PROJECT OWNER CONS LTANT

: POL Depot : IBP Co. Limited. : B!lme" L!#"ie $ Co. Ltd.

Volume - 2 DOC. NO. POL/SPARES Li%t o& Sp!"e%

List of Spares

Contents: PRODUCT PUMPS (HORIZONTAL AND SUBMERSIBLE) LO! METERS IRE !ATER PUMPS "OC#E$ PUMPS SUMP PUMP MOTORS OR IRE I%HTIN% S$STEM DIESEL EN%INE &AL&E (ALL SIZES AND T$PES UPTO '( NB) OR PROCESS ) P S$STEM STRAINERS OR PROCESS ) IRE PROTECTION S$STEM H$DRANT ACCESSORIES !ATER SPRA$* COOLIN% S$STEM ACCESSORIES INSTRUMENTS OR PROCESS ) P S$STEM CONTROL PANEL* IRE ALARM PANEL D% SET

P!'e No. ( o& )

PROJECT OWNER CONS LTANT

: POL Depot : IBP Co. Limited. : B!lme" L!#"ie $ Co. Ltd.

Volume - 2 DOC. NO. POL/SPARES Li%t o& Sp!"e%

1.0

PRODUCT PUMPS (HORIZONTAL AND SUBMERSIBLE) Item Descripti ! i) ii) iii) i$) $) $i) Gasket & O Ring Set Set of Wear Rings Shaft with Key %earing set (ra&ial & thr!st) '"peller n!t( key & lock washer as applica le )artri&ge type "echanical seal "t# i! terms $ % $ e&c' m (e) $ p*mp 100% 30% 100% (applica le for S! "ersi le #!"ps only) 30% 30% 30%

The EPC Contractor shall work out the total quantity of Spares required from the abobe table depending on the number of pumps (both horizontal & submersible +.0 ,LO- METERS Item Descripti ! a) a+1 a+, a+3 a+. a+1 a+3 a+4 ) +1 +, +3 c) c+1 c+, &) &+1 &+, *eter #acking glan& asse" ly *o!nting gasket )o$er O-Ring /&0!ster 2ace an& #inion gear set Gear #late %earing #late Set Strainer %asket (.0 "esh) 5op )o$er gasket %asket lock pin /ir 6li"inator Ree& an& 2loat /sse" ly Seals #reset 7al$e )!p & G!i&e asse" ly Gasket & seals "t# i! terms $ % $ t t&) ! . $ Meter U!its 30% 30% 100% 11% ,0% 11% 11% 11% 30% 30% 10% 30% ,0% 30%
P!'e No. 2 o& )

PROJECT OWNER CONS LTANT

: POL Depot : IBP Co. Limited. : B!lme" L!#"ie $ Co. Ltd.

Volume - 2 DOC. NO. POL/SPARES Li%t o& Sp!"e%

&+3 &+. &+1 &+3 ..0

8inkage /sse" ly #resent co!nter )o!nter Rate of flow in&icator

11% 10% 10% 10%

,IRE -ATER PUMPS Item Descripti ! a) ) c) &) e) f) g) h) ') 0) k) l) ") '"peller #!"p Shaft "*&!tit# i! terms $ % $ t t&) ! . $ P*mps

10% 10% )asing Ring (96 & :96) Sets 100% '"peller Ring (96 & :96) 100% )la"ping #late for split glan& 100% %!sh for glan& 100% 8antern Ring 100% Split Glan& 100% %all %earing (96 & :96) 10% Shaft Slee$e (96 & :96) 10% Gaskets of each type 10% ;O< ring for shaft slee$e 10% #in of each type ,00%

/.0

0O1E2 PUMPS Item Descripti ! a) ) c) &) e) f) g) h) ') 0) k) "t# i! terms $ % $ t t&) ! . $ p*mps

'"peller 10% #!"p Shaft 10%+ 8antern Ring 100% 8i=!i& 9eflector 100% Ra&ial %all %earing 100% Shaft Slee$e Set 10% Key for i"peller & n!t Sets 100% 8ock Washer for i"peller n!t 100% St!ffing %o> packing ,00% Oil Seal ,00% Gaskets of each type 100%

P!'e No. * o& )

PROJECT OWNER CONS LTANT

: POL Depot : IBP Co. Limited. : B!lme" L!#"ie $ Co. Ltd.

Volume - 2 DOC. NO. POL/SPARES Li%t o& Sp!"e%

3.0

SUMP PUMP Item Descripti ! a) ) c) &) e) f) g) "t# i! terms $ % $ t t&) ! . $ p*mps

'"peller 10% #!"p Shaft 10% %earing 100% Key for '"peller & :!t 100% 8ock Washer for i"peller n!t 100% #acking Sets 100% Gaskets of each type (Set) 100%

4.0

MOTORS ,OR ,IRE ,I5HTIN5 S2STEM Item Descripti ! a) %earing of each type T t&) "*&!tit# $ Sp&res i! terms $ % 10% for ?ockey #!"p *otors 10% for S!"p #!"p *otors 100% for Siren

6.0

DIESEL EN5INE (one set means total quantity required for replacement of one complete set Item Descripti ! (Sets) a) ) c) &) e) f) g) h) i) 0) k) l) ") n) o) p) =) "t# i! terms $ % $ t t&) ! . $ e!7i!es

Sprayers('n0ectors 100% #iston 10% #iston ring 100% 'nlet $al$e asse" ly 10% 6>ha!st $al$e asse" ly 10% Springs 100% #acking an& gaskets 100% 2!el filters@ ele"ents & seals ,00% 8! e Oil filters@ ele"ents & seals ,00% Scrapper ring 100% Solenoi& coil for f!el $al$e 100% *ain %earing 10% %ig en& & s"all en& earings of connecting ro& 10% Spee&o"eter 10% Spee&"eter wire 100% Aoses with en& connector of each type 10% )ranking starter asse" ly 10%

P!'e No. + o& )

PROJECT OWNER CONS LTANT

: POL Depot : IBP Co. Limited. : B!lme" L!#"ie $ Co. Ltd.

Volume - 2 DOC. NO. POL/SPARES Li%t o& Sp!"e%

8.0

9AL9E (ALL SIZES AND T2PES UPTO 30 NB) : ,OR PROCESS ; , P S2STEM a) )o"plete $al$e type(siBe 10% of the total $al$e installe& of each or , nos+ of each type(siBe whiche$er is higher+

<.0

STRAINERS : ,OR PROCESS ; ,IRE PROTECTION S2STEM a) ) )o"plete internals incl!&ing stiffener ;O< ring C C C 10% of strainers installe& of each siBe(type with "ini"!" of 1 no+ of each siBe(type+

10.0

H2DRANT ACCESSORIES a) ) c) &) e) f) g) 8!g asse" ly for C hy&rant C 8!g asse" ly for C )o!plings C 7al$e seats for C hy&rant $al$es C '+R+Ring for hy&rant C $al$es C '+R+Ring for co!pling C 8ocking asse" ly for C "onitor C ;0< ring for "onitor C ,1% of total =!antity installe& or 10 nos+ whiche$er is higher+

11.0

-ATER SPRA2=COOLIN5 S2STEM ACCESSORIES a) ) Spray :oBBles Re$ol$ing Aea& 10% of total =!antity of each siBe(type or 10 nos+ of each siBe(type whiche$er is higher+ One of each siBe(type

1+.0

INSTRUMENTS : ,OR PROCESS ; , P S2STEM a) ) c) &) e) f) g) h) #ress!re Ga!ges of each #ress!re Switches 8e$el 'n&icators 8e$el Switches 2low 'n&icators 2low Switches Solenoi& $al$e asse" ly *an!al )all #oint C C C C C C C C C C 10% of total =!antity of each type or 1 :o+ type whiche$er is higher+

P!'e No. , o& )

PROJECT OWNER CONS LTANT

: POL Depot : IBP Co. Limited. : B!lme" L!#"ie $ Co. Ltd.

Volume - 2 DOC. NO. POL/SPARES Li%t o& Sp!"e%

1..0

CONTROL PANEL=,IRE ALARM PANEL a) ) c) &) e) f) g) h) ') 2!ses 'n&ication la"ps C C 10% of total =!antity installe& ,0% of total =!antity installe&

#!sh %!ttons C Selector Switches C /!>ilary relays( C contactors C /nn!nciation win&owC la"ps C )ontrol car&s for C ann!nciation facia C )ontrol car&s for fire C alar" panel C #ower s!pply "o&!le C

10% of total =!antity installe& or , nos+ whiche$er is higher+

1/.0

D5 SET Item Descripti ! a) ) c) &) e) f) g) 6le"ent )orrosion Resistor 6le"ent 8! e Oil 2ilter 6le"ent 8+O+ %ypass 2ilter 6le"ent 2!el 2ilter #late )orrosion Resistor 6le"ent /ir )leaner (O!ter) 6le"ent /ir )leaner ('nner) T t&) "*&!tit# $ Sp&res $ r e&c' D5 Set 3 nos+ 3 nos+ 3 nos+ 3 nos+ 10 nos+ , nos+ , nos+

P!'e No. ) o& )