Health and Safety

Executive

Manual handling assessment

charts

Introduction

Work-related musculoskeletal disorders (MSDs), including manual handling injuries,

are the most common type of occupational ill health in the UK and their prevention
is a priority for HSC/E. It is important to remember that:

■ things can be done to prevent MSDs;

■ preventative measures are cost-effective;
■ you cannot prevent all MSDs, so early reporting of symptoms, proper
treatment and suitable rehabilitation is essential.

The steps to follow

The Manual Handling Operations Regulations 1992 (as amended) establish a clear
This is a web-friendly hierarchy of measures for dealing with risks from manual handling. These are:
version of leaflet INDG383
■ avoid hazardous manual handling operations so far as reasonably practicable;
■ assess any hazardous manual handling operations that cannot be avoided; and
■ reduce the risk of injury so far as reasonably practicable.

The MAC

The Manual Handling Assessment Charts (MAC) is a new tool designed to help
health and safety inspectors assess the most common risk factors in lifting (and
lowering), carrying and team handling operations. Employers, safety officers, safety
representatives and others may also find the MAC useful to identify high-risk
manual handling operations and help them complete their risk assessments.

Structure of the MAC

There are three types of assessment that can be carried out with the MAC:

■ lifting operations pages 2-5;

■ carrying operations pages 6-9;
■ team handling operations pages 9-11.

For each type of assessment there is an assessment guide and a flow chart.
There is a score sheet to complete on page 12.

Note:
The MAC is not appropriate for some manual handling operations, for example
those that involve pushing and pulling. Its use does not comprise a full risk
assessment (see Manual handling, ‘Further reading’). You must consider individual
and psychosocial issues when completing the score sheet. Also, the MAC is not
designed to assess risks from workplace upper limb disorders (see Upper limb
disorders in the workplace, see ‘Further reading’).
1 of 13 pages
How to complete a MAC assessment
■ Spend some time observing the task to ensure that what you are seeing is
representative of normal working procedures. Consult employees and safety
representatives during the assessment process. Where several people do the
same task, make sure you have some insight into the demands of the job
from all workers’ perspective. It may help to videotape the task so you can
view it over again, away from the workplace, if necessary.
■ Select the appropriate type of assessment (ie lifting, carrying or team handling).
If a task involves lifting and carrying, consider both.
■ Ensure you read the assessment guide before you make your assessment.
■ Follow the appropriate assessment guide and flow chart to determine the level
of risk for each risk factor. Information on risk reduction can be found on the
website (see address below). The levels of risk are classified below:

G = GREEN - Low level of risk

The vulnerability of special risk groups (eg pregnant women, young workers etc) should be
considered where appropriate.

A = AMBER - Medium level of risk - Examine tasks closely

R = RED - High level of risk - Prompt action needed

This may expose a significant proportion of the working population to risk of injury.

P = PURPLE - Very high level of risk

Such operations may represent a serious risk of injury and should come under close scrutiny
particularly when the entire weight of the load is supported by one person.

■ Enter the colour band and corresponding numerical score on the score sheet
on page 12. The colour bands help determine which elements of the task
require attention.
■ Add up the total score. The total scores help prioritise those tasks that need
most urgent attention and help check the effectiveness of those improvements.
■ Enter the remaining task information asked for on the score sheet.

Remember:
The purpose of the assessment is to identify and then reduce the overall level
of risk of the task.

Further information on the MAC, including on-line training, can be found at

http://www.hse.gov.uk/msd/mac/index.htm

Assessment guide for lifting operations

A Load weight/frequency

Note the weight of the load and the repetition rate of the lifting operation. Read off
the risk banding on the graph on page 4 and enter the colour band and numerical
score on the score sheet. If the colour band is purple the task should be examined
very closely, such operations may represent a serious risk of injury and should
come under close scrutiny, particularly when the entire weight of the load is
supported by one person. Note: High frequency handling operations of light
weights will fall within the GREEN zone, but may be associated with upper limb

Manual handling assessment charts

1 of 13 pages
problems. Please refer to Upper limb disorders in the workplace (see ‘Further
reading’) for advice on further assessment.

B Hand distance from the lower back

Observe the task and examine the horizontal distance between the operative's
hands and their lower back. Always assess the ‘worst case scenario’. Use the
following to guide your assessment:

CLOSE: Upper MODERATE: MODERATE: FAR: Upper arms

arms aligned Upper arms Trunk bent angled away from
vertically and angled away forward body and trunk
upright trunk G/0 from body A/3 A/3 bent forward R/6

C Vertical lift region

Observe the position of the operative’s hands at the start of the lift and as the lift
progresses. Always assess the ‘worst case scenario’. Use the following illustrations
as a guide:

Above knee and/or Below knee Floor level At head

below elbow height and/or above or below height or
G/0 elbow height A/1 above R/3

D Trunk twisting and sideways bending

Observe the operative's trunk as the load is lifted. If the trunk twists in relation to
the hips and thighs or the operative leans to one side as the load is lifted, the
colour band is amber and the numerical score is 1. If the trunk both twists and
bends to the side as the load is lifted the colour band is red and the numerical
score is 2.

E Postural constraints

If the movements of the operative are unhindered, the colour band is green and the
numerical score is 0. If the operative adopts restricted postures during the lift
because of the space available (eg a narrow gap between pallet load and hopper)
or the workstation design (eg an excessively high monorail conveyor), the colour
band is amber and the numerical score is 1. If the posture is severely restricted, the
colour band is red and the numerical score is 3 (eg work in confined areas such as
baggage holds).
 F Grip on the load

GOOD REASONABLE POOR

G/0 A/1

Containers with well- designed handles or Containers with poor Containers of po

handholds, fit for purpose handles or handholds design. Loose p
irregular objects,
or difficult to han

Loose parts enabling comfortable grip Fingers to be clamped Non-rigid sacks

at 90 degrees under the unpredictable lo
container

G Floor surface

Dry and clean floor in good condition Dry floor but in poor Contaminated/w
condition, worn or steep sloping flo
G/0 uneven A/1 unstable footing

H Other environmental factors

Observe the work environment and score if the lifting operation takes place: in
extremes of temperature; with strong air movements; or in extreme lighting
conditions (dark, bright or poor contrast). If one of the risk factors are present
score 1, if two or more of the risk factors are present score 2.

Load weight/frequency graph for lifting operations

50
P=10 50

W 40 40

ei R=6
gh
t
of 30 30
lo
ad
(k
g)
20 20

10 10

G=0
0 0

One lift per 30 minutes 5 minutes 2 minutes 1 minute 14 seconds 9 seconds 5 seconds
day (2) (12) (30) (60) (250) (400) (720)

One lift every

(lifts per hour)
 Please insert the colour and
LIFTING numerical scores on the
OPERATION score sheet on page 12

SEE GRAPH on p4 G No factors G

0 present
A H 0
SEE GRAPH on p4 A
Load weight/ 4 Other One factor A
frequency (see R environmental present
SEE GRAPH on p4 1
graph on p4) 6 factors
Two or more R
50 kg OR MORE P factors present
10 2
CLOSE: upper arm G
vertical/trunk Dry and in good G
upright 0 condition
B G 0
Hand distance MODERATE: upper A Dry but in poor
arm angled or Floor A
from lower conditions or
trunk bent forward 3 surface uneven
back 1
FAR: upper arm R Contaminated,
angled and trunk wet, sloping or
R
bent forward 6 unstable 2
Above knee and/or G G
below elbow GOOD
C height 0 0
F
Vertical lift Below knee and/or A Grip on A
above elbow REASONABLE
region height 1 the load 1
Floor level or below R R
and/or above POOR
head height 3 2
Little or no twisting G
or sideways G
NONE
bending 0
D E 0
Trunk twisting/ Trunk twisting A
OR Postural A
RESTRICTED
sideways sideways bending 1 constraints 1
bending
Trunk twisting R
AND SEVERELY R
sideways bending 2 RESTRICTED
3
Assessment guide for carrying operations

A Load weight/frequency

Note the weight of the load and the frequency of the carrying operation. Read off
the risk banding on the graph on page 9 and enter the colour band and numerical
score on the score sheet. If the colour band is purple the task should be examined
very closely, such operations may represent a serious risk of injury and should
come under close scrutiny, particularly when the entire weight of the load is carried
by one person.

B Hand distance from the lower back

Observe the task and examine the horizontal distance between the operative's
hands and their lower back. Always assess the ‘worst case scenario’. Use the
following illustrations to guide your assessment:

CLOSE: Upper MODERATE: MODERATE: FAR: Upper arms

arms aligned Upper arms Trunk bent angled away from
vertically and angled away forward body and trunk
upright trunk G/0 from body A/3 A/3 bent forward R/6

C Asymmetrical trunk/load

The operative's posture and the stability of the load are risk factors associated with
musculoskeletal injury. The following illustrations should guide your assessment.

Load and Load and One handed

hands hands carrying to
symmetrical asymmetrical, the
in front of upright body individual’s
the trunk G/0 position A/1 side R/2

D Postural constraints

If the operative’s movements are unhindered, the colour band is green and the
numerical score is 0. If the operative adopts restricted postures during the carry (eg
a narrow doorway making the operative turn or move the load to get through), the
colour band is amber and the numerical score is 1. If the posture is severely
restricted, the colour band is red and the numerical score is 3 (eg carrying loads in
a forward bent posture in areas with low ceilings such as cellars).
E Grip on load

GOOD REASONABLE POOR

G/0 A/1

Containers with well- designed handles or Containers with poor Containers of poo
handholds, fit for purpose handles or handholds design. Loose par
irregular objects, b
or difficult to hand

Loose parts enabling comfortable grip Fingers to be clamped Non-rigid sacks o

at 90 degrees under the unpredictable load
container

F Floor surface

Dry and clean floor in good condition Dry floor but in poor Contaminated/we
condition, worn or steep sloping floo
G/0 uneven A/1 unstable footing

G Other environmental factors

Observe the work environment and score if the carrying operation takes place: in
extremes of temperature; with strong air movements; or in extreme lighting
conditions (dark, bright or poor contrast). If one of the risk factors are present
score 1, if two or more of the risk factors are present score 2.

H Carry distance

Observe the task and estimate the total distance that the load is carried (not the
distance 'as the crow flies').

I Obstacles en route

Observe the route. If the operator has to carry a load up a steep slope, up steps,
through closed doors or around tripping hazards, the coloured band is amber and
the numerical score is 2. If the task involves carrying the load up ladders, enter ‘R’
(red) for the colour band and 3 for the numerical score. If the task involves more
than one of the risk factors (ie a steep slope and then up ladders) total the scores
on the score sheet. Enter the ladder height data and/or the angle in the task
description box on the score sheet.
 Please insert the colour and
CARRYING numerical scores on the
OPERATION score sheet on page 12

SEE GRAPH on p9 G No obstacles G

0 OR
A carry route is flat 0
SEE GRAPH on p9 A
Load weight/ 4 I
Steep slope A
frequency (see R Obstacles 2
SEE GRAPH on p9
graph on p9) 6 en route Trip hazards A
OR
50 kg OR MORE P steps 2
10
Ladders R
CLOSE: upper arm G 3
vertical/trunk
B upright 0 G
H 2 m-4 m
Hand distance MODERATE: upper
0
arm angled or
A Carry
from lower 4 m-10 m A
trunk bent forward 3 distance
back 1
FAR: upper arm R 10 m or more R
angled and trunk 3
bent forward 6
No factors G
Load symmetrical G present
in front/two hands G 0
C 0
Other One factor A
Asymmetrical Asymmetrical or A environmental present
offset load/hands 1
trunk/load 1 factors
Two or more R
One-handed to R factors present
side or twisting/ 2
back bent 2
Dry and in good G
NONE
G condition
F 0
D 0
Floor Dry but in poor A
Postural A conditions or
RESTRICTED surface uneven 1
constraints 1
Contaminated, R
R wet, sloping or
SEVERELY unstable
RESTRICTED 2
3

G
GOOD
E 0
Grip on A
REASONABLE
the load 1
R
POOR
2
 Load weight/frequency graph for carrying operations

50
P=10 50

W 40 40
ei
gh
R=6
t
of 30 30
lo
ad
(k
g) A=4
20 20

10 10

G=0

0 0

One carry per 30 minutes 5 minutes 2 minutes 1 minute 12 seconds

day (2) (12) (30) (60) (300)

One carry every

(carrys per hour)

Assessment guide for team handling operations

A Load weight

Note the weight of the load and the number of operatives performing the task.
Enter the colour band and numerical score on the score sheet. If the colour band is
purple the task should be examined very closely, such operations may represent a
serious risk of injury and should come under close scrutiny, particularly when the
entire weight of the load is supported by the team.

B Hand distance from the lower back

Observe the task and examine the horizontal distance between each operatives'
hands and their lower back. Always assess the ‘worst case scenario’. Use the
following illustrations to guide your assessment:

CLOSE: Upper MODERATE: MODERATE: FAR: Upper arms

arms aligned Upper arms Trunk bent angled away from
vertically and angled away forward body and trunk
upright trunk from body bent forward
G/0 A/3 A/3 R/6
C Vertical lift region

Observe the position of the operatives’ hands at the start of the lift and as the lift
progresses. Always assess the ‘worst case scenario’. Use the following illustrations
as a guide:

Above knee and/or Below knee Floor level At head

below elbow height and/or above or below height or
G/0 elbow height A/1 above R/3

D Trunk twisting and sideways bending

Observe the operatives' trunks as they lift the load. If the trunk twists in relation to
the hips and thighs or if the operatives lean to one side as the load is lifted, the
colour band is amber and the numerical score is 1. If the trunk both twists and
bends to the side as the load is lifted, the colour band is red and the numerical
score is 2.

E Postural constraints

If the movements of the operatives are unhindered, the colour band is green and
the numerical score is 0. If the operatives adopt restricted postures during the lift
because of the space available (eg narrow space between team members) or the
workstation design (eg an excessively high monorail conveyor), the colour band is
amber and the numerical score is 1. If the postures are severely restricted, the
colour band is red and the numerical score is 3 (eg work in confined areas such as
baggage holds).

F Grip on load

GOOD REASONABLE POOR

G/0 A/1

Containers with well- designed handles or Containers with poor Containers of poo
handholds, fit for purpose handles or handholds design. Loose par
irregular objects, b
or difficult to hand

Loose parts enabling comfortable grip Fingers to be clamped Non-rigid sacks o

at 90 degrees under the unpredictable load
container

G Floor surface

Dry and clean floor in good condition Dry floor but in poor Contaminated/we
condition, worn or steep sloping floo
G/0 uneven A/1 unstable footing
H Other environmental factors

Observe the work environment and score if the lifting operation takes place: in
extremes of temperature; with strong air movements; or in extreme lighting
conditions (dark, bright or poor contrast). If one of the risk factors are present
score 1, if two or more of the risk factors are present score 2.

I Communication, co-ordination and control

Communication between the operatives is essential when lifting as part of a team.

Examples of good communication would be that you may hear the operatives
counting 'one, two, three' etc prior to the lift. Look to see if the team have control
of the load, that it is lifted smoothly, and that all members lift together. An
uncoordinated team lift may leave one member of the team bearing the entire
weight.

TEAM Please insert the colour and

HANDLING numerical scores on the
OPERATION score sheet on page 12

2 person < 35 kg G
3 person < 40 kg 0 G
GOOD
A 2 person 35-50 kg A I 0
3 person 40-75 kg
Load weight 4 person 40-100 kg 4 Communication, A
REASONABLE
2 person 50-85 kg R co-ordination 1
3 person 75-125 kg and control
4 person 100-170 kg 6 R
POOR
2 person >85kg P 3
3 person >125kg
4 person >170kg 10
No factors G
present
CLOSE: upper arm G H 0
vertical/trunk
upright 0 Other A
B One factor
present
Hand distance MODERATE: upper A environmental 1
arm angled or
from lower trunk bent forward 3 factors R
Two or more
back factors present
FAR: upper arm R 2
angled and trunk
bent forward 6
Dry and in good G
condition
Above knee and/or G G 0
below elbow
height 0 Floor Dry but in poor A
C condition or
Vertical lift Below knee and/or A surface uneven 1
above elbow
region height 1 Contaminated, R
wet, sloping or
Floor level or below R unstable 2
and/or above
head height 3
G
GOOD
Little or no G F 0
twisting or
D
sideways bending 0 Grip on A
REASONABLE
the load 1
Trunk twisting/ Twisting A
OR
sideways sideways bending 1 R
bending POOR
Trunk twisting R 2
AND
sideways bending 2

G
NONE
E 0
Postural A
RESTRICTED
constraints 1
SEVERELY R
RESTRICTED
3
Further reading

Manual handling. Manual Handling Operations Regulations 1992 (as amended).

Guidance on Regulations L23 (Third edition) HSE Books 2004
ISBN 978 0 7176 2823 0

Upper limb disorders in the workplace HSG60 (Second edition) HSE Books 2002
ISBN 978 0 7176 1978 8

Further information on the MAC, including on-line training, can be found at

www.hse.gov.uk/msd

HSE priced and free publications are available by mail order from HSE Books,
PO Box 1999, Sudbury, Suffolk CO10 2WA Tel: 01787 881165 Fax: 01787 313995
Website: www.hsebooks.co.uk (HSE priced publications are also available from
bookshops and free leaflets can be downloaded from HSE’s website:
www.hse.gov.uk.)

For information about health and safety ring HSE’s Infoline Tel: 0845 345 0055
Fax: 0845 408 9566 Textphone: 0845 408 9577 e-mail: [email protected] or
write to HSE Information Services, Caerphilly Business Park, Caerphilly CF83 3GG.

This leaflet contains notes on good practice which are not compulsory but
which you may find helpful in considering what you need to do.

This leaflet is available in priced packs of 10 from HSE Books,

ISBN 978 0 7176 2741 7. Single free copies are also available from HSE Books.

© Crown copyright This publication may be freely reproduced, except for

advertising, endorsement or commercial purposes. First published 08/03.
Please acknowledge the source as HSE.
 MAC: Score sheet Insert the colour band and numerical score for each of the risk factors in the boxes
Company name: below, referring to your assessment, using the tool.
Colour band
(G, A, R or P) Numerical score
Task Description: Risk factors
Lift Carry Team Lift Carry Team
Pu
blis Load weight and lift/carry frequency
he
d
by Hand distance from the lower back
the
He
alt Vertical lift region
h
an
d Trunk twisting/sideways bending
Saf
ety Asymmetrical trunk/load (carrying)
Ex
ec
uti Postural constraints
ve
Grip on the load
IN
DG Are there indications that the task is high risk? Floor surface
38 (Tick the appropriate boxes)
3
Other environmental factors
Re Task has a history of manual handling incidents (eg company accident book, RIDDOR reports).
pri
nte Carry distance
d Task is known to be hard work or high risk.
04/
08 Obstacles en route (carrying only)
Employees doing the work show signs that they are finding it hard work
(eg breathing heavily, red-faced, sweating). Communication and co-ordination
(team handling only)
Other indications, if so what? Healt
Other risk factors, eg individual h
TOTAL
factors, psychosocial factors etc and
13 SCORE: Safet
of Date: (see website - address on page 12)
13 y
pa Exec
ge Signature: utive
s