PHILIPS fw-R8
Uploaded by
jorgespeedmaxPHILIPS fw-R8
Uploaded by
jorgespeedmaxCDR Mini System FW-R8/17/21/22
SERVICING
For servicing FW-R8, the set can be divided into two parts:
1. Except for the CD-R/W module the set has to be repaired on component level.
2. The CD-R/W module will be exchanged completely in case of a failure.
The defective CD-R/W module has to be returned for central repair.
Available circuit descriptions: The Basics of Compact Disc Recordable/Rewritable 4822 725 25242
3rd generation Compact Disc Recording 3104 125 40100
Table of Contents
Location of printed circuit boards . . . . . . . . . . . . . . . . . . . 1-2 Power Board. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Technical specification . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
Measurement setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2 3 Disc Changer Module . . . . . . . . . . . . . . . . . . . . . . . . . . 10
RC-5 codes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
Brief operating instructions . . . . . . . . . . . . . . . . . . . . . . . . 2-4 CD R/W Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Warnings & safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
Service Testprogram . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3 Exploded view of set. . . . . . . . . . . . . . . . . . . . . . . . . . . . 12-1
Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1 Partslist of set . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12-3
Block/Leveldiagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
Front Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Tuner Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Audio Frequency Board (AF7) . . . . . . . . . . . . . . . . . . . . . 8
CLASS 1
LASER PRODUCT
© Copyright 2000 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in a retrieval
system or transmitted, in any form or by any means, electronic, mechanical, photocopying,
or otherwise without the prior permission of Philips.
Published by HB 0015 Service Audio Printed in The Netherlands Subject to modification © 3103 785 25040
1-2
Location of Printed Circuit Boards
CDC K
EY BO
ARD
RD
BOA
R
NE
TU
H
FRON ITC
T BOA . SW
RD DIG RD
A
BO
LED
BOA
RD
D
AR
BO
NS
AI
DESIG
M
N FRO D
NT BO AR
ARD BO
7
AF
RD
BOA
.
MIC
RD
BOA
NE
PHO
AD
HE
Location of PCB R8 2000 02 14
2-1
Technical Specification
General: CDC unit:
Mains voltage : 120 / 240V switchable (for /21) Frequency response within : 20Hz - 20kHz at ±3dB
: 230V (for /22) Signal/Noise ratio : > 94dB (A-weighted)
: 120V (for /37) Distortion at 1kHz,0dB : -90dB
Mains frequency : 50 ~ 60Hz Channel unbalance : < 0.3dB
Power consumption : 155W at 1/8 PRATED Channel crosstalk at 1kHz : -60dB
: 350W at max output De-emphasis : 0 or 15/50 µS
: ≤15W at Stand by Laser
: ≤2W at ECO Stand by Output power : ≤500µW
Wave length : 780nm ±20nm
Tuner:
CDR unit:
FM
Tuning range : 87.5MHz - 108MHz CD Playback:
Grid : 100kHz Frequency response within : 20Hz - 20kHz at ±3dB
IF : 10.7MHz Signal/Noise ratio : > 90dB (A-weighted)
Aerial input : 75Ω Distortion at 1kHz,0dB : -80dB
Sensitivity Mono : < 7µV (26dB S/N) Channel unbalance : < 1dB
d (RF=1mV,∆f=75kHz) : 3% - typ. 2% Channel crosstalk at 1kHz : -60dB
IF rejection : > 60dB De-emphasis : 0 or 15/50 µS
Image rejection : > 25dB
-3dB Limiting Point : < 23.5dBf Analog recording - digital playback:
Frequency response within : 20Hz - 20kHz at ±3dB
MW Signal/Noise ratio : > 84dB (A-weighted)
Tuning range : 531kHz - 1062kHz Distortion at 1kHz,0dB : -77dB
Grid : 9kHz Channel unbalance : < 1dB
IF : 450kHz ±1kHz Channel crosstalk at 1kHz : -60dB
Sensitivity at 26dB S/N : < 4.0mV/m De-emphasis : 0 or 15/50 µS
d (RF=50mV,m=80%) : < 5% - typ. 3%
IF rejection : > 45dB Laser
Image rejection : > 28dB Output power : ≤1mW during reading
: ≤20mW during writing
Laser class 3B
Amplifier: Wave length : 780nm ±20nm
Output power : 2 x 100W at 6Ω
Headphone : 3.5mm stereo jack
Frequency response : 20Hz - 20kHz (-3dB) Limit
Equalizer : Digital Sound Control
Input sensitivity
Aux/Line : 500mV ±2dB
Microphone : 2.5mV ±2dB at 1kHz
2-2
Measurement Setup
Tuner SW Bandpass
DUT 250Hz-15kHz LF Voltmeter
RF Generator Aerial replacement e.g. 7122 707 48001 e.g. PM2534
e.g. PM5326 Capacitor
Ri=50Ω
R=50Ω
S/N and distortion meter
e.g. Sound Technology ST1700B
To avoid atmospheric interference all AM-measurements have to be carried out in a Faraday´s cage.
Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz).
Tuner AM (MW,LW)
Bandpass
250Hz-15kHz LF Voltmeter
DUT e.g. 7122 707 48001 e.g. PM2534
RF Generator
e.g. PM5326
S/N and distortion meter
e.g. Sound Technology ST1700B
Ri=50Ω
Frame aerial
e.g. 7122 707 89001
To avoid atmospheric interference all AM-measurements have to be carried out in a Faraday´s cage.
CD
Use Audio Signal Disc SBC429 4822 397 30184 (replaces test disc 3)
L.P.F. = 13 th order filter 4822 395 30204
DUT Low pass filter 22kHz
L
S/N and distortion meter
e.g. Sound Technology ST1700B
LEVEL METER
e.g. Sennheiser UPM550
with FF-filter
2-3
RC5 Codes
Remote control key System Code Command Code Remote control key System Code Command Code
Standby 17,20, 21, 26 12 ALARM 16 89
CD1 20 55 SLEEP 16 38
CD2 20 56 BRIGHTNESS 16 71
CD3 20 57 REPEAT 20, 26 29
CDR 26 63 SHUFFLE 20, 26 28
Tuner 17 63 TRACK INCREMENT 26 114
Aux 21 63 VOLUME + 16 16
1(ABC) 17,20, 21, 26 01 VOLUME - 16 17
2 (DEF) 17,20, 21, 26 02 3 20, 26 53
3 (GHI) 17,20, 21, 26 03 8 20, 26 48
4 (JKL) 17,20, 21, 26 04 w 17,20, 21, 26 33
5 (MN) 17,20, 21, 26 05 ∑ 17,20, 21, 26 32
6 (OPQ) 17,20, 21, 26 06 1 CD, CDR MODE 20, 26 50
7 (RST) 17,20, 21, 26 07 1 AUX, TUNER MODE 17, 21 31
8 (UVW) 17,20, 21, 26 08 ¡ CD, CDR MODE 20, 26 52
9 (XYZ) 17,20, 21, 26 09 ¡ AUX, TUNER MODE 17, 21 30
0 (Space) 17,20, 21, 26 00 7 20, 26 54
YES 17,20, 21, 26 87 INCREDIBLE SURROUND 16 64
NO 17,20, 21, 26 49 PURE 16 52
EDIT (TEXT) 17,20, 21, 26 82 LOUDNESS 16 50
PROGRAM 20, 26 36 BALANCE L 16 27
PROGRAM TUNER MODE 17 122 BALANCE R 16 26
MUTE 16 13
CONTROLS AND CONNECTIONS CONTROLS AND CONNECTIONS
On the front
0 Source selection ¡ FINALIZE...............................finalizes and unfinalizes
CD 1, CD 2, CD 3 ..................selects the CD changer, recordings
English
English
switches to CD 1, CD 2 or ™ REC TYPE..............................enters/exits the recording
& 0^ %$ # @ ! 0 98 7 6 5
CD 3 menu
CDR........................................selects the CD recorder £ RECORD
TUNER...................................selects the tuner CD™CD..................................selects high speed recording
DIGITAL / ANALOG AUX ....selects the input for an and automatic finalizing of
additional appliance current CD
OPEN/CLOSE
! ...............................................CD changer tray COMPILE CD ........................selects high speed recording
CD CHANGE
@ OPEN/CLOSE........................opens and closes the and automatic finalizing of
CD
CHAN
GER
• 3 CD CHANGER
CD REWRITABLE COMPATIBLE
CD changer tray current program
ANALOG
DIGITAL /
# CD CHANGE .........................selects the next disc tray ≤ ERASE ...................................erases recordings
AUX
Brief Operating Instructions
STANDBY
ON TUNER
$ ...............................................display ∞ Sound control
R
CD 1 iR SENSO
º AM MASTER VOLUME ..............adjusts the volume
AERIAL
% CD RECORDER .....................CD recorder tray
CD 2 6Ω
SPEAKERS
CD 3 CLOCK
/TIMER
ª ^ y STANDBY ON...................switches the unit on and to TREBLE .................................sets the treble level
CD TEXT
L
MINI HIFI SYSTEM
FW- CD RECORDABLE
• FM AERIAL
standby PURE .....................................switches bass and treble
R8 300Ω
DISPLAY
R
& DISPLAY ...............................selects display settings on/off
CD-TEXT EDITING
≥ information/text INCREDIBLE SURR..............creates an incredibly wide
LOSE
OPEN/C
SUBWOOFER
OUT L
DIGITA
OUT stereo effect
* MIC LEVEL ...........................adjusts the microphone
DER
CD RECOR
L
CDR volume
AUX
IN
LOUDNESS...........................boosts treble and bass
L
DIGITA
R IN
L
( MIC........................................microphone jack BASS.....................................sets the bass level
LINE
RECORD OUT
R
CD CD
) Multiple function control § p ...........................................3.5 mm headphone jack
AC MAINS
~
CD
COMPILE
Rotary control: Note: Connecting the headphones will switch off the
MIC
LEVEL
REC TYPE
í JOG CONTROL ë........CDC, CDR: selects the speakers.
ERASE
FINALIZE
EDIT
previous/next track ≥ OPEN/CLOSE........................opens and closes the
MIC
TUNER: selects the CD recorder tray
2-4
1 23 4 previous/next preset tuner • CD TEXT................................switches through CD text
station information
* ( ) ¡ ™£ ≤ ∞ § Keys to press: ª CLOCK/TIMER......................selects the clock function,
YES ........................................confirms a selection activates and deactivates the
á SEARCH..........................CDC, CDR: searches forward, timer
reviews the tracks in a º iR SENSOR ...........................sensor for the infrared
program, controls the cursor remote control
in different menus
TUNER: tunes to a higher Note: You will recognize that various keys will be illuminated
On the back radio frequency on the unit depending on the different modes or
1 AC MAINS ~ ........................After all other 6 AM AERIAL ..........................connect the supplied loop É PLAY/PAUSE..................starts and interrupts programs you are in. This is for your guidance in order
connections have been antenna here playback/recording to facilitate the finding of the relevant keys for
made, connect the power 7 FM AERIAL 300 Ω ...............connect the supplied wire PROG.....................................opens/closes the program selection.
cord to the power outlet. antenna here menu
For optimal performance 8 AUX IN L/R ...........................connect to the analog audio EDIT TEXT.............................enters/exits the text edit
use only the original output of an additional menu
power cable. appliance EDIT TRACK .........................enters/exits the track edit
2 DIGITAL IN ...........................connect to the coaxial output 9 LINE OUT L/R .......................connect to the analog audio menu
of a digital appliance input of an additional REC LEVEL ............................enables the rotary control to
3 DIGITAL OUT........................connect to the coaxial input appliance adjust the level for
of a digital appliance recordings
4 SPEAKERS 6 Ω L/R .............connect to the supplied Ç STOP...............................stops CD play/record, closes
speakers program memory
5 SUBWOOFER OUT ..............connect to the input of a à SEARCH..........................CDC, CDR: searches
subwoofer backward, reviews the tracks
in a program, controls the
cursor in different menus
TUNER: tunes to a lower
radio frequency
NO..........................................cancels a selection
6 7
INSTALLATION INSTALLATION
Power Antenna connections
The type plate is located on the rear of the unit. AM antenna
The supplied loop antenna is for indoor use only.
English
English
1 Check whether the power voltage as shown on the type
plate corresponds to your local power voltage. If it does 1 Fit the plug of the loop antenna to AM AERIAL as shown
not, consult your dealer or service organization. below. SUBWOOFER
AM
AERIAL
2 Make sure all connections have been made before 2 Position the antenna as far as possible from a TV, VCR or
switching on the power supply. other radiation sources. SPEAKERS 6 Ω
FM AERIAL
300 Ω
3 Connect the supplied power cable to AC MAINS ~ and to 3 Turn the antenna for optimum reception.
the power outlet. This switches on the power supply. R
SUBWOOFER
OUT
DIGITAL
OUT
L
Brief Operating Instructions
For optimal performance use only the original power AUX
IN
R DIGITAL
IN
cable. AM L
AERIAL LINE
OUT
R
AC MAINS ~
When the unit is switched to standby, it is still consuming
some power. To disconnect the unit from the power
completely, remove the power cable from the power outlet.
FM antenna
To avoid overheating of the unit, a safety circuit has The supplied wire antenna can only be used to receive nearby TAPE RECORDER
been built in. Therefore, your unit may disconnect stations. For better reception we recommend using a cable
under extreme conditions. If this happens, switch the antenna system or an outdoor antenna.
unit off and let it cool down before reusing it. CD PLAYER CD RECORDER
1 Open the FM AERIAL 300 Ω click-fits by pushing the lever
Speaker connections down as shown below.
The speaker connections are click-fit connectors. Use them as
Analog audio connections Digital audio connections
2 Insert each wire of the antenna into one hole.
2-5
shown below. AUX IN L/R DIGITAL IN
It is possible to use an additional appliance, e.g. tape You can use this coaxial input for recordings from any digital
3 Close the click-fits using the lever.
recorder, TV or VCR, with the unit. audio equipment with a digital coaxial output e.g. CD player
or DVD player.
4 Move the antenna in different positions for optimum
1 Insert the red plug of a cinch cable to the red jack AUX IN R
reception.
and insert the white plug to the white jack AUX IN L. 1 Use a coaxial cable to connect the coaxial output of the
additional appliance with DIGITAL IN on the unit.
2 Connect the other end of the cinch cable to the audio
outputs of the additional appliance. 2 Press DIGITAL / ANALOG AUX repeatedly to select the
IAL IAL
FM AER FM AER
1 Connect the colored (or marked) wire to the red terminal 300 Ω 300 Ω digital input for the appliance.
and the black (or unmarked) wire to the black terminal. 3 Press DIGITAL / ANALOG AUX repeatedly to select the y AUX Digital is displayed.
analog input for the appliance.
2 Connect: y AUX Analog is displayed. 3 Operate your appliance as usual.
– Left speaker to L (red and black)
– Right speaker to R (red and black) The unit complies with the FCC-Rules, Part 15 and with 4 Operate your appliance as usual and adjust volume and DIGITAL OUT
21 CFR 1040.10. Operation is subject to the following sound with the unit. You can use this coaxial output for recordings on any digital
two conditions: audio equipment with a digital coaxial input e.g. CD recorder.
1. This device may not cause harmful interference, and Note: It is not possible to connect a turntable directly to
2. This device must accept any interference received, AUX IN L/R. If you wish to use a turntable with the • Use a coaxial cable to connect the coaxial input of the
including interference that may cause undesired unit, you have to connect an amplifier to AUX IN L/R on additional appliance with DIGITAL OUT on the unit and
operation. the unit. Then connect the turntable to the amplifier. operate your appliance as usual.
LINE OUT L/R Connecting a subwoofer
You can use these outputs for playback or recording on any
A subwoofer can be used to enhance the bass performance of
analog audio equipment e.g. amplifier or tape recorder.
your unit dramatically.
• Use a cinch cable to connect the analog audio inputs of the
1 Use a cinch cable to connect the input of the subwoofer
additional appliance with LINE OUT L/R on the unit and
with SUBWOOFER OUT at the unit.
operate your appliance as usual.
2 Follow the instructions supplied with the subwoofer.
8 9
REMOTE CONTROL DISPLAY
CD Recorder
Remote control buttons Display COMPILE CDC .....current program is being recorded with
2 ...........................switches the unit to standby The display of the unit is divided into 3 sections, which show high speed dubbing and auto finalize
CDR you the following: FM TUNER ..........FM station is being recorded
English
English
CDR, TUNER, CD1,
2
CD2, CD3, AUX........selects the sources CD=CD ............current disc is being recorded with
TUNER CD1 CD2 CD3
Number/alphabet keys Information area high speed dubbing and auto finalize
PRESET STEP TOTAL TRACK TIME TOTAL
REM REC
REM TOTAL
REC TRACK TIME AUX ...................material from an external source is
1–0 ....................keys in numbers for tracks or stations ABC DEF GHI
AM being recorded
ABC – XYZ ........keys in letters for text 1 2 3 PM
É .........................playback is activated
JKL MN OPQ CD CHANGER CD RECORDER TUNER
SPACE ...............keys in a space within the text COMPILE CDC CD R W FINALIZE STEREO NEWS TA EON
CD R W FM TUNER MIC
Å .........................playback is interrupted
4 5 6 CD CD AUX ALC INCREDIBLE
EDIT TEXT ................enters the text edit menu SURROUND AUX
START RECORDING IN PROGRESS FINISH RECORDING IN PROGRESS ..recording in progress
RST UVW XYZ LOUDNESS DIGITAL ANALOG
PURE START FINISH
-VOLUME.............decreases the volume CD TEXT EDIT TRACK REC 20 + 1 2 3 4
.....status of recording progress is shown
7 8 9 PROG ALARM SLEEP 5 6 7 8 9 10
+VOLUME.............increases the volume REPEAT SHUFFLE 11 12 13 14 15
SPACE TEXT CD ..................................pre-recorded CD, finalized CDR or
DISC TRACK ALL 16 17 18 19
É ...........................starts playback/recording AUX 0 EDIT CDRW inserted
Brief Operating Instructions
í ..........................CDC, CDR: selects the previous track VOLUME
CD R ...............................unfinalized CDR inserted
TUNER: selects the previous preset tuner This area is used for feedback of the CD changer, CD recorder, CD RW ............................unfinalized CDRW inserted
- + tuner frequencies, menu options, values and scrolling text
station É FINALIZE .........................(un)finalizing will start
ë ...........................CDC, CDR: selects the next track messages. MIC ................................microphone input is being used
ë
TUNER: selects the next preset tuner ë ALC ................................auto level control is active
station Status lights and flags
Tuner
Ç ...........................stops CD play/recording, closes program Ç PRESET STEP TOTAL TRACK TIME TOTAL REM REC TRACK TIME
STEREO ...........................FM station is being received in stereo
memory AM
PM
á ...........................CDC, CDR: searches forward, reviews the Å AUX
CD CHANGER CD RECORDER TUNER
NO YES COMPILE CDC CD R W FINALIZE STEREO NEWS TA EON DIGITAL ...........................digital input in use for external source
tracks in a program, controls the cursor in CD R W FM TUNER MIC
CD CD AUX ALC INCREDIBLE
SURROUND AUX ANALOG ..........................analog input in use for external source
different menus START RECORDING IN PROGRESS FINISH
LOUDNESS DIGITAL ANALOG
PROGRAM SHUFFLE REPEAT TRACK INCR. PURE
TUNER: tunes to a higher radio frequency CD TEXT EDIT TRACK REC 20 + 1 2 3 4
PROG ALARM SLEEP 5 6 7 8 9 10
à ...........................CDC, CDR: searches backward, reviews REPEAT SHUFFLE 11 12 13 14 15
Music calendar, sound lights and remote control
TIMER ON/OFF SLEEP MUTE DISC TRACK ALL 16 17 18 19
the tracks in a program, controls the PRESET STEP TOTAL TRACK TIME TOTAL REM REC TRACK TIME
2-6
cursor in different menus AM
BRIGHTNESS BALANCE PM
TUNER: tunes to a lower radio frequency L R
Flags
CD CHANGER CD RECORDER TUNER
CD TEXT ..........................CD text is available COMPILE CDC CD R W FINALIZE STEREO NEWS TA EON
Å ...........................interrupts playback/recording LOUDNESS INCREDIBLE PURE CD R W FM TUNER MIC
CD CD AUX ALC INCREDIBLE
SURROUND AUX
YES ..........................selects a selection CD TEXT EDIT ..................text edit menu is active START RECORDING IN PROGRESS FINISH
LOUDNESS DIGITAL ANALOG
SURROUND PURE
NO ...........................cancels a selection EDIT TRACK ....................track edit menu is active CD TEXT EDIT TRACK REC 20 + 1 2 3 4
PROG ALARM SLEEP 5 6 7 8 9 10
PROGRAM ...............opens/closes the program menu REC X..........................record timer is selected REPEAT SHUFFLE 11 12 13 14 15
DISC TRACK ALL 16 17 18 19
SHUFFLE ..................plays tracks in random order PROG ..............................program menu is active
REPEAT ....................repeats a track, the entire CD(RW) or the X ................................clock is selected
ALARM X .....................alarm timer is selected INCREDIBLE SURROUND ....Incredible Surround is active
program
SLEEP .............................sleep timer is selected LOUDNESS ......................Loudness is active
TRACK INCR. ...........selects automatic or manual increment of
REPEAT DISC ...................selected disc is played repeatedly PURE ..............................bass and treble settings are switched
a track
REPEAT TRACK .................current track is played repeatedly off
TIMER ON/OFF ........activates and deactivates the timer REPEAT ALL .....................all discs in the CD changer (or the ...............................command from remote control is being
SLEEP.......................activates the sleep timer program) are (is) played repeatedly received
MUTE.......................mutes the sound SHUFFLE ..........................either all tracks of the program or of Music calendar
BRIGHTNESS...........controls the brightness of the display Remote control batteries the loaded disc(s) in the CD changer or 1–20..........................CDC, CDR: actual track number played,
L BALANCE..............adjusts the volume balance to the left CD recorder are played in random number of tracks on a disc/program
Open the battery compartment order
speaker of the remote control and insert TUNER: preset number of tuned
R BALANCE .............adjusts the volume balance to the right 2 alkaline batteries, type AA CD Changer station
speaker (R06, UM-3). ........................number of disc trays loaded +................................CDC, CDR: disc or program contains
LOUDNESS ..............boosts treble and bass more than 20 tracks
INCREDIBLE Do not use old and new or É ........................playback is activated TUNER: more than 20 radio stations
SURROUND .............creates an incredibly wide stereo effect different types of batteries in Å .........................playback is interrupted are stored
PURE........................switches bass and treble settings on/off combination. CD 1, 2, 3.....................disc tray 1, 2 or 3 is selected and ......spectrum analyzer
loaded with a pre-recorded CD,
Note: Always press the source key of the source you wish to Remove batteries if they are dead or if the remote control is finalized CDR or CDRW
control (e.g. CD1) before selecting the desired function not to be used for a long time. CD R 1, 2, 3..................disc tray 1, 2 or 3 is selected and
key (e.g. SHUFFLE). loaded with an unfinalized CDR
Batteries contain chemical substances, so they should CD RW 1, 2, 3...............disc tray 1, 2 or 3 is selected and
be disposed of properly. loaded with an unfinalized CDRW
10 11
BASIC FUNCTIONS BASIC FUNCTIONS
3 CD changer: LOUDNESS
OPEN/CLOSE • Press LOUDNESS to switch loudness either on or off.
CD CHANGE
Press OPEN/CLOSE on the unit again to close the tray. RECORD
yLOUDNESS is shown and Loudness is displayed if
CD GER
yThe tray is closed and Reading is displayed.
CHAN
• 3 CD CHANGER loudness is on.
English
English
CD REWRITABLE COMPATIBLE CD
yIf an unfinalized disc is inserted, Initializing will CD
ANALOG
DIGITAL /
be displayed.
CD
AUX COMPILE
yCD, the disc tray number, the total number of tracks and
MUTE
STANDBY
ON TUNER
the total playing time of the disc in the last selected disc This feature allows you to temporarily switch off the sound
OR
CD 1 iR SENS
tray are displayed. The track numbers light up in the music without switching off the unit.
CD 2 REC TYPE
ERASE 1 Press MUTE on the remote control to switch off the sound.
ER
K/TIM
CD 3 CLOC calendar.
CD TEXT
FINALIZE
LE MINI HIFI SYSTEM
yMute is displayed and playback/recording will be
CD RECORDAB
FW-
R8 CD recorder:
DISPLAY T continued without sound.
Press OPEN/CLOSE on the unit again to close the tray.
CD-TEXT EDITING
yThe tray is closed and Reading is displayed.
E 2 Press MUTE on the remote control again to switch on the
OPEN/CLOS
yIf an unfinalized disc is inserted, Initializing will
CD RECO
RDER
Sound control sound again.
CDR
be displayed.
Brief Operating Instructions
yCDR, the total number of tracks and the total playing time
Volume adjustment
• Adjust the volume by using MASTER VOLUME Speaker balance
RECORD
of the disc are displayed. The track numbers light up in the
(-VOLUME/+on the remote control). It is possible to adjust the relative volume balance between
CD CD
music calendar.
y The volume level in dB (decibel) is displayed. the connected front speakers.
CD
COMPILE
MIC REC TYPE Playing a CD(RW)
LEVEL
ERASE
Incredible Surround • Press L BALANCE or R BALANCE on the remote control to
FINALIZE
EDIT 1 Press É PLAY/PAUSE (Éon the remote control) to start Stereo sound is determined by the distance between the front adjust the relative volume of the left or right front speaker.
playback. speakers. Incredible Surround enables you to enjoy an incredibly y Balance L (or R) and the actual volume of the left
MIC
CD changer: wide stereo effect, regardless of the speakers’ distance. (or right) front speaker are displayed.
y CD, the disc tray number, the current track number and y When the volume of both speakers is balanced,
elapsed playing time are displayed. The current track • Press INCREDIBLE SURR. (INCREDIBLE SURROUND on the Balance L=R is displayed.
Switching on, switching to standby number is also blinking in the music calendar. remote control) to switch the surround sound effect either
• To switch the unit on press y STANDBY ON on the unit. on or off. Demo mode
CD recorder:
yINCREDIBLE SURROUND is shown and Incredible
y CDR, the current track number and elapsed playing time The demo mode displays various features of the unit and will
2-7
• To switch the unit to standby press y STANDBY ON Surround is displayed if the surround sound effect is on.
are displayed. The current track number is also blinking start automatically.
again on the unit (2 on the remote control). in the music calendar.
Note: The effect of Incredible Surround may vary with different
types of music. • If any source key is pressed:
Loading the CD changer, CD recorder • To switch through the following information, repeatedly y The unit switches to the selected source.
Important! press DISPLAY on the unit: If y STANDBY ON is pressed:
Treble and Bass level adjustment
1) This system is designed for regular CD(RW)s. y Track number, remaining playing time of current track
1 Press TREBLE or BASS on the unit. y The unit switches to standby. After a few seconds, the
Therefore, do not use any accessories such as disc y Track number, remaining playing time of disc
yThe volume rotary is activated to select the treble/bass demonstration will start again.
stabilizer rings or CD treatment sheets, etc. as offered y Track number, actual playing time of current track
settings.
on the market, because they may cause jamming of Cancelling the demo mode
the changer mechanism. 2 Press Ç STOP (Çon the remote control) to stop playback. 2 Turn the volume rotary to adjust the treble or bass. • Keep Ç STOP on the unit pressed for at least 3 seconds to
2) Do not load more than one disc into one disc tray. CD changer: y Treble or Bass and the actual value (between –5 cancel the demo mode.
y CD, the disc tray number, the total number of tracks and and +5) is displayed briefly. y The demo mode is cancelled permanently. The unit
1 CD changer: the total playing time of the disc are displayed. switches to standby. A few seconds later the unit
Press OPEN/CLOSE on the unit to open the CD changer tray. CD recorder: Note: If the volume rotary is not turned for 5 seconds, it will switches to an economy power save mode.
yOpen CDC is displayed and the tray is opened. switch back to volume.
y CDR, the total number of tracks and the total playing
CD recorder: time of the disc are displayed.
Press OPEN/CLOSE on the unit to open the CD recorder tray. PURE
yOpen CDR is displayed and the tray is opened. • To switch through the following information, repeatedly • Press PURE repeatedly to switch bass and treble settings
press DISPLAY on the unit: either on or off.
2 CD changer: y Total number of tracks, total playing time of disc yPURE is shown and Pure is displayed if bass and treble
You can load up to three discs in the CD changer for y CD text is displayed. settings are switched off.
continuous playback without interruption. Insert an yOptimal is displayed if preset bass and treble
audio disc (printed side up) in the right disc tray. • You can interrupt playback by pressing É PLAY/PAUSE settings are switched on.
(Åon the remote control). yPersonal is displayed if personal preset bass and
• You can load another disc in the left disc tray.
y The time where playback was interrupted is blinking. treble settings are switched on.
• To insert a third audio disc, press CD CHANGE on the unit.
yThe CD carousel will rotate until the empty disc tray
is at the right hand side. • To resume playback press É PLAY/PAUSE (Éon the
remote control) again.
CD recorder:
Insert an audio disc (printed side up) in the tray.
12 13
BASIC FUNCTIONS PROGRAM
Playing tracks in random order RECORD
Selecting a disc on the CD changer 1 Press SHUFFLE on the remote control during playback. Erasing a track from the program
CD CD
• Press either CD 1, CD 2 or CD 3 to select a particular disc. y SHUFFLE is shown and either all tracks of the program or 1 If necessary, press Ç STOP on the unit (Ç on the remote
COMP ILE CD control) to stop playback.
of the loaded disc(s) in the CD changer or CD recorder
English
English
are played in random order.
Selecting a track and searching MIC REC TYPE
2 Press either CD 1, CD 2, CD 3, or CDR to select the desired
LEVEL
2 To return to normal playback, press SHUFFLE again. FINALIZE memory.
Selecting a track during playback
• Rotate í JOG CONTROL ë (pressí or ë on the remote EDIT
control) to skip to the beginning of the previous or next track CD text 3 Press PROG (PROGRAM on the remote control), followed by
MIC à SEARCH or á SEARCH (à or á on the remote
on the selected disc.
y Playback continues with the selected track. control) to move through the program steps.
y The track number at the selected step and the total
Selecting a track when playback is stopped program time are displayed.
1 Rotate í JOG CONTROL ë (pressí or ë on the Programming track numbers
Brief Operating Instructions
remote control) to skip to the required track number. You can select tracks and store them either in the CD changer 4 Press NO to remove the track from the program.
or CD recorder memory. If you use the program for playback y Cleared is displayed briefly.
2 PressÉ PLAY/PAUSE (Éon the remote control) to start you can choose one of the two memories, else if you like to y The next programmed track number will move up to this
playback. specify tracks for recording, use the CD changer memory only! position and is displayed together with the step number
y Playback starts with the selected track. You can store any track more than once. and the remaining total program time.
Note: Instead of using í or ë on the remote control, you can 1 Load the desired disc(s) in the disc tray(s). Clearing the program
also directly key in the required track number by using the 1 If necessary, press Ç STOP on the unit (Ç on the remote
numerical keys. For 2-digit numbers, press the keys in 2 Press either CD 1, CD 2, CD 3, or CDR to select the disc. control) to stop playback.
rapid succession.
3 Press PROG on the unit (PROGRAM on the remote control). 2 Press NO.
Searching for a passage during playback y PROG starts blinking and Program is displayed. y Clear Prog? is displayed.
1 Keep à SEARCH or á SEARCH (à or á on the remote
control) pressed to find a particular passage in a backward 4 If either CD 1, CD 2 or CD 3 is selected: 3 Press YES to clear the program.
2-8
or forward direction. Rotate í JOG CONTROL ë to select either: y Prog Cleared will be displayed and PROG goes off.
y Searching is started and playback continues at a low y CD1 (or 2, 3) All: All tracks of CD 1 (or 2, 3) will be
volume. After 3 seconds, the search speeds up with programmed. Note: When you open the CD recorder tray or the CD changer
volume muted. y CD1 (or 2, 3) and track number: The track number of tray the respective program will be cleared.
CD 1 (or 2, 3) will be programmed.
2 Release the key at the desired passage.
Making a program for recording
y Normal playback continues. If CDR is selected:
Rotate í JOG CONTROL ë (press the numerical keys on 1 Select and store all desired tracks in the CD changer
Note: During SHUFFLE, while repeating a track or while playing the remote control; for 2-digit numbers, press the keys in memory (see “Programming track numbers”).
a program, searching is only possible within the current rapid succession) to select a track number.
track. 2 Enter the recording menu (see “Internal recording”).
5 Press YES to store your selection in the memory.
• If the total time of the program is of larger size than the
SHUFFLE and REPEAT y The number of programmed tracks (STEP), Prog and the
remaining recording time of the CDR(W):
total program time are displayed. The track number
Repeating a track, the disc or the program yNot fitting! will be displayed briefly, followed by
blinks in the music calendar.
1 Repeatedly press REPEAT on the remote control during the remaining recording time and Record Prog?
playback to select either: If you nevertheless start recording, only those tracks of the
6 Select and store all desired tracks in this way.
y REPEAT TRACK: The current track is played repeatedly. program that fit onto the CDR(W) will be recorded in
y REPEAT DISC: The entire selected disc is played repeatedly. entirety.
7 Press PROG on the unit (PROGRAM on the remote control)
y REPEAT ALL: All discs in the CD changer (or the program)
to end programming.
are (is) played repeatedly. y PROG stays shown and the program is currently •To change the program, press NO.
available. yEdit Program will be displayed briefly, PROG and
2 Playback starts in the chosen mode. the time of the program start blinking. Now you can
Note: If the maximum number of programmable tracks is change the program (see “Programming track numbers”,
3 To return to normal playback, press REPEAT on the remote reached, the display shows Program full. “Erasing a track from the program” and “Clearing the
control until the display indication disappears. program”).
Note: REPEAT DISC is not possible during SHUFFLE or while
playing a program.
14 15
ABOUT RECORDING INTERNAL RECORDING
High speed recording and automatic finalizing
Basic information Direct Line Recording (DLR) Recording modes (optional) of the current program
The CD recorder deck offers you 3 main functions: The CD recorder is equipped with the high-performance Direct For internal recordings you can record from the internal 1 Make sure the CDR(W) is absolutely free of scratches and
– Recording from the internal CD changer and tuner or Line Recording technique. It ensures a perfect recording of CD changer or tuner. You can choose from the following dust particles.
English
English
from a selected external source the source material, meaning a true “bit for bit” recording. recording modes:
– Finalizing your CDR(W) discs and unfinalizing your DLR will always become active when you make normal – High speed recording and automatic finalizing: 2 Press COMPILE CD on the unit to enter the record mode.
CDRW discs recordings in listen mode. Fast and easy! Record and finalize your CDR(W) in one yBoth decks will be selected in the display, the arrow
– Erasing a CDRW disc quick step while the sound is muted. You can record the starts blinking. The remaining recording time of the
Auto Level Control (ALC) current CD or a program from the CD changer. CDR(W), the total playing time of the source CD and
The recording procedure is the same for CDR and CDRW – High speed recording: Record Prog? are displayed.
Auto Level Control ensures that the tracks on the recorded
discs. Make sure the CDR(W) is absolutely free of Record your CDR(W) fast while the sound is muted. You can
disc have a similar volume level. At all times the already
scratches and dust particles. record an entire CD, a track, a program or a track edit from 3 Press either:
recorded tracks of the CDR(W) disc will be taken as reference
the CD changer. YES to confirm,
for the volume level of the following recordings. ALC is active
For recordings, the minimum track length is 4 seconds. You can – Normal recording and listening: or
when ALC is shown.
Brief Operating Instructions
record up to a maximum of 99 tracks on a disc. The minimum Listen to the recording while you are making it. You can NO to change the program.
of recording time left on the disc is 7 seconds. Otherwise record an entire CD, a track, a program or a track edit yPROG starts blinking. Now you can change the program
Auto level control becomes active when:
Does not fit is displayed and you cannot enter the from the CD changer. (see “Program”) and return to the record mode by
– COMPILE CD is being used,
record standby mode. – Manual recording: pressing COMPILE CD.
– a disc, a track or a track edit is being high speed recorded
Start and stop your recording manually while listening to
and the CDR(W) has recordings on it,
DO NOT FORGET TO FINALIZE! it. You can do either microphone recordings or radio 4 Auto Fin? is displayed.
– a program (consisting from more than one disc) from the
Finalizing a CDR(W) disc is a simple procedure, necessary to: recordings from the FM tuner. Press either:
CD changer is being high speed recorded, or
– play a recorded CDR on a standard CD player or – CD™CD is being used and the CDR(W) has recordings on it. YES, if the CDR(W) is to be finalized after recording,
– play a recorded CDRW on a CDRW compatible CD player High speed recording and automatic finalizing or
and CD recorder. Auto level control will not become active when: NO, if the CDR(W) is not to be finalized after recording.
– CD™CD is being used and the CDR(W) has no recordings RECORD yThe arrow lights, RECORDING IN PROGRESS is shown, high
Copyright protection on it, speed recording and finalizing (if selected) start and the
CD CD
The Serial Copy Management System (SCMS) prevents the – making recordings from the FM tuner, actual recording time remaining starts to count down.
making of a digital copy from a digital copy. The system allows – making recordings from an external source, or COMPILE
CD
2-9
making a digital recording from the original, however in some – making normal recordings in listen mode. Note: If no program is available and you press COMPILE CD,
countries this may require the authorization of copyright holders. you enter immediately into the program menu. Start
REC TYPE
REC LEVEL key ERASE
your programming and return to the record mode by
FINALIZE pressing PROGRAM or COMPILE CD.
When you try to record copy protected material from an external You can adjust the reference record level. This is also possible
source, Copy Protect will be displayed. No further digital EDIT
when ALC is active. This feature can be used for fading your
recording is possible then. recordings in or out.
DO NOT FORGET TO FINALIZE!
When you try to record copy protected material from the 1 Keep REC LEVEL on the unit pressed to enable the rotary High speed recording and automatic finalizing of the Finalizing a CDR(W) disc is a simple procedure, necessary to:
internal CD changer, no digital recording is possible, however control to adjust the record level. current disc – play a recorded CDR on a standard CD player or
the CD recorder will automatically switch to analog recording. 1 Make sure the CDR(W) is absolutely free of scratches and – play a recorded CDRW on a CDRW compatible CD player
2 Turn the rotary control to the left to adjust the desired dust particles. and CD recorder.
Recording CD text record level.
If the original CD has CD Text, this text will be recorded y The actual record level (in dB) will be displayed. 2 Press CD™CD on the unit to enter the recording mode.
automatically, provided that the CD text is not copy protected. yBoth decks will be selected in the display, the arrow starts
In that case, recording of CD text will not be possible and • The record level is reset after the unit has been switched to blinking. The remaining recording time of the CDR(W), the
Text Protect will be displayed. standby. total playing time of the source CD and Record CD1
(or 2, 3)? are displayed.
3 Press YES to start recording and finalizing.
yThe arrow lights, RECORDING IN PROGRESS is shown, high
speed recording and finalizing start, and the actual
recording time remaining starts to count down.
Note: If a program was already available before pressing
CD™CD, this will be ignored. PROG goes off and the
current disc will be recorded. After finishing the recording,
PROG is shown and the program is available again.
16 17
INTERNAL RECORDING INTERNAL RECORDING
DIGITAL /
ANALOG
5 Press YES to confirm your selection. DIGITAL /
ANALOG
4 Press CD 1, CD 2 or CD 3 to select the disc with which you
AUX AUX
yBoth decks will be selected in the display, the arrow wish to mix the microphone.
STANDBY STANDBY
ON TUNER ON TUNER
starts blinking. The remaining recording time of the
OR OR
CD 1 iR SENS CD 1 iR SENS
CDR(W), the total recording time of the CDR(W) and 5 Press REC TYPE on the unit to enter the recording menu.
English
English
CD 2 either Record CD1 (or 2, 3)?, Record Prog? or CD 2
K/TIM K/TIM
CD 3 CLOC CD 3 CLOC 6 Rotate í JOG CONTROL ë to select the manual recording
CD TEXT CD TEXT
Record A-B? is displayed.
MINI HIFI SYSTEM MINI HIFI SYSTEM mode for the microphone:
CD RECORD ABLE CD RECORD ABLE
FW- FW-
R8 R8
DISPLAY DISPLAY
Note: When the CDR(W) already contains a recording, ALC yCD Mix Mic is displayed.
CD-TEXT EDITIN
G
will also become active and ALC will be shown. CD-TEXT EDITIN
G
7 Press YES to confirm.
SE SE
OPEN/CLO OPEN/CLO
6 Press YES to start high speed recording. yWait and Record? are displayed.
RDER RDER
CD RECO yThe arrow lights, RECORDING IN PROGRESS is shown, high CD RECO
CDR CDR
speed recording starts and the actual recording time 8 Press YES to start recording.
remaining starts to count down.
Brief Operating Instructions
RECORD RECORD 9 Rotate í JOG CONTROL ë to select the desired track.
CD CD
CD
• To stop recording, press Ç STOP on the unit. CD
yThe disc tray number, the current track number and
CD CD
COMPILE COMPILE
playing time of the track are displayed.
Normal recording and listening
MIC REC TYPE MIC REC TYPE
LEVEL LEVEL
ERASE ERASE
10 Press É PLAY/PAUSE to start playback.
FINALIZE
Normal recording and listening of an entire disc, a FINALIZE
yThe selected source is mixed with the microphone.
EDIT track, a program or a track edit EDIT
1 Make sure the CDR(W) is absolutely free of scratches and
MIC MIC 11 Press Ç STOP to stop recording.
dust particles.
• To perform microphone recording only, see “Manual
2 Follow steps 2 and 3 of “High speed recording”.
recording” in chapter “External recording”.
High speed recording Manual recording
3 Rotate í JOG CONTROL ë to select one of the
High speed recording of an entire disc, a track, a Manual recording from the FM tuner
following normal record options:
program or a track edit 1 Make sure the CDR(W) is absolutely free of scratches and DO NOT FORGET TO FINALIZE!
If CD changer is selected:
2-10
1 Make sure the CDR(W) is absolutely free of scratches and dust particles. Finalizing a CDR(W) disc is a simple procedure, necessary to:
yCD Listen?: for listening to the entire disc during
dust particles. – play a recorded CDR on a standard CD player or
normal recording
2 Press TUNER repeatedly to select the FM tuner. Then select – play a recorded CDRW on a CDRW compatible CD player
yTrackListen?: for listening to the track during
2 Press either CD 1, CD 2 or CD 3 to select the disc from the desired radio station (see “Tuning to radio stations”). and CD recorder.
normal recording
which you wish to record.
• Press YES to confirm.
3 Press REC TYPE on the unit to enter the recording menu.
• Rotate í JOG CONTROL ë to select the desired
3 Press REC TYPE on the unit to enter into the recording menu. yFM Tuner? is displayed.
track.
yRec Tr and the track number is displayed.
4 Rotate í JOG CONTROL ë to select one of the 4 Press YES to confirm.
• Continue with step 6 of “High speed recording”.
following high speed recording modes: yWait and Record? are displayed.
If a disc from the CD changer is selected:
If CD changer program mode is available:
yCD Fast?: for high speed recording of an entire disc 5 Press YES to start recording.
yProg Listen?: for listening to the program during
• Continue with step 5. yThe arrow lights, RECORDING IN PROGRESS is shown,
normal recording
yTrack Fast?: for high speed recording of a track manual recording starts and the actual recording time
• Press YES to confirm. remaining starts to count down.
If CD changer track edit mode is available:
• Rotate í JOG CONTROL ë to select the track.
yA-B Listen?: for listening to the A–B track during
yRec Tr and the track number is displayed. 6 Press Ç STOP to stop recording.
normal recording
• Continue with step 6.
Manual microphone recording
4 Follow steps 5 and 6 of “High speed recording”.
If CD changer program mode is available: 1 Make sure the CDR(W) is absolutely free of scratches and
yProg Fast?: for high speed recording of the selected dust particles.
• To stop recording, press Ç STOP on the unit.
disc or of the program
2 Set MIC LEVEL to the minimum level to prevent acoustic
If CD changer track edit mode is available: feedback (e.g. a loud howling sound) before you connect
yA-B Fast?: for high speed recording of the A–B track DO NOT FORGET TO FINALIZE! the microphone.
Finalizing a CDR(W) disc is a simple procedure, necessary to:
– play a recorded CDR on a standard CD player or 3 Connect a microphone to MIC.
– play a recorded CDRW on a CDRW compatible CD player
and CD recorder.
18 19
EXTERNAL RECORDING EXTERNAL RECORDING
DIGITAL /
ANALOG
6 Start playback on the selected source. 4 Repeatedly press DIGITAL / ANALOG AUX to select the
AUX
yThe CD recorder starts to record simultaneously and
Manual recording input for the external source with which you wish to mix
STANDBY
ON TUNER Manual recording from an external source
RECORDING IN PROGRESS is shown. The remaining the microphone.
OR
CD 1 iR SENS 1 Make sure the CDR(W) is absolutely free of scratches and
recording time on the CDR(W) is displayed.
English
English
yAUX Digital is displayed if the digital input is
CD 2 dust particles. selected.
ER
K/TIM
CD 3 CLOC Note: If you start playback on the selected source within a
CD TEXT
yAUX Analog is displayed if the analog input is selected.
MINI HIFI SYSTEM track, recording starts at the beginning of the next track 2 Repeatedly press DIGITAL / ANALOG AUX to select the
CD RECORD ABLE
FW-
R8
DISPLAY input for the external source from which you want to record.
or after 2.7 seconds of silence in analog recordings. 5 Press REC TYPE on the unit to enter the recording menu.
G
yAUX Digital is displayed if the digital input is
CD-TEXT EDITIN
7 If a digital source is selected: selected. 6 Rotate í JOG CONTROL ë to select the type of recording:
SE
OPEN/CLO
After the recording process, the CD recorder stops yAUX Analog is displayed if the analog input is selected. yAUX Mix Mic: the microphone is mixed with the
RDER
CD RECO automatically. external source.
CDR
3 Press REC TYPE on the unit to enter the recording menu. yMic Only: only the microphone is recorded.
Note: Recordings from DAT or DCC will automatically stop
Brief Operating Instructions
RECORD after 20 seconds of silence. 4 Rotate í JOG CONTROL ë to select the type of recording. 7 Press YES to confirm your selection.
CD
CD
yAUX Manual?: for manual start of recording yWait is displayed.
CD
COMPILE
If an analog source is selected: yRecord?, AUX and the remaining recording time of
At the end of the recording process, the CD recorder stops 5 Press YES to confirm your selection. the CDR(W) are displayed.
MIC REC TYPE
LEVEL
after a silence of 20 seconds on the source material. yWait is displayed.
ERASE
FINALIZE
yRecord?, AUX and the remaining recording time of 8 Set the optimal recording level on the CD recorder (see
EDIT
• To stop recording manually, press Ç STOP on the unit. the CDR(W) are displayed. “REC LEVEL key”).
MIC yRECORDING IN PROGRESS goes off.
• In addition, you can also set the optimal recording level
6 Start playback on the external source in order to set the
of the microphone by turning MIC LEVEL.
optimal recording level on the CD recorder (see
DO NOT FORGET TO FINALIZE! “REC LEVEL key”).
Analog or digital recording? 9 If AUX Mix Mic is selected:
Finalizing a CDR(W) disc is a simple procedure, necessary to: Press YES on the unit and simultaneously start playback on
When making recordings from an external source, we – play a recorded CDR on a standard CD player or 7 Stop playback on the external source.
the external source.
recommend to do analog recording only if digital recording is – play a recorded CDRW on a CDRW compatible CD player yThe CD recorder starts to record and RECORDING IN
not possible. Digital recording will usually result in better 8 Go to the beginning of the desired track.
2-11
and CD recorder. PROGRESS is shown. The remaining recording time of the
sound quality.
CDR(W) is displayed.
9 Press YES on the unit and simultaneously start playback on
Recording with automatic start the external source.
If Mic Only is selected:
yThe CD recorder starts to record and RECORDING IN
Recording of an entire disc or a track with automatic Press YES on the unit to start recording.
PROGRESS is shown. The remaining recording time of the
start yThe CD recorder starts to record and RECORDING IN
CDR(W) is displayed.
1 Make sure the CDR(W) is absolutely free of scratches and PROGRESS is shown. The remaining recording time of the
dust particles. CDR(W) is displayed.
Note: If Check Input is flashing, check the digital
connection.
2 Repeatedly press DIGITAL / ANALOG AUX to select the 10 Press Ç STOP on the unit to stop recording.
input for the external source from which you want to record. yUpdate is displayed and RECORDING IN PROGRESS goes off.
10 Press Ç STOP on the unit to stop recording.
yAUX Digital is displayed if the digital input is
yUpdate is displayed and RECORDING IN PROGRESS goes off.
selected.
yAUX Analog is displayed if the analog input is selected.
Manual microphone recording DO NOT FORGET TO FINALIZE!
1 Make sure the CDR(W) is absolutely free of scratches and Finalizing a CDR(W) disc is a simple procedure, necessary to:
3 Press REC TYPE on the unit to enter the recording menu. – play a recorded CDR on a standard CD player or
dust particles.
– play a recorded CDRW on a CDRW compatible CD player
4 Rotate í JOG CONTROL ë to select either: and CD recorder.
2 Set MIC LEVEL to the minimum level to prevent acoustic
yAUX CD?: for recording with synchronized start of an
feedback (e.g. a loud howling sound) before you connect
entire disc
the microphone.
yAUX Track?: for recording with synchronized start of
a track
3 Connect a microphone to MIC.
5 Press YES to confirm your selection.
yStart Source, AUX and the remaining recording
time of the CDR(W) are displayed.
20 21
EXTERNAL RECORDING (UN)FINALIZING, ERASING (UN)FINALIZING, ERASING
5 Press YES to confirm your selection.
Automatic track increment RECORD Unfinalizing CDRW discs yErase?, the total playing time and the total number of
In recording mode, tracks will be incremented automatically so CD CD
If you want to record (or erase) on (from) a finalized CDRW, tracks to be erased are displayed. All track numbers will
that the track numbers are in the same position as the original. you have to unfinalize it first. blink in the music calendar.
English
English
CD
COMPILE
• To switch the automatic track increment function on, press Notes: – Unfinalizing will take approximately 2 minutes. 6 Press YES to start erasing.
as often as necessary TRACK INCR. on the remote control – After unfinalizing of the CDRW, CD changes to CDRW yErase is displayed and the operation time remaining
REC TYPE
during stop when CDR is selected. ERASE on the display. starts to count down. The track number of the actual
FINALIZE
yAuto Tr ON is displayed and the function is on. Track – When unfinalizing a CDRW with CD text on it erased track will go off in the music calendar.
increments are now automatically detected from digital EDIT available, this text will be transferred to the
source material. In analog source material, a silence of CD recorder memory. In case the memory is full, you Erasing one or more tracks
2.7 seconds or more is detected as a track increment. have to erase text (see “Erasing from the memory”) 1 Insert the CDRW from which you want to erase tracks in
or to finalize another disc first in order to obtain the CD recorder tray.
• To switch the automatic track increment function off, press Finalizing CDR(W) discs memory space.
Brief Operating Instructions
as often as necessary TRACK INCR. on the remote control Finalizing a CDR(W) disc is a simple procedure, necessary to: 2 Press CDR to select the CD recorder.
during stop when CDR is selected. – play a recorded CDR on a standard CD player, 1 Insert the CDRW you want to unfinalize in the CD recorder
yAuto Tr OFF is displayed and the function is off. – play a recorded CDRW on a CDRW compatible CD player tray. 3 Press ERASE to enter the erasing menu.
Track numbers can now be incremented manually by and CD recorder,
pressing TRACK INCR. on the remote control during – avoid further unwanted recordings on a disc, or 2 Press CDR to select the CD recorder. 4 Rotate í JOG CONTROL ë to select the track number(s)
recording. The minimum track length is 4 seconds. – avoid erasure of tracks on a CDRW. you wish to erase.
3 Press FINALIZE on the unit. yErase and the track number (e.g. 10+)? are displayed.
Notes: – Track numbers cannot be changed after recording. Notes: – Finalizing will take about 2–4 minutes. yUnfinalize? is displayed.
• To select more tracks to be erased, repeat step 4.
– The automatic track increment only works with – After finalization of the CDR(W), CDR(W) changes to
consumer sources with a digital output signal CD on the display. 4 Press YES to start unfinalizing.
Note: When erasing more tracks, the tracks to be erased
according to the IEC 958 (consumer part) audio – During finalization no other operating commands yUnfinal is displayed and the operation time remaining
must be selected in sequence, starting from the last
standard. DAT, DVD and DCC do not deliver this can be executed. starts to count down.
recorded track. Example: The CDRW has 5 tracks
signal.
recorded on it. Now, you can erase tracks 5 and 4. You
Auto finalizing Erasing from a CDRW disc can also erase tracks 5, 4 and 3, but you cannot erase
2-12
When using either CD™CD or COMPILE CD, your recordings tracks 5 and 3!
will be finalized automatically (see “High speed recording and RECORD
automatic finalizing”). yAll track numbers selected for erasing will blink in the
CD CD
music calendar. The remaining track numbers light up.
Manual finalizing when recording is in progress CD
COMPILE
1 Press FINALIZE on the unit during recording. 5 Press YES to confirm your selection.
yAuto Final? is displayed.
yErase? is displayed.
REC TYPE
ERASE
2 Press YES to confirm. FINALIZE
6 Press YES to start erasing.
yFINALIZE is shown. The finalization will start after recording
EDIT yErase is displayed and the operation time remaining
and the actual finalizing time left will start to count down. starts to count down. The track number of the currently
erased track will go off in the music calendar.
Manual finalizing when recording is stopped
1 Insert the CDR(W) you want to finalize in the CD recorder tray. It is possible to erase one or more tracks (starting from the
end of the last track) or the entire CDRW.
2 Press CDR to select the CD recorder.
Erasing an entire CDRW
3 Press FINALIZE on the unit. 1 Insert the CDRW you want to erase in the CD recorder tray.
yFinalize? is displayed.
2 Press CDR to select the CD recorder.
4 Press YES to start finalizing.
yFINALIZE is shown, Final is displayed and the actual 3 Press ERASE to enter the erasing menu.
finalizing time left starts to count down.
4 Rotate í JOG CONTROL ë to select:
yErase Disc?: for erasing the entire disc
22 23
FEATURES FEATURES
RECORD
Storing text during recording Erasing text
You can store and edit text even while recording a single 1 Press EDIT TEXT to enter the text edit menu. Track editing (on CD changer only)
CD CD
track or single CD, or when recording from an external source yCD TEXT EDIT is blinking, Text Edit is displayed. You can create a “track” by marking a passage of music within
CD
COMPILE or tuner. Editing text during finalizing is not possible. Make one track on the current disc. This new “track” can be used for
English
English
sure, when using high speed recording and automatic 2 Rotate í JOG CONTROL ë to select the text erase menu. recording or playing. The minimum track length is 4 seconds.
MIC REC TYPE finalizing, to enter the text before finalizing starts, otherwise yText Erase is displayed.
LEVEL
FINALIZE automatic finalizing will be cancelled. 1 Press EDIT TRACK on the unit.
EDIT 3 Press YES to confirm. y EDIT TRACK starts blinking, Track and the current track
• Follow steps 3–10 of “Storing text during stop mode”. number ? are displayed. The current track number also
MIC 4 Rotate í JOG CONTROL ë to select one of the following: blinks in the music calendar.
Note: Editing text is not possible when a copy protected track yAll Text: All text of the selected disc is chosen to
is analog recorded. Editing is stopped, CDText be erased in one step. 2 Rotate í JOG CONTROL ë until the desired track
Saved is displayed and your text is saved for later yAlbum Artist: CD artist’s name is chosen to be number is displayed.
EDIT TEXT (on CD recorder only) editing. erased.
Brief Operating Instructions
Storing text during stop mode yAlbum Title: CD title is chosen to be erased. 3 Press YES to confirm the selected track.
After you have recorded your CDR(W) you can enter text, e.g. Auto copied text yArtist Tr 1 or (2, 3,…): artist’s name of track 1 or y The marker position A and the track time will be
names to discs and tracks. The text will be displayed during When an artist’s name has been stored for a track, it will be (2, 3,…) is chosen to be erased. displayed. The first 4 seconds of the track will be played
playback. You can enter up to 60 characters per text field. copied automatically into the next track. yTitle Tr 1 or (2, 3,…): title of track 1 or (2, 3,…) continuously.
Only use an unfinalized CDR or CDRW (finalized CDRW must is chosen to be erased.
be unfinalized first). • Press either: 4 Press É PLAY/PAUSE on the unit to play to the desired
EDIT TEXT to confirm the copied text, 5 Press YES to confirm your selection. start position of your new “track” (The initial position of
1 If necessary, press Ç STOP on the unit (Ç on the remote or yErase? or Erase All? is displayed. marker A is always the start of the chosen track).
control) to stop playback. NO to delete the copied text and enter new text.
6 Press YES to start erasing. • To fast forward to the desired start position, press
2 Press CDR to select the CD recorder. Inserting a space y Update is displayed and the chosen text is erased. à SEARCH or á SEARCH on the unit.
1 Press à SEARCH or á SEARCH (à or á on the remote
3 Press EDIT TEXT on the unit to enter the text edit menu. control) to move to the position where the space is to be Erasing from the memory • To fine tune the position, first press É PLAY/PAUSE on the
yCD TEXT EDIT is blinking, Text Edit is displayed. inserted. When the text memory of your CD recorder is full, the messages unit, then rotate í JOG CONTROL ë.
2-13
y The position starts blinking. Memory Full and Finalize Disc will be displayed. If
4 Press YES to confirm. you still want to add a new disc to the text memory, you either 5 Press YES to confirm the position of marker A.
2 Press YES to confirm the position of the insert character. have to erase another disc from the memory or you have to y The marker position B and the new “track” time will be
5 Rotate í JOG CONTROL ë to select either: y A space will be inserted, text will move to the right. finalize another disc. displayed. The first 4 seconds before marker position B
yAlbum Artist: for editing the CD artist. until marker position B will be played continuously.
yAlbum Title: for editing the CD title. Deleting and substituting a character 1 Press EDIT TEXT to enter the text edit menu.
yArtist Tr 1 or (2, 3,…): for editing the artist of 1 Press à SEARCH or á SEARCH (à or á on the remote yCD TEXT EDIT is blinking, Text Edit is displayed. 6 Press É PLAY/PAUSE on the unit to play to the stop position
track 1 or (2, 3,…). control) to move to the character’s position to be deleted or of your new “track” (the initial position of marker B is always
yTitle Tr 1 or (2, 3,…): for editing the title of track 1 substituted. 2 Rotate í JOG CONTROL ë to select the memory view the position of marker A plus 4 seconds).
or (2, 3,…). y The character starts blinking. menu.
yText Memory is displayed. 7 Press YES to confirm the marked passage.
6 Press YES to confirm the selection. 2 If you want to delete the character: y EDIT TRACK is shown, A-B and the track edit time are
Press NO. 3 Press YES to confirm. displayed.
7 Rotate í JOG CONTROL ë (press the alphabet keys on y The character is deleted and the text is shifted one
the remote control) to select a character. position to the left. 4 Rotate í JOG CONTROL ë to select the disc you wish to Note: If you open the CD changer tray, the edit is deleted.
erase from the text memory.
8 Press YES to confirm the selection. If you want to substitute the character: Clearing the track edit
yThe cursor moves to the next character space. Rotate í JOG CONTROL ë (press the alphabet keys on 5 Press YES to confirm. 1 Press NO during stop.
the remote control) to select a new character. yErase Memory is displayed. y Clear A-B? is displayed.
9 Repeat steps 7 and 8 for adding further characters. Press YES to confirm the selection.
6 Press YES to confirm the text erasure of that particular disc. 2 Press YES to clear the markers.
• To change another character, press à SEARCH or y The markers A-B are cleared.
10 Press EDIT TEXT to save the characters that have been
á SEARCH (à or á on the remote control). Note: If there are no discs stored in the text memory,
selected and to exit to the last position in the text editing
menu. Memory Empty will be displayed.
yUpdate is displayed.
24 25
TUNER CLOCK/TIMER
DIGITAL /
ANALOG
2 Keep PROG (PROGRAM on the remote control) pressed for DIGITAL /
ANALOG
AUX AUX
more than 2 seconds.
STANDBY STANDBY
ON TUNER ON TUNER
y Autoprogram is displayed, PROG and the current
OR OR
CD 1 iR SENS CD 1 iR SENS
preset number in the music calendar start blinking.
English
English
CD 2 y All available radio stations for the selected waveband are CD 2
ER
K/TIM K/TIM
CD 3 CLOC stored automatically. PROG goes off, the preset number, CD 3 CLOC
CD TEXT CD TEXT
MINI HIFI SYSTEM the waveband and the frequency of the last preset station MINI HIFI SYSTEM
CD RECORD ABLE CD RECORD ABLE
FW- FW-
R8 R8
DISPLAY DISPLAY
are displayed briefly.
G G
CD-TEXT EDITIN CD-TEXT EDITIN
• To store radio stations for another waveband, repeat steps
SE SE
OPEN/CLO OPEN/CLO
1–2. Make sure to select the next available preset number
RDER RDER
CD RECO first before proceeding, otherwise already programmed CD RECO
CDR CDR
radio stations may be erased.
Brief Operating Instructions
RECORD • To exit the automatic programming, press PROG (PROGRAM RECORD
CD CD
CD
on the remote control). CD
CD CD
COMPILE COMPILE
Note: Strong stations will always automatically be programmed
MIC REC TYPE MIC REC TYPE
LEVEL LEVEL
ERASE
first, followed by the weak stations. ERASE
FINALIZE FINALIZE
EDIT EDIT
Manual programming
MIC 1 Follow steps 1 and 2 of “Tuning to radio stations”. MIC
2 Keep PROG (PROGRAM on the remote control) pressed for
less than 2 seconds.
Tuning to radio stations y PROG and the current preset number in the music
Clock setting
1 Press TUNER to select the tuner. calendar start flashing. Manual clock setting
y Tuner is scrolled. 1 Press y STANDBY ON as often as necessary on the unit to
2-14
3 Press à SEARCH or á SEARCH (à or á on the remote switch the unit to standby.
2 Press TUNER again to select the desired waveband. control) to tune to the desired radio station.
y The selected waveband is displayed. 2 Press CLOCK/TIMER on the unit.
• To allocate the radio station to another preset number,
3 Keep à SEARCH or á SEARCH (à or á on the remote rotate í JOG CONTROL ë (pressí or ë on the 3 Rotate í JOG CONTROL ë to select the clock.
control) pressed for more than a half second. remote control). y Clock is displayed and X starts blinking.
y The selected waveband and Searching are displayed.
The radio tunes to a station with sufficient signal strength. 4 Press YES to confirm the setting. 4 Press YES to confirm the selection.
y PROG goes off, the preset number, the waveband and y The day of the week digit blinks.
4 Repeat searching until you find the desired station. the frequency of the preset station are displayed.
5 Rotate í JOG CONTROL ë to set the day.
• To tune to a weak station, briefly press à SEARCH or • To exit manual programming, press PROG (PROGRAM on
á SEARCH (à or á on the remote control) as often as the remote control). 6 Use à SEARCH or á SEARCH on the unit to move from
necessary for optimum reception. day of the week to hour.
Tuning to preset stations
Storing radio stations 7 Rotate í JOG CONTROL ë to set the hour.
• Use í JOG CONTROL ë (í or ë on the remote control)
It is possible to store up to 40 radio stations. Stations can be until the preset number of the desired station is displayed.
8 Repeat steps 6 and 7 to set the minutes.
selected and programmed automatically or you can do that
yourself. Programming will overwrite your former presets
9 Press YES to confirm the settings.
starting from the last active preset station. After programming
the last stored preset station will be tuned.
Automatic programming
If no preset is tuned, automatic programming starts at preset
number one.
1 Follow steps 1 and 2 of “Tuning to radio stations”.
26 27
CLOCK/TIMER TECHNICAL DATA
You can select different timer functions which will be activated 5 Use à SEARCH or á SEARCH on the unit to move from Subject to modification without notice. Speakers
at a chosen time. Make sure the clock is set before using one hour to minutes of start of recording. System............................................................3 way bass reflex
of these features. General Impedance ............................................................................6 Ω
6 Rotate í JOG CONTROL ë to set the minutes of start of AC Power ..............................................................120 V / 60 Hz
English
English
Woofer ...........................................................................1 × 6.5"
Alarm timer recording. Power consumption Tweeter ...........................................1 × 2.5", Ferro fluid cooled
Active.........................................................................148 W Tweeter ..........................................................1 × 1", Polydome
Alarm timer setting
7 Continue this procedure by using à SEARCH or Standby.....................................................................< 30 W Dimensions, h × w × d .............................12.2 × 9.4 × 12.7 in.
The unit can be used as an alarm clock, whereby the tuner,
á SEARCH to move on to hour and minutes of end of Economy power save mode .......................................< 2 W Weight .....................................................................4.6 kg/each
CD recorder or CD changer starts playback automatically at a
recording and to the day of the week. After each move, Dimensions, w × h × d ...........................10.4 × 12.2 × 15.6 in.
preset time.
always rotate í JOG CONTROL ë to do the settings. Weight (without speakers) ................................................11 kg
1 Press y STANDBY ON as often as necessary on the unit to Amplifier
8 Press YES to confirm the settings. Output power ................2 × 100 W FTC, 6 Ω, 1 kHz, THD 10%
switch the unit to standby.
Frequency response ................60–12,500 Hz FTC, +0.5/-1.5 dB
9 Rotate í JOG CONTROL ë to select from which you S/N ratio..............................................................≥ 80 dBA (IEC)
2 Press CLOCK/TIMER on the unit.
Brief Operating Instructions
want to record. Input sensitivity
3 Rotate í JOG CONTROL ë to select the alarm timer. If you have chosen the tuner as source: AUX IN L/R...............................................................800 mV
y Alarm is displayed, ALARM is blinking. Rotate í JOG CONTROL ë again to select a preset radio MIC...............................................................................1 mV
station and confirm this selected station by pressing YES. DIGITAL IN ..............................500 mVpp (75 Ω)/12–56 kHz
4 Press YES to confirm the selection. Output
y The hour digit is blinking. 10 Press YES on the unit to confirm the source selection. Impedance speakers...................................................≥ 6 Ω
Impedance headphones ..................................32 Ω–600 Ω
5 Rotate í JOG CONTROL ë to set the hour. • To stop the recording press Ç STOP on the unit. LINE OUT L/R ...........................................................500 mV
DIGITAL OUT ..............................500 mVpp (75 Ω)/44.1 kHz
6 Use à SEARCH or á SEARCH on the unit to move from Switching the alarm and record timer on/off SUBWOOFER OUT...........................................................1 V
hour to minutes. • Press TIMER ON/OFF on the remote control repeatedly to CD changer
switch the alarm and/or record timer on or off: Number of programmable tracks............................................40
7 Rotate í JOG CONTROL ë to set the minutes. y ALARM is shown and Alarm ON is displayed when the
Frequency range ...................................................20–20,000 Hz
alarm timer is on. S/N ratio......................................................................≥ 92 dBA
2-15
8 Press YES to confirm the time settings. y REC is shown and REC Timer ON is displayed when
Cross talk ..........................................................≤ -65 dB (1 kHz)
the record timer is on. Total harmonic distortion..................................≤ -94 dB (1 kHz)
9 Rotate í JOG CONTROL ë to select the source you want y ALARM and REC are shown, REC+Alarm ON is CD recorder
to be woken up with. displayed when the alarm and record timer are on. Number of programmable tracks............................................99
y ALARM and REC go off, REC+AlarmOFF is displayed CD playback
10 Press YES on the unit to confirm the source selection. when the alarm and record timer are off. Frequency range.............................................20–20,000 Hz
S/N ratio playback ................................................≥ 92 dBA
• To stop the alarm, press y STANDBY ON on the unit. Cross talk....................................................≤ -65 dB (1 kHz)
Sleep timer
Total harmonic distortion ...........................≤ -84 dB (1 kHz)
Record timer You can set a certain period of time before the unit switches off. Analog recording, digital playback
Record timer setting Frequency range.............................................20–20,000 Hz
1 Press SLEEP on the remote control until the desired sleeper S/N ratio playback ................................................≥ 86 dBA
The unit can do recordings automatically from an external time is displayed.
source or from a preset radio station at a preset time. Cross talk....................................................≤ -65 dB (1 kHz)
y SLEEP is shown and Sleep 60 min, 45 min, 30
Total harmonic distortion ...........................≤ -81 dB (1 kHz)
min,15 min is displayed or, Sleep OFF is displayed.
1 Follow steps 1 and 2 of “Alarm timer setting”. Laser (CD recorder)
2 As soon as the desired time is displayed, do not press Type ..............................................Semiconductor laser GaAIAs
2 Rotate í JOG CONTROL ë to select the record timer. SLEEP again. Wave length...........................................775–795 nm (at 25° C)
y Rec Timer is displayed, REC is shown and X starts
y After the chosen time has elapsed, the unit switches to
Output power............................2.5 mW (Read), 35 mW (Write)
blinking. standby. Beam divergence........................................................60 degree
Tuner
3 Press YES on the unit to confirm the selection. • To deactivate the sleep timer, press SLEEP on the remote Wave range
y The hour digit for the start of recording blinks. FM..............................................................87.5–108.0 MHz
control until Sleep OFF is displayed.
AM................................................................530–1,700 kHz
4 Rotate í JOG CONTROL ë to set the hour of start of
recording.
28 29
2-16
Brief Operating Instructions
TROUBLESHOOTING
WARNING If you are unable to solve a problem by following these hints,
English
consult your dealer or service center.
Under no circumstances should you try to repair the
unit yourself as this will invalidate the guarantee. Do LASER SAFETY
not open the unit as there is a risk of electric shock. This unit employs a laser. Only a qualified service
If a fault occurs, first check the points listed, before taking person should remove the cover or attempt to service
the unit for repair. this device, due to possible eye injury.
PROBLEM POSSIBLE CAUSE SOLUTION
No sound, Volume is not correctly adjusted. Adjust the volume.
no power Headphones are connected. Disconnect headphones.
Speakers are wrongly or not connected. Make sure speakers are properly connected.
Power cable is not securely connected. Connect power cable properly.
No reaction to Electrostatic discharge Disconnect the unit from power supply, then
controls reconnect after a few seconds.
Poor radio reception Weak radio signal Direct the antenna for optimum reception.
Antenna is positioned near a radiation source Change the position of the interfering unit or
such as a TV, VCR, computer, etc. try to switch it off.
Poor bass sound Speakers are not in phase. Connect the colored (or marked) wires to the
colored terminals and the black (or unmarked)
wires to the black terminals.
Bad sound Badly matched setting for the given type of Correct the sound settings on the unit.
music or sound.
Remote control does not Batteries are inserted incorrectly. Insert batteries correctly.
function properly Batteries are flat. Insert new batteries.
Distance to the unit is too large. Reduce distance.
Insert Disc indication The CD(RW) is scratched badly or dirty. Replace or clean the disc.
No CD(RW) inserted or inserted upside down. Insert a CD(RW), with label facing upwards.
The laser lens is steamed up. Wait until the lens has cleared.
Wrong Disc indication, No digital audio disc is inserted. Insert a digital audio disc marked with “Digital
Use Audio CD indication Audio” and the special logo.
Disc Recover indication Power loss Wait a few minutes. The disc is being repaired.
Disc Error indication Disc Recover was not able The disc can still be played, but not recorded
to repair the disc. or finalized further.
Check Input indication Wrong input is chosen. Select the correct input.
No correct digital source is detected after Make sure the connection cable is properly
starting recording. connected.
Does not record CDR(W) is scratched or dirty. Make sure the CDR(W) is absolutely free of
scratches and dust particles.
The inserted disc is not recordable. Insert a digital CDR(W) and make sure it is
unfinalized.
Recording process is interrupted (power Start recording again.
loss, mechanical shock).
Recorded disc does not The inserted CDR(W) is not finalized. Finalize the CDR(W).
play in another standard The CDRW is inserted in a non-CDRW Insert the CDRW in a CDRW compatible
CD player compatible CD player. CD player.
30
3-1
Warnings & Safety
© WARNING ESD ñ WAARSCHUWING
All ICs and many other semiconductors are susceptible to Alle IC´s en vele andere halfgeleiders zijn gevoelig voor
electrostatic discharges (ESD). Careless handling during electrostatische ontladingen (ESD).
repair can reduce life drastically. Onzorgvuldig behandelen tijdens reparatie kan de levensduur
When repairing, make sure that you are connected with the drastisch doen vermindern. Zorg ervoor dat u tijdens reparatie
same potential as the mass of the set via a wristband with via een polsband met weerstand verbonden bent met hetzelfde
resistance. Keep components and tools at this potential. potentiaal als de massa van het apparaat.
Houd componenten en hulpmiddelen ook op ditzelfde potentiaal.
f ATTENTION i AVVERTIMENTO
Tous les IC et beaucoup d´autres semi-conducteurs sont d WARNUNG Tutti IC e parecchi semi-conduttori sono sensibili alle scariche
sensibles aux décharges statiques (ESD). Leur longévite Alle ICs und viele andere Halbleiter sind empfindlich statiche (ESD).
pourrait être considérablement écourtée par le fait qu´aucune gegenüber elektrostatischen Entladungen (ESD). La loro longevità potrebbe essere fortemente ridatta in caso di
précaution nést prise à leur manipulation. Unsorgfältige Behandlung im Reparaturfall kann die non osservazione della più grande cauzione alla loro
Lors de réparations, s´assurer de bien être relié au même Lebensdauer drastisch reduzieren. manipolazione. Durante le riparationi occorre quindi essere
potentiel que la masse de l´appareil et enfileer le bracelet Sorgen Sie dafür, daß Sie im Reparaturfall über ein Puls- collegato allo stesso potenziale che quello della massa
serti d´une résistance de sécurité. armband mit Widerstand mit dem Massepotential des delápparecchio tramite un braccialetto a resistenza.
Veiller à ce que les composants ainsi que les outils que l´on Gerätes verbunden sind. Assicurarsi che i componenti e anche gli utensili con quali si
utilise soient également à ce potentiel. Halten Sie Bauteile und Hilfsmittel ebenfalls auf diesem lavora siano anche a questo potenziale.
Potential.
© AVAILABLE ESD PROTECTION EQUIPMENT :
anti-static table mat large 1200x650x1.25mm 4822 466 10953
small 600x650x1.25mm 4822 466 10958
anti-static wristband 4822 395 10223
connection box (3 press stud connections, 1MΩ) 4822 320 11307
extendible cable (2m, 2MΩ, to connect wristband to connection box) 4822 320 11305
connecting cable (3m, 2MΩ, to connect table mat to connection box) 4822 320 11306
earth cable (1MΩ, to connect any product to mat or to connection box) 4822 320 11308
KIT ESD3 (combining all 6 prior products - small table mat) 4822 310 10671
wristband tester 4822 344 13999
© SAFETY ñ
Safety regulations require that the set be restored to its Veiligheidsbepalingen vereisen, dat het apparaat in zijn
original condition and that parts which are identical with oorspronkeliijke toestand wordt teruggebracht en dat
those specified be used. onderdelen, identiek aan de gespecificeerde, worden toegepast.
Safety components are marked by the symbol De Veiligheidsonderdelen zijn aangeduid met het symbool
f i
Les normes de sécurité exigent que l`appareil soit remis Le norme di sicurezza estigono che l´apparecchio venga
à l`état d`origine et que soient utilisées les pièces de rimesso nelle condizioni originali e che siano utilizzati i
rechange identiques à celles spécifiées. d pezzi di ricambiago identici a quelli specificati.
Les composants de sécurité sont marqués Bei jeder Reparatur sind die geltenden Sicherheitsvor- Componenty di sicurezza sono marcati con
schriften zu beachten. Der Originalzustand des Gerätes
darf nicht verändert werden. Für Reparaturen sind Original-
ersatzteile zu verwenden.
Sicherheitsbauteile sind durch das Symbol markiert.
© DANGER: Invisible laser radiation when open. CLASS 1
AVOID DIRECT EXPOSURE TO BEAM.
LASER PRODUCT
s Varning ! ∂ Advarsel ! ß Varoitus !
Osynlig laserstrålning när apparaten är öppnad och Usynlig laserstråling ved åbning når sikkerhedsafbrydere Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiina
spärren är urkopplad. Betrakta ej strålen. er ude af funktion. Undgå udsaettelse for stråling. näkymättömälle laserisäteilylle. Älä katso säteeseen !
© f
After servicing and before returning the set to customer "Pour votre sécurite, ces documents doivent être utilisés par
perform a leakage current measurement test from all des spécialistes agréés, seuls habilités à réparer votre
exposed metal parts to earth ground, to assure no appareil en panne".
shock hazard exists.
The leakage current must not exceed 0.5mA.
3-2
Service Tools
TORX T10 screwdriver with shaftlength 150mm ......................................4822 395 50423
TORX screwdriver set SBC 163 ..............................................................4822 295 50145
Audio signal disc SBC 429......................................................................4822 397 30184
Playability test disc SBC444 ...................................................................4822 397 30245
Test disc 5 (disc without errors) +
Test disc 5A (disc with dropout errors, black spots and fingerprints)
SBC 426/426A ....................................................................4822 397 30096
Burn in test disc (65 min. 1kHz signal at -30dB level without "pause") ...4822 397 30155
Handling Chip Components
3-3 3-3
SERVICE TESTPROGRAM
VARIOUS TESTS To enter Service
Testprogram hold * To leave Service Testprogram plug mains cord off.
STOP & PLAY buttons
depressed while
plugging mainscord in.
Display shows S stands for Service mode
version number
of the µP - software. VXX stands for version number
of the software used in the
S-FW-R8-VXX front µP.
EEPROM TEST EEPROM CLEAR QUARTZ TEST NTC TEST ROTARY ENCODER
TEST
LOUDNESS button N PURE button N N SEARCH 5 button AUX button N JOG CONTROL N JOG CONTROL N
pressed? pressed? pressed? pressed? turned ccw? turned cw?
Y Y Y Y Y Y
Tact frequency µP
(divided 32kHz)
Testpattern is written to Load default data ! Display shows Display shows Display shows Display shows
Display shows
an address
32K NTC XX JOG LEFT JOG RIGHT
and
read back again
NEW 2048Hz can be measured XX = value in °C for 2s. for 2s.
for 1 second on pin 9 of µP Source = AUX
N STOP button N
N Test ok? SEARCH 5 button
pressed?
pressed?
Y Y Y
Tact frequency µP
(divided 12MHz)
Display shows
Display shows Display shows
ERR PASS 12M
1465Hz can be measured
on pin 9 of µP
STOP button N
STOP button N pressed?
pressed?
Y
Y
FW-R8 Service Testprogram Main 2000 03 15
3-4 3-4
To enter Service
Testprogram hold * To leave Service Testprogram plug mains cord off. SERVICE TESTPROGRAM
PLAY & STOP buttons CDR MODULE
depressed while
plugging mainscord in.
Display shows S stands for Service mode
version number
of the µP - software. VXX stands for version number
of the software used in the
S-FW-R8-VXX front µP.
CDR ELECTRICAL TEST CDR MECHANICAL TEST CDR DC-ERASE MODE
for visual inspection only
Insert CD-DA disc CDR button N FINALIZE button N ERASE button N
before starting the test pressed? pressed? pressed?
MODULE Y Y Y
INFORMATION
Display shows for 2s each: FOCUS TEST Complete disc will be
• Software version of DASP Objective moves erased with double speed.
(flash ROM 7703) continuously up/down. (starting from PMA-area
• Software version of up to and including
Display shows:
basic engine processor
BUSY ATIP leadout area)
(flash EPROM 7208)
The display shows the
MAIN BOARD DIAGNOSTIC countdown of the
remaining time required
SLIDE TEST TRAY TEST
to complete the operation:
DRAM TEST 7702
FFWD 6 button ER mm ss
Display shows: pressed? N N STOP button NEXT 6 button N OPEN/CLOSE button N
DTST1 mm: remaining minutes
pressed? pressed? pressed?
Y ss: remaining seconds
Y Y Y
CHECKSUM TEST 7703 FFWD 6 button
Display shows: pressed? N
DTST2 Exit Mech. Testprogram
Slide moves Tray opens.
Y continuously in/out. N
Display shows: Disc erased?
Display shows: OPENED
ERASE TEST 7208 BUSY (even when tray is blocked)
Y
Display shows:
DTST3
Display shows:
PASSED
ADC/DAC TEST 7406 FFWD 6 button PREV 5 button N OPEN/CLOSE button N
Display shows: pressed? N pressed? pressed?
DTST4
Y
Y Y
COMMUNICATION TEST STOP button N
(DSA-BUS) FFWD 6 button pressed?
Display shows: pressed? N Dependent on the Tray closes.
DTST5 moving direction, Display shows:
Y Y
slide moves to inner CLOSE
or outer end position. (even when tray is blocked)
Display shows: Exit DC-ERASE Mode
N FFWD 6 button N N
TEST O.K.? DERR n all errors shown?
n=number of failed test pressed?
Y Y
Y
Note: With the DC-Erase mode the CD-RW can be
Display shows next error
changed back in its original state, like a new disc.
Stopping the erase-function by switching power off
will leave the disc in an unpredictable status!
CDR - LOADER TEST
CD-DA disc N Display shows: FFWD 6 button N
inserted? NO DISC pressed?
Y
Y
Display shows actual
playing time.
The test is performed by FFWD 6 button
playing 5s at beginning, pressed? N
5s in the middle and 5s at
Y
the end of the disc.
Exit CDR electrical Test
N Display shows: FFWD 6 button N
TEST O.K.? BERR 1 pressed?
Y
Y
Exit CDR electrical Test Exit CDR electrical Test
FW-R8 Service Testprogram CDR 2000 02 14
4-1 4-1
Wiring Diagram FW-R8
KEY_GND
KEY_GND
CDC_KEY
LIGHT GUIDE 3 CDC KEY
D_GND
+5V6
SUBWOOFER
LED
LINE OUT
1112
0021
AUX IN
1 1
220mm
140mm
8016
8020
3p
3p
1 1
MIC_KILL
1
SW_INFO
19 1104
1 1
1538 AMPLIFIER L/R
FRONTBOARD
1103
0043
SRDT SRDT 1525 1526 1527
MIC_DET CD_SH_STR
CD_SH_CLK
DQSY 8015 ( 280mm ) DQSY Power 5
FW 7/8 R Series LED_CLK
SICL
UP_CLK FFC 4 p UP_CLK
LED_ON D_GND D_GND
LED_STR CD_SH_DATA
1325
DATA SILD 1
SW_INFO
1102
3
+5V6 D_GND CD_SH_STR
D_GND F2 CD_SH_CLK
JOG_A F1 8014 ( 400mm ) SICL
(220mm)
JOG_B -30V FFC 19 p
8322
TU_DATA
CD_SH_DATA
STEREO
ENABLE
CDR_I2C_DATA
TU_CLK
CDR_REQKBE
+5V6
CDR_I2C_CLK
CDR_KEY1
D-GND
SILD
CDR_RESET
CDR_KEY2 D_GND
MPX
D_GND
DIG_SW0
DIG_SW2
DIG_SW1
KEY_GND D_GND F2 27
D_GND
D_GND
D_GND
I2C_CLK
D-GND
JOG_VOL_A F1 1 1262
1
0042 0042
0011
1261
JOG_VOL_B I2C_DATA +5V6 +5V6
+5V
-30V
1124 PWRDWN +5V6 D-GND D-GND
1 NTC +12M +12M
1106
1105
D_GND
SA_IN D_GND A-GND A-GND
8018
1 1 1 HP_DET 1 I2C_CLK +12A +12A
AMP_ON (220mm) AMP_ON
I2C_DATA AWG26
RIGHT RIGHT
AWG 26 / 4 p
AWG 26 / 6 p
PWRDWN 9p
POWER L/R
FFC / 15 p
FFC / 5 p
AA-GND AA-GND
(280mm)
OUT
IN
(340mm)
DIGITAL
DIGITAL
(120mm)
(280mm)
(340mm)
FFC / 7 p
NTC
8002
8006
8011
8012
8016
SA_IN LEFT LEFT
HP_DET
Power 5
19 P5 P5
1536 1 1
AB AB
PWRDWN PWRDWN
1 1
CDR_ON
-30V -30V
TUNER 1160
DIGITAL I2C SHIFT-
+12V M
P_GND
P_GND
1162-A 1162-B F2 8017 F2
1 REGISTER F1 F1
ECO 5 IN/OUT (340mm)
DIG_SW0
DIG_SW1
DIG_SW2
STBY AWG26 STBY
D-GND
TU 95
1258
SWITCHING 8p
1264
CDR_ON CDR_ON
08
10
09
EBU_SIGNAL
EBU_SIGNAL
EBU_SIGNAL
+5V
TU_DATA
NTC NTC
AF-BOARD
STEREO
ENABLE
TU_CLK
1 1 1
EBU_GND
EBU_GND
D-GND
30 1263 1
SHIELD
SHIELD
SHIELD
MPX
Version 7 NON DPL
AWG26
(340)
8323
(220)
8903
(280)
8324
(280)
8325
5p
4p
+3V
4p
3p
1163
1164
1 1 1
MAINS
1913
1912
1911
0027
1 1 21
1
LEFT LEFT Power 5
A-GND 8010 ( 140mm ) A-GND
8350 (220mm)
RIGHT AWG 26 / 4 p RIGHT
AWG26 / 4p
+12V +12V
1
TRANS-
8031
FORMER
1521 Handsoldered wire on Af7
1 1
ANA_IN_LEFT ANA_OUT_LEFT
CD R/W AA_GND
8009 ( 280mm )
AA_GND
ANA_IN_RIGHT ANA_OUT_RIGHT
CDR MINI 99 ANA_OUT_RIGHT AWG 26 / 5 p ANA_IN_RIGHT Ac1 8901 Ac1
ANA_OUT_LEFT ANA_IN_LEFT Ac2 (140) Ac2
2p
1420
Part of
1 1 1537 transformer
EBU_GND +3V
8008 ( 220mm ) 1
EBU_SIGNAL EBU_SIGNAL
CHAU / 3 p
SUPPLY CDr/w
0011
1351
SHIELD SHIELD
1704 EBU_GND 8007 ( 180mm )
1 +5V/-8V/+12V
CDR_ON
Ac1
CD_SH_DATA
Ac2
CDR_I2C_DATA EBU_SIGNAL AWG 26 / 6 p
RIGHT_OUT
CD_SH_STR
CD_SH_CLK
RIGHT_OUT
+12V M
P_GND
P_GND
LEFT_OUT
OE_LATCH
LEFT_OUT
D_GND SHIELD
SW_INFO
RIGHT_IN
CD_PORE
RIGHT_IN
EBU_OUT
LEFT_IN
AA-GND
HP_DET
LEFT_IN
AA-GND
AA-GND
UP_CLK
CDR_I2C_CLK
SHIELD
D_GND
D_GND
D_GND
+5V CD
A_GND
A_GND
1702
A_GND
D-GND
D-GND
D-GND
D-GND
D_GND
D_GND
D_GND
DQSY
SRDT
CD_R
CDR_REQKBE
SILD
CD_L
+12M
+12V
+12A
+12A
SICL
+12V
+5V
+5V
MIC
+3V
-8V
CDR_RESET
+5V
+5V
-8V
D_GND 1354
1501
1528
1533
1522
D_GND 1
0012
26
FAN
1 1 1 1 1 GND
1
SHORTCUT FAN
CONNECTOR (Part of
or JUMPER on AF7 8351 ( 280mm ) Powermodule)
AWG 26 / 7p
8003 ( 400mm )
8004 ( 140mm )
1130
1
AWG 26 / 3p
FFC 26 / 6p
MIC_KILL
MIC_DET FRONTBOARD 2
LED_CLK CDRM 99 (Design front)
LED_ON
LED_STR
DATA LEGEND
+5V6
D_GND 0041 1166 1 1
1167
1142
JOG_A 1 FFC TOP ENTRY
MIC_DET 1 MIC_DET
JOG_B 8019 ( 140mm )
D_GND D_GND FFC SIDE ENTRY
CDR_KEY1
AA-GND
RIGHT_OUT
D_GND D_GND
LEFT_OUT
CDR_KEY2 AWG 26 / 4 p EH TOP ENTRY
RIGHT_IN
+12A
MIC_KILL MIC_KILL
LEFT_IN
HP_DET
AA-GND
MIC
KEY_GND 8030
JOG_VOL_A EH SIDE ENTRY
(140 mm)
JOG_VOL_B DIPMATE
GND bottom plate BOARD to BOARD JQ
MIC-AMP. PH TOP ENTRY
D-GND
1
With ALC HEADPHONE PH SIDE ENTRY
CD-CHANGER UP_CLK
DQSY Mic Mix XH SIDE ENTRY
3CDC 99 DS SRDT
KILL_R/GND
SHIELD FFC / 23 p
8001 (420mm) (Part of 3CDC Module)
EBU_OUT
+3V
KILL_L/GND/OE_L
CD_PORE
D-GND
SILD
CD_SH_DATA
SICL
CD_SH_CLK
CD_SH_STR
SW_INFO
+12M
D-GND
+5V CD
CD_R
AA-GND
CD_L
23
99 Wiring Diagram FW-R8 (2000-02-22)
5-1 5-1
Block / Leveldiagram
not on all versions ALC
x100
p
MIC IN CONTROL Headphone out
Nom. 1 mV BASS 0 dB 2800 mV
ALC IS
MIC L&R
ALC
MUTE 1 POWER
VOLUME I SOUND VOLUME II SLOW AMP
SOURCE x5 FADER Power Board
SELECTOR for details see
TUNER Ri=100K
Chapter 9
Nom. 110 mV
x5 50 dB
Part of TDA7437 Part of TDA7437 Part of TDA7437
Part of TDA7437
3CDC99-DS GAIN
IS
Nom. 1000 mV TU +2 dB MUTE 1 SUBWOOFER OUT
3CDC 0 dB SLOW
45 dB 0 dB 150 mV
CDR99 0 dB
AUX 0 dB
CDR99
CDR99 Nom. 500 mV
Nom. 1000 mV
MUTE 2 LINE OUT
AUX SLOW
MIN 800 mV 45 dB Nom. 500 mV
MAX 2200mV
AF 7 Board
for details see
Sectrum analyzer Chapter 8
Nom. 4000 mV
DIGITAL IN LEVEL
BUFFER
Nom. 500mVpp
DS 2
a CDR99 Digital in
LEVEL
3CDC99 Dig. out BUFFER
b Nom. 2000mVpp
Nom. 500mVpp
DS 1
a Digital out
LEVEL
CDR99 Dig. out BUFFER
b 500mVpp / 75Ω
Nom. 500mVpp
Digital switching Board
6-1 6-1
1160 B2 4204 C2
Digital switch Board Copperside view 1162 B1 4205 B1
1163 B2 4206 B1
1164 A2 5130 A1
2220 B2 7140 B1
2221 A1 7142 C1
2222 B2 7145 B1
2225 B2 9401 B2
2226 A2 9402 B2
3
2227 A2 9403 C1
1164
2221
2228 B1 9404 B1
1
6
1
3368 3356 3362
3363
2235
3354
2230 C1
5130
2232
2226 2231 C2
3
7 1
2232 A1
2233
2222
7140
2227
6
3359
2233 B1
8 14
3365
2234 B1
1163
3364 2235 A1
3366
4205
3358
4206
9401
3351 2236 C2
9402
3350 C2
4203
9404
1
3351 B1
5
2228
1162
9 16 2225 3353 B2
3355
2234
2220
3354 A1
3361
7145 3355 B2
1
3353
1160
2
3367 3360
3356 A1
1 3357
4
8
3
4
3357 B2
5
3350
9 16 3358 B1
2236
3359 B2
2230
7142 2231
4204 3360 B1
8 1
4201 3361 B1
3362 A1
9403 3363 A1
3364 B1
3365 B1
3366 B1
3367 B1
3368 A1
4201 C2
CDR-Mini Digital switch Board Copperside view stage.4 (2000-03-08)
4203 B1
Front Board
TABLE OF CONTENTS
Block Diagram .................................................................6-2
3CDC-Key Board
Circuit Diagram ..............................................................6-1
Component Layout.........................................................6-1
Digital Switching Board
Component Layout.........................................................6-1 3 CDC-Key
Circuit Diagram ..............................................................6-3 1172
1 DSC 3407
3CDC Key Board Copperside view
Light Guide Board DISC CHANGE 1172
10K 2262
OPEN/CLOSE
2
Component Layout.........................................................6-3
3407
1174 1173
2262
100p
3
Circuit Diagram ..............................................................6-3
1173
1174
Technical Front Board CDR-Mini 3CDC Key Board Copperside view stage .4 (2000-02-23)
Component Layout Copperside view .............................6-4
Circuit Diagram ..............................................................6-5
Component Layout Copperside view .............................6-7
Design Front Board
Component Layout.........................................................6-8
Circuit Diagram .............................................................6-9
Microphone Board
Component Layout.......................................................6-10
Circuit Diagram ............................................................6-10
Electrical Partslist ............................................................6-11
6-2 6-2
Blockdiagram
separate blockdiagram
CDR-Module
for details see
Chapter 11
1 1105
FRONT BOARD (Technical Front) PRESET STEP TOTAL TRACK TIME TOTAL REM REC TRACK TIME
I2CW_DATA
CWReqKbe
I2CW_CLK
CWReset
AM
TU CE +D PM
CD CHANGER CD RECORDER TUNER
TU Data 7123 CD R W COMPILE CDC CD R W FINALIZE STEREO NEWS TA EON
FM TUNER MIC 1102
TUNER TU CLK
CD CD AUX
START
STAR
ST ART RECORDING IN PROGRESS
ALC
FINISH
INCREDIBLE
SURROUND AUX
19
for details see 7121 LOUDNESS DIGITAL ANALOG CD Swinfo
PURE
separate blockdiagram STEREO
RDS DECODER CD TEXT EDIT TRACK REC 20 + 1 2 3 4
Chapter 7 PROG ALARM SLEEP 5 6 7 8 9 10 CD ShSTR
SAA6579T RDS REPEAT SHUFFLE 11 12 13 14 15
RDS DISC TRACK ALL 16 17 18 19 CD ShCLK
TUNER BUS RDS
1 DISPLAY BUS CD SICL
CD TEXT BUS
0042
CD ShDATA
1104 +D 7112
1 CD TxtIN CD SILD
RC5
IR EYE CD BUS
3CDC Module CD TxtDQSV 2 1 7108
for details see 3 MICROPROCESSOR
separate blockdiagram CD TxtCLK +D F2
Chapter 10 TMP88CU77ZF AF7 Board
RESET F1 for details see
separate blockdiagram
7111 -30V Chapter 8
7110
+5V6
EEPROM
M24C01
PWRDWN, AmNTC
Light Guide +5V6 +5V6 I2C_CLK, I2C_DATA I2C_CLK, I2C_DATA
+5V6 7122
MULTIPLEXER SA IN
FREQUENCY FILTER
SA1
............ HEF4051BT
SA2 SA_IN
SA3
0021 1103 7107 7120 SA4
1 2
SHIFT REGISTER I C SHIFT REGISTER 1
+5V6 +5V6 74HC4094D M62320FP
3CDC-Key
0043 1172
JOG, VOL
1
KEY1
KEY2
+5V6
1124 1 15
1130 1 15
FRONT BOARD (Design Front)
KILL
DET
LED CLK
LED ON
LED STR
DATA
0041 MIC
1
DET LED +5V6
KEY1, KEY2
LED CLK
LED ON
LED STR
LED CLK
LED ON
LED STR
DATA
Microphone Board
+SR +SR
DATA
KILL 7130 7132
SHIFT REGISTER SHIFT REGISTER
+SR +SR +5V6 +E
74HC4094D 74HC4094D
+E +E
1131 1134
+5V6 +SR
JOG VOL
............ ............
+SR +SR +SR +SR
6-3 6-3
1 2 3 4 5 6 7 8 9
1160 A1
1162-A E9
1162-B B9
1160
+5VA Digital switch Board
to Front Board 1106
1 DIGI_IO_SW1 1163 C1
5,6V
1164 E1
2 DIGI_IO_SW0
10 9 16 2220 B3
3 2221 E8
VDD
LSB MSB 2222 F5
4 DIGI_IO_SW0 LOGIC
A 220R
A 2225 D2
2226 E1
5
+2.5VIC 7142 2227 A3
3359 2,5V
FE-ST-VK-N DIG. IN 2228 E9
HEF4052B
2236
100n
2227
1u
YKC21-3421 2230 B4
100n LL 1 9402 4 2231 B1
2232 F7
2231
5 9403 3 2233 E7
H LH
3350 2234 B9
+5VA
5 1162-B 2235 E8
2220
470R 5,6V
470R
3 2
3361
3367
100n
82R
+2.5VIC L HL
2234 2236 A2
3350 B2
B DIGI_IO_SW1 digital out selection:0/1=CDC/CDR 4 100n B
2230
100n
HH 3351 C3
3365
100K
DIGI_IO_SW0 digital in selection:0/1=CDC/AUX 3353 D4
DIG DIG DIG ANA 3354 E9
DIGI_IO_SW0 mute EBU to CDR:0/1=mute off/mute on
3355 E4
3358 12
LL 3356 E6
10K 1,2V 100R 3357 D3
H 14 3358 B3
LH
12 13 3364 DIGI_IO_SW1 0 Dig-output of set is 3CDC
1,2V 3359 A2
3351 13 L 1 Dig-output of set is CDR
15 3360 E3
HL
1163 7140-F 10K +5VA DIGI_IO_SW0 0 CDR Input is Dig-out of 3CDC 3361 B8
9401
1 CDR Input is Dig-In of set
C 1 EBU GND
C 3362 E6
100K
11
3366
HH 3363 E9
in
2 EBU_OUT DIGI_IO_SW0 0 CDR Inputmute is off
VEE VSS 1 CDR Inputmute is on 3364 C3
3 SHIELD 3365 B3
to CDR
6 7 8
3366 C3
4 EBU GND
+2.5VIC 3367 B8
5 EBU IN 3368 F7
out 5130 E8
6 SHIELD
+5VA 7140-A E6
5,6V 16 9 10 14 7140-B D7
SXXB-EH-A 3 4 1,3V 7140-C D7
VDD
D 2225 +2.5VIC +2.5VIC
MSB
LOGIC
LSB
D 7140-D E7
7140-E E7
100n 7140-B 7140-F C3
ANA DIG
7145 7142 A5
74LVU04D 7140-C
3357
3353
68K
56K
DIG. OUT 7145 D4
HEF4052B 2K2 9401 C2
1,1V YKC21-3421
1 3363 2
LL
5 6 9402 A6
3356
140:50 270R 9403 B6
5 LH H
470R 1,1V 1 2 3354 1 F600 A2
EH-S 2221 F601 A2
to AF BOARD
3362 7140-A 7140-D 1 6 39R
2235
150p
3355 P
3360 P
5 1162-A F602 E9
100K
100K
2 3
E 3 HL L
100n 2 E F603 A2
2 9 8 F604 E9
4 3 4
2228
100n
HH 6RG 5130 F605 A1
1 F606 A2
2233
100n
1164 DIG DIG
DIG F607 C2
2226 7140-E F608 B9
12 LL ANA ANA
100n F609 D2
11 10
F610 E1
2222
100n
ANA DIG ANA
14 H
560R
3368
LH F611 E1
13 F612 E1
L
15
F HL
DIG F
2232
P...for Provision only
1n
11 HH
. . . V DC Voltages measured VSS VEE
V EVM during operation
8 7 6
DIG
DIG DIG DIG DIG
1 2 3 4 5 6 7 8 9
Light Guide Board
Light Guide Copperside view
LTL-503
6170
0021
B
3401
7160
C
6170
3403
3404
E
0021
3401
4501
2260 1 7160
2K7 BC847B
2
3
3403
3404
2260
100n
CDR-Mini LED Board Copperside view stage .4 (2000-02-23)
47R
1K
6-4 6-4
2100 B6 2116 C3 2136 A5 2145 A5 2166 C6 2175 C1 2185 A2 2194 A6 3097 A5 3107 A3 3116 A4 3125 A4 3134 A4 3143 B7 3152 B7 3162 B4 3171 B4 3180 A2 3189 B2 3198 B3 3207 B3 3216 C4 3225 A2 3237 C4 3250 C1 3260 B7 3271 A1
2101 B6 2121 A5 2137 A5 2146 A5 2167 C6 2176 C6 2186 B1 2195 D1 3098 A5 3108 A3 3117 A4 3126 A4 3135 A4 3144 A3 3153 A3 3163 C2 3172 B4 3181 A3 3190 B3 3199 B3 3208 B3 3217 C3 3226 A2 3238 C4 3251 C1 3261 B7 3272 D1
2102 B6 2122 A5 2138 A5 2150 A2 2168 C6 2178 B1 2187 A2 2196 C1 3099 A5 3109 A3 3118 A4 3127 A3 3136 B7 3145 A4 3154 B4 3164 B4 3173 A3 3182 B6 3191 B3 3200 A2 3209 B3 3218 C4 3227 C1 3243 C6 3253 C5 3262 D7 3273 D1
2103 B6 2124 C2 2139 A5 2154 C1 2169 C6 2179 A1 2188 A2 2197 C2 3101 A3 3110 A4 3119 C3 3128 A4 3137 A4 3146 B7 3155 B7 3165 C2 3174 B4 3183 B6 3192 B3 3201 A3 3210 B3 3219 C4 3228 B1 3244 C6 3254 C5 3264 A1 3275 A2
2108 A5 2125 C2 2140 A5 2155 A3 2170 B6 2180 A1 2189 A2 2198 C7 3102 A5 3111 A4 3120 C3 3129 A4 3138 A5 3147 A3 3156 C3 3166 B4 3175 C2 3184 B6 3193 B3 3202 A3 3211 B3 3220 B6 3230 B1 3245 C6 3255 C5 3265 A1 3276 B1
2109 A5 2126 C2 2141 A5 2157 A2 2171 B6 2181 A1 2190 A1 2199 C4 3103 A5 3112 A4 3121 A3 3130 A4 3139 A5 3148 A4 3158 B4 3167 C2 3176 A3 3185 C4 3194 B3 3203 B3 3212 B3 3221 B1 3231 A2 3246 C6 3256 C5 3267 B1 3277 A1
2111 B6 2127 A3 2142 A5 2159 B1 2172 C6 2182 B2 2191 A1 2200 B3 3104 C3 3113 A4 3122 A3 3131 A4 3140 B7 3149 B6 3159 C2 3168 B4 3177 B3 3186 A3 3195 B3 3204 B3 3213 B3 3222 C1 3232 C1 3247 C6 3257 A7 3268 A1 3278 B1
2114 B7 2128 A3 2143 A5 2161 D7 2173 C6 2183 B1 2192 A1 3094 A4 3105 A3 3114 A4 3123 A3 3132 A4 3141 A3 3150 A3 3160 B4 3169 B4 3178 A3 3187 A2 3196 B3 3205 B3 3214 C4 3223 C1 3233 B7 3248 B5 3258 A7 3269 A1 3279 A2
2115 C3 2135 A5 2144 A5 2165 C6 2174 C6 2184 A2 2193 A2 3096 A5 3106 A3 3115 A4 3124 A3 3133 A4 3142 A4 3151 B4 3161 C2 3170 B4 3179 B4 3188 B2 3197 B3 3206 B3 3215 C4 3224 C3 3236 C2 3249 C5 3259 A7 3270 A1 3280 A2
3282 A2
3283 A2
3284 A2
3285 A2
3286 A1
3287 A1
Front Board Copperside view 3288
3289
A1
A1
3290 D1
3291 A1
3292 A1
3293 C5
3294 C5
4001 A7
4002 A5
4004 A5
4005 A5
4006 A5
4007 A5
4008 A5
4009 A5
4012 A2
4013 A2
4014 A2
4015 A1
4016 A2
4017 B5
4018 C5
4019 C5
4021 C4
4022 C4
4024 B3
4025 C4
4026 C3
4027 C3
4028 C3
4029 C3
4030 C3
4031 C2
4032 C2
4033 C1
4034 C1
4035 C1
4036 C3
4037 D1
4038 C1
4039 C1
4040 D1
4041 D1
4042 D1
4043 D1
4044 B1
4045 B1
4046 B1
4047 B1
4048 B1
4049 B1
4050 B1
4051 B6
4052 C4
4053 C3
4054 B1
4055 B1
4056 A1
4057 B5
4058 A1
4059 A1
4060 A1
4061 A1
6200 A4
6201 A4
6202 A4
6203 A4
6205 A4
6206 A4
6207 A4
6208 A4
6209 A3
6210 A3
6211 A3
7101 A3
7102 A5
7103 A5
7104 A4
7105 A5
7106 A5
7107 B6
7108 A3
7110 C1
7111 A2
7120 C1
7121 C6
7122 A1
7123 C5
This assembly drawing shows a summary of all possible versions.
For components used in a specific version see schematic diagram respectively partslist. CDR-Mini Front Board Copperside view stage .4 (2000-02-23)
6-5 6-5
0401 G1 1105 E15 2110 A12 2127 E4 2142 D11 2155 H3 2197 H2 3101 A1 3111 B7 3121 B5 3131 B8 3141 C5 3151 C10 3162 D10 3172 E10 3182 A12 3192 F7 3202 G6 3212 G9 3222 H5 3233 D12 5109 A4 6107 C13 6207 E1 7106 B3
0402 G1 1106 F15 2111 A12 2128 E4 2143 D11 2156 A10 2198 H2 3102 A2 3112 B7 3122 B5 3132 B8 3142 C10 3152 C12 3163 C15 3173 E4 3183 A12 3193 F7 3203 G6 3213 F9 3223 H5 3234 H6 5110 A10 6108 F11 6208 E1 7107 A11
0403 G1 1107 E4 2114 D12 2134 G10 2144 D11 2157 H3 2199 F15 3103 A3 3113 B7 3123 B6 3133 B8 3143 B12 3153 C5 3164 D10 3174 E10 3184 A12 3194 F7 3204 G6 3214 E15 3224 B14 3235 A12 5111 A1 6109 H6 6209 F1 7108 D6
0404 G2 1108 D3 2115 B14 2135 C11 2145 D11 2158 H8 2200 F10 3104 A15 3114 B8 3124 B6 3134 B9 3144 C4 3154 C10 3165 C15 3175 D14 3185 E15 3195 F8 3205 G7 3215 F11 3225 H4 3236 D15 5112 B1 6110 H11 6210 F1 7110 H6
0405 H2 2100 A12 2116 B14 2136 C11 2146 E11 2159 H7 3094 B1 3105 B5 3115 B8 3125 B6 3135 B9 3145 C10 3155 C12 3166 D10 3176 E5 3186 F5 3196 F8 3206 G7 3216 F12 3226 H3 3237 F12 6101 B13 6200 C1 6211 F1 7111 H3
0406 H2 2101 A11 2121 B2 2137 C11 2150 H3 2161 H1 3095 E11 3106 B5 3116 B8 3126 B6 3136 B12 3146 C12 3156 C14 3167 D15 3177 E10 3187 F5 3197 F8 3207 G7 3217 A14 3227 H5 3238 H12 6102 B13 6201 C1 7101 A1 7112 H8
1101 A9 2102 A11 2122 B3 2138 C11 2151 H11 2193 H1 3096 B3 3107 B6 3117 B9 3127 B7 3137 B1 3147 C5 3158 C10 3168 D10 3178 E4 3188 F6 3198 F9 3208 G8 3218 H12 3228 H7 5101 C2 6103 B13 6202 D1 7102 A2
1102 A15 2103 B11 2124 D14 2139 D11 2152 A4 2194 H1 3097 A2 3108 B6 3118 B9 3128 B7 3138 B2 3148 C10 3159 C15 3169 D10 3179 E10 3189 F6 3199 F9 3209 G8 3219 H11 3230 H7 5102 F10 6104 C13 6203 D1 7103 A3
1103 D13 2108 A2 2125 D14 2140 D11 2153 H4 2195 H1 3098 A3 3109 B6 3119 A15 3129 B7 3139 B3 3149 C12 3160 D10 3170 D10 3180 E5 3190 F6 3200 G5 3210 G8 3220 B11 3231 H3 5103 D4 6105 C13 6205 E1 7104 B1
1104 D15 2109 A3 2126 D14 2141 D11 2154 H5 2196 H2 3099 B2 3110 B7 3120 B15 3130 B8 3140 B12 3150 C4 3161 C14 3171 E10 3181 E4 3191 F7 3201 G6 3211 G8 3221 H8 3232 H5 5104 F11 6106 C13 6206 E1 7105 B2
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
BJ721GNK 1101
LEDShDATA
FRONT BOARD SHEET 1 3182
LEDShCLK
4,6V 4,6V 4,6V DISPLAY 470R
3184
3183
1K5
LEDShSTR
+D +D +D
LED_ON
1K5
2101
100n
2100
100p
2102
-27,7V 7101 -27,7V 7102 -27,7V 7103
10n
BC847B BC847B BC847B 70 68 66 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 5 3 1
A -27,8V -27,8V -27,8V
F1
5109 5110
F2
HP_DET 1
1102 A
2u2 2u2
2152
470R
470R
3101
3097
3103
3098
3102
2156
D D D
4K7
82K
82K
10u
10u
2108
180p
2109
180p
P351 5111
SA_IN 2
2u2
G161
G151
G141
G131
G131
G151
P361
P351
AmNTC 3
G13
G15
G12
G11
G10
P35
P10
P11
P12
P13
P14
P15
P16
P17
P18
P19
P20
P21
P22
P23
P24
P25
P26
P27
P28
P29
P30
P31
P32
P33
P34
3235
G9
G8
G7
G6
G5
G4
G3
G2
G1
+5V6
P1
P2
P3
P4
P5
P6
P7
P8
P9
-30V! -30V! D -30V! D D D 74HC4094D 5,5V
PWRDWN 680K 3104 220R 4
7107 16 47R
2110
2111
100n
47u
I2C_DATA 3217 3119 220R
+D
P35
P34
P33
P32
P31
P30
P29
P28
P27
P26
P25
P24
P23
P22
P21
P20
P19
P18
P17
P16
P15
P14
P13
P12
P11
P10
P9
P8
P7
P6
P5
P4
P3
P2
G141
G161
5
G16
SRG8
P36
P361
15
G14
4,6V 4,6V EN1 D D I2C_CLK 3120 6
5112
+D
+D
1
2u2
STB 220R
to AF-BOARD (1536)
470R
470R
3099
3096
10p 2116
10p 2115
7
470R
220R
220R
220R
220R
220R
220R
220R
220R
220R
220R
220R
220R
220R
680K
3094
3105
3106
3108
3109
3110
3113
3115
3116
3117
3224
3107
3111
3112
3114
3
+5V6
220R
3118
4,6V 0V = LED on 8
B -27,7V
-27,7V 7105
BC847B
-27,7V 7106
BC847B
3220
5V = LED off
3136 270R
7x LTL-1CHAE
+5V6
D
9 B
-27,8V -27,8V 2 4 6101 D
4,5V D 1
220R
220R
220R
220R
220R
220R
220R
220R
220R
220R
220R
220R
220R
220R
220R
3121
3122
3123
3125
3126
3127
3128
3130
3131
3132
3134
3135
3124
3129
3133
7104 -27,8V 10
+yP 100R 5 3140 270R 6102 D D -30V
BC847B
3138
3139
2121
180p
180p
11
2122
82K
82K
3143 270R
3137
2103
6 6103 F1
4K7
1n
12
D D 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 7 3146 270R 6104 F2
13
-30V! -30V! VDD-VFT D 14 3149 270R 6105 D
3156
PE5
PE4
PE3
PE2
PE1
PE0
PD7
PD6
PD5
PD4
PD3
PD2
PD1
PD0
P97
P96
P95
P94
P93
P92
P91
P90
P87
P86
P85
P84
P83
P82
220R 220R
PE6
81 50 14
-30V! P1
PE7 P81 13 3152 270R 6106 CDSILD
220R 3141 82 49 470R 3142 12x 180p 1K 3159 15
VFT - DRIVER VFT - DRIVER VFT - DRIVER VFT - DRIVER P36
PF0 P80 12 3155270R 6107
C 12x BAW56 -30V! 3144 220R 83
PF1 PE PD P9 P8 P77
48 3145 3148
G1 G1
2135
EH-B
CDShDATA
3161 470R 16 C
VFT - DRIVER
11 1 CDSICL
5101 220R 3147 3151 220R 2136 1K
-30V
84 47 17
6200 PF2 P76 G2 G2
P1 2u2 9 2 CDShCLK
PF
3150 1K 85 46 220R 3154 2137 +5V6 3163 1K 18
VFT - DRIVER - CIRCUIT G3 G3
VFT - DRIVER
PF3 P75 10
P2 2138
3 CDShSTR 3165 470R
3153 86 45 3158 220R 19
6201 PF4 P74 G4 G4
100R
3233
P3 -30V D D 1103 CDSwInfo
P7
5103 -30V 87 ADRESS / DATA - BUS 220R 3160 2139 8 3167 1K
2126 10p
2125 10p
2124 10p
44 G5 G5
VKK P73 FE-BT-VK-N
P4 +yP 2u2 3162 220R 2140
4,5V 88 43 G6 G6 Sh_DATA
6202 VDD-CPU P72
2114
470p
P5 2141
to AF-BOARD (1538)
89 42 220R 3164 DD 1104
G7 G7 D
CPU - CLK
XIN P71
D P6
6203 D 90
VSS-CPU P70
41 3166 220R
G8 G8
2142 D
CDTXTin 1 D
P7 1108 CdTxtDQSV
91
XOUT 7108
CPU P67
40
220R 3168
G9 G9
2143
3175
2
2144 CDTXTCLK
92 TMP88CU77ZF 39 3169 220R 3
RESET P66 G10 G10 1K
3236
33K
93 38 220R 3170 2145 4
15p 2127 G11 G11
32K768
VFT - DRIVER
P21 P65
D
P10 2146 FE-BT-VK-N
1107
15p 3171 220R
P2
94 RAM ROM 37 G12 G12
P11 6205 D 2128 P22 P64
D
P6
95 36 220R 3172
G13
I/O
TEST P63
3095
D
P12 D
1K
3173 96 35 3174 1K
6206 P20 P62 G14
E P13
1K 3176 97
P00 P61
34 1K 3177
G15
E
P14 P0 D 1105
3178 100R 98 33 3179 1K 3185 1
6207 P01 I/O P1 P3 P4 P5 P60 G16
P16 I2CW_DATA
to CDR-Module (1704)
100R 3180 99 ANALOG IN ANALOG IN 32 1K 100R 2
P18 P02 3-STATE 3-STATE 3-STATE 3-STATE VDD-I|O D
VSS-I|O
3181 1K 100 I/O I/O I/O I/O 31 4,5V +yP 3214 3
P19 6208 P03 VAREF
P04
P05
P06
P07
P10
P11
P12
P13
P14
P15
P16
P17
P30
P31
P32
P33
P40
P41
P42
P43
P44
P45
P46
P47
P50
P51
P52
P53
I2CW_CLK
1K 100R 4
VASS
P22 CWReqKbe
6209 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 4,5V 5
5102
P25 CWReset
2u2
+yP 6
2199
F P26
6210
D KEY 7 F
10n
470R
470R
P30
3190
3194
3186
3187
3188
3189
3191
3192
3193
3195
3196
3197
3198
3199
1K
1K
1K
1K
1K
1K
1K
1K
1K
1K
1K
1K
+C 5104 1N4148 +5V6 D FE-BT-VK-N
P32 3215 3237 3216
4,5V 5,6V
3213
6211 2u2
1K
6108 4R7 4R7 4R7 1106
2200
220u
100n
P33
2134
1
3200
3201
3205
3207
3208
3211
3202
3203
3204
3206
3209
3210
3212
1K
1K
1K
1K
1K
1K
1K
1K
1K
1K
1K
1K
1K
+5V6
to Digital switching
2
D D DIGI_IO_SW2
(1160)
3
CDTXTDQSV
D
LEDShDATA
TuRDSDATA
I2CW_DATA
CDTXTCLK
CWReqKbe
JOG_VOLB
JOG_VOLA
LEDShCLK
TuRDSCLK
CDShDATA
I2CW_CLK
MuxEnable
4
Multiplexin
PWRDWN
CDShSTR
CDShCLK
I2C_DATA
TU_DATA
CDSwInfo
CWReset
CDTXTin
STEREO
I2C_CLK
G TU_CLK
DIGI_IO_SW0
G
CDSICL
CDSILD
AmNTC
JOG_B
JOG_A
TU_CE
RESET
5
RC5
DIGI_IO_SW1
DATA BUS TO SHEET 2 FE-BT-VK-N
RESET
+D +D
I2C_DATA
RC5
0401
0402
0403
0404
3234 6109
I2C_CLK
5V
100R 1N4148 +5V6
100R
3221
2150
100n
6110 3219 3238 3218
2154 100n
7110 8 M24C01 EEPROM
2153
3223 10K
3222 10K
1u
D 1 +D +5V6
VCC E0 4,6V 1N4148 4R7 4R7 4R7 5,6V
220u
2151
4,5V
2155
3225
2
10n
7112
1K
E1
3226
100K
D D D
H D 5 3 2 . . V DC Voltages measured H
2161
2193
2194
2195
2196
2197
2198
3228
IR-EYE .
10K
1n
1n
1n
1n
1n
1n
1n
D 4,4V SDA E2 D VSUP D V EVM during operation
7111 1K 3227
TSOP2836
6
0V BC847B SCL 3230 1 OUT
0406
0405
7 4,5V
WC_ D 1K
3231
100K
2157
2159
2158
VSS
10n
2n2
47u
shield5
shield4
shield2
shield1
shield3
MT GND
3232 4
D 4 3
D D D D D D
1K
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
6-6 6-6
1 2 3 4 5 6 7 8 9 10 11 12 13 0042 A3
0043 E3
F427 E10
F478 A3
1111 B6 F479 A3
1113 E4 F480 A3
FRONT BOARD SHEET 2 1114 E4 F481 A3
1115 E4 F482 A3
+D 1116 E5 F483 B3
DATA BUS from Sheet1 1117 E5 F484 C6
0042
1118 E5 F485 B7
3242
to TUNER 1 2165 100p
3241
3240
10K
10K
10K
D 1119 E6 F486 C7
3243 1K
A 2
A 1120 E6 F487 D8
+D
1121 E6 F488 D8
3 3244 1K TU_CE
1122 F4 F489 E3
3245 1K 1123 F4 F490 E3
3293
4 TU_DATA
47R
1124 G3 F491 G4
5 3246 1K TU_CLK 2165 A3 F492 G4
4,4V 2166 B5 F493 G4
6
3247 1K STEREO I2C Shiftregister 2167 B5 F494 H4
7123 4,6V 2168 B5 F495 H4
DIPMATE BC847B 4,6V
3,9V D 2169 B5 F496 H4
AT-51 TU_RDS_PWR 7120 2170 B6 F497 H4
TU_RDS_PWR M62320FP 16 15 14 2171 B7 F498 H4
B B
2171 47p
2168
2166
2167
47p
47p
47p
2169
47p
2172 C8 F499 H4
CS0
CS1
CS2
1111
2170
82p
2173 C4 F500 H4
3248
5107
2K2
2u2
D D D D 2174 C4 F501 I3
220R CHIP SELECT
2175 C11 F502 I3
D 3249 D I2C_CLK 3250 2 SCL
2176 C4 F503 I4
7121 I 2 C BUS SHIFT 1 2177 D4 F504 I4
220K I2C_DATA 3251 3 SDA
2172
100n
SAA6579T RDS Decoder 13 14 12
TRANSCEIVER REG SO 2178 E7 F505 I4
3252 220R 13 VDD 8 8 8 2179 E12 F506 H8
OSCO
OSCI
VDDD 4,6V PWR OUT I/O IN 2180 E11
47R
2173
2174
560p
2175
D +D 8 GND RES DATA LATCHES 2181 E13
47p
1n
ANTI- 57 Khz OSCILLATOR QUALITY D 8 8 8 2182 F7
3294
2V 4 MUX RECONSTRUCTION QUAL 1
1K
ALIASING BANDPASS AND BIT 2183 F6
C D
FILTER (8th ORDER)
FILTER
DIVIDER GENERATOR D
I/O PORT
C 2184 F13
D7
D6
D5
D4
D3
D2
D1
D0
2V 2185 F11
8 SCOUT 12 11 10 9 7 6 5 4 2186 G3
2176
560p
only for RDS 2187 G12
CLOCKED BIPHASE
COSTAS LOOP DIFFERENTIAL RDDA 2 3253 1K TuRDSDATA DIGI_IO_SW2 2188 G11
2V 7 CIN COMPARATOR SYMBOL
VARIABLE AND DECODER 2189 G13
DECODER MIC_KILL
3,9V5 VDDA FIXED DIVIDER only for RDS 2190 G12
VP1 RDCL 16 3254 TuRDSCLK 2191 H11
MIC_DET 2192 H13
REFERENCE 1K
2V 3 VREF CLOCK TEST LOGIC AND OUTPUT 3240 A5
3255
3256
VOLTAGE T57 15
10K
10K
SELECTOR SWITCH LEDShSTR
REGENERATION 3241 A5
MODE
LED_ON
D D
2177
AND SYNC 3242 A5
2u2
TEST
3243 A3
VSSA VSSD D D DIGI_IO_SW1 3244 A3
6 9 10 11 only without RDS 3245 A3
D D D D D DIGI_IO_SW0
3246 A3
3247 B3
1172 DSC
0043 3248 B7
3407 DSC 1
3257 3258 3259 3260 3261 3262 3263 3264 3265 3266
1
3249 B6
3K9 820R 560R 270R 220R 3250 B11
DISC CHANGE
10K 1K8 1K2 390R 150R 1K
OPEN/CLOSE
3267
2178
100p
SKQNAB
2K7
2 2
3251 B11
1121
1119
1115
1117
1113
1116
1118
1114
1120 +C
1174
1173
2262
100p
3 3 3252 C11
KEY 3253 C8
E DIPMATE
KEY KEY KEY KEY KEY KEY KEY KEY KEY KEY +D 680K 3268 E 3254 D8
3255 D8
standby on CD 1 CD 2 CD 3 Display CDR RDS Tuner AUX 3256 D8
6120 2179 3269 3257 D3
CD TEXT SA3
3272 3273 3274 1K5 3258 E4
220K
150K
2n2
3270
3271
2181
2180
100n
1N4148
33n
3259 E4
220R 150R 1K +D 5108 4,6V 2182 100n 3260 D4
3261 D5
3276
D D D D D
2K7
1123
Open / Close
Clock / Timer
1122
2u2 Multiplexer
HEF4051BT 16 3262 E5
+D
7122 VDD 3263 D5
Y0 13
1N4148
3264 D6
680K
3275
+C
2183
100p
6121
4,5V 3265 E6
F +C
6122 2184
F 3266 E7
11 A0 Y1 14 SA4 3277 3267 E7
1K5 3268 E12
220K
150K
820p
3278
3279
3280
KEY
2185
100n
1N4148
2K7
3269 E13
3281 Y2 15 3270 E12
D D D 3271 E12
1K 3282
2186
100p
3272 E3
+D 680K 3273 E4
10 A1 Y3 12 3274 E5
KEY SA2 6123 2187 3283
SA1 3275 F12
LOGIC 1K5 3276 F4
3284
3285
220K
150K
1N4148 47n
2188
220n
2189
1-of-8
1u
LEVEL
G CONVERSION
DECODER Y4 1 SA2 G 3277 F13
3278 F2
1124 D D D D
MIC_KILL 3286 3279 F12
1
9 A2 Y5 5 +D 680K 3280 F12
MIC_DET SA3
2 3281 F2
3282 G12
3 LEDShCLK 6124 2190 3287
SA1 3283 G13
Y6 2 SA4 3284 G12
LED_ON 10n 1K5
3288
3289
220K
150K
2191
100n
2192
220n
4 1N4148
10K +D 3285 G12
5 LEDShSTR 3286 G12
6 E_ Y7 4 3291 only for 100W D D D D 3287 G13
6 3290 100R
3292 only for 50W 3288 H12
H 7
Sh_DATA
Z 3 Multiplexin 10K D H 3289 H12
3290 H4
+5V6 SA_IN
8 VSS VEE 3291 H9
D 8 7 3292 H9
9 D D 3293 A10
JOG_A MuxEnable 3294 C10
10
I2C_CLK 5107 B7
JOG_B 5108 F6
11
LEDShDATA 6120 E12
12 6121 F13
LEDShCLK 6122 F12
13
6123 G12
I to Design Front 14
KEY I 6124 G12
(1130) JOG_VOLA 7120 B12
15
7121 B4
JOG_VOLB 7122 F6
FFC 7123 B10
F424 G10
F425 G10
FrontBoard sheet2 (2000-03-21)
F426 F10
1 2 3 4 5 6 7 8 9 10 11 12 13
6-7 6-7
0042 C2 0406 C1 1107 A5 1117 B1 1124 D7 2158 B7 3242 B2 5102 C4 5111 A6 6106 A7 6122 A6 9004 A4 9014 A7 9021 B6 9029 B7 9036 C6 9043 B6 9050 B5 9058 B4 9065 B3 9074 C3 9081 C1 9088 D7 9095 B4
0043 A2 1101 A3 1108 A5 1118 D1 2110 B2 2177 C3 3252 B7 5103 A5 5112 A4 6107 A7 6123 A6 9006 A4 9015 A6 9022 B6 9030 B7 9037 B6 9044 B5 9051 B5 9059 B4 9066 C3 9075 C3 9082 C1 9089 D7 9096 B5
0401 B5 1102 C5 1111 B3 1119 C7 2134 B5 3095 A2 3263 B7 5104 B4 6101 D1 6108 C5 6124 A7 9007 A4 9016 A6 9023 A7 9031 B7 9038 B6 9045 B5 9052 B5 9060 B4 9068 B3 9076 B2 9083 C1 9090 B4 9097 B6
0402 A4 1103 C3 1113 A1 1120 A7 2151 B4 3234 C7 3266 B7 5107 C3 6102 B1 6109 D7 7112 A7 9009 A5 9017 A6 9024 A7 9032 B7 9039 B6 9046 B5 9054 C4 9061 B4 9069 B3 9077 B2 9084 B3 9091 B4 9098 D7
0403 A5 1104 C6 1114 A1 1121 A7 2152 A2 3235 B2 3274 B7 5108 B6 6103 A1 6110 C4 9001 A1 9010 A5 9018 B6 9026 A7 9033 C6 9040 B6 9047 B5 9055 B4 9062 B3 9070 B3 9078 C1 9085 C4 9092 C7 9099 B2
0404 A5 1105 C4 1115 A1 1122 D7 2153 C7 3240 B2 3281 B7 5109 A2 6104 A1 6120 A7 9002 A3 9012 A6 9019 B6 9027 A7 9034 C6 9041 B6 9048 B5 9056 C4 9063 B4 9071 B3 9079 C1 9086 C6 9093 A6 9100 B1
0405 C6 1106 C6 1116 B1 1123 B7 2156 A6 3241 B2 5101 A6 5110 A6 6105 A1 6121 A6 9003 A3 9013 A6 9020 B6 9028 A7 9035 C6 9042 B6 9049 B5 9057 C4 9064 B4 9073 C4 9080 B1 9087 D7 9094 B6 9101 A3
Front Board Componentside view
This assembly drawing shows a summary of all possible versions.
For components used in a specific version see schematic diagram respectively partslist. CDR-Mini Front Board Componentside view stage .4 (2000-02-23)
6-8 6-8
0041 A10 1139 C4 1148 C9 1183 B7 2204 B8 2304 A3 3305 C8 3318 B4 3327 C8 3337 A6 3501 A3 4103 C8 6130 C5 6139 B9 6155 A8 9106 A3 9115 C6 9127 C7 9139 C7
1130 B1 1140 C6 1149 B6 1184 B5 2205 C8 2305 A8 3306 C8 3319 B4 3328 B8 3338 B9 3502 A3 4104 C9 6131 C5 6140 B7 6156 A7 9107 B2 9118 A8 9128 A10 9144 C3
1131 B8 1141 C5 1150 B9 1185 A7 2206 B3 2306 A8 3307 B4 3320 C6 3329 A8 3339 A7 3503 A3 4105 A7 6132 A2 6142 A6 6157 C6 9108 B2 9119 A8 9129 B6 9145 B4
1132 A2 1142 C7 1151 A7 1186 C6 2207 B3 2307 A7 3312 B3 3321 C5 3330 B6 3340 A9 3504 A3 4107 B9 6133 B6 6143 C5 7130 A3 9109 B6 9120 B4 9130 A8 9147 A8
1133 C2 1143 B6 1152 A9 1187 C9 2211 A9 2308 A7 3313 C3 3322 C6 3331 C9 3341 A7 3505 A7 4108 C9 6134 B6 6150 B9 7131 A5 9110 A4 9121 C4 9131 A1
1134 B3 1144 C7 1153 A9 1188 A9 2212 A4 3301 B4 3314 C3 3323 C6 3332 B8 3342 A4 3506 A7 4109 A7 6135 A5 6151 B9 7132 A8 9111 C4 9123 C6 9132 A2
1135 C3 1145 B5 1180 B2 2201 A3 2301 B3 3302 B4 3315 C3 3324 C7 3333 A6 3343 A2 3507 A7 4110 C6 6136 B8 6152 B7 9103 A3 9112 C4 9124 C6 9133 A2
1137 A4 1146 C8 1181 A4 2202 A10 2302 B3 3303 B4 3316 B2 3325 B8 3334 C8 3344 A2 3508 A7 4111 C6 6137 B9 6153 B7 9104 A3 9113 B5 9125 C7 9137 A2
1138 C5 1147 A5 1182 C4 2203 B3 2303 B3 3304 C8 3317 C3 3326 B6 3335 A7 3345 A3 4102 C8 4112 B8 6138 A9 6154 C5 9105 A3 9114 B6 9126 A9 9138 B4
Design Front Copperside view
JOG_VOL_A
CDR_KEY2
MIC_DET
LED_ON
D_GND
JOG_B
DATA
JOG_VOL_B
KEY_GND
CDR_KEY1
JOG_A
+5V6
LED_STR
LED_CLK
MIC_KILL
This assembly drawing shows a summary of all possible versions.
For components used in a specific version see schematic diagram respectively partslist.
CDR-Mini Design-Front Copperside view stage.4 (2000-02-23)
6-9 6-9
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 0041 B4 6132 B8
1130 G4 6133 E16
1131 F8 6134 F16
1132 G4 6135 F17
1133 H4 6136 J17
A Design Front A
1134 H8
1135 H4
1137 I4
6137 K17
6138 K17
6139 L17
DIPMATE 1138 H7 6140 L17
1 1139 I4 6142 M16
1140 H7 6143 E16
to MIC (1166)
2 1141 J4 6150 L18
6132 1142 I7 6151 K18
3344 3343
3 +E 1143 J4 6152 F17
B 5,2V B 1144 I7 6153 E17
10R 10R 1N4148
2203 47u
4 1145 K4 6154 D17
1146 J7 6155 K18
MIC_KILL
MIC_DET
0041 1147 K4 6156 M18
1148 J7 6157 E17
FFC 5,3V 1149 L4 7130 C13
1 +SR 1150 K7 7131 F16
C +SR C
5,3V 1151 L4 7132 I13
2 3345 4R7 2201 47u +SR 1152 L6 F400 C4
7130
2202
100n
LED_CLK 1153 L7 F401 D4
3 74HC4094D 16 1180 G3 F402 D4
4 LED_ON 3501 1K5 SRG8 1181 I3 F403 D4
15 Finalize 1182 J3 F404 D4
EN1 3301
to Front board (1124)
5 LED_STR 3502 1K5 1 1183 K3 F405 E4
390R 6130
D STB D 1184 K3 F406 E4
6 DATA 3503 3 1185 L3 F407 E4
1186 I6 F408 E4
7 +5V6 470R RecType RecType 1187 K6 F409 F4
+E +E 3302 1188 L6
D_GND F410 F4
8 3504 2 4
D 1 150R 6143 6131 2201 C8 F411 F4
2202 C15 F412 F4
3305 10K
9 JOG-A 3306 1K 100R 5 Play/Pause
E 3303 E 2203 C8 F413 C4
3304
2301
2302
2303
2304
100p
100n
10K
10n
10n
10 JOG_B 3308 1K 2204 F9 F414 A4
6 6133
150R 2205 F10 F415 B4
Next
11 KEY1 7 3307 2206 I9 F416 B4
6134 2207 I10 F417 C4
12 KEY2 EC16 1 2 14 150R 2209 J15 F418 L15
2205 10n
1131 2210 M4 F419 L16
13
2204
KEY 13 2211 M7 F420 M15
10n
F F 2212 H15 F421 M16
14 VOL_A MT1 MT2 12 6135
2301 E12 F550 D16
4 5 3 7131 RECORD 2302 E13 F551 D15
15 VOL_B 11 BC847B 2303 E13 F552 E16
JOG 3309 2304 E13 F553 E16
1130 9
2305 K12 F554 G16
2K7 2306 K13 F555 J16
1132 10 0V = LED on
G G 2307 K13 F556 K16
5V = LED off 2308 K13 F557 K16
treble
100R
3316
3342
3310
3311
8
47R
150R
3301 D15 F558 K16
1K
+E +E 3302 E15 F559 L16
1133
3303 E15
1K
1K
3314 10K
3315 10K
pure 3304 E9
1138 3305 E10
220R
3317
2212
470p
3312
3313
H H 3306 E8
1135 Erase 3307 E15
270R
3320
3308 E8
I.S. 1140 1134 3309 G15
270R
3318
EC16 1 2 3310 G16
Finalize
390R
3322
2207 10n
3311 G16
2206 10n
1137
1142 3312 H9
3313 H9
3319
I Bass 5,3V I
390R
MT1 MT2
Programm 3314 H9
560R
3324
1139 4 5 3 +SR 3315 H10
1144 7132 3316 G5
3321
loudness 74HC4094D 16 3317 H5
2209
100n
560R
VOLUME
TextEdit 3318 I5
820R
3327
1141 3505 1K5 SRG8
15 3319 I4
1146 EN1 +SR 3320 H7
3323
J RecType J
820R
3506 1K5 1 3321 J4
TrackEdit STB
3331
JOG
1K2
1143 3507 470R 3325 3322 I7
1148 3 3323 J5
Play/Pause 180R 6136 3324 I7
3326
STOP
1K2
REC/Level 3328 3325 J15
3334
1K8
1145 3508 3326 K4
1150 2 4 6137
D 1 150R 3327 J7
Compile CD 100R 3329 NO
K 5 K 3328 K15
3330
1K8
STOP
2305
2306
100p
2307
100n
2308
6138 3329 K15
10n
10n
1147 180R
6 3330 K4
3338
PREV
3K9
3332
1152 3331 J7
CD > CD
3333
7
3K9
150R 6139 3332 K15
1149 PREV 3335 JOG 3333 L5
14
3340
10K
3334 K7
Next 180R 6140 3335 L15
L 13 L
1153 3337 L5
3337
10K
12 3339 3338 K7
1151 NO 3339 L15
11 560R 3340 L7
YES 3341 3341 M15
9 3342 G15
330R
2211 3343 B7
M 10 0V = LED on M 3344 B6
5V = LED off 6142 6156
100p 3345 C7
3501 D12
KEY 8
100p 2210 3502 D12
3503 D12
KEY 3504 E12
YES YES 3505 J12
N N 3506 J12
3507 J12
3508 K12
6130 D16
DesignFront FW-R8 (2000-02-22)
6131 E16
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
6-10 6-10
1 2 3 4 5 6 7 8 9 10 11 12 13
1165 D2
Microphone Board 1166 C13
1167 E13
+12A 2240 A13
2241 B6
2242 B12
2243 B10
3370
6K8
BC817-25 2244 B10
A 0V
7150 A 2245 B8
2246 B9
2240
10n
2K2 2247 C9
3371
+12A 0V
4K7
+12A 2248 C6
3373
22K
2241 3372 2249 C6
2250 D3
2242
10n
3375
3374
2251 D5
2K7
1K
470u
3376
2K2
2252 E8
2253 E6
2243
B B
10u
3377 3378 10u 2254 E11
2255 E7
1M 1M 2244
5,9V 2256 E9
3379
2245
470n
2K7
2246 1,9V 7151
2257 F9
6 9 4,6V 2258 D12
470n BC847B 3370 A2
5 8 3,9V BC857B
2 3383
3380 1,3V 3371 A2
7152
3
4 7 3372 A12
10K 3381 3382 2248 2247 1n
C 0V 0,7V 7153
C
20K
3373 A11
3384
BC847B 3374 B9
1K
2 22R 180R 100n
to design Front (0041)
3375 B10
1
7154 0V 0,1V 1166
3 3396 2249 1 3376 B6
BC817-25 MIC_DET
2250
3377 B6
3385
4n7
10K
HSJ0914 1 220K 1n
2251
2
3386
33R
3378 B9
1n
1165
3
3379 B6
3380 C1
6160 3387 3397 3381 C2
D 4
MIC_KILL D 3382 C4
1N4148 2K2 470R
+12A EH-B 3383 C8
3384 C9
2258
100u
3385 D4
3389 3386 D6
3390
1K
+12A 3387 D6
9,4V 470R 3388 F12
to AF-BOARD (26)
3391 6161 2252 3392 3389 E6
E 7155 0V 1167
E 3390 E9
3393
4K7
1
BC847B 10K 100n 1M 3391 E7
1N4148 7,3V a
3392 E9
2253
2
1N4148
0V 2256
1n
MIC
2255
3394
6162
3393 E10
10u
47K
3388 3
BC847B +12A 3394 E6
7156 0,9V 1u 470R 3395 F9
0,3V 2257 EH-B 3396 C6
. . . V DC Voltages measured with 3397 D12
connected microphone
F F
150R
6160 D5
3395
V EVM 1n 2254
6161 E7
100n 6162 E8
7150 A11
7151 C10
7152 C7
7153 C7
7154 C4
7155 E6
7156 F8
1 2 3 4 5 6 7 8 9 10 11 12 13
1165 B1 3383 B1
1166 A4 3382 B2
1167 C4 3384 A3
Microphone Board Copperside view 2240 B4 3385 A1
2241 B2 3386 C2
2242 A3 3387 A2
B
7150
2243 B2 3388 B4
3372
3385
3384
2242
2247 3397 2244 B4 3389 B3
E
2250 3381 6160
3387 E B 2245 B1 3390 C3
3375 2246 C4 3391 B3
7151
2
4401 3370
4
3371
C 2258 2247 A4 3392 C3
6161
6162
2255
6
9
2243 2248 B2 3393 C3
1166
2244
1165
3378 2249 B2 3394 B3
1
3391
3373
4304
2250 A1 3395 B3
3394
4
7
2251 B2 3396 B2
2254
3380
1
2253 2252 C3 3397 A4
3
3382 2251 3374
2248
E B 3395 2253 B2 4304 B2
2240 2254 B4 4401 A2
3377
3396
E B 7155
2257 9302 2255 B2 6160 A2
2249 7154 C
C E B
2256 C3 6161 B3
3389
3
E B E B 2257 B3 6162 B3
3383
7156
2245
7152 7153 3386 3388 2258 A4 7150 A3
3
C
C C 3392 3370 A2 7151 A4
1167
2246
1
9301 3371 A2 7152 B1
3390
3379
3376
2252 3372 A4 7153 B2
1
2241 3373 B2 7154 B2
3393 3374 B4 7155 B2
3375 A3 7156 B3
2256 3376 C1 9301 C3
3377 B1 9302 B4
3378 B4
3379 C2
CDR-Mini Microphone Board Copperside view stage.4 (2000-03-07)
3380 B2
3381 A1
6-11
ELECTRICAL PARTSLIST FRONT BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
MISCELLANEOUS CAPACITORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
1101 3103 308 52930 DISPLAY, BJ721GNK 2126 © 5322 122 32448 10pF 5% 50V
1102 8203 303 90420 FFC SOCKET, 19P 2127 © 4822 126 13486 15pF 2% 63V
1104 4822 267 10733 FFC SOCKET, 4P 2128 © 4822 126 13486 15pF 2% 63V
1105 4822 267 10953 FFC SOCKET, 7P 2134 4822 124 12245 220µF 20% 16V
1106 4822 267 10954 FFC SOCKET, 5P 2135 © 4822 126 10326 180pF 5%
1113 4822 276 13775 TACT SWITCH 2136 © 4822 126 10326 180pF 5%
1114 4822 276 13775 TACT SWITCH 2137 © 4822 126 10326 180pF 5%
1115 4822 276 13775 TACT SWITCH 2138 © 4822 126 10326 180pF 5%
1116 4822 276 13775 TACT SWITCH 2139 © 4822 126 10326 180pF 5%
1117 4822 276 13775 TACT SWITCH 2140 © 4822 126 10326 180pF 5%
1118 4822 276 13775 TACT SWITCH 2141 © 4822 126 10326 180pF 5%
1119 4822 276 13775 TACT SWITCH 2142 © 4822 126 10326 180pF 5%
1120 4822 276 13775 TACT SWITCH 2143 © 4822 126 10326 180pF 5%
1121 4822 276 13775 TACT SWITCH 2144 © 4822 126 10326 180pF 5%
1122 4822 276 13775 TACT SWITCH 2145 © 4822 126 10326 180pF 5%
1123 4822 276 13775 TACT SWITCH 2146 © 4822 126 10326 180pF 5%
1124 4822 265 10979 FFC SOCKET, 15P 2150 © 4822 126 14585 100nF 10% 50V
1130 4822 265 10979 FFC SOCKET, 15P 2151 4822 124 12245 220µF 20% 16V
1131 8203 303 84410 JOG ENCODER 2152 4822 124 22833 10µF 20% 50V
1132 4822 276 13775 TACT SWITCH 2153 4822 124 21913 1µF 20% 63V
1133 4822 276 13775 TACT SWITCH 2154 © 4822 126 13838 100nF 10% 50V
1134 8203 303 84400 VOL ENCODER 2155 © 4822 122 33177 10nF 20% 50V
1135 4822 276 13775 TACT SWITCH 2156 4822 124 22833 10µF 20% 50V
1137 4822 276 13775 TACT SWITCH 2157 © 4822 122 33177 10nF 20% 50V
1138 4822 276 13775 TACT SWITCH 2158 4822 124 81286 47µF 20% 16V
1139 4822 276 13775 TACT SWITCH 2159 © 4822 122 33127 2,2nF 10% 63V
1140 4822 276 13775 TACT SWITCH 2161 © 5322 122 31647 1nF 10% 63V
1141 4822 276 13775 TACT SWITCH 2165 © 5322 122 32531 100pF 5% 50V
1142 4822 276 13775 TACT SWITCH 2166 © 4822 126 13692 47pF 1% 63V
1143 4822 276 13775 TACT SWITCH 2167 © 4822 126 13692 47pF 1% 63V
1144 4822 276 13775 TACT SWITCH 2168 © 4822 126 13692 47pF 1% 63V
1145 4822 276 13775 TACT SWITCH 2169 © 4822 126 13692 47pF 1% 63V
1146 4822 276 13775 TACT SWITCH 2170 © 4822 126 13695 82pF 1% 63V
1147 4822 276 13775 TACT SWITCH 2171 © 4822 126 13692 47pF 1% 63V
1148 4822 276 13775 TACT SWITCH 2172 © 4822 126 14585 100nF 10% 50V
1149 4822 276 13775 TACT SWITCH 2173 © 4822 126 13692 47pF 1% 63V
1150 4822 276 13775 TACT SWITCH 2174 © 5322 116 80853 560pF 5% 63V
1151 4822 276 13775 TACT SWITCH 2175 © 5322 122 31647 1nF 10% 63V
1152 4822 276 13775 TACT SWITCH 2176 © 4822 122 33173 560pF 10% 63V
1153 4822 276 13775 TACT SWITCH 2177 4822 124 22652 2,2µF 20% 50V
1160 4822 267 10958 FFC-SOCKET, 5P, SIDE ENTRY 2178 © 5322 122 32531 100pF 5% 50V
1162 4822 267 31448 CINCH SOCKET, 2-FOLD 2179 © 4822 122 33127 2,2nF 10% 63V
1165 4822 267 40898 MICROPHONE SOCKET 2180 © 4822 126 14585 100nF 10% 50V
1173 4822 276 13775 TACT SWITCH 2181 © 4822 126 12105 33nF 5% 63V
1174 4822 276 13775 TACT SWITCH 2182 © 4822 126 14585 100nF 10% 50V
CAPACITORS 2183 © 5322 122 32531 100pF 5% 50V
––––––––––––––––––––––––––––––––––––––––––––––––––––– 2184 © 5322 126 10184 820pF 5% 50V
2100 © 5322 122 32531 100pF 5% 50V 2185© 4822 126 14585 100nF 10% 50V
2101 © 4822 126 14585 100nF 10% 50V 2186 © 5322 122 32531 100pF 5% 50V
2102 © 4822 122 33177 10nF 20% 50V 2187 © 4822 126 13751 47nF 10% 50V
2103 © 5322 122 31647 1nF 10% 63V
2108 © 4822 126 10326 180pF 5% 2188 © 4822 126 14076 220nF 20% 25V
2189 © 4822 126 14043 1µF 20% 16V
2109 © 4822 126 10326 180pF 5% 2190 © 4822 122 33177 10nF 20% 50V
2110 4822 124 40433 47µF 20% 25V 2191 © 4822 126 14585 100nF 10% 50V
2111 © 4822 126 14585 100nF 10% 50V 2192 © 4822 126 14076 220nF 20% 25V
2114 © 5322 122 34099 470pF 10% 63V
2115 © 5322 122 32448 10pF 5% 50V 2193 © 5322 122 31647 1nF 10% 63V
2194 © 5322 122 31647 1nF 10% 63V
2116 © 5322 122 32448 10pF 5% 50V 2195 © 5322 122 31647 1nF 10% 63V
2121 © 4822 126 10326 180pF 5% 2196 © 5322 122 31647 1nF 10% 63V
2122 © 4822 126 10326 180pF 5%
2124 © 5322 122 32448 10pF 5% 50V
2125 © 5322 122 32448 10pF 5% 50V
6-12
ELECTRICAL PARTSLIST FRONT BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
CAPACITORS RESISTORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
2197 © 5322 122 31647 1nF 10% 63V 3094 © 4822 051 20471 470Ω 5% 0,1W
2198 © 5322 122 31647 1nF 10% 63V 3095 4822 050 11002 1kΩ 5% 0,2W
2199 © 4822 122 33177 10nF 20% 50V 3096 © 4822 051 20471 470Ω 5% 0,1W
2200 © 4822 126 14585 100nF 10% 50V 3097 © 4822 051 20471 470Ω 5% 0,1W
2201 4822 124 81286 47µF 20% 16V 3098 © 4822 051 20471 470Ω 5% 0,1W
2202 © 4822 126 14585 100nF 10% 50V 3099 © 4822 051 20471 470Ω 5% 0,1W
2203 4822 124 81286 47µF 20% 16V 3101 © 4822 051 20472 4,7kΩ 5% 0,1W
2204 © 4822 122 33177 10nF 20% 50V 3102 © 4822 117 11149 82kΩ 1% 0,1W
2205 © 4822 122 33177 10nF 20% 50V 3103 © 4822 117 11149 82kΩ 1% 0,1W
2206 © 4822 122 33177 10nF 20% 50V 3104 © 4822 117 11503 220Ω 5% 0,1W
2207 © 4822 122 33177 10nF 20% 50V 3105 © 4822 117 11503 220Ω 5% 0,1W
2209 © 4822 126 14585 100nF 10% 50V 3106 © 4822 117 11503 220Ω 5% 0,1W
2210 © 5322 122 32531 100pF 5% 50V 3107 © 4822 117 11503 220Ω 5% 0,1W
2211 © 5322 122 32531 100pF 5% 50V 3108 © 4822 117 11503 220Ω 5% 0,1W
3109 © 4822 117 11503 220Ω 5% 0,1W
2212 © 5322 122 34099 470pF 10% 63V
2220 © 4822 126 14585 100nF 10% 50V 3110 © 4822 117 11503 220Ω 5% 0,1W
2221 © 4822 126 14585 100nF 10% 50V 3111 © 4822 117 11503 220Ω 5% 0,1W
2222 © 4822 126 14585 100nF 10% 50V 3112 © 4822 117 11503 220Ω 5% 0,1W
2227 © 4822 126 14043 1µF 20% 16V 3113 © 4822 117 11503 220Ω 5% 0,1W
3114 © 4822 117 11503 220Ω 5% 0,1W
2228 © 4822 126 14585 100nF 10% 50V
2230 © 4822 126 14585 100nF 10% 50V 3115 © 4822 117 11503 220Ω 5% 0,1W
2232 © 5322 126 10511 1nF 5% 50V 3116 © 4822 117 11503 220Ω 5% 0,1W
2234 © 4822 126 14585 100nF 10% 50V 3117 © 4822 117 11503 220Ω 5% 0,1W
2235 © 5322 122 33538 150pF 5% 63V 3118 © 4822 117 11503 220Ω 5% 0,1W
3119 © 4822 117 11503 220Ω 5% 0,1W
2240 © 4822 122 33177 10nF 20% 50V
2241 4822 124 80791 470µF 20% 16V 3120 © 4822 117 11503 220Ω 5% 0,1W
2242 © 4822 122 33177 10nF 20% 50V 3121 © 4822 117 11503 220Ω 5% 0,1W
2243 4822 124 40248 10µF 20% 63V 3122 © 4822 117 11503 220Ω 5% 0,1W
2244 4822 124 40248 10µF 20% 63V 3123 © 4822 117 11503 220Ω 5% 0,1W
3124 © 4822 117 11503 220Ω 5% 0,1W
2245 © 4822 126 13482 470nF 20% 16V
2246 © 4822 126 13482 470nF 20% 16V 3125 © 4822 117 11503 220Ω 5% 0,1W
2247 © 5322 122 31647 1nF 10% 63V 3126 © 4822 117 11503 220Ω 5% 0,1W
2248 © 4822 126 14585 100nF 10% 50V 3127 © 4822 117 11503 220Ω 5% 0,1W
2249 © 5322 122 31647 1nF 10% 63V 3128 © 4822 117 11503 220Ω 5% 0,1W
3129 © 4822 117 11503 220Ω 5% 0,1W
2250 © 5322 126 10223 4,7nF 10% 63V
2251 © 5322 122 31647 1nF 10% 63V 3130 © 4822 117 11503 220Ω 5% 0,1W
2252 © 4822 126 14585 100nF 10% 50V 3131 © 4822 117 11503 220Ω 5% 0,1W
2253 © 5322 122 31647 1nF 10% 63V 3132 © 4822 117 11503 220Ω 5% 0,1W
2254 © 4822 126 14585 100nF 10% 50V 3133 © 4822 117 11503 220Ω 5% 0,1W
3134 © 4822 117 11503 220Ω 5% 0,1W
2255 4822 124 40248 10µF 20% 63V
2256 4822 124 21913 1µF 20% 63V 3135 © 4822 117 11503 220Ω 5% 0,1W
2257 © 5322 122 31647 1nF 10% 63V 3136 © 4822 117 11504 270Ω 1% 0.1W
2258 4822 124 41584 100µF 20% 10V 3137 © 4822 051 20472 4,7kΩ 5% 0,1W
2260 © 4822 126 14585 100nF 10% 50V 3138 © 4822 117 11149 82kΩ 1% 0,1W
3139 © 4822 117 11149 82kΩ 1% 0,1W
2262 © 5322 122 32531 100pF 5% 50V
2301 © 4822 122 33177 10nF 20% 50V 3140 © 4822 117 11504 270Ω 1% 0.1W
2302 © 5322 122 32531 100pF 5% 50V 3141 © 4822 117 11503 220Ω 5% 0,1W
2303 © 4822 126 14585 100nF 10% 50V 3142 © 4822 117 11503 220Ω 5% 0,1W
2304 © 4822 122 33177 10nF 20% 50V 3143 © 4822 117 11504 270Ω 1% 0.1W
3144 © 4822 117 11503 220Ω 5% 0,1W
2305 © 4822 122 33177 10nF 20% 50V
2306 © 5322 122 32531 100pF 5% 50V 3145 © 4822 051 20471 470Ω 5% 0,1W
2307 © 4822 126 14585 100nF 10% 50V 3146 © 4822 117 11504 270Ω 1% 0.1W
2308 © 4822 122 33177 10nF 20% 50V 3147 © 4822 117 11503 220Ω 5% 0,1W
3148 © 4822 117 11503 220Ω 5% 0,1W
3149 © 4822 117 11504 270Ω 1% 0.1W
3150 © 4822 117 11503 220Ω 5% 0,1W
3151 © 4822 117 11503 220Ω 5% 0,1W
3152 © 4822 117 11504 270Ω 1% 0.1W
3153 © 4822 051 10102 1kΩ 2% 0,25W
3154 © 4822 117 11503 220Ω 5% 0,1W
6-13
ELECTRICAL PARTSLIST FRONT BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
RESISTORS RESISTORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
3155 © 4822 117 11504 270Ω 1% 0.1W 3216 © 4822 051 20478 4,7Ω 5% 0,1W
3156 © 4822 051 10102 1kΩ 2% 0,25W 3217 © 4822 051 20684 680kΩ 5% 0,1W
3158 © 4822 117 11503 220Ω 5% 0,1W 3218 © 4822 051 20478 4,7Ω 5% 0,1W
3159 © 4822 051 20471 470Ω 5% 0,1W 3219 © 4822 051 20478 4,7Ω 5% 0,1W
3160 © 4822 117 11503 220Ω 5% 0,1W 3220 © 4822 051 20101 100Ω 5% 0,1W
3161 © 4822 051 10102 1kΩ 2% 0,25W 3221 © 4822 051 20101 100Ω 5% 0,1W
3162 © 4822 117 11503 220Ω 5% 0,1W 3222 © 4822 117 10833 10kΩ 1% 0,1W
3163 © 4822 051 10102 1kΩ 2% 0,25W 3223 © 4822 117 10833 10kΩ 1% 0,1W
3164 © 4822 117 11503 220Ω 5% 0,1W 3224 © 4822 051 20684 680kΩ 5% 0,1W
3165 © 4822 051 20471 470Ω 5% 0,1W 3225 © 4822 051 10102 1kΩ 2% 0,25W
3166 © 4822 117 11503 220Ω 5% 0,1W 3226 © 4822 117 10837 100kΩ 1% 0,1W
3167 © 4822 051 10102 1kΩ 2% 0,25W 3227 © 4822 051 10102 1kΩ 2% 0,25W
3168 © 4822 117 11503 220Ω 5% 0,1W 3228 © 4822 117 10833 10kΩ 1% 0,1W
3169 © 4822 117 11503 220Ω 5% 0,1W 3230 © 4822 051 10102 1kΩ 2% 0,25W
3170 © 4822 117 11503 220Ω 5% 0,1W 3231 © 4822 117 10837 100kΩ 1% 0,1W
3171 © 4822 117 11503 220Ω 5% 0,1W 3232 © 4822 051 10102 1kΩ 2% 0,25W
3172 © 4822 051 10102 1kΩ 2% 0,25W 3233 © 4822 051 20101 100Ω 5% 0,1W
3173 © 4822 051 10102 1kΩ 2% 0,25W 3234 4822 116 52175 100Ω 5% 0,5W
3174 © 4822 051 10102 1kΩ 2% 0,25W 3235 4822 116 52195 47Ω 5% 0,5W
3175 © 4822 051 10102 1kΩ 2% 0,25W 3236 © 4822 051 20333 33kΩ 5% 0,1W
3176 © 4822 051 20101 100Ω 5% 0,1W 3237 © 4822 051 20478 4,7Ω 5% 0,1W
3177 © 4822 051 10102 1kΩ 2% 0,25W 3238 © 4822 051 20478 4,7Ω 5% 0,1W
3178 © 4822 051 20101 100Ω 5% 0,1W 3240 4822 050 21003 10kΩ 2% 0,25W
3179 © 4822 051 10102 1kΩ 2% 0,25W 3241 4822 050 21003 10kΩ 2% 0,25W
3180 © 4822 051 10102 1kΩ 2% 0,25W 3242 4822 050 21003 10kΩ 2% 0,25W
3181 © 4822 051 10102 1kΩ 2% 0,25W 3243 © 4822 051 10102 1kΩ 2% 0,25W
3182 © 4822 051 20471 470Ω 5% 0,1W 3244 © 4822 051 10102 1kΩ 2% 0,25W
3183 © 4822 117 11139 1,5kΩ 1% 0,1W 3245 © 4822 051 10102 1kΩ 2% 0,25W
3184 © 4822 117 11139 1,5kΩ 1% 0,1W 3246 © 4822 051 10102 1kΩ 2% 0,25W
3185 © 4822 051 20101 100Ω 5% 0,1W 3247 © 4822 051 10102 1kΩ 2% 0,25W
3186 © 4822 051 10102 1kΩ 2% 0,25W 3248 © 4822 117 11449 2,2kΩ 1% 0,1W
3187 © 4822 051 10102 1kΩ 2% 0,25W 3249 © 4822 117 13579 220kΩ 1% 0.1W
3188 © 4822 051 10102 1kΩ 2% 0,25W 3250 © 4822 117 11503 220Ω 5% 0,1W
3189 © 4822 051 20471 470Ω 5% 0,1W 3251 © 4822 117 11503 220Ω 5% 0,1W
3190 © 4822 051 10102 1kΩ 2% 0,25W 3252 4822 116 52195 47Ω 5% 0,5W
3191 © 4822 051 20471 470Ω 5% 0,1W 3253 © 4822 051 10102 1kΩ 2% 0,25W
3192 © 4822 051 10102 1kΩ 2% 0,25W 3254 © 4822 051 10102 1kΩ 2% 0,25W
3193 © 4822 051 10102 1kΩ 2% 0,25W 3255 © 4822 117 10833 10kΩ 1% 0,1W
3194 © 4822 051 10102 1kΩ 2% 0,25W 3256 © 4822 117 10833 10kΩ 1% 0,1W
3195 © 4822 051 10102 1kΩ 2% 0,25W 3257 © 4822 051 20392 3,9kΩ 5% 0,1W
3196 © 4822 051 10102 1kΩ 2% 0,25W 3258 © 4822 051 20182 1,8kΩ 5% 0,1W
3197 © 4822 051 10102 1kΩ 2% 0,25W 3259 © 4822 051 20122 1,2kΩ 5% 0,1W
3198 © 4822 051 10102 1kΩ 2% 0,25W 3260 © 4822 117 11454 820Ω 1%
3199 © 4822 051 10102 1kΩ 2% 0,25W 3261 © 4822 051 20561 560Ω 5% 0,1W
3200 © 4822 051 10102 1kΩ 2% 0,25W 3262 © 4822 051 20391 390Ω 5% 0,1W
3201 © 4822 051 10102 1kΩ 2% 0,25W 3263 4822 116 83876 270Ω 5% 0.16W
3202 © 4822 051 10102 1kΩ 2% 0,25W 3264 © 4822 117 11503 220Ω 5% 0,1W
3203 © 4822 051 10102 1kΩ 2% 0,25W 3265 © 4822 117 10353 150Ω 5% 0,1W
3204 © 4822 051 10102 1kΩ 2% 0,25W 3266 4822 050 11002 1kΩ 5% 0,2W
3205 © 4822 051 10102 1kΩ 2% 0,25W 3267 © 4822 117 12955 2,7kΩ 1% 0,1W
3206 © 4822 051 10102 1kΩ 2% 0,25W 3268 © 4822 051 20684 680kΩ 5% 0,1W
3207 © 4822 051 10102 1kΩ 2% 0,25W 3269 © 4822 117 11139 1,5kΩ 1% 0,1W
3208 © 4822 051 10102 1kΩ 2% 0,25W 3270 © 4822 117 13579 220kΩ 1% 0.1W
3209 © 4822 051 10102 1kΩ 2% 0,25W 3271 © 4822 051 20154 150kΩ 5% 0,1W
3210 © 4822 051 10102 1kΩ 2% 0,25W 3272 © 4822 117 11503 220Ω 5% 0,1W
3211 © 4822 051 10102 1kΩ 2% 0,25W 3273 © 4822 117 10353 150Ω 5% 0,1W
3212 © 4822 051 10102 1kΩ 2% 0,25W 3274 4822 050 11002 1kΩ 5% 0,2W
3213 © 4822 051 10102 1kΩ 2% 0,25W 3275 © 4822 051 20684 680kΩ 5% 0,1W
3214 © 4822 051 20101 100Ω 5% 0,1W 3276 © 4822 117 12955 2,7kΩ 1% 0,1W
3215 © 4822 051 20478 4,7Ω 5% 0,1W 3277 © 4822 117 11139 1,5kΩ 1% 0,1W
6-14
ELECTRICAL PARTSLIST FRONT BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
RESISTORS RESISTORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
3278 © 4822 117 12955 2,7kΩ 1% 0,1W 3350 4822 116 83883 470Ω 5% 0,16W
3279 © 4822 117 13579 220kΩ 1% 0.1W 3351 © 4822 117 10833 10kΩ 1% 0,1W
3280 © 4822 051 20154 150kΩ 5% 0,1W 3353 © 4822 117 11148 56kΩ 1% 0,1W
3281 4822 050 11002 1kΩ 5% 0,2W 3354 © 4822 051 20399 39Ω 5% 0,1W
3282 © 4822 051 20684 680kΩ 5% 0,1W 3356 © 4822 117 11449 2,2kΩ 1% 0,1W
3283 © 4822 117 11139 1,5kΩ 1% 0,1W 3357 © 4822 051 20683 68kΩ 5% 0,1W
3284 © 4822 117 13579 220kΩ 1% 0.1W 3358 © 4822 117 10833 10kΩ 1% 0,1W
3285 © 4822 051 20154 150kΩ 5% 0,1W 3359 © 4822 117 11503 220Ω 5% 0,1W
3286 © 4822 051 20684 680kΩ 5% 0,1W 3362 © 4822 051 20471 470Ω 5% 0,1W
3287 © 4822 117 11139 1,5kΩ 1% 0,1W 3364 © 4822 051 20101 100Ω 5% 0,1W
3288 © 4822 117 13579 220kΩ 1% 0.1W 3366 © 4822 117 10837 100kΩ 1% 0,1W
3289 © 4822 051 20154 150kΩ 5% 0,1W 3367 © 4822 051 20829 82Ω 5% 0,1W
3290 © 4822 051 20101 100Ω 5% 0,1W 3368 © 4822 051 20561 560Ω 5% 0,1W
3291 © 4822 117 10833 10kΩ 1% 0,1W 3370 © 4822 117 11507 6,8kΩ 1% 0,1W
3293 © 4822 051 20479 47Ω 5% 0,1W 3371 © 4822 051 20472 4,7kΩ 5% 0,1W
3294 © 4822 051 10102 1kΩ 2% 0,25W 3372 © 4822 117 11449 2,2kΩ 1% 0,1W
3301 4822 116 83881 390Ω 5% 0,5W 3373 © 4822 051 20223 22kΩ 5% 0,1W
3302 4822 116 83868 150Ω 5% 0,5W 3374 © 4822 117 12955 2,7kΩ 1% 0,1W
3303 4822 116 83868 150Ω 5% 0,5W 3375 © 4822 051 10102 1kΩ 2% 0,25W
3304 © 4822 117 10833 10kΩ 1% 0,1W 3376 © 4822 117 11449 2,2kΩ 1% 0,1W
3305 © 4822 117 10833 10kΩ 1% 0,1W 3377 © 4822 051 20105 1MΩ 5% 0,1W
3306 © 4822 051 10102 1kΩ 2% 0,25W 3378 © 4822 051 20105 1MΩ 5% 0,1W
3307 4822 116 83868 150Ω 5% 0,5W 3379 © 4822 117 12955 2,7kΩ 1% 0,1W
3308 © 4822 051 10102 1kΩ 2% 0,25W 3380 © 4822 117 10833 10kΩ 1% 0,1W
3309 © 4822 117 12955 2,7kΩ 1% 0,1W 3381 © 4822 051 20229 22Ω 5% 0,1W
3310 © 4822 051 10102 1kΩ 2% 0,25W 3382 © 4822 117 11448 180Ω 10% 0,1W
3311 © 4822 051 20479 47Ω 5% 0,1W 3383 4822 101 21204 POTMETER, 20k
3312 4822 050 11002 1kΩ 5% 0,2W 3384 © 4822 051 10102 1kΩ 2% 0,25W
3313 4822 050 11002 1kΩ 5% 0,2W 3385 © 4822 117 10833 10kΩ 1% 0,1W
3314 © 4822 117 10833 10kΩ 1% 0,1W 3386 © 4822 051 20339 33Ω 5% 0,1W
3315 © 4822 117 10833 10kΩ 1% 0,1W 3387 © 4822 117 11449 2,2kΩ 1% 0,1W
3316 4822 116 83868 150Ω 5% 0,5W 3388 4822 116 83883 470Ω 5% 0,16W
3317 4822 116 83872 220Ω 5% 0,5W 3389 4822 116 83883 470Ω 5% 0,16W
3318 4822 116 83876 270Ω 5% 0.16W 3390 © 4822 051 10102 1kΩ 2% 0,25W
3319 4822 116 83881 390Ω 5% 0,5W 3391 © 4822 117 10833 10kΩ 1% 0,1W
3320 © 4822 117 11504 270Ω 1% 0.1W 3392 © 4822 051 20105 1MΩ 5% 0,1W
3321 4822 116 52226 560Ω 5% 0,5W 3393 © 4822 051 20472 4,7kΩ 5% 0,1W
3322 4822 116 83881 390Ω 5% 0,5W 3394 © 4822 117 10834 47kΩ 1% 0,1W
3323 4822 116 52231 820Ω 5% 0,5W 3395 © 4822 117 10353 150Ω 5% 0,1W
3324 4822 116 52226 560Ω 5% 0,5W 3396 © 4822 117 13579 220kΩ 1% 0.1W
3325 4822 116 52213 180Ω 5% 0,5W 3397 © 4822 051 20471 470Ω 5% 0,1W
3326 4822 116 52207 1,2kΩ 5% 0,5W 3401 © 4822 117 12955 2,7kΩ 1% 0,1W
3327 4822 116 52231 820Ω 5% 0,5W 3403 © 4822 051 10102 1kΩ 2% 0,25W
3328 © 4822 117 10353 150Ω 5% 0,1W 3404 © 4822 051 20479 47Ω 5% 0,1W
3329 4822 116 52213 180Ω 5% 0,5W 3407 © 4822 117 10833 10kΩ 1% 0,1W
3330 4822 116 52249 1,8kΩ 5% 0,16W 3501 © 4822 117 11139 1,5kΩ 1% 0,1W
3331 4822 116 52207 1,2kΩ 5% 0,5W 3502 © 4822 117 11139 1,5kΩ 1% 0,1W
3332 © 4822 117 10353 150Ω 5% 0,1W 3503 © 4822 051 20471 470Ω 5% 0,1W
3333 © 4822 051 20392 3,9kΩ 5% 0,1W 3504 © 4822 051 20101 100Ω 5% 0,1W
3334 4822 116 52249 1,8kΩ 5% 0,16W 3505 © 4822 117 11139 1,5kΩ 1% 0,1W
3335 4822 116 52213 180Ω 5% 0,5W 3506 © 4822 117 11139 1,5kΩ 1% 0,1W
3337 4822 050 21003 10kΩ 2% 0,25W 3507 © 4822 051 20471 470Ω 5% 0,1W
3338 4822 116 52276 3,9kΩ 5% 0,5W 3508 © 4822 051 20101 100Ω 5% 0,1W
3339 4822 116 52226 560Ω 5% 0,5W 4001 © 4822 051 20008 CHIP JUMPER 0805
3340 4822 050 21003 10kΩ 2% 0,25W 4002 © 4822 051 20008 CHIP JUMPER 0805
3341 4822 116 52219 330Ω 5% 0,5W 4004 © 4822 051 20008 CHIP JUMPER 0805
3342 © 4822 051 20101 100Ω 5% 0,1W 4005 © 4822 051 20008 CHIP JUMPER 0805
3343 © 4822 051 20109 10Ω 5% 0,1W 4006 © 4822 051 20008 CHIP JUMPER 0805
3344 © 4822 051 20109 10Ω 5% 0,1W 4007 © 4822 051 20008 CHIP JUMPER 0805
3345 4822 052 10478 4,7Ω 5% NFR 4008 © 4822 051 20008 CHIP JUMPER 0805
6-15
ELECTRICAL PARTSLIST FRONT BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
RESISTORS RESISTORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
4009 © 4822 051 20008 CHIP JUMPER 0805 4201 © 4822 051 20008 CHIP JUMPER 0805
4012 © 4822 051 20008 CHIP JUMPER 0805 4203 © 4822 051 20008 CHIP JUMPER 0805
4013 © 4822 051 20008 CHIP JUMPER 0805 4204 © 4822 051 20008 CHIP JUMPER 0805
4014 © 4822 051 20008 CHIP JUMPER 0805 4205 © 4822 051 20008 CHIP JUMPER 0805
4015 © 4822 051 20008 CHIP JUMPER 0805 4206 © 4822 051 20008 CHIP JUMPER 0805
4016 © 4822 051 20008 CHIP JUMPER 0805 4304 © 4822 051 20008 CHIP JUMPER 0805
4017 © 4822 051 20008 CHIP JUMPER 0805 4401 © 4822 051 20008 CHIP JUMPER 0805
4018 © 4822 051 20008 CHIP JUMPER 0805 4501 © 4822 051 20008 CHIP JUMPER 0805
4019 © 4822 051 20008 CHIP JUMPER 0805
4021 © 4822 051 20008 CHIP JUMPER 0805 COILS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
4022 © 4822 051 20008 CHIP JUMPER 0805 1107 4822 242 70938 CRYSTAL 32,768kHz
4024 © 4822 051 20008 CHIP JUMPER 0805 1108 5322 242 73686 CERAMIC RESONATOR, 12MHZ
4025 © 4822 051 20008 CHIP JUMPER 0805 1111 4822 242 72195 XTAL 4,332MHz
4026 © 4822 051 20008 CHIP JUMPER 0805 5101 4822 156 21721 2,2µH
4027 © 4822 051 20008 CHIP JUMPER 0805 5102 4822 156 21721 2,2µH
4028 © 4822 051 20008 CHIP JUMPER 0805 5103 4822 156 21721 2,2µH
4029 © 4822 051 20008 CHIP JUMPER 0805 5104 4822 156 21721 2,2µH
4030 © 4822 051 20008 CHIP JUMPER 0805 5107 4822 156 21721 2,2µH
4031 © 4822 051 20008 CHIP JUMPER 0805 5108 4822 156 21721 2,2µH
4032 © 4822 051 20008 CHIP JUMPER 0805 5109 4822 156 21721 2,2µH
4033 © 4822 051 20008 CHIP JUMPER 0805 5110 4822 156 21721 2,2µH
4034 © 4822 051 20008 CHIP JUMPER 0805 5111 4822 156 21721 2,2µH
4035 © 4822 051 20008 CHIP JUMPER 0805 5112 4822 156 21721 2,2µH
4036 © 4822 051 20008 CHIP JUMPER 0805 5130 2422 536 00019 TRANSFORMER, DIGITAL OUT
4037 © 4822 051 20008 CHIP JUMPER 0805
DIODES
4038 © 4822 051 20008 CHIP JUMPER 0805 –––––––––––––––––––––––––––––––––––––––––––––––––––––
4039 © 4822 051 20008 CHIP JUMPER 0805 6101 4822 130 11589 LED, LTL-1CHAE
4040 © 4822 051 20008 CHIP JUMPER 0805 6102 4822 130 11589 LED, LTL-1CHAE
4041 © 4822 051 20008 CHIP JUMPER 0805 6103 4822 130 11589 LED, LTL-1CHAE
4042 © 4822 051 20008 CHIP JUMPER 0805 6104 4822 130 11589 LED, LTL-1CHAE
6105 9322 131 65675 LED, LTL-1CHEE
4043 © 4822 051 20008 CHIP JUMPER 0805
4044 © 4822 051 20008 CHIP JUMPER 0805 6106 4822 130 11589 LED, LTL-1CHAE
4045 © 4822 051 20008 CHIP JUMPER 0805 6107 4822 130 11589 LED, LTL-1CHAE
4046 © 4822 051 20008 CHIP JUMPER 0805 6108 4822 130 30621 1N4148
4047 © 4822 051 20008 CHIP JUMPER 0805 6109 4822 130 30621 1N4148
6110 4822 130 30621 1N4148
4048 © 4822 051 20008 CHIP JUMPER 0805
4049 © 4822 051 20008 CHIP JUMPER 0805 6120 4822 130 30621 1N4148
4050 © 4822 051 20008 CHIP JUMPER 0805 6121 4822 130 30621 1N4148
4051 © 4822 051 20008 CHIP JUMPER 0805 6122 4822 130 30621 1N4148
4052 © 4822 051 20008 CHIP JUMPER 0805 6123 4822 130 30621 1N4148
6124 4822 130 30621 1N4148
4053 © 4822 051 20008 CHIP JUMPER 0805
4054 © 4822 051 20008 CHIP JUMPER 0805 6130 4822 130 11589 LED, LTL-1CHAE
4055 © 4822 051 20008 CHIP JUMPER 0805 6131 4822 130 11589 LED, LTL-1CHAE
4056 © 4822 051 20008 CHIP JUMPER 0805 6132 4822 130 30621 1N4148
4057 © 4822 051 20008 CHIP JUMPER 0805 6133 4822 130 11589 LED, LTL-1CHAE
6134 4822 130 11589 LED, LTL-1CHAE
4058 © 4822 051 20008 CHIP JUMPER 0805
4059 © 4822 051 20008 CHIP JUMPER 0805 6135 8203 303 84440 LED 5MM BLUE
4060 © 4822 051 20008 CHIP JUMPER 0805 6136 8203 303 84850 LED, LTL2R3KFK-071A
4061 © 4822 051 20008 CHIP JUMPER 0805 6137 4822 130 11589 LED, LTL-1CHAE
4102 © 4822 051 20008 CHIP JUMPER 0805 6138 4822 130 11589 LED, LTL-1CHAE
6139 4822 130 11589 LED, LTL-1CHAE
4103 © 4822 051 20008 CHIP JUMPER 0805
4104 © 4822 051 20008 CHIP JUMPER 0805 6140 8203 303 84850 LED, LTL2R3KFK-071A
4105 © 4822 051 20008 CHIP JUMPER 0805 6142 8203 303 84450 LED 5MM AMBER/H.E.RED
4106 © 4822 051 20008 CHIP JUMPER 0805 6143 4822 130 11589 LED, LTL-1CHAE
4107 © 4822 051 20008 CHIP JUMPER 0805 6160 4822 130 30621 1N4148
6161 4822 130 30621 1N4148
4108 © 4822 051 20008 CHIP JUMPER 0805
4109 © 4822 051 20008 CHIP JUMPER 0805 6162 4822 130 30621 1N4148
4110 © 4822 051 20008 CHIP JUMPER 0805 6170 8203 303 84430 LED 5MM 90 DEGREE BLUE
4111 © 4822 051 20008 CHIP JUMPER 0805 6200 5322 130 30691 BAW56
4112 © 4822 051 20008 CHIP JUMPER 0805 6201 5322 130 30691 BAW56
6202 5322 130 30691 BAW56
6-16
ELECTRICAL PARTSLIST FRONT BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
DIODES
–––––––––––––––––––––––––––––––––––––––––––––––––––––
6203 5322 130 30691 BAW56
6205 5322 130 30691 BAW56
6206 5322 130 30691 BAW56
6207 5322 130 30691 BAW56
6208 5322 130 30691 BAW56
6209 5322 130 30691 BAW56
6210 5322 130 30691 BAW56
6211 5322 130 30691 BAW56
TRANSISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7101 © 4822 130 60511 BC847B
7102 © 4822 130 60511 BC847B
7103 © 4822 130 60511 BC847B
7104 © 4822 130 60511 BC847B
7105 © 4822 130 60511 BC847B
7106 © 4822 130 60511 BC847B
7111 © 4822 130 60511 BC847B
7123 © 4822 130 60511 BC847B
7131 © 4822 130 60511 BC847B
7150 © 4822 130 42804 BC817-25
7151 © 4822 130 60511 BC847B
7152 © 4822 130 60373 BC856B
7153 © 4822 130 60511 BC847B
7154 © 4822 130 42804 BC817-25
7155 © 4822 130 60511 BC847B
7156 © 4822 130 60511 BC847B
7160 © 4822 130 60511 BC847B
INTEGRATED CIRCUITS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7107 © 4822 209 15449 74HC4094D, SHIFT REGISTER
7108 © 8203 303 90210 TMP88CU77ZF, µP
7110 © 9322 131 04668 M24C01, EEPROM
7112 9322 137 14667 IR RECEIVER TSOP2836ZC1
7120 © 4822 209 17345 M62320FP, I2C SHIFT REGISTER
7121 4822 209 31981 SAA6579T/V1, RDS DECODER
7122 © 5322 209 11446 HEF4051BT, MULTIPLEXER
7130 © 4822 209 15449 74HC4094D, SHIFT REGISTER
7132 © 4822 209 15449 74HC4094D, SHIFT REGISTER
7140 © 4822 209 17235 74LVU04D, 6-FOLD INVERTER
7142 4822 209 10263 HEF4052BP, SELECTOR IC
7145 4822 209 10263 HEF4052BP, SELECTOR IC
7A-1
Tuner 95
(3 Band RDS Tuner)
TABLE OF CONTENTS
Adjustment table .............................................................7A-2
Blockdiagram ..................................................................7A-3
Circuit Diagram ...............................................................7A-4
Component Layout..........................................................7A-5
Electrical Partslist ............................................................7A-6
7A-2
TUNER ADJUSTMENT TABLE ( TUNER 95 FM/MW/LW - version with AM-frame aerial )
Waverange Input frequency Input Tuned to Adjust Output Scope/Voltmeter
VARICAP ALIGNMENT
FM 108MHz check 7...9V
87.5 - 108MHz
(50kHz grid) 87.5MHz check 1.3...2V
MW 1602kHz 5123 8.3V ±0.2V
531 - 1602kHz 6
(9kHz grid) 531kHz check 1V ±0.4V
LW 279kHz 5122 8.3V ±0.2V
153 - 279kHz
(3kHz grid) 153kHz check 1V ±0.4V
FM - IF
98MHz 1mV
continuous wave 1
FM A 98MHz 5107 0mV ±3mV
shortcircuit pin 21 2
of IC7108 to ground
FM - VCO
98MHz 1mV
FM A 98MHz 3142 3 152kHz ±1kHz 1)
continuous wave
DISTORTION
98MHz 1mV mixcoil
FM 90% Left + 9% pilot A 98MHz inside tuner 4 min. distortion
mod=1kHz 1110
AM IF
5111
450kHz
max.
∆f=10kHz
100nF
7
as low as possible 50R
C
MW MW 5112 fo
symmetric
C
450kHz 1
5114 0mV ±2mV
continuous wave 2
AM RF 2)
558kHz 558kHz 5102
MW B 7
max.
1494kHz 1494kHz 2106
∆f = ±30kHz
VRF as low as fo
symmetric
possible
LW 198kHz 198kHz 5103
Tuner 95, 3104 217 04120 (2000-02-17)
1) If sensitivity of frequency counter is too low adjust to max. channel separation
(input signal: stereo left 90% + 9%, adjust output on right channel to minimum)
2) For AM RF adjustments the original frame antenna has to be used !
Repeat
7A-3 7A-3
BLOCK DIAGRAM TUNER95
+FM IF-AM IF-AM AM-DET
10,7MHz
2 1
450kHz 450kHz 450kHz 1121
VCC1 VDD 5111 5112 5114 VCC2
TEA5762 1
7 23 35 34 33 38 40 41 36 32 19 20 22 GND
6 3
VCC1 VDD FM-IF2 V Stab B FM-IF2I V Stab A AM-MIX Out AM-IF1 In AM-IF2 AM-AFC AFC- AFC+ VCC2 2
+B AGC RDS RDS
FM FRONTEND 29
WRITE Enable 3
A ENABLE
STABILIZER AFC 28
DATA 4
DATA
CLOCK 27 5
1102 CLOCK
1 Ant1 IF Out 7 10,7MHz 37 FM-IF1I In P1 31 6
FM FM AM AM STEREO
Fa IF1 IF2 IF DET
FM/AM 39
CONTROL
F if 10,7 MHz 5 FM Osc. 3
P0 30
Fo
Mono/
CHARGE Stereo 24 4
4 GND Osc Out 8 1124
PUMP
Left 14 1
LEFT
AM FM
f0 = fin + fif MT VT
6 FRONTEND DET Mute 13
2
MT 5 STEREO GND
8 I-Tune AM
DECODER
AM MIXER
OSC. Right 15 3
2 AM-RF RIGHT
XTAL
AGC
OSC PILOT 16
Filter
C Fieldstrength
Ripple AM-Osc. FM GND RF GND IF GND Dig. GND RF GND FM-Demod AGC AF-Out Indc. MPX-In VC0 LPF
1 6 3 4 17 26 42 18 44 10 21 25 11 9 12
AM-RF AM-OSC
10,7MHz 75kHz
3142 +FM
5102 5123
MW MW
2106
7
5103 5122 4 VCC
VCC1
LW LW ANTI BIRDY FILTER
VC0
B VDD
RDS
VCC2
MW/LW-SELECTION
7A-4 7A-4
1102 D1 1124 F21 2107 J6 2122 M7 2128 I13 2132 I17 2136 H19 2140 C14 2144 K20 2150 C6 2160 I15 3104 G4 3120 H5 3128 L9 3132 J7 3141 I16 3145 I17 3151 I20 3155 J20 3161 D19 3167 I20 3177 M10 3184 I8 3192 C12 5107 J12 5112 C12 5122 L7 6106 H5 7103 K17 7110 I19
1103 G2 1126 E20 2108 L2 2123 L7 2129 I8 2133 G18 2137 G19 2141 H15 2145 E19 2151 H12 2161 I15 3107 C6 3123 I6 3129 K8 3134 L6 3142 I16 3146 L20 3152 F20 3158 E19 3162 I15 3169 L5 3178 N20 3185 I13 3197 L11 5109 B6 5114 C13 5123 K7 6107 K20 7104 J2 7122 L9
1110 D4 2102 C2 2109 L3 2125 L7 2130 J20 2134 G19 2138 H18 2142 K19 2147 E19 2152 I11 2162 H20 3108 J1 3124 K7 3130 K8 3137 L5 3143 K17 3147 N20 3153 G20 3159 E19 3163 J8 3172 B6 3181 C7 3186 K16 5102 I3 5110 C9 5115 J15 6105a I5 6120 E17 7105 K2 7124 L6
1121 C21 2106 J4 2120 K7 2127 H16 2131 I17 2135 F19 2139 I7 2143 K20 2148 E19 2158 L18 3103 G3 3109 K1 3125 L11 3131 M10 3140 F7 3144 K17 3150 H19 3154 J20 3160 D19 3164 I20 3173 B6 3183 I13 3188 M20 5103 L4 5111 C11 5121 I15 6105b I6 7101 C15 7109 L10
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
TUNER 95
A A
5109
3172 10,7 MHz V
0E
B 0,5V IF - AM IF - AM AM - DET B
0E
+12V 3173
3 0 0V = No communication
+FM 6
FM FRONTEND 1 1 6 During communication
82E
2150 2
0E
0E
2102 3107 3181 3192
100n
470u 3 4 3 4 V
2 1 V
C 5110 C
+7V 10,7 MHz 5111 5112 5114 1
6 7
+6V 450 kHz 450 kHz 450 kHz 2140 0V 0 1121
+8V +9,6V
+B IF Out
VCC1 VDD
7101 VCC2
mono stereo
High = During communication
1110 470n TEA5762 1
7 23 35 1,4V 34 33 1,4V 38 40 41 36 32 19 20 22 GND
FE415-G23
VCC1 VDD FM-IF2 V Stab B FM-IF2I V Stab A AM-MIX Out AM-IF1 In AM-IF2 AM-AFC AFC- AFC+ VCC2 1,3V 2 MPX-RDS
D A (VCC2) D
29 3161
WRITE Enable 1 3
470E ENABLE
STABILIZER AFC 28 3160
1102 1 DATA 2 4
FM 470E DATA
ANT. Ant1 Fa 27 3159
CLOCK 3 5
470E CLOCK
F if 10,7 MHz 6120 3158
E 37 FM-IF1I In P1 31 4 6 E
FM FM AM AM 470E STEREO
Fo IF1 IF2 IF DET 1N4148
FM/AM 39 2145 2147 2148
CONTROL 220p 220p 22n 1126
4 Osc Out 8 5 FM Osc. STEREO = LOW
GND P0 30 3
330E
3140
Mono/
F Fo = Fa + Fi f CHARGE Stereo 24 1124 F
AGC MT VT PUMP
3 MT 5 Left 14 2135 3152
1
470E LEFT
6 AM FM
0E
1k
220n
3103 3104 FRONTEND DET Mute 13 2134
VT 8 I-Tune 0,7V 15n
2
STEREO 2133 4 GND
AM
G MIXER
DECODER 1µ G
1103 AM
OSC. Right 15 2137 3153
3
2 AM-RF 470E RIGHT
2 XTAL
AGC 220n
OSC PILOT 16 2136
6106 15n
1 Filter 0,9V
1N4148 2138 11,8V
Fieldstrength
C
Ripple AM-Osc. FM GND RF GND IF GND Dig. GND RF GND FM-Demod AGC AF-Out Indc. MPX-In VC0 LPF 2µ2
H 11,2V H
0E
3120 3150
AM-FRAME SOCKET 2V 1 6 3 4 17 26 42 18 0V 44 10 2V 21 25 11 1V 9 0,8V 12
4k7
2141
V
68k
2151 100n 2127 2162
3151
0E
3183
0E
3184 15p 220n 22 µ
2139 0V
2128 AM FM
150k
56k
2k2
100n 2160
2129 3162 3141 3145
3 10 µ 12p 0,5V
I B 6 1µ 2131 +FM I
5102 MT 5
+12V 7110
LW = 0,7V 470n
2152 BC858B
4E7
100k
2161 5121 2132 3164
0E
0E
MW = 0V 3123 3185 3142
2 82p 2 4 1n 75 kHz 470n
6105a 6105b 3167
3108 VCC1 4 VCC
7104 HN1V02H HN1V02H 220E
2k2 5 +8V +12V
BC338-40 1 5107
VC0
150E
2130
1 7 6 5 Toko 7KM 3154
MW 22n
3
J 2 3 J
75 kHz
0E
2106 3132
5115 3155
0E
3163 +7V
5p2- 2107 VDD 330E
4 6
30p 470n +6V
1 4 MW-OSC 7 2144
0E
3124 +8V
0E
5123 3129 VCC1 1µ
3 4 ANTI BIRDY
FILTER
22k
K 2120 2 3 2 1 7103 3143 VCC2 K
0E
3130 +9,6V
7105 33p +7V +7V BC858C 3144
1,3V 6107
BC338-40 1 6 1k
+6V +6V 3186 BZX79/
3109 V 2142 2143
3 VDD VDD 1k C11
2k2 2125 100n 220n
22k
47E
3134 3146
LW = 0V 560p
2108 2109 2 LW-OSC 0V
4k7
MW = 0,7V 3197 MW LW
82p 22p 5103 7124 5122 7122 LW = 0,7V
L BC848C BC848C MW = 0V 3125 L
3 4
3169 3137 3128 10k
1 LW 0E 10k 2k2 7109
2123 2 2158
BC858B
390p 100n
22k
0E
1 6 3177 3131
V
V
2122
0V
M 3n9 MW LW M
0V
MW LW
3188
0E
.....V FM mode stereo Signal path
only in RDS version (04121) 3178
0E
.....V FM FM
not in RDS version (04341)
3147
N .....V AM AM N
0E
AF
3104 217 04120 bl. 130 - 01 LEU0150
3104 217 04121/04341 bl. 130 - 01 ITCL/9851-9813
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
7A-5 7A-5
1102 E4 2107 B4 2128 B7 2136 F10 2144 D10 2160 D9 3120 C6 3132 D5 3143 F8 3153 F9 3163 E8 3176 C9 3188 F11 5111 B8 6106 D7 7110 C11 9108 F11 9121 C9
1103 B4 2108 B6 2129 B8 2137 D11 2145 F11 2161 D9 3123 D4 3134 D5 3144 G9 3154 B10 3164 B11 3177 E7 3192 C8 5112 B9 6107 A10 7122 E7 9111 B4 9123 C9
1110 F7 2109 B5 2130 E8 2138 D10 2147 F11 2162 B11 3124 D5 3137 F5 3145 E9 3155 B10 3165 C8 3178 A8 3197 B7 5114 C8 6120 C10 7124 F6 9114 D5 9125 C8
1121 G11 2120 E5 2131 E9 2139 D8 2148 D9 3103 G6 3125 B7 3138 C9 3146 A10 3158 F11 3167 E8 3181 C8 5102 B4 5115 F9 7101 D9 9100 E4 9115 B8 9126 B8
1124 G9 2122 D6 2132 E9 2140 E10 2150 E8 3104 F6 3128 E6 3139 E8 3147 G9 3159 F11 3169 C5 3183 D7 5103 B5 5121 D9 7103 F9 9101 D7 9116 F8
1126 F10 2123 E6 2133 E10 2141 D10 2151 E9 3107 F7 3129 D6 3140 G8 3150 B11 3160 F11 3171 C11 3184 D7 5107 E10 5122 D7 7104 C5 9102 C10 9118 F10
2102 F7 2125 F6 2134 F10 2142 D9 2152 E9 3108 B6 3130 D6 3141 F9 3151 B10 3161 F11 3172 E7 3185 D7 5109 C7 5123 D5 7105 A6 9104 D6 9119 F7
2106 B5 2127 E9 2135 F11 2143 B10 2158 C10 3109 A7 3131 B6 3142 F10 3152 F9 3162 C9 3173 E7 3186 F8 5110 D9 6105 C4 7109 B6 9107 E11 9120 C10
1 2 3 4 5 6 7 8 9 10 11 12 13
V
TUNER 95 Copper side view VDD
FM = 6V
0V
AM = 7V AM FM
A A
7105 3109 3178 6107 3146
3150
5103
9111 2109
c b e +9,6V
3131 3125
5102
9115
9126
2108 3154 2143
1103 3197 3155 2162
2129
e b 5112
2128
B 7109 3151 B
2 e b
3108 c
1 c b e 3164
2107 2106 5111 7110 c
9121
9123
7104
3169 3165 6120 FM = 12V
1 8 3138 9102 AM = <0,5V
6105 2158
9125
C 4 5 5114 9120 C
3181 3176
3120 3171
5109 3192
3162 VDD
9101
3129 5110 2161 FM = 6V
VT 3132 2148
3130 34 AM = 7V
+1,4V +1,4V 2144
6 6106 2138
2139 5121 2137
3124 9104
3123 3185
2160
D 3134 5123 2141 D
2122 3183 23 2142
5122
9114 7101
3184 1 2151
3139 2140
1102
2120 3172 +9,6V 9107
2130
c 2152 5107 2136
7122 12
LW = 0,7V b
e 3173 3163
E MW = 0V 3128 3177 2131 E
2123 2150 3167 2133
3145
9100 2127 2132
+8V
2147
2134
2145
c 5115
2102 3143 2135
LW = 0V 2125 7124 9116
b e 3142
3161
3186
3158
3159
3160
9118
MW = 0,7V 3137 9119 9108
3104 3141
1110 c
3152
3107 +FM
F +12V 7103 3153
3188 F
1 8 1126
b e
4 1
1124
3103 3140
+12V 3144 4 1 6 1
IC 6105 3147 1121
VCC +12V
RIGHT
LEFT
STEREO
CLOCK
DATA
ENABLE
MPX
3104 213 34853
G G
e b
only in RDS version (04121)
1 not in RDS version (04341)
H H
TUNER 95 bis c LEU0149
3104 217 04121/04341 bl. 110 - 01 9813
1 2 3 4 5 6 7 8 9 10 11 12 13
7A-6 7A-6
ELECTRICAL PARTSLIST TUNER 95
–––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– ELECTRICAL PARTSLIST TUNER 95
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
MISCELLANEOUS RESISTORS INTEGRATED CIRCUITS
––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
1102 4822 267 10283 SOCKET COAX, IEC 75Ω 3140 © 4822 051 20331 330Ω 5% 0,1W 7101 4822 209 90315 TEA5762H/V1, RADIO IC
1103 4822 265 31184 JST CONNECTOR 2 POLE 3141 © 4822 117 11148 56kΩ 1% 0,1W
1110 4822 210 10492 FRONTEND ASSY /02/08 3142 4822 100 11163 100kΩ TRIMPOT LIN.
1110 4822 210 10739 FM-FRONTEND FE415-G23 3143 © 4822 051 20223 22kΩ 5% 0,1W
3144 © 4822 051 10102 1kΩ 2% 0,25W
CAPACITORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– 3145 © 4822 117 11449 2,2kΩ 1% 0,1W
2102 4822 124 80791 470µF 20% 16V 3146 © 4822 051 20479 47Ω 5% 0,1W
2106 4822 125 60102 30pF TRIMCAP 3150 © 4822 051 20472 4,7kΩ 5% 0,1W
2107 4822 121 51252 470nF 5% 63V 3151 © 4822 051 20683 68kΩ 5% 0,1W
2108 © 4822 126 13695 82pF 1% 63V 3152 © 4822 051 20471 470Ω 5% 0,1W
2109 © 5322 122 32658 22pF 5% 50V
3153 © 4822 051 20471 470Ω 5% 0,1W
2120 © 5322 122 32659 33pF 5% 50V 3154 4822 116 83868 150Ω 5% 0,5W
2122 © 5322 126 10465 3,9nF 10% 63V 3155 4822 116 52219 330Ω 5% 0,5W
2123 4822 121 10766 390pF 1% 630V 3158 4822 116 83883 470Ω 5% 0,16W
2125 4822 121 10578 560pF 1% 630V 3159 4822 116 83883 470Ω 5% 0,16W
2127 © 4822 122 32927 220nF 10% 63V
3160 4822 116 83883 470Ω 5% 0,16W
2128 4822 124 41579 10µF 20% 50V 3161 4822 116 83883 470Ω 5% 0,16W
2129 4822 124 40242 1µF 20% 63V 3162 © 4822 117 13579 220kΩ 1% 0.1W
2130 4822 126 11585 22nF 20% 50V 3163 © 4822 051 10008 CHIP JUMPER 1206
2131 © 4822 122 33325 470nF 20% 50V 3164 4822 052 10478 4,7Ω 5% NFR
2132 © 4822 122 33325 470nF 20% 50V
3167 4822 116 83872 220Ω 5% 0,5W
2133 4822 124 40242 1µF 20% 63V 3169 © 4822 051 20008 CHIP JUMPER 0805
2134 © 4822 126 13188 15nF 5% 63V 3172 © 4822 051 10008 CHIP JUMPER 1206
2135 © 4822 122 32927 220nF 10% 63V 3181 © 4822 051 10008 CHIP JUMPER 1206
2136 © 4822 126 13188 15nF 5% 63V 3183 © 4822 051 10008 CHIP JUMPER 1206
2137 © 4822 122 32927 220nF 10% 63V
3184 © 4822 051 10008 CHIP JUMPER 1206
2138 4822 124 41576 2,2µF 20% 50V 3185 © 4822 051 10008 CHIP JUMPER 1206
2140 4822 121 51252 470nF 5% 63V 3186 © 4822 051 10102 1kΩ 2% 0,25W
2141 © 4822 122 31947 100nF 20% 50V 3188 © 4822 051 10008 CHIP JUMPER 1206
2142 © 4822 122 31947 100nF 20% 50V 3191 © 4822 117 10353 150Ω 5% 0,1W
2143 © 4822 122 32927 220nF 10% 63V
3192 © 4822 051 20008 CHIP JUMPER 0805
2144 4822 124 40242 1µF 20% 63V 3197 © 4822 051 20472 4,7kΩ 5% 0,1W
2145 © 4822 122 33575 220pF 5% 50V
2147 © 4822 122 33575 220pF 5% 50V COILS
2148 © 4822 122 33575 220pF 5% 50V –––––––––––––––––––––––––––––––––––––––––––––––––––––
2150 © 4822 122 31947 100nF 20% 50V 5102 4822 157 71634 RF-COIL MW
5103 4822 157 71635 RF-COIL LW
2158 © 4822 122 31947 100nF 20% 50V 5109 4822 157 71639 FM-IF FILTER 10,7MHz
2160 © 4822 122 32139 12pF 5% 63V 5110 4822 242 70665 FM-IF FILTER 10,7MHz
2161 © 5322 122 34123 1nF 10% 50V 5111 4822 158 60511 AM-IF FILTER 450kHz
2162 4822 124 81151 22µF 20% 50V
5112 4822 157 70302 AM-IF FILTER 450kHz
RESISTORS 5114 4822 157 70302 AM-IF FILTER 450kHz
––––––––––––––––––––––––––––––––––––––––––––––––––––– 5115 4822 157 71636 ANTI BIRDY FILTER
3090 4822 116 52206 120Ω 5% 0,5W 5120 4822 242 10251 CER. DISCR. 10.7MG61KA-TF21
3091 4822 116 52206 120Ω 5% 0,5W 5121 4822 242 10261 QUARTZ 75kHz
3092 4822 116 52219 330Ω 5% 0,5W
3102 © 4822 117 13579 220kΩ 1% 0.1W 5122 4822 157 60517 RF-COIL AM
3103 © 4822 051 20184 180kΩ 5% 0,1W 5123 4822 157 60517 RF-COIL AM
3104 © 4822 051 10102 1kΩ 2% 0,25W DIODES
3107 © 4822 051 20829 82Ω 5% 0,1W –––––––––––––––––––––––––––––––––––––––––––––––––––––
3108 © 4822 117 11449 2,2kΩ 1% 0,1W 6105 © 4822 130 83075 HN1V02H
3109 © 4822 117 11449 2,2kΩ 1% 0,1W 6106 4822 130 30621 1N4148
3120 © 4822 051 20008 CHIP JUMPER 0805 6107 4822 130 34488 BZX79-C11
6120 4822 130 30621 1N4148
3123 © 4822 051 10008 CHIP JUMPER 1206
3124 © 4822 051 10008 CHIP JUMPER 1206 TRANSISTORS
3125 4822 116 83864 10kΩ 5% 0,5W –––––––––––––––––––––––––––––––––––––––––––––––––––––
3128 4822 116 52256 2,2kΩ 5% 0,16W 7103 © 4822 130 42513 BC858C
3129 © 4822 051 20008 CHIP JUMPER 0805 7104 5322 130 44779 BC338-40
7105 5322 130 44779 BC338-40
3130 © 4822 051 10008 CHIP JUMPER 1206 7109 © 5322 130 41983 BC858B
3131 © 4822 051 10008 CHIP JUMPER 1206 7110 © 5322 130 41983 BC858B
3132 © 4822 051 20008 CHIP JUMPER 0805
3134 © 4822 051 20223 22kΩ 5% 0,1W 7122 © 5322 130 42136 BC848C
3137 © 4822 117 10833 10kΩ 1% 0,1W 7124 © 5322 130 42136 BC848C
7B-1
Tuner ECO 5
(3 Band Tuner)
TABLE OF CONTENTS
Adjustment table .............................................................7B-2
Blockdiagram ..................................................................7B-3
Circuit Diagram ...............................................................7B-4
Component Layout..........................................................7B-5
Electrical Partslist ............................................................7B-6
7B-2
TUNER ADJUSTMENT TABLE ( ECO5 FM/MW- and FM/MW/LW - versions with AM-frame aerial )
Waverange Input frequency Input Tuned to Adjust Output Scope/Voltmeter
VARICAP ALIGNMENT
FM 108MHz 5130 8V ±0.2V
87.5 - 108MHz
(65.81 - 74, 87.5 - 108MHz) 87.5MHz check 4.3V ±0.5V
(65.81MHz) (1.2V ±0.5V)
MW 1700kHz 5123 8V ±0.2V
FM/AM-version, 10kHz grid
530 - 1700kHz 530kHz check 1.1V ±0.4V
FM/MW-version, 9kHz grid 1602kHz 5123 6.9V ±0.2V
531 - 1602kHz 531kHz check 1 1.1V ±0.4V
LW 279kHz 5122 8V ±0.2V
153 - 279kHz 153kHz check 1.1V ±0.4V
MW 1602kHz 5123 8V ±0.2V
FM/MW/LW- version, 9kHz grid
531 - 1602kHz 531kHz check 1.1V ±0.4V
FM IF
IC 7101 21
10.7MHz, 50mV
FM F shortcircuit 5119 2 0 ± 3 mV DC
continuous wave to block AFC
2141
FM RF
FM 108MHz A 108MHz 2155
87.5 - 108MHz 4 MAX
(65.81 - 74, 87.5 - 108MHz) 87.5MHz mod=1kHz 87.5MHz 5131
(65.81MHz) ∆f=±22.5kHz (65.81MHz)
VCO
98MHz, 1mV
FM A 98MHz 3142 3 152kHz ±1kHz 1)
continuous wave
AM IF
IC 7101 36
100nF
C 5111
220R
max.
MW 450kHz 4
∆f=±15kHz IC 7101 40
100nF 5112
connect pin 6 of VRF = 3mV
220R
see fo
IC 7101 (AM Osc.) remark 2) symmetric
with short wire to
AM AFC ground (pin 4) C
MW
5114 2 0 ± 2 mV DC
continuous wave
VRF = 10mV
AM RF 3)
MW 4) 1494kHz 1494kHz 2106
FM/MW/LW- and FM/MW-version B
( 9kHz grid)
531 - 1602kHz 558kHz 558kHz 5102
max.
LW 198kHz 198kHz 5103 4
MW 1500kHz ∆f = ±30kHz 1500kHz 2106 fo
symmetric
FM/AM-version, 10kHz grid VRF as low as
530 - 1700kHz 560kHz possible 560kHz 5102
ECO5, discr. coil, 090797
Use service test program. By selecting the TUNER TEST test frequencies will be stored as preset frequencies automatically.
1) If sensitivity of frequency counter is too low adjust to max. channel separation 2) RC network serves for damping the IF-filter while adjusting the other one.
(input signal: stereo left 90% + 9%, adjust output on right channel to minimum)
3) For AM RF adjustments the original frame antenna has to be used ! 4) MW has to be aligned before LW.
Repeat
7B-3 7B-3
BLOCK DIAGRAM TUNER ECO5
TUNER BOARD
ECO 5 systems
buffer ampl.
VStabA VStabB Vcc1
Discriminator 5 Vdd
RDS Vcc2
FM-RF
(MPX)
1101 VLoop
VCO 1124
(1102) 10,7 MHz 10,7 MHz 10,7 MHz LF filter Vcc
4
4 right
A FM 3 39 37 35 33 18 10 11 9
right 15
43 FM FM Stereo left 14 4
FM IF1 IF2 left 1
frontend Mixer Det. Decoder
stereo
FM-Osc. 24 Version
VLoop
5 FM Pre- RADIO IC 3
Osc. scaler TEA 5757T 1126 1121
Multi- stereo
AM-Osc. plexer clock 27
4 6
clock
6 AM
AM-FRAME AERIAL VLoop Osc. data 28 data
1103 AM-RF
2 enable 29 enable
AM AM AM IF AM CONTROL 1
Frontend Mixer Det. RDS
(MPX)
C
VLoop 1
AGC P1 31
programmable
output ports P0 30
B 1 8 Charge
VLoop pump
VStabA 38
AFC Reference MW/LW
34 Oscillator
VStabB
AFC +
AFC -
23 7 22 40 41 36 44 32 19 20 25
AM-RF,
AM-Osc.
Vdd Vcc1 Vcc2 75kHz
450kHz 450kHz 450kHz
2
VStabA VStabB VStabB
ECO5 sys., 240698
7B-4 7B-4
TUNER ADJUSTMENT TABLE ( ECO5 FM/MW- and FM/MW/LW - versions with AM-frame aerial )
Waverange Input frequency Input Tuned to Adjust Output Scope/Voltmeter
VARICAP ALIGNMENT
FM 108MHz 5130 8V ±0.2V
87.5 - 108MHz
(65.81 - 74, 87.5 - 108MHz) 87.5MHz check 4.3V ±0.5V
(65.81MHz) (1.2V ±0.5V)
MW 1700kHz 5123 8V ±0.2V
FM/AM-version, 10kHz grid
530 - 1700kHz 530kHz check 1.1V ±0.4V
FM/MW-version, 9kHz grid 1602kHz 5123 6.9V ±0.2V
531 - 1602kHz 531kHz check 1 1.1V ±0.4V
LW 279kHz 5122 8V ±0.2V
153 - 279kHz 153kHz check 1.1V ±0.4V
MW 1602kHz 5123 8V ±0.2V
FM/MW/LW- version, 9kHz grid
531 - 1602kHz 531kHz check 1.1V ±0.4V
FM IF
IC 7101 21
10.7MHz, 50mV
FM F shortcircuit 5119 2 0 ± 3 mV DC
continuous wave to block AFC
2141
FM RF
FM 108MHz A 108MHz 2155
87.5 - 108MHz 4 MAX
(65.81 - 74, 87.5 - 108MHz) 87.5MHz mod=1kHz 87.5MHz 5131
(65.81MHz) ∆f=±22.5kHz (65.81MHz)
VCO
98MHz, 1mV
FM A 98MHz 3142 3 152kHz ±1kHz 1)
continuous wave
AM IF
IC 7101 36
100nF
C 5111
220R
max.
MW 450kHz 4
∆f=±15kHz IC 7101 40
100nF 5112
connect pin 6 of VRF = 3mV
220R
see fo
IC 7101 (AM Osc.) remark 2) symmetric
with short wire to
AM AFC ground (pin 4) C
MW
5114 2 0 ± 2 mV DC
continuous wave
VRF = 10mV
AM RF 3)
MW 4) 1494kHz 1494kHz 2106
FM/MW/LW- and FM/MW-version B
( 9kHz grid)
531 - 1602kHz 558kHz 558kHz 5102
max.
LW 198kHz 198kHz 5103 4
MW 1500kHz ∆f = ±30kHz 1500kHz 2106 fo
7B-5 7B-5
2101 C4 2120 B4 2145 C1 2160 C4 3108 A4 3122 B3 3144 C2 3178 A1 4110 A3 4160 A1 7109 A3
2102 C4 2122 B3 2146 C1 2161 A3 3109 A4 3123 A3 3145 C2 3179 A1 4111 C1 4161 A1 7111 A1
1101 A1 2106 C2 2137 C5 3149 C5 3173 A5 5114 C4 5130 A3 7104 C2 9117 B2 9129 B3 2103 C3 2124 A5 2147 C1 2163 A2 3111 A3 3125 A3 3146 A1 3180 A4 4120 C2 4162 C1 7120 B4
1102 A1 2107 C2 2138 A5 3152 A5 5102 C2 5115 A4 5131 A3 7105 C3 9118 B4 9130 C3 2108 A4 2126 C2 2149 B2 2164 B1 3112 A3 3126 B3 3148 A1 3181 C3 4150 B2 4163 C1 7121 B3
1103 C1 2110 C2 2144 B5 3154 C5 5103 C2 5116 A4 6101 A2 7107 B3 9119 C4 9131 A5 2109 A4 2127 C2 2150 B2 2165 B3 3113 A2 3127 B3 3153 C2 4101 A4 4151 B3 6105 A4 7122 B4
1104 B1 2115 C1 2148 B4 3157 B5 5104 C2 5119 B5 6102 A1 7119 C4 9120 B4 9133 C3 2111 A2 2131 C2 2151 C2 2166 B2 3114 A3 3128 B3 3155 A2 4102 A4 4152 B3 6110 A4 7123 B4
1105 A1 2123 A2 2155 A3 3158 A5 5105 B2 5120 B4 6103 A1 9100 A2 9121 A2 9134 B3 2112 B5 2132 C1 2152 C3 2167 B2 3115 A3 3133 B4 3156 A1 4103 C2 4153 B4 6111 B4 7124 C4
1119 C5 2125 A2 2162 A2 3159 A5 5106 B2 5121 B4 6104 A2 9101 B3 9122 C3 9136 A5 2113 A4 2134 C1 2153 C3 2168 B1 3116 A3 3134 B4 3167 C2 4104 A2 4154 C3 6130 C2 7125 A1
1120 A5 2128 C3 3105 B3 3160 A5 5109 B4 5122 B3 6106 B3 9105 B2 9123 B1 9137 A5 2114 A4 2136 B1 2154 C3 3101 C3 3117 B4 3136 B4 3168 B3 4105 B3 4155 A4 6131 C3
1130 B5 2129 C4 3110 A2 3161 A5 5110 B4 5123 B2 6107 C5 9111 C2 9124 C4 2116 B3 2139 B2 2156 C4 3102 C3 3118 B3 3137 B4 3169 B2 4106 B4 4156 A2 7101 B2
1131 B5 2130 A4 3132 B3 3170 C5 5111 C3 5124 B2 6109 C2 9113 B2 9125 A3 2117 A3 2141 B1 2157 B4 3103 C3 3119 A3 3140 B2 3175 A2 4107 C4 4157 B3 7103 C2
2104 A2 2133 A4 3142 A4 3171 C5 5112 C4 5126 B3 6120 C4 9114 B2 9126 B5 2118 B4 2142 B1 2158 B4 3104 B3 3120 B4 3141 C2 3176 C2 4108 B4 4158 C2 7106 A3
2105 A1 2135 B5 3147 B5 3172 C5 5113 B3 5127 B4 7102 A3 9115 B3 9128 A2 2119 B4 2143 A1 2159 C2 3106 C4 3121 A3 3143 C2 3177 A1 4109 A3 4159 A2 7108 A3
1 2 3 4 5 5 4 3 2 1
ECO 5 TUNER BOARD / component side view ECO 5 TUNER BOARD / copper side view
STEREO
ENABLE
ENABLE
CLOCK
RIGHT
1 F C 4 E
VCC2
DATA
DATA
LEFT
GND
GND
MPX
VCC
6103
6104
9136
1122
1124
1127
1123
1126
1125
1120
1121
3103 303 33962 98-05-14
3146
A 3110 4156
5115
5116
5130
4102
5131
3
3109
3179
3148
9137
7102 1 1 1
4110
2108
3125
2163
4101
2161
A A A A
4160
4161
E
3113
9100 2162 FM-OSC 3175
AM FRAME
3142
3108 2109
9121
3158
3159
FM-RF
3116
3114
4104 7125
3173
3180
3160
3161
3152
3155 7111
6102
2104 7106 7109 B
2143
VCO
3119
A
9131
9125
6101 A 4109 4159 3178
9128 C B 3111
1
FM 75 OHM
4155
2155
3112
C
9119
3115
2114
3123
2123 2130 2124 1 7108 2111
2133 2138
3177
FM-RF 1 8
6105
2105
FM
1105
6110
2113
E
2117
3156
2125 9126
D 3121
3117
5122 4 4 5
9129
5
5119 3133
3157 3120 2116
LW-OSC
49
4105
1102 DISCRIMI- 3122
21
5120
2148
FM 300 OHM C 5123 SW 2157
11
3126
4108
NATOR 7120
34
C
2112
67
9123
MW-OSC AM-IF
0
9134 2119 3118 2142
15
21
2118
4153 4106
9115
B 2144
34
3104 2
GND 3128 3169
4151
A C
2164 2141
9114
B B B 2 B
9113
3105
AM - stereo Module
2165 4152
3132 21 +FM
A 6111
9114
C
2166
7122B 7121
3168
5124 51 7101
3134
Connector for
1101 6106 R-FM
23
1
9117
3147
SW SW-OSC L-FM C
2120
C
4150
43
11
1
5126
3127
2122
5113
5127
SW 5106 5105 3171 2135 L out
D
2158
6120
2139 3140 2168
3170
12
9101 3137 3136 7123
4157
4120
5109
1104 R out 2136
9105
5 5104 7107 5110 2160
4 5111 VCOkill
2159
2115
2145
SW-ANT SW-RF 2156
E 7124
2105
3181
B STSIG
2154
9120
9118
FM
2131
2132
5114
Voltage multiplier board
3145
1 2107 2153 2127
SW-RF AM-IF1 2137 STEREO
A
3172
2106 AM-AFC 3102 C 6130 4111
4107 2126
2134
3153
V+ 2101
9119
6109 C
B 11
2152
3106
A6131 A
2146
2147
7119
MW-RF 9122 4103
9130
EMARF MA
1131 1130 2151
1
3103
7104 B 5112 3149 7103 3141
5102 2128 1119 6101 4163
3176
2110 AM-IF2 VCC2 3143
MW-RF 5103 SEARCH
C 2129
C C E
C
3144
1103 LW-RF GND SENS. 2102
AM FRAME AERIAL
3154
LW-RF
2103
3167
7105 VCC 4154
3
1
9111 9133 9124
4162
4158
3101
41-50-89 26933 303 3013 6107
This assembly drawing shows a summary 2SA... BC... C C This assembly drawing shows a summary
of all possible versions.
For components used in a specific version marked components to be assembled
B E 41.. Chip jumper
(not all items shown
1 F C 5 4 of all possible versions.
C B For components used in a specific version
see schematic diagram respectively partslist. as service solution for Local/DX - switching in schematic diagram) marked components to be assembled
E C A B E see schematic diagram respectively partslist.
ECO5 3396 stage .2, 250698
as service solution for Local/DX - switching ECO5 3396 stage .2, 250698
1 2 3 4 5 5 4 3 2 1
7B-6 7B-6
ELECTRICAL PARTSLIST TUNER ECO5
–––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– ELECTRICAL PARTSLIST TUNER ECO5
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
MISCELLANEOUS RESISTORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
1101 4822 267 31505 SOCKET 2P CLICKFIT 3142 4822 100 12159 TRIMPOT. 100kΩ
1102 4822 267 10283 SOCKET COAX, IEC 75Ω 3145 © 4822 117 11449 2,2kΩ 1% 0,1W
1103 4822 265 31184 JST CONNECTOR 2 POLE 3146 © 4822 051 20229 22Ω 5% 0,1W
3152 4822 116 83883 470Ω 5% 0,16W
CAPACITORS 3153 © 4822 051 20471 470Ω 5% 0,1W
–––––––––––––––––––––––––––––––––––––––––––––––––––––
2101 © 4822 126 13692 47pF 1% 63V 3154 4822 116 83868 150Ω 5% 0,5W
2101 © 5322 122 32531 100pF 5% 50V 3155 © 4822 051 20471 470Ω 5% 0,1W
2102 © 4822 122 33177 10nF 20% 50V 3156 © 4822 117 10837 100kΩ 1% 0,1W
2103 © 5322 122 31647 1nF 10% 63V 3158 4822 116 83883 470Ω 5% 0,16W
2104 4822 122 33195 100pF 10% 50V 3159 4822 116 83883 470Ω 5% 0,16W
2106 4822 125 60101 3-11pF TRIMCAP 3160 4822 116 83883 470Ω 5% 0,16W
2107 4822 121 51319 1µF 20% 50V 3161 4822 116 83883 470Ω 5% 0,16W
2120 © 5322 122 32658 22pF 5% 50V 3167 © 4822 117 11503 220Ω 5% 0,1W
2125 4822 121 10673 560PF 1% 630V 3169 © 4822 051 20154 150kΩ 5% 0,1W
2126 © 5322 122 31863 330pF 5% 50V 3170 4822 116 52234 100kΩ 5% 0,5W
2127 © 4822 126 13473 220nF 20% 50V 3171 4822 116 52219 330Ω 5% 0,5W
2128 4822 124 40248 10µF 20% 63V 4101 © 4822 051 20008 CHIP JUMPER 0805
2129 4822 124 41584 100µF 20% 10V 4102 © 4822 051 20008 CHIP JUMPER 0805
2130 4822 126 11585 22nF 20% 50V 4103 © 4822 051 20008 CHIP JUMPER 0805
2131 © 4822 126 13482 470nF 20% 16V 4104 © 4822 051 20008 CHIP JUMPER 0805
2132 © 4822 126 13482 470nF 20% 16V 4105 © 4822 051 20008 CHIP JUMPER 0805
2133 4822 124 21913 1µF 20% 63V 4106 © 4822 051 20008 CHIP JUMPER 0805
2134 © 4822 126 13188 15nF 5% 63V 4108 © 4822 051 20008 CHIP JUMPER 0805
2134 © 5322 122 32654 22nF 10% 63V 4111 © 4822 051 20008 CHIP JUMPER 0805
2135 4822 124 40746 0,22µF 20% 63V 4120 © 4822 051 20008 CHIP JUMPER 0805
2136 © 4822 126 13188 15nF 5% 63V 4150 © 4822 051 20008 CHIP JUMPER 0805
2136 © 5322 122 32654 22nF 10% 63V 4152 © 4822 051 20008 CHIP JUMPER 0805
2137 4822 124 40746 0,22µF 20% 63V 4153 © 4822 051 20008 CHIP JUMPER 0805
2138 4822 124 22652 2,2µF 20% 50V 4154 © 4822 051 20008 CHIP JUMPER 0805
2139 © 4822 126 14236 15pF 5% 50V 4157 © 4822 051 20008 CHIP JUMPER 0805
2141 © 4822 126 13838 100nF 10% 50V 4158 © 4822 051 20008 CHIP JUMPER 0805
2142 © 4822 126 13838 100nF 10% 50V 4159 © 4822 051 20008 CHIP JUMPER 0805
2143 © 4822 126 13473 220nF 20% 50V
2144 4822 124 21913 1µF 20% 63V COILS
2145 © 4822 122 33575 220pF 5% 50V –––––––––––––––––––––––––––––––––––––––––––––––––––––
5102 4822 157 71634 RF-COIL MW
2146 © 4822 122 33575 220pF 5% 50V 5109 4822 242 70665 FM-IF FILTER 10,7MHz
2147 © 4822 122 33575 220pF 5% 50V 5110 4822 242 70665 FM-IF FILTER 10,7MHz
2148 4822 126 11585 22nF 20% 50V 5111 4822 158 60511 AM-IF FILTER 450kHz
2149 © 5322 122 32654 22nF 10% 63V 5112 4822 157 70302 AM-IF FILTER 450kHz
2150 © 4822 122 33496 100nF 10% 63V
5114 4822 157 70302 AM-IF FILTER 450kHz
2152 © 4822 126 12105 33nF 5% 63V 5119 4822 157 11443 DISCRIMINATOR COIL
2153 © 4822 126 13486 15pF 2% 63V 5121 4822 242 10261 QUARTZ 75kHz
2155 4822 125 60101 3-11pF TRIMCAP 5123 4822 157 60517 RF-COIL AM
2159 © 5322 122 32659 33pF 5% 50V 5130 4822 157 11843 RF COIL 1,5 TURNS
2160 © 5322 122 32654 22nF 10% 63V
5131 4822 157 11843 RF COIL 1,5 TURNS
2164 © 4822 126 13482 470nF 20% 16V
2165 © 4822 126 13838 100nF 10% 50V DIODES
2166 © 5322 122 31647 1nF 10% 63V –––––––––––––––––––––––––––––––––––––––––––––––––––––
2167 © 4822 122 33926 12pF 5% 50V 6103 4822 130 30621 1N4148
2168 © 4822 126 13695 82pF 1% 63V 6104 4822 130 30621 1N4148
6105 © 4822 130 83075 HN1V02H
RESISTORS 6106 4822 130 30621 1N4148
––––––––––––––––––––––––––––––––––––––––––––––––––––– 6107 4822 130 34488 BZX79-C11
3101 © 4822 051 20333 33kΩ 5% 0,1W
3102 © 4822 117 10837 100kΩ 1% 0,1W 6120 4822 130 30621 1N4148
3103 © 4822 117 10965 18kΩ 2% 0,1W 6130 © 4822 130 82833 1SV228
3104 © 4822 117 11448 180Ω 10% 0,1W 6131 © 4822 130 82833 1SV228
3105 4822 116 83872 220Ω 5% 0,5W
TRANSISTORS
3110 4822 116 52195 47Ω 5% 0,5W –––––––––––––––––––––––––––––––––––––––––––––––––––––
3120 © 4822 051 20008 CHIP JUMPER 0805 7102 4822 130 60093 2SA838B
3132 4822 116 52195 47Ω 5% 0,5W 7111 © 5322 130 42755 BC847C
3134 © 4822 051 20223 22kΩ 5% 0,1W
3141 © 4822 117 11148 56kΩ 1% 0,1W INTEGRATED CIRCUITS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7101 © 4822 209 90924 TEA5757H/V1, RADIO IC
8-1 8-1
1542 B1 1544 A3 2692 A2 2694 A3 5523 A3 5532 B2
1543 A2 2691 A2 2693 A3 2695 A2 5531 B2 9641 A3
1 2 3
2692
22n 2u2
A 2691 2694 A
100n 100n
1543
9
8
B B
5532
5531
4 1
2u2
2u2
5 2
FE-BT-VK-N
1542 6
DPL_SW 1 3
TC38
Rhp 2
R 3
GNDa 4
C L 5
C
Lhp 6
# : Provision.
Note : Some values may varies, see respective parts list for correct value.
1 2 3
Headphone Board
Componentside view Copperside view
2692
2694
2693
4716
AF7 Board 4715
2695
2691
08558 012 9328 8239 210 85580
TABLE OF CONTENTS
Circuit Diagram Headphone Board....................................8-1
Component Layout Headphone Board ..............................8-1
Circuit Diagram AF7 Bord..................................................8-2
Component Layout AF7 Bord ............................................8-4
Electrical Partslist ..............................................................8-6
8-2 8-2
Blockdiagram AF7 Board
+12A
AF7 BOARD
SA_IN
1526 7512
1527
LINE SUB-
OUT WOOFER
OUT
MUTE MUTE_SW
Line Out MUTE LO
1525
AUX
BassALC on/off
1521
CDR-Module CDR WRITE ALC EN
for details see
separate blockdiagram 7511 Headphone
Chapter 11 TDA7437 7515
0042 1542 Board
CDR READ Headphone
Aux Incredible amplifier L 1543
p
CDR Stereo
Rear
0021
Tuner
Front
3CDC
TUNER TUNER R
for details see
separate blockdiagram
Chapter 7
I2C Decoder I2C Bus
1533
7551
MUTE LO
3CDC PORE 2 SET MUTE
I C SHIFT REGISTER
ALC EN
STDBY M62320FP
AMP_ON
+CD
AB
CD ON
+12
0027
+CD +5V6 L
CD CONTROL R
AMP_ON
3CDC Module
for details see Power Board
separate blockdiagram +12A for details see
Chapter 10 separate blockdiagram
Chapter 9
PORE +12M
+5V6
CD DIGITALOUT
+CDR_ON
I2C_DATA
I2C_CLK
STDBY
SA_IN
+5V6
NTC
NTC
CD TEXT
PW_DN AB
F2
F1
-30V
-30V
F2
F1
1538 1537 1535 0030
Digital Switching
separate blockdiagram
separate blockdiagram
separate blockdiagram
Power Board
Front Board
Front Board
for details see
for details see
for details see
Chapter 6
Chapter 6
Chapter 9
Board
8-3 8-3
2501 E2 2545 F9 2613 E7 2662 F9 2734 D1 2783 B1 2873 D6 3534 D4 3560 F8 3588 C5 3617 E7 3645 E3 3675 F9 3716 D2 3744 A4 4517 D6 4541 C6 4565 E4 4589 D3 4613 F4 7515 F4 7712 B3
2511 C6 2547 E4 2614 F7 2663 F9 2736 B2 2784 C2 2874 E6 3535 E4 3561 C3 3589 D5 3618 F7 3646 F3 3676 F9 3717 E2 3748 C2 4518 D7 4542 D6 4566 D1 4590 B2 4614 E4 7521 E4 7713 A4
2512 D7 2548 E4 2615 F7 2668 D9 2737 D1 2785 D1 2875 D8 3536 D4 3562 C3 3590 C5 3619 E7 3647 F3 3677 E9 3718 E2 3751 C4 4519 E2 4543 D6 4567 E4 4591 C5 4615 F6 7522 E4 7714 B4
2515 D6 2551 A5 2616 F7 2669 D9 2738 D1 2786 D1 2877 B3 3537 E4 3563 E5 3591 D5 3620 F7 3648 F3 3678 E8 3719 D2 3753 C3 4520 E2 4544 D8 4568 F3 4592 E2 4616 B5 7523 D5 7715 C1
2516 D7 2553 A5 2617 E7 2670 D7 2739 D1 2787 D1 3511 E6 3538 D4 3564 C7 3592 C5 3621 E7 3649 B5 3679 E9 3720 D2 3754 B1 4521 B9 4545 D7 4569 F3 4593 E2 4617 B5 7524 C5 7716 C2
2517 D6 2577 D7 2618 F7 2671 D6 2740 D1 2788 D1 3512 E6 3540 C6 3565 D6 3594 F4 3622 F7 3650 B5 3680 E8 3721 D2 3755 B3 4522 B8 4546 E9 4570 F3 4594 B3 4618 B1 7526 B5 7717 C3
2519 D6 2578 D7 2623 D6 2672 E6 2741 C1 2789 C2 3515 D8 3541 E4 3566 E6 3595 F8 3623 F7 3651 B5 3682 E9 3722 D2 3756 C3 4523 D2 4547 E8 4571 F3 4595 B4 4619 B1 7527 B5
2520 D7 2579 E7 2624 D7 2673 D6 2746 C1 2791 A4 3516 D8 3542 D4 3569 C4 3596 F8 3624 F7 3652 B5 3683 D9 3723 D2 3757 B3 4524 B9 4548 E8 4572 F2 4596 C3 4620 E8 7528 F8
2523 D6 2580 E7 2625 E4 2674 E6 2747 C1 2792 B2 3517 B3 3543 E4 3570 D4 3597 E8 3625 E6 3653 E2 3684 D9 3724 D2 3758 C3 4525 D9 4549 D2 4573 F2 4597 C3 4621 D4 7529 C6
2524 D7 2581 D8 2626 D4 2677 D7 2753 C2 2793 B1 3518 B3 3544 D4 3571 D5 3598 F8 3626 F6 3656 B8 3686 E5 3725 D2 3759 B4 4526 D2 4550 E7 4574 F2 4598 B3 4622 E6 7531 F7
2525 D9 2595 D5 2633 E3 2678 F9 2754 B1 2794 B1 3519 A4 3545 B2 3572 C5 3601 F8 3627 F6 3657 B8 3687 E6 3726 D1 3760 C4 4527 C7 4551 F6 4575 E3 4599 D3 4623 E6 7532 F8
2526 E9 2596 C5 2634 F3 2681 B6 2755 B1 2795 B1 3520 A4 3546 B2 3573 D5 3602 E7 3628 F6 3658 B8 3688 B3 3727 D1 3761 B3 4528 D7 4552 E6 4576 E4 4600 D3 4624 C7 7533 E7
2527 D9 2597 D5 2635 F3 2682 B8 2759 C2 2796 B2 3521 C7 3547 A2 3574 C5 3603 F7 3629 E6 3659 B8 3689 B3 3728 D1 3762 C3 4529 D7 4553 E6 4577 D3 4601 B5 4625 C9 7534 F7
2528 E9 2598 C5 2636 F3 2715 D2 2760 C9 2797 B3 3522 D7 3548 A2 3575 E6 3604 F7 3631 E3 3660 B8 3690 E4 3729 D1 3763 E3 4530 B8 4554 D2 4578 D4 4602 A1 4626 B1 7535 E3
2529 E9 2601 F8 2637 E4 2716 D2 2761 B1 2798 C3 3523 D9 3549 B3 3577 E8 3605 E7 3633 F4 3662 F3 3691 F4 3732 C2 3764 D2 4531 B6 4555 E6 4579 B7 4603 A2 4627 E1 7536 F2
2530 B2 2602 E8 2638 F4 2719 D2 2763 C1 2800 D2 3524 E9 3550 C6 3578 E7 3606 F7 3634 F4 3663 F3 3692 C7 3733 C2 3765 C9 4532 B6 4556 E6 4580 B1 4604 B1 4628 D1 7537 B8
2531 E7 2603 F7 2639 F4 2720 D1 2764 A4 2865 B9 3525 D9 3551 A5 3580 E8 3609 E7 3635 E3 3665 B6 3693 C8 3734 C2 3774 B1 4533 D8 4557 E6 4581 E3 4605 D2 4629 B3 7538 B8
2535 D4 2604 F8 2649 E3 2721 D1 2768 D2 2866 B9 3526 E9 3552 A4 3581 E6 3610 F8 3636 F3 3666 B7 3694 C8 3735 C1 3775 C2 4534 B6 4558 E8 4582 E4 4606 B3 4630 B6 7539 B8
2536 D4 2605 E7 2650 F2 2722 D1 2775 B3 2867 B9 3527 E9 3553 A5 3582 E6 3611 F8 3637 E3 3667 D6 3696 B6 3736 D1 4511 D6 4535 D9 4559 F8 4583 E4 4607 B4 5512 E3 7541 F9
2537 D4 2606 F7 2651 B5 2723 D1 2776 C3 2868 E8 3528 F9 3554 B5 3583 D6 3612 F7 3638 F3 3668 D7 3711 E3 3738 C1 4512 C7 4536 E9 4560 D8 4584 A2 4608 B2 5513 A2 7542 E9
2538 D4 2607 E7 2652 B5 2724 D1 2777 B4 2869 D5 3529 E4 3555 B5 3584 E6 3613 F7 3639 E4 3671 F8 3712 D2 3740 B4 4513 E8 4537 E7 4561 F8 4585 D4 4609 B4 5713 D2 7543 E9
2539 D3 2608 F7 2656 B7 2725 D1 2778 C4 2870 E6 3530 E4 3556 B5 3585 D5 3614 F7 3640 F4 3672 F8 3713 E2 3741 A4 4514 E9 4538 C6 4562 D7 4586 D4 4610 B6 7511 D7 7551 B7
2543 F9 2611 F7 2657 B7 2726 D1 2781 A5 2871 D6 3531 E4 3557 A5 3586 C5 3615 F7 3642 F3 3673 F8 3714 D2 3742 B4 4515 E1 4539 F9 4563 F5 4587 D4 4611 A2 7512 D4 7553 C8
2544 F9 2612 F7 2658 E1 2733 D1 2782 C1 2872 E6 3532 D4 3559 E8 3587 D5 3616 F7 3643 F3 3674 F9 3715 D2 3743 A4 4516 F3 4540 D5 4564 F4 4588 D4 4612 B3 7513 D5 7711 C1
AF7 Board copperside view
This assembly drawing shows a summary
of all possible versions.
For components used in a specific version
see schematic diagram respectively partslist.
AF7 Board Layout stage .1 1999 12 21
8-4 8-4
1 2 3 4 5 6 7 8 9 10 11 12 13 14
4,1V 3587
Circuit Diagram AF7 Board Bass ALC Circuit
BC847B
7523 150K
ALC
4,1V
A +8,5V
To and from CDR Module
1521 3585
5 3 4,2V
CDR_PB_L NJM4560M 8
2549
3543 47K
4,2V 1
2595
470p
4
CDR_PB_R CDR_Rec_L 7513-A
2571
220n
2573
470n
3546 4u7 3K3
3563
3 4619 2 Incredible Surround Circuit
2K7
CDR_Rec_R
1K5 4,2V 2575
3548
2
18K
a a 3591
1 1u +IS
3535 22K
3571
3573
a
4K7
4K7
K_OUT 2597
B FE-BT-VK-N
3545 4618
CDR_Rec_L 120K
2537 220p
3607
1K5 a a
10K
3547
18K
2593 +IS
15p 3589
3537
33K
a 2607
a 2K2
NJM4560M 2 6V 47u
100n
3625
2541
1K
3541 3583
220R
680K
3575
3603
3621
1
2535
680p
2603
8K2
3n3
L_OLEFT 7512-A
1u 1K 6V 220R 9,3V
3 3531
2591
220u
5 3623
3525 4535 3521 2623 4 6V 1,1V 7531
2K2
3581
AUX_L
2K2
3 BC847B 47K
2533
2K7 18K 1u a
2523
2527
470p
4u7
a 0,6V
22p
3533
220K
3605
2605
470p
2869
C
3667
3K9
1u
BREF 2615
3609
4,8
10K
a a
4 100K
3565
4K7
YKC21-3440 a a
220p
2577
2579
2n2
1525-A a
1n
AUX_IN a a a
D a 3599
2625
220p
5 +8,5V 0,6V
2624 100n
2671
100n
2673
2873
2871
3526 3522 a
22n
4n7
22n
4536 a 100R
AUX_R
1 2868 2670 7533
2675
2563
220n
0u47
2K7 18K 1u 2524 a
2528
470p
22p
D BC847B
3668
3K9
a 100n a
2
8,3V
2529
100n
YKC21-3440 a a
1525-B a 7511
TDA7437 21 20 12 44 22 23 24 25 34 36 41
D
IN_L
a
MUXOUT_L
LOUD_L
MID_IN_L
MID_OUT_L
BASS_IN_L
BASS_OUT_L
FRONT_L
TREBLE_L
DGND DVDD
16 STEREO_1L
2609 3613 2611 3617
AUX_L DIGITAL SUPPLY
3513 2513 17 STEREO_2L 470n 5K6 1n8 8K2
CDC_L MUTE
3619
2613
8K2
1n
1K5 4u7 LEFT VOLUME VOLUME 2 3601 3615
3515
470R
32
2515
100p
TREBLE MIDDLE BASS REAR_L
18 STEREO_3L
CHANNEL LOUDNESS FADER
IN GAIN 3K3 5K6 +IS
3612
2601
a a
5K6
33n
SOURCE SELECTOR
15 STEREO_4L
3517 2521
40 +IS
I2C INTERFACE
D
3686 CDR_PB_L ADDR
3608
4517 14
10K
DIFF_L
3K3 4u7
3689
I2C_DATA
100p
2519
470R
3577 3697
3611
37
2602
a
5K6
33n
12K 13 DATA
E DIPMATE DIFF_GND_L
2608
To and from Tuner Board
470R 3578 470R 3698
3626
38
1K
21 CLK
3511 2511 2677 470R 470R I2C_CLK 100n
3622
TUNER_L LOGIC CONTROL
8K2
4 MONO
11
680K
3604
2604
3n3
1K a
MUTE CONTROL
100n 10n
3628
3 28 9,3V
a 8 STEREO_1R
SMEXT 3624
3512 2512 AUX_R 35 1,1V
2 7532
3514 2514 9 STEREO_2R
PAUSE 47K
1K 100n CDC_R 2517 BC847B 2616
1 19
+12A 3687 1K5 CSM 0,6V
470R
220K
3606
4u7
2606
470p
3516
a
2516
100p
100n 220p 4,8V
3610
a 10
10K
STEREO_3R
12K
0,6V
2618
7 STEREO_4R
IN GAIN
29 3602 a a a
F CDR_PB_R
3518 2522 RIGHT-
CHANNEL
VOLUME
LOUDNESS
TREBLE MIDDLE BASS
MUTE
VOLUME 2
FADER
REAR_R
3K3
7534
4518 6 DIFF_R BC847B
3K3 4u7 2610 3614 2612 3618
3688
100p
2520
470R
BASS_OUT_R
MID_OUT_R
MUXOUT_R
BASS_IN_R
5 39
TREBLE_R
DIFF_GND_R CREF
FRONT_R
MID_IN_R
REF 470n 5K6 1n8 8K2
3620
LOUD_R
2614
ANALOG SUPPLY
8K2
1n
2531
IN_R
2532
AGND AVDD
22n
47u
3616
TUNER_R a a
3 2 4 1 31 30 26 27 33 43 42 5K6
3576
2564
220n
2676
0u47
YKC21-3440 a
L_OLEFT 220R
2580
5 1526-A REF
1n
3527 0V 7525
12V
2874
2672
100n
2674
2872
a
G 8,5V BC547B
22n
22n
4n7
3 1K +8,5V +12A
0V
2543
BC847B
2n2
3597
3595
2560
0u47
33K
a
1M
7521
3580
2578
a
2K7
2n2
4 BC847B
3566
2870
a
4K7
Level
1u
LINE_OUT 0V 7522
2547 BREF K_OUT 9,1V
5 a
1N4148
BZX79-C9V1
6515
3528
2583
100u
6512
2582
100u
2581
0V
2n2
a 10p 4578 a
1 1K
3582
3529
2545
100n
2544
for FW-R7 only
2K2
2K2
2n2
7529 a a a a
2548
3596
100K
3530 0V BC857B 5V
3538
a
33K
2 +5V
a 1526-B a 7528
a 10p 2K2
YKC21-3440 3536 3586 3584 BC847B
2534
H
4u7
To and from Microphone Board
3550 4,2V 4,2V
5V 120K 47K 220R ALC
5 4,2V
DIPMATE 47K 2538 NJM4560M
3540
2592
220u
10K
26
2596
470p
2572
220n
2574
470n
3579 7
15p 6V 7513-B
3532
2K2
3 3,4V
+12A 6 4,2V 6 a
4R7 2576
2
K_OUT MUTE_LO 2542 3542 4 4,2V +8,5V +C
2536
680p
3598
7 a
4M7
7512-B 3592 1u
1
6V 6514
1u 1K
3572
3574
a 5 +12
4K7
4K7
+12M
NJM4560M 22K
6V 1N4003
3558
2M2
8
3590
2626
220p
2K2
2876
3559
470u
2598
2M2
100K
3534
a a 12V 12V
+12A +12M
I 3554 2550
220p
2539
100p
+12A 7524
3539
CDR_Rec_R
33R
150R
390R
M
3555
4,1V BC847B
2552
2594
47u
4u7
47u
BREF
3773
3560
2784
100p
4M7
3569
3642
a
4K7
4K7
4,1V
1K
a a
3629
SA_IN +12A 4,1V 3588 +IS +12A BREF HPREF
820R
330K
3553
3556
3544 ALC 6V 6V
2553
1K2
ALC_EN
15p
1,3V 150K
220u
2621
100u
3570
3643
2540
2641
100u
4K7
4K7
3K3 Bass ALC Circuit
3564
2K7
3519 3551 BC857B
CDR_Rec_L
33K 150K 2551 0,6V 7526 a a a a
0,6V a
J 3520 3552 100n
7527
BC847B
CDR_Rec_R
3557
82K
33K 150K
1 2 3 4 5 6 7 8 9 10 11 12 13 14
8-5 8-5
0021 E1 2617 C15 3552 J2 3651 E20
12 13 14 15 16 17 18 19 20 21 22 0026 H1 2618 F15 3553 J3 3652 E20
0027 D21 2619 B16 3554 I3 3655 D16
0030 H20 2620 F15 3555 I3 3656 D16
1521 A1 2621 J10 3556 J3 3657 D17
1525 C1 2623 C3 3557 J3 3658 D17
1526 H1 2624 C3 3558 I14 3660 D17
A 1527 F21 2625 C6 3559 I14 3661 C18
1528 C21 2626 I7 3560 I14 3662 D18
1533 G22 2631 C16 3563 B6 3663 D18
1535 G21 2632 E15 3564 J7 3667 C3
1537 H22 2633 C16 3565 C8 3668 C3
Incredible Surround Circuit 1538 G22 2634 E16 3566 G8 3671 E19
2216 F15 2635 B16 3569 I12 3672 E19
+IS
HPREF 2355 D17 2636 F16 3570 J12 3673 E19
a 2511 E2 2637 C17 3571 B10 3674 F18
2635
100p
NJM4556AM
B
3635
2512 E2 2638 E17 3572 I8 3675 F18
10K
3607
2513 D3 2639 F17 3573 B10 3676 G18
10K
+IS 2619 3631 6V 3
2647 2514 F3 2640 F17 3574 I9 3677 F18
2607 4u7 820R 3645 3647
2633
470p
1 2515 D4 2641 J13 3575 C13 3678 F19
2631 7515-A
100n 3633 47R 22u 47R
3625
2 2516 F4 2647 B18 3576 G13 3679 G19
1K
4
220R
680K
3603
3575
3621
2603
8K2
3n3
4u7 5K6 6V 2517 F11 2648 E18 3577 E11 3680 F19
9,3V
3623 3637 2637 -30V 2519 E4 2649 D18 3578 E11 3681 F20
220R
3627
1,1V 7531
HPREF 2520 F4 2650 D18 3579 H1 3682 G19
BC847B 47K 47K 47p
0,6V 3639 2521 E3 2651 E20 3580 G11 3683 F20
220K
3605
2605
470p
2615 C
3661
3609
4M7
4,8V
10K
6K8 FE-BT-VK-N 2522 F3 2652 E20 3581 C9 3684 F20
220p 2523 C4 2661 F18 3582 H9 3686 E1
2579
1528
1n
Lhp
2617
470p
a a a
Open if Headphone is connected
0V 1
MUTE CIRCUIT 2524 C4 2662 G18 3583 C9 3687 F1
To Headphone Board
0,6V 7538 7539
BC847B BC857B 3662 Left Channel
2649
100p
a 5,6V -8V L 2
+5V6
-8V
2527 C2 2663 F18 3584 H9 3688 F3
7533 0V 1K
BC847B
a Voltages measured 7535 a
3 2528 D2 2664 F18 3585 A10 3689 E3
a during normal operation 3657 3658
0V 0V
BC817-25 R 4 2531 G11 2665 F19 3586 H9 3690 F15
(not muted)
1K 5K6 Right Channel Rhp 2532 G11 2666 F19 3587 A10 3691 F16
3660
5
3655
7537 2533 C6 2668 F20 3588 J9 3692 J16
D
4K7
0,7V 6
SET_MUTE 3663 -8V 2534 H6 2669 G21 3589 B9 3693 I15
2650
100p
2655
4u7
2609 3613 2611 3617 10K
3656
2535 C6 2670 D10 3590 I8 3694 I16
10K
1K 27
1N4148
BC847B
6516
470n 5K6 1n8 8K2 7536 3649
BC817-25
9 2536 I6 2671 C8 3591 B9 3695 I15
3619
2613
L
8K2
0V
1n
3601 3615 47R 2537 B6 2672 G8 3592 I7 3696 J16
3651
8
2651
3K9
22n
3K3 5K6 +IS 3640 aa 2539 I6 2673 C8 3593 F15 3697 E11
3612
2601
a a MUTE_SW 7
5K6
33n
To Power amplifier
Level right
2540 J12 2674 G8 3594 F16 3698 E12
Level left
6K8 3650
2638 2648 6
+IS 3638 3646 3648 AMP_ON AMP_ON 2541 C5 2675 D7 3595 G14 3699 J17
3608
47R
3652
5
10K
2652
2542 I5 2676 G7 3596 H14 3773 I14
3K9
HPREF 47K
22n
I2C_DATA 47p 47R 22u 47R +12A
3611
+12A
2602
5K6
33n
220K
220K
3671
3672
698 2608 2632 3634
4
E 2543 G2 2677 E5 3597 G13 3929 J10
3626
6V
1K
a 2681 I16 3598 I14 4517 E5
6 3 2544 H2
70R I2C_CLK 100n 4u7 5K6 6V +12M
3622
+12M
2634
470p
8K2
7515-B 2545 H1 2682 H22 3599 C10 4518 F5
680K
3604
2604
2
3n3
3673
7
2K7
3632
220R
3628
9,3V 3624 M 2547 G4 2784 I14 3601 D12 4535 C2
6V 5 8 NJM4556AM 1
1,1V 7532 820R +5V6 +5V6 2548 H3 2868 C10 3602 F12 4536 C2
47K 3681
2636
100p
3636
10K
BC847B 2616 2640 DIPMATE 2549 A5 2869 C9 3603 C13 4578 H6
2620
4u7
2661
0,6V +12A
220K
1u
3606
2606
470p
2550 I5 2870 G9 3604 E13 4618 B2
2666
100u
470R
3680
3675
220p 4,8V 47u
3610
22R
5511
3K9
10K
2u2
HPREF 22n
2551 J2 2871 C8 3605 C13 4619 B2
3690
3691
0,6V
2618
470p
10R
10R
3602 a a a 2552 I3 2872 G8 3606 F13 4630 I20
2639 2663 2664 2665 1527 YKC21-3416 F 2553 J2 2873 C8 3607 B14 5511 F17
3641
7534 3677 3678 3683
10R
3K3
2610 3614 2612 3618 BC847B
a a ! a
10p 1u 470R 220K 10u
0V
470R 2
SUB_WOOFER_OUT 2560 G13 2874 G8 3608 E14 5734 F15
3594
3593
3674
27K
27K
3684
2668
470p
2563 D7 2876 I10 3609 C14 6512 H10
3K9
470n 5K6 1n8 8K2 8,3V BC817-25
3620
2614
8K2
1n
3
3616 +12M
330K
3,2V 3,6V 0V 1 2564 G7 3511 E1 3610 F14 6514 I10
2669
100n
a a a
a a 7541 7542
2,9V
7543 2571 B10 3512 E1 3611 E13 6515 H14
5K6 0,9V
3576 BC847B BC847B 2572 H8 3513 D3 3612 E13 6516 D18
390R
3679
3682
1K
0,25V
2573 B10 3514 F3 3613 D13 6531 I16
2662
220R
1n
REF
2580
100R
3676
2599
1n
47u
a 2574 H9 3515 D3 3614 F13 7511 D6
To and from
a a
a
Front Board G 2575 B10 3516 F3 3615 D14 7512-AC6
3597
3595
MUTE_SW To and from
2560
0u47
33K
a 2576 H9 3517 E3 3616 G13 7512-BI6
1M
1535
SA_IN 18 CD Board
Level both channels
SA_IN 1533 1538 2577 C8 3518 F3 3617 D14 7513-AA9
NTC 17 GND_TXT 2578 G8 3519 J1 3618 F14 7513-BH8
To Front Board
1N4148
4
6515
23
PW_DN 16 up_CLK 2579 C13 3520 J1 3619 D14 7515-AB17
PW_DN 3
I2C_DATA 15
22
DQSY
2580 G12 3521 C3 3620 F14 7515-BE17
I2C_DATA 2 2581 H11 3522 C3 3621 C14 7521 G3
3596
100K
21
I2C_CLK 14 SRDT
7528
D
I2C_CLK
2682 20 1 2582 H11 3525 C2 3622 E14 7522 H3
BC847B 13
2583 H10 3526 C2 3623 C15 7523 A10
4,2V 7551 30 GND_COAX 1537
H
Switching Board
4,2V D 10n 19
ALC M62320FP 16 15 14 NTC 12 SHIELD 2591 C10 3527 G2 3624 E15 7524 I9
To Digital
18 3
CS0
CS1
CS2
8
CDR_ON
11 COAX2 2592 H9 3528 H2 3625 C15 7525 G10
+5V6 2
3,4V +5V 7
-30V 10
17
COAX1
2593 B9 3529 H4 3626 E15 7526 J3
7552 CHIP SELECT STANDBY
+CD 3695 BC327-25 +5V6 6
F1
16 1 2594 I8 3530 H3 3627 C15 7527 J3
+8,5V 2 SCL F1 9
3598
4M7
I2C_CLK I 2 C BUS SHIFT 1 5 15 2595 A9 3531 C6 3628 E15 7528 H14
2R2
4630
3 SDA F2 F2 8 PORE
I2C_DATA TRANSCEIVER REG SO
4 14
2596 H8 3532 H6 3631 B16 7529 H4
+5V6 6531 8 8 8
3694
7
13 VDD 2597 B9 3533 C6 3632 E16 7531 C14
3558
-30V GND_CD
5K6
2M2
PWR
3559
2M2
12V 12V OUT I/O IN 3 13
+12A +12M
1N4148 8 GND RES DATA LATCHES PW_DN
6
SILD 2598 I7 3534 I6 3633 C16 7532 F14
I
2681
100n
2
D 8 8 8 5
CDSHDATA
12
2599 G16 3535 B6 3634 E16 7533 D15
AB
I/O PORT 1 11 2601 E13 3536 H6 3635 B16 7535 D18
3693
4
3773
3560
SICL
2784
5K6
100p
4M7
From Power
3642
3569
D7
D6
D5
D4
D3
D2
D1
D0
2602 E13 3537 B6 3636 F16 7536 D18
4K7
4K7
1K
10
Supply Board 3 CDSHCLK
12 11 10 9 7 6 5 4
9
2603 C14 3538 H6 3637 C16 7537 D17
3696
3638 E16 7538 D17
3699
HPREF 7553 CD_ON 2 STR 2604 E14 3539 I6
1K
6V BC847B 8
ALC_EN
2K2 1 SW_INFO 2605 C14 3540 H4 3639 C17 7539 D17
220u
3570
3643
2540
2641
100u
4K7
4K7
3692
10K
7
+12 2606 F14 3541 C5 3640 E17 7541 G18
MUTE_LO
AMP_ON
ALC_EN
SET_MUTE
AB
STANDBY
PORE
+12
a a a a
6 2607 B14 3542 I5 3641 F17 7542 F19
D D
+CD
5 J 2608 E14 3543 A6 3642 I13 7543 F19
+CD 4
2609 D13 3544 J6 3643 J13 7551 H17
CDC_R
CDC_R 2610 F13 3545 B1 3645 B17 7552 I15
3
2611 D14 3546 B1 3646 E17 7553 J16
2
CDC_L 2612 F14 3547 B1 3647 B18
CDC_L 1
AF7 Circuit Diagram stage .2 (31 03 2000)
2613 D15 3548 B1 3648 E18
2614 F15 3550 H4 3649 D20
12 13 14 15 16 17 18 19 20 21 22 2615 C15 3551 J2 3650 E20
8-6 8-6
21 E4 1504 F1 1535 A2 2534 D6 2573 D5 2619 E7 2666 F2 2731 D9 2757 C7 2780 B6 3608 F3 3745 B8 6513 A5 9515 C4 9528 B1 9543 C3 9557 F5 9570 C4 9583 B5 9597 B9 9616 D7 9633 F7
23 A8 1521 B8 1536 A2 2540 C6 2574 C5 2620 F6 2675 C4 2732 D9 2758 B8 2790 C8 3632 F6 3746 C8 6514 A4 9516 C4 9529 B1 9544 E1 9558 E4 9571 C4 9584 B5 9598 B9 9617 D7 9634 A4
24 D1 1522 A9 1537 A1 2541 E7 2575 D5 2621 E4 2676 D3 2735 E9 2762 B9 2876 C2 3641 F4 3752 C7 6515 F2 9517 D4 9530 B2 9545 D2 9559 E4 9572 C4 9585 B5 9599 B9 9618 D7 9635 C4
25 A6 1523 B8 1538 C2 2542 E6 2576 C5 2631 E6 2711 E8 2742 C9 2765 D8 3513 D2 3655 B3 3772 B9 6516 F2 9518 D3 9531 E5 9546 D2 9560 E5 9573 B4 9586 B5 9600 B9 9620 E7 9636 C6
26 A9 1525 E1 1539 C1 2546 A7 2582 D2 2632 F6 2712 E8 2743 C9 2766 D8 3514 D2 3661 B6 3773 B9 6517 B5 9519 B9 9532 D8 9547 E2 9561 E5 9574 C5 9587 A4 9601 B9 9621 D7 9711 C8
27 B4 1526 F1 1711 A6 2549 D7 2583 D3 2640 F6 2713 E9 2744 C9 2767 D8 3533 D6 3681 F2 5511 F5 6531 B4 9520 B2 9533 E6 9549 E2 9562 E5 9575 B5 9588 A4 9602 A7 9622 E7 9712 B8
28 B3 1527 D1 1712 C1 2550 E8 2591 D5 2641 F7 2714 E8 2745 C9 2769 C7 3539 C6 3685 C5 5611 B1 6711 B9 9521 B2 9535 B1 9550 E2 9563 E5 9576 B5 9589 A4 9605 C6 9624 E7
29 A3 1528 F8 2513 D2 2552 B6 2592 E4 2647 E7 2717 E8 2748 C9 2770 D8 3558 E2 3695 B1 5612 B1 7525 E2 9522 B1 9536 C3 9551 E3 9564 E5 9577 B4 9590 A7 9608 E7 9625 D7
30 A3 1529 A6 2514 D2 2560 F2 2593 D5 2648 F7 2718 D8 2749 B9 2771 C6 3576 F5 3697 C2 5711 B9 7552 C2 9523 B2 9537 C1 9552 E3 9565 D5 9578 B4 9591 B8 9609 C6 9626 E7
31 A3 1531 B1 2521 B6 2563 D4 2594 C5 2655 B2 2727 E9 2750 C9 2772 C7 3579 E7 3698 C3 5712 C8 9511 C6 9524 B2 9538 C1 9553 E3 9566 D5 9579 B4 9592 C6 9610 B7 9627 D6
1501 E8 1532 C1 2522 B6 2564 C3 2599 F6 2661 F1 2728 E9 2751 C8 2773 B7 3593 F5 3699 C4 5714 B9 9512 B8 9525 B1 9539 B1 9554 E4 9567 D6 9580 B4 9593 E5 9612 D7 9628 D6
1502 E8 1533 C1 2532 E3 2571 D5 2609 F2 2664 E1 2729 E9 2752 C7 2774 C7 3599 D3 3737 B8 6511 B7 9513 A5 9526 B2 9540 D2 9555 F5 9568 D4 9581 C5 9594 E3 9613 D7 9631 C6
1503 B5 1534 C1 2533 E6 2572 C5 2610 E3 2665 E1 2730 D9 2756 C8 2779 B6 3607 F3 3739 B6 6512 E2 9514 A4 9527 A2 9542 C3 9556 F5 9569 C3 9582 B5 9595 B9 9615 E7 9632 C3
AF7 Board componentside view
This assembly drawing shows a summary
of all possible versions.
For components used in a specific version
see schematic diagram respectively partslist.
AF7 Board Layout stage .1 1999 12 21
8-7 8-7
ELECTRICAL PARTSLIST AF7 BOARD
–––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– ELECTRICAL PARTSLIST AF7 BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
MISCELLANEOUS CAPACITORS CAPACITORS RESISTORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
1521 4822 267 10954 FFC SOCKET, 5P 2579 © 5322 122 31647 1nF 10% 63V 2664 4822 124 21913 1µF 20% 63V 3543 © 4822 051 20332 3,3kΩ 5% 0,1W
1525 4822 267 20452 CINCH SOCKET 2P 2580 © 5322 122 31647 1nF 10% 63V 2665 4822 124 40248 10µF 20% 63V 3544 © 4822 051 20332 3,3kΩ 5% 0,1W
1526 4822 267 20452 CINCH SOCKET 2P 2581 © 4822 122 33127 2,2nF 10% 63V 2666 4822 124 40207 100µF 20% 25V 3545 © 4822 117 11139 1,5kΩ 1% 0,1W
1527 4822 267 31729 CINCH SOCKET, 1P 2582 4822 124 40207 100µF 20% 25V 2668 © 5322 122 34099 470pF 10% 63V 3546 © 4822 117 11139 1,5kΩ 1% 0,1W
1528 4822 267 10731 FFC SOCKET, 6P 2583 4822 124 40207 100µF 20% 25V 2669 © 4822 126 13838 100nF 10% 50V 3547 © 4822 117 10965 18kΩ 2% 0,1W
1533 4822 267 10757 FFC SOCKET, 23P, TOP ENTRY 2591 4822 124 80144 220µF 20% 25V 2670 © 4822 126 13838 100nF 10% 50V 3548 © 4822 117 10965 18kΩ 2% 0,1W
1535 4822 265 11553 FFC SOCKET, 19P 2592 4822 124 80144 220µF 20% 25V 2671 © 4822 126 13838 100nF 10% 50V 3550 © 4822 117 10834 47kΩ 1% 0,1W
1538 4822 267 10733 FFC SOCKET, 4P 2593 4822 124 40433 47µF 20% 25V 2672 © 4822 126 13838 100nF 10% 50V 3551 © 4822 051 20154 150kΩ 5% 0,1W
1542 4822 267 10731 FFC SOCKET, 6P 2594 4822 124 40433 47µF 20% 25V 2673 © 5322 122 32654 22nF 10% 63V 3552 © 4822 051 20154 150kΩ 5% 0,1W
1543 4822 265 11529 HEADPHONE SOCKET 2595 © 5322 122 34099 470pF 10% 63V 2674 © 5322 122 32654 22nF 10% 63V 3553 © 4822 051 20334 330kΩ 5% 0,1W
CAPACITORS 2596 © 5322 122 34099 470pF 10% 63V 2675 5322 124 41948 0,47µF 20% 50V 3554 © 4822 117 10353 150Ω 5% 0,1W
––––––––––––––––––––––––––––––––––––––––––––––––––––– 2597 © 4822 122 33575 220pF 5% 50V 2676 5322 124 41948 0,47µF 20% 50V 3555 © 4822 051 20391 390Ω 5% 0,1W
2501 © 4822 126 13838 100nF 10% 50V 2598 © 4822 122 33575 220pF 5% 50V 2677 © 5322 122 34098 10nF 10% 50V 3556 © 4822 051 20122 1,2kΩ 5% 0,1W
2511 © 4822 126 13838 100nF 10% 50V 2599 4822 124 41751 47µF 20% 16V 2681 © 4822 126 14585 100nF 10% 50V 3557 © 4822 117 11149 82kΩ 1% 0,1W
2512 © 4822 126 13838 100nF 10% 50V 2601 © 4822 126 12105 33nF 5% 63V 2682 © 5322 122 34098 10nF10%50V 3558 4822 053 20225 2,2MΩ 5% 0,25W
2513 4822 124 40769 4,7µF 20% 100V
2514 4822 124 40769 4,7µF 20% 100V 2602 © 4822 126 12105 33nF 5% 63V 2691 © 5322 122 32654 22nF 10% 63V 3559 © 4822 051 20225 2,2MΩ 5% 0,1W
2603 © 4822 122 33891 3,3nF 10% 63V 2692 © 5322 122 32654 22nF 10% 63V 3560 © 4822 051 20475 4,7MΩ 5% 0,1W
2515 © 5322 122 32531 100pF 5% 50V 2604 © 4822 122 33891 3,3nF 10% 63V 2694 © 4822 126 13838 100nF 10% 50V 3563 © 4822 117 12955 2,7kΩ 1% 0,1W
2516 © 5322 122 32531 100pF 5% 50V 2605 © 5322 122 34099 470pF 10% 63V 2781 © 5322 122 32654 22nF 10% 63V 3564 © 4822 117 12955 2,7kΩ 1% 0,1W
2517 © 4822 126 14585 100nF 10% 50V 2606 © 5322 122 34099 470pF 10% 63V 2784 © 5322 122 32531 100pF 5% 50V 3565 © 4822 051 20472 4,7kΩ 5% 0,1W
2519 © 5322 122 32531 100pF 5% 50V
2520 © 5322 122 32531 100pF 5% 50V 2607 © 4822 126 14585 100nF 10% 50V 2868 © 4822 126 14585 100nF 10% 50V 3566 © 4822 051 20472 4,7kΩ 5% 0,1W
2608 © 4822 126 14585 100nF 10% 50V 2869 © 4822 126 14043 1µF 20% 16V 3569 © 4822 051 20472 4,7kΩ 5% 0,1W
2521 4822 124 40769 4,7µF 20% 100V 2609 4822 121 51252 470nF 5% 63V 2870 © 4822 126 14043 1µF 20% 16V 3570 © 4822 051 20472 4,7kΩ 5% 0,1W
2522 4822 124 40769 4,7µF 20% 100V 2610 4822 121 51252 470nF 5% 63V 2871 © 5322 122 32654 22nF 10% 63V 3571 © 4822 051 20472 4,7kΩ 5% 0,1W
2523 © 5322 122 32658 22pF 5% 50V 2611 © 4822 126 10847 1,8nF 10% 50V 2872 © 5322 126 10223 4,7nF 10% 63V 3572 © 4822 051 20472 4,7kΩ 5% 0,1W
2524 © 5322 122 32658 22pF 5% 50V
2527 © 5322 122 34099 470pF 10% 63V 2612 © 4822 126 10847 1,8nF 10% 50V 2873 © 5322 126 10223 4,7nF 10% 63V 3573 © 4822 051 20472 4,7kΩ 5% 0,1W
2613 © 5322 122 31647 1nF 10% 63V 2874 © 5322 122 32654 22nF 10% 63V 3574 © 4822 051 20472 4,7kΩ 5% 0,1W
2528 © 5322 122 34099 470pF 10% 63V 2614 © 5322 122 31647 1nF 10% 63V 2876 4822 124 80791 470µF 20% 16V 3575 © 4822 117 11503 220Ω 5% 0,1W
2529 © 4822 126 13838 100nF 10% 50V 2615 © 4822 122 33575 220pF 5% 50V 3576 4822 116 83872 220Ω 5% 0,5W
2531 © 5322 122 32654 22nF 10% 63V 2616 © 4822 122 33575 220pF 5% 50V RESISTORS 3577 © 4822 051 20471 470Ω 5% 0,1W
2532 4822 124 40433 47µF 20% 25V –––––––––––––––––––––––––––––––––––––––––––––––––––––
2533 4822 124 40769 4,7µF 20% 100V 2617 © 5322 122 34099 470pF 10% 63V 3511 © 4822 051 10102 1kΩ 2% 0,25W 3578 © 4822 051 20471 470Ω 5% 0,1W
2618 © 5322 122 34099 470pF 10% 63V 3512 © 4822 051 10102 1kΩ 2% 0,25W 3579 4822 052 10478 4,7Ω 5% NFR
2534 4822 124 40769 4,7µF 20% 100V 2619 4822 124 40769 4,7µF 20% 100V 3513 4822 116 52243 1,5kΩ 5% 0,16W 3580 © 4822 117 12955 2,7kΩ 1% 0,1W
2535 © 4822 122 32535 680pF 2620 4822 124 40769 4,7µF 20% 100V 3514 4822 116 52243 1,5kΩ 5% 0,16W 3581 © 4822 117 11449 2,2kΩ 1% 0,1W
2536 © 4822 122 32535 680pF 2621 4822 124 40207 100µF 20% 25V 3515 © 4822 051 20471 470Ω 5% 0,1W 3582 © 4822 117 11449 2,2kΩ 1% 0,1W
2537 © 4822 126 13486 15pF 2% 63V
2538 © 4822 126 13486 15pF 2% 63V 2623 © 4822 126 14043 1µF 20% 16V 3516 © 4822 051 20471 470Ω 5% 0,1W 3583 © 4822 117 11503 220Ω 5% 0,1W
2624 © 4822 126 14043 1µF 20% 16V 3517 © 4822 051 20332 3,3kΩ 5% 0,1W 3584 © 4822 117 11503 220Ω 5% 0,1W
2539 © 5322 122 32531 100pF 5% 50V 2625 © 4822 122 33575 220pF 5% 50V 3518 © 4822 051 20332 3,3kΩ 5% 0,1W 3585 © 4822 117 10834 47kΩ 1% 0,1W
2540 4822 124 12245 220µF 20% 16V 2626 © 4822 122 33575 220pF 5% 50V 3519 © 4822 051 20333 33kΩ 5% 0,1W 3586 © 4822 117 10834 47kΩ 1% 0,1W
2541 4822 124 21913 1µF 20% 63V 2631 4822 124 40769 4,7µF 20% 100V 3520 © 4822 051 20333 33kΩ 5% 0,1W 3587 © 4822 051 20154 150kΩ 5% 0,1W
2542 4822 124 21913 1µF 20% 63V
2543 © 4822 122 33127 2,2nF 10% 63V 2632 4822 124 40769 4,7µF 20% 100V 3521 © 4822 117 10965 18kΩ 2% 0,1W 3588 © 4822 051 20154 150kΩ 5% 0,1W
2633 © 5322 122 34099 470pF 10% 63V 3522 © 4822 117 10965 18kΩ 2% 0,1W 3589 © 4822 117 11449 2,2kΩ 1% 0,1W
2544 © 4822 122 33127 2,2nF 10% 63V 2634 © 5322 122 34099 470pF 10% 63V 3525 © 4822 117 12955 2,7kΩ 1% 0,1W 3590 © 4822 117 11449 2,2kΩ 1% 0,1W
2545 © 4822 126 13838 100nF 10% 50V 2635 © 5322 122 32531 100pF 5% 50V 3526 © 4822 117 12955 2,7kΩ 1% 0,1W 3591 © 4822 051 20223 22kΩ 5% 0,1W
2547 © 5322 122 32448 10pF 5% 50V 2636 © 5322 122 32531 100pF 5% 50V 3527 © 4822 051 10102 1kΩ 2% 0,25W 3592 © 4822 051 20223 22kΩ 5% 0,1W
2548 © 5322 122 32448 10pF 5% 50V
2549 4822 124 40769 4,7µF 20% 100V 2637 © 4822 126 13692 47pF 1% 63V 3528 © 4822 051 10102 1kΩ 2% 0,25W 3593 4822 116 52264 27kΩ 5% 0,5W
2638 © 4822 126 13692 47pF 1% 63V 3529 © 4822 117 11449 2,2kΩ 1% 0,1W 3594 © 4822 051 20273 27kΩ 5% 0,1W
2550 4822 124 40769 4,7µF 20% 100V 2639 © 5322 122 32654 22nF 10% 63V 3530 © 4822 117 11449 2,2kΩ 1% 0,1W 3595 © 4822 051 20333 33kΩ 5% 0,1W
2551 © 4822 126 14585 100nF 10% 50V 2640 4822 124 40433 47µF 20% 25V 3531 © 4822 117 11449 2,2kΩ 1% 0,1W 3596 © 4822 117 10837 100kΩ 1% 0,1W
2552 4822 124 41751 47µF 20% 16V 2641 4822 124 40207 100µF 20% 25V 3532 © 4822 117 11449 2,2kΩ 1% 0,1W 3597 © 4822 051 20105 1MΩ 5% 0,1W
2553 © 4822 126 13486 15pF 2% 63V
2560 5322 124 41948 0,47µF 20% 50V 2647 4822 124 81151 22µF 20% 50V 3533 4822 116 52234 100kΩ 5% 0,5W 3598 © 4822 051 20475 4,7MΩ 5% 0,1W
2648 4822 124 81151 22µF 20% 50V 3534 © 4822 117 10837 100kΩ 1% 0,1W 3599 4822 116 52175 100Ω 5% 0,5W
2563 4822 124 40746 0,22µF 20% 63V 2649 © 5322 122 32531 100pF 5% 50V 3535 © 4822 051 20124 120kΩ 5% 0,1W 3601 © 4822 051 20332 3,3kΩ 5% 0,1W
2564 4822 124 40746 0,22µF 20% 63V 2650 © 5322 122 32531 100pF 5% 50V 3536 © 4822 051 20124 120kΩ 5% 0,1W 3602 © 4822 051 20332 3,3kΩ 5% 0,1W
2571 4822 121 42408 220nF 5% 63V 2651 © 5322 122 32654 22nF 10% 63V 3537 © 4822 051 20333 33kΩ 5% 0,1W 3603 © 4822 051 20684 680kΩ 5% 0,1W
2572 4822 121 42408 220nF 5% 63V
2573 4822 121 51252 470nF 5% 63V 2652 © 5322 122 32654 22nF 10% 63V 3538 © 4822 051 20333 33kΩ 5% 0,1W 3604 © 4822 051 20684 680kΩ 5% 0,1W
2655 4822 124 40769 4,7µF 20% 100V 3539 4822 052 10339 33Ω 5% NFR 3605 © 4822 117 13579 220kΩ 1% 0.1W
2574 4822 121 51252 470nF 5% 63V 2661 4822 124 21913 1µF 20% 63V 3540 © 4822 117 10833 10kΩ 1% 0,1W 3606 © 4822 117 13579 220kΩ 1% 0.1W
2575 4822 121 51319 1µF 20% 50V 2662 © 5322 122 31647 1nF 10% 63V 3541 © 4822 051 10102 1kΩ 2% 0,25W 3607 4822 050 21003 10kΩ 2% 0,25W
2576 4822 121 51319 1µF 20% 50V 2663 © 5322 122 32448 10pF 5% 50V 3542 © 4822 051 10102 1kΩ 2% 0,25W 3608 4822 050 21003 10kΩ 2% 0,25W
2577 © 4822 122 33127 2,2nF 10% 63V
2578 © 4822 122 33127 2,2nF 10% 63V
8-8 8-8
ELECTRICAL PARTSLIST AF7 BOARD
–––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– ELECTRICAL PARTSLIST AF7 BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
RESISTORS RESISTORS RESISTORS RESISTORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
3609 © 4822 117 10833 10kΩ 1% 0,1W 3679 © 4822 051 20391 390Ω 5% 0,1W 4558 © 4822 051 20008 CHIP JUMPER 0805 4630 © 4822 051 20008 CHIP JUMPER 0805
3610 © 4822 117 10833 10kΩ 1% 0,1W 3680 © 4822 051 20471 470Ω 5% 0,1W 4559 © 4822 051 20008 CHIP JUMPER 0805 4715 © 4822 051 20008 CHIP JUMPER 0805
3611 © 4822 051 20562 5,6kΩ 5% 0,1W 3681 4822 052 10229 22Ω 5% 0,33W 4560 © 4822 051 20008 CHIP JUMPER 0805 4716 © 4822 051 20008 CHIP JUMPER 0805
3612 © 4822 051 20562 5,6kΩ 5% 0,1W 3682 © 4822 051 10102 1kΩ 2% 0,25W 4561 © 4822 051 20008 CHIP JUMPER 0805
3613 © 4822 051 20562 5,6kΩ 5% 0,1W 3683 © 4822 051 20471 470Ω 5% 0,1W 4562 © 4822 051 20008 CHIP JUMPER 0805 COILS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3614 © 4822 051 20562 5,6kΩ 5% 0,1W 3684 © 4822 051 20392 3,9kΩ 5% 0,1W 4563 © 4822 051 20008 CHIP JUMPER 0805 5511 4822 157 62552 2,2µH
3615 © 4822 051 20562 5,6kΩ 5% 0,1W 3686 © 4822 117 11383 12kΩ 1% 0,1W 4564 © 4822 051 20008 CHIP JUMPER 0805 5523 4822 157 62552 2,2µH
3616 © 4822 051 20562 5,6kΩ 5% 0,1W 3687 © 4822 117 11383 12kΩ 1% 0,1W 4565 © 4822 051 20008 CHIP JUMPER 0805 5531 4822 157 62552 2,2µH
3617 © 4822 051 20822 8,2kΩ 5% 0,1W 3688 © 4822 051 20471 470Ω 5% 0,1W 4567 © 4822 051 20008 CHIP JUMPER 0805 5532 4822 157 62552 2,2µH
3618 © 4822 051 20822 8,2kΩ 5% 0,1W 3689 © 4822 051 20471 470Ω 5% 0,1W 4568 © 4822 051 20008 CHIP JUMPER 0805
DIODES
3619 © 4822 051 20822 8,2kΩ 5% 0,1W 3690 © 4822 051 20109 10Ω 5% 0,1W 4569 © 4822 051 20008 CHIP JUMPER 0805 –––––––––––––––––––––––––––––––––––––––––––––––––––––
3620 © 4822 051 20822 8,2kΩ 5% 0,1W 3691 © 4822 051 20109 10Ω 5% 0,1W 4570 © 4822 051 20008 CHIP JUMPER 0805 6512 4822 130 30862 BZX79-C9V1
3621 © 4822 051 20822 8,2kΩ 5% 0,1W 3692 © 4822 117 10833 10kΩ 1% 0,1W 4571 © 4822 051 20008 CHIP JUMPER 0805 6514 4822 130 31878 1N4003G
3622 © 4822 051 20822 8,2kΩ 5% 0,1W 3693 © 4822 051 20562 5,6kΩ 5% 0,1W 4572 © 4822 051 20008 CHIP JUMPER 0805 6515 4822 130 30621 1N4148
3623 © 4822 117 10834 47kΩ 1% 0,1W 3694 © 4822 051 20562 5,6kΩ 5% 0,1W 4573 © 4822 051 20008 CHIP JUMPER 0805 6516 4822 130 30621 1N4148
6531 4822 130 30621 1N4148
3624 © 4822 117 10834 47kΩ 1% 0,1W 3695 4822 116 81154 2,2Ω 5% 0,5W 4574 © 4822 051 20008 CHIP JUMPER 0805
3625 © 4822 051 10102 1kΩ 2% 0,25W 3696 © 4822 117 11449 2,2kΩ 1% 0,1W 4575 © 4822 051 20008 CHIP JUMPER 0805 TRANSISTORS
3626 © 4822 051 10102 1kΩ 2% 0,25W 3697 4822 116 83883 470Ω 5% 0,16W 4576 © 4822 051 20008 CHIP JUMPER 0805 –––––––––––––––––––––––––––––––––––––––––––––––––––––
3627 © 4822 117 11503 220Ω 5% 0,1W 3698 4822 116 83883 470Ω 5% 0,16W 4577 © 4822 051 20008 CHIP JUMPER 0805 7521 © 4822 130 60511 BC847B
3628 © 4822 117 11503 220Ω 5% 0,1W 3699 4822 050 11002 1kΩ 5% 0,2W 4579 © 4822 051 20008 CHIP JUMPER 0805 7522 © 4822 130 60511 BC847B
7523 © 4822 130 60511 BC847B
3629 © 4822 117 11454 820Ω 1% 3773 4822 050 11002 1kΩ 5% 0,2W 4580 © 4822 051 20008 CHIP JUMPER 0805 7524 © 4822 130 60511 BC847B
3631 © 4822 117 11454 820Ω 1% 4516 © 4822 051 20008 CHIP JUMPER 0805 4581 © 4822 051 20008 CHIP JUMPER 0805 7525 4822 130 40959 BC547B
3632 4822 116 52231 820Ω 5% 0,5W 4517 © 4822 051 20008 CHIP JUMPER 0805 4582 © 4822 051 20008 CHIP JUMPER 0805
3633 © 4822 051 20562 5,6kΩ 5% 0,1W 4518 © 4822 051 20008 CHIP JUMPER 0805 4583 © 4822 051 20008 CHIP JUMPER 0805 7526 © 4822 130 60373 BC856B
3634 © 4822 051 20562 5,6kΩ 5% 0,1W 4519 © 4822 051 20008 CHIP JUMPER 0805 4585 © 4822 051 20008 CHIP JUMPER 0805 7527 © 4822 130 60511 BC847B
7528 © 4822 130 60511 BC847B
3635 © 4822 117 10833 10kΩ 1% 0,1W 4520 © 4822 051 20008 CHIP JUMPER 0805 4586 © 4822 051 20008 CHIP JUMPER 0805 7529 © 4822 130 60373 BC856B
3636 © 4822 117 10833 10kΩ 1% 0,1W 4521 © 4822 051 20008 CHIP JUMPER 0805 4587 © 4822 051 20008 CHIP JUMPER 0805 7531 © 4822 130 60511 BC847B
3637 © 4822 117 10834 47kΩ 1% 0,1W 4522 © 4822 051 20008 CHIP JUMPER 0805 4588 © 4822 051 20008 CHIP JUMPER 0805
3638 © 4822 117 10834 47kΩ 1% 0,1W 4524 © 4822 051 20008 CHIP JUMPER 0805 4589 © 4822 051 20008 CHIP JUMPER 0805 7532 © 4822 130 60511 BC847B
3639 © 4822 117 11507 6,8kΩ 1% 0,1W 4525 © 4822 051 20008 CHIP JUMPER 0805 4591 © 4822 051 20008 CHIP JUMPER 0805 7533 © 4822 130 60511 BC847B
7534 © 4822 130 60511 BC847B
3640 © 4822 117 11507 6,8kΩ 1% 0,1W 4526 © 4822 051 20008 CHIP JUMPER 0805 4592 © 4822 051 20008 CHIP JUMPER 0805 7535 © 4822 130 42804 BC817-25
3641 ! 4822 052 10109 10Ω 5% NFR 4527 © 4822 051 20008 CHIP JUMPER 0805 4593 © 4822 051 20008 CHIP JUMPER 0805 7536 © 4822 130 42804 BC817-25
3642 © 4822 051 20472 4,7kΩ 5% 0,1W 4528 © 4822 051 20008 CHIP JUMPER 0805 4595 © 4822 051 20008 CHIP JUMPER 0805
3643 © 4822 051 20472 4,7kΩ 5% 0,1W 4529 © 4822 051 20008 CHIP JUMPER 0805 4597 © 4822 051 20008 CHIP JUMPER 0805 7537 © 4822 130 60511 BC847B
3645 © 4822 051 20479 47Ω 5% 0,1W 4531 © 4822 051 20008 CHIP JUMPER 0805 4599 © 4822 051 20008 CHIP JUMPER 0805 7538 © 4822 130 60511 BC847B
7539 © 4822 130 60373 BC856B
3646 © 4822 051 20479 47Ω 5% 0,1W 4532 © 4822 051 20008 CHIP JUMPER 0805 4600 © 4822 051 20008 CHIP JUMPER 0805 7541 © 4822 130 60511 BC847B
3647 © 4822 051 20479 47Ω 5% 0,1W 4533 © 4822 051 20008 CHIP JUMPER 0805 4601 © 4822 051 20008 CHIP JUMPER 0805 7542 © 4822 130 60511 BC847B
3648 © 4822 051 20479 47Ω 5% 0,1W 4534 © 4822 051 20008 CHIP JUMPER 0805 4602 © 4822 051 20008 CHIP JUMPER 0805
3649 © 4822 051 20479 47Ω 5% 0,1W 4535 © 4822 051 20008 CHIP JUMPER 0805 4603 © 4822 051 20008 CHIP JUMPER 0805 7543 © 4822 130 42804 BC817-25
3650 © 4822 051 20479 47Ω 5% 0,1W 4536 © 4822 051 20008 CHIP JUMPER 0805 4605 © 4822 051 20008 CHIP JUMPER 0805 7552 4822 130 41246 BC327-25
7553 © 4822 130 60511 BC847B
3651 © 4822 051 20392 3,9kΩ 5% 0,1W 4537 © 4822 051 20008 CHIP JUMPER 0805 4606 © 4822 051 20008 CHIP JUMPER 0805
3652 © 4822 051 20392 3,9kΩ 5% 0,1W 4538 © 4822 051 20008 CHIP JUMPER 0805 4607 © 4822 051 20008 CHIP JUMPER 0805 INTEGRATED CIRCUITS
3655 4822 050 21003 10kΩ 2% 0,25W 4540 © 4822 051 20008 CHIP JUMPER 0805 4608 © 4822 051 20008 CHIP JUMPER 0805 –––––––––––––––––––––––––––––––––––––––––––––––––––––
3656 © 4822 117 10833 10kΩ 1% 0,1W 4541 © 4822 051 20008 CHIP JUMPER 0805 4609 © 4822 051 20008 CHIP JUMPER 0805 7511 © 4822 209 17386 TDA7437T, Selector&Sound processor
3657 © 4822 051 10102 1kΩ 2% 0,25W 4542 © 4822 051 20008 CHIP JUMPER 0805 4611 © 4822 051 20008 CHIP JUMPER 0805 7512 © 4822 209 83357 NJM4560M, 2-FOLD OP-AMP.
7513 © 4822 209 83357 NJM4560M, 2-FOLD OP-AMP.
3658 © 4822 051 20562 5,6kΩ 5% 0,1W 4543 © 4822 051 20008 CHIP JUMPER 0805 4612 © 4822 051 20008 CHIP JUMPER 0805 7515 © 4822 209 31378 NJM4556M, 2-FOLD OP-AMP.
3660 © 4822 051 20472 4,7kΩ 5% 0,1W 4544 © 4822 051 20008 CHIP JUMPER 0805 4613 © 4822 051 20008 CHIP JUMPER 0805 7551 © 4822 209 17345 M62320FP, I2C SHIFT REGISTER
3661 4822 053 20475 4,7MΩ 5% 0,25W 4545 © 4822 051 20008 CHIP JUMPER 0805 4614 © 4822 051 20008 CHIP JUMPER 0805
3662 © 4822 051 10102 1kΩ 2% 0,25W 4546 © 4822 051 20008 CHIP JUMPER 0805 4615 © 4822 051 20008 CHIP JUMPER 0805
3663 © 4822 051 10102 1kΩ 2% 0,25W 4547 © 4822 051 20008 CHIP JUMPER 0805 4618 © 4822 051 20008 CHIP JUMPER 0805
3667 © 4822 051 20392 3,9kΩ 5% 0,1W 4548 © 4822 051 20008 CHIP JUMPER 0805 4619 © 4822 051 20008 CHIP JUMPER 0805
3668 © 4822 051 20392 3,9kΩ 5% 0,1W 4549 © 4822 051 20008 CHIP JUMPER 0805 4620 © 4822 051 20008 CHIP JUMPER 0805
3671 © 4822 117 13579 220kΩ 1% 0.1W 4550 © 4822 051 20008 CHIP JUMPER 0805 4621 © 4822 051 20008 CHIP JUMPER 0805
3672 © 4822 117 13579 220kΩ 1% 0.1W 4551 © 4822 051 20008 CHIP JUMPER 0805 4622 © 4822 051 20008 CHIP JUMPER 0805
3673 © 4822 117 12955 2,7kΩ 1% 0,1W 4552 © 4822 051 20008 CHIP JUMPER 0805 4623 © 4822 051 20008 CHIP JUMPER 0805
3674 © 4822 051 20334 330kΩ 5% 0,1W 4553 © 4822 051 20008 CHIP JUMPER 0805 4624 © 4822 051 20008 CHIP JUMPER 0805
3675 © 4822 051 20392 3,9kΩ 5% 0,1W 4554 © 4822 051 20008 CHIP JUMPER 0805 4625 © 4822 051 20008 CHIP JUMPER 0805
3676 © 4822 051 20101 100Ω 5% 0,1W 4555 © 4822 051 20008 CHIP JUMPER 0805 4626 © 4822 051 20008 CHIP JUMPER 0805
3677 © 4822 051 20471 470Ω 5% 0,1W 4556 © 4822 051 20008 CHIP JUMPER 0805 4627 © 4822 051 20008 CHIP JUMPER 0805
3678 © 4822 117 13579 220kΩ 1% 0.1W 4557 © 4822 051 20008 CHIP JUMPER 0805 4629 © 4822 051 20008 CHIP JUMPER 0805
9-1 9-1
Technical remarks
POWER 5-VA Module
(70 / 100W Version)
Stage .6
TABLE OF CONTENTS
Wiring Diagram .......................................................................................9-2
Block Diagram.........................................................................................9-3
Component layout Supply part and L/R Amplifier part ............................9-4
Circuit Diagram Mains part and Supply part ...........................................9-5
Component layout Mains part .................................................................9-6
Component layout Supply part and L/R Amplifier part ............................9-6
Circuit diagram L/R Amplifier part ...........................................................9-7
Circuit diagram CDR Supply part ............................................................9-8
Component layout CDR Supply part .......................................................9-9
Exploded view .......................................................................................9-10
Partslist ...............................................................................................9-11ff
9-2 9-2
WIRING DIAGRAM POWER5-VA MODULE To AF Board To CDR Module To AF Board
CDR-ON
CDR-ON
AMP ON
GNDD
GNDA
STBY
+12M
+12M
+12A
GND
GND
GND
GND
MFD
-30V
5,6V
NTC
REL
RIN
LIN
PD
AB
+V
F2
F1
1 1 1 1
1263 1264 1262 1258
optional for VCD
FAN
+ -
To CDR Module
1325 1261
+12M
1 1
GND
GND
GND
GND
+5V
+5V
Matrix Surround
AB
NTC
AC3
AC4
AC5
-8V
F1
F2
DC
16 1328 AMP OFF 10 1 91
1 1 1 1
L L
12 1354
8921
3 GND Left / Right GND Supply part
R Amplifier 3 R 11
1 HST1 1
MatrixSurround Versions
optional for
+VH
SAT +VL
GND
GNDL
AC1'
AC2'
AC2
AC1
1264 11
7 GND
CDR-ON 1
8322 GNDR 8 CDR Supply
GND
-VL
14 GND
-VH
OPTIONAL +12M
5
5
4
1355
8326
8323
8324
8325
8903
1
1911
Mains Transformer /21 1914
1912 1913
secondary
Interconnection Board
secondary side
Mains transformer
pin 10
primary
primary side Interconnection Board
2
4
8901
8902
pin 8
1
1
1910
1909
27
Transformer Pin 3
Pin 4
Transformer Pin 5
Pin 6
Pin 7
Pin 8
REL
MFD
+V
GND
pin 3
Pos. Service code Description
5001 3103 308 30510 MAINS TRANSFORMER /22 Mains part
5001 3103 308 30520 MAINS TRANSFORMER /21
1901
5001 3103 308 30530 MAINS TRANSFORMER /37
Power5 VA-CDR Wiring Diagram 27 03 2000
for /21 only
Mains socket
9-3 9-3
BLOCK DIAGRAM 70/100W VERSION
11 → 3
SUPPLY PART LEFT / RIGHT AMPLIFIER
Mains Transformer +VH
with interconnection boards +VL
1914 → 14 7329
1911 → 8
1920
1921
+VH 1261 → 1325
6251 +VL
L
1922
-VL
1923
-VH
Thermal fuse
7282,7286
Mains socket -30V
R
1901
1905 6284
6289,6290
1912 → 10
3920
Stand by F1
CONTROL
Relais
5903 F2
NTC
Amp. on/off (mute)
Matrix Surround
AMP OFF
SOAR Prot.
-VL
-VH
1913 → 9 DC
1924 6260-6263
1925 7251,7252,7254
+12A,+12M
7260,7253,7255 STANDBY
Stand by
Transformer +V
6901-6904
5903 27 → 1258 6295
+5V
7281
+5,6V
6281
6905 6906 REL
7260,7263 STANDBY
PD
MFD
7280
MFD=Mains Failure Detection
9-4 9-4
COMPONENT LAYOUT SUPPLY PART & L/R AMPLIFIER PART
3 C 2 1321 D 6 2260 D 11 2284 C 8 2326 E 4 2344 D 3 2362 B 1 3257 E 12 3275 D 8 3299 D 7 3317 A 13 3334 D 2 3352 D 1 3372 E 3 5321 C 5 6271 C 12 6298 B 7 7251 E 13 7286 B 9 9254 C 7 9272 A 11 9291 C 9 9314 A 9 9333 B 5 9355 B 5
8 D 9 1322 B 6 2261 C 11 2285 B 9 2327 E 3 2345 D 2 2363 D 3 3258 E 12 3278 D 13 3300 D 7 3318 A 9 3335 D 2 3353 D 1 3373 C 1 5322 E 5 6272 A 10 6299 B 7 7252 C 12 7290 D 7 9255 B 7 9273 E 12 9292 C 11 9315 B 9 9335 E 4 9356 D 5
9 B 13 1323 B 6 2262 C 11 2286 A 10 2328 E 3 2346 C 4 2364 D 3 3259 A 12 3279 E 12 3301 B 7 3319 A 7 3336 C 2 3355 C 3 3376 C 1 5323 C 5 6281 E 12 6301 B 11 7253 A 8 7292 E 12 9256 E 12 9274 A 13 9293 A 9 9316 D 13 9336 E 3 9357 D 5
10 B 10 1324 B 6 2263 B 13 2287 B 9 2329 D 4 2347 C 4 2365 D 2 3260 C 12 3280 A 13 3302 B 7 3320 A 7 3337 D 2 3356 C 3 3377 B 5 5324 E 5 6283 B 11 6302 B 7 7254 D 12 7323 C 1 9258 A 7 9275 C 10 9294 A 10 9319 C 6 9337 E 3 9358 E 4
11 D 8 1325 B 2 2264 D 13 2288 A 13 2330 E 4 2348 C 4 2366 C 5 3261 C 11 3281 C 12 3303 E 13 3321 B 1 3338 C 2 3357 E 1 3378 B 5 6251 E 10 6284 B 10 6325 C 3 7255 C 12 7324 C 1 9259 B 9 9276 D 9 9298 E 8 9320 E 6 9338 E 4 9359 E 4
14 D 9 1326 B 1 2265 C 13 2289 A 13 2331 C 2 2349 C 4 2367 D 3 3262 C 12 3282 C 7 3304 B 9 3322 B 1 3339 D 2 3358 E 2 3379 B 5 6252 B 13 6285 B 8 6326 C 4 7260 A 8 7325 E 1 9260 A 10 9277 B 11 9299 B 12 9321 B 1 9340 C 3 9360 A 2
16 A 4 1327 A 4 2266 C 13 2290 D 7 2333 E 3 2350 D 4 2368 C 4 3263 B 12 3283 D 11 3305 C 9 3323 E 1 3340 C 2 3359 C 6 3380 B 5 6253 B 13 6286 B 8 6327 B 4 7262 B 13 7326 E 2 9261 A 12 9278 E 9 9300 B 12 9322 B 1 9342 D 5 9361 A 2
1258 A 13 1328 E 4 2267 D 12 2295 C 12 2334 E 3 2351 D 4 2369 C 4 3265 B 12 3284 D 11 3306 A 8 3324 E 2 3341 D 3 3360 E 6 3381 A 4 6255 E 9 6287 B 8 6328 C 3 7263 A 13 7327 D 1 9262 A 8 9279 E 10 9302 A 11 9323 B 3 9343 B 1 9362 A 2
1261 C 6 2251 D 10 2268 C 12 2300 B 7 2335 E 3 2352 E 2 3248 A 11 3266 A 8 3285 B 9 3307 C 5 3325 E 2 3342 C 3 3363 C 5 3383 D 1 6260 D 13 6288 B 8 6329 B 4 7265 A 7 7328 C 1 9263 A 11 9280 D 10 9303 B 11 9324 C 3 9344 D 3 9363 A 2
1262 A 12 2252 E 10 2269 C 12 2301 B 8 2336 E 3 2353 C 5 3249 A 11 3267 A 8 3286 B 10 3308 A 10 3326 E 3 3343 D 3 3364 D 5 3384 D 1 6261 D 13 6289 B 10 6330 C 3 7266 B 7 7329 D 4 9264 A 11 9281 D 10 9304 B 12 9325 C 3 9345 C 4 9364 A 4
1263 A 7 2253 D 10 2270 B 9 2302 A 9 2337 E 3 2354 D 5 3250 A 11 3268 A 10 3287 B 11 3309 B 7 3327 E 3 3344 C 3 3365 D 5 3385 C 5 6262 C 13 6290 B 10 6333 E 4 7268 A 7 7330 C 4 9265 E 12 9284 C 12 9305 A 10 9326 C 3 9347 C 2 9365 A 3
1264 A 10 2254 D 9 2271 A 12 2303 A 7 2338 E 3 2355 C 6 3251 D 13 3269 B 10 3288 B 10 3310 A 9 3328 E 3 3345 E 1 3366 D 5 3386 D 5 6263 C 13 6292 D 7 6334 E 4 7280 A 12 7350 D 2 9266 E 12 9285 C 12 9306 B 12 9327 D 3 9348 B 5 9366 A 3
1265 C 9 2255 E 9 2279 D 12 2321 E 3 2339 B 3 2356 D 6 3252 D 12 3270 C 12 3289 B 10 3311 A 10 3329 D 4 3346 E 1 3367 D 1 3387 D 6 6264 C 11 6293 B 12 6335 E 4 7281 E 11 8327 E 4 9267 E 12 9286 C 9 9307 B 10 9328 C 2 9349 B 2 9367 A 3
1268 D 13 2256 D 9 2280 C 12 2322 E 3 2340 C 3 2357 A 5 3253 A 13 3271 D 7 3290 E 8 3312 B 9 3330 E 3 3347 E 1 3368 C 1 3388 D 6 6265 A 13 6294 B 13 6336 E 4 7282 B 10 8328 C 9 9268 E 13 9287 C 10 9308 C 9 9329 C 3 9350 C 2 9368 A 3
1280 C 7 2257 D 8 2281 C 12 2323 E 2 2341 D 2 2359 A 5 3254 B 7 3272 E 13 3295 D 7 3313 B 12 3331 E 3 3348 E 1 3369 B 5 3389 E 5 6267 A 13 6295 A 10 6337 D 1 7283 A 10 9251 E 9 9269 E 12 9288 D 10 9309 B 8 9330 E 5 9351 D 5 9369 A 3
1290 E 11 2258 C 8 2282 D 11 2324 E 2 2342 C 2 2360 B 5 3255 E 13 3273 B 8 3296 E 8 3315 A 8 3332 E 3 3350 D 2 3370 E 5 3391 D 4 6269 B 11 6296 A 9 6339 D 1 7284 A 11 9252 E 8 9270 A 10 9289 B 11 9312 A 9 9331 C 5 9353 C 5 9370 A 2
1291 C 9 2259 D 10 2283 A 11 2325 D 4 2343 D 1 2361 B 1 3256 B 13 3274 E 8 3298 D 7 3316 A 8 3333 D 2 3351 D 2 3371 E 3 3392 E 4 6270 B 12 6297 A 9 6360 D 5 7285 A 11 9253 E 12 9271 E 11 9290 C 10 9313 A 8 9332 B 5 9354 C 2
13 12 11 10 9 8 7 6 5 4 3 2 1
Copperside view
Supply part
1
AMP ON
CDR-ON
3
02-90-99 68143 303 3013
1262
1264
+12M
+12A
3280
6267
9261
CDR-ON
+12M
MFD
2357 3381
REL
9369 9370
5V6
2283
+V
7285 9294
STBY
R
9363
L
16 9368
NTC
3319
9258
3320
3318
-30
PD
AB
F1
F2
9364 9367 9362
1258 1 1 5 1 3310
3259
2286
1327
A 2289 2288 2271 3248
6297
6296
3266
3267
3306
3315
3316
9260
9293 1263 1 4 3 2 1
9366 9361
9263
6272
3249
7284 9365 9360
3250
7260
3308 9314
9274
7283
2303
7265
3268
7263 9264 3311
3253
6265
9306
9300
2302
3256
9272
7268
3312
9315
3304
9313
9302
2359
9312
3302
9303
9262
3254
1
7280
AMP OFF
1324
7253 2362 2361
9304
10 9332 3377
1326
6302
2270 S OUT 9348
9299
HST1
SAT
3317
6301
7266
AB
9270
9305
6295
R
3379
1
L
7262
1
1
9 6290 3309 3380
1323
1
3313
6293
3285
2285 9333 3378 1325
3273
6299
3301
9259
6298
2300
3269
6253 7282
9355
7286 2301 2360
B
6288
6287
6286
6285
6329
3265
3263
6269
9289
9277
2339 9322
6294 C OUT 6327 3322
6252 3369
3287
3288
3289
2263
6284
3286
6289
9307
9343
1322
6270
2287
9324
2348 2346 9349
A1-T CEI 1
9323
2284 9255 9321
6283 9309 7328
68143 303
1265 5321
3262
2265 7255 7252 1280
02-90-99
9308
5323 3321
3385
2266 SAT
3305
9347 3376
HST1
9345
2261
9319
2262 21
6271
3359
2366
3363 2331
3261
6264
3356
3355
2269
9290 2349 2347 3373
6325
9354
1261
6330
6328
9254
3281
2280
6326
9340
9328
2353
3013
9329
3282 L
C 2281
2295
8328
1291
2258 3338
7324 7323
6262
6263
9292
2268 AMP OFF 9353 23 9325 3
40 2342
9287
9275
A1-T CEI
6260
6261
AB
1
2355 3307 9331 3342 3336
3368
1 +L 9350
9284
9285
9281 3344 3340
2369
2368
3386
3387
9356
3300
9326
3283
3384
2290 2341
3271
6292
3295 9327
3299
3298
9291
9344
9286
9351 3335 2343 3367
6360
3284
8 2350 2351 3341 3339 3337
3270
3260
2367
1
3252 3343 3383
9316
2282 +VH
7254
2257 -L 2356
+VL
1
14 9280
9342 9357
SAT 9276
2267
3366
3352
6337
2363 2364
NC 9288 12256
3275
2354
11
1268
3333
3334
6339
AMP OFF
7290
3353
2264 2279 2259 2329
2325
3329
2253
DC
3365
2260
3251
9273
9253
9266
9269
9267
9265
9256
6281
9271
+VL -VH 3364 2344 2345
2365
3350
3351
1290 2251 2254 7350 7327
-VL 2327
3303
3258
9337
3327
+VL
-R 2352
3391
3388
3360
2252 2255 2326
3257
3389
9330
2330
9268
3296
3278
3348
3274
2337
2321
2335
5324
3272
3331
A1-T CEI
9320
-VL 5322 2328 2333 2323
3325
3358
3324
3347
3346
3357
3345
3323
3255
3392
11
9298
-VL printed fuse
9278 9252 +R
3279
3330
9335
9279 2324
9338
7330
7329
in case of damage 9251
7251 7292 7281 6251 6255 8327
E B C E B C E I G O
insert fuse T1A
4822 071 51002 -VL +VL
3290
3370 6335
7326 7325
3328
1321
2338
3332
2322
2336
9336
6333 2334
-42V 63V AC +42V 1328 9359
3326
9358
This assembly drawing shows a summary
1 6336 3372
3371
6334
Transistor pinning
of all possible versions.
For components used in a specific version C Left / Right Channel
B
see schematic diagram respectively partslist.
E Amplifier
Power5VA Supply-L/R Amplifier Board Layout stage .6 1999 09 20
13 12 11 10 9 8 7 6 5 4 3 2 1
9-5 9-5 9-5
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29
0010 G14 6299 F24
0011 B29 6301 H24
POWER 5-VA SUPPLY PART 70/100W Version 14 8
AMPLIFIER SUPPLY +VH
+42V
0011
1
+VH
1258
1261
1262
K14
F29
H29
6302 H25
6900 K 9
6901 L 6
+42V 1263 M29 6902 M 6
PRIMARY TRAFO 1 1 +43V 2 1264 M29 6903 L 7
+VH +VL +VL
A 1911 1914 A 1265 N29 6904 M 6
9901 9903 1268 B29 6905 L 5
9276
3 GNDL
1909 8902 1280 E18 6906 L 5
trf8 trf10
TO L/R AMP
9xxx
9925 1920 1 1 2 2 GNDL 1290 C26 6908 N 8
7 (4) 4 6255 4 GND 1291 B26 6909 L 9
1901 5902 5905 T-5A GBU8D 14 A14 6910 N 9
6 230V 9924
9927
trf-ee25 5 (3) 3 GND 1901 A1 6911 K10
2254
2255
+43V
47n
47n
1905 5 10V 5 GNDR
2 trf7 trf11 1921 +VL 1903 J15 6912 K11
2 2
GNDR 1905 A3 7251 H19
T6.3A UL 4 Printed Fuse -42V 1906 C6 7252 J20
T-5A 6 -VL
3907
3 3 63V 1907 C6 7253 L23
V
T5A IEC 110V -VL
SPST - 9V
120V In case of damage insert Fuse T1A 1909 A7 7255 J18
1 trf6 trf12 -42V
3 3 4822 071 51002 7 -VH 1910 D7 7260 L24
1291
T-1A
9915 -VH 1911 A13 7262 N20
B 3 (2) 2 9923 B
LC121503-PCT 1912 E13 7263 N20
5901 4 4 2256 1913 H13 7265 H24
230V trf5 trf13 1922 4 4 -43V 1914 A13 7266 E24
47n
9904
3 9906 1920 A12 7268 F24
9902 T-5A -VL 1921 A12 7280 N17
2 1268
9928
1907 9922 -42V 11 1922 B12 7281 L17
9280
1290
1 (1) 1 trf14
T-1A
1923 5 5 -VL -VL 1923 C12 7282 E20
9xxx
3272
1 trf4 3k3 for DPL
2k7
T-2,5A 5 5 Printed Fuse 1924 H12 7283 M23
120V 120V T-5A In case of damage insert Fuse T1A 10 1925 I12 7284 O23
-43V -VL 2251 A16 7285 O24
9916 9917 9921 4822 071 51002
C 3 (2) 2 -VH C 2252 A16 7286 E20
9
6800u/50V for/37
6800u/50V for/37
9905 trf3 GNDS 2253 B17 7290 N26
2254 A18
4700u/63V
4700u/63V
7292 K17
9251
1906 1 9920 * 2255 A18 7901 L 8
9918
3275
3274
2257
9252
2258
1 (1)
33k
33k
8
GND 2256 B19 7902 M 8
3278
2k2
T-2,5A 2257 C18 8 A15
1910 8901 7 2258 C19 8901 D 8
GNDC 2260 C20 8902 A 8
TO C/S AMP
2262 C20 9 H14
Voltage Selector for /21 only +42V 6 2263 I16 9251 C17
+VL +VL
2264 I17 9252 C18
D 5 D 2265 I17 9253 H20
+VL 2266 I17 9254 E19
2267 H19 9255 H23
4 2268 I20 9256 L17
DC 2269 J20 9258 H27
1280 DISPLAY-SUPPLY DC PROTECTION CIRCUIT 2270 K24 9260 N28
-42V 4,5V 3 2271 I21 9261 N17
-39V AMP_OFF
T-1A 5V6 5V6 2279 M17 9276 A16
7286 7282 2 2280 J16 9280 C16
3282 -29V HST2 2281 J16 9900 N 8
9254 -49V BC327-40 BC327-40
47R +5,6V +5,6V 2282 M18 9901 A 2
E -30 E 2283 N24 9902 B 2
1
BZX79C5V6
3302
SAT 2286 N25 9903 A 3
47k
3254
680R 2287 F20 9904 B 4
9930 6298 2288 O17 9905 C 6
6284
390R for 100W
-40V -30V ONLY FOR FOUR CHANNEL VERSIONS
1912 7266 2289 O17 9906 B 6
2290 O26 9910 K 9
BC557B BZX79C6V8 1261 2295 J16 9911 F 1
trf15 3920 1
3269
2300 F23 9912 G 1
220
1R 3285 3286 2301 F25 9913 G 1
3k3 3k3 7268 8
NTC SAT 2302 K25 9914 G 1
F 6k8 for 100W 6k8 for 100W BC547B F 2303 G24 9915 B 6
3287
7
22k
3309 6299
BZX79B30V
27 J13 9916 C 4
33k HST1 HST1 2902 L6 9917 C 5
trf16 6
22u/50V
1 2903 M7 9918 C 3
3289
3288
1N4148
6290
47R
47R
2287
2
100u/10V
4,9V R 2904 N7 9920 C 9
2300
3265
3301
100k
100k
2301
10n
TO L/R AMP
trf17 5 2905 N6 9921 C 9
3 2 2906 N7 9922 C 9
A 4 3248 O23 9923 B 9
3 NTC -24V 3249 O24 9924 A 9
L 3250 O24
F2 3 9925 A 9
HST1 -42V 4,5V 3251 H18 9927 A13
-24V AMP OFF
G 4 F1 G 3252 I18 9928 C13
trf18 5V6 0V 2 3253 O20 9930 E12
4
0010 DC 3254 E24 trf10 A11
+5,6V +VH +4,5V 1 3255 I19 trf11 A11
2303
ab 3256 O21 trf12 B11
+VL +33V +12V REGULATOR 10n 3259 L22 trf13 B11
3273
9255
15k
3319
9258
3320
3260 J17 trf14 C11
12k
22k
3261 I21
3305
trf15 F12
22k
+12V 6301
3262 J21 trf16 F11
3251
+12M 6292
2k2
3263 I22 trf17 G12
1913 9 1N4148 1262 3265 F24 trf18 G11
H +23,5V 2267 H
1N4148 +5V6 7265 3266 K25 trf19 H11
trf19 1924 100u/50V BC556B 9 3267 K25 trf20 I11
1 1
BZX79 3V3
+25V +12V 9253 L 3268 J26 trf21 I11
3304
6302
47k
ST.BY REL. 12V MODE 6260 6262 +12A +5,6V 8 3269 F21 trf3 C10
1N5392
T-2,5A
6294
1N5392 1N5392 7251 3270 J18 trf4 C10
4700u/35V
3300u/35V
2263
100n
11V 3271 O26 trf5 B10
3283
BDX53BFI 7
6k8
2265
2266
L OFF OFF ST.BY trf20 R 3272 C21 trf6 B10
1925 2 2 +13,5V
BZX79B11V
3273 H23 trf7 A10
6264
6
2268
4u7
3274 C19 trf8 A10
470R
6269 AMP ON
3255
T-1,6A 3263 6283
Z ON OFF CLOCK AMP ON = +5V AMP OFF = 0V 3275 C18
TO AF7
6261 6263 10k 5 3278 C21
1N5392
1N4003
2264
100n
I +2V +12V I
6252
6253
11V 1N5392 1N5392 1N4148 +12A +12A 3279 L17
BZX79C15V
3252
2k2
4 3280 O17
3284
H ON ON 12V ON MODE trf21
47u/25V
120R
1k
A 3281 N18
3261
3 3 AMP ON/OFF CIRCUIT
2271
A 3 3282 E18
+12V
2269 +12M +12M 3283 I23
+13,5V 3284 I23
D 2
3n3 A D 3285 F19
7252 D 1 3286 F20
+0,7V
0.33R
3270
BC547B 5V6 3287 F22
0V 5V6 3288 F21
4700u/25V
4700u/16V
3300u/16V
2295
2280
2281
J J
120R
3289 F21
3262
3290 O26
7255 5V +5V 3268 3295 N26
3260 BC547B ON/OFF CONTROL FOR RELAY, +12V 10k 3296 O27
A A
27 0R33 3298 N27
3299 N28
3318
6911 6912 AUX-SUPPLY 1263 3300 N27
10k
1258 3301 F25
1 REL 6296 1 3302 E24
1N4148 1N4148 3267 AB
1 12V 3304 H24
REL +V 3k9 3305 H25
K PD 2 K
MFD 2 +11V +V 1N4148 PD 3306 L23
2
10u/50V
3308 N23
1N4148
680R
MFD
2302
100n
-29V
3316
3266
6297
3
2270
47k
9910 +11V -30 -30 3309 F24
3902
3903
3 7292
1k
1k
1903 for /21only +V +V 4 3310 N23
3
12V +11V BD242BFI +5,6V 6295 5V F2 F2 3311 N23
3259
6900 4
TO AF7
10k
GND 3312 L23
T200mA 5 3313 N20
1N4148
1N4148
GND 1N4148 +5V F1 F1
1N4003 4 7281 7253
6905
6906
7260 +4,6V 3315 L24
5903 3279 7805CP BC547B 6 3316 K24
3908 not /21 6 BC547B STBY
1R +0,6V 3317 O19
L 470Ω 5 L 3318 K26
3315
9256 +11V I O 5V6 39k 7
56k
120Ω for/37 6901 6903 +4V CDR-ON CDR-ON 3319 H27
1N4003 1N4003 3306 3320 H27
2902
+5,6V
47n
7 5,5V 8 3901 N3
3312
7901 12,7V NTC NTC
10k
4 10V 12,7V
BC327-25 3V 6909 12V 3902 K5
8
25,3V G +0,6V 3903 K6
1N4003 8328 3904 M7
3
1N4002
10u/50V
3905 M8
6281
2282
2279
100n
6902 6904 HEATSINK 3906 N5
9
2903
25V 12V
47n
5,5V 1N4003 1N4003 1264 3907 B1
2 10V 3908 L4
M 15k for D D D M 3920 F12
3904
3905
1
4k7
2k2
10 +5,6V-STABILIZER CDR-ON CDR-ON 5901 B2
/00,/17
1 25V 6,5V 2 5902 A2
7,2V GND 5903 L4
TO CDR
8,3V 7902 3 5905 A4
BC547B 9260 GND 6251 A17
AB = DISABLE CLASS H
BZX79C8V2
+12V 6252 I15
4
100u/50V
100u/25V
12,6V 6253 J15
10M
3901
9900
2904
2906
+12M +12M
6908
HST = HEATSINK TEMPERATURE 9261 +V
+4V
7263 +12V +12V 6255 A18
6260 H16
3313
SAT = SATURATION INDICATION (CLIPPING) BC337-25 6261 I16
330R
330R
1k
3295
3300
3298
3299
5R6
270
N 6267 +11V N 6262 H17
6910 +1,2V 6263 I17
12V MFD = MAINS FAILURE DETECT 5V
BC327-25 6264 I20
+5V 1N4148
3281
10k
1N4003 7262 7290 6265 N21
7280 1265
1N4148
100u/10V
BC547B 6267 N17
6270
3280
+0,5V
120k
2288
100u/25V
ELECTRONIC VOLTAGE SELECTOR BC547B PD 3256 6265 +5,6V 6269 I22
3906
+8,2V
2905
1
10k
5V6 6270 O19
FOR STAND BY CIRCUIT +
3271
3296
1k
470
MAINS VOLTAGE 6271 O19
1k
FAN
-0,2V BZX79C5V6 +6 - +11V 2 6272 N24
BZX79C8V2
230V 120V
1N4148
FOR /21 ONLY - 6281 M17
6271
3317
10R
470R
6293
3253
............. Vdc measured during AMPLIFIER ON 6283 I23
100u/25V
NTC 10k
1u/50V
6284 E22
2289
2290
3290
V EVM 6289 F21
O V Vdc measured during AMPLIFIER OFF (mute) O 6290 F20
6292 H23
Voltages measured at nominal mains voltage and low output signal 6293 O18
POWER DOWN CIRCUIT RELAY CONTROL CIRCUIT FAN REGULATION 6294 H15
6295 K18
6296 K26
6297 K26
P5VA L/R Supply 70/100W CDR (2000-02-22)
6298 E25
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29
9-6 9-6 9-6
COMPONENT LAYOUT MAINS BOARD COMPONENT LAYOUT SUPPLY PART & L/R AMPLIFIER PART
Interconnection Board Mains Board
primary side secondary side
8901 E 5 1911 A 5 9930 B 4 trf10 A 3 27 B 1 2905 A 1 5905 C 1 7901 A 1 9909 A 2
3 C 2 1321 D 6 2260 D 11 2284 C 8 2326 E 4 2344 D 3 2362 B 1 3257 E 12 3275 D 8 3299 D 7 3317 A 13 3334 D 2 3352 D 1 3372 E 3 5321 C 5 6271 C 12 6298 B 7 7251 E 13 7286 B 9 9254 C 7 9272 A 11 9291 C 9 9314 A 9 9333 B 5 9355 B 5
8902 D 5 1912 B 5 9931 A 4 trf11 A 3 1901 E 3 2906 B 1 6900 B 1 7902 B 1 9910 B 1 8 D 9 1322 B 6 2261 C 11 2285 B 9 2327 E 3 2345 D 2 2363 D 3 3258 E 12 3278 D 13 3300 D 7 3318 A 9 3335 D 2 3353 D 1 3373 C 1 5322 E 5 6272 A 10 6299 B 7 7252 C 12 7290 D 7 9255 B 7 9273 E 12 9292 C 11 9315 B 9 9335 E 4 9356 D 5
9920 E 4 1913 C 5 9932 A 4 trf12 A 3 1902 E 2 3901 B 1 6901 A 3 8904 D 1 9911 A 1 9 B 13 1323 B 6 2262 C 11 2286 A 10 2328 E 3 2346 C 4 2364 D 3 3259 A 12 3279 E 12 3301 B 7 3319 A 7 3336 C 2 3355 C 3 3376 C 1 5323 C 5 6281 E 12 6301 B 11 7253 A 8 7292 E 12 9256 E 12 9274 A 13 9293 A 9 9316 D 13 9336 E 3 9357 D 5
9921 E 4 1914 A 5 9933 A 4 trf13 A 3 1903 C 2 3902 A 2 6902 A 2 8905 C 1 9912 A 1 10 B 10 1324 B 6 2263 B 13 2287 B 9 2329 D 4 2347 C 4 2365 D 2 3260 C 12 3280 A 13 3302 B 7 3320 A 7 3337 D 2 3356 C 3 3377 B 5 5324 E 5 6283 B 11 6302 B 7 7254 D 12 7323 C 1 9258 A 7 9275 C 10 9294 A 10 9319 C 6 9337 E 3 9358 E 4
9922 E 4 1920 A 4 9934 A 4 trf14 B 3 1904 B 2 3903 A 2 6903 A 3 9900 B 1 9913 A 2 11 D 8 1325 B 2 2264 D 13 2288 A 13 2330 E 4 2348 C 4 2366 C 5 3261 C 11 3281 C 12 3303 E 13 3321 B 1 3338 C 2 3357 E 1 3378 B 5 6251 E 10 6284 B 10 6325 C 3 7255 C 12 7324 C 1 9259 B 9 9276 D 9 9298 E 8 9320 E 6 9338 E 4 9359 E 4
9923 D 4 1921 A 4 9935 B 4 trf15 B 3 1905 C 3 3904 B 1 6904 A 2 9901 D 3 9914 A 2 14 D 9 1326 B 1 2265 C 13 2289 A 13 2331 C 2 2349 C 4 2367 D 3 3262 C 12 3282 C 7 3304 B 9 3322 B 1 3339 D 2 3358 E 2 3379 B 5 6252 B 13 6285 B 8 6326 C 4 7260 A 8 7325 E 1 9260 A 10 9277 B 11 9299 B 12 9321 B 1 9340 C 3 9360 A 2
9924 D 4 1922 A 4 9936 B 4 trf16 B 3 1906 C 1 3905 A 1 6905 A 2 9902 D 3 9915 D 2 16 A 4 1327 A 4 2266 C 13 2290 D 7 2333 E 3 2350 D 4 2368 C 4 3263 B 12 3283 D 11 3305 C 9 3323 E 1 3340 C 2 3359 C 6 3380 B 5 6253 B 13 6286 B 8 6327 B 4 7262 B 13 7326 E 2 9261 A 12 9278 E 9 9300 B 12 9322 B 1 9342 D 5 9361 A 2
9925 D 4 1923 B 5 9937 B 4 trf17 B 3 1907 E 1 3906 A 1 6906 A 2 9903 C 3 9916 D 2 1258 A 13 1328 E 4 2267 D 12 2295 C 12 2334 E 3 2351 D 4 2369 C 4 3265 B 12 3284 D 11 3306 A 8 3324 E 2 3341 D 3 3360 E 6 3381 A 4 6255 E 9 6287 B 8 6328 C 3 7263 A 13 7327 D 1 9262 A 8 9279 E 10 9302 A 11 9323 B 3 9343 B 1 9362 A 2
trf3 E 4 1924 C 4 9938 B 4 trf18 C 3 1909 D 1 3907 E 3 6908 B 1 9904 D 2 9917 D 1 1261 C 6 2251 D 10 2268 C 12 2300 B 7 2335 E 3 2352 E 2 3248 A 11 3266 A 8 3285 B 9 3307 C 5 3325 E 2 3342 C 3 3363 C 5 3383 D 1 6260 D 13 6288 B 8 6329 B 4 7265 A 7 7328 C 1 9263 A 11 9280 D 10 9303 B 11 9324 C 3 9344 D 3 9363 A 2
trf4 E 4 1925 C 4 9939 C 4 trf19 C 3 1910 C 1 3908 C 2 6909 B 1 9905 C 1 9918 C 3 1262 A 12 2252 E 10 2269 C 12 2301 B 8 2336 E 3 2353 C 5 3249 A 11 3267 A 8 3286 B 10 3308 A 10 3326 E 3 3343 D 3 3364 D 5 3384 D 1 6261 D 13 6289 B 10 6330 C 3 7266 B 7 7329 D 4 9264 A 11 9281 D 10 9304 B 12 9325 C 3 9345 C 4 9364 A 4
trf5 E 4 3920 B 4 9940 C 4 trf20 C 3 2902 A 3 5901 D 3 6910 B 1 9906 E 1 9919 C 3 1263 A 7 2253 D 10 2270 B 9 2302 A 9 2337 E 3 2354 D 5 3250 A 11 3268 A 10 3287 B 11 3309 B 7 3327 E 3 3344 C 3 3365 D 5 3385 C 5 6262 C 13 6290 B 10 6333 E 4 7268 A 7 7330 C 4 9265 E 12 9284 C 12 9305 A 10 9326 C 3 9347 C 2 9365 A 3
trf6 D 4 9927 A 5 9941 C 4 trf21 C 3 2903 A 2 5902 D 3 6911 B 1 9907 B 3 9926 C 2 1264 A 10 2254 D 9 2271 A 12 2303 A 7 2338 E 3 2355 C 6 3251 D 13 3269 B 10 3288 B 10 3310 A 9 3328 E 3 3345 E 1 3366 D 5 3386 D 5 6263 C 13 6292 D 7 6334 E 4 7280 A 12 7350 D 2 9266 E 12 9285 C 12 9306 B 12 9327 D 3 9348 B 5 9366 A 3
trf7 D 4 9928 A 5 9942 C 4 2904 A 2 5903 B 2 6912 B 1 9908 A 2 9929 B 2 1265 C 9 2255 E 9 2279 D 12 2321 E 3 2339 B 3 2356 D 6 3252 D 12 3270 C 12 3289 B 10 3311 A 10 3329 D 4 3346 E 1 3367 D 1 3387 D 6 6264 C 11 6293 B 12 6335 E 4 7281 E 11 8327 E 4 9267 E 12 9286 C 9 9307 B 10 9328 C 2 9349 B 2 9367 A 3
trf8 D 4 1268 D 13 2256 D 9 2280 C 12 2322 E 3 2340 C 3 2357 A 5 3253 A 13 3271 D 7 3290 E 8 3312 B 9 3330 E 3 3347 E 1 3368 C 1 3388 D 6 6265 A 13 6294 B 13 6336 E 4 7282 B 10 8328 C 9 9268 E 13 9287 C 10 9308 C 9 9329 C 3 9350 C 2 9368 A 3
1280 C 7 2257 D 8 2281 C 12 2323 E 2 2341 D 2 2359 A 5 3254 B 7 3272 E 13 3295 D 7 3313 B 12 3331 E 3 3348 E 1 3369 B 5 3389 E 5 6267 A 13 6295 A 10 6337 D 1 7283 A 10 9251 E 9 9269 E 12 9288 D 10 9309 B 8 9330 E 5 9351 D 5 9369 A 3
1290 E 11 2258 C 8 2282 D 11 2324 E 2 2342 C 2 2360 B 5 3255 E 13 3273 B 8 3296 E 8 3315 A 8 3332 E 3 3350 D 2 3370 E 5 3391 D 4 6269 B 11 6296 A 9 6339 D 1 7284 A 11 9252 E 8 9270 A 10 9289 B 11 9312 A 9 9331 C 5 9353 C 5 9370 A 2
5 4 3 2 1 1291 C 9 2259 D 10 2283 A 11 2325 D 4 2343 D 1 2361 B 1 3256 B 13 3274 E 8 3298 D 7 3316 A 8 3333 D 2 3351 D 2 3371 E 3 3392 E 4 6270 B 12 6297 A 9 6360 D 5 7285 A 11 9253 E 12 9271 E 11 9290 C 10 9313 A 8 9332 B 5 9354 C 2
Interconnection Board Mains Board Copperside view
Transformer secondary 13 12 11 10 9 8 7 6 5 4 3 2 1
trf10 Copperside view
1920
9914
9913
9912
9911
2902 2903 Supply part
6905
3902
3903
6906
9927 9931
1
AMP ON
CDR-ON
7901 3
6901 02-90-99 68143 303 3013
1262
1264
1 1
+12M
+12A
3280
6267
9261
9932
CDR-ON
+12M
MFD
2357 3381
REL
6902
A A 9369 9370
5V6
1911
2283
+V
6903 7285 9294
STBY
R
9363
L
9933 16 9368
NTC
3319
9258
3320
6904 3905 3318
-30
PD
AB
F1
F2
2904 9364 9367 9362
1914
1921 9908 2905 1258 1 1 5 1 3310
3259
2286
1327
A 2289 2288 2271 3248
6297
6296
3266
3267
3306
3315
3316
9260 1 9366 9361
9910
5 1263
6910
6909
5 9909 7902 9293 4 3 2 1
9263
6272
3249
7284 9365 9360
3906
9934 3250
7260
9314
9928
3308
9274
9935 7283
2303
7265
9907
3268
1922 5903 1904 3311
1923
3904
9264
6900
7263
3253
6265
9306
9300
2302
3256
9272
7268
9929
3312
9315
3304
9313
9302
2359
9312
3302
9303
9262
3254
1
7280
9900
AMP OFF
2906
1324
7253 2362 2361
9304
9936 10 9332 3377
1326
6302
2270 S OUT 9348
9299
HST1
SAT
3317
6301
7266
AB
9270
9305
6295
4
R
3379
1
L
3920 9930 7262
Am002-T
1
1
1 6290 3309
B 9937
B 9 3380
27
1323
1
3313
6293
3285
6908
6911
6912
9333 3378 1325
1912
2285
3273
6299
3301
9259
6298
2300
3269
6253 7282
9355
3901 5905 7286 2301 2360
B
6288
6287
6286
6285
6329
3265
3263
6269
9289
9277
4 9938 1 2339 9322
6294 C OUT 6327 3322
6252 3369
3287
3288
3289
2263
6284
3286
6289
9307
9939 9343
1322
6270
2287
9324
9349
1924
2348 2346
A1-T CEI 1
9323
2284 9255 9321
9309
6283 7328
68143 303
1265 5321
3262
1 2 3 4 2265 7255 7252 1280
02-90-99
9940
9308
5323 3321
3385
9919 9926 2266 SAT
3305
1 3908 3376
1906 9347
1913
HST1
9345
2261
A3,6-T ASC/LU
9903
9319
21
1925
1903
A5-T CEI 2262
6271
9941 R
3359
C C
2366
3 3363 2331
3261
6264
3356
3355
2269
9290 2349 2347 3373
6325
9354
1261
6330
6328
1905 9254
3281
2280
6326
9340
9328
A5-T CEI
2353
3013
9329
1 3282 L
C 2281 1291
9918
9942 Am002-T CEI 7324 7323
9905 2295 2258 3338
8905
1910
trf21 8328
6262
6263
9292
9 5 2268 AMP OFF 9353 23 9325 3
9916 40 2342
9287
9275
A1-T CEI
6260
6261
AB
1
2 2355 3307 9331 3342 3336
9917 3368
5902 1 +L 9350
9284
9285
9281 3344 3340
2369
2368
3386
3387
9356
3300
trf8
9326
3283
3384
2290 2341
3271
6292
9327
3295
3299
3298
9925
9291
9344
4
9286
9904 1 9351 3335 2343 3367
6360
3284
8 2350 2351 3341 3339 3337
3270
3260
2367
5901
1
3252 3343 3383
9316
2282 +VH
D 9924 D 7254
2257 -L 2356
+VL
1
14 9280
9342 9357
SAT 9276
2267
D
3366
3352
6337
2363 2364
9901
9902
9915 NC 12256
8902
9288
3275
trf7 2354
1909
8904
11
1268
3333
3334
6339
AMP OFF
7290
3353
2264 2279 2259 2329
47143 303 3013 2325
3329
9923
2253
DC
3365
3907 2260
3251
9273
9253
9266
9269
9267
9265
9256
6281
9271
51-30-99 -VH 2344
+VL 3364 2345
2365
3350
3351
trf6 1290 2251 2254 7350 7327
-VL 2327
3303
3258
9337
3327
4 5 6 +VL
-R 2352
3391
3388
9922
V042
3360
V021
1 1901 2252 2255 2326
3257
4
3389
9330
2330
9268
3296
3278
trf5
3348
3274
2337
2321
2335
A5-T CEI 3272 5324
3331
1 2 3 A1-T CEI
9320
9921 1902 1907 -VL 5322 2328 2333 2323
3325
3358
3324
3347
3346
3357
3345
3323
3255
3392
11
9298
2 -VL printed fuse
9278 9252 +R
NEUTRAL
3279
3330
9335
9279 2324
9338
9906
LIFE
7330
7329
trf4 in case of damage 9251
8901
E 9920 E E 7251 7292 7281
insert fuse T1A
6251 6255 3290
3370
8327
6335 7325
1 B C E B C E I G O 4822 071 51002 -VL +VL 7326
3328
1321
2338
3332
2322
2336
9336
6333 2334
trf3 -42V 63V AC +42V 1328 9359
3326
9358
This assembly drawing shows a summary
1 6336 3372
3371
6334
This assembly drawing shows a summary Transistor pinning Transistor pinning
C of all possible versions.
of all possible versions.
B For components used in a specific version C Left / Right Channel
Interconnection Board For components used in a specific version B
see schematic diagram respectively partslist.
E see schematic diagram respectively partslist.
E Amplifier
Transformer primary Power5VA Supply-L/R Amplifier Board Layout stage .6 1999 09 20
Power5VA MainsBoard Layout stage .4 1999 06 14
13 12 11 10 9 8 7 6 5 4 3 2 1
5 4 3 2 1
9-7 9-7
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
1321 D18
1325 D 1
1328 G18
POWER 5-VA L/R AMPLIFIER BOARD 3
2321 B 6
2322 H 6
2323 D 4
3333 1 2324 F 4
A
130W Version
70W/100W Version 47R
+52V
+42V
+VH A 2325 D 5
2326 F 5
1N4003
2327 E 6
for /37 only
100n/63V
6329
22u/100V
10u/100V
22u/50V
2350
2328 G 6
2363
2344
2348
2329 D 6
9323
2330 F 6
1N4003
2331 E 3
6327
2333 E 5
2334 G 5
2335 B 6
9324 +42V
+37V 2 2336 H 6
+VL 2337 B 6
for /37 only
2338 H 6
2367
100n
B B 2341 K 7
6325
C6V8
10u/50V
2346
2342 K 6
2335 2337 2321 2343 K 3
2344 A 8
10p 4p7 10p 2345 J10
2346 B10
3355
3331
6k8
2347 I11
56k 2348 A10
+42V
+37V
+52V
+42V
+52V
2349 J11
7329 9
17 3 4 1 2350 A 7
2351 J10
C C
+VP
+VL
2352 H 5
+VH
STK496-430
100W = STK496-090 2353 E14
BZX79/C15
70W = STK496-070 2k2 for 2354 F14
6360
3386
6k8
30V 2355 E18
+VS 5 100W Versions DC 2356 G18
-30V 2366
-VS 6 2363 A 7
1325 4p7 2364 J10
CONTROL SW 3 ab 2365 K 4
4 3321 2u2/50V 3385 100W Versions SPEAKER CLICKFIT 2366 C12
L GND 2 3363
3365
3370
3369
10k 82k 1321 2367 B8
47k
47k
82k
68k
2n2 for /37 1R 2368 I8
2323 4R7
2325
CH1
3n3
D 18 IN1 D
2329
470p
9321 10 2369 I9
3325
3327
1k2
56k
+ OUT1 614 0V0V 5321 4 3 A16
3391 19 NF1 3321 D 2
220 - 1uH
11 +L 3322 F 2
22n 4n7 for /37
22u/50V 680 for 70W
for /37 only 3323 F 3
not for /37
2353
100n
3324 G 4
2327
220p
560R
470R
3329
2331 3325 D 4
5 3326 F 4
3387
10k
GND
2355
4n7 L 3327 D 5
for /37 only T1 513 3328 F 5
2333
E 20
12 CCC THERMAL HST1 GND -L E 3329 E 5
T2 12 3330 G 5
-50V
-40V -42V
-52V DETECTOR 3 3 3331 C 6
4 3332 H 6
3333 A 8
3322 4
SUPPLY GND_L
3334 J11
6 2324 2n2 for /37 3335 K 8
R 100W Versions 3364 GROUND 3336 K 6
3366
10k
82k
68k
470p 4R7
3392 2330
2u2/50V CH2 82k 3337 K 8
22
14 IN2 3338 K 6
2326
9322
3326
3328
3n3
1k2
56k
+ OUT2 715 5322 1
for /37 only
0V0V 3341 K 8
F 21 NF2 F 3342 K 5
220
- 1uH 3343 K 9
22n 4n7 for /37
13 3344 K 5
only for only for +R
2354
100n
-50V -52V
-40V -42V
3389
22R
9358
3345 G 2
70W Versions 100W Versions
22u/50V 680 for 70W
3323 3346 H 3
not for /37
-52V
-42V
2356
7326 3347 G 3
560R
470R
2328
220p
3330
3388
100k
10k
BC547B 3348 G 4
R 3350 K 5
3324
10k
-52V
-42V 3351 J 4
GND -R
BZX79/C15
BZX79/C15
3352 J 3
2334
6334
6333
9358
9359
3353 K 5
3358
G 5 2 G
1k
3355 C12
-52V
-VC2
-VC1
3356 I12
-VH
-VP
-V0
-VL
3347 -50V
3348
3358 G 5
33k 100R GND_R 3363 D14
3345 816 111 10
2 9 7 8 3364 E14
+37V
+42V
AMP 82k for 82k for
1000u/10V
-52V
-42V
-36V
-37V
3368
3367
-42V
-36V
-52V
3 4,5V
4,7V 3332
82k
82k
7325 1328 3365 D13
2352
100k 100W Versions 100W Versions
OFF -42V
-52V -52V
-42V BC547B 56k 1 3366 F13
-51V
-41V 3367 H15
3346
-42V 2336 2322
10k
-52V 2338 3368 H14
3k9 for 3k9 for 3369 D18
10p 10p
3384
3383
3k3
12k
3k3
12k
H 8 4p7 H 3370 D17
100W Versions 100W Versions 3383 H15
SAT SAT
3384 H14
3385 D12
for /37 only
for /37 only
-37V-42V 6 3386 C13
-VL
2368
2369
3387 E17
100n
100n
3388 G17
2
C6V8
3389 F13
10u/50V
1N4003
6326
2347
6330
5321 D14
7 5322 F14
HST1 HST1 5323 D14
I I 5324 F14
9329
1 6325 B12
3356
6k8
ab ab 6326 I12
1N4003
6327 A13
6328
2 6328 I13
DC DC
3334 7 6329 A13
-52V-42V
47R -VH 3 6330 I13
6333 G14
for /37 only
6334 G14
100n/63V
22u/100V
10u/100V
22u/50V
2351
1N4148
2364
2345
2349
6337 J 3
6337
3352
100k
J J 6339 K 5
-42V
-52V 9325
9326 6360 C12
3351 7327 7323 K 7
100k BC546B ONLY FOR SURROUND VERSIONS 7324 K 7
-52V
-42V -42V 7325 H 4
-52V 7326 G 4
2343
2,2u
0V 6339 0V 7327 J 4
7329 C 6
7350 1N4148 7324 7323 7350 K 4
BC546B BC546B 9321 D 2
3353
-52V BC556
22k
0V 9322 F 2
K -42V 3338 -42V
-36V -42V
-36V 3337 K 9323 A12
0V 1k 1k 9324 J 6
9325 J 6
9326 J 6
2365
0R22
0R22
0R22
0R22
3342
3341
3350
3344
3336
3335
3343
22n
9327
9328
1k2
1k2
1k
9327 K 9
1k
1k
9328 K10
-36V
-42V 9329 I12
9330 F12
9331 D12
SOAR PROTECTION 9358 G14
9359 G15
............. Vdc measured during AMPLIFIER ON
L
V EVM L
V Vdc measured during AMPLIFIER OFF (mute)
Voltages measured at nominal mains voltage and low output signal
P5VA
P5VA
L/RL/R
Amplifier
Amplifier
70/100W
130W 2000 03 27
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
9-8 9-8
011 C9
1 2 3 4 5 6 7 8 9 012 A9
1350 A2
1351 A1
POWER SUPPLY CDR 1353 B2
1354 E9
+5V REGULATOR 3350 1355 A1
3K3 2350 A7
1351
1350 2351 B8
1
A from P4 +CDR Overcurrent Sensor A 2352 B4
2350
CDR Transformer Regulator
10u
Switching transistor
11V AC 2 T2A5 0.5V 2353 B8
6350 6351 7350
012 2354 C1
1N5392 1N5392 BD438 BC557C BD438
12.9V +5V 2355 C2
7351 5.2V 7352 5.2V 2356 C5
5.2V 7 2357 D6
6352 6353 +CDR 2358 D2
2351
BZX79-F3V9
47u
6
to CDR Module
1N5392 1N5392
2352
2359 D3
6m8
3351 4.4V
6354
2353
2360 E2
4u7
12.3V 5
GND_P
3353
3352
2361 F6
1K
1K
100R
4 2362 F6
100K
3354
3355
4K7
T315mA
Overvoltage 3356 2363 F8
1353
GND_P
B Protection
1V 100R
GND_D 12.2V
3
B 3350 A7
BZX79-C5V6
BZX79-C3V3
+12M 2 3351 B7
120R
3357
-8.4V 3352 B5
6355
6356
7353 -8V 1 3353 B6
1.8V BC547C DIPMATE 3354 B4
1N4003
1N4003
2354
470u
2355
470u
6357
6358
0.9V 3355 B6
0.2V 7354 3356 B7
1N4148
BC547C 3357 B8
110R
150R
150R
3376
3358
6359
3359
3358 C5
3360
100n
2356
1K
3359 C8
VOLTAGE DOUBLER 3360 C6
C C 3361 D5
3362 D7
1N4003
1N4003
-8.4V REGULATOR 3363 D2
6360
6361
GND_P GND_P GND_P GND_P GND_D 011 3364 D3
7355 0.6V 3365 E6
from Power-Supply part
BC327-40
BC337-40 CDR-ON 1 3366 E7
-13.8V 7357 -8.4V 0.6V
7356
-8V 2 3369 E5
3362
100n
2357
3361
22K
10K
BC547C 0.6V 3370 E5
3 3371 E3
-8.9V
3372 E6
GND_P 4
2358
2359
3373 F5
47u
1m
560R
3363
12.2V 3374 F3
470R
+12M
3364
GND_P GND_P GND_P GND_P
D DIPMATE D 3375 F4
3376 C4
+12M 6350 A3
FAN CONTROL
BZX79-C4V7
+12M 6351 A3
GND_P 6352 B3
6362
GND_P 6353 B3
6354 B8
100u
2360
220R
3365
3366
6355 B5
5R6
+5V SWITCHING PART 3369 6356 B6
BZX79-C3V9
BZX79-C5V1
CDR-ON 560R 6357 C2
6358 C2
6363
6364
6359 C7
E 12.2V
E 6360 C2
3370
1K8
6361 C2
5.3V 11.8V BC327-25
1354 6362 D3
3371 7358 6363 E3
GND_P GND_P 5V BC557C 10.5V 7.9V 1 +
GND_P 6364 E4
3372
FAN
7359
1K
100K 7.9V
2 6365 F7
3373
2363
100u
7360 6365 - 7350 A6
0V
3374
39K
10K BC547C EH-B 7351 A5
7352 A7
3375
BZX79-C3V9
10K
7353 B7
2361
100u
2362
7354 C6
7355 C5
t
F GND_P GND_P
F 7356 C7
7357 C3
7358 E7
GND_P GND_P GND_P GND_P GND_P 7359 E4
7360 F5
Circuit Diagram PowerSupply CDR (15.02.2000)
1 2 3 4 5 6 7 8 9
9-9 9-9
011 B4
012 B3
1350 A7
E D C B A 1351
1353
A7
D7 A B C D E
1354 B1
1355 A7
Component Layout component side view 2350
2351
D2
B2 Component Layout bottom side view
2352 B7
2353 E2 1351 1355
2354 E5
2355 E5
2356 D4
2357 B5 6353
2358 E4
7 7
2359
2360
D5
D6
7 6351
1353
7
2361 D1 9356
2362 C2 1350
2363 B1 9357 3358
6358
6357
3350 D1
3351 C2 9351
2352
3352 D2
6352
6350
3353 D2 9350
6 6
3354
3355
B6
D4
6 3376
6
3356 C3 2360
3354
3357 E1
3362
2354
3358 D7
6361
6360
3359 B3
3360 D3
3361 E3 2357
3362 B5 7356
5 5
7351
3364
E
6363
3363 D5 C
3363
E
5 5 2355
6362
3364 D5 B
7355
3365 C2
B
3366 D1 2359
3369 E2
C
3370 E3
E
3371 D4 9355
3355
7357
3372 C1
B
3374
3373 E3
3374 B4
4 4
C
9352
4 4 3375
3376
6350
E2
D6
A6 3371
2358
2356
6351 A7
E
E
6352 A6
7360
7354
3361
6353 A7
9353
6359
7353
B
B
6354 E1
3373
6355 D3
C
3360
C
3 3
C
6356 D3
9354
3 3 6357
6358
6359
E7
E7
C4 3356 6355
7352
6360 E6 6356 3370
6361 E6 3351
012
6362 D5 3369
E
3359
6363 C5 7359
7350
6364 E1 E
B
C
3352
3353
3375
6365 C1
2 B
E
2
C
7350 D2
2 2 7351
7352
C5
C3
3365
2350
B
2362
2351
7353 C3
C
7354 D3
6365
3372
7355 B5 2353
3350
7356 D5
6354
6364
3366
7357 D4 1354 2363 2361
E
7358 C1
1 1
7358
7359 E2
B
1 1 7360
9350
E3
C6
C
3357
9351 C6
9352 C4
9353 B3
9354 D3 This assembly drawing shows a summary
This assembly drawing shows a summary of all possible versions.
of all possible versions. 9355 E4 For components used in a specific version
For components used in a specific version 9356 C7 see schematic diagram respectively partslist.
9357 C6 CDR Supply Board Layout stage .2 (2000 02 16)
see schematic diagram respectively partslist. CDR Supply Board Layout stage .2 (2000 02 16)
E D C B A A B C D E
9-10 9-10
EXPLODED VIEW Power5VA Module
SCREW
3x10 TORX (2x)
501
502
SUPPLY PART
SCREW
3x16 TORX (2x)
CDR SUPPLY PART
506 (4x)
507
1241
LEFT/RIGHT
AMPLIFIER PART
511
SCREW
AIRFLOW 3x16 TORX (2x)
SCREW
2.9x13 TORX (3x)
508
509
512
SCREW
3x10 TORX (2x)
513
9-11
ELECTRICAL PARTSLIST POWER BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
MECHANICAL PARTS CAPACITORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
0002 4822 256 10556 HOLDER STK407/P5-VA 2333 4822 124 81151 22µF 20% 50V
0222 3103 304 07050 INSULATING WASHER (TO126) 2334 4822 124 81151 22µF 20% 50V
1241 4822 361 11161 KD1206PTS3, FAN 2337 4822 122 10465 4,7pF 10% 50V
2338 4822 122 10465 4,7pF 10% 50V
MISCELLANEOUS 2341 4822 126 11585 22nF 20% 50V
–––––––––––––––––––––––––––––––––––––––––––––––––––––
1321 4822 267 31176 SPEAKER TERMINAL 2342 4822 126 11585 22nF 20% 50V
1901 4822 265 31015! MAINS SOCKET, IEC 2343 4822 124 22652 2,2µF 20% 50V
1901 4822 265 31016! MAINS SOCKET, UL 2344 4822 124 40764 22µF 20% 100V
1902 4822 272 10269! VOLTAGE SELECTOR 2345 4822 124 40764 22µF 20% 100V
1903 4822 071 52001! FUSE 200mA/T 2348 4822 124 81043 10µF 20% 100V
1905 4822 071 55002! FUSE T5A 2349 4822 124 81043 10µF 20% 100V
1905 4822 252 51123! FUSE T6,3A 2350 5322 121 42386 100nF 5% 63V
1906 4822 071 52502! FUSE T 2,5A 2351 5322 121 42386 100nF 5% 63V
1907 4822 071 52502! FUSE T 2,5A 2352 4822 124 40181 220µF 20% 10V
1920 4822 071 55002! FUSE T5A 2353 5322 121 42386 100nF 5% 63V
1923 4822 071 55002! FUSE T5A 2354 5322 121 42386 100nF 5% 63V
1924 4822 071 52502! FUSE T 2,5A 2355 5322 122 32261 4,7nF 10% 100V
1925 4822 071 51602! FUSE 1,6A 2356 5322 122 32261 4,7nF 10% 100V
5903 4822 146 11142! STAND BY TRAFO, for /37 only 2365 4822 126 12785 47nF 20% 50V
5903 4822 146 11143! STAND BY TRAFO, for /22 only 2367 5322 121 42386 100nF 5% 63V
5903 4822 146 11144! STAND BY TRAFO, for /21 only 2368 5322 121 42386 100nF 5% 63V
5905 4822 280 10382! STAND BY RELAIS, SDT-SS-109DM 2369 5322 121 42386 100nF 5% 63V
2399 4822 126 12882 100nF 20% 50V
CAPACITORS 2902 4822 121 43526 47nF 5% 100V
––––––––––––––––––––––––––––––––––––––––––––––––––––– 2903 4822 121 43526 47nF 5% 100V
2254 4822 121 43526 47nF 5% 100V
2255 4822 121 43526 47nF 5% 100V 2904 4822 124 40255 100µF 20% 50V
2256 4822 121 43526 47nF 5% 100V 2905 4822 124 40207 100µF 20% 25V
2257 4822 124 11504 6800µF 20 63V
2257 4822 124 80415 4700µF 20% 50V RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
2258 4822 124 11504 6800µF 20 63V 3251 4822 116 52256 2,2kΩ 5% 0,16W
2258 4822 124 80415 4700µF 20% 50V 3252 4822 116 52256 2,2kΩ 5% 0,16W
2263 5322 121 42386 100nF 5% 63V 3254 4822 116 52228 680Ω 5% 0,5W
2264 5322 121 42386 100nF 5% 63V 3255 4822 116 83883 470Ω 5% 0,16W
2265 4822 124 80563 4700µF 20% 35V 3259 4822 050 21003 10kΩ 2% 0,25W
2267 4822 124 40255 100µF 20% 50V 3260 4822 117 11342 0,33Ω 5% 2W
2268 4822 124 40769 4,7µF 20% 100V 3261 4822 116 52206 120Ω 5% 0,5W
2269 4822 121 51387 10nF 20% 16V 3262 4822 116 52206 120Ω 5% 0,5W
2269 4822 122 10577 3,3nF 10% 16V 3263 4822 050 21003 10kΩ 2% 0,25W
2270 4822 124 40248 10µF 20% 63V 3265 4822 116 52234 100kΩ 5% 0,5W
2271 4822 124 40433 47µF 20% 25V 3266 4822 116 52228 680Ω 5% 0,5W
2279 5322 121 42386 100nF 5% 63V 3267 4822 116 52276 3,9kΩ 5% 0,5W
2280 4822 124 12328 6800µF 20% 16V 3268 4822 050 21003 10kΩ 2% 0,25W
2282 4822 124 40248 10µF 20% 63V 3269 4822 116 83881 390Ω 5% 0,5W
2285 4822 124 40255 100µF 20% 50V 3270 4822 117 11342 0,33Ω 5% 2W
2289 4822 124 21913 1µF 20% 63V 3272 4822 116 52263 2,7kΩ 5% 0,5W
2300 4822 121 51387 10nF 20% 16V 3273 4822 116 52244 15kΩ 5% 0,5W
2301 4822 124 41584 100µF 20% 10V 3274 4822 050 23303 33kΩ 1% 0,6W
2303 4822 121 41857 10nF 5% 250V 3275 4822 050 23303 33kΩ 1% 0,6W
2323 4822 124 22652 2,2µF 20% 50V 3278 4822 116 52256 2,2kΩ 5% 0,16W
2324 4822 124 22652 2,2µF 20% 50V 3280 4822 116 52239 120kΩ 5% 0,5W
2325 4822 122 33532 3,3nF 5% 50V 3281 4822 050 21003 10kΩ 2% 0,25W
2326 4822 122 33532 3,3nF 5% 50V 3282 4822 052 10339! 33Ω 5% NFR
2327 5322 122 32334 220pF 10% 100V 3285 4822 116 83961 6,8kΩ 5% 0,16W
2328 5322 122 32334 220pF 10% 100V 3286 4822 116 83961 6,8kΩ 5% 0,16W
2329 5322 122 32311 470pF 10% 100V 3287 4822 116 52257 22kΩ 5% 0,5W
2329 5322 122 32818 2,2nF 10% 100V 3288 4822 052 10399! 39Ω 5% 0,33W
2330 5322 122 32311 470pF 10% 100V 3289 4822 052 10399! 39Ω 5% 0,33W
2330 5322 122 32818 2,2nF 10% 100V 3302 4822 116 83884 47kΩ 5% 0,16W
2331 5322 122 32261 4,7nF 10% 100V 3304 4822 116 83884 47kΩ 5% 0,16W
9-12
ELECTRICAL PARTSLIST POWER BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
RESISTORS RESISTORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
3305 4822 116 52257 22kΩ 5% 0,5W 3905 4822 116 52256 2,2kΩ 5% 0,16W
3306 4822 116 83882 39kΩ 5% 0,5W 3906 4822 050 21003 10kΩ 2% 0,25W
3309 4822 050 23303 33kΩ 1% 0,6W 3908 4822 053 10121! 120Ω 5% 1W
3312 4822 050 21003 10kΩ 2% 0,25W 3908 4822 053 10471! 470Ω 5% 1W
3313 4822 050 11002 1kΩ 5% 0,2W 3920 4822 052 10108! 1Ω 5% 0,33W
3315 4822 116 52291 56kΩ 5% 0,5W COILS
3316 4822 116 83884 47kΩ 5% 0,16W –––––––––––––––––––––––––––––––––––––––––––––––––––––
3317 4822 116 52176 10Ω 5% 0,5W 5321 4822 157 70599 1µH
3321 4822 050 21003 10kΩ 2% 0,25W 5322 4822 157 70599 1µH
3322 4822 050 21003 10kΩ 2% 0,25W 5901 4822 157 11832! 400µH
5902 4822 157 11628! MAINS CHOKE
3323 4822 116 52234 100kΩ 5% 0,5W
3324 4822 050 21003 10kΩ 2% 0,25W DIODES
3325 4822 116 52207 1,2kΩ 5% 0,5W –––––––––––––––––––––––––––––––––––––––––––––––––––––
3326 4822 116 52207 1,2kΩ 5% 0,5W 6252 5322 130 80686 1N5392
3327 4822 116 52291 56kΩ 5% 0,5W 6253 4822 130 31878 1N4003G
6255 4822 130 11139! GBU8D
3328 4822 116 52291 56kΩ 5% 0,5W 6260 5322 130 80686 1N5392
3329 4822 116 52226 560Ω 5% 0,5W 6261 5322 130 80686 1N5392
3330 4822 116 52226 560Ω 5% 0,5W
3331 4822 116 52291 56kΩ 5% 0,5W 6262 5322 130 80686 1N5392
3332 4822 116 52291 56kΩ 5% 0,5W 6263 5322 130 80686 1N5392
6264 9331 668 80133 DIO REG BZX79-B11
3333 4822 052 10479! 47Ω 5% 0,3W 6269 4822 130 34281 BZX79-C15
3334 4822 052 10479! 47Ω 5% 0,3W 6270 4822 130 30621 1N4148
3335 4822 116 52207 1,2kΩ 5% 0,5W
3336 4822 116 52207 1,2kΩ 5% 0,5W 6271 4822 130 30621 1N4148
3337 4822 050 11002 1kΩ 5% 0,2W 6281 4822 130 31878 1N4003G
6284 4822 130 34173 BZX79-B5V6
3338 4822 050 11002 1kΩ 5% 0,2W 6285 4822 130 31878 1N4003G
3341 4822 117 11744! 0,22Ω 5% 1W 6290 4822 130 34328 BZX79-C30
3342 4822 117 11744! 0,22Ω 5% 1W
3343 4822 117 11744! 0,22Ω 5% 1W 6292 4822 130 30621 1N4148
3344 4822 117 11744! 0,22Ω 5% 1W 6293 4822 130 34382 BZX79-B8V2
6294 5322 130 80686 1N5392
3345 4822 116 52234 100kΩ 5% 0,5W 6295 4822 130 30621 1N4148
3346 4822 050 21003 10kΩ 2% 0,25W 6298 4822 130 34278 BZX79-C6V8
3347 4822 050 23303 33kΩ 1% 0,6W
3348 4822 116 83872 220Ω 5% 0,5W 6299 4822 130 30621 1N4148
3350 4822 050 11002 1kΩ 5% 0,2W 6301 4822 130 30621 1N4148
6302 5322 130 31504 BZX79-B3V3
3351 4822 116 52234 100kΩ 5% 0,5W 6337 4822 130 30621 1N4148
3352 4822 116 52234 100kΩ 5% 0,5W 6339 4822 130 30621 1N4148
3353 4822 116 52257 22kΩ 5% 0,5W
3358 4822 050 11002 1kΩ 5% 0,2W 6900 4822 130 31878 1N4003G
3363 4822 053 10478! 4,7Ω 5% 1W 6901 4822 130 31878 1N4003G
6902 4822 130 31878 1N4003G
3364 4822 053 10478! 4,7Ω 5% 1W 6903 4822 130 31878 1N4003G
3365 4822 116 52304 82kΩ 5% 0,5W 6904 4822 130 31878 1N4003G
3366 4822 116 52304 82kΩ 5% 0,5W
3367 4822 116 52304 82kΩ 5% 0,5W 6905 4822 130 30621 1N4148
3368 4822 116 52304 82kΩ 5% 0,5W 6906 4822 130 30621 1N4148
6908 4822 130 34382 BZX79-B8V2
3369 4822 116 83884 47kΩ 5% 0,16W 6909 4822 130 32245 BYV10-40
3370 4822 116 83884 47kΩ 5% 0,16W 6910 4822 130 31878 1N4003G
3383 4822 116 83884 47kΩ 5% 0,16W
3384 4822 116 52276 3,9kΩ 5% 0,5W 6911 4822 130 30621 1N4148
3386 4822 116 52256 2,2kΩ 5% 0,16W 6912 4822 130 30621 1N4148
3387 4822 050 21003 10kΩ 2% 0,25W TRANSISTORS
3388 4822 050 21003 10kΩ 2% 0,25W –––––––––––––––––––––––––––––––––––––––––––––––––––––
3389 4822 052 10229 22Ω 5% 0,33W 7251 9322 139 23687 BDX53BFP
3391 4822 116 83872 220Ω 5% 0,5W 7252 4822 130 40959 BC547B
3392 4822 116 83872 220Ω 5% 0,5W 7253 4822 130 40959 BC547B
7255 4822 130 40959 BC547B
3901 4822 053 21106! 10MΩ 5% 0,5W 7260 4822 130 40959 BC547B
3902 4822 050 11002 1kΩ 5% 0,2W
3903 4822 050 11002 1kΩ 5% 0,2W 7263 4822 130 40981 BC337-25
3904 4822 116 52244 15kΩ 5% 0,5W 7265 4822 130 41691 BC556B
3904 4822 116 52283 4,7kΩ 5% 0,5W 7266 4822 130 44568 BC557B
7268 4822 130 40959 BC547B
7280 4822 130 40959 BC547B
9-13
ELECTRICAL PARTSLIST POWER BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
TRANSISTORS INTEGRATED CIRCUITS
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
7282 4822 130 41327! BC327-40 7281 4822 209 31841 L7805CP
7286 4822 130 41327! BC327-40 7329 9322 084 99682 STK496-090C, POWER AMPLIFIER
7323 4822 130 44461 BC546B
7324 4822 130 44461 BC546B
7325 4822 130 40959 BC547B
7326 4822 130 40959 BC547B
7327 4822 130 44461 BC546B
7350 4822 130 41691 BC556B
7901 4822 130 41246 BC327-25
7902 4822 130 40959 BC547B
ELECTRICAL PARTSLIST POWER SUPPLY CDR BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
MISCELLANEOUS DIODES
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
1350 4822 071 52502! FUSE T 2,5A 6350 5322 130 80686 1N5392
1353 4822 071 53151! FUSE 315mA 6351 5322 130 80686 1N5392
6352 5322 130 80686 1N5392
CAPACITORS 6353 5322 130 80686 1N5392
––––––––––––––––––––––––––––––––––––––––––––––––––––– 6354 3198 010 53980 DIO REG BZX79-B3V9
2350 4822 124 11947 10µF 20% 16V
2351 4822 124 40433 47µF 20% 25V 6355 4822 130 34173 BZX79-B5V6
2352 4822 124 12328 6800µF 20% 16V 6356 5322 130 31504 BZX79-B3V3
2353 4822 124 40769 4,7µF 20% 100V 6357 4822 130 31878 1N4003G
2354 4822 124 80791 470µF 20% 16V 6358 4822 130 31878 1N4003G
6359 4822 130 30621 1N4148
2355 4822 124 80791 470µF 20% 16V
2356 5322 121 42386 100nF 5% 63V 6360 4822 130 31878 1N4003G
2357 5322 121 42386 100nF 5% 63V 6361 4822 130 31878 1N4003G
2358 4822 124 81144 1000µF 20% 16V 6362 4822 130 34174 BZX79-B4V7
2359 4822 124 40433 47µF 20% 25V 6363 4822 130 31981 BZX79-B3V9
6364 4822 130 34233 BZX79-B5V1
2360 4822 124 41584 100µF 20% 10V
2361 4822 124 23052 100µF 20% 16V 6365 4822 130 31981 BZX79-B3V9
2363 4822 124 23052 100µF 20% 16V
TRANSISTORS
RESISTORS –––––––––––––––––––––––––––––––––––––––––––––––––––––
––––––––––––––––––––––––––––––––––––––––––––––––––––– 7350 9336 500 90126 BC557C
2362 4822 117 12063 10kΩ NTC 7351 4822 130 40995 BD438
3350 4822 116 52269 3,3kΩ 5% 0,5W 7352 4822 130 40995 BD438
3351 4822 116 52175 100Ω 5% 0,5W 7353 4822 130 44503 BC547C
3352 4822 050 11002 1kΩ 5% 0,2W 7354 4822 130 44503 BC547C
3353 4822 050 11002 1kΩ 5% 0,2W
7355 4822 130 41344 BC337-40
3354 4822 116 52234 100kΩ 5% 0,5W 7356 4822 130 44503 BC547C
3355 4822 116 52283 4,7kΩ 5% 0,5W 7357 4822 130 41327 BC327-40
3356 4822 116 52175 100Ω 5% 0,5W 7358 4822 130 41246 BC327-25
3357 4822 116 52206 120Ω 5% 0,5W 7359 9336 500 90126 BC557C
3358 4822 053 11151! 150Ω 5% 2W
7360 4822 130 44503 BC547C
3359 4822 050 21101 110Ω 1% 0,6W
3360 4822 050 11002 1kΩ 5% 0,2W
3361 4822 050 21003 10kΩ 2% 0,25W
3362 4822 116 52257 22kΩ 5% 0,5W
3363 4822 116 52226 560Ω 5% 0,5W
3364 4822 116 83883 470Ω 5% 0,16W
3365 4822 116 83872 220Ω 5% 0,5W
3366 4822 052 10568! 5,6Ω 5% 0,33W
3369 4822 116 52226 560Ω 5% 0,5W
3370 4822 116 52249 1,8kΩ 5% 0,16W
3371 4822 116 52234 100kΩ 5% 0,5W
3372 4822 050 11002 1kΩ 5% 0,2W
3373 4822 050 21003 10kΩ 2% 0,25W
3374 4822 116 83882 39kΩ 5% 0,5W
3375 4822 050 21003 10kΩ 2% 0,25W
3376 4822 053 11151! 150Ω 5% 2W
10-1
3CDC99-DS Module
(3 Disc Carousel Changer)
TABLE OF CONTENTS
Dismantling Hints.............................................................10-2
Servicing Hints.................................................................10-3
Lubrication Instructions....................................................10-4
ESD Warnings ................................................................10-6
Blockdiagram ...................................................................10-7
Wiring ..............................................................................10-8
Circuit Diagram part1.......................................................10-9
Component Layout .......................................................10-10
Circuit Diagram part2.....................................................10-11
Exploded View...............................................................10-12
Mechanical Partslist.......................................................10-13
Electrical Partslist ..........................................................10-15
10-2
Dismantling Hints
B B
C
D
A
Dismantling of Drawer Dismantling of Flex Plate
→ A Pull drawer outwards → D Lift plate to unlock pin from bottom plate
→ B Unlock drawer with screwdriver → E Move plate inwards to demount from bottom plate
→ C Lift drawer to demount from chassis
10-3
Servicing Hints
Replacement of CD Drive
See also exploded view of changer mechanism.
1. Dismantle printed circuit board: remove 5 screws. 5. Dismantle CD drive support (pos 95) B.
2. Disconnect flexfoil cable and JST connector. 6. Replace CD drive (pos 100). The wire tree of JST
Pay attention to WARNING! connector has to be desoldered and resoldered on the
3. Loosen 2 screws (pos 107,108) and remove CD drive- new CD drive again.
lockings (pos 105,106).
4. Turn gearwheel (pos 42) of disc change mechanism by
finger to move CD drive support in upper position as
shown in picture below A.
Mounting of Carousel
1. Turn gearwheel (pos 42) of disc change mechanism by finger until CD drive is in play position.
2. Mount carousel (pos 115) so that disc is positioned right on turntable. Carousel position number doesn´t matter.
10-4
Lubrication Instructions
CHASSIS
Grease
Grease inside grove
Grease on top of rib
Grease
DRAWER
Grease on four Grease inside Grease on slide
rectangular surfaces groves
Grease on four
profile groves
Grease on top
of highest ring
10-5
DRAWER MECHANISM
Grease
DISC CHANGE MECHANISM
Grease
Grease
Grease on first
and last tooth
Grease on first
and last tooth
Use only grease Polylub GLY 801 service codenumber 4822 390 10136
10-6
WARNING
CHARGED CAPACITORS ON THE SERVO BOARD MAY DAMAGE THE CD DRIVE ELECTRONICS WHEN
CONNECTING A NEW CD MECHANISM. THAT´S WHY, BESIDES THE SAFETY MEASURES LIKE
• SWITCH OFF POWER SUPPLY
• ESD PROTECTION
ADDITIONAL ACTIONS MUST BE TAKEN BY THE REPAIR TECHNICIAN.
The following steps have to be done when replacing the CD mechanism:
1. Disconnect flexfoil cable from old CD drive
2. Put a paper clip onto the flexfoil cable to short-circuit connections (fig.1) fig.1
3. Remove old CD drive
4. Remove paper clip from flexfoil cable
5. Connect flexfoil cable to new CD drive
6. Position new CD drive on its studs
7. Remove soldered short-circuit from Laserunit (see below)
Attention: The laser diode of this CD drive is protected against ESD by a solder joint which shortcircuits the laser
diode to ground.
For proper functionality of the CD drive this solder joint must be removed after connecting the drive to
the set.
Service Position
10-7
Blockdiagram
CD MECHANISM PHOTODIODE & HF AMPLIFIER - LOADER CONTROL PCB 1805
+10V 18
+5V 20
DISC 7876
7806 7877
TDA7073A RCK EXCK 1321
TURNTABLE FOC + DQSY
SUB SBSO DQSY
MOTOR 1222
FOCUS 55 FO SBSY SCOR SRDT
MOTOR FOC - SRDT
SFSY WFCK 11 20
CL11 MCK SCLK
µP_CLK
CD Text
LC89170M
RAD +
RADIAL 54 7810
RA
MOTOR RAD -
16 23
SERIAL INTERFACE
D/A
CD LEFT
7807 WLCK 28 WCLK 1
TDA7073A 27 DATA 2
D/A
SLEDGE + SERVO - DECODER DATA
Converter
SLEDGE 56 CD10 29 SCLK 3 PCM1716
SL SLCK
MOTOR SLEDGE - SAA7324 (SAA7325)
13 21
D/A
CD RIGHT
TTM - 59
MOT1 7878
TURNTABLE 5 8,9,15
MOTOR TTM + 26 CL16
60 CL16 +10V
MOT2
CONNECTED VIA FLEXFOIL 8001 TO SET
LASER & MC78L05ACP
MONITOR +5V +3,3V
DIODE 38 10
2 13 7801 PORE
1 PORE
LD
7 64 42 12
LD ON SILD
SILD
40 14
SCL
SICL
4 7874
MON 11 61
CD R/W V4 Level converter
PHOTO Laser Control 39 13
DIODES & SDA DATA
HF AMPLIFIER
D4 D2-D4 5 TZA1024 (TZA1025) 10 2
D1 D5 HF IN
D2 D3 7875
6,14
D1
D1-D5 D2 +3,3V
D3 VCC +5V
D4 5,17,21,52,57
R1,R2 V1 KILL DOBM
INNER SWITCH
63 34 32 51
7
EBU OUT
9
KILL L
5
KILL R
17
SWITCH INFO SWITCH INFO
7873
1882 2
DATA
Closed if carrousel is in Position 1. 11
O7
3 15
SHR_CL
CD POS.1 SWITCH SHR_CL
1880 1 16
STB
SHR-STR
Closed if the tray is in one endposition. 12
O6
Open during movement.
TRAY SWITCH
1881 SHIFT
REGISTER
13
O5 16
HEF4094BT VDD +10V
CD DRIVE UP/DOWN SWITCH
5V1
7871
TDA7073A 15
4 EN1
OO V
CARROUSEL
MOTOR
5 VDD (pin 16)
O1
EN1 (pin 15)
t
Power on
6
O2
TRAY MOTOR
7
O3
Blockdiagram 3CDC99-DS 2000-02-17
10-8
Wiring of CD Drive
Pict. 1
8005
Pict. 2
10-9 10-9
1800 D2 2803 C5 2810 A4 2822 F9 2833 C10 2840 G4 2851 B11 2879 H5 2891 F4 3802 C4 3811 B4 3820 D3 3826 F9 3834 A4 3841 G5 3847 F5 3857 C2 3870 E3 3897 E7
1801 G1 2805 B5 2811 A5 2823 F10 2834 C10 2841 F5 2855 B4 2880 D8 2892 D5 3803 C4 3812 H5 3821 D3 3827 E10 3835 F5 3842 F5 3848 H6 3862 B10 3873 D14 7801 E7
1810 C10 2806 B5 2814 D5 2824 F10 2835 F7 2842 F4 2856 D15 2884 E8 3709 C14 3805 B4 3815 E5 3822 D3 3828 G10 3837 F7 3843 F5 3849 H5 3863 H13 3889 D15 7806 G3
2800 C4 2807 A4 2815 D5 2825 F9 2837 H4 2844 G5 2857 G5 2885 F9 3728 E14 3806 B4 3816 G12 3823 D8 3831 B14 3838 F6 3844 F5 3850 H5 3866 D7 3892 E15 7807 H3
2801 C5 2808 A5 2816 B12 2826 G12 2838 E8 2849 C1 2859 H5 2887 B10 3800 C4 3807 A4 3817 H12 3824 D8 3832 D15 3839 G6 3845 F5 3852 H5 3867 B11 3894 E9 7877 D12
2802 C4 2809 H4 2818 B11 2828 G13 2839 F4 2850 D14 2869 D3 2888 E5 3801 C4 3808 A4 3819 D14 3825 F9 3833 A4 3840 H6 3846 F5 3853 E9 3869 D3 3895 H12
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
3833 3808
3CDC-mainboard D1 R2 (CD10)
22K 10K Signal Processor
2810
180p
2811
220p
part 1
A 3834 3807 R1 (CD10)
A
D5
22K 10K
2807
330p
2808
220p
only for digital out versions
+3.3V +3.3V
3805
(Quartz used)
D4 (CD10)
10K to DAC (7810)
2806
220p
120R
3867
100R
3862
CL16 DATA WCLK SCLK
B D4 3811 3806 D3 (CD10) 3.2V B
+3.3V
18K 10K
2855
2805
470p
220p
3V
2887 100n
3831
22K
2818 2851 2816
1n5
to 1805 on part 2
47u 1n5
2834
2833
SELPLL
33p
33p
3802 3803
TEST1
TEST2
D3 D2 (CD10)
WCLK
VNEG
VPOS
SCLK
CL16
DATA
KILL_L
RN
RP
VDDA2
LN
EF
LP
56K 10K
+5V
2802
180p
2803
220p
TF01 1810 KILL
17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 KILL_R
16 CRIN VSSD1 33
33R
3857
TIMING
C D2 3800 3801 D1 (CD10)
+3.3V C
SER. DATA 3709
15 CROUT BITSTREAM DAC VERSAT. V2|V3 34
56K 10K INTERFACE KILL
2800
180p
2801
220p
INTERF. 3.3V 22K
14 VSSA2 WCLI 35
CD Drive 2849 4u7 5V Laser power control HF-Amplifier +3.3V
3822 2K7
3820 5K6
3821 5K6
VAM2202 1800
TZA1024 VrefCD10 3823 1K 13 R2 SER. DATA SDI 36
LOOPBACK 2850
100n
2880
7
3832
10K
# 2814 3824 1K
D5 GND 15 CMFB 8 INTERF.
PWRON 2x 1n
12 R1 SCLI 37
D3 14 100n 6 RFFB 9 3866 3819
GND PORE
D3
D D5 13 2815 5 DIN 4x RFEQO 10 10K 11 D4 7877 RESETn 38 470R
D
to 1805 on part 2
D4 PRE-
SAA7324 2856
33n PROCESSING
(uP-interface)
D2 VCC 12 CDRW 11 ADC
27p
2869
47n
10 D3 SDA 39
VrefCD10 1x SDA
VREF 11 4 MON EQSEL 12
MICROCONTROLLER
D1 CONTROL AUDIO 3873 470R
10 3869 4R7 2892 4n7 3 CFIL VCC2 13 3.1V 9 D2 FUNCTION PROCESSOR SCL 40 3889
LD U >400mV
INTERFACE
SICL
->Laser dead !
2884 4u7
MON 9 RGADJ 14 470R
3897 100R
V/I 8 D1 RAB 41
3870 100R 3815
Vgap
D4 8 2 VCCL
+5V
D1 1 LD 3853 1.5V 7 VRIN SILD 42 3892
7 4R7 V/I
2888
SILD
4u7
VREF GEN.
470R 470R
E D2 6 E
2838
10u
+3.3V +3.3V 6 IREF STATUS 43
7801
GND 5
L Servo driver 33K 3827 EFM SRAM
T+ 3894 5 VDDA1 TEST3 44 3728
4 3.2V DEMOD
TRACK Vref ADDR
F- 3 16 +3servo 33R 4K7
TRACK
FOCUS
1.6V
2842
4 VSSA1 FRONT RCK 45
3844
2885
+ 1
2n2
4K7
4u7
F+ - PEAK RCK
2825
2 3 END ERROR
10n
DIG.
PROCESSOR
TRACK 1.6V 3843 3842
3837
2 HF
1K
DET.
SUBCODE
CORR.
to 7876 on sheet 2
1 14 + 3 ISLICE PLL SUB 46
(CD-TEXT IC)
T- 33K 47K SUB
270p
2841
_ 15 3835 1.6V
3826
22K
13 EQSEL
1 2 HFIN EBU SFSY 47
11 +10V D Vref 3825 2822 HFIN MOTOR OUTPUT SFSY
F 3R3 HF INTERF. F
2835 47n
2839
3838 1K
2 5 10V VERSATILE
CONTROL STAGES
12 VDD 1K 1n5 1 HFREF SBSY 48
2823
47p
_ 6 1.6V 47u INTERFACE SBSY
3 2824
4 + Vref
1.6V
2891
3847
FOCUS 7 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49
1n8
6K8
4
10 - D D 47n
DOBM
V1
V5
V4
VSSD3
VDDD2C
SL
FO
RA
CFLG
VDDD1P
VSSD2
3846 3845
CL11|4
MOTO2
MOTO1
LDON
5 3V
9+ 8
FOCUS 33K 47K 3V for CD_DA : 0V
270p
2844
6
for CD_RW : 3V +3servo 2826
CL11
7806 TDA7073A 0V 3.2V
1801 D 0V
PH-S 47u
3828
EYE-PATTERN
22K
G Motor Driver 100K
Innersw to dig. out circuitry G
DOBM
during Focus search 3839 de_emph 3816 2828 on part 2
2857
3V
Innersw
to DAC(part2)
10n
2840
+ 16
100n
3841
4K7
1 47K 47u
- D 0V
DISC 3 DISC 0V 800mVpp
100K
3895
2
10R
3863
33R
+
14 3852
15 3812 3840
_ +10V
13 2837 2R2 +3servo
TB = 0.5µs/div M2 M1 SL FO RA
2859
11 2R2
10n
+3.3V +3.3V
5 10V 47u
12 VDD Vref 3817
6 D
...DC voltages measured
2809
0u47
3850
_ 1.6V
3K9
H + 680K in Play mode with following conditions H
SLIDE
4
7 1.6V 3849 100K V EVM
10 -
'+A'=+10.5V and '+5V'=+5V
SLIDE 100K 3848
2879
47n
+ 9 8
#.... for provision only
D
7807 TDA7073A
3CDC99-DS sheet1 2000-03-27
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
10-10 10-10
Mapping
3CDC99 DS Board Componentside view 1800
1801
E3
H5
3714
3715
H2
H3
3886
3887
J3
I3
3CDC99 DS Board Copperside view
1805 A1 3716 A2 3888 I3
1810 D3 3718 C5 3889 B5
1876 J1 3728 B5 3890 I3
1878 I1 3730 B5 3891 I3
1880 A5 3731 C5 3892 C4
1881 I2 3760 B3 3893 I3
1882 B5 3761 B3 3894 D4
2800 D2 3762 B3 3895 D5
2801 D3 3763 C4 3896 H3
2802 E2 3764 C2 3897 F1
2803 D3 3766 B3 3899 C2
2804 D5 3768 J4 5803 J1
2805 D3 3769 J4 5804 I1
2806 D3 3800 D2 5805 A5
2807 D2 3801 D2 6871 H4
2808 D3 3802 D3 6872 I4
2809 E5 3803 D2 6873 I4
2810 D2 3805 D2 6874 H4
2811 D3 3806 D2 6875 I4
2812 C2 3807 D2 6876 C1
2814 E2 3808 D2 6877 A3
2815 E1 3809 D5 7801 F2
2816 C4 3811 D2 7806 H3
2818 C3 3812 G4 7807 F5
2822 F4 3814 D2 7810 B3
2823 D4 3815 D1 7812 H3
2824 D4 3816 E5 7871 I1
2825 D4 3817 E4 7873 J4
2826 D4 3819 B5 7874 C1
2828 D5 3820 E2 7875 C2
2829 J2 3821 E2 7876 C5
2830 C2 3822 E3 7877 C4
2831 B2 3823 F1 7878 C2
2832 B2 3824 F1 9805 C1
2833 D2 3825 G3 9806 E2
2834 C2 3826 E4 9807 G5
2835 E5 3827 E3 9808 F1
2837 F4 3828 F4 9809 F4
2838 F4 3831 C2 9810 B3
2839 H4 3832 A2 9813 D1
2840 E5 3833 F2 9815 A2
2841 E5 3834 F2 9817 A5
2842 G4 3835 H4 9818 B1
2844 E5 3837 E5 9819 B2
2849 E4 3838 D5 9820 B2
2850 B4 3839 E5 9821 A4
2851 C3 3840 E5 9823 C1
2852 C5 3841 E5 9825 H1
2853 C5 3842 E5 9826 A1
2854 B3 3843 G4 9828 A5
2855 E2 3844 G4 9830 D1
2856 C4 3845 E5 9831 C4
2857 G5 3846 G4 9832 E5
2858 C3 3847 G3 9833 H1
2859 G5 3848 E5 9834 D1
2860 B3 3849 E5 9835 A1
2861 A2 3850 E5 9836 D5
2862 B4 3851 J2 9837 J3
2863 C3 3852 G5 9838 A1
2864 D5 3853 F4 9839 A1
2865 A3 3854 B2 9841 E4
2869 F2 3855 B2 9842 E4
2870 J1 3857 G4 9844 F4
2871 I1 3858 B2 9845 D5
2872 I4 3859 A2 9849 A4
2873 I2 3862 C3 9851 D5
2875 I3 3863 D5 9852 E5
2876 B3 3864 B3 9853 E4
2877 J3 3865 C3 9855 E3
2878 J3 3866 F2 9856 E3
2879 E5 3867 C3 9857 G2
2880 F2 3868 B2 9858 G3
2881 I3 3869 G2 9859 G3
2882 A3 3870 G2 9861 G5
2884 E2 3871 I3 9862 G5
2885 E3 3872 A2 9863 G2
2887 C4 3873 B5 9864 F3
2888 E1 3874 A3 9876 C1
2891 G3 3875 C1 9884 G3
2892 E2 3876 A2 9885 G2
2893 J3 3877 I3 9886 C3
3700 C5 3878 D1 9887 H4
3705 D5 3879 J3 9888 H4
3706 C5 3880 I2 9889 H4
This assembly drawing shows a summary Transistor pinning 3707 C5 3881 I2 9898 J1 This assembly drawing shows a summary Transistor pinning
of all possible versions.
C 3708 C5 3882 J3 9899 I1 of all possible versions.
C
For components used in a specific version B 3709 B4 3883 J2 For components used in a specific version B
see schematic diagram respectively partslist. E 3CDC99DS Layout stage .3 2000 02 09 3711 B5 3884 I2 see schematic diagram respectively partslist. E 3CDC99DS Layout stage .3 2000 02 09
3713 I3 3885 J3
10-11 10-11
1805 H15 2804 H4 2852 I2 2862 C2 2872 F10 2881 F8 3707 H4 3716 H12 3762 A3 3809 H11 3859 B7 3874 B13 3880 G6 3886 G6 3896 G10 6872 D8 7810 A3 7876 H3 9839 C14
1876 F3 2812 C1 2853 H4 2863 D2 2873 F5 2882 D5 3708 H4 3718 H3 3763 B3 3814 C12 3864 C2 3875 C12 3881 G6 3887 D12 3899 D12 6873 C8 7812 F8 7878 C1 9876 C13
1878 G3 2829 F5 2854 C5 2864 H12 2875 G5 2893 F12 3711 H5 3730 H2 3764 C1 3851 F6 3865 C2 3876 B12 3882 F6 3888 E12 5803 F3 6874 G7 7871 G5 9826 H14 9898 E3
1880 D8 2830 D2 2858 D3 2865 B5 2876 C2 3700 I2 3713 F8 3731 H2 3766 A5 3854 A7 3868 G14 3877 E11 3883 F6 3890 E11 5804 F3 6875 E12 7873 C10 9834 F10 9899 G3
1881 D8 2831 B8 2860 A7 2870 F3 2877 F11 3705 H4 3714 F8 3760 A3 3768 D7 3855 B7 3871 E11 3878 C7 3884 F6 3891 F11 5805 C11 6876 C13 7874 B12 9835 G11
1882 C8 2832 A8 2861 B7 2871 G3 2878 F11 3706 H4 3715 G8 3761 A3 3769 D7 3858 A7 3872 B13 3879 F6 3885 E6 3893 F11 6871 D8 6877 D12 7875 C12 9838 C14
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
3CDC mainboard / part 2 7810 PCM1716
WCLK 3760 1 28 2860 3854
LRCIN ML
1K 22u 100R
A A
3858
2832
22K
3n3
DATA 3761 2
FROM 7877 ON PART 1
27
DIN MC de_emph
1K from7877 (part1)
3766
10K
SCLK 3762 3 26
BCKIN MD GNDA GNDA
1K
2861 3855
4 25
CLKO MUTE 22u 100R
3876 +3.3V
2831
3859
3874 10K
3n3
3872 10K
22K
CL16 3763 5 100K # #
B XTI MODE
24 B
to/from 7877 on part 1
820R
SICL
6 23 GNDA GNDA
XTO CS 3.2V SILD
DAC 7874
SDA
100n
2865
SDA
7 22 3V-5V log. Level
DGND RST 0V
Transformer
MC78L05ACP +3.3V
3764 7878 BC547B
3864 5V 8 21 5805 4U7
VDD ZERO
+10V 1 3 10R for provision only
2812
2876
220u
2862
C 3R3 3875 10K 9876 C
47n
47n
5V 9 20 47n SW_INFO +3.3V
2 5V 6876
VCC 2R VCC 2L GNDA 4,2V 3814
2854 voltage stab. 7875
8 7873 +3.3V 33R
GNDA 1N4148
GNDA GNDA 3865 10 19 1882
5.6V version only
GNDA AGND 2R 3878 6873 VSS
AGND 2L POS 1 rec. 10 BC547B
10R
220u
2863
2882
2858 22u 10K 1N4148 9 Os
6877 3899
11 18 1880 6871
EXTR EXTL TRAY POS BZX79-F3V9 100R
11 O7
GNDA 22u +4V
TO 7801 ON PART 1 1N4148 12 O6 to connector board
D GNDA 12 17 EQSEL DRIVE UP/ 1881 6872 Changer Control +5V
D
NC NC 1 DOWN 13 O5 on rear side of module
10K 4K7 1N4148 14 O4
logic +5.6V
or combi-board
2830 13 +10V
16 5V(5.6V)
VOUT R VOUT L 3769 3768 7 O3 HEF4094BP
3887
10n 23
5V1 470R
6 O2 LEFT
GNDA 14 15 5V 22
GNDA AGND 1 VCC 1 5 O1 GNDA
GNDA 21
4 O0 2 D RIGHT
BZX79-C5V1
1 D
3877
3871
20
3888
6875
10K
10K
10K
+5V(+5.6V)
BASIC VERSION
E 19 E
3 CP SHR_CL GND
18
1 STR SHR_STR +10V
STB 17
SW_INFO
(15 Pin)
EN1 5V 3890 16
SRG8 15
9898 3885
SHR_STR
16 VDD 1K 15
1851 16 5V 3891 SHR_CL
DIPMATE 100K
2829
3884
0V 14
10u
3882
3K9
1
47K
5803 100u - 1K
RF-500TB
2881
2 SICL
4u7
3883 3893
2870
2872
2 0V 13
47n
47n
2 +
M
8003
3714
1 14 DATA
10K
10V 3851 100K OE_LATCH 470R
F 1 15 12 F
2877
2878
220p
2893
SILD
220p
13
47p
DIPMATE 11 +10V 5V
3713
11
22K
1876 OUT1- 3R3
TRAY-MOTOR for prov. only 0V GND
2873
47u
5 7812 10
5804 100u VDD PORE
to/from 7877 on part 1
1850 DIPMATE 12 3879 BC547B PORE
6 0V 1N4148 Output enable KILL_L
9
KILL_L
RF-500TB
6874
100K
2
3715
2 4 +
7 0V 10K delay circuitry 3868 8
330R
3880
2875
9899
22n
2871
+3V
M
8002
47n
1 1 10 - +3.3V
(19 Pin)
3881
DIGout
33R 7
EBU_Out
DIPMATE 9 8
10K 6
1878 EBU_GND
CAROUSEL-MOTOR
3886
47K
7871 EBUGND 5
G KILL_R KILL_R
G
TDA7073A 4
CD-TEXT INFO SRDT
CD-TEXT
3
4V only during DQSY
(23 Pin)
+4V +4V DQSY 2
CD-Text circuitry 2853
TOC-reading
1
uP_CLK
3.3ms GND
220R
2804
3705
4u7
22n
3718 SCLK 1805
7876 4K7
3711
3730
from
10K
33K
LC89170M 3809
H 3731 1 14 4V
7877
on DOBM H
RCK EXCK VDD SRDT
470R
3716
part1
100
to 32 x 8
10K 2 SBSO DQSY 13 3706 470R
SUB 2 PORT
CPU
7877 3 SCOR RAM 3707 470R
SBSY INTERF SRDT 12 SRDT
on
4 WFCK SCLK 11 3708 470R DQSY
SFSY
part1 CRC
3700 470R 5 MCK SW2 10 SCLK
CL11 CHECK
7.35KHz 11MHz 6 XMODE SW1 9 ...DC voltages measured
TIMING & SYNC in Play mode with following conditions
V EVM
2852
7 8
47n
GND PROTECTION TEST '+A'=+10.5V and '+5V'=+5V
I I
#.... for provision only
3CDC99-DS sheet2 2000-03-27
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
10-12 10-12
POS. 60
73 74
61
98
98
97
97
98 82
96
98 70
80
96
81
100
95 83 84
108
107
106
105
23
22
60 POS. 25
39 48
25 35
123
38
24 47 46 26
21 45
43
40
50
41
51
42
54 6x 115 52
44
53
10-13
125
115
116 117 118
Printed Circuit
Board
MECHANICAL PARTSLIST 3CDC-99 MODULE
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
0003 4822 463 11235 GUIDING LEFT 0040 4822 463 11237 SLIDE
0004 4822 463 11236 GUIDING RIGHT 0041 4822 522 10509 CONTROL DISC
0012 4822 466 12146 RUBBER 0042 4822 522 10492 GEAR WHEEL
0013 4822 466 12146 RUBBER 0043 4822 528 10937 PULLEY
0021 4822 418 10403 DRAWER 0044 4822 522 10493 IDLER WHEEL
0022 4822 402 11236 BRACKET TUMBLER 0045 4822 358 10115 BELT
0023 4822 492 11721 SPRING 0046 4822 466 10735 ECCENTRIC GEAR WHEEL
0024 4822 492 11721 SPRING 0050 4822 532 12364 WASHER
0038 4822 502 12548 SCREW M2,6x3,5 0051 4822 532 12364 WASHER
0039 4822 502 12548 SCREW M2,6X3,5 0052 4822 532 12364 WASHER
continued on next page
10-14
14 2
10 7
8
5
12 13
MECHANICAL PARTSLIST 3CDC-99 MODULE
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
0053 4822 532 12364 WASHER 0097 4822 529 10387 RUBBER DAMPER CD DRIVE, FRONT
0073 4822 502 12548 SCREW M2,6X3,5 0100 9305 022 30201 VAM2202/01
0074 4822 502 12548 SCREW M2,6X3,5 0115 4822 466 10736 CAROUSEL
0080 4822 528 10937 PULLEY 0117 4822 532 12365 BUSH DRAWER
0081 4822 522 10494 GEAR DRAWER 0123 4822 402 11237 SWITCH-BRACKET
0082 4822 358 10115 BELT 0125 4822 401 11708 DISC CLAMP VAM DRIVE 3CDC
0083 4822 532 12364 WASHER
0084 4822 532 12364 WASHER
0095 4822 404 10985 SUPPORT-VAM
0096 4822 529 10387 RUBBER DAMPER CD DRIVE, FRONT
10-15
ELECTRICAL PARTSLIST 3CDC-99 MODULE
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
MISCELLANEOUS CAPACITORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
0035 4822 361 10753 CAROUSEL MOTOR 2863 4822 124 11912 220µF 20% 6,3V
0070 4822 361 10753 TRAY MOTOR 2865 4822 126 12882 100nF 20% 50V
1800 4822 265 10925 FFC SOCKET, 15P 2869 4822 126 12785 47nF 20% 50V
1805 4822 265 11533 FFC SOCKET, 23P 2872 4822 126 12785 47nF 20% 50V
1880 4822 276 13503 SWITCH 2873 4822 124 12233 47µF 20% 25V
1881 4822 276 13503 SWITCH 2875 4822 126 11585 22nF 20% 50V
1882 4822 276 13503 SWITCH 2876 4822 126 12785 47nF 20% 50V
8001 3103 308 92020 FLEX FOIL CABLE 23P, 420mm 2877 4822 122 33848 47pF 5% 50V
8005 3103 308 91820 FLEX FOIL CABLE 15P, 95mm 2878 4822 122 10466 220pF 10% 50V
2879 4822 126 12785 47nF 20% 50V
CAPACITORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– 2880 4822 126 12882 100nF 20% 50V
2800 4822 126 10053 180pF 10% 50V 2881 4822 124 40769 4,7µF 20% 100V
2801 4822 122 10466 220pF 10% 50V 2882 4822 124 81151 22µF 20% 50V
2802 4822 126 10053 180pF 10% 50V 2884 4822 124 40769 4,7µF 20% 100V
2803 4822 122 10466 220pF 10% 50V 2885 4822 124 40769 4,7µF 20% 100V
2804 4822 124 40769 4,7µF 20% 100V
2887 4822 126 12882 100nF 20% 50V
2805 4822 122 10466 220pF 10% 50V 2888 4822 124 40769 4,7µF 20% 100V
2806 4822 122 10466 220pF 10% 50V 2891 4822 122 10576 1,8nF 10% 16V
2807 4822 126 12787 330pF 10% 50V 2892 4822 126 11714 4,7nF 20% 16V
2808 4822 122 10466 220pF 10% 50V 2893 4822 122 10466 220pF 10% 50V
2809 5322 124 41948 0,47µF 20% 50V
RESISTORS
2810 4822 126 10053 180pF 10% 50V –––––––––––––––––––––––––––––––––––––––––––––––––––––
2811 4822 122 10466 220pF 10% 50V 3700 4822 116 83883 470Ω 5% 0,16W
2812 4822 126 12785 47nF 20% 50V 3705 4822 116 83872 220Ω 5% 0,5W
2815 4822 126 13174 33nF 20% 16V 3706 4822 116 83883 470Ω 5% 0,16W
2816 4822 126 12878 1,5nF 10% 16V 3707 4822 116 83883 470Ω 5% 0,16W
3708 4822 116 83883 470Ω 5% 0,16W
2818 4822 126 12878 1,5nF 10% 16V
2822 4822 126 12878 1,5nF 10% 16V 3709 4822 116 52257 22kΩ 5% 0,5W
2823 4822 122 33848 47pF 5% 50V 3711 4822 050 21003 10kΩ 2% 0,25W
2824 4822 126 12785 47nF 20% 50V 3713 4822 116 52257 22kΩ 5% 0,5W
2825 4822 121 51387 10nF 20% 16V 3714 4822 050 21003 10kΩ 2% 0,25W
3715 4822 116 52234 100kΩ 5% 0,5W
2826 4822 124 80231 47µF 20% 16V
2828 4822 124 40433 47µF 20% 25V 3716 4822 116 52175 100Ω 5% 0,5W
2829 4822 124 21732 10µF 20% 25V 3718 4822 116 52283 4,7kΩ 5% 0,5W
2830 4822 121 51387 10nF 20% 16V 3728 4822 116 52283 4,7kΩ 5% 0,5W
2831 4822 122 10577 3,3nF 10% 16V 3730 4822 050 23303 33kΩ 1% 0,6W
3731 4822 050 21003 10kΩ 2% 0,25W
2832 4822 122 10577 3,3nF 10% 16V
2833 4822 122 33069 33pF 5% 50V 3760 4822 050 11002 1kΩ 5% 0,2W
2834 4822 122 33069 33pF 5% 50V 3761 4822 050 11002 1kΩ 5% 0,2W
2835 4822 126 12785 47nF 20% 50V 3762 4822 050 11002 1kΩ 5% 0,2W
2837 4822 124 40433 47µF 20% 25V 3763 4822 116 52231 820Ω 5% 0,5W
3764 4822 052 10338 3,3Ω NFR25
2838 4822 124 40248 10µF 20% 63V
2839 4822 124 40433 47µF 20% 25V 3766 4822 050 21003 10kΩ 2% 0,25W
2840 4822 126 12882 100nF 20% 50V 3768 4822 116 52283 4,7kΩ 5% 0,5W
2841 4822 126 12702 270pF 10% 50V 3769 4822 050 21003 10kΩ 2% 0,25W
2842 4822 126 12339 2,2nF 10% 16V 3800 4822 116 52291 56kΩ 5% 0,5W
3801 4822 050 21003 10kΩ 2% 0,25W
2844 4822 126 12702 270pF 10% 50V
2849 4822 124 40769 4,7µF 20% 100V 3802 4822 116 52291 56kΩ 5% 0,5W
2850 4822 122 33197 1nF 10% 50V 3803 4822 050 21003 10kΩ 2% 0,25W
2851 4822 124 40433 47µF 20% 25V 3805 4822 050 21003 10kΩ 2% 0,25W
2852 4822 126 12785 47nF 20% 50V 3806 4822 050 21003 10kΩ 2% 0,25W
3807 4822 050 21003 10kΩ 2% 0,25W
2853 4822 126 11585 22nF 20% 50V
2854 4822 126 12785 47nF 20% 50V 3808 4822 050 21003 10kΩ 2% 0,25W
2855 4822 122 33519 470pF 10% 50V 3809 4822 116 83883 470Ω 5% 0,16W
2856 4822 122 33848 47pF 5% 50V 3811 4822 116 52251 18kΩ 5% 0,5W
2857 4822 121 51387 10nF 20% 16V 3812 4822 053 10228 2,2Ω 5% 1W
3814 4822 116 52191 33Ω 5% 0,5W
2858 4822 124 81151 22µF 20% 50V
2859 4822 121 51387 10nF 20% 16V 3815 4822 052 10478 4,7Ω 5% NFR
2860 4822 124 41596 22µF 20% 50V 3816 4822 116 83884 47kΩ 5% 0,16W
2861 4822 124 41596 22µF 20% 50V 3817 4822 116 52298 680kΩ 5% 0,5W
2862 4822 124 11912 220µF 20% 6,3V 3819 4822 116 83883 470Ω 5% 0,16W
3820 4822 116 52289 5,6kΩ 5% 0,16W
10-16
ELECTRICAL PARTSLIST 3CDC-99 MODULE
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
RESISTORS RESISTORS
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
3821 4822 116 52289 5,6kΩ 5% 0,16W 3888 4822 050 21003 10kΩ 2% 0,25W
3822 4822 116 52263 2,7kΩ 5% 0,5W 3889 4822 116 83883 470Ω 5% 0,16W
3823 4822 050 11002 1kΩ 5% 0,2W 3890 4822 050 11002 1kΩ 5% 0,2W
3824 4822 050 11002 1kΩ 5% 0,2W 3891 4822 050 11002 1kΩ 5% 0,2W
3825 4822 050 11002 1kΩ 5% 0,2W 3892 4822 116 83883 470Ω 5% 0,16W
3826 4822 116 52257 22kΩ 5% 0,5W 3893 4822 116 83883 470Ω 5% 0,16W
3827 4822 050 23303 33kΩ 1% 0,6W 3894 4822 116 52191 33Ω 5% 0,5W
3828 4822 116 52257 22kΩ 5% 0,5W 3895 4822 116 52176 10Ω 5% 0,5W
3831 4822 116 52257 22kΩ 5% 0,5W 3897 4822 116 52175 100Ω 5% 0,5W
3832 4822 050 21003 10kΩ 2% 0,25W 3899 4822 116 52175 100Ω 5% 0,5W
3833 4822 116 52257 22kΩ 5% 0,5W COILS
3834 4822 116 52257 22kΩ 5% 0,5W –––––––––––––––––––––––––––––––––––––––––––––––––––––
3835 4822 052 10338 3,3Ω NFR25 1810 4822 242 10849 CRYSTAL 8,46MHz
3837 4822 050 11002 1kΩ 5% 0,2W
3838 4822 050 11002 1kΩ 5% 0,2W DIODES
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3839 4822 116 52234 100kΩ 5% 0,5W 6871 4822 130 30621 1N4148
3840 4822 116 52234 100kΩ 5% 0,5W 6872 4822 130 30621 1N4148
3841 4822 116 52283 4,7kΩ 5% 0,5W 6873 4822 130 30621 1N4148
3842 4822 116 83884 47kΩ 5% 0,16W 6874 4822 130 30621 1N4148
3843 4822 050 23303 33kΩ 1% 0,6W 6875 3198 010 55180 DIO REG BZX79-B5V1
3844 4822 116 52283 4,7kΩ 5% 0,5W 6877 3198 010 53980 DIO REG BZX79-B3V9
3845 4822 116 83884 47kΩ 5% 0,16W
3846 4822 050 23303 33kΩ 1% 0,6W TRANSISTORS
3847 4822 116 83961 6,8kΩ 5% 0,16W –––––––––––––––––––––––––––––––––––––––––––––––––––––
3848 4822 116 52234 100kΩ 5% 0,5W 7812 4822 130 40959 BC547B
7874 4822 130 40959 BC547B
3849 4822 116 52234 100kΩ 5% 0,5W 7875 4822 130 40959 BC547B
3850 4822 116 52276 3,9kΩ 5% 0,5W
3851 4822 052 10338 3,3Ω NFR25 INTEGRATED CIRCUITS
3852 4822 052 10228 2,2Ω 5% 0,33W –––––––––––––––––––––––––––––––––––––––––––––––––––––
3853 4822 116 83883 470Ω 5% 0,16W 7801 © 4822 209 17286 TZA1024T/N1 HF-AMPLIFIER
7806 9352 628 49112 IC TDA7073A/N4
3854 4822 116 52175 100Ω 5% 0,5W 7807 9352 628 49112 IC TDA7073A/N4
3855 4822 116 52175 100Ω 5% 0,5W 7810 © 8203 303 11278 D/A CONVERTER PCM1716
3857 4822 116 52191 33Ω 5% 0,5W 7871 9352 628 49112 IC TDA7073A/N4
3858 4822 116 52257 22kΩ 5% 0,5W
3859 4822 116 52257 22kΩ 5% 0,5W 7873 5322 209 10421 HEF4094BP
7876 © 4822 209 16143 LC89170M
3862 4822 116 52175 100Ω 5% 0,5W 7877 © 9352 641 80557 SAA7324H/M2B CD10/M2B
3863 4822 116 52191 33Ω 5% 0,5W 7878 4822 209 72042 MC78L05ACP
3864 4822 116 52176 10Ω 5% 0,5W
3865 4822 116 52176 10Ω 5% 0,5W
3866 4822 050 21003 10kΩ 2% 0,25W
3867 4822 116 52206 120Ω 5% 0,5W
3869 4822 050 24708 4,7Ω 1% 0,6W
3870 4822 116 52175 100Ω 5% 0,5W
3871 4822 050 21003 10kΩ 2% 0,25W
3872 4822 050 21003 10kΩ 2% 0,25W
3873 4822 116 83883 470Ω 5% 0,16W
3874 4822 050 21003 10kΩ 2% 0,25W
3875 4822 050 21003 10kΩ 2% 0,25W
3876 4822 116 52234 100kΩ 5% 0,5W
3877 4822 050 21003 10kΩ 2% 0,25W
3878 4822 050 21003 10kΩ 2% 0,25W
3879 4822 050 21003 10kΩ 2% 0,25W
3880 4822 116 52219 330Ω 5% 0,5W
3881 4822 050 21003 10kΩ 2% 0,25W
3882 4822 116 83884 47kΩ 5% 0,16W
3883 4822 116 52234 100kΩ 5% 0,5W
3884 4822 116 52276 3,9kΩ 5% 0,5W
3885 4822 116 52234 100kΩ 5% 0,5W
3886 4822 116 83884 47kΩ 5% 0,16W
3887 4822 116 83883 470Ω 5% 0,16W
11-1 11-1
SERVICING HINT
The CD-R/W module will be exchanged completely in case of a failure. For checking the CD R/W module use the Service
Testprogram (chapter 3-4).
The defective CD-R/W module has to be returned for central repair. Service Code for new Module = 3104129 52590
Available circuit descriptions: The Basics of Compact Disc Recordable/Rewritable 4822 725 25242
3rd generation Compact Disc Recording 3104 125 40100
CDR99 Module
TABLE OF CONTENTS
Blockdiagram...................................................................11-2
11-2 11-2
BLOCK DIAGRAM CDR-MODULE
CDR MAIN BOARD
CDL 4009
LOADER ASSY 7703
CDM3800 7330
FLASH
+5V
1501
HALL
1330
+5V
M FLEX 11P
DRIVE, HALL FEEDBACK
MOTOR ROM
DRIVER +12V
TURN BA6856FP -8V
TABLE ADDRESS
BUS
7702
DATA
BUS
7008 7300
DRAM
EFMTIM3
LO9805
EFMDATA, EFMCLK, LWRT CDR60
SAA7392
7701
1704
EFM TIMING A1 - A20 D16 - D31 SYS-RESET
GENERATOR DOBM-CDR
2
I C BUS
DECODER
SUBCODE BUS
ENCODER
MOTOR CONTROL
I2S BUS 1
CONTROL CONTROL 7801
LINES LINES
DIGITAL
POT
1000 EXT-ANALOG-IN
DS1807
7016 OFFTRACK ATIPSYNC
LASER
HIN WOBBLE
CONTROL LLP
& IR, IW, IE LASER XDAC LINES CDR60PLL
FORWARD CONTROL M62364
HF AMP 7405
SENSE FILTER
DASP
MCF5244
ANALOG
IN
1420
7406
CAHF
SYS-CLK-11W
DIGITAL AUDIO
PHOTO SIGNAL CODEC ANALOG
7409
DIODES FLEX 30P
A1LF, A2LF, B1LF, B2LF
C1LF - C4LF
CONTROL
LINES
PROCESSOR
I2S BUS 2/4
UDA1341TS
OUT
L3 BUS ADC / DAC
7207
CONTROL CONTROL I2C
EEPROM
DATA 1702
RAD+, RAD- LINES LINES
RADIAL
BUS
FOC+, FOC-
7010 M24C08 EXT-DIG-IN
FOCUS
AEGER
TZA1020
2
I C BUS
ANALOG
DIG-OUT-C
ERROR SIGNAL
GENERATOR 7270
FOR ALPHA0
MACE2
RECORDABLE DSA-CDR
A1, A2, CALF
SAA7399
TLN, MIRN, FEN, REN, RE SYS-CLK-16W (16.9344 Mhz)
PCS PRE-AMP
1707
7802
NE532D
7225 33.8688 MHz
1220 SIN+, SIN-
COS+, COS- REFSIN, SINPHI, REFCOS, COSPHI
RAM
M FLEX 10P
SL+, SL- BASIC ENGINE
SLEDGE
POWER PROCESSOR
7706A
DRIVER
BA5938FM 7240
MAD0 - MAD7 SYS-CLK-BE
(8.4672 Mhz)
/2
7208 74F74D
RAD
FOCUS VRA, VFO, VSL FLASH
SLEDGE
EPROM ADDRESS
BUS
1200
M
2 WIRES TRAYIN, TRAYOUT
TR+, TR- TRAY
MA8 - MA17
TRAY 2 WIRES TRAYSW TRAYSWF
7209
DEMUX
TRAY
SYS-CLK-BE
(8.4672 Mhz)
SWITCH
CDR785, 180100
12-1 12-1
M3x10
Exploded view 1 (7x)
3x12
3x12
Power5 Module 274
3x12
3x6
3x12 3x12
3x6
3x12
only for /21
3x12
278
3x6
3x6 291
269 3x12 (6x)
Tuner Board
3x6 Wash
(13x)
204 Digital Board
202 M3x8 (4x)
272
3x12
Mains AF7 Board
Transformer
see exploded view 3x12
3CDC-DS 288
3x6
285
3x12 Mains Board
3x6 Wash 3x6
3x6 281
3x6
3x12 226
341
3x6 Wash
M3x6(4x) 3x6 Wash
see exploded view 2
223 3x6 Wash
279 Partslist on chapter 12-3
3x6(2x)
3x6(2x)
276
280 271
M3x10 Exploded view1 FW-R8 (15.02.2000)
12-2 12-2
Exploded view 2
242 244
203
239 242
255 231
256
267 243 236
245
246
249 237
254 3x12
(2x)
240
232
250
234 241
257
233
247
3x12 (9x)
235
3x6 (2x)
CDR MODULE
200 260
261
213
262
263
3x12 (3x) 225
3x12 (4x)
219
FRONT-BOARD 3x6 (2x)
224
266 227
3CDC KEY-BOARD 264
3x12 (2x) 229
201 265
228
3x12 (3x) 3x12 (2x)
215
220
LED-BOARD 214
230
MICROPHONE
BOARD
3x12 (2x)
212
210
3x12 (2x)
221
208 205
216
3x12
3x12 (7x)
209
217
222 222
206
207
Exploded view2 FW-R8 (15.02.2000)
222
12-3
MECHANICAL PARTS MISCELLANEOUS
––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––
0001 3103 307 99160 SPEAKER-BOX LEFT ASSY FW-R8 0351 4822 303 50063 FM AERIAL
0002 3103 307 99170 SPEAKER-BOX RIGHT ASSY FW-R8 0351 4822 320 11094 FW ANTENNA WIRE /37
0201 3103 307 98780 FRONT PRINTED 0384 4822 303 50082 AM FRAME AERIAL
0203 3103 307 98350 ORNAMENTAL FRONT 8002 4822 320 12335 FLEX FOIL CABLE,17P, 125mm
0204 4822 454 13408 WORDMARK PHILIPS 8004 3103 308 92450 FLEX FOIL CABLE, 6P, 140mm
0205 3103 307 98360 FRAME ORNAMENTAL 8006 3103 308 92320 FLEXFOIL CABLE, 7P, 280mm
0206 3103 304 67260 DOOR CDR 8009 3103 308 92330 FLEX FOIL CABLE, 5P, 280mm
0207 3103 301 06490 SPRING DOOR CDR 8013 3103 308 92340 FLEX FOIL CABLE, 5P, 280mm
0208 3103 307 98430 WINDOW DISPLAY 8014 3103 308 92470 FLEX FOIL CABLE, 19P, 400mm
0209 3103 307 98440 WINDOW CDR 8015 3103 308 92360 FLEX FOIL CABLE, 4P, 280mm
0210 4822 454 13339 ORNAMENTAL PLATE REPLACEMENTS
0212 3103 304 68130 LENS IR –––––––––––––––––––––––––––––––––––––––––––––––––––––
0213 3103 304 68990 CUTSHEET-FTD 3104129 52590 CD-R/W MODULE
0214 3103 304 67810 LIGHT GUIDE CDR
0215 3103 304 68120 HOLDER LIGHT GUIDE
0216 3103 307 98560 KNOB MIC-LEVEL
0222 4822 462 40683 FOOT RUBBER
0225 3103 307 98390 BUTTON SET POWER
0226 3103 301 45270 BRACKET CDR RIGHT
0227 3103 307 98570 BUTTON SET AUX/TUNER
0228 3103 307 98400 BUTTON SET 3CDC
0229 3103 307 98410 BUTTON SELECT CDR
0230 3103 307 98420 BUTTON CDR-OPEN
0231 3103 307 98460 BUTTON SET STOP
0232 3103 307 98470 BUTTON SET PLAY
0233 3103 307 98490 BUTTON SET REC-MODE
0234 3103 307 98500 BUTTON SET TRACK/TEXT
0235 3103 307 98550 BUTTON INCREDIBLE SURROUND
0236 3103 307 98480 BUTTON SET DISC-REC
0237 3103 304 67410 BUTTON SET TREBLE/BASS
0239 3103 307 98450 BUTTON SET JOG
0240 3103 304 67470 LIGHT GUIDE STOP
0241 3103 304 67480 LIGHT GUIDE PLAY
0242 3103 304 67490 LIGHT GUIDE PREV/NEXT
0243 3103 304 67550 LIGHT GUIDE YES
0244 3103 304 68370 LIGHT GUIDE NO
0245 3103 304 67560 LIGHTGUIDE DISC REC
0246 3103 304 68210 LIGHT GUIDE REC-MODE
0247 3103 304 67570 LIGHTGUIDE FINALISE
0249 3103 304 07030 JOG ROTARY
0250 3103 307 98330 VOLUME ROTARY
0254 3103 307 98530 COVER JOG PLAY
0255 3103 307 98510 COVER JOG YES/NO
0256 3103 307 98520 COVER JOG STOP
0257 3103 307 98540 COVER VOLUME
0260 3103 304 67360 LIGHT GUIDE POWER
0261 3103 304 67370 LIGHT GUIDE CD1
0262 3103 304 67380 LIGHT GUIDE CD2
0263 3103 304 67390 LIGHT GUIDE CD3
0264 3103 304 67870 LIGHT GUIDE AUX
0265 3103 304 67880 LIGHT GUIDE TUNER
0266 3103 304 67930 LIGHT GUIDE CDR
0267 3103 304 67540 LIGHT GUIDE JOG ROTARY
0271 4822 462 40683 FOOT RUBBER
0356 3139 228 83640 REMOTE CONTROL, RC2506/01
0385 3104 128 92560 MAINS CORD, UL
0385 4622 004 50290 CORDSET
5001 3103 308 30510 MAINS TRANSFORMER /22
5001 3103 308 30520 MAINS TRANSFORMER /21
5001 3103 308 30530 MAINS TRANSFORMER /37
You might also like
- 9780 Philips FWM206-55-77 Ver 1.1 Sistema Audio Hi-Fi CD-USB Manual de ServicioNo ratings yet9780 Philips FWM206-55-77 Ver 1.1 Sistema Audio Hi-Fi CD-USB Manual de Servicio23 pages
- Philips FWD186 Service Manual, Repair Schematics, Online DownloadNo ratings yetPhilips FWD186 Service Manual, Repair Schematics, Online Download69 pages
- Manual Service Mini Hi Fi System PhillipsNo ratings yetManual Service Mini Hi Fi System Phillips23 pages
- MCW770 Micro System: Class 1 Laser ProductNo ratings yetMCW770 Micro System: Class 1 Laser Product77 pages
- FWD792 DVD Mini System: Class 1 Laser ProductNo ratings yetFWD792 DVD Mini System: Class 1 Laser Product47 pages
- B.Tech R20 III Year ECE Model Papers FINAL WsNo ratings yetB.Tech R20 III Year ECE Model Papers FINAL Ws23 pages
- Philips Wireless Foot Switch Data SheetNo ratings yetPhilips Wireless Foot Switch Data Sheet18 pages
- Transmission Lines: TEM Waves & ReflectionsNo ratings yetTransmission Lines: TEM Waves & Reflections18 pages
- Preparation Summary For EEE Job Exams Taken by BUET100% (9)Preparation Summary For EEE Job Exams Taken by BUET9 pages
- Definition of Quality of Service Parameters and Their Computation 4.0 6 June 2011No ratings yetDefinition of Quality of Service Parameters and Their Computation 4.0 6 June 201137 pages
- SKMW30, DKMW30-spec Power Supply Converter 50v To 12v For Controller 30jul2024No ratings yetSKMW30, DKMW30-spec Power Supply Converter 50v To 12v For Controller 30jul20246 pages
- CARPROG Motorola HC05 Programmer ManualNo ratings yetCARPROG Motorola HC05 Programmer Manual13 pages
- 22 d75 Eclipse RXT7406 Datasheet 2025 WebNo ratings yet22 d75 Eclipse RXT7406 Datasheet 2025 Web2 pages
