Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c
Spare parts list
Edition 20120123
Valid for serial no. 712, 714,715,716,725,726,743,747,748,749,751,750-xxx-xxxx
Ordering no
Product
Notes
Ser.no
0349 308 500 OrigoTM Mig 402cw
400V 415V, 3~50Hz; with water cooler
712
0349 310 750 OrigoTM Mig 402c
400V 415V, 3~50Hz
714
0349 310 760
OrigoTM
Mig 502cw
400V 415V, 3~50Hz; with water cooler
715
0349 310 770
OrigoTM
Mig 502c
400V 415V, 3~50Hz
716
0349 310 800
OrigoTM
Mig 652cw
400V 415V, 3~50Hz; with water cooler
725
0349 311 060
OrigoTM
Mig 652c
400V 415V, 3~50Hz
726
0349 311 230
OrigoTM
Mig 402cw
230V 500V, 3~50Hz, 3~60Hz; with water cooler
743
0349 311 220
OrigoTM
Mig 402c
230V 500V, 3~50Hz, 3~60Hz
747
0349 311 250
OrigoTM
Mig 502cw
230V 500V, 3~50Hz, 3~60Hz; with water cooler
748
0349 311 240
OrigoTM
Mig 502c
230V 500V, 3~50Hz, 3~60Hz
749
0349 311 270
OrigoTM
Mig 652cw
230V 500V, 3~50Hz, 3~60Hz; with water cooler
751
0349 311 260
OrigoTM
Mig 652c
230V 500V, 3~50Hz, 3~60Hz
750
Spare parts are to be ordered through the nearest ESAB agency. Kindly indicate type of unit, serial
number, denominations and ordering numbers according to the spare parts list.
Maintenance and repair work should be performed by an experienced person, and electrical work only
by a trained electrician. Use only recommended spare parts.
Rights reserved to alter specifications without notice.
0349 300 543
-1-
R0349 300 543/E20120123/P14
Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c
(A) = accessory
C = component designation in the circuit diagram
Item
Qty
402c
Qty
502c
Qty
652c
Ordering no.
Denomination
Notes
101
0349 310 348
Bottom plate
102
0349 310 458
Rubber sheet
103
0349 310 457
Cover
104
0349 493 173
Blind plug
105
0458 992 001
Blind plug
only c machines
106
0321 173 001
Chain
L=700mm
107
0349 310 455
Side panel
108
0349 302 267
Bottle shelf
109
0349 302 268
Clamp
110
0469 516 005
Shaft
111
0349 481 044
Plain washer
21
112
0469 872 001
Wheel
250
113
0192 859 126
Locking washer
114
0349 304 853
Castor wheel
115
0349 310 454
Side panel
116
0349 310 390
Panel plate
117
0349 480 394
Roll pin
118
0468 796 001
Support plate
119
0349 310 962
Seal
120
0349 311 382
Switch
121
0349 311 632
Knob
122
0349 302 754
Guide pin
125
Q01
c = machines without water cooling system
ba44s1
-2-
R0349 300 543/E20120123/P14
Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c
ba44s1
-3-
R0349 300 543/E20120123/P14
Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c
C = component designation in the circuit diagram
Item
Qty
Ordering no.
203
0349 302 284
Handle
Valid for serial no.: xxx 8xx xxxx to xxx 9xx xxxx, xxx
0xx xxxx to xxx 110 xxxx
204
0349 302 283
Right corner
Valid for serial no.: xxx 8xx xxxx to xxx 9xx xxxx, xxx
0xx xxxx to xxx 110 xxxx
205
0349 302 282
Left corner
Valid for serial no.: xxx 8xx xxxx to xxx 9xx xxxx, xxx
0xx xxxx to xxx 110 xxxx
212
0349 310 966
Handle
Valid from serial no.: xxx 111 xxxx
213
0349 311 034
Cover right
Valid from serial no.: xxx 111 xxxx
214
0349 311 035
Bracket right
Valid from serial no.: xxx 111 xxxx
215
0349 311 033
Base right
Valid from serial no.: xxx 111 xxxx
216
0349 311 039
Reduction insert
Valid from serial no.: xxx 111 xxxx
217
0349 311 037
Cover left
Valid from serial no.: xxx 111 xxxx
218
0349 311 038
Bracket left
Valid from serial no.: xxx 111 xxxx
219
0349 311 036
Base left
Valid from serial no.: xxx 111 xxxx
220
0349 310 376
Lower front plate
221
0349 310 387
Front panel
222
0349 302 285
Grill
223
0460 600 321
Knob
224
0349 310 765
Potentiometer
225
0369 733 007
Signal lamp
White, 48V
H4
226
0369 733 005
Indicating lamp
Orange, 24V
H1, H2
227
0368 544 003
Socket burndy
ba44s1
Denomination
Notes
P1
X01
-4-
R0349 300 543/E20120123/P14
Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c
ba44s1
-5-
R0349 300 543/E20120123/P14
Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c
Item
Qty
402c
Qty
502c
Qty
652c
Ordering no.
301
0459 118 002
Protection frame
302
0349 310 932
Panel cpl.
0349 310 397
Panel cpl.
0349 311 301
Label MMC Panel M0
0349 310 399
Label MMC Panel A13
304
0349 302 287
Plate
305
0349 310 037
Shield
306
0455 226 004
Spacer
307
0349 491 336
Capacitor cpl.
308
0460 600 321
Knob
309
0460 600 836
Knob
310
0349 310 918
Potentiometer
R02, R03
311
0349 304 108
Rotary switch
S1
312
0192 724 007
Potentiometer
R01
303
ba44s1
Denomination
-6-
Notes
R0349 300 543/E20120123/P14
Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c
ba44s1
-7-
R0349 300 543/E20120123/P14
Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c
Item
Qty
Ordering no.
401
0349 310 264
Rear panel
402
0349 311 701
Radiator
403
0469 893 001
Fan mantle
404
0369 827 001
Fan
405
0349 310 469
Pump bracket
only cw machines
406
0459 288 001
Pump
only cw machines
407
0469 689 001
Water tank
only cw machines
408
0366 481 004
Sealing
only cw machines
409
0469 689 002
Cover
only cw machines
410
0469 950 880
Cable inlet
411
0466 884 008
Connection
412
0466 884 006
Terminal
413
0191 085 206
Capacitor
6uF
C1
414
0191 085 203
Capacitor
3uF
C2
415
0160 362 881
OKC contact
416
0365 803 011
Quick connector
Blue, only cw machines
417
0365 803 012
Quick connector
Red, only cw machines
Denomination
Notes
only cw machines
M1
8pol.
M2
X30
X40
cw = machines with water cooling system
ba44s1
-8-
R0349 300 543/E20120123/P14
Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c
ba44s1
-9-
R0349 300 543/E20120123/P14
Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c
Item
Qty
402c
Qty
502c
Qty
652c
Ordering no.
501
0349 310 304
Shelf
502
0349 310 272
Intermediate plate
503
0349 308 601
Chopper 400
V0
0349 311 236
Chopper 500
V0
0349 311 237
Chopper 600
V0
Valid up to serial no xxx145xxxx
0349 310 721
Transformer
sv machines
TC1
0349 311 231
Transformer
mv machines
TC1
0349 484 211
Contactor
sv machines
K1
0349 311 407
Contactor
sv machines
K1
0349 307 633
Contactor
mv machines
K1
0349 311 408
Contactor
mv machines
K1
0349 311 409
Contactor
mv machines
K1
506
0193 927 001
Contactor
507
0469 701 001
Bracket
508
0349 311 574
PC board mains filter
509
0162 772 001
Connection block
510
0469 899 001
Connection block
0469 889 001
Connection block
511
0457 290 046
Rectifier bridge
VB1
512
0349 310 724
Resistor
R2
513
0349 485 729
Resistor
R3
514
0349 309 889
Electronics board
CH20
0349 311 578
Electronics board
CH20
0349 311 579
Electronics board
CH20
515
0349 310 568
Electronics board
CH10
516
0349 310 271
Shield
505
Notes
Thermal switch
504
SCOMES
0349311821
Denomination
SEMIKRON
0349311822
B2
K2, K3
K69
9pol., > 1 piece for sv machines
X10
XT1
9pol., > 2 pieces for mv machines
X10
sv = 400415V
mv = 230500V
ba44s1
- 10 -
R0349 300 543/E20120123/P14
Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c
ba44s1
- 11 -
R0349 300 543/E20120123/P14
Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c
Item
Qty
402c
Qty
502c
Qty
652c
Ordering no.
601
0349 309 518
Transformer
sv machines
TR1
0349 311 255
Transformer
mv machines
TR1
0349 310 145
Transformer
sv machines
TR1
0349 311 256
Transformer
mv machines
TR1
0349 310 796
Transformer
sv machines
TR1
0349 311 254
Transformer
mv machines
TR1
0349 309 558
Inductor
L1
0349 310 798
Inductor
L1
603
0467 992 881
Shunt
RB
604
0160 362 881
OKC connector
602
Denomination
Notes
sv = 400415V
mv = 230500V
ba44s1
- 12 -
R0349 300 543/E20120123/P14
NOTES
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
.............................................................................................................................................................
notes
- 13 -
paut
- 14 -
R0349 300 543/E20120123/P14
