33 FA1−2 2 B XC026:17 EA1−2 1 B
FRC:55 BC1 2 B XC002:25 EA1−2 2 C XC008:25 ID3 1 C XC023:35 AB2 0 C XC026:18 EA1−2 1 B
FRC:57 DA1 3 B XC003:9 XO1 2 B XC022:2 AB2 2 C XC023:36 YA1−2 1 C XC026:19 EA1−2 0 B
FRC:57 DA2−1 2 A XC003:10 XO1 2 B XC022:3 AB2 1 C XC024:1 YA1−2 1 C XC026:20 EA1−2 0 B
FRC:57 DA2−2 2 A XC003:12 AA2 3 D XC022:4 AB2 2 C XC024:4 XH1 2 A XC027:1 AD1 2 B
FRC:59 AB2 4 A XC004:1 EA2 1 C XC022:5 AB2 4 D XC024:5 XH1 2 A XC027:3 BA1 1 B
FRC:60 YA1−4 4 B XC004:2 EA2 1 C XC022:6 AB2 4 D XC024:6 XA1 4 A XC027:4 FB1 2 D
FRC:61 JE1 2 B XC004:3 EA2 1 C XC022:7 AB2 3 D XC024:7 XA1 4 A XC027:5 FB1 2 D
FRC:62 BD1−2 3 A XC004:4 EA2 2 C XC022:8 AB2 4 B XC024:8 XE1−1 2 B XC027:6 FB2 2 C
FRC:62 CB1−1 2 B XC004:5 AD1 2 B XC022:9 BH2 2 C XC024:9 XE1−1 2 B XC027:7 FB2 2 C
FRC:63 BC1 1 B XC004:10 AD1 2 B XC022:10 BH2 2 C XC024:10 XH1 5 B XC027:8 FB2 2 C
FRC:64 VA2 3 A XC005:1 CA1−1 3 D XC022:11 BH2 2 C XC024:11 XH1 5 B XC027:11 FD1 1 B
FRC:67 JA1 1 A XC005:5 VD4 1 B XC022:12 BH2 2 C XC024:12 XF1 2 A XC027:12 EA2 3 B
FRC:68 AB2 2 A XC005:6 BD1−2 3 B XC022:13 BI1 2 B XC024:13 XF1 2 B XC027:13 EA2 3 B
FRC:74 OH1 1 A XC005:6 CB1−1 2 C XC022:14 BI1 2 B XC024:14 XG1 2 B XC027:14 EA2 3 B
GND1:1 ZA1 1 E XC005:7 BD1−2 3 D XC022:15 BI1 2 B XC024:15 XG1 3 B XC027:15 CA1−1 3 C
GND2:1 ZA1 3 E XC005:14 BE1 1 C XC022:16 BI1 2 B XC024:16 XE1−2 2 C XC027:16 FA3 2 B
3

3
GND5:1 ZA1 3 E XC005:14 BE2 2 C XC022:17 BI1 2 B XC024:17 XE1−2 2 B XC027:17 FA3 2 B
GND6:1 ZA1 4 E XC005:15 BE1 2 C XC022:18 EH1 2 D XC024:18 JD2 4 B XC027:18 EB1 2 D
GND21:1 AA2 1 E XC005:15 BE2 2 C XC022:19 EH1 2 D XC024:18 JF1 2 B XC027:19 DA1 1 C
GND21:1 AA2 0 D XC005:16 BE1 2 C XC022:20 EH1 2 D XC024:19 OH1 1 B XC027:20 DA1 2 C
GND61:1 AD1 2 E XC005:16 BE2 2 C XC022:21 EH1 3 D XC024:20 OH1 3 C XC027:21 DA1 3 B
GND62:1 AC1 0 E XC005:17 BE1 2 C XC022:23 BE2 2 B XC024:21 OG1 2 B XC027:22 DA1 3 B
GND63:1 ZA1 4 E XC005:18 FB4 1 D XC022:24 BE1 2 B XC024:22 OG1 2 B XC027:22 DA2−1 2 B
GND64:1 ZA1 4 E XC005:29 XH1 1 C XC022:24 BE2 2 B XC024:23 OG1 1 B XC027:22 DA2−2 2 B
GND65:1 CI1 2 E XC005:30 XH1 1 C XC022:25 EG1 2 C XC024:23 OH1 2 B XC027:23 DA2−1 1 B
GND65:1 CI1 1 E XC005:31 XA1 3 C XC022:26 EH1 1 D XC024:25 JA1 1 B XC027:24 FC2−2 2 B
XB:1 ZA1 0 C XC005:32 XA1 3 C XC022:27 GA1 3 C XC025:1 GA1 3 D XC027:25 FA1−2 3 B
XC001:1 AC1 2 B XC005:33 XB1 2 B XC022:28 BC1 1 B XC025:2 GA1 3 D XC028:1 FA3 1 B
XC001:2 AA2 3 D XC005:34 XB1 2 B XC022:29 BC1 2 B XC025:3 GA1 3 D XC028:2 FA3 1 B
XC001:3 CE1 2 C XC006:8 EA2 3 C XC022:30 EF1 2 C XC025:4 GA1 3 D XC028:3 FA3 1 B
XC001:4 EA1−1 3 C XC006:9 EA2 3 C XC022:31 BF1 1 B XC025:5 OG1 2 B XC028:4 AA2 3 D
XC001:5 EA1−1 3 C XC006:10 EA2 3 C XC022:31 JD2 3 B XC025:6 GA1 3 C XC028:9 BD1−2 3 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 12(44)

D

A
C

B
E
 D

A
C

B
E
0

0
INLINE PAGE INLINE PAGE INLINE PAGE INLINE PAGE
XC028:9 CB1−1 2 B XC080:16 AD1 2 C XC200:12 CB1−1 1 B XD:8 ZA1 0 B
XC028:15 EA2 2 B XC080:17 FB1 2 C XC200:13 FB1 2 B XD:9 ZA1 0 B
XC028:16 EA2 1 B XC080:18 FB1 2 C XC200:13 FB4 1 B XD:10 ZA1 0 B
XC028:17 EA1−2 2 B XC080:19 BA1 1 A XC200:14 BA1 1 A XD:11 ZA1 0 B
XC028:18 EA1−2 2 B XC080:24 VD4 1 C XC200:15 CB1−1 2 B XD:12 ZA1 0 B
XC028:19 EA1−2 2 B XC080:27 BD1−2 3 C XC200:16 CA1−1 2 B XE:1 ZA1 0 B
XC028:20 EA1−2 1 B XC080:28 BD1−2 3 C XC200:17 CA1−1 2 B XF:1 FA1−1 2 B
XC028:21 EA2 1 B XC080:29 CA1−1 3 D XC200:18 AC1 2 B XF:4 YA1−4 3 B
XC028:22 EA2 1 B XC080:32 ID3 1 C XC200:19 CA1−1 2 B XF:12 YA1−4 3 B
XC070:1 FB2 2 D XC080:33 ID3 1 C XC200:20 CA1−1 1 B XF:15 FA1−1 1 B
XC070:2 FB2 2 D XC080:34 BD1−2 3 B XC200:21 CE2 1 B XF:18 YA1−1 3 B
XC070:3 FB2 2 D XC080:34 CB1−1 2 C XC200A:1 AA2 4 D XG:1 AA2 4 A
XC070:4 FD1 1 C XC080:37 XH1 1 D XC200B:1 CI1 2 A XG:1 YA1−1 4 B
XC070:7 EB1 2 D XC080:38 XH1 1 D XC200F:1 AC1 0 A XH:1 AB2 3 B
XC070:8 EB1 2 D XC080:39 XB1 3 B XC200G:1 AC1 0 A XJ:1 OG1 2 B
XC070:9 EA1−2 1 C XC080:40 XB1 3 B XC300:5 CI1 1 B XJ:2 OG1 3 B
XC070:10 EA1−2 2 C XC080:43 BE1 1 D XC300:8 CI1 3 C XJ:11 BF1 1 A
XC070:11 EA1−2 2 C XC080:43 BE2 2 C XC300:21 CI1 1 B XJ:11 JD2 3 B
XC070:12 EA1−2 2 C XC080:44 BE1 2 D XC300A:1 CI1 2 C XK:3 OG1 1 B
XC080:44 BE2 2 C XC300D:1 CI1 2 B XK:3 OH1 2 A
1

1
XC070:13 EA2 1 C
XC070:14 EA2 1 C XC080:45 BE1 2 D XC300G:1 CI1 1 C XK:6 OG1 3 B
XC070:15 EA2 1 C XC080:45 BE2 2 C XC:1 ZA1 0 C XK:9 DA1 2 B
XC070:16 EA2 2 C XC080:46 BE1 2 D XC:2 BA1 1 E XK:12 DA1 1 B
XC070:17 FA3 1 C XC080:47 XJ1 1 C XC:2 ZA1 0 C XK:14 YA1−5 2 B
XC070:18 FA3 1 C XC080:48 XJ1 1 C XC:3 BB1 2 D XL:1 BA1 0 B
XC070:19 FA3 1 C XC080:54 FB4 1 C XC:3 ZA1 0 C XL:3 BA1 1 B
XC070:20 FA3 2 C XC080:57 AD1 2 C XC:4 ZA1 0 C XL:4 EF1 2 B
XC070:21 FA3 3 C XC080:58 DA1 1 C XC:5 EA1−1 1 D XL:5 BA1 1 B
XC070:22 FA3 3 C XC080:58 DA2−1 1 C XC:5 ZA1 0 C XL:7 DA1 3 B
XC070:23 FA3 3 C XC080:59 DA2−1 2 C XC:6 EA1−1 1 D XL:8 BD1−1 2 A
XC070:24 FA3 1 C XC094A:3 FC2−1 2 B XC:6 ZA1 0 C XL:8 BE1 1 A
XC070:25 FA3 1 C XC096:1 FC2−1 2 C XC:7 FA1−1 1 D XL:8 BG1 2 A
XC070:26 FA3 2 C XC100:2 YA1−2 4 B XC:7 ZA1 0 C XM:1 AB2 4 B
XC070:27 FA3 2 C XC100:6 AC1 2 A XC:8 FA1−1 1 D XM:2 AB2 4 B
XC070:28 EA2 3 C XC100:8 AA2 3 D XC:8 ZA1 0 C XM:3 AB2 4 B
XC070:29 EA2 3 C XC100:9 YA1−2 4 B XC:9 GA1 0 D XM:4 AB2 4 B
XC070:30 EA2 3 C XC100:11 AA2 3 D XC:9 ZA1 0 C XM:11 AB2 3 B
XC070:31 FA5 1 C XC100:12 AA2 4 B XC:10 GA1 0 D XM:18 BD1−1 2 A
XC080:1 GD2−2 2 C XC100:13 YA1−2 3 B XC:10 ZA1 0 C XM:18 BD1−2 1 A
XC080:2 GD2−2 2 C XC100:15 AB2 1 A XC:11 ZA1 0 C XM:18 BG1 2 A
2

2
XC080:3 GC1−2 1 C XC100:15 BE1 1 A XC:12 ZA1 0 C XO:1 AA2 4 A
XC080:4 GC1−2 2 C XC100:16 AD1 2 B XCB604M:1 CF1 2 C XS:1 AB2 4 B
XC080:5 GD1 1 D XC100B:1 AA2 3 B XCB604M:3 CF1 2 D XT:1 AA2 4 A
XC080:6 GD1 2 D XC100C:1 AA2 3 B XD:1 AB2 0 B
XC080:7 GB2 2 D XC100F:1 AA2 4 B XD:1 ZA1 0 B
XC080:8 GD3 2 C XC100G:1 AA2 4 C XD:2 AB2 2 C
XC080:9 GC1−2 2 C XC200:2 ID1 2 B XD:2 ZA1 0 B
XC080:10 GC1−2 2 C XC200:2 ID3 3 B XD:3 AB2 4 B
XC080:11 GC2 2 C XC200:6 FD1 2 B XD:3 ZA1 0 B
XC080:12 GC2 2 C XC200:7 VD4 2 B XD:4 ZA1 0 B
XC080:13 XA1 3 C XC200:8 CA1−1 2 B XD:5 ZA1 0 B
XC080:14 XA1 3 C XC200:10 CA1−1 1 B XD:6 ZA1 0 B
XC080:15 AC1 2 B XC200:11 FD1 2 B XD:7 ZA1 0 B
3

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 13(44)

D

A
C

B
E
 D

A
C

B
E
SPLICES
0

0
SPLICE PAGE SPLICE PAGE
XCB604M_1−3 ( ) CF1 2 D XS−2042_04 ( ) FB1 2 B
XS−0022_01 ( ) EF1 2 C XS−2042_04 ( ) FB4 1 B
XS−0095_01 ( ) CB1−4 0 B XS−2050_01 ( ) CB1−2 1 C
XS−0178_01 ( ) AB2 0 C XS−2050_01 ( ) EH3 2 B
XS−0190_01 ( ) FA1−2 1 B XS−2077_01 ( ) FA3 2 C
XS−0190_01 ( ) FA2 1 C XS−2078_01 ( ) FA3 3 C
XS−0202_01 ( ) FA5 1 C XS−2096_01 ( ) CB1−4 4 C
XS−1020_01 ( ) EA1−2 3 E XS−2097_01 ( ) CB1−4 1 C
XS−1021_01 ( ) BD1−3 3 D XS−2097_01 ( ) EH3 1 B
XS−1021_01 ( ) EA1−1 3 D XS−2098_01 ( ) CB1−4 1 C
XS−1021_02 ( ) BD1−3 2 B XS−3006_01 ( ) GC1−2 2 B
XS−1021_02 ( ) EA1−1 2 C XS−3007_01 ( ) GC1−2 2 B
XS−1021_02 ( ) YA1−6 2 C XS−3008_02 ( ) GD1 1 D
XS−1022_01 ( ) AC1 2 C XS−3009_02 ( ) GD1 2 C
XS−1023_01 ( ) CA1−2 1 B XS−3010_01 ( ) GD3 2 C
XS−1023_01 ( ) CF1 2 D XS−3012_01 ( ) GD2−2 2 C
XS−1024_01 ( ) BI1 2 C XS−3013_01 ( ) GD2−2 2 C
XS−1037_01 ( ) FA3 2 D XS−3014_01 ( ) GD2−1 2 C
XS−1038_01 ( ) FA3 3 C XS−3014_02 ( ) GD2−1 0 C
XS−3015_01 ( ) GD2−1 2 C
1

1
XS−1050_01 ( ) CB1−2 3 C
XS−1050_01 ( ) EH3 3 B XS−3015_02 ( ) GD2−1 4 C
XS−1050_02 ( ) CB1−2 2 D XS−3026_01 ( ) GB2 2 D
XS−1051_01 ( ) CB1−2 1 C XS−3027_01 ( ) GC2 2 C
XS−1051_01 ( ) CB1−4 2 C XS−3027_03 ( ) YA1−3 3 B
XS−1051_01 ( ) EH3 2 B XS−3027_04 ( ) GC2 0 C
XS−1051_03 ( ) CB1−4 2 D XS−3028_01 ( ) GC2 2 C
XS−2002_01 ( ) AA2 2 A XS−3028_03 ( ) GC2 4 C
XS−2002_02 ( ) AA2 2 A XS−3028_04 ( ) GC1−1 3 C
XS−2002_03 ( ) YA1−2 3 C XS−3029_01 ( ) GC1−1 2 C
XS−2003_01 ( ) AC1 2 C XS−3032_01 ( ) GB1−1 3 C
XS−2003_02 ( ) BD1−1 2 C XS−3032_02 ( ) GB1−2 3 D
XS−2003_02 ( ) BD1−2 1 B XS−4002_01 ( ) OH1 2 C
XS−2003_02 ( ) BG1 2 C XS−4002_02 ( ) OH1 3 C
XS−2003_03 ( ) BF1 1 B XS−5004_01 ( ) AB2 2 C
XS−2003_04 ( ) DA2−1 1 B XS−5006_01 ( ) ID3 3 E
XS−2003_05 ( ) DA2−1 1 D XS−5006_02 ( ) YA1−4 2 C
XS−2003_06 ( ) EA1−1 1 C XS−6001_01 ( ) AB2 1 C
XS−2003_08 ( ) ID1 2 B XS−6001_01 ( ) BF1 2 B
XS−2003_08 ( ) ID3 3 C XS−6001_01 ( ) EB1 2 A
XS−2003_10 ( ) JA1 1 C XS−6001_01 ( ) GA1 3 B
2

2
XS−2003_11 ( ) BF1 1 B XS−6001_01 ( ) JA1 3 C
XS−2003_11 ( ) JD2 3 B XS−6001_01 ( ) JB1 1 B
XS−2003_13 ( ) BC1 1 C XS−6001_01 ( ) VA2 4 D
XS−2003_14 ( ) FC2−2 2 C XS−6001_02 ( ) ED1 1 B
XS−2003_15 ( ) JE1 1 B XS−6001_02 ( ) EH1 1 B
XS−2003_15 ( ) JF1 2 B XS−6001_02 ( ) FA2 1 C
XS−2004_01 ( ) AB2 4 B XS−6001_02 ( ) FA5 2 C
XS−2004_02 ( ) AB2 4 D XS−6001_02 ( ) GA1 3 B
XS−2004_03 ( ) AC1 2 B XS−6002_01 ( ) ID3 1 D
XS−2004_04 ( ) BD1−1 2 C XS−7052_01 ( ) AC1 2 C
XS−2004_04 ( ) BE1 1 B XS−GND_01 ( ) DA2−1 2 D
XS−2004_04 ( ) BG1 2 C XS−GND_03 ( ) JA1 1 C
XS−2004_05 ( ) BD1−2 3 B XSC−7001_01 ( ) XA1 1 A
XS−2004_06 ( ) BD1−2 3 B XSC−7001_02 ( ) XA1 2 A
XS−2004_06 ( ) CB1−1 2 C XSC−7001_03 ( ) XA1 2 A
XS−2004_07 ( ) DA2−1 2 B XSC−7001_04 ( ) XA1 3 A
XS−2004_07 ( ) DA2−2 2 B XSC−7001_05 ( ) XA1 3 A
XS−2004_09 ( ) JE1 2 B XSC−7001_06 ( ) XA1 5 A
XS−2004_18 ( ) AB2 4 B XSC−7001_07 ( ) XA1 5 C
XS−2004_18 ( ) EB1 2 A XSC−7001_08 ( ) XA1 4 C
XS−2004_18 ( ) ED1 1 B XSC−7001_09 ( ) XA1 4 C
3

3
XS−2004_18 ( ) EH1 1 B XSC−7001_10 ( ) XA1 2 C
XS−2004_18 ( ) FA2 3 C XSC−7001_11 ( ) XA1 2 C
XS−2004_18 ( ) GA1 1 A XSC−7001_12 ( ) XA1 3 C
XS−2004_18 ( ) VA2 4 C XSC−7002_01 ( ) XA1 1 A
XS−2005_02 ( ) JA1 1 C XSC−7002_02 ( ) XA1 2 A
XS−2005_03 ( ) OG1 1 C XSC−7002_03 ( ) XA1 2 A
XS−2005_03 ( ) OH1 2 B XSC−7002_04 ( ) XA1 3 A
XS−2005_04 ( ) OH1 1 C XSC−7002_05 ( ) XA1 3 A
XS−2005_06 ( ) JD2 4 B XSC−7002_06 ( ) XA1 5 A
XS−2005_06 ( ) JF1 2 B XSC−7002_07 ( ) XA1 5 C
XS−2018_01 ( ) CB1−3 1 B XSC−7002_08 ( ) XA1 4 C
XS−2018_01 ( ) CB1−5 2 C XSC−7002_09 ( ) XA1 4 C
XS−2040_01 ( ) BI1 2 C XSC−7002_10 ( ) XA1 2 C
XS−2042_01 ( ) CA1−1 1 C XSC−7002_11 ( ) XA1 2 C
XS−2042_02 ( ) CA1−1 2 C XSC−7002_12 ( ) XA1 4 C
XS−2042_03 ( ) CA1−1 2 C XSC−7003_01 ( ) XB1 1 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 14(44)

D

A
C

B
E
 D

A
C

B
E
0

0
SPLICE PAGE SPLICE PAGE
XSC−7003_02 ( ) XB1 3 B XSCG1−31 (Low Current Ground) DA1 2 D
XSC−7003_03 ( ) XB1 3 B XSCG1−31 (Low Current Ground) DA2−1 3 D
XSC−7003_04 ( ) XB1 5 B XSCG1−31 (Low Current Ground) DA2−2 3 D
XSC−7003_05 ( ) XB1 1 B XSCG1−31 (Low Current Ground) FC2−2 2 E
XSC−7003_06 ( ) XB1 2 B XSCG1−31 (Low Current Ground) JA1 0 B
XSC−7003_07 ( ) XB1 2 B XSCG1−31 (Low Current Ground) VA2 3 C
XSC−7004_01 ( ) XB1 1 B XSCG1−31 (Low Current Ground) ZA1 1 B
XSC−7004_02 ( ) XB1 3 B XSCG1−32 ( ) AB2 1 D
XSC−7004_03 ( ) XB1 3 B XSCG1−32 ( ) EB1 2 B
XSC−7004_04 ( ) XB1 5 B XSCG1−32 ( ) GA1 3 E
XSC−7004_05 ( ) XB1 1 B XSCG1−32 ( ) ZA1 1 B
XSC−7004_06 ( ) XB1 2 B XSCG1−33 ( ) ED1 1 C
XSC−7004_07 ( ) XB1 2 B XSCG1−33 ( ) EH1 1 B
XSC−7007_01 ( ) XD1 2 A XSCG1−33 ( ) FA2 1 D
XSC−7007_02 ( ) XD1 3 A XSCG1−33 ( ) FA5 2 D
XSC−7008_01 ( ) XD1 3 A XSCG1−33 ( ) GA1 1 B
XSC−7008_02 ( ) XD1 3 A XSCG1−33 ( ) ZA1 1 B
XSC−7011_02 ( ) XH1 3 A XSCG1−34 ( ) BC1 1 D
XSC−7011_03 ( ) XH1 4 A XSCG1−34 ( ) JD2 4 D
XSCG1−34 ( ) JF1 2 C
1

1
XSC−7011_04 ( ) XH1 5 C
XSC−7011_05 ( ) XH1 3 C XSCG1−34 ( ) ZA1 1 B
XSC−7011_06 ( ) XH1 2 C XSCG1−36 ( ) BD1−1 1 E
XSC−7012_02 ( ) XH1 3 A XSCG1−36 ( ) BG1 2 D
XSC−7012_03 ( ) XH1 4 A XSCG1−36 ( ) EG1 2 E
XSC−7012_04 ( ) XH1 5 B XSCG1−36 ( ) JE1 1 C
XSC−7012_05 ( ) XH1 3 B XSCG1−36 ( ) ZA1 1 B
XSC−7012_06 ( ) XH1 2 B XSCG2−21 (Medium current ground) AA2 4 C
XSC−7013_01 ( ) XF1 1 A XSCG2−21 (Medium current ground) CE1 2 D
XSC−7013_02 ( ) XF1 2 A XSCG2−21 (Medium current ground) FA1−2 1 D
XSC−7013_04 ( ) XF1 4 A XSCG2−21 (Medium current ground) FC2−1 2 E
XSC−7013_05 ( ) XF1 3 A XSCG2−21 (Medium current ground) ZA1 3 C
XSC−7013_06 ( ) XF1 4 C XSCG5−21 (Medium current ground) FA3 1 D
XSC−7014_01 ( ) XF1 1 B XSCG5−21 (Medium current ground) FA5 1 E
XSC−7014_02 ( ) XF1 2 B XSCG5−21 (Medium current ground) ZA1 3 C
XSC−7014_04 ( ) XF1 4 B XSCG5−31 (Low Current Ground) EB1 2 E
XSC−7014_05 ( ) XF1 3 B XSCG5−31 (Low Current Ground) FD1 1 D
XSC−7015_01 ( ) XE1−1 1 B XSCG5−31 (Low Current Ground) ZA1 3 B
XSC−7015_02 ( ) XE1−1 3 B XSCG6−11 (High current ground) ZA1 4 D
XSC−7015_03 ( ) XE1−1 4 B XSCG6−21 (Medium current ground) AC1 3 D
XSC−7015_04 ( ) XE1−1 2 B XSCG6−21 (Medium current ground) CE2 1 D
2

2
XSC−7015_05 ( ) XE1−1 3 B XSCG6−21 (Medium current ground) DA1 1 C
XSC−7016_01 ( ) XE1−1 2 B XSCG6−21 (Medium current ground) FD1 2 D
XSC−7016_02 ( ) XE1−1 4 B XSCG6−21 (Medium current ground) GC2 1 D
XSC−7016_03 ( ) XE1−1 4 B XSCG6−21 (Medium current ground) ZA1 4 C
XSC−7016_04 ( ) XE1−1 3 B XSCG6−22 (Medium current ground) CA1−2 4 D
XSC−7016_05 ( ) XE1−1 3 B XSCG6−22 (Medium current ground) CA1−3 1 C
XSC−7017_01 ( ) XM1 2 B XSCG6−22 (Medium current ground) ZA1 4 C
XSC−7018_01 ( ) XM1 2 B XSCG6−23 (Medium current ground) CB1−1 1 E
XSC−7021_01 ( ) XE1−2 1 B XSCG6−23 (Medium current ground) CB1−3 1 D
XSC−7022_01 ( ) XE1−2 1 C XSCG6−23 (Medium current ground) CB1−5 2 C
XSC−7044_01 ( ) XJ1 2 A XSCG6−23 (Medium current ground) ZA1 4 C
XSC−7045_01 ( ) XJ1 2 B XSCG6−31 ( ) AC1 1 E
XSC−7097_01 ( ) XO1 2 C XSCG6−31 ( ) CA1−1 2 B
XSC−7097_02 ( ) XO1 3 B XSCG6−31 ( ) CI1 3 D
XSC−7098_01 ( ) XO1 2 C XSCG6−31 ( ) FB4 3 D
XSC−7098_02 ( ) XO1 3 B XSCG6−31 ( ) FD1 2 D
XSCG−EXTL−21 (Medium current ground) ZA1 2 C XSCG6−31 ( ) ZA1 4 B
XSCG−EXTL−31 ( ) GB1−1 1 B XSCG6−32 ( ) GB2 3 D
XSCG−EXTL−31 ( ) GB1−2 0 B XSCG6−32 ( ) GC1−2 4 D
XSCG−EXTL−31 ( ) GB2 1 A XSCG6−32 ( ) ZA1 4 B
XSCG−EXTL−31 ( ) ZA1 2 B XSCG6−33 ( ) GB2 0 D
3

3
XSCG−EXTL−32 ( ) GB1−1 2 B XSCG6−33 ( ) GC1−2 0 D
XSCG−EXTL−32 ( ) GB1−2 3 B XSCG6−33 ( ) ZA1 4 B
XSCG−EXTL−32 ( ) GB2 2 A
XSCG−EXTL−32 ( ) ZA1 2 B
XSCG−EXTL−33 ( ) GC1−1 1 B
XSCG−EXTL−33 ( ) GD2−1 0 C
XSCG−EXTL−33 ( ) ZA1 2 B
XSCG−EXTL−34 ( ) GB1−2 2 C
XSCG−EXTL−34 ( ) ZA1 3 B
XSCG1−21 ( ) ZA1 1 C
XSCG1−22 ( ) OG1 3 D
XSCG1−22 ( ) OH1 2 C
XSCG1−22 ( ) ZA1 1 C
XSCG1−31 (Low Current Ground) BE1 1 C
XSCG1−31 (Low Current Ground) BE2 2 C
XSCG1−31 (Low Current Ground) BF1 1 E

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 15(44)

D

A
C

B
E
 D

A
C

B
E
SHELLS
0

0
REF PARTNUMBER PAGE REF PARTNUMBER PAGE
A03 {part_no mating_978309} BD1−1 1 D A27 GC1−1 2 D
A03 {part_no mating_978309} BD1−2 2 D A27 GC1−2 2 A
A03 {part_no mating_978309} BD1−3 3 B A27 GC2 2 A
A03 {part_no mating_978309} EA1−1 3 B A27 GD1 2 B
A03 {part_no mating_978309} EB1 2 C A27 GD2−1 2 D
A03 {part_no mating_978309} GA1 3 B A27 GD2−2 2 A
A03 {part_no mating_978309} GC2 1 A A27 GD3 2 B
A03 {part_no mating_978309} JB1 2 B A27 OG1 3 C
A03 {part_no mating_978309} XA1 4 D A27 OH1 3 D
A03 {part_no mating_978309} XE1−1 4 C A27 XA1 3 B
A03 {part_no mating_978309} XH1 2 C A27 XH1 4 B
A03 {part_no mating_978309} YA1−3 3 C A27 YA1−1 2 B
A03 {part_no mating_978309} YA1−4 3 C A27 YA1−3 1 B
A03 {part_no mating_978309} YA1−6 2 C A27 YA1−5 3 B
A07 {part_no mating_20429800} JA1 1 D A33 BE1 1 B
A07 {part_no mating_20429800} XE1−1 3 C A33 JE1 2 B
A07 {part_no mating_20429800} XH1 1 C A33 XE1−1 5 C
A13A *opt* DA1 1 D A33 YA1−4 4 C
A13A *opt* XA1 1 E A36 {part_no mating_20409352} AA2 3 E
1

1
A13A *opt* XB1 4 D A36 {part_no mating_20409352} AB2 0 E
A13A *opt* XC1 2 C A36 {part_no mating_20409352} AD1 2 A
A16 FA1−1 1 C A36 {part_no mating_20409352} BB1 2 C
A16 FA1−2 2 B A36 {part_no mating_20409352} EA2 3 A
A16 FA2 3 B A36 {part_no mating_20409352} EG1 2 B
A16 FA3 2 A A36 {part_no mating_20409352} FD1 1 B
A16 FA5 2 B A36 {part_no mating_20409352} ID3 2 B
A16 XA1 3 B A36 {part_no mating_20409352} VA2 4 E
A16 XH1 3 B A36 {part_no mating_20409352} VD4 1 B
A16 YA1−6 3 B A36 {part_no mating_20409352} XA1 1 B
A17 {part_no mating_978310} AB2 4 E A36 {part_no mating_20409352} XF1 1 C
A17 {part_no mating_978310} AC1 4 C A36 {part_no mating_20409352} XH1 3 B
A17 {part_no mating_978310} BA1 1 D A36 {part_no mating_20409352} YA1−4 2 B
A17 {part_no mating_978310} BE1 2 A A36 {part_no mating_20409352} YA1−5 1 B
A17 {part_no mating_978310} BE2 2 A A41 *opt* EH3 1 D
A17 {part_no mating_978310} BH2 2 B A79 {part_no mating_978309} DA1 2 C
A17 {part_no mating_978310} BI1 2 A A79 {part_no mating_978309} XA1 4 D
A17 {part_no mating_978310} CA1−1 3 C A79 {part_no mating_978309} XH1 3 C
A17 {part_no mating_978310} CE1 1 C A80 *opt* FB1 2 C
A17 {part_no mating_978310} CE2 2 C A125 JE1 1 C
A17 {part_no mating_978310} EF1 2 E A125 XB1 2 C
2

2
A17 {part_no mating_978310} EG1 2 B A125 XE1−1 3 C
A17 {part_no mating_978310} EH1 2 D A125 XH1 2 C
A17 {part_no mating_978310} FB1 2 E A132 {part_no mating_9521501} BF1 1 D
A17 {part_no mating_978310} FB2 2 B A132 {part_no mating_9521501} XF1 4 C
A17 {part_no mating_978310} FB4 2 B A163 AC1 2 B
A17 {part_no mating_978310} GD1 2 A A163 CI1 1 B
A17 {part_no mating_978310} XA1 2 B A163 FB4 3 C
A17 {part_no mating_978310} XE1−1 1 C A163 XB1 3 C
A17 {part_no mating_978310} XH1 2 B A174 {part_no mating_20429843} CB1−1 1 D
A17 {part_no mating_978310} YA1−4 1 B A174 {part_no mating_20429843} CB1−2 3 B
A17 {part_no mating_978310} YA1−6 3 B A174 {part_no mating_20429843} CB1−3 1 B
A19_A {part_no 70305037} DA2−2 2 D A174 {part_no mating_20429843} CB1−4 4 A
A19_A {part_no 70305037} XJ1 3 C A174 {part_no mating_20429843} CB1−5 2 C
A19C {part_no 978308} DA1 3 E A174 {part_no mating_20429843} EH3 2 A
A21 EA1−1 1 C A174 {part_no mating_20429843} XA1 2 D
A21 EA1−2 2 A A174 {part_no mating_20429843} XB1 3 C
A21 EA2 1 A A174 {part_no mating_20429843} XD1 2 B
A21 EB1 2 C A176 {part_no mating_21422277} VA2 1 B
A21 EC1 2 A A176 {part_no mating_21422277} XM1 2 C
A21 ED1 1 D A190 {part_no mating_993655} CB1−4 2 E
A21 XA1 2 B A195 {part_no mating_978310} BC1 1 C
3

3
A21 XH1 3 B A195 {part_no mating_978310} EF1 2 E
A21 YA1−4 2 B A195 {part_no mating_978310} FB4 1 D
A22 {part_no mating_978308} JF1 2 C A195 {part_no mating_978310} VA2 3 B
A22 {part_no mating_978308} XA1 5 B A195 {part_no mating_978310} XF1 2 C
A22 {part_no mating_978308} XE1−2 0 C A195 {part_no mating_978310} XG1 2 C
A22 {part_no mating_978308} XH1 5 C A195 {part_no mating_978310} XH1 4 C
A26 {part_no 21138410} VA2 0 C A200 {part_no mating_21237814} DA2−1 1 D
A26 {part_no 21138410} XA1 3 D A200 {part_no mating_21237814} XA1 2 D
A26 {part_no 21138410} XB1 1 C A200 {part_no mating_21237814} XH1 1 E
A26 {part_no 21138410} XM1 1 C A200 {part_no mating_21237814} XJ1 0 D
A27 AA2 1 E A201 {part_no mating_978309} JD2 1 C
A27 AB2 3 E A201 {part_no mating_978309} XE1−1 2 C
A27 GA1 2 C A201 {part_no mating_978309} XE1−2 1 C
A27 GB1−1 2 E A201 {part_no mating_978309} XF1 4 C
A27 GB1−2 2 E A201 {part_no mating_978309} XH1 5 C
A27 GB2 2 B A224 {part_no 3987479} VA2 3 C

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 16(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF PARTNUMBER PAGE REF PARTNUMBER PAGE
A234 {part_no mating_978310} FC2−2 2 D E11RA *opt* GC2 4 B
A234 {part_no mating_978310} XB1 2 C E11RB *opt* GC2 3 E
A234 {part_no mating_978310} XF1 3 D E13LS *opt* GC1−1 1 B
A234 {part_no mating_978310} XO1 2 D E13LS2 *opt* GC1−2 1 E
A235 {part_no 994044} FC2−1 2 D E13RL *opt* GC1−2 2 D
A235 {part_no 994044} XO1 3 D E13RS *opt* GC1−1 4 B
B03 {part_no mating_20813785} EA1−1 1 B E13RS2 *opt* GC1−2 3 E
B06 {part_no 3944972} FB2 2 D E21LR *opt* GB2 1 E
B07 {part_no 3944972} BD1−3 3 C E21R *opt* GB2 2 E
B12 {part_no 1079282} BE1 1 E E21RR *opt* GB2 3 E
B12 {part_no 1079282} BE2 2 D E23L *opt* ID3 0 D
B13B {part_no 874955} EA1−2 0 D E23R *opt* ID3 1 D
B14B {part_no 874955} EA1−2 1 D E27L *opt* GC1−2 1 D
B15 {part_no 874955} EA1−2 2 D E27L *opt* GD1 0 E
B16 {part_no 874955} EA1−2 2 D E27L *opt* GD2−2 1 D
B22 {part_no 1307049} BD1−3 2 D E27L *opt* GD3 1 D
B25 {part_no 1096614} BI1 2 D E27R *opt* GC1−2 4 D
B28 {part_no 3944972} FA1−2 2 D E27R *opt* GD1 3 E
B29 {part_no 3944972} FA3 3 D E27R *opt* GD2−2 3 D
E27R *opt* GD3 3 D
1

1
B30 {part_no 3944972} FA3 3 D
B32 {part_no 3944972} CA1−3 2 C E83L *opt* GB1−1 1 A
B39 {part_no 3944972} CA1−2 1 C E83L *opt* GB1−2 1 A
B40A {part_no 984431} EA1−2 0 D E83L *opt* GC1−1 2 B
B40B {part_no 984431} EA1−2 0 D E83L *opt* GD2−1 2 B
B42 {part_no 984431} EA1−2 1 D E83R *opt* GB1−1 2 A
B43 {part_no 984431} EA1−2 1 D E83R *opt* GB1−2 3 A
B49 {part_no mating_20383174} EC1 2 D E83R *opt* GC1−1 3 B
B50 {part_no 990704} EC1 2 D E83R *opt* GD2−1 2 B
B52 {part_no mating_20734604} CA1−2 0 C E111 {part_no 20938696} VA2 0 D
B56 {part_no 3944972} FA1−2 2 C E136 CI1 1 D
B57 {part_no 3944972} FA3 2 C E137 CI1 2 D
B58 {part_no 3944972} FA3 2 C F01 *opt* EF1 2 A
B69 {part_no 3944972} EH3 2 D F03 *opt* YA1−4 3 A
B85 {part_no 993669} CB1−2 1 C F05 *opt* BD1−1 2 A
B96A {part_no mating_990051} CB1−3 1 C F05 *opt* BD1−2 1 A
B96A {part_no mating_990051} XD1 2 B F05 *opt* BG1 2 A
B96B {part_no mating_993444} CB1−3 2 C F06 *opt* AC1 4 B
B96B {part_no mating_993444} XD1 3 B F06 *opt* BA1 1 B
B97 {part_no 993671} CB1−2 2 C F06 *opt* CA1−1 3 B
B98 {part_no 993670} CB1−2 2 C F06 *opt* CE2 2 B
2

2
B115 {part_no mating_990052} CB1−2 1 C F06 *opt* FB1 3 B
B142B {part_no 21106105} CB1−4 4 D F06 *opt* FB4 2 B
B152 {part_no 3944972} EA1−1 3 D F07 *opt* BA1 1 B
B153 {part_no 3944972} EA1−1 3 D F08 *opt* BD1−1 2 A
B238 {part_no mating_21511728} VA2 2 B F08 *opt* BE1 1 A
B238 {part_no mating_21511728} XM1 3 C F08 *opt* BG1 2 A
B250 {part_no 993364} AA2 1 D F11 *opt* DA1 2 B
B262 {part_no 993361} CB1−4 3 C F12 *opt* DA1 1 B
B263 {part_no mating_995701} CB1−4 3 C F13 *opt* OG1 3 A
B274 {part_no 3944972} BD1−2 3 C F13 *opt* OH1 2 A
B275B {part_no 3944972} BD1−2 3 C F14 *opt* YA1−5 2 A
B276 {part_no 3944972} FD1 1 D F20 *opt* BF1 1 A
B278 {part_no 3944972} EA2 3 D F20 *opt* JD2 3 A
B279 {part_no 3944972} BD1−3 3 C F23 *opt* FA1−1 2 A
B280A {part_no mating_22656871} CF1 2 B F28 *opt* EA1−1 1 A
B280B {part_no mating_22656871} CF1 2 B F30 *opt* AB2 3 B
B281 {part_no mating_22656871} CF1 2 C F35 *opt* YA1−1 4 A
B291L *opt* EA2 1 D F36 *opt* YA1−1 3 C
B291R *opt* EA2 1 D F38 *opt* GA1 1 A
B292L *opt* EA2 1 D F39 *opt* JD2 4 A
B292R *opt* EA2 2 D F39 *opt* JF1 2 A
3

3
B307 {part_no mating_21577478} CB1−5 2 D F42 *opt* VA2 4 A
B349 VD4 1 D F43 *opt* CE1 2 B
D1 {part_no mating_949597} EG1 2 C F46 *opt* YA1−2 0 A
E06 *opt* GD3 2 D F48 *opt* EA1−1 1 A
E07L {part_no mating_25002508} GB2 2 A F49 *opt* FA1−1 1 A
E07R {part_no mating_25002508} GB2 2 A F50 *opt* FC2−2 2 B
E08FSL1 *opt* GD2−1 0 B F51 *opt* BB1 2 A
E08FSL2 *opt* GD2−1 0 B F52 *opt* YA1−2 0 A
E08FSL3 *opt* GD2−1 1 E F53 *opt* DA2−1 1 A
E08FSR1 *opt* GD2−1 4 B F54 *opt* JE1 1 A
E08FSR2 *opt* GD2−1 4 B F54 *opt* JF1 2 A
E08FSR3 *opt* GD2−1 4 E F55 *opt* BC1 2 A
E09 *opt* GD1 1 E F57 *opt* DA1 3 A
E09R *opt* GD1 2 E F57 *opt* DA2−1 2 A
E11LA *opt* GC2 0 B F57 *opt* DA2−2 2 A
E11LB *opt* GC2 0 E F59 *opt* AB2 4 A

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 17(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF PARTNUMBER PAGE REF PARTNUMBER PAGE
F60 *opt* YA1−4 4 A K80 {part_no mating_8141996} AB2 2 C
F61 *opt* JE1 2 A K81 {part_no mating_8141996} AB2 0 B
F62 *opt* BD1−2 3 A K84 {part_no mating_8141996} EF1 2 B
F62 *opt* CB1−1 2 A K85 *opt* OH1 1 D
F63 *opt* BC1 1 A K102 *opt* AA2 4 B
F64 *opt* VA2 3 A K103 {part_no mating_8141996} AA2 3 C
F67 *opt* JA1 1 A K106 {part_no stud_M10} CI1 1 C
F68 *opt* AB2 2 A K107 {part_no stud_M10} CI1 2 C
F74 *opt* OH1 1 A K200 {part_no mating_8141996} AC1 2 A
F77 *opt* GA1 0 A K200 {part_no mating_8141996} BA1 3 A
F78 *opt* GA1 0 A K200 {part_no mating_8141996} CE2 1 B
F79 *opt* GA1 0 A K201 {part_no mating_8141996} BA1 2 A
F80 *opt* GA1 0 A K201 {part_no mating_8141996} CA1−1 2 A
F81 *opt* GA1 0 A K201 {part_no mating_8141996} FB1 2 A
F82 *opt* GA1 1 A K201 {part_no mating_8141996} FB4 1 A
F84 *opt* JD2 4 A K202 {part_no mating_8141996} FD1 2 B
F85 *opt* JA1 1 A K401 {part_no mating_8141996} VA2 3 B
F86 *opt* BD1−1 1 A K402 {part_no mating_8141996} VA2 3 B
F87 *opt* AB2 0 A M01 {part_no dummy_socket} OG1 1 D
M02 *opt* OH1 2 D
1

1
F88 *opt* FC2−1 2 B
F89 *opt* YA1−3 3 B M03 *opt* OH1 1 D
F90 *opt* YA1−3 3 B M04 *opt* AD1 1 D
F100 *opt* AA2 4 C R06 {part_no 1079282} CE2 1 C
F101 *opt* AA2 4 B R56 {part_no 993380} CB1−4 0 D
F104 *opt* AA2 3 B R57 {part_no 994228} CB1−4 1 D
F108 *opt* YA1−2 4 A R66 {part_no 984849} XA1 1 A
F109 *opt* AD1 2 A R67 {part_no Free_end} XB1 1 B
F110 *opt* YA1−2 3 A R88 {part_no 984849} XE1−2 3 C
F115 *opt* AB2 1 A R89 {part_no mating_free_end_terminal} VA2 4 D
F115 *opt* BE1 1 A R91 {part_no 984849} XO1 4 B
F118 *opt* YA1−2 4 A S01 {part_no mating_978308} GA1 2 B
F120 *opt* AC1 2 A S02 {part_no mating_9456277} BH2 2 D
F121 *opt* AA2 3 B S02 {part_no mating_9456277} GA1 3 D
F200 *opt* AC1 0 A S06 {part_no 20367824} BD1−2 0 C
F201 *opt* AC1 0 A S06 {part_no 20367824} OG1 1 B
F206 *opt* CI1 2 A S06 {part_no 20367824} OH1 2 B
F207 *opt* AA2 4 D S08 EB1 2 B
F208 *opt* AC1 2 B S11 FA5 2 D
F209 *opt* CE2 1 B S12 AB2 1 C
F210 *opt* CA1−1 1 B S14A *opt* YA1−2 1 C
2

2
F211 *opt* CA1−1 2 B S14B *opt* YA1−2 2 C
F212 *opt* CA1−1 2 B S15 {part_no mating_1598668} AB2 3 C
F213 *opt* CA1−1 2 B S16 *opt* YA1−2 2 C
F214 *opt* FB1 2 B S24 {part_no 20367822} EH1 2 B
F214 *opt* FB4 1 B S31 ED1 2 B
F215 *opt* CA1−1 1 B S32 ED1 1 B
F217 *opt* VD4 2 A S34 {part_no 981854} JB1 2 D
F218 *opt* ID1 2 A S41 {part_no stud_M10} AA2 3 C
F218 *opt* ID3 3 A S43 {part_no 3944972} EG1 2 D
F223 *opt* FD1 2 A S45 {part_no 1079282} EB1 2 E
F224 *opt* CB1−1 1 A S57L2 *opt* ID3 3 D
F300 *opt* CI1 1 C S57R2 *opt* ID3 4 D
F301 *opt* CI1 2 C S68 {part_no 993364} CA1−2 2 C
G01A {part_no stud_B} AA2 1 C S70 {part_no 3944972} FD1 2 D
G01B {part_no stud_M10} AA2 1 C S202 VA2 3 E
G02A *opt* AC1 0 C S304 FA2 2 D
G02B *opt* AC1 0 D S314 EH1 1 C
G02C *opt* AC1 0 D S315 {part_no 3944972} CA1−2 1 B
G10A {part_no stud_M6} AD1 2 D S316 {part_no 3944972} CA1−2 2 B
G10B {part_no stud_M10} AD1 2 D S321 {part_no 948995} DA2−2 2 C
H01 {part_no 8159013} YA1−2 1 D S322 {part_no mating_949597} AB2 1 B
3

3
H02 {part_no 8159013} YA1−2 1 E S322 {part_no mating_949597} YA1−1 0 B
K05 {part_no mating_8141996} OG1 3 B S324 BF1 2 C
K22 {part_no mating_8141996} AB2 3 A S325 FA2 3 C
K72 {part_no mating_8141996} AC1 4 A S348 VA2 3 E
K72 {part_no mating_8141996} BA1 1 A U03 {part_no 20846136} EA1−2 1 D
K72 {part_no mating_8141996} CA1−1 3 A U06 {part_no 3987480} JA1 1 B
K72 {part_no mating_8141996} CE1 1 A U08 {part_no mating_3987740} EA1−2 0 D
K72 {part_no mating_8141996} CE2 2 B U36 {part_no 20846136} EA2 1 D
K72 {part_no mating_8141996} FB1 3 A U37 {part_no 3987480} GB1−2 2 B
K72 {part_no mating_8141996} FB4 2 A U38 {part_no 993390} AD1 2 C
K73 {part_no mating_8141996} AB2 4 A V03 {part_no mating_949597} GB1−2 2 C
K74 {part_no mating_8141996} DA1 1 A V04 {part_no mating_949597} GB1−2 2 C
K75 {part_no mating_8141996} ID3 1 B V41 {part_no mating_949597} OG1 2 C
K75 {part_no mating_8141996} YA1−4 3 B V43 {part_no mating_949597} DA1 3 A
K76 {part_no mating_8141996} FA1−1 2 B X09 {part_no 20367821} YA1−2 1 C
K77 {part_no mating_8141996} YA1−1 3 B X43 {part_no mating_60110514} BG1 2 D

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 18(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF PARTNUMBER PAGE REF PARTNUMBER PAGE
X43 {part_no mating_60110514} XB1 1 C XCB721R {part_no 3963412} GD1 0 D
X43 {part_no mating_60110514} XH1 3 C XCB721R {part_no 3963412} GD2−2 1 C
X47 {part_no stud_M10} AA2 0 D XCB721R {part_no 3963412} GD3 1 D
X69 {part_no 3987479} DA2−1 3 C XCB722R {part_no mating_70328307} GB2 3 D
X69 {part_no 3987479} XA1 5 D XCB723R {part_no mating_70328307} GB2 1 D
X69 {part_no 3987479} XH1 5 C XCB801F *opt* GB2 2 C
X69 {part_no 3987479} XJ1 2 C XCB801F *opt* GC1−2 1 B
X130 {part_no 3987479} JA1 2 B XCB801F *opt* GC2 2 B
X132 {part_no 20383169} BF1 1 C XCB801F *opt* GD1 1 C
XCA020A AC1 1 C XCB801F *opt* GD2−2 2 B
XCA020A CA1−1 1 D XCB801F *opt* GD3 2 B
XCA020A CA1−2 0 D XCB801F *opt* ID3 1 B
XCA020A CF1 2 A XCB801F *opt* VD4 1 B
XCA020A XA1 1 D XCB801F *opt* XE1−1 1 C
XCA020A XB1 5 D XCB801F *opt* XG1 2 C
XCA020A XC1 2 C XCB801F *opt* YA1−3 1 C
XCA020A XD1 4 B XCB801F *opt* YA1−4 1 D
XCA020B CA1−2 0 A XCB801F *opt* YA1−7 0 B
XCA020B CA1−3 2 D XCB801x *opt* YA1−7 0 C
XCB803F *opt* YA1−5 0 D
1

1
XCA021 {part_no 20567733} BE1 1 D
XCA021 {part_no 20567733} BE2 2 D XCB803F *opt* YA1−6 0 D
XCA021 {part_no 20567733} DA1 1 D XCB805 GA1 1 D
XCA021 {part_no 20567733} DA2−1 1 D XCB805 GD2−1 4 D
XCA021 {part_no 20567733} EH3 1 C XCB906 {part_no 3963412} YA1−2 3 C
XCA021 {part_no 20567733} XA1 2 D XCG11 {part_no stud_M10} ZA1 1 D
XCA021 {part_no 20567733} XB1 4 C XJB101 {part_no stud_M8} AA2 2 B
XCA021 {part_no 20567733} XC1 2 C XJB102 {part_no stud_M8} AA2 4 B
XCA021 {part_no 20567733} XH1 1 D XJB201 {part_no stud_M10} AA2 1 B
XCA021 {part_no 20567733} XJ1 1 C XJB202 {part_no stud_M8} AA2 2 B
XCB401B {part_no 984944} XH1 3 C XJB601 {part_no stud_M10} AC1 0 B
XCB401B {part_no 984944} YA1−1 0 D XJB601 {part_no stud_M10} AD1 1 D
XCB403 {part_no 20367823} XF1 1 C Y02 {part_no 3944972} EB1 2 E
XCB403 {part_no 20367823} YA1−2 0 C Y11 {part_no 3944972} EA1−2 3 D
XCB500 {part_no 1096615} OG1 2 D Y12 {part_no 3944972} EA1−2 3 D
XCB500 {part_no 1096615} OH1 1 C Y25 {part_no 3944972} FA3 1 D
XCB501BLF {part_no 984944} GB1−1 1 B Y36 {part_no 3944972} FD1 2 D
XCB501BLF {part_no 984944} GB1−2 0 B Y37 {part_no 984944} CA1−2 3 B
XCB501BLF {part_no 984944} GC1−1 2 B Y40 {part_no 3944972} FA1−2 1 D
XCB501BLF {part_no 984944} GD2−1 2 B Y80B {part_no mating_995794} CB1−4 0 C
XCB501BRF {part_no 984944} GB1−1 3 B Y81C {part_no 994234} CB1−4 1 C
2

2
XCB501BRF {part_no 984944} GB1−2 3 B Y147 {part_no 3944972} CA1−3 3 B
XCB501BRF {part_no 984944} GC1−1 3 B Y158 {part_no 3944972} EF1 2 C
XCB501BRF {part_no 984944} GD2−1 3 B Y159 {part_no 3944972} EF1 3 C
XCB502 GB1−1 2 C Y160 {part_no 990705} CE1 2 C
XCB502 GB1−2 1 D Y162B {part_no 984944} CA1−3 1 B
XCB502 GB2 2 B Y163 {part_no 3944972} FA5 1 D
XCB502 GC1−1 2 C Y169A {part_no 993364} FB4 1 C
XCB502 GD2−1 2 C Y170 {part_no 3944972} FB4 3 D
XCB502 YA1−1 2 D
XCB503 {part_no 984944} GC1−2 1 D
XCB503 {part_no 984944} GC2 0 A
XCB503 {part_no 984944} GD1 2 D
XCB503 {part_no 984944} GD3 1 B
XCB601F GC1−1 1 B
XCB601F GD2−1 0 C
XCB601M GC2 0 D
XCB601M ID3 3 D
XCB602F GC1−1 4 B
XCB602F GD2−1 4 C
XCB602M GC2 4 D
XCB602M ID3 4 D
3

3
XCB703R {part_no 3944541} GB2 2 D
XCB703R {part_no 3944541} GC1−2 2 D
XCB703R {part_no 3944541} GD1 1 D
XCB703R {part_no 3944541} GD2−2 2 D
XCB703R {part_no 3944541} GD3 2 D
XCB703R {part_no 3944541} ID1 2 C
XCB703R {part_no 3944541} VD4 2 C
XCB720R {part_no 3963412} GC1−2 4 D
XCB720R {part_no 3963412} GD1 3 D
XCB720R {part_no 3963412} GD2−2 3 C
XCB720R {part_no 3963412} GD3 3 D
XCB721R {part_no 3963412} GC1−2 0 D

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 19(44)

D

A
C

B
E
 D

A
C

B
E
REFERENCES
0

0
REF DESCRIPTION PAGE
A03 Instrument cluster BD1−1 1 D
A03 Instrument cluster BD1−2 2 D
A03 Instrument cluster BD1−3 3 B
A03 Instrument cluster EA1−1 3 B
A03 Instrument cluster EB1 2 C
A03 Instrument cluster GA1 3 B
A03 Instrument cluster GC2 1 A
A03 Instrument cluster JB1 2 B
A03 Instrument cluster XA1 4 D
A03 Instrument cluster XE1−1 4 C
A03 Instrument cluster XH1 2 C
A03 Instrument cluster YA1−3 3 C
A03 Instrument cluster YA1−4 3 C
A03 Instrument cluster YA1−6 2 C
A07 Control unit, Audio JA1 1 D
A07 Control unit, Audio XE1−1 3 C
A07 Control unit, Audio XH1 1 C
A13A Control unit, TECU (Transmission ECU) DA1 1 D
A13A Control unit, TECU (Transmission ECU) XA1 1 E
1

1
A13A Control unit, TECU (Transmission ECU) XB1 4 D
A13A Control unit, TECU (Transmission ECU) XC1 2 C
A16 Control unit, ECS (Electronic Controlled FA1−1 1 C
A16 Control unit, ECS (Electronic Controlled FA1−2 2 B
A16 Control unit, ECS (Electronic Controlled FA2 3 B
A16 Control unit, ECS (Electronic Controlled FA3 2 A
A16 Control unit, ECS (Electronic Controlled FA5 2 B
A16 Control unit, ECS (Electronic Controlled XA1 3 B
A16 Control unit, ECS (Electronic Controlled XH1 3 B
A16 Control unit, ECS (Electronic Controlled YA1−6 3 B
A17 Control unit, VECU (Vehicle ECU) AB2 4 E
A17 Control unit, VECU (Vehicle ECU) AC1 4 C
A17 Control unit, VECU (Vehicle ECU) BA1 1 D
A17 Control unit, VECU (Vehicle ECU) BE1 2 A
A17 Control unit, VECU (Vehicle ECU) BE2 2 A
A17 Control unit, VECU (Vehicle ECU) BH2 2 B
A17 Control unit, VECU (Vehicle ECU) BI1 2 A
A17 Control unit, VECU (Vehicle ECU) CA1−1 3 C
A17 Control unit, VECU (Vehicle ECU) CE1 1 C
A17 Control unit, VECU (Vehicle ECU) CE2 2 C
A17 Control unit, VECU (Vehicle ECU) EF1 2 E
2

2
A17 Control unit, VECU (Vehicle ECU) EG1 2 B
A17 Control unit, VECU (Vehicle ECU) EH1 2 D
A17 Control unit, VECU (Vehicle ECU) FB1 2 E
A17 Control unit, VECU (Vehicle ECU) FB2 2 B
A17 Control unit, VECU (Vehicle ECU) FB4 2 B
A17 Control unit, VECU (Vehicle ECU) GD1 2 A
A17 Control unit, VECU (Vehicle ECU) XA1 2 B
A17 Control unit, VECU (Vehicle ECU) XE1−1 1 C
A17 Control unit, VECU (Vehicle ECU) XH1 2 B
A17 Control unit, VECU (Vehicle ECU) YA1−4 1 B
A17 Control unit, VECU (Vehicle ECU) YA1−6 3 B
A19_A Control unit, GECU (gear selector ECU) G DA2−2 2 D
A19_A Control unit, GECU (gear selector ECU) G XJ1 3 C
A19C Control unit, GECU I−shift DA1 3 E
A21 Control Unit, EBS (Electronic Brake Syste EA1−1 1 C
A21 Control Unit, EBS (Electronic Brake Syste EA1−2 2 A
A21 Control Unit, EBS (Electronic Brake Syste EA2 1 A
A21 Control Unit, EBS (Electronic Brake Syste EB1 2 C
A21 Control Unit, EBS (Electronic Brake Syste EC1 2 A
A21 Control Unit, EBS (Electronic Brake Syste ED1 1 D
A21 Control Unit, EBS (Electronic Brake Syste XA1 2 B
3

3
A21 Control Unit, EBS (Electronic Brake Syste XH1 3 B
A21 Control Unit, EBS (Electronic Brake Syste YA1−4 2 B
A22 Control unit, FMS (Fleet Management Syst JF1 2 C
A22 Control unit, FMS (Fleet Management Syst XA1 5 B
A22 Control unit, FMS (Fleet Management Syst XE1−2 0 C
A22 Control unit, FMS (Fleet Management Syst XH1 5 C
A26 Control unit, DACU (Driver Assistance Con VA2 0 C
A26 Control unit, DACU (Driver Assistance Con XA1 3 D
A26 Control unit, DACU (Driver Assistance Con XB1 1 C
A26 Control unit, DACU (Driver Assistance Con XM1 1 C
A27 Control unit, LCM ( Light Control Module AA2 1 E
A27 Control unit, LCM ( Light Control Module AB2 3 E
A27 Control unit, LCM ( Light Control Module GA1 2 C
A27 Control unit, LCM ( Light Control Module GB1−1 2 E
A27 Control unit, LCM ( Light Control Module GB1−2 2 E
A27 Control unit, LCM ( Light Control Module GB2 2 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 20(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
A27 Control unit, LCM ( Light Control Module GC1−1 2 D
A27 Control unit, LCM ( Light Control Module GC1−2 2 A
A27 Control unit, LCM ( Light Control Module GC2 2 A
A27 Control unit, LCM ( Light Control Module GD1 2 B
A27 Control unit, LCM ( Light Control Module GD2−1 2 D
A27 Control unit, LCM ( Light Control Module GD2−2 2 A
A27 Control unit, LCM ( Light Control Module GD3 2 B
A27 Control unit, LCM ( Light Control Module OG1 3 C
A27 Control unit, LCM ( Light Control Module OH1 3 D
A27 Control unit, LCM ( Light Control Module XA1 3 B
A27 Control unit, LCM ( Light Control Module XH1 4 B
A27 Control unit, LCM ( Light Control Module YA1−1 2 B
A27 Control unit, LCM ( Light Control Module YA1−3 1 B
A27 Control unit, LCM ( Light Control Module YA1−5 3 B
A33 Tachograph BE1 1 B
A33 Tachograph JE1 2 B
A33 Tachograph XE1−1 5 C
A33 Tachograph YA1−4 4 C
A36 Control unit, BBM (Body Builder Module) AA2 3 E
1

1
A36 Control unit, BBM (Body Builder Module) AB2 0 E
A36 Control unit, BBM (Body Builder Module) AD1 2 A
A36 Control unit, BBM (Body Builder Module) BB1 2 C
A36 Control unit, BBM (Body Builder Module) EA2 3 A
A36 Control unit, BBM (Body Builder Module) EG1 2 B
A36 Control unit, BBM (Body Builder Module) FD1 1 B
A36 Control unit, BBM (Body Builder Module) ID3 2 B
A36 Control unit, BBM (Body Builder Module) VA2 4 E
A36 Control unit, BBM (Body Builder Module) VD4 1 B
A36 Control unit, BBM (Body Builder Module) XA1 1 B
A36 Control unit, BBM (Body Builder Module) XF1 1 C
A36 Control unit, BBM (Body Builder Module) XH1 3 B
A36 Control unit, BBM (Body Builder Module) YA1−4 2 B
A36 Control unit, BBM (Body Builder Module) YA1−5 1 B
A41 Component group transmission. Contains B EH3 1 D
A79 Control unit, I−shift gateway DA1 2 C
A79 Control unit, I−shift gateway XA1 4 D
A79 Control unit, I−shift gateway XH1 3 C
A80 Airdryer, electronical controlled FB1 2 C
A125 Control unit, TGW (Telematics Gateway) JE1 1 C
A125 Control unit, TGW (Telematics Gateway) XB1 2 C
2

2
A125 Control unit, TGW (Telematics Gateway) XE1−1 3 C
A125 Control unit, TGW (Telematics Gateway) XH1 2 C
A132 Control unit, alcolock BF1 1 D
A132 Control unit, alcolock XF1 4 C
A163 Control unit, CCIOM, Central Chassis IO M AC1 2 B
A163 Control unit, CCIOM, Central Chassis IO M CI1 1 B
A163 Control unit, CCIOM, Central Chassis IO M FB4 3 C
A163 Control unit, CCIOM, Central Chassis IO M XB1 3 C
A174 Control unit, ACM (Aftertreatment Control CB1−1 1 D
A174 Control unit, ACM (Aftertreatment Control CB1−2 3 B
A174 Control unit, ACM (Aftertreatment Control CB1−3 1 B
A174 Control unit, ACM (Aftertreatment Control CB1−4 4 A
A174 Control unit, ACM (Aftertreatment Control CB1−5 2 C
A174 Control unit, ACM (Aftertreatment Control EH3 2 A
A174 Control unit, ACM (Aftertreatment Control XA1 2 D
A174 Control unit, ACM (Aftertreatment Control XB1 3 C
A174 Control unit, ACM (Aftertreatment Control XD1 2 B
A176 Control unit, LPOS, Lane Position and Obj VA2 1 B
A176 Control unit, LPOS, Lane Position and Obj XM1 2 C
A190 Component group urea CB1−4 2 E
A195 Control unit, BIO Bus I/O ECU BC1 1 C
3

3
A195 Control unit, BIO Bus I/O ECU EF1 2 E
A195 Control unit, BIO Bus I/O ECU FB4 1 D
A195 Control unit, BIO Bus I/O ECU VA2 3 B
A195 Control unit, BIO Bus I/O ECU XF1 2 C
A195 Control unit, BIO Bus I/O ECU XG1 2 C
A195 Control unit, BIO Bus I/O ECU XH1 4 C
A200 Control unit, TECU (Transmission ECU) ZF DA2−1 1 D
A200 Control unit, TECU (Transmission ECU) ZF XA1 2 D
A200 Control unit, TECU (Transmission ECU) ZF XH1 1 E
A200 Control unit, TECU (Transmission ECU) ZF XJ1 0 D
A201 Control unit, AIC (Advanced Information C JD2 1 C
A201 Control unit, AIC (Advanced Information C XE1−1 2 C
A201 Control unit, AIC (Advanced Information C XE1−2 1 C
A201 Control unit, AIC (Advanced Information C XF1 4 C
A201 Control unit, AIC (Advanced Information C XH1 5 C
A224 Seat Haptic Vibration VA2 3 C

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 21(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
A234 Control Unit, VDS GW (Volvo Dynamic Steer FC2−2 2 D
A234 Control Unit, VDS GW (Volvo Dynamic Steer XB1 2 C
A234 Control Unit, VDS GW (Volvo Dynamic Steer XF1 3 D
A234 Control Unit, VDS GW (Volvo Dynamic Steer XO1 2 D
A235 Control Unit, VDS (Volvo Dynamic Steering FC2−1 2 D
A235 Control Unit, VDS (Volvo Dynamic Steering XO1 3 D
B03 Sensor, footbrake valve EA1−1 1 B
B06 Sensor, air pressure, air tank FB2 2 D
B07 Sensor, fuel level BD1−3 3 C
B12 Sensor, tachograph / speedometer BE1 1 E
B12 Sensor, tachograph / speedometer BE2 2 D
B13B Sensor, wheel speed, lhs. front axle EA1−2 0 D
B14B Sensor, wheel speed, rhs. front axle EA1−2 1 D
B15 Sensor, wheel speed, lhs. 1:st driven re EA1−2 2 D
B16 Sensor, wheel speed, rhs. 1:st driven re EA1−2 2 D
B22 Sensor, outdoor temperature BD1−3 2 D
B25 Sensor, accelerator pedal BI1 2 D
B28 Sensor, chassis level, front axle FA1−2 2 D
B29 Sensor, chassis level, lhs. rear axle FA3 3 D
1

1
B30 Sensor, chassis level, rhs.rear axle FA3 3 D
B32 Sensor, engine cooling fan speed CA1−3 2 C
B39 Sensor, air filter pressure and air filt CA1−2 1 C
B40A Sensor, brake lining wear indicator, lhs EA1−2 0 D
B40B Sensor, brake lining wear indicator, lhs EA1−2 0 D
B42 Sensor, brake lining wear indicator, lhs EA1−2 1 D
B43 Sensor, brake lining wear indicator, rhs EA1−2 1 D
B49 Sensor, steering angle EC1 2 D
B50 Sensor, yaw−rate EC1 2 D
B52 Sensor, water level, water separator CA1−2 0 C
B56 Sensor, air pressure, suspension bellows FA1−2 2 C
B57 Sensor, air pressure, suspension bellows FA3 2 C
B58 Sensor, air pressure, suspension bellows FA3 2 C
B69 Sensor, coolant temperature, retarder EH3 2 D
B85 Sensor, exhaust temp, downstream DPF CB1−2 1 C
B96A Sensor, NOx CB1−3 1 C
B96A Sensor, NOx XD1 2 B
B96B Sensor, NOx CB1−3 2 C
B96B Sensor, NOx XD1 3 B
B97 Sensor, exhaust temp, upstream catalyst CB1−2 2 C
B98 Sensor, exhaust temp, downstream catalyst CB1−2 2 C
2

2
B115 Sensor, DPF pressure (Diesel particulate CB1−2 1 C
B142B Sensor, AdBlue level and temperature CB1−4 4 D
B152 Sensor, Brake Air Pressure 1 EA1−1 3 D
B153 Sensor, Brake Air Pressure 2 EA1−1 3 D
B238 Sensor, FLS (Forward Looking Sensor) VA2 2 B
B238 Sensor, FLS (Forward Looking Sensor) XM1 3 C
B250 Sensor, Battery AA2 1 D
B262 Sensor, Urea Pressure CB1−4 3 C
B263 Sensor, Urea Air Pressure CB1−4 3 C
B274 Sensor, Hydraulic oil level Engine fan BD1−2 3 C
B275B Sensor, Hydraulic oil level Mechanical Po BD1−2 3 C
B276 Sensor, Hydraulic oil pressure Boogie FD1 1 D
B278 Sensor, Brake Air Pressure 3 EA2 3 D
B279 Sensor, Fuel Level Second BD1−3 3 C
B280A Sensor, Heat Sensor Air Filter CF1 2 B
B280B Sensor, Heat Sensor Air Filter CF1 2 B
B281 Sensor, Heat Sensor Third Alternator CF1 2 C
B291L Sensor Indicator EBS Additional Brake Lin EA2 1 D
B291R Sensor Indicator EBS Additional Brake Lin EA2 1 D
B292L Sensor, Speed EBS Additional Wheel Left EA2 1 D
B292R Sensor, Speed EBS Additional Wheel Right EA2 2 D
3

3
B307 Sensor Fuel Quality CB1−5 2 D
B349 Sensor, Hatch Engine VD4 1 D
D1 Diode Parkbrake EG1 2 C
E06 Lamp, reversing light GD3 2 D
E07L Lamp, fog light, left GB2 2 A
E07R Lamp, fog light, right GB2 2 A
E08FSL1 Lamp, parking light Front side left GD2−1 0 B
E08FSL2 Lamp, parking light Front side left GD2−1 0 B
E08FSL3 Lamp, parking light Front side left GD2−1 1 E
E08FSR1 Lamp, parking light Front side right GD2−1 4 B
E08FSR2 Lamp, parking light Front side right GD2−1 4 B
E08FSR3 Lamp, parking light Front side left GD2−1 4 E
E09 Lamp, brake light GD1 1 E
E09R Lamp, brake light GD1 2 E
E11LA Lamp, side marker light, left side 1 GC2 0 B
E11LB Lamp, side marker light, left side 2 GC2 0 E

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 22(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
E11RA Lamp, side marker light, right side 1 GC2 4 B
E11RB Lamp, side marker light, right side 2 GC2 3 E
E13LS Lamp, direction indicator, left side GC1−1 1 B
E13LS2 Lamp, direction indicator, left side GC1−2 1 E
E13RL Lamp, direction indicator, left rear GC1−2 2 D
E13RS Lamp, direction indicator, right side GC1−1 4 B
E13RS2 Lamp, direction indicator, right side GC1−2 3 E
E21LR Lamp, rear fog light Left GB2 1 E
E21R Lamp, Rear Fog light, Right GB2 2 E
E21RR Lamp, rear fog light Right GB2 3 E
E23L Lamp, luggage compartment illumination, l ID3 0 D
E23R Lamp, luggage compartment illumination, r ID3 1 D
E27L Tail lamp module, left GC1−2 1 D
E27L Tail lamp module, left GD1 0 E
E27L Tail lamp module, left GD2−2 1 D
E27L Tail lamp module, left GD3 1 D
E27R Tail lamp module, right GC1−2 4 D
E27R Tail lamp module, right GD1 3 E
E27R Tail lamp module, right GD2−2 3 D
1

1
E27R Tail lamp module, right GD3 3 D
E83L HEADLAMP LEFT GB1−1 1 A
E83L HEADLAMP LEFT GB1−2 1 A
E83L HEADLAMP LEFT GC1−1 2 B
E83L HEADLAMP LEFT GD2−1 2 B
E83R HEADLAMP RIGHT GB1−1 2 A
E83R HEADLAMP RIGHT GB1−2 3 A
E83R HEADLAMP RIGHT GC1−1 3 B
E83R HEADLAMP RIGHT GD2−1 2 B
E111 LED Module, (Forward Collision Warning) VA2 0 D
E136 Heater, Regeneration, Water Tank 1 CI1 1 D
E137 Heater, Regeneration, Water Tank 2 CI1 2 D
F01 Fuse, APBE Automatic parking brake evacua EF1 2 A
F03 Fuse, Luggage light YA1−4 3 A
F05 Fuse, Instrument cluster & On Board Diagn BD1−1 2 A
F05 Fuse, Instrument cluster & On Board Diagn BD1−2 1 A
F05 Fuse, Instrument cluster & On Board Diagn BG1 2 A
F06 Fuse, Alternator ECU & Engine Components AC1 4 B
F06 Fuse, Alternator ECU & Engine Components BA1 1 B
F06 Fuse, Alternator ECU & Engine Components CA1−1 3 B
F06 Fuse, Alternator ECU & Engine Components CE2 2 B
2

2
F06 Fuse, Alternator ECU & Engine Components FB1 3 B
F06 Fuse, Alternator ECU & Engine Components FB4 2 B
F07 Fuse, Vehicle ECU Feed BA1 1 B
F08 Fuse, Instrument cluster & On Board Diagn BD1−1 2 A
F08 Fuse, Instrument cluster & On Board Diagn BE1 1 A
F08 Fuse, Instrument cluster & On Board Diagn BG1 2 A
F11 Fuse, Transmission, I−shift GECU DA1 2 B
F12 Fuse, Transmission, TECU DA1 1 B
F13 Fuse, Wiper & Washer OG1 3 A
F13 Fuse, Wiper & Washer OH1 2 A
F14 Fuse, Body +15 YA1−5 2 A
F20 Fuse, Alcolock & Advanced information clu BF1 1 A
F20 Fuse, Alcolock & Advanced information clu JD2 3 A
F23 Fuse, Electronic Controlled Air Suspensio FA1−1 2 A
F28 Fuse, Electronic brake system EA1−1 1 A
F30 Fuse, Ignition +15 AB2 3 B
F35 Fuse, Front external light YA1−1 4 A
F36 Fuse, Day running light YA1−1 3 C
F38 Fuse, Light Control Module GA1 1 A
F39 Fuse, Fleet Management System Gate Way (T JD2 4 A
3

F39 Fuse, Fleet Management System Gate Way (T JF1 2 A

3
F42 Fuse, DACU VA2 4 A
F43 Fuse, Fuel Cut Off Valve CE1 2 B
F46 Fuse, Horn YA1−2 0 A
F48 Fuse, Electronic Brake System EA1−1 1 A
F49 Fuse, Electronic Control Suspension FA1−1 1 A
F50 Fuse, GW (Gate Way) FC2−2 2 B
F51 Fuse, BBM ECU BB1 2 A
F52 Fuse, Body System +30 YA1−2 0 A
F53 Fuse, Gearbox, TECU ZF Ecolife DA2−1 1 A
F54 Fuse, Dynafleet & Fleet Management System JE1 1 A
F54 Fuse, Dynafleet & Fleet Management System JF1 2 A
F55 Fuse, Bus I/O ECU BC1 2 A
F57 Fuse, Gearbox, TECU ZF Ecolife DA1 3 A
F57 Fuse, Gearbox, TECU ZF Ecolife DA2−1 2 A
F57 Fuse, Gearbox, TECU ZF Ecolife DA2−2 2 A
F59 Fuse, Dashboard Switch Feed AB2 4 A

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 23(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
F60 Fuse, +DR Body YA1−4 4 A
F61 Fuse, Infotainment AIC (Telematics Interf JE1 2 A
F62 Fuse, After treatment Control Module (AMC BD1−2 3 A
F62 Fuse, After treatment Control Module (AMC CB1−1 2 A
F63 Fuse, Bus I/O ECU BC1 1 A
F64 Fuse, Active Safety Seat Haptic VA2 3 A
F67 Fuse, Radio, Audio JA1 1 A
F68 Fuse, Ignition Key AB2 2 A
F74 Fuse, Windscreen & Headlamp Washer OH1 1 A
F77 Fuse, Light Control Module Feed GA1 0 A
F78 Fuse, Light Control Module Feed GA1 0 A
F79 Fuse, Light Control Module Feed GA1 0 A
F80 Fuse, Light Control Module Feed GA1 0 A
F81 Fuse, Light Control Module Feed GA1 0 A
F82 Fuse, Light Control Module Feed GA1 1 A
F84 Fuse, Infotainment, AIC (Telematics Inter JD2 4 A
F85 Fuse, Radio (Audio) JA1 1 A
F86 Fuse, Instrument Cluster BD1−1 1 A
F87 Fuse, Main Switch AB2 0 A
1

1
F88 Fuse, VDS (Volvo Dynamic steering) FC2−1 2 B
F89 Fuse, Sidemarkers Left YA1−3 3 B
F90 Fuse, Sidemarkers Right YA1−3 3 B
F100 Fuse, VPDUR AA2 4 C
F101 Fuse, +30 Chassis AA2 4 B
F104 Fuse, B+ AA2 3 B
F108 Fuse, Body Builder YA1−2 4 A
F109 Fuse, I−Start AD1 2 A
F110 Fuse, Bodybuilder YA1−2 3 A
F115 Fuse, Tachograph AB2 1 A
F115 Fuse, Tachograph BE1 1 A
F118 Fuse, Spare Body YA1−2 4 A
F120 Fuse, Battery Sensor AC1 2 A
F121 Fuse, ARMS AA2 3 B
F200 Fuse, Alternator / DCDC AC1 0 A
F201 Fuse, Alternator AC1 0 A
F206 Fuse, +30 CI1 2 A
F207 Fuse, VPDUF AA2 4 D
F208 Fuse, CCIOM AC1 2 B
F209 Fuse, Fuel Heater CE2 1 B
F210 Fuse, EMS Supply CA1−1 1 B
2

2
F211 Fuse, EMS Supply CA1−1 2 B
F212 Fuse, EMS Supply CA1−1 2 B
F213 Fuse, EMS Supply CA1−1 2 B
F214 Fuse, Air Compressor/Dryer FB1 2 B
F214 Fuse, Air Compressor/Dryer FB4 1 B
F215 Fuse, UQS Sensor CA1−1 1 B
F217 Fuse, Engine Hatch VD4 2 A
F218 Engine Room Light ID1 2 A
F218 Engine Room Light ID3 3 A
F223 Fuse, Hydraulic Steering FD1 2 A
F224 Fuse, ACM Supply CB1−1 1 A
F300 Fuse, Water Heater 1 CI1 1 C
F301 Fuse, Water Heater 2 CI1 2 C
FH1:1P GA1 0 B
FH1:1S AA2 1 A
FH1:2P GA1 0 B
FH1:2S AA2 2 A
FH1:3P GA1 0 B
FH1:3S AA2 2 A
FH2:1P GA1 0 B
FH2:1S AA2 2 A
3

3
FH2:2P GA1 0 B
FH2:2S AA2 2 A
FH2:3P GA1 1 B
FH2:3S AA2 2 A
FH3:1S AA2 2 A
FH3:2P JD2 4 B
FH3:2S AA2 2 A
FH3:3P JA1 1 A
FH3:3S AA2 2 A
FH4:1P BD1−1 1 A
FH4:1S AA2 2 A
FH4:2P AB2 0 A
FH4:2S AA2 2 A
FH4:3P FC2−1 2 B
FH4:3S AA2 2 A
FH5:1P YA1−3 3 C

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 24(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
FH5:1S YA1−3 3 B
FH5:2P YA1−3 3 C
FH5:2S YA1−3 3 B
FRC:28 EA1−1 1 A
FRC:30 AB2 3 B
FRC:35 YA1−1 4 B
FRC:36 YA1−1 3 C
FRC:38 GA1 1 B
FRC:39 JD2 4 B
FRC:39 JF1 2 B
FRC:42 VA2 4 A
FRC:43 CE1 2 B
FRC:46 YA1−2 0 B
FRC:48 EA1−1 1 A
FRC:49 FA1−1 1 B
FRC:50 FC2−2 2 B
FRC:51 BB1 2 B
FRC:52 YA1−2 0 B
FRC:53 DA2−1 1 A
1

1
FRC:54 JE1 1 B
FRC:54 JF1 2 B
FRC:55 BC1 2 B
FRC:57 DA1 3 B
FRC:57 DA2−1 2 A
FRC:57 DA2−2 2 A
FRC:59 AB2 4 A
FRC:60 YA1−4 4 B
FRC:61 JE1 2 B
FRC:62 BD1−2 3 A
FRC:62 CB1−1 2 B
FRC:63 BC1 1 B
FRC:64 VA2 3 A
FRC:67 JA1 1 A
FRC:68 AB2 2 A
FRC:74 OH1 1 A
G01A Battery 1 AA2 1 C
G01B Battery 2 AA2 1 C
G02A Alternator 1 AC1 0 C
G02B Alternator 2 AC1 0 D
G02C Alternator 3 AC1 0 D
2

2
G10A Battery, I−Start Battery 1 AD1 2 D
G10B Battery, I−Start Battery 2 AD1 2 D
GND1:1 ZA1 1 E
GND2:1 ZA1 3 E
GND5:1 ZA1 3 E
GND6:1 ZA1 4 E
GND21:1 AA2 1 E
GND21:1 AA2 0 D
GND61:1 AD1 2 E
GND62:1 AC1 0 E
GND63:1 ZA1 4 E
GND64:1 ZA1 4 E
GND65:1 CI1 2 E
GND65:1 CI1 1 E
H01 Horn, air−operated YA1−2 1 D
H02 Horn YA1−2 1 E
K05 Relay Front wiper On/Off OG1 3 B
K22 Relay Ignition +15 AB2 3 A
K72 Relay VECU (Vehicle ECU) AC1 4 A
K72 Relay VECU (Vehicle ECU) BA1 1 A
K72 Relay VECU (Vehicle ECU) CA1−1 3 A
3

3
K72 Relay VECU (Vehicle ECU) CE1 1 A
K72 Relay VECU (Vehicle ECU) CE2 2 B
K72 Relay VECU (Vehicle ECU) FB1 3 A
K72 Relay VECU (Vehicle ECU) FB4 2 A
K73 Relay Ignition +DR AB2 4 A
K74 Relay I−shift DA1 1 A
K75 Relay Luggage Door Switch ID3 1 B
K75 Relay Luggage Door Switch YA1−4 3 B
K76 Relay, ECS (Electronic Controlled Suspens FA1−1 2 B
K77 Relay Day Light Running YA1−1 3 B
K80 Relay Emergency Switch AB2 2 C
K81 Relay Main Switch AB2 0 B
K84 Relay, APBE (Automatic Park Brake Engine) EF1 2 B
K85 Relay Disconnect Headlight wash OH1 1 D
K102 Relay Main Relay AA2 4 B
K103 Relay ARMS (Automatic Reset Main Switch) AA2 3 C

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 25(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
K106 Relay Water Heater 1 CI1 1 C
K107 Relay, Water Heater 2 CI1 2 C
K200 Relay, Heater/CCIOM (Central Chassis IO M AC1 2 A
K200 Relay, Heater/CCIOM (Central Chassis IO M BA1 3 A
K200 Relay, Heater/CCIOM (Central Chassis IO M CE2 1 B
K201 Relay, EMS (Engine Management System) BA1 2 A
K201 Relay, EMS (Engine Management System) CA1−1 2 A
K201 Relay, EMS (Engine Management System) FB1 2 A
K201 Relay, EMS (Engine Management System) FB4 1 A
K202 Relay Steerable Axle FD1 2 B
K401 Relay Seat Haptic 12V VA2 3 B
K402 Relay Seat Haptic 24V VA2 3 B
M01 Motor, windscreen wiper OG1 1 D
M02 Motor, windscreen washer pump OH1 2 D
M03 Motor, headlamp high pressure washer pum OH1 1 D
M04 Motor, starter motor AD1 1 D
R06 Heater, fuel water separator CE2 1 C
R56 Heater, AdBlue hose, White CB1−4 0 D
R57 Heater, AdBlue hose, Black CB1−4 1 D
1

1
R66 Resistor, CAN termin Backbone 1 XA1 1 A
R67 Resistor, CAN termin Backbone 2 XB1 1 B
R88 Resistor FMS CAN XE1−2 3 C
R89 Resistor FCW LED, Pull−up VA2 4 D
R91 Resistor, VDS−CAN CAN Termination XO1 4 B
S01 Switch, main lighting, GA1 2 B
S02 Stalk switch, full− / dipped beams BH2 2 D
S02 Stalk switch, full− / dipped beams GA1 3 D
S06 Stalk switch, windscreen wiper, selector BD1−2 0 C
S06 Stalk switch, windscreen wiper, selector OG1 1 B
S06 Stalk switch, windscreen wiper, selector OH1 2 B
S08 Switch, differential gear lock, rear whe EB1 2 B
S11 Switch, bogie lift, selector type FA5 2 D
S12 Switch, Main Control AB2 1 C
S14A Switch, push button, horn YA1−2 1 C
S14B Switch, push button, horn YA1−2 2 C
S15 Switch Key switch AB2 3 C
S16 Switch, push button, air horn YA1−2 2 C
S24 Stalk switch, retarder, selector type EH1 2 B
S31 Switch, TCS ( Traction Control System ) ED1 2 B
S32 Switch, brake hold ED1 1 B
2

2
S34 Switch unit, steering wheel push buttons JB1 2 D
S41 Switch, battery main switch control AA2 3 C
S43 Switch Indicator Parking Brake Pressure N EG1 2 D
S45 Position switch, differential gear lock i EB1 2 E
S57L2 Position switch, luggage compartment lig ID3 3 D
S57R2 Position switch, luggage compartment lig ID3 4 D
S68 Proximity switch, coolant level, NC. CA1−2 2 C
S70 Position switch, flow sensor, power−stee FD1 2 D
S202 Switch, LDWS, Lane Departure Warning Sys VA2 3 E
S304 Switch Air Suspension Kneeling FA2 2 D
S314 Switch Retarder EH1 1 C
S315 Switch Engine Start Rear CA1−2 1 B
S316 Switch Engine Start Enable Rear CA1−2 2 B
S321 Switch Alternative Gearshift Program ZF E DA2−2 2 C
S322 Switch Emergency Cut−Out AB2 1 B
S322 Switch Emergency Cut−Out YA1−1 0 B
S324 Switch Driver Change Alcolock BF1 2 C
S325 Switch Air Suspension Raise/Lower Level FA2 3 C
S348 Switch AEBS (Advanced Emergency Braking S VA2 3 E
TC30−1_88 twisted pair BI1 2 B
TC30−1_98 twisted pair BI1 2 C
3

3
TC30−1_1000 twisted pair BI1 2 B
TC30−1_2061 twisted pair XH1 3 A
TC30−1_2089 twisted pair XH1 1 D
TC30−1_7012 twisted pair XH1 4 C
TC30−2_117 twisted pair XH1 1 C
TC30−2_2089 twisted pair XH1 2 A
TC30−2_7012 twisted pair XH1 1 D
TC30−3_288 twisted pair XH1 2 A
TC30−4_288 twisted pair XH1 5 A
TC30−4_2089 twisted pair XH1 3 A
TC30−5_288 twisted pair XH1 4 A
TC30−8_670 twisted pair XH1 4 C
TC30−8_2031 twisted pair XH1 3 C
TC30−8_2089 twisted pair XH1 2 C
TC30−9_207 twisted pair XH1 4 A
TC30−9_670 twisted pair XH1 5 C

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 26(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
TC30−9_2030 twisted pair XH1 5 C
TC30−10_670 twisted pair XH1 2 C
TC30−10_2044 twisted pair XH1 3 C
TC30−12_22 twisted pair XH1 1 C
TC30−12_117 twisted pair XH1 1 B
TC30−12_2050 twisted pair XH1 3 A
TC30−13_117 twisted pair XH1 4 B
TC30−14_2089 twisted pair XH1 3 C
TC30−16_117 twisted pair XH1 3 B
TC30−20_117 twisted pair XH1 5 B
TC40−1_670 twisted pair XE1−1 2 B
TC40−2_670 twisted pair XE1−1 3 B
TC40−6_670 twisted pair XE1−2 1 C
TC40−7_670 twisted pair XE1−2 0 C
TC45−1_200 twisted pair CA1−3 2 D
TC45−1_230 twisted pair BE1 1 C
TC45−1_288 twisted pair AC1 2 C
TC45−1_300 twisted pair EH1 3 C
TC45−1_670 twisted pair XA1 5 B
1

1
TC45−1_670_1 twisted pair XB1 2 B
TC45−1_677 twisted pair EC1 1 B
TC45−1_756 twisted pair XF1 3 B
TC45−1_796 twisted pair XF1 3 A
TC45−1_1562 twisted pair BE2 2 B
TC45−1_2020 twisted pair XJ1 1 C
TC45−1_2089 twisted pair XB1 3 B
TC45−1_3564 twisted pair XB1 5 B
TC45−1_3565 twisted pair YA1−7 2 B
TC45−1_5720 twisted pair XB1 1 B
TC45−1_7001 twisted pair XA1 2 B
TC45−1_7007 twisted pair XD1 2 B
TC45−2_288 twisted pair AC1 2 D
TC45−2_670 twisted pair XB1 2 B
TC45−2_677 twisted pair EC1 1 C
TC45−2_796 twisted pair XO1 2 B
TC45−2_1562 twisted pair BE2 2 B
TC45−2_2000 twisted pair XD1 2 B
TC45−2_2089 twisted pair XF1 2 B
TC45−2_3564 twisted pair XB1 4 B
TC45−2_3565 twisted pair YA1−7 3 B
2

2
TC45−2_5720 twisted pair XA1 3 C
TC45−2_7008 twisted pair XD1 3 B
TC45−3_77 twisted pair XA1 1 A
TC45−3_670 twisted pair XE1−1 2 B
TC45−3_677 twisted pair EC1 2 C
TC45−3_731 twisted pair AC1 2 C
TC45−3_742 twisted pair XB1 1 B
TC45−3_796 twisted pair XB1 2 B
TC45−3_2089 twisted pair XE1−1 1 B
TC45−3_5721 twisted pair XM1 1 C
TC45−4_20 twisted pair XA1 2 D
TC45−4_203 twisted pair XB1 3 B
TC45−4_670 twisted pair XE1−1 3 B
TC45−4_677 twisted pair EC1 2 D
TC45−4_2010 twisted pair XA1 2 D
TC45−4_2089 twisted pair XE1−1 4 B
TC45−5_160 twisted pair XA1 2 C
TC45−5_200 twisted pair XB1 4 B
TC45−5_670 twisted pair XE1−1 3 B
TC45−5_796 twisted pair XF1 2 A
TC45−5_2010 twisted pair XB1 4 C
3

3
TC45−5_2089 twisted pair XE1−1 4 C
TC45−5_3564 twisted pair XB1 3 A
TC45−5_7001 twisted pair XA1 3 D
TC45−6_209 twisted pair XB1 3 B
TC45−6_2089 twisted pair XA1 1 B
TC45−6_3564 twisted pair XB1 4 A
TC45−6_7001 twisted pair XA1 4 D
TC45−7_210 twisted pair XA1 4 D
TC45−7_670 twisted pair XE1−2 3 B
TC45−7_796 twisted pair XM1 3 B
TC45−7_2021 twisted pair XJ1 1 D
TC45−7_2089 twisted pair XF1 1 B
TC45−7_2090 twisted pair XA1 3 B
TC45−7_5721 twisted pair XM1 2 C
TC45−8_205 twisted pair XA1 3 B
TC45−8_796 twisted pair XM1 3 C

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 27(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
TC45−9_117 twisted pair XA1 3 C
TC45−9_670 twisted pair XE1−2 2 B
TC45−9_796 twisted pair XO1 3 B
TC45−10_117 twisted pair XA1 3 C
TC45−10_670 twisted pair XF1 4 A
TC45−10_796 twisted pair XO1 4 B
TC45−11_207 twisted pair XE1−1 3 B
TC45−11_222 twisted pair XF1 1 B
TC45−11_288 twisted pair BE1 2 D
TC45−11_2040 twisted pair XA1 5 D
TC45−11_2089 twisted pair XE1−1 5 B
TC45−12_20 twisted pair XG1 2 B
TC45−12_288 twisted pair BE1 2 D
TC45−12_796 twisted pair XO1 2 C
TC45−12_2089 twisted pair XF1 4 B
TC45−13_21 twisted pair XG1 2 B
TC45−13_288 twisted pair BE1 2 E
TC45−13_796 twisted pair XO1 2 D
TC45−13_2060 twisted pair XA1 2 B
1

1
TC45−13_2089 twisted pair XB1 1 B
TC45−14_98 twisted pair AC1 2 C
TC45−14_117 twisted pair XA1 4 C
TC45−14_288 twisted pair BE1 1 D
TC45−14_731 twisted pair EA1−2 0 B
TC45−14_796 twisted pair XO1 3 C
TC45−14_2070 twisted pair XE1−1 1 B
TC45−15_117 twisted pair XD1 3 A
TC45−15_288 twisted pair BE1 1 D
TC45−15_731 twisted pair EA1−2 0 B
TC45−15_796 twisted pair XB1 1 B
TC45−15_2089 twisted pair XA1 1 D
TC45−16_117 twisted pair XA1 4 C
TC45−16_288 twisted pair BE1 1 E
TC45−16_731 twisted pair EA1−2 0 C
TC45−16_2089 twisted pair XB1 5 C
TC45−17_288 twisted pair XA1 5 C
TC45−17_731 twisted pair EA1−2 1 B
TC45−17_2089 twisted pair XC1 2 B
TC45−18_98 twisted pair BE1 2 C
TC45−18_288 twisted pair XA1 1 A
2

2
TC45−18_731 twisted pair EA1−2 1 B
TC45−18_2089 twisted pair XD1 4 B
TC45−19_288 twisted pair XA1 2 A
TC45−19_731 twisted pair EA1−2 1 C
TC45−20_288 twisted pair XA1 2 A
TC45−20_731 twisted pair EA1−2 1 C
TC45−21_288 twisted pair XA1 3 A
TC45−21_731 twisted pair EA2 1 B
TC45−21_2089 twisted pair XJ1 1 C
TC45−22_77 twisted pair XB1 1 B
TC45−22_117 twisted pair XA1 5 B
TC45−22_288 twisted pair XA1 3 A
TC45−22_731 twisted pair EA2 1 B
TC45−23_288 twisted pair XA1 4 A
TC45−23_731 twisted pair EA2 1 C
TC45−24_731 twisted pair EA2 1 D
TC45−25_288 twisted pair XE1−1 2 B
TC45−27_117 twisted pair XB1 2 B
TC45−27_288 twisted pair XF1 3 A
TC45−28_117 twisted pair XB1 3 B
TC45−29_117 twisted pair XB1 3 B
3

3
TC45−30_288 twisted pair XE1−1 4 B
TC45−41_2089 twisted pair XJ1 1 B
TC45−51_2089 twisted pair XJ1 2 B
TC45−51_7001 twisted pair XA1 2 D
TC45−55_77 twisted pair XF1 2 A
TC45−61_2089 twisted pair XJ1 3 B
TC45−66_98 twisted pair EA1−2 2 D
TC45−67_98 twisted pair EA1−2 2 D
U03 Modulator, EBS, rear axle EA1−2 1 D
U06 Voltage converter JA1 1 B
U08 Modulator, EBS, one front axle EA1−2 0 D
U36 Modulator, EBS Additional axle EA2 1 D
U37 Voltage converter 12V Bi−Xenon GB1−2 2 B
U38 Voltage converter I−Start DC/DC AD1 2 C
V03 Diode GB1−2 2 C
V04 Diode GB1−2 2 C

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 28(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
V41 Diode Windscreen Wiper OG1 2 C
V43 Diode Supply Control I−Shift transmission DA1 3 A
X09 Slip contact Horn YA1−2 1 C
X43 Connector, OBD (On−Board Diagnostics) BG1 2 D
X43 Connector, OBD (On−Board Diagnostics) XB1 1 C
X43 Connector, OBD (On−Board Diagnostics) XH1 3 C
X47 Plug, Battery charging AA2 0 D
X69 Plug, ZF diagnostics DA2−1 3 C
X69 Plug, ZF diagnostics XA1 5 D
X69 Plug, ZF diagnostics XH1 5 C
X69 Plug, ZF diagnostics XJ1 2 C
X130 Connector, BB (Body Builder) Radio Interf JA1 2 B
X132 Interface, External Customer Alcolock BF1 1 C
XB:1 ZA1 0 C
XC001:1 AC1 2 B
XC001:2 AA2 3 D
XC001:3 CE1 2 C
XC001:4 EA1−1 3 C
XC001:5 EA1−1 3 C
1

1
XC001:6 EA1−1 3 C
XC001:7 EA1−1 3 C
XC001:8 BD1−3 3 C
XC001:9 BD1−3 3 C
XC001:10 BD1−3 2 C
XC001:10 EA1−1 2 C
XC001:11 EA1−1 1 B
XC001:12 EA1−1 1 B
XC001:13 EA1−1 1 B
XC001:14 EA1−1 1 B
XC001:15 EA1−1 2 B
XC001:16 AA2 1 D
XC001:17 EA1−2 1 C
XC001:18 EA1−2 1 C
XC001:19 EA1−2 0 C
XC001:20 EA1−2 0 C
XC001:21 FA1−2 2 C
XC001:21 FA3 1 B
XC001:22 FA1−2 2 C
XC001:22 FA3 2 B
XC001:23 FA1−2 2 C
2

2
XC001:23 FA3 2 B
XC001:24 FA1−2 3 C
XC001:24 FA3 3 B
XC001:25 AB2 1 B
XC001:25 BE1 1 B
XC002:1 EA1−2 3 C
XC002:2 EA1−2 3 C
XC002:3 EA1−2 3 C
XC002:4 EA1−2 3 C
XC002:5 EC1 2 C
XC002:6 EC1 2 C
XC002:7 EC1 3 C
XC002:8 EC1 3 C
XC002:9 FA1−2 1 C
XC002:10 FA1−2 1 C
XC002:11 FA1−2 1 C
XC002:13 FA1−2 2 C
XC002:14 BD1−3 2 C
XC002:16 FA1−2 2 C
XC002:17 XM1 3 C
XC002:18 XM1 3 C
3

3
XC002:19 VA2 2 B
XC002:20 VA2 2 B
XC002:21 AD1 2 B
XC002:25 EA1−2 2 C
XC003:9 XO1 2 B
XC003:10 XO1 2 B
XC003:12 AA2 3 D
XC004:1 EA2 1 C
XC004:2 EA2 1 C
XC004:3 EA2 1 C
XC004:4 EA2 2 C
XC004:5 AD1 2 B
XC004:10 AD1 2 B
XC005:1 CA1−1 3 D
XC005:5 VD4 1 B
XC005:6 BD1−2 3 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 29(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
XC005:6 CB1−1 2 C
XC005:7 BD1−2 3 D
XC005:14 BE1 1 C
XC005:14 BE2 2 C
XC005:15 BE1 2 C
XC005:15 BE2 2 C
XC005:16 BE1 2 C
XC005:16 BE2 2 C
XC005:17 BE1 2 C
XC005:18 FB4 1 D
XC005:29 XH1 1 C
XC005:30 XH1 1 C
XC005:31 XA1 3 C
XC005:32 XA1 3 C
XC005:33 XB1 2 B
XC005:34 XB1 2 B
XC006:8 EA2 3 C
XC006:9 EA2 3 C
XC006:10 EA2 3 C
1

1
XC006:15 FD1 1 C
XC006:16 BD1−2 3 D
XC006:22 FA5 1 C
XC006:24 BA1 1 B
XC006:33 FB1 2 D
XC006:34 FB1 2 D
XC007:1 AC1 2 B
XC007:9 FB2 2 C
XC007:10 FB2 2 C
XC007:11 FB2 2 C
XC007:12 EB1 2 D
XC007:13 EB1 2 D
XC007:14 FA3 1 B
XC007:15 FA3 1 B
XC007:16 FA3 1 B
XC007:19 DA1 1 C
XC007:19 DA2−1 1 C
XC007:20 DA2−1 2 C
XC007:21 XJ1 1 B
XC007:22 XJ1 1 B
XC007:25 ID3 1 C
2

2
XC008:1 GD2−2 2 B
XC008:2 GD2−2 2 B
XC008:3 GC1−2 1 B
XC008:4 GC1−2 2 B
XC008:5 GD1 1 C
XC008:6 GD1 2 C
XC008:7 GB2 2 C
XC008:8 GD3 2 B
XC008:9 GC1−2 2 B
XC008:10 GC1−2 2 B
XC008:11 GC2 2 C
XC008:12 GC2 2 C
XC008:13 FA3 2 B
XC008:14 FA3 2 B
XC008:15 FA3 3 B
XC008:16 FA3 3 B
XC008:17 EA1−2 2 C
XC008:18 EA1−2 2 C
XC008:19 EA1−2 2 C
XC008:20 EA1−2 1 C
XC008:21 FA3 1 B
3

3
XC008:22 FA3 1 B
XC008:23 FA3 2 B
XC008:24 FA3 3 B
XC008:25 ID3 1 C
XC022:2 AB2 2 C
XC022:3 AB2 1 C
XC022:4 AB2 2 C
XC022:5 AB2 4 D
XC022:6 AB2 4 D
XC022:7 AB2 3 D
XC022:8 AB2 4 B
XC022:9 BH2 2 C
XC022:10 BH2 2 C
XC022:11 BH2 2 C
XC022:12 BH2 2 C
XC022:13 BI1 2 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 30(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
XC022:14 BI1 2 B
XC022:15 BI1 2 B
XC022:16 BI1 2 B
XC022:17 BI1 2 B
XC022:18 EH1 2 D
XC022:19 EH1 2 D
XC022:20 EH1 2 D
XC022:21 EH1 3 D
XC022:23 BE2 2 B
XC022:24 BE1 2 B
XC022:24 BE2 2 B
XC022:25 EG1 2 C
XC022:26 EH1 1 D
XC022:27 GA1 3 C
XC022:28 BC1 1 B
XC022:29 BC1 2 B
XC022:30 EF1 2 C
XC022:31 BF1 1 B
XC022:31 JD2 3 B
1

1
XC022:32 JD2 4 B
XC022:33 JE1 2 B
XC022:35 JE1 1 B
XC022:35 JF1 2 B
XC023:1 BD1−1 1 B
XC023:2 BD1−1 2 B
XC023:2 BE1 1 B
XC023:2 BG1 2 B
XC023:3 BD1−1 2 B
XC023:3 BD1−2 1 B
XC023:3 BG1 2 B
XC023:4 YA1−3 3 B
XC023:5 YA1−4 3 D
XC023:6 YA1−4 3 D
XC023:7 YA1−4 4 D
XC023:8 EA1−1 1 C
XC023:9 EA1−1 1 C
XC023:10 EA1−1 1 C
XC023:11 EA1−1 1 C
XC023:12 EA1−1 2 C
XC023:13 ED1 3 C
2

2
XC023:14 ED1 3 C
XC023:15 EB1 2 B
XC023:16 ED1 1 C
XC023:17 ED1 1 C
XC023:18 FA2 1 B
XC023:19 FA2 2 B
XC023:20 FA1−2 1 B
XC023:20 FA2 1 B
XC023:20 YA1−6 3 C
XC023:21 FA1−2 1 B
XC023:22 FA1−2 1 B
XC023:23 FA5 1 B
XC023:24 FA2 3 B
XC023:25 FA2 3 B
XC023:26 EC1 1 B
XC023:27 EC1 2 B
XC023:28 EC1 2 B
XC023:29 EC1 2 B
XC023:30 FA5 2 B
XC023:31 FA1−2 2 B
XC023:31 FA3 1 B
3

3
XC023:32 FA1−2 2 B
XC023:32 FA3 2 B
XC023:33 FA1−2 2 B
XC023:35 AB2 0 C
XC023:36 YA1−2 1 C
XC024:1 YA1−2 1 C
XC024:4 XH1 2 A
XC024:5 XH1 2 A
XC024:6 XA1 4 A
XC024:7 XA1 4 A
XC024:8 XE1−1 2 B
XC024:9 XE1−1 2 B
XC024:10 XH1 5 B
XC024:11 XH1 5 B
XC024:12 XF1 2 A
XC024:13 XF1 2 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 31(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
XC024:14 XG1 2 B
XC024:15 XG1 3 B
XC024:16 XE1−2 2 C
XC024:17 XE1−2 2 B
XC024:18 JD2 4 B
XC024:18 JF1 2 B
XC024:19 OH1 1 B
XC024:20 OH1 3 C
XC024:21 OG1 2 B
XC024:22 OG1 2 B
XC024:23 OG1 1 B
XC024:23 OH1 2 B
XC024:25 JA1 1 B
XC025:1 GA1 3 D
XC025:2 GA1 3 D
XC025:3 GA1 3 D
XC025:4 GA1 3 D
XC025:5 OG1 2 B
XC025:6 GA1 3 C
1

1
XC025:7 GA1 2 C
XC025:8 GA1 2 C
XC025:9 GA1 2 C
XC025:10 GA1 2 C
XC025:11 GA1 2 C
XC025:12 GA1 2 C
XC025:13 GA1 1 C
XC025:14 GA1 1 C
XC025:15 GA1 1 C
XC025:16 YA1−6 2 C
XC025:17 VA2 4 B
XC025:18 YA1−6 1 C
XC025:19 YA1−6 2 C
XC025:20 YA1−6 2 C
XC025:21 YA1−6 2 C
XC025:22 YA1−6 2 C
XC025:23 VA2 4 D
XC025:24 JA1 1 B
XC025:26 BH2 1 C
XC025:27 BH2 1 C
XC025:28 FA1−2 2 B
2

2
XC025:29 FA1−2 3 B
XC025:29 FA3 3 B
XC025:30 FA1−2 2 B
XC025:30 FA3 2 B
XC025:31 FA3 3 B
XC025:32 FA3 3 B
XC025:33 VA2 2 B
XC025:34 VA2 2 B
XC025:35 VA2 4 B
XC025:36 VA2 3 B
XC026:1 AA2 1 D
XC026:2 AA2 3 D
XC026:3 CE1 2 C
XC026:4 EA1−2 3 B
XC026:5 EA1−2 3 B
XC026:6 EA1−2 3 B
XC026:7 EA1−2 3 B
XC026:8 EA1−2 2 B
XC026:10 VA2 3 B
XC026:11 VA2 3 B
XC026:14 GD2−1 1 D
3

3
XC026:15 GD2−1 4 D
XC026:16 GA1 1 D
XC026:17 EA1−2 1 B
XC026:18 EA1−2 1 B
XC026:19 EA1−2 0 B
XC026:20 EA1−2 0 B
XC027:1 AD1 2 B
XC027:3 BA1 1 B
XC027:4 FB1 2 D
XC027:5 FB1 2 D
XC027:6 FB2 2 C
XC027:7 FB2 2 C
XC027:8 FB2 2 C
XC027:11 FD1 1 B
XC027:12 EA2 3 B
XC027:13 EA2 3 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 32(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
XC027:14 EA2 3 B
XC027:15 CA1−1 3 C
XC027:16 FA3 2 B
XC027:17 FA3 2 B
XC027:18 EB1 2 D
XC027:19 DA1 1 C
XC027:20 DA1 2 C
XC027:21 DA1 3 B
XC027:22 DA1 3 B
XC027:22 DA2−1 2 B
XC027:22 DA2−2 2 B
XC027:23 DA2−1 1 B
XC027:24 FC2−2 2 B
XC027:25 FA1−2 3 B
XC028:1 FA3 1 B
XC028:2 FA3 1 B
XC028:3 FA3 1 B
XC028:4 AA2 3 D
XC028:9 BD1−2 3 B
1

1
XC028:9 CB1−1 2 B
XC028:15 EA2 2 B
XC028:16 EA2 1 B
XC028:17 EA1−2 2 B
XC028:18 EA1−2 2 B
XC028:19 EA1−2 2 B
XC028:20 EA1−2 1 B
XC028:21 EA2 1 B
XC028:22 EA2 1 B
XC070:1 FB2 2 D
XC070:2 FB2 2 D
XC070:3 FB2 2 D
XC070:4 FD1 1 C
XC070:7 EB1 2 D
XC070:8 EB1 2 D
XC070:9 EA1−2 1 C
XC070:10 EA1−2 2 C
XC070:11 EA1−2 2 C
XC070:12 EA1−2 2 C
XC070:13 EA2 1 C
XC070:14 EA2 1 C
2

2
XC070:15 EA2 1 C
XC070:16 EA2 2 C
XC070:17 FA3 1 C
XC070:18 FA3 1 C
XC070:19 FA3 1 C
XC070:20 FA3 2 C
XC070:21 FA3 3 C
XC070:22 FA3 3 C
XC070:23 FA3 3 C
XC070:24 FA3 1 C
XC070:25 FA3 1 C
XC070:26 FA3 2 C
XC070:27 FA3 2 C
XC070:28 EA2 3 C
XC070:29 EA2 3 C
XC070:30 EA2 3 C
XC070:31 FA5 1 C
XC080:1 GD2−2 2 C
XC080:2 GD2−2 2 C
XC080:3 GC1−2 1 C
XC080:4 GC1−2 2 C
3

3
XC080:5 GD1 1 D
XC080:6 GD1 2 D
XC080:7 GB2 2 D
XC080:8 GD3 2 C
XC080:9 GC1−2 2 C
XC080:10 GC1−2 2 C
XC080:11 GC2 2 C
XC080:12 GC2 2 C
XC080:13 XA1 3 C
XC080:14 XA1 3 C
XC080:15 AC1 2 B
XC080:16 AD1 2 C
XC080:17 FB1 2 C
XC080:18 FB1 2 C
XC080:19 BA1 1 A
XC080:24 VD4 1 C

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 33(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
XC080:27 BD1−2 3 C
XC080:28 BD1−2 3 C
XC080:29 CA1−1 3 D
XC080:32 ID3 1 C
XC080:33 ID3 1 C
XC080:34 BD1−2 3 B
XC080:34 CB1−1 2 C
XC080:37 XH1 1 D
XC080:38 XH1 1 D
XC080:39 XB1 3 B
XC080:40 XB1 3 B
XC080:43 BE1 1 D
XC080:43 BE2 2 C
XC080:44 BE1 2 D
XC080:44 BE2 2 C
XC080:45 BE1 2 D
XC080:45 BE2 2 C
XC080:46 BE1 2 D
XC080:47 XJ1 1 C
1

1
XC080:48 XJ1 1 C
XC080:54 FB4 1 C
XC080:57 AD1 2 C
XC080:58 DA1 1 C
XC080:58 DA2−1 1 C
XC080:59 DA2−1 2 C
XC094A:3 FC2−1 2 B
XC096:1 FC2−1 2 C
XC100:2 YA1−2 4 B
XC100:6 AC1 2 A
XC100:8 AA2 3 D
XC100:9 YA1−2 4 B
XC100:11 AA2 3 D
XC100:12 AA2 4 B
XC100:13 YA1−2 3 B
XC100:15 AB2 1 A
XC100:15 BE1 1 A
XC100:16 AD1 2 B
XC100B:1 AA2 3 B
XC100C:1 AA2 3 B
XC100F:1 AA2 4 B
2

2
XC100G:1 AA2 4 C
XC200:2 ID1 2 B
XC200:2 ID3 3 B
XC200:6 FD1 2 B
XC200:7 VD4 2 B
XC200:8 CA1−1 2 B
XC200:10 CA1−1 1 B
XC200:11 FD1 2 B
XC200:12 CB1−1 1 B
XC200:13 FB1 2 B
XC200:13 FB4 1 B
XC200:14 BA1 1 A
XC200:15 CB1−1 2 B
XC200:16 CA1−1 2 B
XC200:17 CA1−1 2 B
XC200:18 AC1 2 B
XC200:19 CA1−1 2 B
XC200:20 CA1−1 1 B
XC200:21 CE2 1 B
XC200A:1 AA2 4 D
XC200B:1 CI1 2 A
3

3
XC200F:1 AC1 0 A
XC200G:1 AC1 0 A
XC300:5 CI1 1 B
XC300:8 CI1 3 C
XC300:21 CI1 1 B
XC300A:1 CI1 2 C
XC300D:1 CI1 2 B
XC300G:1 CI1 1 C
XC:1 ZA1 0 C
XC:2 BA1 1 E
XC:2 ZA1 0 C
XC:3 BB1 2 D
XC:3 ZA1 0 C
XC:4 ZA1 0 C
XC:5 EA1−1 1 D
XC:5 ZA1 0 C

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 34(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
XC:6 EA1−1 1 D
XC:6 ZA1 0 C
XC:7 FA1−1 1 D
XC:7 ZA1 0 C
XC:8 FA1−1 1 D
XC:8 ZA1 0 C
XC:9 GA1 0 D
XC:9 ZA1 0 C
XC:10 GA1 0 D
XC:10 ZA1 0 C
XC:11 ZA1 0 C
XC:12 ZA1 0 C
XCA020A Connector, Engine Interface 1 AC1 1 C
XCA020A Connector, Engine Interface 1 CA1−1 1 D
XCA020A Connector, Engine Interface 1 CA1−2 0 D
XCA020A Connector, Engine Interface 1 CF1 2 A
XCA020A Connector, Engine Interface 1 XA1 1 D
XCA020A Connector, Engine Interface 1 XB1 5 D
XCA020A Connector, Engine Interface 1 XC1 2 C
1

1
XCA020A Connector, Engine Interface 1 XD1 4 B
XCA020B Connector Engine Interface 2 CA1−2 0 A
XCA020B Connector Engine Interface 2 CA1−3 2 D
XCA021 Connector Gearbox Interface BE1 1 D
XCA021 Connector Gearbox Interface BE2 2 D
XCA021 Connector Gearbox Interface DA1 1 D
XCA021 Connector Gearbox Interface DA2−1 1 D
XCA021 Connector Gearbox Interface EH3 1 C
XCA021 Connector Gearbox Interface XA1 2 D
XCA021 Connector Gearbox Interface XB1 4 C
XCA021 Connector Gearbox Interface XC1 2 C
XCA021 Connector Gearbox Interface XH1 1 D
XCA021 Connector Gearbox Interface XJ1 1 C
XCB401B Connector Body Interface 3 XH1 3 C
XCB401B Connector Body Interface 3 YA1−1 0 D
XCB403 Connector Body interface Horn XF1 1 C
XCB403 Connector Body interface Horn YA1−2 0 C
XCB500 Connector Wiper motor Windscreen System OG1 2 D
XCB500 Connector Wiper motor Windscreen System OH1 1 C
XCB501BLF Connector Front lights 2 Left GB1−1 1 B
XCB501BLF Connector Front lights 2 Left GB1−2 0 B
2

2
XCB501BLF Connector Front lights 2 Left GC1−1 2 B
XCB501BLF Connector Front lights 2 Left GD2−1 2 B
XCB501BRF Connector Front lights 2 Right GB1−1 3 B
XCB501BRF Connector Front lights 2 Right GB1−2 3 B
XCB501BRF Connector Front lights 2 Right GC1−1 3 B
XCB501BRF Connector Front lights 2 Right GD2−1 3 B
XCB502 Connector Body interface Front lights GB1−1 2 C
XCB502 Connector Body interface Front lights GB1−2 1 D
XCB502 Connector Body interface Front lights GB2 2 B
XCB502 Connector Body interface Front lights GC1−1 2 C
XCB502 Connector Body interface Front lights GD2−1 2 C
XCB502 Connector Body interface Front lights YA1−1 2 D
XCB503 Connector Extra lights Rear GC1−2 1 D
XCB503 Connector Extra lights Rear GC2 0 A
XCB503 Connector Extra lights Rear GD1 2 D
XCB503 Connector Extra lights Rear GD3 1 B
XCB601F Connector Side Front lights Left GC1−1 1 B
XCB601F Connector Side Front lights Left GD2−1 0 C
XCB601M Connector Side−marker lights Left GC2 0 D
XCB601M Connector Side−marker lights Left ID3 3 D
XCB602F Connector Front lights Right GC1−1 4 B
3

3
XCB602F Connector Front lights Right GD2−1 4 C
XCB602M Connector Side−marker lights Right GC2 4 D
XCB602M Connector Side−marker lights Right ID3 4 D
XCB604M:1 CF1 2 C
XCB604M:3 CF1 2 D
XCB604M_1−3 CF1 2 D
XCB703R Connector Rear lights 2 Left GB2 2 D
XCB703R Connector Rear lights 2 Left GC1−2 2 D
XCB703R Connector Rear lights 2 Left GD1 1 D
XCB703R Connector Rear lights 2 Left GD2−2 2 D
XCB703R Connector Rear lights 2 Left GD3 2 D
XCB703R Connector Rear lights 2 Left ID1 2 C
XCB703R Connector Rear lights 2 Left VD4 2 C
XCB720R Connector Rear lights 3 Right GC1−2 4 D
XCB720R Connector Rear lights 3 Right GD1 3 D
XCB720R Connector Rear lights 3 Right GD2−2 3 C

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 35(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
XCB720R Connector Rear lights 3 Right GD3 3 D
XCB721R Connector Rear lights 3 Left GC1−2 0 D
XCB721R Connector Rear lights 3 Left GD1 0 D
XCB721R Connector Rear lights 3 Left GD2−2 1 C
XCB721R Connector Rear lights 3 Left GD3 1 D
XCB722R Connector Rear lights 1 Right GB2 3 D
XCB723R Connector Rear lights 1 Left GB2 1 D
XCB801F Connector Body interface 1 GB2 2 C
XCB801F Connector Body interface 1 GC1−2 1 B
XCB801F Connector Body interface 1 GC2 2 B
XCB801F Connector Body interface 1 GD1 1 C
XCB801F Connector Body interface 1 GD2−2 2 B
XCB801F Connector Body interface 1 GD3 2 B
XCB801F Connector Body interface 1 ID3 1 B
XCB801F Connector Body interface 1 VD4 1 B
XCB801F Connector Body interface 1 XE1−1 1 C
XCB801F Connector Body interface 1 XG1 2 C
XCB801F Connector Body interface 1 YA1−3 1 C
XCB801F Connector Body interface 1 YA1−4 1 D
1

1
XCB801F Connector Body interface 1 YA1−7 0 B
XCB801x Connector Body interface 1x YA1−7 0 C
XCB803F Connector Body interface 2 YA1−5 0 D
XCB803F Connector Body interface 2 YA1−6 0 D
XCB805 Connector Parking lights Front GA1 1 D
XCB805 Connector Parking lights Front GD2−1 4 D
XCB906 Connector Body Interface 4 YA1−2 3 C
XCG11 Pass Through ELC junction GND ZA1 1 D
XD:1 AB2 0 B
XD:1 ZA1 0 B
XD:2 AB2 2 C
XD:2 ZA1 0 B
XD:3 AB2 4 B
XD:3 ZA1 0 B
XD:4 ZA1 0 B
XD:5 ZA1 0 B
XD:6 ZA1 0 B
XD:7 ZA1 0 B
XD:8 ZA1 0 B
XD:9 ZA1 0 B
XD:10 ZA1 0 B
2

2
XD:11 ZA1 0 B
XD:12 ZA1 0 B
XE:1 ZA1 0 B
XF:1 FA1−1 2 B
XF:4 YA1−4 3 B
XF:12 YA1−4 3 B
XF:15 FA1−1 1 B
XF:18 YA1−1 3 B
XG:1 AA2 4 A
XG:1 YA1−1 4 B
XH:1 AB2 3 B
XJ:1 OG1 2 B
XJ:2 OG1 3 B
XJ:11 BF1 1 A
XJ:11 JD2 3 B
XJB101 Pass Through ELC junction B+ AA2 2 B
XJB102 Pass Through ELC junction +30 AA2 4 B
XJB201 Junction Box, Interface Batt/Front Fuse B AA2 1 B
XJB202 Junction Box, Interface BBox/Battery Main AA2 2 B
XJB601 Junction, I−Start Batt/Starter Motor AC1 0 B
XJB601 Junction, I−Start Batt/Starter Motor AD1 1 D
3

3
XK:3 OG1 1 B
XK:3 OH1 2 A
XK:6 OG1 3 B
XK:9 DA1 2 B
XK:12 DA1 1 B
XK:14 YA1−5 2 B
XL:1 BA1 0 B
XL:3 BA1 1 B
XL:4 EF1 2 B
XL:5 BA1 1 B
XL:7 DA1 3 B
XL:8 BD1−1 2 A
XL:8 BE1 1 A
XL:8 BG1 2 A
XM:1 AB2 4 B
XM:2 AB2 4 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 36(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
XM:3 AB2 4 B
XM:4 AB2 4 B
XM:11 AB2 3 B
XM:18 BD1−1 2 A
XM:18 BD1−2 1 A
XM:18 BG1 2 A
XO:1 AA2 4 A
XS−0022_01 EF1 2 C
XS−0095_01 CB1−4 0 B
XS−0178_01 AB2 0 C
XS−0190_01 FA1−2 1 B
XS−0190_01 FA2 1 C
XS−0202_01 FA5 1 C
XS−1020_01 EA1−2 3 E
XS−1021_01 BD1−3 3 D
XS−1021_01 EA1−1 3 D
XS−1021_02 BD1−3 2 B
XS−1021_02 EA1−1 2 C
XS−1021_02 YA1−6 2 C
1

1
XS−1022_01 AC1 2 C
XS−1023_01 CA1−2 1 B
XS−1023_01 CF1 2 D
XS−1024_01 BI1 2 C
XS−1037_01 FA3 2 D
XS−1038_01 FA3 3 C
XS−1050_01 CB1−2 3 C
XS−1050_01 EH3 3 B
XS−1050_02 CB1−2 2 D
XS−1051_01 CB1−2 1 C
XS−1051_01 CB1−4 2 C
XS−1051_01 EH3 2 B
XS−1051_03 CB1−4 2 D
XS−2002_01 AA2 2 A
XS−2002_02 AA2 2 A
XS−2002_03 YA1−2 3 C
XS−2003_01 AC1 2 C
XS−2003_02 BD1−1 2 C
XS−2003_02 BD1−2 1 B
XS−2003_02 BG1 2 C
XS−2003_03 BF1 1 B
2

2
XS−2003_04 DA2−1 1 B
XS−2003_05 DA2−1 1 D
XS−2003_06 EA1−1 1 C
XS−2003_08 ID1 2 B
XS−2003_08 ID3 3 C
XS−2003_10 JA1 1 C
XS−2003_11 BF1 1 B
XS−2003_11 JD2 3 B
XS−2003_13 BC1 1 C
XS−2003_14 FC2−2 2 C
XS−2003_15 JE1 1 B
XS−2003_15 JF1 2 B
XS−2004_01 AB2 4 B
XS−2004_02 AB2 4 D
XS−2004_03 AC1 2 B
XS−2004_04 BD1−1 2 C
XS−2004_04 BE1 1 B
XS−2004_04 BG1 2 C
XS−2004_05 BD1−2 3 B
XS−2004_06 BD1−2 3 B
XS−2004_06 CB1−1 2 C
3

3
XS−2004_07 DA2−1 2 B
XS−2004_07 DA2−2 2 B
XS−2004_09 JE1 2 B
XS−2004_18 AB2 4 B
XS−2004_18 EB1 2 A
XS−2004_18 ED1 1 B
XS−2004_18 EH1 1 B
XS−2004_18 FA2 3 C
XS−2004_18 GA1 1 A
XS−2004_18 VA2 4 C
XS−2005_02 JA1 1 C
XS−2005_03 OG1 1 C
XS−2005_03 OH1 2 B
XS−2005_04 OH1 1 C
XS−2005_06 JD2 4 B
XS−2005_06 JF1 2 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 37(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
XS−2018_01 CB1−3 1 B
XS−2018_01 CB1−5 2 C
XS−2040_01 BI1 2 C
XS−2042_01 CA1−1 1 C
XS−2042_02 CA1−1 2 C
XS−2042_03 CA1−1 2 C
XS−2042_04 FB1 2 B
XS−2042_04 FB4 1 B
XS−2050_01 CB1−2 1 C
XS−2050_01 EH3 2 B
XS−2077_01 FA3 2 C
XS−2078_01 FA3 3 C
XS−2096_01 CB1−4 4 C
XS−2097_01 CB1−4 1 C
XS−2097_01 EH3 1 B
XS−2098_01 CB1−4 1 C
XS−3006_01 GC1−2 2 B
XS−3007_01 GC1−2 2 B
XS−3008_02 GD1 1 D
1

1
XS−3009_02 GD1 2 C
XS−3010_01 GD3 2 C
XS−3012_01 GD2−2 2 C
XS−3013_01 GD2−2 2 C
XS−3014_01 GD2−1 2 C
XS−3014_02 GD2−1 0 C
XS−3015_01 GD2−1 2 C
XS−3015_02 GD2−1 4 C
XS−3026_01 GB2 2 D
XS−3027_01 GC2 2 C
XS−3027_03 YA1−3 3 B
XS−3027_04 GC2 0 C
XS−3028_01 GC2 2 C
XS−3028_03 GC2 4 C
XS−3028_04 GC1−1 3 C
XS−3029_01 GC1−1 2 C
XS−3032_01 GB1−1 3 C
XS−3032_02 GB1−2 3 D
XS−4002_01 OH1 2 C
XS−4002_02 OH1 3 C
XS−5004_01 AB2 2 C
2

2
XS−5006_01 ID3 3 E
XS−5006_02 YA1−4 2 C
XS−6001_01 AB2 1 C
XS−6001_01 BF1 2 B
XS−6001_01 EB1 2 A
XS−6001_01 GA1 3 B
XS−6001_01 JA1 3 C
XS−6001_01 JB1 1 B
XS−6001_01 VA2 4 D
XS−6001_02 ED1 1 B
XS−6001_02 EH1 1 B
XS−6001_02 FA2 1 C
XS−6001_02 FA5 2 C
XS−6001_02 GA1 3 B
XS−6002_01 ID3 1 D
XS−7052_01 AC1 2 C
XS−GND_01 DA2−1 2 D
XS−GND_03 JA1 1 C
XS:1 AB2 4 B
XSC−7001_01 XA1 1 A
XSC−7001_02 XA1 2 A
3

3
XSC−7001_03 XA1 2 A
XSC−7001_04 XA1 3 A
XSC−7001_05 XA1 3 A
XSC−7001_06 XA1 5 A
XSC−7001_07 XA1 5 C
XSC−7001_08 XA1 4 C
XSC−7001_09 XA1 4 C
XSC−7001_10 XA1 2 C
XSC−7001_11 XA1 2 C
XSC−7001_12 XA1 3 C
XSC−7002_01 XA1 1 A
XSC−7002_02 XA1 2 A
XSC−7002_03 XA1 2 A
XSC−7002_04 XA1 3 A
XSC−7002_05 XA1 3 A
XSC−7002_06 XA1 5 A

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 38(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
XSC−7002_07 XA1 5 C
XSC−7002_08 XA1 4 C
XSC−7002_09 XA1 4 C
XSC−7002_10 XA1 2 C
XSC−7002_11 XA1 2 C
XSC−7002_12 XA1 4 C
XSC−7003_01 XB1 1 B
XSC−7003_02 XB1 3 B
XSC−7003_03 XB1 3 B
XSC−7003_04 XB1 5 B
XSC−7003_05 XB1 1 B
XSC−7003_06 XB1 2 B
XSC−7003_07 XB1 2 B
XSC−7004_01 XB1 1 B
XSC−7004_02 XB1 3 B
XSC−7004_03 XB1 3 B
XSC−7004_04 XB1 5 B
XSC−7004_05 XB1 1 B
XSC−7004_06 XB1 2 B
1

1
XSC−7004_07 XB1 2 B
XSC−7007_01 XD1 2 A
XSC−7007_02 XD1 3 A
XSC−7008_01 XD1 3 A
XSC−7008_02 XD1 3 A
XSC−7011_02 XH1 3 A
XSC−7011_03 XH1 4 A
XSC−7011_04 XH1 5 C
XSC−7011_05 XH1 3 C
XSC−7011_06 XH1 2 C
XSC−7012_02 XH1 3 A
XSC−7012_03 XH1 4 A
XSC−7012_04 XH1 5 B
XSC−7012_05 XH1 3 B
XSC−7012_06 XH1 2 B
XSC−7013_01 XF1 1 A
XSC−7013_02 XF1 2 A
XSC−7013_04 XF1 4 A
XSC−7013_05 XF1 3 A
XSC−7013_06 XF1 4 C
XSC−7014_01 XF1 1 B
2

2
XSC−7014_02 XF1 2 B
XSC−7014_04 XF1 4 B
XSC−7014_05 XF1 3 B
XSC−7015_01 XE1−1 1 B
XSC−7015_02 XE1−1 3 B
XSC−7015_03 XE1−1 4 B
XSC−7015_04 XE1−1 2 B
XSC−7015_05 XE1−1 3 B
XSC−7016_01 XE1−1 2 B
XSC−7016_02 XE1−1 4 B
XSC−7016_03 XE1−1 4 B
XSC−7016_04 XE1−1 3 B
XSC−7016_05 XE1−1 3 B
XSC−7017_01 XM1 2 B
XSC−7018_01 XM1 2 B
XSC−7021_01 XE1−2 1 B
XSC−7022_01 XE1−2 1 C
XSC−7044_01 XJ1 2 A
XSC−7045_01 XJ1 2 B
XSC−7097_01 XO1 2 C
XSC−7097_02 XO1 3 B
3

3
XSC−7098_01 XO1 2 C
XSC−7098_02 XO1 3 B
XSCG−EXTL−21 Medium current ground ZA1 2 C
XSCG−EXTL−31 GB1−1 1 B
XSCG−EXTL−31 GB1−2 0 B
XSCG−EXTL−31 GB2 1 A
XSCG−EXTL−31 ZA1 2 B
XSCG−EXTL−32 GB1−1 2 B
XSCG−EXTL−32 GB1−2 3 B
XSCG−EXTL−32 GB2 2 A
XSCG−EXTL−32 ZA1 2 B
XSCG−EXTL−33 GC1−1 1 B
XSCG−EXTL−33 GD2−1 0 C
XSCG−EXTL−33 ZA1 2 B
XSCG−EXTL−34 GB1−2 2 C
XSCG−EXTL−34 ZA1 3 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 39(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
XSCG1−21 ZA1 1 C
XSCG1−22 OG1 3 D
XSCG1−22 OH1 2 C
XSCG1−22 ZA1 1 C
XSCG1−31 Low Current Ground BE1 1 C
XSCG1−31 Low Current Ground BE2 2 C
XSCG1−31 Low Current Ground BF1 1 E
XSCG1−31 Low Current Ground DA1 2 D
XSCG1−31 Low Current Ground DA2−1 3 D
XSCG1−31 Low Current Ground DA2−2 3 D
XSCG1−31 Low Current Ground FC2−2 2 E
XSCG1−31 Low Current Ground JA1 0 B
XSCG1−31 Low Current Ground VA2 3 C
XSCG1−31 Low Current Ground ZA1 1 B
XSCG1−32 AB2 1 D
XSCG1−32 EB1 2 B
XSCG1−32 GA1 3 E
XSCG1−32 ZA1 1 B
XSCG1−33 ED1 1 C
1

1
XSCG1−33 EH1 1 B
XSCG1−33 FA2 1 D
XSCG1−33 FA5 2 D
XSCG1−33 GA1 1 B
XSCG1−33 ZA1 1 B
XSCG1−34 BC1 1 D
XSCG1−34 JD2 4 D
XSCG1−34 JF1 2 C
XSCG1−34 ZA1 1 B
XSCG1−36 BD1−1 1 E
XSCG1−36 BG1 2 D
XSCG1−36 EG1 2 E
XSCG1−36 JE1 1 C
XSCG1−36 ZA1 1 B
XSCG2−21 Medium current ground AA2 4 C
XSCG2−21 Medium current ground CE1 2 D
XSCG2−21 Medium current ground FA1−2 1 D
XSCG2−21 Medium current ground FC2−1 2 E
XSCG2−21 Medium current ground ZA1 3 C
XSCG5−21 Medium current ground FA3 1 D
XSCG5−21 Medium current ground FA5 1 E
2

2
XSCG5−21 Medium current ground ZA1 3 C
XSCG5−31 Low Current Ground EB1 2 E
XSCG5−31 Low Current Ground FD1 1 D
XSCG5−31 Low Current Ground ZA1 3 B
XSCG6−11 High current ground ZA1 4 D
XSCG6−21 Medium current ground AC1 3 D
XSCG6−21 Medium current ground CE2 1 D
XSCG6−21 Medium current ground DA1 1 C
XSCG6−21 Medium current ground FD1 2 D
XSCG6−21 Medium current ground GC2 1 D
XSCG6−21 Medium current ground ZA1 4 C
XSCG6−22 Medium current ground CA1−2 4 D
XSCG6−22 Medium current ground CA1−3 1 C
XSCG6−22 Medium current ground ZA1 4 C
XSCG6−23 Medium current ground CB1−1 1 E
XSCG6−23 Medium current ground CB1−3 1 D
XSCG6−23 Medium current ground CB1−5 2 C
XSCG6−23 Medium current ground ZA1 4 C
XSCG6−31 AC1 1 E
XSCG6−31 CA1−1 2 B
XSCG6−31 CI1 3 D
3

3
XSCG6−31 FB4 3 D
XSCG6−31 FD1 2 D
XSCG6−31 ZA1 4 B
XSCG6−32 GB2 3 D
XSCG6−32 GC1−2 4 D
XSCG6−32 ZA1 4 B
XSCG6−33 GB2 0 D
XSCG6−33 GC1−2 0 D
XSCG6−33 ZA1 4 B
XT:1 AA2 4 A
Y02 Solenoid valve, differential lock, rear EB1 2 E
Y11 Solenoid valve unit, ABS, front left EA1−2 3 D
Y12 Solenoid valve unit, ABS, front right EA1−2 3 D
Y25 Solenoid valve unit, level control, air FA3 1 D
Y36 Solenoid valve, steerable axle FD1 2 D
Y37 Solenoid Valve Unit Engine brake / AVU (A CA1−2 3 B

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 40(44)

D

A
C

B
E
 D

A
C

B
E
0

0
REF DESCRIPTION PAGE
Y40 Solenoid valve unit, front axle, air sus FA1−2 1 D
Y80B Solenoid valve, AdBlue dosing unit CB1−4 0 C
Y81C Solenoid valve, AdBlue tank heating CB1−4 1 C
Y147 Solenoid Valve Cooling Fan / Shut off Val CA1−3 3 B
Y158 Solenoid Valve, Automat Park Break Evac V EF1 2 C
Y159 Solenoid Valve, Automat Park Break Evac V EF1 3 C
Y160 Solenoid Valve Fuel Cut Off CE1 2 C
Y162B Solenoid Valve Unit Body Heating /AVU (Ai CA1−3 1 B
Y163 Solenoid Valve Unit Air Suspension Boogie FA5 1 D
Y169A Valve Air Inlet FB4 1 C
Y170 Valve Air Outlet FB4 3 D
1

1
2

2
3

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 41(44)

D

A
C

B
E
 D

A
C

B
E
EQUIPOTENTIAL LIST
0

0
EQPOT__DESCRIPTION EQPOT__DESCRIPTION
1 {Generic ground} 0143 {GECU Ishift PMO 3}
0002 {Electrical air drier enable valve B} 0144 {GECU Ishift PMO 4}
0003 {Air tank pressure} 0145 {GECU Ishift PMI 1}
0011 {Speed Signal C3} 0146 {GECU Ishift PMI 2}
0018 {Hydralic oil level 1} 0147 {GECU Ishift PMI 3}
0019 {Hydralic oil level 2} 0148 {GECU Ishift PMI 4}
0020 {Hydralic oil pressure} 0157 {LCM Flash−to−pass Request}
0021 {Steerible Bogie Axle Position Switch Output} 0158 {LCM High/low beam Request}
0022 {Speed signal 5 km/h } 0159 {LCM Dir Ind Left Request}
0022 {Speed signal 5 km/h} 0160 {LCM Dir Ind Right Request}
0023 {APBE Control 1} 0161 {LCM LCP Input 1}
0024 {APBE Control 2} 0162 {LCM LCP Input 2}
0031 {Thrird Brake Pressure Sensor Signal} 0163 {LCM Front Foglights Request}
0036 {DPF Pressure} 0164 {LCM Rear Foglights Request}
0037 {DPF Temp} 0165 {Hazard Request}
0038 {CAT temp downstream} 0166 {Hazard Indication}
0039 {CAT temp upstream} 0167 {Dashboard illumination control}
0043 {EBS FBM Signal 2} 0168 {Instr Switch Select}
0044 {EBS FBM Switch 1} 0169 {Instr Switch Escape}
0170 {Instr Switch Up}
1

1
0045 {EBS FBM Signal 1}
0046 {EBS Diff Lock Request} 0171 {Instr Switch Down}
0047 {Auto Diff Lock Request} 0173 {SWS Comunication}
0048 {EBS Diff Lock Control} 0174 {CC Time Gap −}
0049 {Diff Lock Indicator} 0175 {CC Time Gap +}
0056 {EBS DA LWS A Signal} 0178 {Main switch Signal}
0057 {EBS DA LWS B Signal} 0179 {Relay control +30 hold}
0058 {EBS DA WSS A1} 0180 {Alcolock Driver Change Request}
0059 {EBS DA WSS A2} 0182 {Cruise Control Resume Accelerate}
0060 {EBS DA WSS B1} 0183 {Cruise Control Decelerate}
0061 {EBS DA WSS B2} 0184 {Cruise Control Resume}
0062 {EBS PCV Outlet Valve R} 0185 {Cruise Control Enable}
0063 {EBS PCV Inlet Valve R} 0186 {Retarder set −}
0064 {EBS PCV Outlet Valve L} 0187 {Retarder set +}
0065 {EBS PCV Inlet Valve L} 0188 {ECS front solenoid valve 1}
0066 {Brake Air Pressure Sensor 1 Signal} 0189 {ECS front solenoid valve 2}
0067 {Brake Air Pressure Sensor 2 Signal} 0190 {ECS front solenoid valve 3}
0068 {EBS HCS Request} 0191 {ECS front axle pressure}
0069 {ECS HCS Status} 0193 {ECS Chassis Level Front Axle}
0070 {ECS TCS Request} 0194 {ECS Axle 2 Level Ctrl Central}
0071 {ECS TCS Status} 0195 {ECS Axle 2 Level Ctrl Left}
2

2
0072 {Parking Brake Applied} 0196 {ECS Axle 2 Level Ctrl Right}
0073 {Parking Brake Applied} 0197 {ECS Axle 2 Pressure Left}
0074 {Retarder Enable Request} 0198 {ECS Axle 2 Pressure Right}
0075 {Retarder Stalk Signal} 0199 {ECS Axle 2 Level Left}
0076 {I−start charge status} 0200 {ECS Axle 2 Level Right}
0079 {Accelerator Pedal Position} 0202 {ECS Axle 3 Level Ctrl Central}
0080 {Accelerator Pedal IVS} 0213 {ECS Activate Kneel}
0081 {Accelerator Pedal IVS supply} 0214 {ECS Cancel Kneel}
0083 {Adbluetank level control} 0215 {Main switch relay signal}
0084 {Adbluetank temp control} 0216 {ECS Boogie lift request}
0085 {Engine start request rear} 0218 {ECS Kneel Down}
0087 {Engine stop request rear} 0219 {ECS Kneel Up}
0088 {Adblue Pressure} 0220 {Switch Air Susp Function LED}
0089 {Fan 1 speed +} 0222 {Tachograph info output}
0090 {Adblue pressure} 0223 {Wheel speed sens sign}
0091 {Adblue air temp control} 0224 ARMS
0092 {Adblue air valve on/off} 0227 {Wheel speed sens Data sign}
0093 {Adblue tank heating valve on/off} 0229 {Washer Fluid Low Level}
0094 {Adblue heater hose control 1} 0232 {DACU Seat Haptic Ctrl Left}
0095 {Adblue heater hose control 2} 0233 {DACU Seat Haptic Ctrl Right}
0234 {DACU Seat Haptic Ctrl Left Gnd}
3

0096 {Adblue dosage pump ls}

3
0097 {Adblue dosage pump hs} 0235 {DACU Seat Haptic Ctrl Right Gnd}
0098 IVS 0236 {DACU PWM 1}
0099 {Retarder PWM control} 0237 {DACU LDWS Switch}
0100 {Retarder air pressure} 0238 {DACU AEBS Switch}
0101 {Retarder oil temp} 0239 {BBM PWM 2}
0102 {Retarder water temp} 0272 {Body heating valve}
0106 {Air filter indicator, signal} 0273 {Shut Off Valve}
0107 {Water in fuel sensor} 0313 {Air Inlet Valve}
0109 {Wiper Position Sign} 0314 {Air Outlet Valve}
0110 {Coolant level sensor} 0315 {Water heater relay ctrl 1}
0111 {Air Inlet Temp} 0316 {Water heater relay ctrl 2}
0113 {Fuel Level Sensor 1 Signal} 0317 {Water heater 1}
0114 {Fuel Level Sensor 2 Signal} 0318 {Water heater 2}
0140 {Gearbox supply control 2} 0334 {AVU control PWM}
0141 {GECU Ishift PMO 1} 0335 {Alternator CM signal}
0142 {GECU Ishift PMO 2} 0349 {Fuel Quality Signal}

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 42(44)

D

A
C

B
E
 D

A
C

B
E
0

0
EQPOT__DESCRIPTION EQPOT__DESCRIPTION
0372 {Electrical air drier enable valve A} 3009 {Brake lamp. Right}
1001 {VECU Analog ground} 3010 {Reverse Lights}
1004 {EBS 3rd Modulator Ground} 3011 {Reverse warning signal, relay output }
1007 {EBS Brake Pressure Sensor Ground} 3011 {Reverse warning signal, relay output}
1008 {LPOS − FLS Low Ref} 3012 {Park lights, side tail left}
1012 {EBS FBM Ground} 3013 {Park lights side tail right}
1013 {EBS ESP Sensors ground} 3014 {Park lights side left}
1014 {EBS Front Modulator Ground} 3015 {Park lights side right}
1015 {EBS Drive Axle Modulator Ground} 3016 {Headlamp low beam right}
1018 {EBS Drive Axle LWS A ground} 3017 {Brake pedal applied}
1019 {EBS Drive Axle LWS B ground} 3021 {Alarm / Hazard light}
1020 {EBS PCV Valves ground} 3022 {Hazard activation}
1021 {IC Sensor ground} 3026 {Foglights rear}
1022 {LIN GND} 3027 {Park and destignation lights}
1023 {Engine Switch & Sensor ground} 3030 {Headlamp high beam right}
1024 {VECU Analog ground} 3032 {Day running light}
1025 {Engine Sensor ground} 3036 {Bi−xenon light shutter left}
1026 {Fan 1 & 2 speed −} 3037 {Bi−xenon light shutter right}
1036 {SWS Ground} 3046 {Foglamp/Cornering lamp left}
1

1
1037 {ECS Sensor Ground} 3047 {Foglamp/Cornering lamp right}
1038 {ECS Sensor Ground} 3048 {Extra High beam left and right}
1050 {Temp sensor ground} 3059 {Direction Indicator left}
1051 {ACM Sensor ground} 3059 {Direction indicator left}
2001 Bpol+ 3060 {Direction Indicator right}
2002 B+ 3060 {Direction indicator right}
2003 +30 4001 {Stalk switch, Windscreen wiper, low speed}
2004 +DR 4002 {Stalk switch, Windscreen wiper, wash}
2005 +15 4003 Horn
2006 +50 4009 {Wiper interval relay}
2007 {+30 VECU hold} 4015 {Stalk switch, Windscreen wiper, pulse}
2010 {VECU Sensor Supply 2} 4016 {Stalk switch, Windscreen wiper, high speed}
2017 {FCW LED Supply} 4191 {Radio Mute}
2019 {Steerable Axle Valve supply} 4192 {Antenna Out}
2020 {APBE Supply} 5001 {Engine Door Switch}
2021 {EBS 3rd Modulator Supply} 5003 {External main switch }
2024 {Brake sensor supply} 5004 {Emergency switch}
2027 {LPOS Power Supply} 5005 {Door switch}
2028 {FLS Sensor Power Supply} 5006 {Luggage door switch}
2029 {EBS FBM Supply} 5007 {Alcolock Mode Request}
2030 {EBS ESP Sensors supply} 5008 {Heat sensor signal}
2

2
2033 {EBS DA LWS A Supply} 5009 {Heat sensor}
2034 {EBS DA LWS B Supply} 5010 {Seat belt reminder}
2035 {EBS Front Modulator Supply} 5012 {Audible hazard warning indication}
2036 {EBS Drive Axle Modulator Supply} 6001 {Dimmer, dashboard illumination }
2037 {Brake Air Pressure Sensor 1 Supply} 6001 {Dimmer, dashboard illumination}
2038 {Brake Air Pressure Sensor 2 Supply} 6002 {Luggage light outputs}
2040 {VECU Sensor Supply 1} 7001 {J1939−1/Backbone 1 CAN H}
2042 {Power supply VPDUR} 7002 {J1939−1/Backbone 1 CAN L}
2050 {V5EXT1 Supply} 7003 {Backbone 2 CAN H}
2071 {SWS Supply} 7004 {Backbone 2 CAN L}
2072 {Bpol+ (+12V)} 7005 {PT Subnet CAN H}
2073 {Power Supply Service and Starter switch} 7006 {PT Subnet CAN L}
2075 {Main switch enable} 7007 {Engine Subnet CAN H}
2076 {VECU Stalk Switch Supply} 7008 {Engine Subnet CAN L}
2077 {ECS Sensor Supply} 7011 {J1587/1708 A}
2078 {ECS Sensor Supply} 7012 {J1587/1708 B}
2081 {Starter Motor} 7013 {D−BUS CAN H}
2082 {I−Start 12V} 7014 {D−BUS CAN L}
2084 {I−Start 24V} 7015 {J1939−2−3 CAN H}
2085 {ECS Supply Relay Control} 7016 {J1939−2−3 CAN L}
2086 {ECS Supply} 7017 {Safety Subnet 2 CAN H}
3

3
2090 {Wheel speed sens sply} 7018 {Safety Subnet 2 CAN L}
2095 {Stalk switch, Windscreen wiper, pulse sign} 7019 {E−Bus CAN H}
2096 {ACM Sensor Supply} 7020 {E−Bus CAN L}
2097 {Actuator Supply1} 7021 {J1939−2 CAN H}
2098 {Actuator Supply2} 7022 {J1939−2 CAN L}
2099 {Haptic Seat Motor Sply Left} 7023 {EBS 3rd Modulator CAN H}
2100 {HAptic Seat Motor Sply Right} 7024 {EBS 3rd Modulator CAN L}
2102 {B+ (12V)} 7027 {EBS ESP Sensors CAN H}
2103 {+30 (12V)} 7028 {EBS ESP Sensors CAN L}
2108 {Nox supply} 7029 {EBS Front Modulator CAN H}
3001 {Headlamp High Beam left} 7030 {EBS Front Modulator CAN L}
3002 {Extra main beam, relay output } 7031 {EBS Drive Axle Modulator CAN H}
3002 {Extra main beam, relay output} 7032 {EBS Drive Axle Modulator CAN L}
3003 {Headlamp low beam left} 7035 {SLCM LIN3}
3008 {Brake lamp, Left} 7044 {ZF CAN_H}
3009 {Brake lamp. Right } 7045 {ZF CAN_L}

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 43(44)

D

A
C

B
E
 D

A
C

B
E
0

0
EQPOT__DESCRIPTION EQPOT__DESCRIPTION
7050 {AIC Sign RS485−} 8023 {Any door open}
7051 {AIC Sign RS485+} 8025 {Full dump}
7052 {LIN2 CCIOM} 8026 {Pinch protection}
7067 {ZF CAN Termination} 8027 {Head lamp off}
7097 {VDS−CAN H}
7098 {VDS−CAN L}
8001 {Alternator charging }
8001 {Alternator charging}
8002 {Speed signal C6}
8003 {Speed signal X km/h }
8003 {Speed signal X km/h}
8004 {Body indicator}
8005 {Body indicator}
8006 {Low priority loads}
8007 {Idle switch}
8008 {Start disable}
8009 {Heat sensor alarm body}
8010 {AC 1}
8011 {Disable AC}
1

1
8012 {Prevent ECS action}
8013 {Glass heating}
8014 {Host call}
8015 {Door failure}
8016 {Door brake status}
8017 {AC 1 50 percent}
8018 {Indoor temp}
8019 {Outdoor temp}
8021 {Next stop indicator}
8022 {Pram indicator}
2

2
3

Document title
4

WIRING DIAGRAM
Document type
PRODUCT SCHEMATICS
Document No Issue Volume Sheet No

70402006 05 03(03) 44(44)

D

A
C

B
E
 Engineering Release Location Change Description A = Added W = Was Document Release Status
Notice (ERN) U = Deleted
RELEASED
Date Modification Count
See DCN

WIRING DIAGRAM INDEX, TELEMATICS

NAME DESCRIPTION PAGE NAME DESCRIPTION PAGE
JD1-1 AIC4 – INTERFACE CONNECTIONS 03 JG1 VEHICLE INTERFACE 10
JD1-3 HM MODEM 04 XA1A BACKBONE 1 11
JD1-4 TELEMATICS SIGNAL INDICATOR 05 XB1A BACKBONE 2 12
JD1-5 AIC4 – I-COACH 06 XE1A CAN 2/3 13
JD2 AIC4 – POWER SUPPLY 07 XE1C FMS – CAN 14
TGW2 – POWER SUPPLY & D – BUS
JE1 08 XF1A 15
GROUNDING
JF1 FMS – GW 09 XH1A J1587 16

VOLUME NO CONTENT PAGES

01 WIRING DIAGRAM 1-16
02 BILL OF MATERIAL/COMPONENT LIST 1-2

Document Title
The copying, distribution and utilization of this document as well as the WIRING DIAGRAM
communication of its contents to others without expressed authorization
is prohibited. Offenders will be held liable for payment of damages. All TELEMATICS – EURO6
rights reserved in the event of the grant of a patent, utility model or
ornamental design registration. BRIDGE PLAN

Document Type
EDM-W 2000-04-01

PRODUCT SCHEMATIC
Owner Domain:Document Prefix

Volvo Bus Corporation Document No Issue Index Volume No Page No

22087802 03 01(02) 1(16)

ABREVIATIONS

AIC Advanced Information Cluster

BB Body Builder
FMS Fleet Management System
GND Ground
GPS Global Positioning System
GSM Global System for Mobile Communications
H High
HDI High Digital Input
I/O Input / Output
L Low
RX Receiver
SPLY Supply
SRC Source
TGW Telematics Gateway
TX Transmitter
USB Universal Serial Bus
WLAN Wireless Local Area Network

Document Title
WIRING DIAGRAM
Document Type
PRODUCT SCHEMATIC
Volvo Bus Corporation Document No Issue Index Volume No Page No

22087802 03 01(02) 2(16)

 0 1 2 3 4
AIC4 − INTERFACE CONNECTIONS JD1−1

A A
A201
USB Audio Control AIC Digital Input Ethernet RJ−45

Digital_Output
Control unit, AIC

Transmit_(+)

Transmit_(−)
ACC_(12V)

Receive_(+)
Camera PIP

Receive_(−)
(Advanced Information Cluster)

Wake_Up

ACC_(~)
External

Camera
VBUS

Driver
Cabin
GND
D−

D+

nc

nc

nc

nc
GND Gnd SPK Audio_L Audio_R
E 1 E 2 E 3 E 4 5 E A 20 A 21 A 22 A 4 A 5 A 6 B 1 B 3 B 5 B 8 A 19 A 10 F 1 F 2 F 3 F 4 F 5 F 6 F 7 F 8

0.75WH/BN 0.75WH/YE 0.75WH/GN 0.75BN 0.75YE 0.75GN

4012 4013 4014 4128 4129 4130
0.75WH/BK 0.75BU 0.75VT 0.75WH/GY 0.75BN 0.75YE
External Cable
1046 4010 4011 4006 4007 4008
External Cable

B B

ENET:1

ENET:2

ENET:3

ENET:6
XC931
Ethernet RJ−45

USB

C C

X126 4 5 6 1 2 3 1 3 4 7 8 9 X127
Connector, BB Connector, BB
Speaker Right

Digital output
Audio Control − External

Digital Input Camera PIP

Accelerometer Sensor Sply

Audio Control − Cabin

Accelerometer Sensor
Digital Input Camera
Ground

Speaker Left

Digital Input
Audio Control − Driver

(Body Builder) Amplifier (Body Builder)

I/O Interface 1

D D

BB Amplifier Connector BB AIC I/O

Interface

E E
TELEMATICS
22087802 03 01 03(16)
2013−06−04 03

0 1 2 3 4
 0 1 2 3 4

Bpol+ HM MODEM JD1−3

B+
+30
+DR
+15
A A
XSC−XC021:4

0.75RD VBC149.5
2002 JD2:0 B

0.75WH/OG
2088

B B
A 6 A 13

SRC B+
A203

ON/OFF
PWR
AIC
Control unit, AIC
GPS
Modem (Advanced Information Cluster)
GSM Modem
RS232 RS232
GPS Modem

TX

RX

RX
TX
GND Gnd Gnd Gnd
A 5 A 14 A 12 A 11 A 10 A 4 A 3

0.75BK 0.75WH/BK 0.75GN 0.75YE

0.75YE 0.75WH/BK 0.75GN
1 1047 7047 7046 1048 7049 7048
XSCG−TELE

C C

B 11 B 13 B 12 B 14 B 16 B 15

GND Gnd
RX
GND Gnd A201

RX
TX

TX
Control unit, AIC
RS232 RS232 (Advanced Information Cluster)
GPS Modem

D AIC D

E E
TELEMATICS
22087802 03 01 04(16)
2013−06−04 03

0 1 2 3 4
 0 1 2 3 4
Telematics Signal Indicator JD1−4

Bpol+
A B+ A
+30
+DR
+15

A202 XSC−XC021:5

SIGN 5 4 3 2 1
Control unit, AIC
(Advanced Information Cluster)
Sign unit

SIGN 5 4 3 2 1

SIGN 5 4 3 2 1
B B
SIGN 5 4 3 2 1

5 4 3 2 1

AIC

SUPLY

GND
SIGN + −
A 3 A 2 A 5 A 4

0.75YE 0.75GN 0.75RD/GN 0.75BK

7051 7050 2005 1

C XSCG−TELE
C

A 14 A 15

+ −
A201
Control unit, AIC
RS485 (Advanced Information Cluster)
D AIC
D

E E
TELEMATICS
22087802 03 01 05(16)
2013−10−15 03

0 1 2 3 4
 0 1 2 3 4
AIC4 − I−COACH JD1−5
Bpol+
B+
+30
A +DR A
+15

XSC−XC021:5

0.75RD/GN

A208
I−COACH Control unit, I−Coach
B B

A 1 A 2 A 3 A 4 A 5

0.75YE 0.75GN 0.75BK 0.75BK

7051 7050 1 1

XSC−A208

C 0.75BK
1
C
2005

XSCG−TELE

C 3 C 2 A 2

+ − A201
Control unit, AIC
RS485 (Advanced Information Cluster)

AIC
D D

E E
TELEMATICS
22087802 03 01 06(16)
2013−10−15 03

0 1 2 3 4
 0 1 2 3 4
AIC4 − POWER SUPPLY & GROUNDING JD2

Bpol+
B+
A +30 A
+DR
+15
XC021.1
JG1:1 D
XSC−XC021:5 XSC−XC021:4

1.0RD
2003
XSC−A201 0.5RD/GN 0.5RD
2005 2002

0.75RD 0.75RD
2003 2003

B (1) 86 X2 4 X2 1 X2 9
B
VBC149 (3)
30 A203.A13
JD1−3:2 B M S77
Relays Switch,
AIC modem (5) 87 87a (4)
Emergency call
(2) 0 1
85
X2 6 X2 8 X2 10 X2 2
0.75WH/OG
2088

0.75RD 0.5VT
2003

C B
SRC
2

+30 LSD
A 7

Rel_Ctrl
B
HDI
4

Emerge_Sw
A
SRC
3

+15
A
SRC B+
1

A201
C
PWR PWR PWR Control unit, AIC
(Advanced Information Cluster)
5V

AIC
An_IN

SRC SPLY GND Gnd Gnd GND GND

A 17 A 18 A 16 A 20 A 2

0.75BK
1

XSCG−TELE
D D

A 4 A 1 A 2 A 3 A 5
A205
Control unit, AIC
(Advanced Information Cluster)
AIC2
SATELLITE Satellite

E E
TELEMATICS
22087802 03 01 07(16)
2013−06−04 03

0 1 2 3 4
 0 1 2 3 4
TGW2 − POWER SUPPLY & GROUNDING JE1
Bpol+
B+
+30
+DR
A +15 A
XSC−XC021:2

0.5RD
2003

XC021.3
JG1:1 D
0.5GY
4225

0.5RD/GN
20 XC021
2004 Connector, Telematics Interface
B B

XSC−XC021:3

0.5RD/GN 0.5RD/GN
2004 2004

X1 1 X1 2 X1 24 X1 27
A125

INFO−IF
SRC +30 SRC +DR SRC +R

Control unit, TGW

(Telematics Gateway)
PWR PWR PWR TGWII
GPS

GSM
C USB Ethernet
WLAN
C
Gnd VBUS D− D+ GND ID TX+ TX− Wake−Up Reset RX+ RX−
GND

X1 35 X2 1 X2 8 X2 9 X2 5 X2 4 X3 3 X3 4 X3 5 X3 6 X3 7 X3 8
0.5BK
1

XSCG−TELE

D D

E E
TELEMATICS
22087802 03 01 08(16)
2013−10−15 03

0 1 2 3 4
 0 1 2 3 4
FMS−GW JF1
Bpol+
B+
+30
A +DR A
+15

XSC−XC021:2 XSC−XC021:5

0.75RD 0.75RD/GN
2003 2005

B B

A 1 A 3

SRC kl.30 SRC kl.15 A22

PWR PWR
Control unit, FMS
(Fleet Management System)

C GND Gnd
FMS gateway C
A 16

0.75BK
1
XSCG−TELE

D D

E E
TELEMATICS
22087802 03 01 09(16)
2013−06−04 03

0 1 2 3 4
 0 1 2 3 4
VEHICLE INTERFACE JG1

Bpol+
B+
A +30 A
+DR
+15

XSC−XC021:2 XSC−XC021:4 XSC−XC021:5

B B
1.0RD 1.0RD 1.0RD/GN
2003 2002 2005

JD2:0 B
XSC−A201
JE1:2 B
XSC−XC021:3

XSCG−TELE
C 1.0RD 0.5RD/GN
C
2003 2004 4.0BK
1

1 2 3 4 5 19
XC021
Connector, Telematics Interface

D D

E E
TELEMATICS
22087802 03 01 10(16)
2013−06−04 03

0 1 2 3 4
 0 1 2 3 4
BACKBONE 1 XA1A

A A

B B

XSC−J1939−1L_1

XSC−J1939−1H_1

0.5YE 0.5YE 0.5GN 0.5GN

7001 7001 7002 7002

C C
6 7 8 9 XC021
Connector, Telematics Interface

0.5GN 0.5YE
7002 7001

6 7

CAN L CAN H A22

Control unit, FMS
(Fleet Management System)

D D

E E
TELEMATICS
22087802 03 01 11(16)
2013−06−04 03

0 1 2 3 4
 0 1 2 3 4
BACKBONE 2 XB1A

A A

XSC−BB2L
B 0.5GN
7004
XSC−BB2H
0.5GN
7004 B
0.5OG 0.5OG
7003 7003

0.5OG 0.5GN
7003 7004

C C
X1 37
X1 36

CAN L
CAN H
1 2 3 XC020−1 1 2 3 XC020−2
Connector, Telematics Interface BB2 Connector, Telematics Interface BB2

A125
Control unit, TGW
(Telematics Gateway)

D D

E E
TELEMATICS
22087802 03 01 12(16)
2013−06−04 03

0 1 2 3 4
 0 1 2 3 4
CAN 2/3 XE1A

A A

B B
XSC−J19392−3L_1 XSC−J19392−3L_2
0.5GN 0.5GN 0.5GN
7016 7016 7016
XSC−J19392−3H_1 XSC−J19392−3H_2
0.5YE 0.5YE 0.5YE
7015 7015 7015

C C
0.5YE 0.5YE 0.5GN
0.5GN
7015 7016 7015 7016

X1 15X1 16 C 17 C 18

XC021
CAN H

CAN L

CAN H

CAN L
22 23 24 25
Connector, Telematics Interface

A125
A201
Control unit, TGW
(Telematics Gateway) Control unit, AIC
D (Advanced Information Cluster) D

E E
TELEMATICS
22087802 03 01 13(16)
2012−11−27 03

0 1 2 3 4
 0 1 2 3 4

FMS−CAN XE1C

A A

XSC−J1939FMSH−1
0.5YE
7021
B B
XSC−J1939FMSL−1
0.5GN
7022

0.5YE 0.5GN
7021 7022 0.5GN 0.5YE
7022 7021
C C

A 14 A 13 C 16 C 14

CAN L
CAN H

CAN L

CAN H
17 16 XC021

A22 A201
Control unit, FMS Control unit, AIC
D (Fleet Management System) (Advanced Information Cluster) D

E E
TELEMATICS
22087802 03 01 14(16)
2014−04−22 03

0 1 2 3 4
 0 1 2 3 4

D−BUS XF1A

A A
B7900/8900 B9700

Connector, Telematics Interface

13 12
XC021 2 3 XBDBUS

B 0.75GN
7014
0.75YE
7013 0.75GN
7014
0.75YE
7013
B

XSC−DBUS−H_1 XSC−DBUS−H_2

C 0.75YE 0.75YE
C
0.75YE 0.75YE
7013 7013 7013 7013

13 A 12 A 11 A 13 A 12 A 11 A
CAN L

CAN H

CAN L

CAN H
TERM

TERM
A201 A201
Control unit, AIC Control unit, AIC
(Advanced Information Cluster) (Advanced Information Cluster)

D D

E E
TELEMATICS
22087802 03 01 15(16)
2014−04−22 03

0 1 2 3 4
 0 1 2 3 4
J1587 XH1A

A A

XSC−J1587A_1 XSC−J1587A_2
0.5GY
7011
XSC−J1587B_1 XSC−J1587B_2
0.5OG
7012
B B

0.5OG 0.5OG 0.5GY

0.5GY 0.5OG 0.5GY
0.5GY 0.5OG
7011 7012 7012 7011
7011 7012 7011 7012

C C
A 4 A 5 A 8 A 9 X1 6 X1 5

XC021
CAN A

CAN B

CAN A

CAN A
CAN B

CAN B
14 15
Connector, Telematics Interface

A22 A201 A125

Control unit, FMS Control unit, AIC Control unit, TGW
(Fleet Management System) (Advanced Information Cluster) (Telematics Gateway)

D D

E E
TELEMATICS
22087802 03 01 16(16)
2013−06−04 03

0 1 2 3 4
 BILL OF MATERIAL/COMPONENT LIST

Part Name Description Location Part Type

Control unit, FMS (Fleet {XE1C 1 C} {XH1A 0 C}
A22 Management System) {JF1 2 C} {XA1A 1 D} componentSymbol
Control unit, TGW (Telematics {XH1A 3 C} {XE1A 1 C}
A125 Gateway) {XB1 2 C} {JE1 1 C} componentSymbol
A152 Control unit, SID++ {JD1-2 2 C} componentSymbol
{XE1C 2 C} {XH1A 1 C}
{XE1A 2 C} {JD1-1 2
A} {JD1-3 2 D} {JD2 1
C} {JD1-5 2 D} {JD1-4
Control unit, AIC (Advanced 1 D} {XF1A 3 C} {XF1A
A201 Information Cluster) 1 C} componentSymbol
Control unit, AIC (Advanced
A202 Information Cluster) Sign unit {JD1-4 2 B} componentSymbol
Control unit, AIC (Advanced
A203 Information Cluster) Modem {JD1-3 2 B} componentSymbol
Control unit, AIC (Advanced
A205 Information Cluster) Satellite {JD2 0 D} componentSymbol
A208 Control unit, I-Coach {JD1-5 1 B} componentSymbol
S77 Switch, Emergency call {JD2 1 B} componentSymbol
VBC149 Relays AIC modem {JD2 0 B} componentSymbol
Connector, BB (Body Builder)
X126 Amplifier {JD1-1 1 C} componentSymbol
Connector, BB (Body Builder)
X127 I/O Interface 1 {JD1-1 2 C} componentSymbol
XBDBUS {XF1A 3 B} componentSymbol
Connector, Telematics Interface
XC020-1 BB2 {XB1 1 C} componentSymbol
Connector, Telematics Interface
XC020-2 BB2 {XB1 3 C} componentSymbol
{XE1C 3 C} {XH1A 3 C}
{XE1A 3 C} {JE1 2 B}
{JG1 1 D} {XA1A 2 C}
XC021 Connector, Telematics Interface {XF1A 1 B} componentSymbol
XSC-A201 {JD2 0 B} physical_splice_connector
XSC-A208 {JD1-5 2 C} physical_splice_connector
XSC-BB2H {XB1 2 B} physical_splice_connector
XSC-BB2L {XB1 2 B} physical_splice_connector
XSC-DBUS-H_1 {XF1A 1 C} physical_splice_connector
XSC-DBUS-H_2 {XF1A 3 C} physical_splice_connector
XSC-J1587A_1 {XH1A 1 B} physical_splice_connector
XSC-J1587A_2 {XH1A 3 B} physical_splice_connector

Document Title
WIRING DIAGRAM
Document Type
PRODUCT SCHEMATIC
Volvo Bus Corporation Document No Issue Index Volume No Page No

22087802 03 02(02) 01(02)

Part Name Description Location Part Type
XSC-J1587B_1 {XH1A 1 B} physical_splice_connector
XSC-J1587B_2 {XH1A 3 B} physical_splice_connector
XSC-J1939-1H_1 {XA1A 1 C} physical_splice_connector
XSC-J1939-1L_1 {XA1A 1 B} physical_splice_connector
XSC-J1939FMSH-1 {XE1C 2 B} physical_splice_connector
XSC-J1939FMSL-1 {XE1C 2 B} physical_splice_connector
XSC-J19392-3H_1 {XE1A 1 B} physical_splice_connector
XSC-J19392-3H_2 {XE1A 2 B} physical_splice_connector
XSC-J19392-3L_1 {XE1A 1 B} physical_splice_connector
XSC-J19392-3L_2 {XE1A 2 B} physical_splice_connector
{JE1 1 A} {JF1 2 A}
XSC-XC021:2 {JG1 2 B} physical_splice_connector
XSC-XC021:3 {JE1 2 B} physical_splice_connector
{JD1-3 1 A} {JD2 3 A}
XSC-XC021:4 {JG1 2 B} physical_splice_connector
{JD2 3 A} {JF1 2 A}
{JG1 2 B} {JD1-5 3 B}
XSC-XC021:5 {JD1-4 3 A} physical_splice_connector
{JD1-3 1 C} {JD2 3 D}
{JE1 1 D} {JF1 2 C}
{JG1 2 C} {JD1-5 2 C}
XSCG-TELE {JD1-4 2 C} physical_splice_connector

Document Title
WIRING DIAGRAM
Document Type
PRODUCT SCHEMATIC
Volvo Bus Corporation Document No Issue Index Volume No Page No

22087802 03 02(02) 02(02)

 Engineering Release Location Change Description A = Added W = Was Document Release Status
Notice (ERN) D = Deleted
RELEASED
Date Modification Count
D-15377-52 2013-03-20

WIRING DIAGRAM P3606

MD11 E6 BUS
Issue Change description Date By
01 First release 2010-07-21 CB
P3606 Project I/O EU6 Reg No PD1-101005 Issue No 2.0
Remove CAC By pass
Remove coolant pump
Update Fan System (Remove cooling fan 2 shutt off valve
2)
Update AVU connection
Remove Fuel Pressure
Add Heat sensors B14
Remove EGR position
02 2011-11-03 CB
Update Heater Sensor to Heat Sensor
Update NO to NC for Heat Sensor
Update Air Filter Indicator connexion to EMS (remove A15
add A29)
Add Body Heating Valve
Delete connector C10
Add component Y148
Add connector C2
Delete WIF B265
P3606 Project I/0 EU6 (P-serie) Reg No PD1-101005 Issue
No 3.0.
Add WIF B265
Remove connection A14.EB7 from K01.3.1 by A14.EB7
from R01.2-1n.
03 2012-07-13 CC
Remove A14.EA:3 by A14.EA:10.
Delete EA30, EI22 and connection.
Delete XE28.
Add VCIR:9 on XE02.

P3606 Project I/O Eu6 (P-series) Reg. no. PD1-101005

Issue No 3.3
Add Fuel priming pump M15.
Change connector EGR 993360 -> 994225.
04 Change VCIF13 by VCIR14. 2013-03-20 CC.
Change VCIF11 by VCIR11.
Change VCIF10 by VCIR10.
Remove connection B265:2 from XE02 by B265:2 from
XE33.
Document Title
The copying, distribution and utilization of this document as well as the
communication of its contents to others without expressed authorization WIRING DIAGRAM
is prohibited. Offenders will be held liable for payment of damages. All
rights reserved in the event of the grant of a patent, utility model or P3606
ornamental design registration.
MD11 E6 BUS
Document Type
EDM-W 2000-04-01

TECHNICAL REGULATION
Owner Domain:Document Prefix

Volvo Powertrain Corporation Document No Issue Index Volume No Page No

21599708 04 01 1(5)
Engineering Release Location Change Description A = Added W = Was Document Release Status
Notice (ERN) D = Deleted

Date Modification Count

D-15377-52 2013-03-20

Document Title
The copying, distribution and utilization of this document as well as the
communication of its contents to others without expressed authorization WIRING DIAGRAM
is prohibited. Offenders will be held liable for payment of damages. All
rights reserved in the event of the grant of a patent, utility model or P3606
ornamental design registration.
MD11 E6 BUS
Document Type
TECHNICAL REGULATION
Owner Domain:Document Prefix

Volvo Powertrain Corporation Document No Issue Index Volume No Page No

21599708 04 01 1(5)
 Document Title
WIRING DIAGRAM
Document Type
TECHNICAL REGULATION
Volvo Powertrain Corporation Document No Issue Index Volume No Page No

21599708 04 01 2(5) - 2 -5 - 2 -2(7)

 Document Title
WIRING DIAGRAM
Document Type
TECHNICAL REGULATION
Volvo Powertrain Corporation Document No Issue Index Volume No Page No

21599708 04 01 3(5) - 3 -5 - 3 -2(7)

Group 37 Multiplex electrical system Version 2